2012 Mitsubishi I-Miev TSBs

connection when certain devices are connected to WiFi.

Power Supply Control System section.

electrically insulated gloves, MB992648-01. While servicing an i-MiEV or Outlander PHEV, these gloves are essential in protecting a Technician from a potentially fatal electric shock.

Included in this kit is a set of electrically insulated gloves, MB992648-01. While servicing an i-MiEV, these gloves are essential in protectling a Technician from a potentially fatal electric shock. We would like to reiterate the importance of properly maintaining these gloves and adhering to the following guidelines:

100,000 miles, whichever comes first. In the event the Main Drive Lithium-ion Battery cannot be charged to full available capacity when properly connected to a properly functioning compatible charger, however Mitsubishi is extending the warranty on the Main Drive Lithium-ion Battery to 10 years or 100,000 miles, whichever comes first.

electrically insulated gloves available for use while servicing an i-MiEV or Outlander PHEV to assist in protecting a Technician from a potentially fatal electric shock.

with water.

Use of a Clipper Creek charger could potentially damage the internal components within the i-MiEV electrical system. If this damage occurs, it could potentially affect the i-MiEV's ability to start. This bulletin describes the procedures necessary to update the software programming of the EV-ECU to ensure compatibility between an i-MiEV and the Clipper Creek EVSE.

This may be due to a frozen EV control relay. This TSB advises dealers that an improved EV control relay is available to correct this condition, and provides replacement instructions.

P1A17, P1A26, and P1AF2.

This bulletin updates the Chassis Electrical section of the affected Service Manual, to update the diagnosis procedure for DTC P0A09 (DC-DC Converter).

This notice reminds dealers of the importance of using and maintaining electrically insulated gloves servicing affect vehicles. The notice provides dealers with guidelines.

This bulletin updates the Exterior section of the affected Service Manual, to add materials and detailed steps to Removal and Installation of the under cover. The additional materials and steps are added to prevent corrosion of the battery frame for vehicles produced through June 2012.

This bulletin provides dealers with a basic description of the hands-free systems used in Mitsubishi built vehicles. The bulletin covers components and operation, system layouts showing the differences in Japan built and U.S. built vehicles, diagnostic flow charts, a list of commonly used acronyms and terms, and part numbers. The bulletin also provides a comprehensive Hands-free/FUSE Information Sheet to guide the service writer in getting complete and accurate details from the customer. With this information, dealer personnel can answer questions and conduct an efficient diagnosis to resolve customer concerns as quickly as possible.

This bulletin provides dealers with a basic description of the hands-free systems used in Mitsubishi built vehicles. The bulletin covers components and operation, system layouts showing the differences in Japan built and U.S. built vehicles, diagnostic flow charts, a list of commonly used acronyms and terms, and part numbers. The bulletin also provides a comprehensive Hands-free/FUSE Information Sheet to guide the service writer in getting complete and accurate details from the customer. With this information, dealer personnel can answer questions and conduct an efficient diagnosis to resolve customer concerns as quickly as possible.

The bulletin updates the Supplemental Restraint System (SRS) section of the affected Service Manuals to correct diagnostic information for front and side impact sensors.

This notice instructs and informs dealers the importance of using electrical insulated gloves while servicing an i-MiEV or Outlander PHEV. The notice provides guidelines how to properly maintain electrically insulated gloves.

Bulletin (TSB-15-54-002) regarding the warranty extension for the Main Drive Lithium-ion Battery not being able to be charged to full available capacity.

Lithium-ion Battery not being able to be charged to full available capacity. This Technical Service Bulletin also provides troubleshooting procedures, if the customer reports not being able to charge the Main Battery to full available capacity.

DTC P1A15 HIGH VOLTAGE SYSTEM ERROR. MODEL 2012-13 I-MIEV. *PE

MODEL 2012 I-MIEV. *PE UPDATED 6/26/15. *PE

SECURING LI ON MAIN DRIVE BATTERY UNDER COVERS AND NON ESSENTIAL GROUND CONNECTIONS. MODEL 2012 I-MIEV. *PE

SELECT DOCUMENT SEARCH BUTTON BELOW. NON ESSENTIAL GROUND CONNECTIONS, ALONG BOLTS SECURING MAIN DRIVE LITHIUM ION BATTERY, IS SUSCEPTIBLE TO RUST AND REPAIR PROCEDURES IS AVAILABLE. MODEL 2012 I-MIEV. SEE CUSTOMER LETTER *LJ UPDATED 6/26/15. *PE

LITHIUM-ION (TRACTION) BATTERY ENERGY LEVEL GAUGE FAILS TO DISPLAY "FULLY CHARGED". MODEL 2012-14 I-MIEV. *PE

MODEL 2012-2014 I-MIEV. *PE

MODEL 2012-2013 I-MIEV. *PE

THE CHARGER, ELECTRIC VEHICLE SUPPLY EQUIPMENT, BY CLIPPER CREEK, IS INCOMPATIBLE WITH INTERNAL SOFTWARE PROGRAMMING FOR EV-ECU AND CAUSES MISCOMMUNICATION, AND POTENTIAL DAMAGE TO INTERNAL COMPONENTS WITH IN I-MIEV ELECTRICAL SYSTEM. MODELS 2012 I-MIEV. *PE UPDATED ON 4/24/2013. *KB

DUE TO A FALSE FAILURE DETECTION OF MAIN DRIVE LITHIUM-ION BATTERY, SOFTWARE PROGRAMMING, FOR CELL MONITORING UNIT (CMU), MAY RESULT IN ILLUMINATION OF WARNING LIGHT AND REDUCTION OF BATTERY OUTPUT. MODEL 2012 I-MIEV. *PE

*PE

notification letters are being sent to vehicle owners with Puerto Rico addresses to inform them of open Takata recalls.

vehicle owners with open Takata recalls.

Commission, notification letters are being sent to vehicle owners with Alabama addresses to inform of open Takata recalls.

Service section of the applicable Service Manual.

Commission, notification letters are being sent to vehicle owners with Puerto Rico addresses to inform of open Takata recalls.

letterhead are being sent to vehicle owners insured by USAA to inform them of open Takata recalls.

residue.

capacity be affixed to vehicles when the total net weight of accessories is more than 1.5 percent of the vehicle's gross vehicle weight rating (GVWR) or 100 lbs.

Public Safety notification letters are being sent to vehicle owners with South Carolina address to inform of open Takata recalls.

reminder to have a Takata recall completed on their vehicle. The letters were printed with State of Virginia letterhead.

reminder to have a Takata recall completed on their vehicle. The letters were printed on a State of Georgia letterhead.

has resumed for dealerships and customer facilities.

(DMV), notification letters are being sent to vehicle owners with Texas addresses to inform them of open Takata recalls.

notification letters are being sent to vehicle owners with Ohio addresses to inform them of open Takata recalls.

notification letters are being sent to vehicle owners with Louisiana addresses to inform them of open Takata recalls.

notification letters are being sent to vehicle owners with Arizona addresses to inform them of open Takata recalls.

Vehicle Division, notification letters are being sent to vehicle owners with Georgia addresses to inform them of open Takata recalls.

Vehicle Division, notification letters are being sent to vehicle owners with Georgia addresses to inform them of open Takata recalls.

Vehicle Division, notification letters are being sent to vehicle owners with Georgia addresses to inform them of open Takata recalls.

Vehicles, notification letters are being sent to vehicle owners with New York addresses to inform of open Takata recalls.

Vehicles, notification letters are being sent to vehicle owners with California addresses to inform of open Takata recalls.

Vehicles, notification letters are being sent to vehicle owners with Texas addresses to inform of open Takata recalls.

Motor Vehicles, notification letters are being sent to vehicle owners with New York addresses to inform of open Takata recalls.

Safety and Motor Vehicles, notification letters are being sent to vehicle owners with Florida addresses to inform of open Takata recalls.

Vehicles, notification letters are being sent to vehicle owners with Nevada addresses to inform of open Takata recalls.

Vehicles (RMV), notification letters are being sent to vehicle owners with Massachusetts addresses to inform of open Takata recalls.

(MVD), notification letters are being sent to vehicle owners with New Mexico addresses to inform of open Takata recalls.

Vehicles notification letters are being sent to vehicle owners with Colorado addresses to inform of open Takata recalls.

Motor Vehicles notification letters are being sent to vehicle owners with New York addresses to inform of open Takata recalls.

base inside the Motor Control Unit (MCU) MAY DECREASE AND FLEAD TO UNSTABLE VOLTAGE WITHIN THE CIRCUIT. This condition can result in reduced electric motor power (turtle mode) and in the worst case, prevent the vehicle from befing frestarted or the Main Drive lithium-ion battery from being recharged.

Charger/DC-DC Converter diagnosis in 54D, Electric Motor Unit and Traction Battery section. These procedures have been added because a new service part is available for the on board charger/DC-DC converter.

America.

Vibration, to the service manual.

warranty for the On-Board Charger on 2012 i-MiEV vehicles to 10 years / unlimited miles. Letters are being sent to owners of affected vehicles informing them of the warranty extension.

warranty for the On-Board Charger on the affected vehicles to 10 years / unlimited miles.

The bulletin updates the Chassis Electrical section of the affected Service Manual to add the Main Drive Lithium-ion Battery Disassembly & Maintenance Procedure to Electric Motor Unit and Traction Battery/Main Drive Lithium-ion Battery.

decrease and lead to unstable voltage within the circuit. This condition can result in reduced electric motor power (turtle mode) and in the worst case, prevent the vehicle from being restarted or the Main Drive lithium−ion battery from being recharged.

that were not manufactured to factory specifications. This can lead to an unstable voltage within the circuit, potentially resulting in reduced electric motor power (turtle mode) during vehicle operation. In the worst case scenario, MCU related functions such as starting the vehicle and/or charging the Main Drive lithium-ion battery may be prohibited. What your dealer will do: Your local certified i-MiEV Mitsubishi dealer will replace the MCU, free of charge. This repair will take approximately 1.5 hours to complete. However, the dealer may need your vehicle for a longer period of time due to scheduling. Every effort will be made to minimize your inconvenience.

SEE DOCUMENT SEACH BUTTON BELOW. THE UNDECARRIAGE ON CERTAIN VEHICLES, ALONG WITH THE BOLTS SECURING THE MAIN DRIVE LITHIUM BATTERY UNDER COVERS AND GROUND CONNECTIONS ,WHICH CAN CAUSE RUST. *LJ

*LJ

VOLTAGE WIRING AND COMPONENTS OF ELECTRONIC MOTOR UNIT AND TRACTION BATTERY. MODEL 2012-2014 I MIEV. *PE

gloves.

gloves.

quantity of parts to complete the recall of in-stock dealer units.

driving range of their electric vehicle when operated in colder temperatures.

converter of 2012 i-MiEV vehicles are now covered under an extended warranty period of 10 years, unlimited mileage.

SC-14-003REV will be made available shortly.

THIS DOES NOT APPLY TO MITSUBISHI MULTI ENTERTAINMENT SYSTEM FOR THE 2014 AND LATER MIRAGE. INCLUDED IN THE MAPCARE UPDATE ARE: LANCER, LANCER SPORTBACK, LANCER EVOLUTION, OUTLANDER, AND OUTLANDER SPORT/RVR MODEL YEAR 2014. MAP UPDATES FOR PURCHASE INCLUDE: LANCER/ LANCER EVOLUTION MODEL YEARS 2008-2013. LANCER SPORTBACK MODEL YEARS 2009-2013. OUTLANDER MODEL YEARS 2007-2013. OUTLANDER SPORT/RVR MODEL YEARS 2001-2013, ENDEAVOR MODEL YEARS 2007-2011, GALANT MODEL YEARS 2007-2012, I-MIEV MODEL YEARS 2012-2013. *JS

customers affected by the TAKATA Airbag recall and also urged dealers to accurately capture customer data during visits.

promotional offer for customers affected by the Takata Airbag Inflator Recall Campaign as part of our continuing efforts to minimize the number of vehicles with an open recall.

This TSB provides updated caution statements.

This notice informs dealers that MMNA will be mailing letters to owners, with Mississippi addresses, with open Takata airbag recalls. The notice instructs dealers to not only familiarize themselves with the attached sample customer letter but to also make sure the dealer has enough recall parts on hand in order to minimize customer inconvenience.

This notice informs dealers that MMNA will be mailing letters to owners, with Mississippi addresses, with open Takata airbag recalls. The notice instructs dealers to not only familiarize themselves with the attached sample customer letter but to also make sure the dealer has enough recall parts on hand in order to minimize customer inconvenience.

Customers may report the front seat belt fraying as a result of being caught under the seat reclining adjusting lever. This TSB instructs dealers how to replace the front seat belt and reclining adjusting lever (driver and/or passenger side) with a countermeasure part, to prevent fraying of the seat belt should it get caught under the lever, on affected vehicles.

INFORMATION, REGARDING SUPPLEMENTAL RESTRAINT SYSTEM (SRS), IS INSERTED OR INCLUDED. MODELS 2012 I-MIEV. *PE

speakers in Mitsubishi vehicles equipped with original equipment audio components.

It provides dealers instructions for resolving customer's report that Bluetooth pairing code given by the Hands Free Link system does not work for certain smartphone models, namely, Samsung Galaxy and Sony Xperia. For these smartphone models, the pairing code for Bluetooth connection must be set to a fixed code of ?0000.? This TSB instructs dealers how to register these smartphones using the pairing code ?0000.?

code and to update Parts Information. Screen shots have also been updated using MUT3-SE. The "i-MiEV Customer Interview Sheet for EV Related Concerns" has been updated slightly for improved readability.

code and to update Parts Information. Screen shots have also been updated using MUT3-SE. The "i-MiEV Customer Interview Sheet for EV Related Concerns" has been updated slightly for improved readability.

RECOGNITION TO COMPLETE BEFORE CONNECTION TO THE PHONE BEGINS, TO RECTIFY THE CONDITION WHERE THE HFM ATTEMPTS A BLUETOOTH CONNECTION WITH A MOBILE PHONE WHILE VOICE RECOGNITION IS BOOTING AT THE SAME TIME. IF THE BLUETOOTH CONNECTION COMPLETES BEFORE VOICE RECOGNITION COMPLETES, VOICE RECOGNITION CANNOT BE USED.

procedure for the EV Water PTC Heater installation due to changes in the specification of service parts.

This bulletin updates the Heater, Air Conditioning and Ventilation section of the affected Service Manuals, to correct the heater unit and blower disassembly and assembly procedures.

The bulletin updates the updates the Heater, Air Conditioning and Ventilation section of the affected Service Manual to update Diagnostic Trouble Code procedures for DTC B1106 and B1108, of the A/C Control Unit.

technician quiz for 2023.

technician quiz for 2023.

a natural phenomenon, and water penetration caused by improper sealing or a defective/broken part.

manuals.

ground connection bolts and undercarriage. This Bulletin also provides instructions for the anti-corrosion wax application to the vehicle frame.

ILLUMINATION OF INSTRUMENT PANEL WARNING LIGHTS AND INTERFERE WITH COMMUNICATION SYSTEM. *PE

addresses printed on an Alabama Law Enforcement Agency letterhead and mailed in an envelope with MMNAs Alabama mail processing return address, who own certain 2004-2007 Lancer, 2006-2009 Raider, and 2012-2017 i-MiEV vehicles with open Takata recalls.

of Transportation (DOT), MMNA mailed letters with the Pennsylvania DOT letterhead to owners with Pennsylvania addresses, who own certain 2004-2007 Lancer, 2006-2009 Raider, and 2012-2017 i-MiEV vehicles with open Takata recalls.

addresses, who own certain 2004-2007 Lancer, 2006-2009 Raider, and 2012-2017 i-MiEV vehicles with open Takata recalls.

become inoperable due to failure of an internal component. If the vacuum pump becomes inoperable, the brake warning light will illuminate and the brake warning buzzer will alert the vehicle operator. Vacuum pump inoperability will result in reduced brake power assist, which may increase stopping distances and could lead to greater risk of crash. Please reference Safety Recall Bulletin SR-13-001 for remediation.

IPHONE/IPOD/IPAD WHEN THE DEVICE IS CONNECTED TO WI‐FI. THIS UPDATE ADDRESSES UNSTABLE, REPEATEDLY CONNECTING AND DISCONNECTING FROM THE VEHICLE'S BLUETOOTH WHEN THE IPHONE'S WI‐FI IS ENABLED. THE CONDITION DOES NOT OCCUR WHEN WI‐FI IS TURNED OFF.

This bulletin supersedes TSB-18-00-003, issued April, 2018, to add updated information for Carrying Capacity Reduced Label.

The bulletin updates the Front Suspension section of the affected Service Manuals to update the special service tool used in replacement of the Lower Arm Ball Joint Dust Cover.