2004 Mercury Sable TSBs

CAMSHAFT TICK NOISE - 3.0L 4V ENGINE ONLY.

SPARK KNOCK, HESITATION ABOVE 3000 RPM, LOSS OF POWER, MISFIRE, AND POSSIBLE ENGINE DAMAGE DUE TO DETONATION AND PRE-IGNITION - 3.0L-2V VULCAN GAS/FFV.

WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING.

SURGE, IDLE ROLL, ROUGH IDLE ONLY WHEN THE ENGINE COOLING FANS ARE OPERATING.

VARIOUS DRIVEABILITY CONDITIONS-3.0L 2V AND FLEX FUEL ENGINE.

NO CRANK - BATTERY DISCHARGED ON 3.0L 4V ENGINE.

ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS.

WIPER MOTOR CONTINUOUS OPERATION.

WATER IN THE BLOWER CASE OR ON THE PASSENGER SIDE FLOOR, AN INOPERATIVE CLIMATE CONTROL BLOWER MOTOR, A MOTOR THAT...

COLD ENGINE HARD START/NO START AND/OR SLIGHT SURGING AT IDLE.

MALFUNCTION INDICATOR LAMP ON WITH DIAGNOSTIC TROUBLE CODE P0300 (RANDOM MISFIRE DETECTED).

LOWER ENGINE OIL LEAKS 3.0L 2V VULCAN ENGINE.

HESITATION WHEN ACCELERATING OR DURING TRANSMISSION UPSHIFT.

ENGINE OIL LEAKS FROM THE FILTER AREA ON VEHICLES WITH A 3.0L 2-VALVE ENGINE.

NO START OR ENGINE QUIT CONDITION AFTER CLOSING LUGGAGE COMPARTMENT LID.

This article supersedes TSB 19-2026 to update the vehicle model years affected.

Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns...

Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns...

POWER WINDOW CONCERNS - SERVICE TIP.

ALUMINUM CORROSION - SERVICE TIP.

GRUNTING NOISE FROM FRONT POWER WINDOW GLASS IS POWERED TO THE FULL UP POSITION.

WINDSHIELD WIPER CONTINUES TO RUN.

UNCOMMANDED DECKLID OPENING, DOME-LIGHT ILLUMINATED, CHIME SOUNDING, AND/OR MULTIPLE DOOR AJAR WARNING.

RKE INOPERATIVE. *EH

SAFETY BELT RETRACTION SPEED.

VIBRATION IN ACCELERATOR PEDAL 40-42 MPH ON 2004-2005 TAURUS/SABLE MODELS.

SPEEDOMETER CONCERNS.

VIBRATION IN ACCELERATOR PEDAL 40-42 MPH.

A NO START/HARD START CONDITION DURING A COLD START.

EXTENDED WARRANTY COVERAGE FOR VEHICLES WITH HARD START WHEN OPERATING ON E85 FUEL, POWERTRAIN CONTROL MODULE (PCM) CALIBRATION.

GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES.

GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES.

MALFUNCTION INDICATOR LAMP ILLUMINATION DUE TO WIRE HARNESS CHAFING.

AN INTERMITTENT MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODE (DTC) P0462 (FUEL LEVEL SENSOR A...

REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR.

REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR.

INOPERATIVE ELECTRIC REAR WINDOW DEFROSTER (HEATED BACKLITE) GRID LINES, INTEGRAL ANTENNA CONCERNS.

FUEL GAUGE READS EMPTY WITH FUEL IN TANK.

MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS.

MALFUNCTION INDICATOR LAMP ON WITH DIAGNOSTIC TROUBLE CODE P0133, P1131 OR P2195.

MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODE (DTC) P0171/P0174, P1131/P1151, AND/OR P2195/P2197 IN CONTINUOUS MEMORY.

HARD START/NO START COLD AND/OR MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODES (DTCS) P2196/P2198.

POWER LOCK CONCERNS - SERVICE TIP.

SAFETY BELT WEB STOP BUTTON SERVICE.

REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS.

ERRATIC FLUID LEVEL READING ON TRANSAXLE DIPSTICK-LEAKS-4F50N, AX4N, AX4S TRANSAXLE.

4F50N TRANSAXLE NO 1-2 UPSHIFT AND DIAGNOSITC TROUBLE CODE P0732.

GROAN/BUZZ/VIBRATION WHEN THE GEAR SELECTOR IS IN PARK WITH THE VEHICLE PARKED ON AN INCLINE.

TENTHS DIGIT NOT DISPLAYED ON ODOMETER AFTER 10,000 MILES/KILOMETERS.

ACCELERATION PEDAL VIBRATION.

AIR BAG SYSTEM WARNING LIGHT ON WITH DIAGNOSTIC TROUBLE CODE (DTC) B1884.

NOISE FROM FRONT SUSPENSION AREA.

STEERING COLUMN LOCK DISCONTINUED.