2008 MINI Cooper Clubman S TSBs
19 Technical Service Bulletins across 6 categories
Engine
10 bulletinsMINI: FAULTY SOFTWARE FOR THE TANK VENTILATION CONTROL DISPLAYS ENGINE THROTTLE REACTION WHEN TEMPERATURE IS HIGH...
Read full bulletin
OUTSIDE, AND MORE OBVIOUS IF THE TANK IS ONLY PARTLY FILLED. *MA
MINI: A MECHANICAL FAILURE AND DME SOFTWARE ERROR OF THE VANOS ACTUATORS CAUSE THE ENGINE TO RUN ROUGH WHICH ACTIVATES THE MALFUNCTION WARNING LIGHT.
Read full bulletin
*MA
MINI: CAMSHAFT TIMING CONTROL INTAKE, CAMSHAFT JAMMING, SIGNAL IMPLAUSIBLE, POSITION NOT REACHED, TOLERANCE RANGE...
Read full bulletin
OUTSIDE, CANNOT CONTROL COLD START EXHAUST AND ENGINE RUNNING ROUGH WITH MALFUNCTION WARNING ILLUMINATED DUE TO SOFTWARE ISSUE. *PE
MINI: SOME VEHICLES HAVE TURBOCHARGER NOISE AND A LACK OR LOSS OF PERFORMANCE, DUE TO RESTRICTION OF TURBOCHARGER OIL...
Read full bulletin
SUPPLY, RESULTING IN OIL STARVATION AND SEIZING OF TURBOCHARGER ASSEMBLY. MODEL ALL. *PE
MINI: THERE IS A SOFTWARE ERROR CAUSING THE SERVICE ENGINE SOON LIGHT TO BE ILLUMINATED THAT IS RELATED TO VALVETRONIC DIAGNOSTICS.
Read full bulletin
MODELS R55, R56, R58, R57, R60, R59. NO MODEL YEARS LISTED. *PE
MINI: WHEN RESEALING ENGINE OIL PAN, ENGINE OIL PAN GASKET REPLACEMENT SHOULD NO LONGER BE USED DUE TO CAUSING SEALING FLANGE BECOMING DEFORMED.
Read full bulletin
MODELS R55, R56, R59, R60, R57, AND R58. NO MODEL YEARS LISTED. *PE
BMW: ENGINE TOO HOT MESSAGE IS DISPLAYED WITH STORED TROUBLE CODES.
Read full bulletin
THE WATER PUMP DOESNT POWER UP. *RM
BMW SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER.
Read full bulletin
THERE MAY BE A PROBLEM WITH A VAPOR RECOVERY PUMP WHICH WILL CAUSE THE SERVICE ENGINE SOON LIGHT TO COME ON. *RM
MINI: SERVICE ENGINE SOON OR CHECK GAS CAP WARNING IS ILLUMINATED: TANK LEAKAGE.
Read full bulletin
LEAKAGE IS DETECTED IN THE TANK VENTILATION OR EVAPORATIVE SYSTEM. *PE
MINI: TURBOCHARGER FAILURE; OIL SUPPLY LINE BLOCKAGE.
Read full bulletin
LOSS OF PERFORMANCE AND TURBOCHARGER NOISE. *PE UPDATED 8/16/11. *PE
Electrical
4 bulletinsMINI electrical systems have continued to develop over the past few years.
Read full bulletin
As a result, the demand on the batteries has increased. Breakdowns due to an empty battery or problems in the vehicles electrical system can have various causes, most of which are not due to the battery itself. For this reason, a battery replacement will permanently eliminate the problem only in the rarest of cases. The energy diagnosis test module helps to localize these causes. This document covers important information for the dealer on how to handle discharged battery complaints. Without performing the energy diagnosis test plan, the root cause of a discharged battery cannot be identified. In order to properly repair the vehicle the first time, it is very important that the diagnostic test plan is performed to completion; with all results taken into consideration.
MINI: INFORMATION PROVIDED REGARDING PROCEDURE OF REPLACING FUEL LEVEL SENSOR DUE TO FAILURE ON THE RIGHT AND/OR LEFT SIDE.
Read full bulletin
*PE
BMW: THE AIRBAG WARNING LIGHT IS ON WITH A FAULT STORED.
Read full bulletin
THE WIRING UNDER THE SEAT MAY BE PINCHED OR DAMAGED. *RM
BMW MINI: AIR BAG WARNING LAMP ILLUMINATED AND EITHER FC 93B0 OR 93B1 (DRIVER OR PASSENGER HEAD AIR BAG-SHORT TO...
Read full bulletin
NEGATIVE) IS STORED IN THE ACSM (ADVANCED CRASH SAFETY MODULE). MODELS R55 (COOPER CLUBMAN, COOPER CLUBMAN S). *PE
Other
2 bulletinsBMW: DESCRIPTION AND SPECIFICATIONS OF CRANKCASE VENTILATION SYSTEM.
Read full bulletin
*RM
MINI: TO IMPROVE CUSTOMER SATISFACTION WITH FRM RELATED COMPLAINTS, AN ENHANCEMENT TECHNICAL SUPPORT (TEILECLEARING)...
Read full bulletin
PROCESS HAS BEEN DEVELOPED TO HELP IDENTIFY THE ROOT CAUSES OF THESE COMPLAINTS. *PE
Lighting
1 bulletinMINI: CHECK SVS FUNCTION.
Read full bulletin
ON CERTAIN VEHICLES, THE VOICE INPUT SYSTEM (SVS SA 620) DOES NOT FUNCTION. THE SVS WAS NOT INSTALLED IN THE VEHICLES. *PE
Body & Paint
1 bulletinMINI: REAR SPLIT DOOR OPENING PROBLEMS.
Read full bulletin
ONE OR BOTH OF THE REAR SPLIT DOORS INTERMITTENTLY HAVE FUNCTIONAL PROBLEMS. THE DOOR(S) MAY NOT UNLATCH WHEN THE LEVER ON THE HANDLE IS PULLED OR THE LATCH MAY RELEASE UNEXPECTEDLY WITHOUT BEING PULLED. *PE UPDATED 7/10/09. *PE
Transmission
1 bulletinBMW(MINI): TRANSMISSION - VARIOUS EGS FAULTS CAUSED BY WIRING HARNESS DAMAGE.
Read full bulletin
DIFFICULT TO ENGAGE THE D OR R GEARS FROM PARK POSITION; GEAR SHIFTS ARE EXTREMELY HARSH DURING DRIVE; INTERMITTENTLY THE TRANSMISSION WARNING LIGHT MAY BE DISPLAYED. *PE