1998 Mercury Mountaineer TSBs

SOME VEHICLES BUILT PRIOR TO 9/15/2001 MAY EXHIBIT LOW LINE PRESSURE READINGS WHILE IN DRIVE, NO 2ND GEAR, NO 3RD GEAR,...

SOME VEHICLES MAY EXHIBIT A NO 1-2 UPSHIFT, NO 2-3 UPSHIFT, A NO ENGINE BRAKING CONDITION IN MANUAL 1 OR DIAGNOSTIC...

SOME VEHICLES EQUIPPED WITH THE 4.0L SOHC ENGINE MAY EXHIBIT A CHECK ENGINE LIGHT ON WITH DIAGNOSTIC TROUBLE CODES P0300 (RANDOM MISFIRE) OR P0301.

ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE.

SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA.

SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174.

SOME IGNITION SWITCH LOCK CYLINDER ASSEMBLIES MAY EXHIBIT ROUGNESS AND / OR EXCESS EFFORT IN TURNING, KEY DOES NOT FULLY...

SOME VEHICLES MAY EXHIBIT HARSH DOWNSHIFT FROM 3RD TO 1ST GEAR WHILE STOPPING, HESITATION AFTER ACCELERATION FROM STOP...

SOME VEHICLES BUILT THROUGH 01/1999, EQUIPPED WITH A 5.0L ENGINE MAY EXHIBIT A COLD START OR HOT ENGINE DECELERATION NOISE COMING FROM THE #5 CYLINDER.

SOME 4X4 VEHICLES MAY EXHIBIT AN OIL LEAK FROM THE FRONT AXLE PINION SEAL.

SUBJECT REGARDING ADDITIONAL COVERAGE ON THE FRONT CAM CHAIN GUIDE ASSEMBLY FOR RENTAL VEHICLES WITH 4.0L SINGLE OVERHEAD CAM (SOHC) ENGINES.

SOME VEHICLES EQUIPPED WITH THE 4.0 SOHC ENGINE MAY EXHIBIT A PRIMARY CHAIN RATTLE NOISE (SOMETIMES DESCRIBED AS A SPARK KNOCK-TYPE NOISE).

OWNER NOTIFICATION PROGRAM REGARDING ADDITIONAL COVERAGE PROGRAM FOR FRONT CAM CHAIN GUIDE ASSEMBLY WHICH MAY WEAR OR...

SUBJECT REGARDING CLIMATE CONTROL - EATC - BLOWER MOTOR CONTROL SERVICE TIPS.

CONCERNS WITH BROKEN THERMOSTATS ON ENGINES.

VEHICLES MAY EXPERIENCE START UP TIMING CHAIN NOISE.

SUBJECT REGARDING OWNER NOTIFICATION SUPPLLEMENTAL PROGRAM FOR VEHICLES EQUIPPED WITH 4.0L SOHC ENGINES - CAMSHAFT CHAIN...

SOME VEHICLES BUILT THROUGH 01/1999 AND EQUIPPED WITH A 5.0L ENGINE MAY EXHIBIT A COLD START OR HOT ENGINE DECELERATION...

FORD MOTOR COMPANY IS PROVIDING ADDITIONAL COVERAGE FOR THE 4.0L SOHC CAMSHAFT CHAIN TENSIONER AND LOWER INTAKE MANIFOLD GASKET.

BRIEF INFORMATION REGARDING ENGINE STALL CONDITION.

INFORMATION ON VEHICLES EXHIBITING UPPER ENGINE NOISE.

BRIEF INFORMATION FOR VEHICLES EXHIBITING ENGINE STALL.

SOME VEHICLES MAY EXHIBIT NO / LOW A/C PERFORMANCE AT HIGH AMBIENT TEMPERATURES AND PROLONGED IDLE.

ENGINEERING IS INVESTIGATING CONCERNS OF NOISY FRONT SYSTEM BLOWER MOTORS ON CERTAIN VEHICLES.

SOME VEHICLES MAY EXHIBIT AN OIL LEAK FROM THE FRONT AXLE PINION OIL SEAL AREA.

SOME VEHICLES MAY EXPERIENCE AN OIL LEAK AT THE REAR CRANKSHAFT AREA AFTER SERVICE.

SOME VEHICLES MAY EXHIBIT AN OIL LEAK FROM THE FRONT AXLE PINION OIL SEAL AREA.

SOME VEHICLES MAY EXPERIENCE AN OIL LEAK AT THE REAR CRANKSHAFT AREA AFTER SERVICE.

SOME VEHICLES EQUIPPED WITH A 5.0L ENGINE MAY EXHIBIT A RUBBING NOISE DURING RIGHT HAND TURNS FROM THE REAR OF THE VEHICLE.

SOME VEHICLES MAY EXHIBIT A HESITATION / LACK OF POWER ON RE-ACCELERATION AFTER DECELERATING FROM HIGHWAY SPEED (45-65...

SOME VEHICLES EQUIPPED WITH 5.0L ENGINES MAY EXHIBIT AN UPPER ENGINE TAPPING NOISE ON COLD START.

ALL VEHICLES EQUIPPED WITH 4.0L SOHC THAT REQUIRE ENGINE SERVICE PLEASE NOTE THAT THE XL2Z-6M289-AA (DRIVE...

REPEAT MESSAGE REGARDING ENGINE STALLING *TT

BRIEF INFORMATION REGARDING UPPER ENGINE NOISE.

INFORMATION CONCERNING THE REPLACEMENT OF THE ENGINES ON VEHICLES EQUIPPED WITH A 4.0L SOHC THAT REQUIRE SERVICE.

SOME VEHICLES EQUIPPED WITH 5.0L ENGINES AND ALL WHEEL DRIVE (AWD) TRANSFER CASE MAY EXHIBIT A CONDITION OF 4X4...

SOME VEHICLES EQUIPPED WITH 5.0L ENGINE AND ALL WHEEL DRIVE (AWD) TRANSFER CASE MAY EXHIBIT A CONDITION OF 4X4...

SOME VEHICLES EQUIPPED WITH 4.0L SOHC ENGINES MAY EXHIBIT AN OVERHEAT CONDITION THAT MAY BE ATTRIBUTED TO THE THERMOSTAT.

CONCERNS WITH VEHICLES EXHIBITING AN OIL LEAK FROM THE FRONT AXLE PINION SEAL.

EXPERIENCING VERY LIGHT STEERING VIBRATION / SHIMMY / NIBBLE AT ENGINE IDLE OR LOW SPEEDS (PARKING LOT TYPE MANEUVERS).

SOME VEHICLES MAY EXHIBIT NO / LOW AIR CONDITIONER PERFORMANCE AT HIGH AMBIENT TEMPERATURES AND PROLONGED IDLE.

EXHIBITING VERY LIGHT STEERING VIBRATION / SHIMMY / NIBBLE AT ENGINE IDLE OR LOW SPEEDS.

SOME VEHICLES MAY EXHIBIT AN OIL LEAK FROM THE FRONT AXLE PINION SEAL.

INFORMATION REGARDING CLEAN AIR TUBE RETAINING CLAMPS / THROTTLE BODY CAM.

SOME 4X4 VEHICLES MAY EXHIBIT AN OIL LEAK FROM THE FRONT AXLE PINION SEAL.

SOME VEHICLES WITH 4.0L SOHC ENGINES MAY EXHIBIT A VIBRATION / MOAN / BOOM AT IDLE.

SOME VEHICLES EQUIPPED WITH 4.0L SOHC ENGINES MAY EXHIBIT A VIBRATION / MOAN / BOOM AT IDLE.

INFORMATION REGARDING CAMSHAFT POSITION (CMP) SENSOR ALIGNMENT TOOL CHART.

INFORMATION REGARDING 4.0L SOHC ENGINE REPAIR PROCEDURE UPDATE.

INFORMATION REGARDING SOHC ENGINE NOISE (CAM CHAIN NOISE).

INFORMATION REGARDING 4.0L SOHC ENGINE NOISE (CAM CHAIN NOISE).

INFORMATION REGARDING 4.0 L SOHC CAMSHAFT BOLT TORQUE.

SOME SERVICE MANUALS MAY LIST THE INCORRECT CAMSHAFT POSITION SENSOR ALIGNMENT TOOL FOR VEHICLES WITH VARIOUS ENGINE SIZES.

SUBJECT REGARDING 4.0L SOHC ENGINE REPAIR PROCEDURE UPDATE.

SOME VEHICLES MAY EXHIBIT ENGINE NOISE(CAM CHAIN NOISE).

INFORMATION REGARDING 4.0L SOHC CAMSHAFT BOLT TORQUE.

SOME VEHICLES MAY EXHIBIT THE CHECK ENGINE LIGHT ON WITH DIAGNOSTIC TROUBLE CODE PO420.

CONCERNS WITH BURNING ODOR OR SMOKE, AND / OR RUSTLING NOISE WHILE BLOWER MOTOR IS ON.

SOME VEHICLES MAY EXHIBIT A BURNING ODOR OR SMOKE, AND / OR RUSTLING NOISE OCCURING WHEN THE BLOWER MOTOR IS RUNNING IF...

VEHICLES WITH A4WD TRANSMISSION AND 4.0L ENGINE MAY HAVE THE 4X4 INDICATOR LAMPS FLASHING.

SOME VEHICLES MAY EXHIBIT AN ENGINE OIL LEAK FROM THE REAR MAIN CRANKSHAFT SEAL.

SOME VEHICLES BUILT BEFORE 1/1/1999 EQUIPPED WITH 5.0L ENGINE MAY EXHIBIT A FRONT ACCESSORY DRIVE (FEAD) BELT NOISE.

THE MALFUNCTION INDICATOR LAMP (MIL) MAY ILLUMINATE AND DIAGNOSTIC TROUBLE CODES (DTCS) P0171, P0174, P1131, AND / OR...

FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS.

FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR.

FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS.

SOME CUSTOMERS HAVE REPORTED THE THROTTLE STUCK AT IDLE ON SOME VEHICLES.

EXPERIENCING A NOISE AND VIBRATION DURING IDLE.

ENGINEERING IS INVESTIGATING CONDITIONS CONCERNING ROOF RACK TAP PLATES.

EXPERIENCING IDLE VIBRATION / EXHAUST BOOM.

ENGINE-GEAR DRIVEN SYNCHRONIZERS-INCORRECT INSTALLATION-CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION.

RATTLE/BUZZ SOUND FROM UNDER THE VEHICLE ON 4.0L SINGLE OVERHEAD CAM (SOHC) ENGINES.

INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER,...

ON SOME VEHICLES, THE ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) BLOWS COLD AIR FROM THE FLOOR DUCTS ON VEHICLES PRODUCED BEFORE 9/30/2000 ONLY.

SOME VEHICLES MAY EXHIBIT A SQUEAK, SNAP, RATTLE, OR CLUNK IN THE FRONT END WHEN TURNING OR GOING OVER BUMPS.

SUBJECT REGARDING OWNER NOTIFICATION PROGRAM 01M01 SUPPLEMENT #2: REVISED TECHNICAL INSTRUCTIONS AND NEW LABOR OPERATION.

SOME 4X4 VEHICLES MAY EXHIBIT A HIGH-PITCHED SQUEAL OR WHISTLE TYPE NOISE FROM THE FRONT AXLE AREA OF THE VEHICLE AT...

SOME VEHICLES MAY EXHIBIT AN INTERMITTENT HESITATION ON ACCELERATION OR WHILE TURNING.

SUBJECT REGARDING OWNER NOTIFICATION PROGRAM 01M01 REGARDING ADDITIONAL COVERAGE FOR FRONT CAM CHAIN GUIDE ASSEMBLY.

HIGH-PITCHED FRONT AXLE SQUEAL OR WHISTLE TYPE NOISE FROM THE FRONT OF THE VEHICLE AT SPEEDS FROM 16 TO 64 KM/H (10 TO 40 MPH).

CONCERNS WITH VEHICLES EXHBIT FLUID LEAKAGE FROM THE FRONT AXLE VENT TUBE.

SOME 4X4 VEHICLES MAY EXHIBIT A FLUID LEAK FROM THE FRONT AXLE VENT TUBE.

ON SOME VEHICLES, INCLUDING SPORT AND SPORT TRAC, THE FRONT AXLE LEAKS FLUID FROM THE VENT TUBE.

VEHICLES EQUIPPED WITH PASSIVE ANTI-THEFT SYSTEM (PATS) MAY NOT START OR CRANK.

SOME VEHICLES MAY EXHIBIT HESITATION ON ACCELERATION OR WHILE TURNING.

SUBJECT REGARDING ADVANCE NOTICE ON UPCOMING OWNER NOTIFICATION PROGRAM WHICH WILL PROVIDE ADDITIONAL COVERAGE ON THE...

SUBJECT PERTAINING TO BROKEN THERMOSTAT.

SOME VEHICLES MAY EXHIBIT A SEAT SQUEAK / RATTLE / ROCK FROM THE FRONT POWER SEAT TRACK.

SOME VEHICLES MAY COME IN FOR A BENT FRONT SEAT BACK RECLINER LEVER.

SOME VEHICLES MAY EXHIBIT A SEAT SQUEAK / RATTLE / ROCK FROM THE FRONT POWER SEAT TRACK.

SOME VEHICLES MAY COME IN FOR A BENT FRONT SEAT BACK RECLINER LEVER.

SUBJECT REGARDING NEUTRAL TOW INOPERATIVE AFTER GEM REPLACEMENT.

SOME VEHICLES MAY EXHIBIT A VIBRATION / GROAN ON ACCELERATION OR TAKE OFF.

SOME VEHICLES MAY EXHIBIT A SQUEAK NOISE FROM THE REAR WHILE DRIVING, ESPECIALLY WHEN GOING BUMPS.

SOME VEHICLES MAY EXHIBIT A HIGH PITCHED SQUEAL OR WHISTLE TYPE NOISE FROM THE FRONT END AT SPEEDS FROM 10 MPH TO 40 MPH.

SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO (DTC)...

SOME VEHICLES WITH A4WD BUILT PRIOR TO 9/13/99 MAY EXHIBIT A VIBRATION / PULSATION AT 0 - 45 MPH.

THE REAR WIPER BLADE ON SOME VEHICLES BUILT THROUGH 1/22/99 MAY FLIP OVER WHEN RUN THROUGH SOFT CLOTH STYLE CAR WASHES.

USE KLEENEX BRAND JUNIORS OR LI'L TRAVELERS TO REFILL TISSUES FOR CERTAIN VEHICLES WITH THE HIGH SERIES CENTER CONSOLE FACIAL TISSUE COMPARTMENT.

VEHICLES WITH LIMITED SLIP / TRACTION-LOK REAR AXLES MAY EXHIBIT A CHATTER NOISE WHILE TURNING.

SOME VEHICLES MAY EXHIBIT A HIGH PITCHED SQUEAL OR WHISTLE TYPE NOISE FROM THE FRONT END AT SPEEDS FROM 10 MPH TO 40 MPH.

A CONDITION WITH THE REAR WIPER BLADE ON VEHICLES BUILT THROUGH 1/22/1999 MAY FLIP OVER WHEN RUN THROUGH SOFT CLOTH STYLE CAR WASHES.

INFORMATION REGARDING NEUTRAL TOW KIT AVAILABLE.

INFORMATION REGARDING SEAT THAT WILLL NOT MOVE FORWARD.

INFORMATION REGARDING NEUTRAL TOW KIT AVAILABILITY.

INFORMATION REGARDING SEAT THAT WILL NOT MOVE FORWARD.

EXPERIENCING AN INOPERATIVE OR INACCURATE ODOMETER / SPEEDOMETER READINGS.

INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA.

INFORMATION ON PROGRAMMING / DIAGNOSING ANY PASSIVE ANTI-THEFT SYSTEM (PATS) RELATED ISSUES.

PATS KEY PROGRAMMING.

INFORMATION REGARDING PROGRAMMING / DIAGNOSING PASSIVE ANTI-THEFT SYSTEM (PATS) RELATED ISSUES.

CONCERNS WITH AXLE WIND-UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS.

SOME 1997-1998 EXPLORER/MOUNTAINEER/EXPEDITION OR NAVIGATOR VEHICLES WITH 4-WD 4X4 SYSTEM MAY EXHIBIT BOTH

INFORMATION ON ADDITIONS TO THE FORD QUALITY RENEWAL ASSEMBLY PROGRAM.

INFORMATION ON RESETTING THE PASSIVE ANTI-THEFT SYSTEM (PATS).

EXPERIENCING A GRUNT NOISE WHILE TURNING.

SOME 4X4 VEHICLES MAY EXHIBIT A HIGH PITCHED SQUEAL OR WHISTLE TYPE NOISE FROM THE FRONT END AT SPEEDS FROM 10 MPH TO 40 MPH.

INFORMATION ON REFILLING TISSUES FOR THE CENTER CONSOLE FACIAL TISSUE COMPARTMENT.

VEHICLES MAY EXHIBIT A FRONT ACCESSORY DRIVE (FEAD) BELT NOISE.

INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS.

EXPERIENCING DRIFT / PULL TO THE RIGHT CONDITONS.

CONCERNS OR ERRATIC OR INSUFFICIENT TEMPERATURE CONTROL.

SOME VEHICLES MAY EXHIBIT A HESITATION / LACK OF POWER ON RE-ACCELERATION AFTER DECELERATING FROM 45 - 65 MPH TO A SLOW ROLL CONDITION.

EXPERIENCING A WHINNING NOISE FROM THE TRANSFER CASE.

ON SOME VEHICLES BUILT THROUGH 1/22/99 THE REAR WIPER BLADE MAY FLIP OVER WHEN RAN THROUGH SOFT CLOTH STYLE CAR WASHES.

SOME VEHICLES EQUIPPED WITH LIMITED SLIP / TRACTION-LOCK REAR AXLES MAY EXHIBIT A CHATTER NOISE WHILE TURNING.

COMPLAINTS THAT THE REAR WIPER BLADE FLIPS OVER.

COMPLAINTS THAT THE IN-DASH CD STOPS OPERATING WHEN HOT.

VEHICLE MAY EXHIBIT A HIGH PITCHED SQUEAL / WHISTLE TYPE NOISE FROM THE FRONT END AT SPEEDS FROM 10 MPH TO 40 MPH.

INFORMATION REGARDING REPLACEMENT AND / OR REPAIRS ON ANY LOCK COMPONENT.

SOME VEHICLES WITH A VERY LOW ODOMETER READING MAY EXPERIENCE A LACK TEMPERATURE CONTROL.

ISSUES REGAREDING DIAGNOSTIC TROUBLE CODES ( DTCS ) P0705, P0708, P1704, AND / OR P1705 MAY BE STORED IN MEMORY.

CONDENSATE MAY LEAK ONTO THE PASSENGER FLOOR ON SOME VEHICLES.

CONCERNS WITH THE POWER SEAT CONTROL BUTTON ( KNOB ) MAY DETACH FROM THE SWITCH ACTUATOR.

CONDITIONS WITH THE FRONT SEAT BACK LEVER BENT.

CONCERNS WITH BUILT-IN REAR CHILD SAFETY SEAT MAY NOT EASILY ACCOMMODATE SOME CHILDREN.

CONCERNS WITH A WHISTLING OR HISSING NOISE FROM THE MAIN CONTROL AREA OCCURING WHILE IDLING IN DRIVE AND / OR REVERSE ON SOME VEHICLES.

SOME DIFFICULTY IN MATCHING THE TEXTURE OF THE OEM ANTI-CHIP STONE ABRASION MATERIAL TO RPAIR MATERIALS WHEN SERVICING.

REPAIRS TO VINYL COVERED SURFACES.

FRONT AXLE LEAKS FLUID FROM VENT TUBE - VEHICLES EQUIPPED WITH 4X4 OR AWD.

FLUID MAY LEAK OUT OF THE FRONT AXLE VENT TUBE.

LOW LINE PRESSURE READING AT WIDE OPEN THROTTLE (WOT), SLIPPING SHIFTS AND / OR DELAYED ENGAGEMENTS WITH POSSIBLE...

BRAKE SHIFT INTERLOCK.*JB

INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS.

SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) ACCOMPANIED BY A DIAGNOSTIC TROUBLE CODE...

SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM.

ALL 4X4 VEHICLES WITH ELECTRONIC SHIFT ONTHE FLY TRANSFER CASES WILL DISPLAY CONTACT PLATE PIDS OPPOSITE OF THE 1999 OR...

WHEN DIAGNOSING CRANK / NO START ON CERTAIN VEHICLES EQUIPPED WITH PASSIVE ANTI-THEFT (PATS) CHECK THE CUSTOMERS KEY...

FOR CERTAIN MODEL VEHICLES, THE 4R70W TRANSMISSION SOLENOID MOLDED LEADFRAME MUST BE REPLACED WHEN REMOVED.

INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP.

SOME VEHICLES MAY EXHIBIT A VIBRATION / GROAN ON ACCELERATION OR TAKE-OFF DUE TO THE REAR TRANSMISSION MOUNT BEING...

ALL VEHICLES WITH ELECTRONIC SHIFT ON THE FLY TRANSFER CASES WILL DISPLAY CONTACT PLATE PIDS OPPOSITE OF WHAT THE 1999...

EXHIBITING A POWER STEERING FLUID LEAK FROM THE STEERING GEAR BOOT(S).

BRIEF INFORMATION ON CHECKING TRANSMISSION FLUID LEVEL.

VEHICLES BUILT BETWEEN 3/15/1997 AND 12/31/1998 AND WITH 4R70W TRANSMISSIONS MAY EXPERIENCE DELAYED OR NO 2-3 UPSHIFT,...

EXHIBITING A POWER STEERING FLUID LEAK FROM THE STEERING GEAR BOOT(S).

CONCERNS WITH TRANSMISSION FLUID LEAKING AT THE RADIATOR.

EXPERIENCING A DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD ON VEHICLES WITH FORD QALITY...

SOME VEHICLES MAY EXHIBIT HARSH DOWNSHIFT FROM 3RD TO 1ST GEAR WHILE STOPPING; HESITATION AFTER ACCELERATION FROM STOP;...

SERVICE TIPS FOR CHECKING TRANSMISSION FLUID LEVEL.

CONCERNS WITH TRANSMISSION FLUID LEAKING AT RADIATOR.

THE 4R70W TRANSMISSION INSTALLED IN SOME VEHICLES WILL HAVE AN ORANGE

INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART.

LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK.

NEW SERVICE PART - NUMBER 5 NEEDLE BEARING AND RACE KIT - 4R70W TRANSMISSION - SERVICE TIP.

AN UNCOMMANDED SHIFT TO 4X4 LOW.

NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS.

INFORMATION REGARDING DISCHARGED BATTERY CHARGING SERVICE TIPS AND GUIDELINES.

INFORMATION ON REPLACING A GEM MODULE ON 4X4 VEHICLES EQUIPPED WITH 4.0L SOHC, OHV AND THE NEUTRAL TOW KIT.

FOR ALL VEHICLES WITH GENERIC ELECTRONIC MODULE (GEM) CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST...

SOME VEHICLES EQUIPPED WITH PATS (SECURILOCK) EXCEPT CERTAIN MODELS NOW HAVE AVAILABILITY OF FLEET KEYS THROUGH ROTUNDA.

SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO DIAGNOSTIC...

SUBJECT REGARDING ALL VEHICLES REQUIRES A PARAMETER RESET TO BE PERFORMED ON THE PASSIVE ANTI-THEFT SYSTEM MODULE (PATS...

INFORMATION ON REPLACING AND REMOVING THE GENERIC ELECTRONIC MODULE (GEM).

INFORMATION ON REMOVING AND / OR REPLACING THE GENERIC ELECTRONIC MODULE (GEM).

INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS.

SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES.

INFORMATION REGARDING HARNESS CHAFING ISSUE.

INFORMATION PERTAINING TO HARNESS CHAFFING ISSUE.

VEHICLE EXHIBITING MULTIPLE GENERIC ELECTRONIC MODULE (GEM) RELATED SYMPTOMS.

INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS).

MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP.

GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES.

GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES.

CONCERNS WITH REAR WIPERS THAT DO NOT SUFFICIENTLY CLEAN THE BACK GLASS.

ON SOME VEHICLES THE REAR WIPER ARM FAILS TO CLEAN BACK GLASS.

SUBJECT REGARDING POP / CREAK NOISE FROM THE REAR UNDERBODY WHILE DRIVING.

ON SOME VEHICLES, THE ACCELERATOR PEDAL BRACKET MAY BECOME LOOSE OR SEPARATED FROM THE DASH PANEL.

SOME VEHICLES MAY EXHIBIT A WATER LEAK CONCERN FROM THE MOONROOF.

SOME VEHICLES MAY EXHIBIT A WATER LEAK CONCERN FROM THE MOONROOF.

EXPERIENCING WATER LEAK INTO THE VEHICLE THROUGH THE MOONROOF OPENING.

INFORMATION ON REPLACING THE FRONT BUMPER BRACKET.

SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP.

CONCERNS WITH THE POTENTIAL EFFECTS OF ADHESIVES USED FOR BODY PANEL REPAIRS.

CONCERNS WITH ADHENSIVES NOT RECOMMENDED FOR BODY PANEL REPAIRS.

SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF,...

A NEW SILICONE GASKET AND SEALANT.

EXHIBITING A SQUEAKING / CREAKING NOISE HEARD FROM THE RIGHT SIDE OF THE INSTRUMENT PANEL WHILE TURNING OR DURING ANY BODY FLEXING.

SERVICE TIPS FOR SURFACE DEFECT REMOVAL WITHOUT REPAINTING.

INFORMATION ON VEHICLES EXHIBITNG FUEL LINE DAMAGE DUE TO PINCHING/SQUEEZING OF THE FUEL RETURN LINE.

VEHIUCLES WITH 4.0L OHV/SOHC, 5.0L, 4.6L, 5.4L MAY EXHIBIT A MALFUNCTION INDICATOR LAMP ON WITH EVAP SYSTEM DIAGNOSTIC...

A DIRECT REPLACEMENT PART FOR THE EVAPORATIVE EMISSION CANISTER AND BRACKET ASSEMBLY.

SOME VEHICLES MAY EXHIBIT A NO START CONDITION WHEN PARKED ON AN INCLINE WITH THE VEHICLE IN A NOISE DOWN POSITION AND LESS THAN 1/4 TANK OF FUEL.

VEHICLES MAY EXPERIENCE A NO START CONDITION WHEN PARKED ON AN INCLINE WITH THE VEHICLE IN A NOSE DOWN POSITION AND LESS THAN 1/4 TANK OF FUEL.

A NO START CONDITION WHEN VEHICLE IS PARKED ON AN INCLINE WITH THE VEHICLE IN A NOSE DOWN POSITION AND LESS THAN 1/4 TANK OF FUEL MAY OCCUR.

SOME VEHICLES MAY EXHIBIT A NO START CONDITION WHEN PARKED ON AN INCLINE WITH THE VEHICLE IN A NOSE DOWN POSITION AND LESS THAN 1/4 TANK OF FUEL.

EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP.

FUEL PUMP REPLACEMENT PROCEDURE - SERVICE TIP.

EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM.

SERVICE TIPS ON COMPOSITE FUEL RAIL.

BRIEF INFORMATION ON PERFORMING THE FUEL ECONOMY TEST.

MALFUNCTION INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0442, P0455, P0456, P0457 OR P1442 OR A...

MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK...

CERTAIN VEHICLES WITH 4X4 OR ALL-WHEEL DRIVE MAY HAVE A FLUID LEAK FROM THE FRONT AXLE VENT TUBE.

OWNER NOTIFICATION PROGRAM SUPPLEMENT 7 REVISED INFORMATION - REGARDING REPLACEMENT OF WILDERNESS AT TIRES.

SUBJECT PERTAINING TO SUPPLEMENTAL TIRE INFLATION LABEL.

INFORMATION REGARDING PUMP ALIGNMENT TOOLS.

INFORMATION ON SETTING THE TIRE INFLATION PRESSURE FOR 1991 THROUGH 1999 MODEL YEAR VEHICLES IN THE PRE-DELIVERY PROCESS...

SOME ALL WHEEL DRIVE VEHICLES MAY EXPERIENCE A LOW SPEED WHINING NOISE FROM THE TRANSFER CASE.

INFORMATION ON 5R55E - 4R55E - 4R44E PUMP ALIGNMENT TOOLS.

INFORMATION ON MAINTAINING TIRE PRESSURE.

SOME VEHICLES MAY EXPERIENCE AXLE WIND UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING...

SUBJECT REGARDING REVOLUTIONS PER MILE TIRE SIZE DATA.

INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE.

SOME VEHICLES MAY EXHIBIT A DRIFT/PULL, SHOW SIGNS OF TIRE WEAR, OR EXHIBIT POOR RIDE QUALITY.

INFORMATION REGARDING MALFUNCTION INDICATOR LIGHT ILLUMINATING WITH DIAGNOSTIC TROUBLE CODE P0300/P0301.*YH

SOME 4.0L VEHICLES WITH A4WD BUILT PRIOR TO 9/13/99 MAY EXHIBIT A VIBRATION / PULSATION AT 0-45 MPH ON DRY PAVEMENT...

SOME VEHICLES MAY COME IN FOR A MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODE P0171 AND/OR P0174 IN SELF TEST.

REPEAT / REVISE MESSAGE REGARDING FLASHING 4X4 LIGHTS WITH NO DIAGNOSTIC TROUBLE CODES.

THIS BULLETIN STATES THAT WHENEVER THE CLEAN AIR TUBE RETAINING CLAMPS ARE REMOVED FOR ANY REPAIR, PROCEDURES MUST BE...

VEHICLES EQUIPPED THE NEUTRAL TOW FEATURE, BE AWARE THAT WHEN THE NEUTRAL TOW FEATURE IS ENABLED AND THE CUSTOMER PLACES...

VIBRATION ON LIGHT TO MODERATE ACCELERATION AT 0 - 45 MPH ON A4WD VEHICLES.

INFORMATION ON DIAGNOSING A VEHICLE WITH MALFUNCTION INDICATOR LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODES P0442 AND...

SOME 4.0L VEHICLES WITH A4WD MAY EXHIBIT A VIBRATION / PULSATION AT 0-45 MPH ON DRY PAVEMENT UNDER LIGHT TO MODERATE ACCELERATION.

SOME VEHICLES MAY EXHIBIT AN OVERDRIVE (O/D) LIGHT FLASHING WITH DIAGNOSTIC TROUBLE CODE (DTC) P0741 AND / OR P1740.

SOME VEHICLE MAY EXHIBIT MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS) PO171, PO174,...

DRIVEABILITY-MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED-DIAGNOSTIC TROUBLE CODES (DTC'S) P0420 AND/OR P0430.

CONCERNS WITH BRAKE VIBRATION, ROUGHNESS AND / OR GRINDING NOISE, AND EXCESSIVE BRAKE ROTOR CORROSION.

CONCERNS WITH HIGH BRAKE PEDAL FORCE TO STOP AFTER ROTOR MACHINING.

SOME VEHICLES MAY EXHIBIT AN INTERMITTENT HIGH FREQUENCY BRAKE SQUEAL NOISE.

THIS BULLETIN MENTIONS THAT FOR ALL VEHICLES WITH ANTILOCK BRAKE MODULE CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE...

INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT.

CONCERNS WITH ANTI-LOCK BRAKE SYSTEM (ABS) DIAGNOSTIC TROUBLE CODES AND / OR ABS LIGHT FLASHING WHILE DRIVING.

SOME VEHICLES EQUIPPED WITH TEVES FOUR WHEEL ANTI-LOCK BRAKES (4WABS) MAY EXHIBIT A YELLOW ANTI-LOCK BRAKE LAMP...

SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT.

INFORMATION ON REPLACING A FOUR WHEEL ANTI-LOCK BRAKES (4WABS) HYDRAULIC CONTROL UNIT (HUC).

AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT.

HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE.

EXPERIENCING A CLICKING / POPPING NOISE FROM THE UPPER STEERING COLUMN AREA WHEN TURNING THE STEERING WHEEL.

INFORMATION ON VEHICLES EXHIBITING STEERING WHEEL SHIMMY, VIBRATION OR GRUNT ON SLOW SPEED TURNS.

STEERING WHEEL SHIMMY, VIBRATION OR GRUNT ON SLOW SPEED TURNS.

REVISED MESSAGE REGARDING STEERING WHEEL SHIMMY, VIBRATION OR GRUNT ON SLOW SPEED TURNS ACTION ON SOHC EQUIPPED VEHICLES, PERFORM TSB 98-21-01.

SOME 4.0L VEHICLES WITH A4WD MAY EXHIBIT A VIBRATION / PULSATION FELT FROM THE DRIVELINE IN THE STEERING WHEEL AND...

SOME VEHICLES MAY EXHIBIT A POWER STEERING GRUNT / GROAN / NOISE WHILE TURNING.

EXHIBITING A GRUNTING NOISE HEARD FROM THE POWER STEERING SYSTEM DURING SLOW SPEED TURNING, OR WHILE STATIONARY WHEN...

SOME VEHICLES WITH A4WD MAY EXHIBIT A VIBRATION / PULSATION FELT FROM THE DRIVELINE IN THE STEERING WHEEL AND FLOORPAN...

EXHIBITING A POWER STEERING NOISE.

STEERING WHEEL SHIMMIES, VIBRATION OR GRUNT ON SLOW SPEED TURNS..

CONCERNS WITH POWER STEERING MAKING A GRUNTING / GROANING NOISE WHILE TURNING.

SERVICE ACTION BULLETIN REGARDING ON-BOARD DIAGNOSTIC SYSTEM UPGRADE.

SERVICE TIPS WHEN SERVICING A 4.0L SOHC SHORT BLOCK ASSEMBLY.

SERVICE TIP INFORMATION WHEN SERVICING THE 4.0L SOHC SHORT BLOCK ASSEMBLY.

SERVICE TIPS INFORMATION PROVIDED TO ASSIST WHEN SERVICING VEHICLES WITH SHORT BLOCK ASSEMBLY.

RECALL INFORMATION REGARDING SPEED CONTROL CABLE REPLACEMENT.

SUBJECT REGARDING PASSIVE ANTI THEFT SYSTEM (PATS) DIAGNOSTIC SERVICE TIPS.

DIAGNOSTIC SERVICE TIPS ON PASSIVE ANTI THEFT SYSTEM ( PATS ).

REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS.

SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS.

INFORMATION REGARDING MANUAL A/C SYSTEM- BLOWER WORKS IN HIGH SETTING ONLY.

SUBJECT ON MANUAL A/C SYSTEM-BLOWER WORKS IN HIGH SETTING ONLY.

INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS.

CLIMATE CONTROL A/C SERVICE TECH TIPS.

SOME VEHICLES EQUIPPED WITH A DUAL MEDIA (AM / FM CASS / CD) RADIO MAY EXHIBIT AN AUDIO CONCERN OF NO DISPLAY OR GRAPHICS.

SOME VEHICLES EQUIPPED WITH A DUAL MEDIA (AM/FM/CASS/CD) RADIO MAY EXHIBIT AN AUDIO CONCERN OF NO DISPLAY OR GRAPHICS.

CONCERNS WITH THE IN-DASH CD STOPS OPERATING WHEN HOT / RADIO DISPLAY READS CD TOO HOT.

INFORMATION REGARDING THE AUDIO SYSTEM SELECTIVE LIGHTING FEATURE.

EXHIBITING AN AIR BAG LAMP ON INTERMITTENTLY WITH LAMP FAULT CODE (LFC) 24, OR DIAGNOSTIC TROUBLE CODE B1924 AND / OR B1342 STORED IN MEMORY.

SOME VEHICLES MAY EXHIBIT AN AIR BAG LIGHT ON INTERMITTENTLY WITH DIAGNOSTIC TROUBLE CODE B1924.

VEHICLES EXHIBITING INTERMITTENT ILLUMINATION OF AIR BAG LIGHT WITH DIAGNOSTIC TROUBLE CODE B1924.

EXHIBITING A SQUEAK TYPE NOISE FROM THE REAR STABILIZER BAR WHILE DRIVING, ESPECIALLY WHEN GOING OVER BUMPS.

VARIOUS NOISE ISSUES FROM THE REAR LEAF SPRINGS WHILE DRIVING.

SERVICE ACTION 00E11, SUPPLEMENT #1 - UPDATE INFORMATION REGARDING ON-BOARD DIAGNOSTIC SYSTEM UPGRADE.