2001 Mercury Mountaineer TSBs

SOME VEHICLES BUILT PRIOR TO 9/15/2001 MAY EXHIBIT LOW LINE PRESSURE READINGS WHILE IN DRIVE, NO 2ND GEAR, NO 3RD GEAR,...

SOME VEHICLES EQUIPPED WITH THE 4.0 SOHC (SINGLE OVER-HEAD CAM) ENGINE MAY EXHIBIT A PRIMARY TIMING CHAIN RATTLE NOISE.

SOME VEHICLES MAY EXHIBIT A NO 1-2 UPSHIFT, NO 2-3 UPSHIFT, A NO ENGINE BRAKING CONDITION IN MANUAL 1 OR DIAGNOSTIC...

INFORMATION ON DIAGNOSING ENGINE RATTLE NOISE FROM PRIMARY CHAIN DRIVE AREA BETWEEN 2000-3000 RPM ON COLD ENGINE OPERATION ONLY.

SOME VEHICLES EQUIPPED WITH THE 4.0L SOHC ENGINE MAY EXHIBIT A CHECK ENGINE LIGHT ON WITH DIAGNOSTIC TROUBLE CODES P0300 (RANDOM MISFIRE) OR P0301.

SOME VEHICLES MAY EXHIBIT A CHECK ENGINE LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457 (GROSS LEAK AFTER FUEL FILL).

CONCERNS WITH SPARK KNOCK NOISE OR CHAIN RATTLE NOISE BETWEEN 2000-3000 RPM, DURING COLD ENGINE OPERATION ONLY.

ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE.

SOME 4.0L SOHC MAY EXHIBIT AN ENGINE OIL LEAK CONDITION, COMING FROM THE OIL PAN OR LADDER FRAME AREA.

SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA.

SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174.

SOME IGNITION SWITCH LOCK CYLINDER ASSEMBLIES MAY EXHIBIT ROUGNESS AND / OR EXCESS EFFORT IN TURNING, KEY DOES NOT FULLY...

SOME VEHICLES MAY EXHIBIT DRIVABILITY CONDITIONS OR CHECK ENGINE LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0455 OR P0457.

SOME VEHICLES MAY EXHIBIT DRIVABILITY CONDITIONS OR CHECK ENGINE LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0455 OR P0457 STORED.

EXHIBITING DRIVABILITY CONDITIONS OR CHECK ENGINE LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0455 (GROSS LEAK DETECTED).

SOME VEHICLES EQUIPPED WITH 5.0L ENGINE MAY EXHIBIT A MALFUNCTION INDICATOR LIGHT (MIL) ON WITH POSSIBLE DIAGNOSTIC...

SOME VEHICLES EQUIPPED WITH 4.0L SOHC MAY EXHIBIT A HIGHER THAN NORMAL BASE IDLE SPEED OF 1200-1400 RPM WHEN THE VEHICLE...

SOME VEHICLES EQUIPPED WITH THE 4.0 SOHC ENGINE MAY EXHIBIT A PRIMARY CHAIN RATTLE NOISE (SOMETIMES DESCRIBED AS A SPARK KNOCK-TYPE NOISE).

SUBJECT REGARDING CLIMATE CONTROL - EATC - BLOWER MOTOR CONTROL SERVICE TIPS.

CONCERNS WITH BROKEN THERMOSTATS ON ENGINES.

SOME VEHICLES EQUIPPED WITH A 5.0L ENGINE MAY EXHIBIT A MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODE...

SOME VEHICLES EQUIPPED WITH 5.0L ENGINE MAY EXHIBIT A MALFUNCTION INDICATOR LIGHT (MIL) ON WITH POSSIBLE DIAGNOSTIC...

SOME VEHICLES EQUIPPED WITH A 5.0L ENGINE MAY EXHIBIT A MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE...

FORD MOTOR COMPANY IS PROVIDING ADDITIONAL COVERAGE FOR THE 4.0L SOHC CAMSHAFT CHAIN TENSIONER AND LOWER INTAKE MANIFOLD GASKET.

SOME VEHICLES MAY EXHIBIT AN OIL LEAK FROM THE FRONT AXLE PINION OIL SEAL AREA.

SOME VEHICLES MAY EXHIBIT AN OIL LEAK FROM THE FRONT AXLE PINION OIL SEAL AREA.

SOME 2000 AND 2001 MODEL YEAR VEHICLES MAY EXHIBIT AN OIL LEAK FROM THE INSIDE DIAMETER OF THE REAR AXLE PINION OIL SEAL.

SOME VEHICLES MAY EXHIBIT AN OIL LEAK FROM THE INSIDE DIAMETER OF THE REAR AXLE PINION OIL SEAL.

RATTLE/BUZZ SOUND FROM UNDER THE VEHICLE ON 4.0L SINGLE OVERHEAD CAM (SOHC) ENGINES.

IDLE AIR CONTROL (IAC) VALVE DIAGNOSTIC SERVICE TIPS.

INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER,...

ON SOME VEHICLES, THE ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) BLOWS COLD AIR FROM THE FLOOR DUCTS ON VEHICLES PRODUCED BEFORE 9/30/2000 ONLY.

SOME VEHICLES MAY EXHIBIT A SQUEAK, SNAP, RATTLE, OR CLUNK IN THE FRONT END WHEN TURNING OR GOING OVER BUMPS.

SOME VEHICLES MAY EXHIBIT A HARD START/LONG CRANK CONDITION AFTER SITTING FOR AN HOUR OR MORE.

SOME VEHICLES BUILT BEFORE APRIL 23, 2001 MAY EXHIBIT A HARD START/LONG CRANK AFTER SITTING FOR AN HOUR OR MORE.

SOME 4X4 VEHICLES WITH FEWER THAN 10,000 MILES MAY EXHIBIT GREASE OOZING FROM THE FRONT DRIVESHAFT CV JOINT.

INFORMATION REGARDING MULTIFUNCTION SWITCH PART NUMBER CLARIFICATION.

SOME 4X4 VEHICLES MAY EXHIBIT A HIGH-PITCHED SQUEAL OR WHISTLE TYPE NOISE FROM THE FRONT AXLE AREA OF THE VEHICLE AT...

SOME VEHICLES WITH FEWER THAN 10,000 MILES MAY EXHIBIT GREASE OOZING FROM THE FRONT DRIVESHAFT CV JOINT.

CONCERNS WITH VEHICLES EXHIBITING THE OIL PRESSURE GAUGE REGISTERING LOW OR NO OIL PRESSURE USUALLY ON INITIAL START-UP...

HIGH-PITCHED FRONT AXLE SQUEAL OR WHISTLE TYPE NOISE FROM THE FRONT OF THE VEHICLE AT SPEEDS FROM 16 TO 64 KM/H (10 TO 40 MPH).

CONCERNS WITH VEHICLES EXHBIT FLUID LEAKAGE FROM THE FRONT AXLE VENT TUBE.

SOME 4X4 VEHICLES MAY EXHIBIT A FLUID LEAK FROM THE FRONT AXLE VENT TUBE.

ON SOME VEHICLES, INCLUDING SPORT AND SPORT TRAC, THE FRONT AXLE LEAKS FLUID FROM THE VENT TUBE.

VEHICLES EQUIPPED WITH PASSIVE ANTI-THEFT SYSTEM (PATS) MAY NOT START OR CRANK.

SOME VEHICLES MAY EXHIBIT THE OIL PRESSURE GAUGE REGISTERING LOW OR NO OIL PRESSURE USUALLY ON INITIAL STRT-UP AFTER SEVERAL HOURS OF COLD SOAK.

SOME VEHICLES MAY EXHIBIT HESITATION ON ACCELERATION OR WHILE TURNING.

SUBJECT PERTAINING TO BROKEN THERMOSTAT.

SOME VEHICLES MAY EXHIBIT A HARD START / NO START CONDITION WHEN ATTEMPTING TO START THE VEHICLE.

FRONT AXLE LEAKS FLUID FROM VENT TUBE - VEHICLES EQUIPPED WITH 4X4 OR AWD.

SAFETY BELT RETRACTION SPEED.

FLUID MAY LEAK OUT OF THE FRONT AXLE VENT TUBE.

LOW LINE PRESSURE READING AT WIDE OPEN THROTTLE (WOT), SLIPPING SHIFTS AND / OR DELAYED ENGAGEMENTS WITH POSSIBLE...

BRAKE SHIFT INTERLOCK.*JB

INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS.

SOME VEHICLES EQUIPPED WITH A 4R70W AUTOMATIC TRANSMISSION MAY EXHIBIT A CLUNK NOISE DURING THE 2-1 DOWNSHIFT EVENT.

SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) ACCOMPANIED BY A DIAGNOSTIC TROUBLE CODE...

SOME VEHICLES EQUIPPED WITH 4R70W TRANSMISSION MAY EXHIBIT THE TCIL ON WITH DIAGNOSTIC TROUBLE CODE P0741 (TORQUE...

SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM.

LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK.

NEW SERVICE PART - NUMBER 5 NEEDLE BEARING AND RACE KIT - 4R70W TRANSMISSION - SERVICE TIP.

AN UNCOMMANDED SHIFT TO 4X4 LOW.

NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS.

SOME VEHICLES BUILT BEFORE APRIL 23, 2001 MAY EXHIBIT A HARD START/LONG CRANK AFTER SITTING FOR AN HOUR OR MORE DUE TO FUEL SYSTEM CONTAMINATION.

INFORMATION ON VEHICLES EXHIBITNG FUEL LINE DAMAGE DUE TO PINCHING/SQUEEZING OF THE FUEL RETURN LINE.

REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR.

REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR.

INOPERATIVE ELECTRIC REAR WINDOW DEFROSTER (HEATED BACKLITE) GRID LINES, INTEGRAL ANTENNA CONCERNS.

FUEL SIGNAL TO INSTRUMENT CLUSTER SERVICE TIP.

MALFUNCTION INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0442, P0455, P0456, P0457 OR P1442 OR A...

MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK...

CONCERNS WITH REAR WIPERS THAT DO NOT SUFFICIENTLY CLEAN THE BACK GLASS.

SOME 4 DOOR VEHICLES WITH THE AUTOLAMP FEATURE MAY EXHIBIT A CONDITION OF THE HEADLAMPS STAYING ON ALL THE TIME.

ON SOME VEHICLES THE REAR WIPER ARM FAILS TO CLEAN BACK GLASS.

SOME VEHICLES MAY EXHIBIT ONE OR ALL POWER WINDOWS INOPERATIVE, ALL OR ONE OF THE POWER DOOR LOCKS INOPERATIVE OR ALLTHE...

SUBJECT REGARDING POP / CREAK NOISE FROM THE REAR UNDERBODY WHILE DRIVING.

SOME VEHICLES MAY EXHIBIT A SQUEAK NOISE FROM THE FRONT LOWER DOOR HINGE(S) WHEN OPENING OR CLOSING THE DOORS.

ALUMINUM CORROSION - SERVICE TIP.

PAINT-PREMATURE CLEARCOAT CRACKING-SERVICE TIPS.

INFORMATION REGARDING MALFUNCTION INDICATOR LIGHT ILLUMINATING WITH DIAGNOSTIC TROUBLE CODE P0300/P0301.*YH

SOME VEHICLES MAY COME IN FOR A MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODE P0171 AND/OR P0174 IN SELF TEST.

SOME VEHICLES MAY EXHIBIT A COOLING SYSTEM LEAK DUE TO A BROKEN CONSTANT TENSION CLAMP.

SOME VEHICLES MAY EXHIBIT A COOLING SYSTEM LEAK DUE TO A BROKEN CONSTANT TENSION CLAMP.

MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS.

SOME VEHICLES MAY EXHIBIT REPEAT SERVICE FOR AIR BAG LAMP ON WITH DIAGNOSTIC TROUBLE CODE B1994 (DRIVER SIDE AIR BAG...

INFORMATION REGARDING DISCHARGED BATTERY CHARGING SERVICE TIPS AND GUIDELINES.

GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES.

GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES.

SOME VEHICLES MAY EXHIBIT REPEAT SERVICE FOR AN AIR BAG LAMP ON WITH DIAGNOSTIC TROUBLE CODES B1994 AND B1998 SET.

SEAT BELT WARNING SYSTEM - BELT REMINDER FUNCTION, OPERATION AND SERVICE TIPS.

AIR BAG LAMP ON WITH DIAGNOSTIC TROUBLE CODES B1994 AND / OR B1998 STORED IN MEMORY.

CERTAIN VEHICLES WITH 4X4 OR ALL-WHEEL DRIVE MAY HAVE A FLUID LEAK FROM THE FRONT AXLE VENT TUBE.

OWNER NOTIFICATION PROGRAM SUPPLEMENT 7 REVISED INFORMATION - REGARDING REPLACEMENT OF WILDERNESS AT TIRES.

SUBJECT PERTAINING TO SUPPLEMENTAL TIRE INFLATION LABEL.

CONCERNS WITH BRAKE VIBRATION, ROUGHNESS AND / OR GRINDING NOISE, AND EXCESSIVE BRAKE ROTOR CORROSION.

CONCERNS WITH HIGH BRAKE PEDAL FORCE TO STOP AFTER ROTOR MACHINING.

SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS.

CLIMATE CONTROL A/C SERVICE TECH TIPS.

EXPERIENCING A CLICKING / POPPING NOISE FROM THE UPPER STEERING COLUMN AREA WHEN TURNING THE STEERING WHEEL.

WARNING INDICATORS-PARKING AID-REVERSE SENSING SYSTEM (RSS) AND FORWARD SENSING SYSTEM (FSS)-FALSE ACTIVATION OF WARNING TONE-SERVICE TIPS.

REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS.

VARIOUS NOISE ISSUES FROM THE REAR LEAF SPRINGS WHILE DRIVING.