1997 Mercury Sable TSBs

SOME VEHICLES EQUIPPED WITH THE 3.0L 4V DURATEC ENGINE MAY EXHIBIT A MALFUNCTION INDICATOR LAMP ILLUMINATED WITH A...

ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE.

SOME VEHICLES MAY EXHIBIT A CHECK ENGINE LIGHT AND/OR EGR DIAGNOSTIC TROUBLE CODES 332, P0401, P1407 (LACKOF EGR FLOW).

SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA.

SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174.

ON SOME VEHICLES, ENGINE OIL MAY CONTINUE TO LEAK FROM THE ENGINE OIL PAN GASKET AREA AFTER AN ENGINE OIL PAN GASKET REPAIR HAS BEEN PERFORMED.

SOME VEHICLES MAY EXHIBIT COOLING SYSTEM CONDITIONS SUCH CONTAMINATED / CORRODED COOLANT; LEAKING / DISCOLORED COOLANT...

SUBJECT REGARDING ENGINE OIL RECOMMENDATIONS FOR USE IN 2001 VEHICLES - SAE 5W-20 MOTOR OIL.

SOME VEHICLES EQUPPED WITH 3.0L 2V VULCAN OR 4V DURATEC ENGINE MAY EXHIBIT AN EXHAUST RUST-THRU, WELD FATIGUE CONDITION...

SOME VEHICLES MAY EXHIBIT CONTAMINATED / CORRODED COOLANT, HIGH OR FLUCTUATING TEMP GAUGE, COOLANT ODOR, COOLANT...

SOME VEHICLES MAY EXHIBIT A HARD START / LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN.

SOME VEHICLES MAY EXHIBIT CONTAMINATED / CORRODED COOLANT, HIGH OR FLUCTUATING TEMP GAUGE, COOLANT ODOR, COOLANT...

SOME VEHICLES MAY EXHIBIT DIAGNOSTIC TROUBLE CODE P1518 AND/OR P1519, RELATED TO INTAKE MANIFOLD RUNNER CONTROL (IMRC).

SOME VEHICLES MAY EXHIBIT DTC P1518 AND / OR P1519, RELATED TO INTAKE MANIFOLD RUNNER CONTROL (IMRC).

SOME VEHICLES EQUIPPED WITH 3.0L 4-VALVE ENGINES MAY EXHIBIT A CUSTOMER CONCERN OF A MOAN NOISE AT IDLE.

SOME VEHICLES MAY EXHIBIT A HARD START/LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN.

SOME VEHICLES (3.0L 4 VALVE ONLY) MAY EXHIBIT A CATALYTIC CONVERTER BUZZ OR RATTLE CONDITION ON A COLD START OR DURING A LOW RPM STEADY SPEED.

REPEAT MESSAGE REGARDING CONTAMINATED / CORRODED COOLANT, HIGH OR FLUCTUATING TEMP GAUGE; COOLANT ODOR, COOLANT...

SOME VEHICLES EQUIPPED WITH 3.0L 2-VALVE ENGINES MAY EXHIBIT A SPARK KNOCK CONCERN ON ACCELERATION.

INFORMATION REGARDING CAMSHAFT POSITION (CMP) SENSOR ALIGNMENT TOOL CHART.

SOME SERVICE MANUALS MAY LIST THE INCORRECT CAMSHAFT POSITION SENSOR ALIGNMENT TOOL FOR VEHICLES WITH VARIOUS ENGINE SIZES.

ENGINE CHECK LAMP ON WITH MISFIRE DTC(S).

SOME 1996-1998 TAURUS/SABLE VEHICLES WITH 3.0L 4-V ENGINE MAY EXHIBIT A CONCERN OF MOAN NOISE AT IDLE.

ENGINE SPARK KNOCK ON ACCELERATION.

FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS.

FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR.

FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS.

CONCERNS WITH THE TIMING ARROWS/FLAGS ON THE BACK OF THE CAMSHAFT SPROCKET (S) ARE MIS-MARKED BY AS MUCH AS 30 DEGREES ROTATION.

SOME ENGINE VALVES MAY EXHIBIT A CUSTOMER CONCERN OF A MOAN NOISE AT IDLE.

VEHICLES EXPERIENCING COOLANT ODOR, COOLANT OVERFLOW, HIGH OR FLUCTUATING TEMP GAUGE READINGS, BLOWN OR LEAKING HOSES,...

EXERPEINCING A MOANING NOISE HEARD FROM THE POWER STEERING DURING ENGINE IDLE.

THE MALFUNCTION INDICATOR LAMP (MIL) MAY ILLUMINATE FOR MISFIRES AT HIGH ENGINE RPMS DURNG ENGINE WARM UP.

SOME VEHICLES DURING WET WEATHER CONDITIONS AND/OR WHEN DRIVING THROUGH PUDDLES AND /OR THE CRANKSHAFT PULLEY MAY BE DAMAGED.

VEHICLES EXHIBITING A "SQUEAKING" OR "CHIRPING" FROM THE BLOWER MOTOR AT LOW BLOWER MOTOR SPEEDS.

SOME VEHICLES MAY EXPERIENCE A KNOCK OR WOP NOISE IN THE PASSENGER COMPARTMENT.

VEHICLES MAY EXPERIENCE A KNOCK OR WOP NOISE IN THE PASSENGER COMPARTMENT.

BLOWER MOTOR- "CHIRPING" OR "SQUEAKING" FROM BLOWER MOTOR AT LOW SPEEDS.

HESITATION- ON ACCELERATION- VEHICLES WITH 3.0L 4-VALVE ENGINE.

HESITATION- ON ACCELERATION- VEHICLES WITH 3.0L 4-VALVE ENGINE.

CONCERN OF WATER INGESTION IN ENGINE.

WHISTLE OR SQUEAL NOISE IN THE ENGINE COMPARTMENT ON 1997 VEHICLES BUILT BEFORE 11/1/96 WITH THE 2-VALVE ENGINE.

WHISTLE OR SQUEAL NOISE FROM ENGINE COMPARTMENT.

BUZZ NOISE IN AX4S TRANSAXLES AT ALL SPEEDS OR IDLE ON VEHICLES.

SURGE AT STEADY CRUISE (POWER TRAIN SHUFFLE), MISFIRE CODES, STALLS AT HIGH AMBIENT TEMPERATURES.

FOR 1996 3.0L 2-VALVE VEHICLES STOP UPDATING THE PROCESSOR TO THE R-12 CALIBRATION.

A "GRUNTING" OR "GROANING" NOISE MAY OCCUR AS THE STEERING WHEEL RETURNS TO ITS CENTER POSITION DURING A FULL RIGHT TURN...

ENGINES ARE EQUIPPED WITH A UNIQUE CRANKSHAFT PULLEY ASSEMBLY WHICH THREADS INTO THE CRANKSHAFT DAMPER USING A LEFT-HANDED THREAD.

THE REAR MAIN SEAL REMOVAL TOOL LISTED IN THE SERVICE MANUAL FOR THE 3.0L 4V DURATIC AND 4.6L CONTINENTAL ENGINES, IS INCORRECT.

OWNER GUIDE LISTS THAT THE 3.0L 2V VULCAN ENGINE USES A FL-400-S OIL FILTER AND THE 3.0L 4V DURATEC USES A FL-820-S FILTER.

UNEVEN IDLE RPM, STALL, ROUGH RUNNING, SURGE, AND/OR SPARK KNOCK WHEN THE COOLING FANS COME ON AT A IDLE.

THE CRANKSHAFT DAMPER BOLT, FOUND UNDERNEATH THE PULLEY HAS A STANDARD RIGHT AND LEFT HAND THREAD.

RESIDUAL BRAKE PRESSURE ON THE REAR BRAKES OF A 1996-1997 TAURUS OR SABLE, MAKE SURE TO SUPPORT THE REAR CONTROL ARMS TO...

FOR 1996 3.OL 2-VALVE VEHICLES STOP UPDATING THE PROCESSOR TO THE R-12 CALIBRATION.

TRANSAXLE - AX4S - EXTENDED 2-3 SHIFT AND/OR HIGHER THAN EXPECTED ENGINE RPM DURING 2-3 SHIFT AT LIGHT TO MEDIUM...

PROCEDURE FOR UPDATING THE CALIBRATION FROM R-11 TO R-12 FOR STALLING ON DECEL & MISFIRE CODES ON 3.0L VEHICLES.

CONCERNS OF VEHICLE STALL, HESITATION STUMBLE, ROUGH IDLE, MISSING, FUEL PRESSURE, OR FUEL PRESSURE RELATED CHECK THE REAR GROUND.

REPETITIVE THUMPING/KNOCKING NOISE PROPORTIONAL TO WHEEL SPEED WHEN BRAKING.

SURGE, IDLE ROLL, ROUGH IDLE ONLY WHEN THE ENGINE COOLING FANS ARE OPERATING.

ENGINE-GEAR DRIVEN SYNCHRONIZERS-INCORRECT INSTALLATION-CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION.

INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER,...

VEHICLES EQUIPPED WITH PASSIVE ANTI-THEFT SYSTEM (PATS) MAY NOT START OR CRANK.

DIAGNOSING HARD START / LONG CRANK CONDITION.

SUBJECT REGARDING GENERAL STALLING CONCERNS.

REPEAT MESSAGE REGARDING HARD START / LONG CRANK CONDITION.

VEHICLES MAY EXHIBIT A BUZZ OR RATTLE CONDITION ON A COLD START OR DURING A LOW RPM STEAD SPEED.

THE OWNER NOTIFICATION PROGRAM 98B23 CONTAINED INCORRECT LABOR ALLOWANCE AND COOLANT PART NUMBER INFORMATION

INFORMATION REGARDING THE WINNERS OF THE EDSR OF THE MONTH QUALITY AWARDS FOR THE MONTH OF AUGUST.

INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA.

INFORMATION ON PROGRAMMING / DIAGNOSING ANY PASSIVE ANTI-THEFT SYSTEM (PATS) RELATED ISSUES.

INFORMATION REGARDING PROGRAMMING / DIAGNOSING PASSIVE ANTI-THEFT SYSTEM (PATS) RELATED ISSUES.

EXHIBITING A VIBRATION AT SPPEDS OF 45 MPH AND ABOVE WITH THE CRUISE ON.

SOME VEHICLES MAY EXHIBIT AN INTERMITTENT NEUTRAL CONDITION AFTER DRIVING AND COMING TO A STOP.

HARD START/LONG CRANK.

CLUNK OR PLOP COMING FROM FRONT END.

CONTAMINATED/CORRODED COOLANT, HIGH OR FLUCTUATING TEMPERATURE GAUGE.

INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS.

INFORMATION ON SERVICING OIL PAN GASKET LEAKS.

INSTALLATION OF COOLING SYSTEM BY-PASS KIT.

INFORMATION REGARDING REPLACEMENT AND / OR REPAIRS ON ANY LOCK COMPONENT.

SOME VEHICLES WITH A VERY LOW ODOMETER READING MAY EXPERIENCE A LACK TEMPERATURE CONTROL.

SOME VEHICLES EXPERIENCE A HARD START/LONG CRANK TIME CONDITION.

EXPERIENCING A HARD START / LONG CRANK.

OWNER NOTIFICATION PROGRAM 98B18- COOLING SYSTEM BY-PASS KIT INSTALLATION.

SOME VEHICLES MAY EXPERIENCE AN NO FORWARD OR REVERSE MOVEMENT.

REPAIRS TO VINYL COVERED SURFACES.

INFORMATION IN TSB 97-09-04 IS INCORRECT.

VEHICLES HAVE A CABIN AIR FILTER THAT MUST BE CHANGED EVERY 15000 MILES.

PASSIVE ANTI-THEFT SYSTEM.

FRAME - SUBFRAME INSULATORS - CLUNK ON HEAVY ACCELERATION AND/OR DECELERATION HEARD OR FELT IN FLOOR PAN AREA - VEHICLES BUILT THROUGH 2/28/97.

NOISE-"CREAKING" IN A-PILLAR WHEN GOING OVER BUMPS AND/OR TURNING-VEHICLES BUILT THROUGH 12/31/96.

DIAGNOSTIC PROCEDURE FOR SYSTEM INDICATORS KIT WITH DTCS C1165 AND/OR C1175.

PROCEDURE FOR CONCERNS OF RIDE QUALITY.

CONCERNS OF A SURGE (POWERTRAIN SHUFFLE) AT 35-40 MPH.

SOME VEHICLES MAY EXHIBIT A PARK PULLOUT CLUNK NOISE WHEN SHIFTING FROM PARK TO ANOTHER GEAR POSITION.

SOME VEHICLES MAY EXHIBIT A GROAN/BUZZ/VIBRATION WHEN THE GEAR SELECTOR IS IN PARK.

BRAKE SHIFT INTERLOCK.*JB

INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS.

WHEN DIAGNOSING CRANK / NO START ON CERTAIN VEHICLES EQUIPPED WITH PASSIVE ANTI-THEFT (PATS) CHECK THE CUSTOMERS KEY...

INFORMATION REGARDING TSB 98-5A-12 (TRANSAXLE/TRANSMISSION/TRANSFER CASE-VEHICLES TOWED BEHIND RECREATIONAL...

INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP.

SOME VEHICLES EQUIPPED WITH AX4S TRANSAXLE, MAY EXHIBIT A HARSH 2-3 DOWNSHIFT MAY OCCUR WHEN COASTING AROUND A CORNER AND THEN ACCELERATING.

SOME VEHICLES EQUIPPED WITH THE AX4S TRANSAXLE MAY EXHIBIT A HARSH 3-2 DOWNSHIFT WHEN COASTING AROUND A CORNER AND THEN...

CONCERNS WITH BUZZ OR VIBRATION WITH THE GEAR SELECTOR IN PARK.

CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK.

INFORMATION ON TRANSAXLE SERVICE CASE REPLACEMENT WITH OSS (OUTPUT SHAFT SPEED SENSOR) HOLE.

CONCERNS WITH REVERSE CLUTCH THAT COULD BECOME SHEARED OR TORN IN EXTREMELY COLD TEMPERATURES.

A REVISED FORWARD CLUTCH INNER SEAL FOR THE AXOD, AXODE, AX4S & AX4N TRANSAXLE IS AVAILABLE WITH IMPROVED SEALING AND...

TORQUE CONVERTER CLUTCH NOT ENGAGING AND/OR DIAGNOSTIC TROUBLE CODE (DTC) P0741 OR P1744 STORED IN MEMORY.

INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART.

TRANSAXLES USE A NEW TRANSMISSION FLUID.

CONCERNS WITH HARSH ENGAGEMENTS AND HARSH SHIFTS WITH DIAGNOSTIC TROUBLE CODES (DTCS) 628, P0741 AND/OR P1744.

HARSH 1-2 UPSHIFT. *TW

FLUID- TRANSMISSION FLUID USAGE CHARTS.

BUZZ NOISE IN AX4S TRANSAXLES.

VERIFY THE TRANSAXLE INSTALLED IN THE VEHICLE IS THE CORRECT MODEL AND MODEL YEAR FOR THE VEHICLE.

A BUZZ NOISE IN AX4S TRANSAXLES ON 1996/97 TAURUS/SABLE AND WINDSTARS.

TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP.

TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP.

SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL.

VEHICLES SHIPPED W/ LOW TRANSAXLE FLUID LEVEL.

LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK.

GROAN/BUZZ/VIBRATION WHEN THE GEAR SELECTOR IS IN PARK WITH THE VEHICLE PARKED ON AN INCLINE.

NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS.

TORQUE CONVERTER CLUTCH NOT ENGAGING WHEN COMMANDED AND/OR DIAGNOSTIC TROUBLE CODES P0741 OR P1744 STORED IN MEMORY.

SOME VEHICLES MAY EXHIBIT AN INTERMITTENT LOSS OF INTEGRATED CONTROL PANEL (ICP) ILLUMINATION.

INFORMATION ON INSTALLING A NEW FUEL PUMP ON CERTAIN VEHICLES.

SOME VEHICLES MAY EXHIBIT A HARD / NO START CONCERN WHEN PARKED IN A STEEP NOSE-UP POSITION WITH LESS THAN 1/4 TANK OF...

SUBJECT REGARDING SERVICE EVAPORATOR ASSEMBLIES.

SOME VEHICLES MAY EXHIBIT A HARD / NO START CONCERN WHEN PARKED IN A STEEP NOSE-UP POSITION WITH LESS THAN 1/4 TANK OF...

INFORMATION ON THE SERVICE EVAPORATOR ASSEMBLIES.

SOME VEHICLES MAY EXHIBIT MALFUNCTION INDICATOR LIGHT ON WITH EVAPORATIVE DIAGNOSTIC TROUBLE CODES P0442, P0455 SET.

SOME VEHICLES MAY EXHIBIT AN INTERMITTENT LOSS OF INTEGRATED CONTROL PANEL (ICP) ILLUMINATION.

INFORMATION ON INSTALLATION A NEW FUEL PUMP , ENSURE THAT THE PUMP HAS PLASTIC SHEATHING OVER THE WIRES.

A DIRECT REPLACEMENT PART FOR THE EVAPORATIVE EMISSION CANISTER AND BRACKET ASSEMBLY.

MIL LIGHT ON WITH EVAPORATIVE DTC P0442, P0455

FUEL GAUGE ACCURACY OR FUEL GAUGE ERRATIC OPERATION.

EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP.

EXPERIENCING DIFFICULTY DIAGNOSING VEHICLES WITH EVAPORATIVE FUEL SYSTEM DIAGNOSTIC TROUBLE CODES.

EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM.

INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM.

FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE.

NOISY FUEL PUMPS ON 1996/97 VEHICLES.

NOISY FUEL PUMPS ON 1996/1997 TAURUS/SABLE VEHICLES.

VEHICLES MAY EXHIBIT A WHISTLE CONDITION FROM THE A/C EVAPORATOR.

THE EGR TUBE TORQUE SPECIFICATIONS IN SERVICE MANUAL ARE INCORRECT.

MALFUNCTION INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0442, P0455, P0456, P0457 OR P1442 OR A...

MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK...

SOME VEHICLES MAY EXPERIENCE A SEPARATION BETWEEN LAYERS OF THE INSTRUMENT PANEL.

A SEPARATION BETWEEN LAYERS OF THE INSTRUMENT PANEL.*JB

SOME VEHICLES MAY EXHIBIT A POWER WINDOW THAT WILL NOT OPERATE DOWNWARD BECAUSE IT'S STUCK / BOUND TO THE WEATHERSHIP HEADER.

SOME VEHICLES MAY EXHIBIT AN INOPERATIVE POWER WINDOW CONCERNS.

INFORMATION ON VEHICLES EXHIBITING AN INOPERATIVE POWER WINDOW.

SOME VEHICLES MAY EXHIBIT AN INTERMITTENT LOSS OF INSTRUMENT CONTROL PANEL (ICP) ILLUMINATION.

VEHICLES MAY EXHIBIT INTERMITTENT INSTRUMENT CONTROL PANEL (ICP) ILLUMINATION.

A TRANSEAL COATING IS ON THE FRONT AND REAR BUMPERS.

SOME VEHICLES MAY EXHIBIT B1522 OR GEM "HOOD SW" PID CONCERNS.

SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP.

EXHIBITING AN INOPERATIVE POWER WINDOW.

SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF,...

A NEW SILICONE GASKET AND SEALANT.

WATER LEAK AT THE RIGHT FRONT FLOOR, CHECK FOR A BROKEN COWL TOP INNER PANEL SHIELD.

WATER LEAK AT THE RIGHT FRONT FLOOR ON VEHICLES, CHECK FOR A BROKEN COWL TOP INNER PANEL SHIELD.

WATER LEAK IN THE REAR OF A TAURUS OR SABLE WAGON, CHECK FOR WATER ENTERING IN AT THE REAR HATCH HINGES.

WINDSHIELD AND INTERIOR GLASS - FOG/FILM.

ERRATIC OPERATION OF THE COOL/WARM FUNCTION OF THE TEMPERATURE CONTROL SYSTEM - REPAIR PROCEDURE FOR STRATIFICATION (SECONDARY) TEMPERATURE BLEND DOOR.

SOME VEHICLES MAY EXHIBIT A NGS ERROR MESSAGE, TOTAL CHECKSUM ERROR AFTER NGS / SBTS PCM REPROGRAMMING.

SOME VEHICLES MAY EXHIBIT A NGS ERROR MESSAGE AFTER NGS/SBTS PCM REPROGRAMMING.

SOME VEHICLES EQUIPPED WITH PATS (SECURILOCK) EXCEPT CERTAIN MODELS NOW HAVE AVAILABILITY OF FLEET KEYS THROUGH ROTUNDA.

INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS.

SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES.

INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS).

MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP.

CONCERNS OF A POSSIBLE CHAFING OF THE FUEL PUMP ASSEMBLY WIRES RESULTING IN AN OPEN FUSE AND/OR INOPERABLE FUEL PUMP ASSEMBLY OR A NO START CONDITION.

VEHICLES ARE EQUIPPED WITH PASSIVE ANTI-THEFT SYSTEM (PATS) - VEHICLE WILL NOT START WITHOUT THE CORRECT IGNITION KEY.

BATTERY OES DEAD OVERNIGHT.

BATTERY GOES DEAD- CHECK THE CURRENT DRAW WITH AN AMMETER.

BODY - PRODUCT CHANGES FOR 1997 TAURUS/SABLE AND TAURUS SHO VEHICLES ELECTRICAL - PRODUCT CHANGES FOR 1997 TAURUS/SABLE...

POWERTRAIN CONTROL MODULE -REPROGRAM POWERTRAIN CONTROL MODULE (PCM) - SERVICE PROCEDURES - SERVICE TIP.

MASS AIR FLOW SENSOR - REPLACEMENT AS AN ASSEMBLY - SERVICE TIP.

WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS.

GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES.

GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES.

EXHAUST SYSTEM Y-PIPE CRACK AT THE NOISE VIBRATION HARNESS BRACKET.

SOME VEHICLES MAY EXHIBIT A RATTLING OR CLUNKING NOISE FROM THE FRONT END (FRONT STABILIZER LINK) UNDER NORMAL DRIVING...

DIAGNOSTIC AND INSPECTION PROCEDURE FOR FRONT SUSPENSION NOISE.

SOME VEHICLES MAY EXHIBIT A CLUNKING NOISE FROM THE REAR SUSPENSION WHEN DRIVING OVER BUMPS.

AIR CONDITIONING- R-134A TRACER DYE INSTALLED IN A/C SYSTEM AND THREE O-RING SPRING LOCK COUPLERS- SERVICE TIP.

THUMP/KLUNK NOISE FROM FRONT SUSPENSION AREA.

REPLACING FRONT OR REAR STRUTS ON A 1996/97 VEHICLE, THE REPLACEMENT STRUT MAY APPEAR TO BE APPROXIMATELY 2" TOO SHORT...

REPLACING FRONT REAR STRUTS ON A VEHICLE, THE REPLACEMENT STRUT MAY APPEAR TO BE APPOXIMATELY 2" TOO SHORT.

THUMP/CLUNK NOISE FROM FRONT SUSPENSION AREA.

SUSPENSION - CLUNKING NOISE FROM FRONT SUSPENSION - TAURUS SABLE BUILT THROUGH 1/14/97 - CONTINENTAL BUILT THROUGH 12/16/96.

REMOVING OR REPLACING ONE OF THE FRONT STRUT SPRING ON A VEHICLE US A ROTUNDA #014-00781 STRUT SPRING COMPRESSOR MASTER SET.

THUMP/CLUNK NOISE FROM FRONT SUSPENSION AREA.

REMOVING OR REPLACING ONE OF THE FRONT STRUT SPRINGS ON A 1996/97 TAURUS OR SABLE VEHICLE USE ROTUNDA #014-00781 STRUT SPRING COMPRESSOR MASTER SET.

SUSPENSION - REAR - AVAILABILITY OF CAMBER KIT TO IMPROVE INNER EDGE WEAR ON REAR TIRES.

THUMP/CLUNK NOISE FROM FRONT SUSPENSION AREA.

SERVICE ACTION BULLETIN REGARDING ON-BOARD DIAGNOSTIC SYSTEM UPGRADE.

SERVICE TIP INFORMATION ON REVISED OIL PAN GASKET REPLACEMENT PROCEDURE.

SUBJECT REGARDING PASSIVE ANTI THEFT SYSTEM (PATS) DIAGNOSTIC SERVICE TIPS.

DIAGNOSTIC SERVICE TIPS ON PASSIVE ANTI THEFT SYSTEM ( PATS ).

DEACTIVATION PROCEDURE - CLARIFICATION OF INSTRUCTIONS IN SERVICE MANUAL.

LOCKS- REMOTE KEYLESS ENTRY (RKE)- LOCATION OF RKE FOBS- SERVICE TIP- VEHICLES BUILT AFTER 3/17/97.

INTERIOR- LEATHER SEAT CLEANING PROCEDURE- SERVICE TIP.

REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS.

SOME VEHICLES MAY EXHIBIT FRONT SUSPENSION NOISE DUE TO FRONT STRUT, FRONT SWAY BAR LINKS OR SYMPTOMS SUCH AS PREMATURE...

INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT.

SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT.

AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT.

SERVICE TIP INFORMATION REGARDING ELIMINATION OF SANDING ROTORS AND DRUMS.

HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE.

RESIDUAL BRAKE PRESURE ON THE REAR BRAKES OF A 1996-1997 VEHICLE, MAKE SURE TO SUPPORT THE REAR CONTROL ARMS TO REMAIN...

ABS INDICATOR ILLUMINATION WITH DTC C1095.

SOME VEHICLES MAY EXHIBIT FRONT OUTER TIE RODS SQUEAK AND / OR POP NOISE OVER BUMPS AND / OR TURNING.

SOME VEHICLES MAY EXHIBIT A STEERING GROAN NOISE.

THE FRONT END ACCESSORY DRIVE (FEAD) BELT MAY SLIP MOMENTARILY IN WET CONDITIONS CAUSING A REDUCTION IN POWER STEERING ASSIST OR THE GENERATOR LAMP.

STEERING- STEERING COLUMN- AIR BAG SLIDING CONTACT SERVICING- SERVICE TIP.

GROAN OR MOAN NOISE FROM THE POWER STEERING WHEN RETURNING FROM A RIGHT TURN.

GROAN OR MOAN NOISE FROM THE POWER STEERING WHEN RETURNING FROM A RIGHT TURN.

REPEAT POWER STEERING GRUNT/GROAN AFTER COMPLETION OF TSB 97-02-04.

STEERING - GRUNTING OR GROANING NOISE DURING STEERING WHEEL RETURN FROM FULL RIGHT TURN - VEHICLES BUILT THROUGH 11/8/96.

SOME VEHICLES MAY EXHIBIT A SLIGHT VIBRATION DURING ACCELERATION ONLY.

LOCKS FAILED. YD

INFORMATION REGARDING SLIGHT VIBRATION UPON ACCELERATION.

INFORMATION ON DIAGNOSING A VEHICLE WITH MALFUNCTION INDICATOR LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODES P0442 AND...

SOME VEHICLES MAY EXHIBIT A MALFUNCTION INDICATOR LAMP (MIL) WITH DIAGNOSTIC TROUBLE CODE (DTC) P1135 OR P1155 STORED IN...

EXPERIENCING DIFFICULTIES WITH THE MALFUNCTION INDICATOR LAMP (MIL).

MOISTURE CAN BECOME TRAPPED BETWEEN THE RUBBER MOLDING AND LENS EDGE OF THE REAR TAIL LAMPS.

SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS.

INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS.

SERVICE INFORMATION FOR MUSTY AND MILDEW TYPE ODORS COMING FROM THE AIR CONDITIONING / HEATING SYSTEM.

MICRON FILTER - REMINDER THAT THE FILTER MUST BE CHANGED EVERY 15000 MILES - SYMPTOMS THAT MIGHT INDICATE NEED FOR...

CLIMATE CONTROL A/C SERVICE TECH TIPS.

EXPERIENCING A SQUEAKING AND / OR POPPING NOISE FROM THE FRONT OUTER TIRE RODS.

INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE.

CONCERNS OF GRUNT OR GROAN DURING WHEEL RETURN.

INFORMATION FOR CONCERNS OF GRUNT OR GROAN DURING WHEEL RETURN FROM FULL RIGHT TURN.

FIRESTONE P235 TIRES MAY EXHIBIT A HIGH FREQUENCY VIBRATION AT 65-75 MPH.

SOME VEHICLES EQUIPPED WITH COMPACT DISC CHANGER MAY EXHIBIT A 6 DISC CD CHANGER THAT IS NOT EJECTING THE MAGAZINE OR IS...

EXPERIENCING A WHINING / BUZZING NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO.

SOME VEHICLES MAY EXPERIENCE STATIC IN THE AM BAND OF THE RADIO WHILE DRIVING.

MAY HAVE NO AUDIO IN CDDJ MODE.

SERVICE ACTION 00E11, SUPPLEMENT #1 - UPDATE INFORMATION REGARDING ON-BOARD DIAGNOSTIC SYSTEM UPGRADE.

WHEN PERFORMING THE AIR BAG DEACTIVATION PROCEDURE, THE SERVICE MANUALS DO NOT CLEARLY STATE WHICH SIMULATORS TO USE ON THE PASSENGER SIDE AIR BAG.