2005 Mercury Mountaineer TSBs

MIL ON WITH DTC P0191 WITH OR WITHOUT VARIOUS DRIVABILITY SYMPTOMS AND/OR ADDITIONAL DTCS.

A TINY CRACK, OR CRACKS, AROUND THE TRANSFER CASE DRAIN PLUG HOLE.

REAR AXLE NOISE REPAIR.

NO START/HARD START ON COLD SOAK.

REAR AXLE NOISE REPAIR.

WELD BONDING PROCEDURE.

INCREASED EFFORT DURING LOW SPEED SHARP TURNS ON 4X4 VEHICLES.

SAFETY BELT RETRACTION SPEED.

LIMITED SLIP AXLE CHATTER, SHUDDER, BINDING SENSATION, OR VIBRATION DURING LOW SPEED TURNING MANEUVERS.

DRIVELINE 1ST ORDER VIBRATION/BOOM/DRONE.

INCREASED TURNING EFFORT DURING LOW SPEED SHARP TURNS FALSE 4X4 ENGAGEMENT.

NO CRANK/NO START CONDITION WHEN VEHICLE TEMPERATURE IS BELOW FREEZING (32F/0C).

FORD/LINCOLN/MERCURY: IF BATTERY WAS DISCONNECTED OR DEAD, VEHICLES/TRUCKS MAY EXPERIENCE HARD STARTS AND ENGINE...

SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT...

WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING.

NO START/HARD START ON COLD SOAK - 4.0L ENGINE.

SERVICE ENGINE SOON LAMP ON WITH PCM DTC P0463, INSTRUMENT CLUSTER DTC B1201 AND OR FUEL GAUGE DROPS TO EMPTY-VEHICLES BUILT 8/2/2004 THROUGH 4/7/2005.

THROTTLE PEDAL RESPONSE ON TIP IN VEHICLES BUILT BEFORE 10/4/2004 EQUIPPED WITH A 4.0L ENGINE.

ROUGH IDLE IN DRIVE. *EH

MIL ON AND/ OR RUNS ROUGH/MISFIRE DTCS P0300-P0308 P0316 AND OR P0171/P0174 4.6L ENGINE.

ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS.

Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns...

Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns...

FORD: SOME VEHICLES MAY EXHIBIT OIL SEPARATION FROM THE INTERNAL LUBE FOUND IN THE UNITIZED CARTRIDGE SEAL.

BACKGLASS DIFFICULT TO CLOSE AND AN INTERMITTENT DOOR AJAR LAMP.

RATTLING NOISE - RIGHT FRONT FENDER WHILE DRIVING.

ALUMINUM CORROSION - SERVICE TIP.

AXLE SEAL LEAKS. LEAKS FROM REAR HALFSHAFT AXLE SEAL.

LIFTGATE GLASS APPLIQUE DAMAGED/CRACKED.

The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs).

LOW TIRE INDICATOR ON - TPMS SYSTEM SENSOR WAKE UP.

MALFUNCTION INDICATOR LAMP ON WITH PCM DIAGNOSTIC TROUBLE CODE P0463 AND/OR IC DIAGNOSTIC TROUBLE CODE B1201 - FUEL...

GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES.

GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES.

OPEN FUSE F2.20 (5 AMP) AND/OR F2.1 (30 AMP) WHICH MAY RESULT IN LOSS OF FUNCTION OF SEVERAL SYSTEMS INCLUDING POWER...

MAF DIAGNOSTIC SERVICE TIP - VEHICLES EQUIPPED WITH EGR SYSTEM MODULE (ESM).

MIL ON WITH DTC P0463 OR ERRATIC FUEL GAUGE OPERATION.

MIL ON WITH P0463 OR ERRATIC FUEL GAUGE OPERATION.

REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR.

FUEL GAUGE SLOW TO UPDATE AFTER REFUELING.

WRENCH LAMP ON AND NO DIAGNOSTIC TROUBLE CODE (DTC) STORED.

FRONT SEAT(S) SLIGHT MOVEMENT WHEN ACCELERATING AND/OR DECELERATING.

MALFUNCTION INDICATOR LAMP (MIL) AND ELECTRONIC THROTTLE CONTROL (ETC) LAMPS ON WITH BOTH DIAGNOSTIC TROUBLE CODE (DTC) P2106 AND P2135.

MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTC'S) P0172 AND/OR P0175.

DELAYED OR HARSH REVERSE ENGAGEMENTS - 5R55S TRANSMISSION - VEHICLES BUILT PRIOR TO 09/23/2004.

GEAR SELECTOR LEVER - INCREASED EFFORT TO SHIFT FROM DRIVE TO PARK.

IMPROPERLY FORMULATED TRANSMISSION FLUID THAT, OVER TIME, MAY CAUSE DELAYED/HARSH REVERSE ENGAGEMENTS.

VIBRATION DIAGNOSIS - TIRE/WHEEL RUNOUT.

NOISE FROM REAR WHEEL HUB BEARINGS.