2005 Mercury Monterey TSBs
41 Technical Service Bulletins across 12 categories
Categories
Other
9 bulletinsADVANCED TRACTION CONTROL SYSTEM - SHORT DURATION ACTIVATION.
Read full bulletin
*KB
ADVANCED TRACTION CONTROL SYSTEM - DURATION ACTIVATION.
Read full bulletin
*KB
A BROKEN OUTER C/V JOINT ON VEHICLES BUILT BEFORE 5/1/2005.
Read full bulletin
*TT
INSTRUMENT CLUSTER DTC U1262 AND OR U1135.
Read full bulletin
*EH
INSTRUMENT CLUSTER DTC U1130.
Read full bulletin
*EH
WELD BONDING PROCEDURE.
Read full bulletin
*TT
SAFETY BELT RETRACTION SPEED.
Read full bulletin
*TT
3RD ROW SEAT STRAP BREAKING.
Read full bulletin
*EH
3RD ROW SEAT STRAP BREAKING (STRAP USED FOR STOWING OR ACCESSING THE REAR SEAT).
Read full bulletin
*TT
Electrical
7 bulletinsThe Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs).
Read full bulletin
The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate when reading these PIDs and cannot display quickly enough to validate a concern. The PCM automatically monitors these inputs more accurately and will set diagnostic trouble codes (DTCs) when appropriate. Using these PIDs for diagnostics will lead to inaccurate results and improper ETB replacements. If a concern is intermittent and no DTCs are present, refer to historical DTCs and the PC/ED, Section 3 No DTCs Present Index chart for further information.
RESTRAINT CONTROL MODULE DIAGNOSTIC TROUBLE CODE B2296 - SERVICE TIP.
Read full bulletin
*TT
SERVICE WIRING HARNESS REPLACEMENT GUIDELINES - SERVICE TIPS.
Read full bulletin
*TT
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES.
Read full bulletin
*TT
GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES.
Read full bulletin
*TT
MAF DIAGNOSTIC SERVICE TIP - VEHICLES EQUIPPED WITH EGR SYSTEM MODULE (ESM).
Read full bulletin
*TT
BEEPING SOUND FROM THE INSTRUMENT PANEL WHEN DRIVING AT/OVER 75 MPH, TRACTION CONTROL OFF INDICATOR ILLUMINATE WHEN...
Read full bulletin
VEHICLE IS NOT EQUIPPED WITH TRACTION CONTROL, AND/OR DIAGNOSTIC TROUBLE CODE B2477 (MODULE CONFIGURATION FAILURE) STORED IN THE INSTRUMENT CLUSTER MODULE (ICM). *TT THIS INFORMATION DATED 10/01/2003 HAS BEEN UPDATED TO INCLUDE 2005 MONTEREY. *TT
Body & Paint
5 bulletinsSLIDING DOOR(S) CONTACTING THE REAR QUARTER GLASS.
Read full bulletin
*TT THIS INFORMATION UPDATES PREVIOUS INFORMATION, DATED 03/01/2002. *TT
Safety recall 13S01 - Corrosion on sheet metal that supports 3rd row seat latch strikeers - requests for recall service...
Read full bulletin
action
FORD/MERCURY: SAFETY RECALL REGARDING SHEET METAL SUPPORT FOR FOLDING 3RD ROW SEAT LATCH STRIKERS CAN EXPERIENCE...
Read full bulletin
CORROSION AND WILL COMPROMISE MOUNTING POINT CAUSING SEAT TO MOVE. MODEL 2004-07 FREESTAR, MONTEREY. *PE
FORD/MERCURY: SHEET METAL SUPPORTING FOLDING 3RD ROW SEAT LATCH STRIKERS WILL EXPERIENCE CORROSION AND COMPROMISE...
Read full bulletin
MOUNTING POINT FOR FORWARD PORTION OF 3RD ROW SEAT, IF VEHICLE IS OPERATED IN HIGH CORROSION AREAS FOR EXTENDED PERIOD. MODEL 2004-2007 FREESTAR, MONTEREY. *PE
POWER SLIDING DOORS AND POWER LIFTGATE INOPERATIVE WHEN USING THE OVERHEAD CONSOLE AND/OR REMOTE KEYLESS ENTRY...
Read full bulletin
TRANSMITTER OPEN/CLOSE BUTTONS - DIAGNOSTIC TROUBLE CODE (DTC) C1999. *TT
Brakes
5 bulletinsABS LIGHT ON AND DTCS C1175/C1236, C1165/C1235 - REAR WHEEL SPEED SENSOR.
Read full bulletin
*TT
TRACTION CONTROL LAMP - ABS LAMP - ABS SELF ACTIVATION WITH DTC C1288.
Read full bulletin
*TT UPDATED 11/8/07. *NJ
REAR BRAKE LINING ACCELERATED WEAR.
Read full bulletin
*TT
TRACTION CONTROL ABS AND PARK BRAKE LAMP.
Read full bulletin
FLICKER FLASH ILLUMINATE. *EH
ACCELERATED REAR BRAKE WEAR.
Read full bulletin
OASIS. *TT
Transmission
4 bulletinsERRATIC FLUID LEVEL READING ON TRANSAXLE DIPSTICK-LEAKS-4F50N, AX4N, AX4S TRANSAXLE.
Read full bulletin
*SC
DTCS P0760 AND P0763-4F50N TRANSAXLE-VEHICLES BUILT BEFORE 3/15/2005.
Read full bulletin
THIS MAY BE DUE TO A SHORTED TRANSAXLE INTERNAL HARNESS, CAUSED BY A SHARP EDGE ON THE INSIDE OF THE SIDE COVER CASTING. *SC
4F50N TRANSAXLE NO 1-2 UPSHIFT AND DIAGNOSITC TROUBLE CODE P0732.
Read full bulletin
*TT
GROAN/BUZZ/VIBRATION WHEN THE GEAR SELECTOR IS IN PARK WITH THE VEHICLE PARKED ON AN INCLINE.
Read full bulletin
*TT THIS BULLETIN UPDATES PREVIOUS BULLETIN 17358, DATED 11/01/2003 TO INCLUDE 2005 MODELS. *TT
Steering
3 bulletinsPOWER STEERING HOSE LEAK NEAR COOLER EXTREME COLD CLIMATE AREAS ONLY -4 DEGREES AND COOLER.
Read full bulletin
*KB
STEERING WHEEL. *EH
ACCESS DOOR WRAPED OR BREAKING OFF FROM THE UNDERSIDE OF THE STEERING WHEEL SHROD.
Read full bulletin
*EH
Fuel System
3 bulletinsREAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR.
Read full bulletin
*TT
REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR.
Read full bulletin
*TT
INOPERATIVE ELECTRIC REAR WINDOW DEFROSTER (HEATED BACKLITE) GRID LINES, INTEGRAL ANTENNA CONCERNS.
Read full bulletin
*TT
Air Bags & Safety
1 bulletinFor 2004-2007 Freestar or Monterey vehicles Safety Recall 13S01 has been issued for vehicles that are operated in high...
Read full bulletin
corrosion areas for an extended period, where the sheet metal that supports the folding 3rd row seat latch strikers could experience corrosion and may compromise the mounting point for the forward portion of the 3rd row seat. Initially, this condition may result in seat movement when passengers sit on or put weight on the seat, or difficulty latching the front of the seat when in its seating position. If corrosion is severe, the seat latch strikers may become detached from the vehicle. The seat belts and the permanent mounting attachment at the rear of the seat are unaffected.
HVAC & Climate
1 bulletinREAR CLIMATE CONTROL NOISES - SERVICE TIP.
Read full bulletin
*TT
Infotainment
1 bulletinINABILITY TO PLAY HOME MADE CD ON SINGLE CD AUDIO SYSTEM WITHOUT MP3 CAPABILITY.
Read full bulletin
*EH
Pre-Delivery & Maintenance
1 bulletinSAFETY BELT WEB STOP BUTTON SERVICE.
Read full bulletin
*EH
Engine
1 bulletinFRONT BLOWER MOTOR WHISTLE NOISE.
Read full bulletin
*TT