2001 MINI Cooper S TSBs
23 Technical Service Bulletins across 6 categories
Engine
14 bulletinsMINI: FAULTY SOFTWARE CAUSES THE CHECK CONTROL AND ENGINE POWER REDUCED LIGHT TO APPEAR.
Read full bulletin
*MA
MINI: DUE TO FAULTY DME SOFTWARE, THE SERVICE ENGINE LIGHTS COMES ON, INCLUDING THE CHECK CONTROL MESSAGE FOR MOTOR FORCE DECREASE.
Read full bulletin
*MA
MINI: DIFFERENT FAULTS ACTIVATES ENGINE MALFUNCTION AND OIL WARNING.
Read full bulletin
*MA
MINI: A MECHANICAL FAILURE AND DME SOFTWARE ERROR OF THE VANOS ACTUATORS CAUSE THE ENGINE TO RUN ROUGH WHICH ACTIVATES THE MALFUNCTION WARNING LIGHT.
Read full bulletin
*MA
MINI: SOME VEHICLES HAVE TURBOCHARGER NOISE AND A LACK OR LOSS OF PERFORMANCE, DUE TO RESTRICTION OF TURBOCHARGER OIL...
Read full bulletin
SUPPLY, RESULTING IN OIL STARVATION AND SEIZING OF TURBOCHARGER ASSEMBLY. MODEL ALL. *PE
MINI: THERE IS A PROCEDURAL ERROR IN THE REMOVING AND INSTALLING OR REPLACING HIGH PRESSURE PUMP CURRENT VERSION THAT...
Read full bulletin
HAS BEEN REPLACED WITH THE CORRECTED REPAIR INSTRUCTION PORTION FOR THE N14 AND N18 ENGINE. MODELS R55, 56, 57, 58, 59, 60, 61. NO MODEL YEARS LISTED. *PE
MINI: WHEN RESEALING ENGINE OIL PAN, ENGINE OIL PAN GASKET REPLACEMENT SHOULD NO LONGER BE USED DUE TO CAUSING SEALING FLANGE BECOMING DEFORMED.
Read full bulletin
MODELS R55, R56, R59, R60, R57, AND R58. NO MODEL YEARS LISTED. *PE
BMW: SERVICE ENGINE SOON LIGHT MAY BE ON WITH STORED TROUBLE CODES AND REDUCED ENGINE POWER.
Read full bulletin
THE HIGH PRESSURE FUEL PUMP MALFUNCTIONS. *RM
MINI: ELECTRIC COOLING FAN RUNS AFTER ENGINE IS SHUT OFF.
Read full bulletin
AFTER THE ENGINE IS SHUT OFF, THE ELECTRIC COOLING FAN CONTINUES TO RUN. DUE TO THE OPERATING STRATEGY OF THE DME, THE ELECTRIC COOLING FAN MAY CONTINUE TO RUN AFTER THE ENGINE IS SHUT OFF IN TWO DIFFERENT SCENARIOS. ENGINE COOLANT TEMP REACHES 108 DEGREES CELSIUS (DUE TO HEAT SOAK), COOLING FAN WILL ACTIVATE TIL COOLANT TEMP DROPS BELOW 105 DEGREES CELSIUS. FAN WILL RUN TO ASSIST THE AUXILIARY WATER PUMP, WHICH IS USED TO COOL TURBO CHARGER AFTER ENGINE SHUT DOWN. NO MODEL YEARS LISTED. *PE
MINI: WHEN REPLACING THE CYLINDER HEAD COVER ON A VEHICLE EQUIPPED WITH THE NEW N14 ENGINE, THE COVER WILL LOOK DIFFERENT IN APPEARANCE.
Read full bulletin
THE REPLACEMENT COVER IS NOW EQUIPPED WITH A CRANKCASE VENTILATION SYSTEM PRESSURE RELIEF VALVE. NO MODEL YEARS LISTED. *PE
MINI: SERVICE ENGINE SOON OR CHECK GAS CAP WARNING IS ILLUMINATED: TANK LEAKAGE.
Read full bulletin
LEAKAGE IS DETECTED IN THE TANK VENTILATION OR EVAPORATIVE SYSTEM. *PE
MINI: TURBOCHARGER FAILURE; OIL SUPPLY LINE BLOCKAGE.
Read full bulletin
LOSS OF PERFORMANCE AND TURBOCHARGER NOISE. *PE UPDATED 8/16/11. *PE
MINI: FUEL ODOR FROM THE ENGINE COMPARTMENT.
Read full bulletin
THE HIGH PRESSURE PUMP (HDP) AND/OR THE LOW PRESSURE SUPPLY HOSE CONNECTION CAN ALLOW FUEL SEEPAGE, RESULTING IN THE FUEL ODOR. *PE
MINI- R5 & R56 (COOPER; COOPER S) WITH GETRAG 6 SPEED MANUAL TRANSMISSION: COMPLAINT OF AN INTERMITTENT NO-CRANK, NO START SITUATION.
Read full bulletin
THE CLUTCH SWITCH MODULE HAS NOT BEEN SECURED IN THE CORRECT POSITION ON THE CLUTCH MASTER CYLINDER. *PE
Other
3 bulletinsAdhesive Film Return
MINI: AFTER DRIVE-AWAY LOCKING ACTIVATES, IT IS NOT POSSIBLE TO UNLOCK THE BOOT.
Read full bulletin
*KB
BMW: DESCRIPTION AND SPECIFICATIONS OF CRANKCASE VENTILATION SYSTEM.
Read full bulletin
*RM
Body & Paint
3 bulletinsMINI: THERE IS A DISCONNECTION OR KINK, IN WNIDSHIELD WASHER HOSE, WHICH IS TOO SHORT, CAUSING WINDSHIELD FRONT WASHER JET TO FAIL.
Read full bulletin
MODEL F56 (COOPER, COOPER S). *PE
MINI: WATER LEAK FROM THE FRONT DOORS.
Read full bulletin
AFTER HEAVY RAIN, THE CARPET MAY BE WET IN THE AREA NEAR THE REAR OF THE FRONT DOORS OR IN THE FOOTWELL AREA. WATER WHICH IS ALLOWED TO ENTER THE VEHICLE AT THE TOP REAR EDGE OF THE DOOR IS NOT ABLE TO DRAIN OUT THROUGH THE BOTTOM OF THE DOOR SEAL. AS A RESULT, THE WATER TRAVELS ALONG THE DOOR SEAL AND INTO THE PASSENGER COMPARTMENT. *PE
MINI: REAR SPLIT DOOR OPENING PROBLEMS.
Read full bulletin
ONE OR BOTH OF THE REAR SPLIT DOORS INTERMITTENTLY HAVE FUNCTIONAL PROBLEMS. THE DOOR(S) MAY NOT UNLATCH WHEN THE LEVER ON THE HANDLE IS PULLED OR THE LATCH MAY RELEASE UNEXPECTEDLY WITHOUT BEING PULLED. *PE UPDATED 7/10/09. *PE
Transmission
1 bulletinMINI: BECAUSE OF THE DME SOFTWARE, AND A DAMAGED CLUTCH, THE DRIVETRAIN MALFUNCTION CHECK MESSAGE APPEAR.
Read full bulletin
*MA
Steering
1 bulletinMINI: MODELS R50, R52, AND R53 WITH THE ELECTRO-HYDRAULIC POWER-ASSIST STEERING PUMP AND COOLING FANS WILL HAVE AN...
Read full bulletin
LIMITED WARRANTY EXTENSION TO 13 YEARS/150,000 MILES. *TA
Lighting
1 bulletinMINI: CHECK SVS FUNCTION.
Read full bulletin
ON CERTAIN VEHICLES, THE VOICE INPUT SYSTEM (SVS SA 620) DOES NOT FUNCTION. THE SVS WAS NOT INSTALLED IN THE VEHICLES. *PE