2006 Mercury Montego TSBs
23 Technical Service Bulletins across 11 categories
Categories
Electrical
4 bulletinsThe Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs).
Read full bulletin
The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate when reading these PIDs and cannot display quickly enough to validate a concern. The PCM automatically monitors these inputs more accurately and will set diagnostic trouble codes (DTCs) when appropriate. Using these PIDs for diagnostics will lead to inaccurate results and improper ETB replacements. If a concern is intermittent and no DTCs are present, refer to historical DTCs and the PC/ED, Section 3 No DTCs Present Index chart for further information.
TRACTION CONTROL LAMP ON--NO DTC'S PRESENT, OR DTC P1889 IN DIFFERENTIAL ELECTRONIC MODULE (DEM).
Read full bulletin
*NJ
MIL ON WITH DTC P0191 - FUEL RAIL PRESSURE SENSOR CIRCUIT PERFORMANCE.
Read full bulletin
*KB
BATTERY LIGHT ILLUMINATED.
Read full bulletin
*KB
Transmission
4 bulletinsTRANSMISSION HARSH SHIFTING - NO DTC'S - MILEAGE OVER 20,000 MILES.
Read full bulletin
*KB
TRANSMISSION SHIFTER BINDING / HIGH EFFORT BEZEL REPLACEMENT.
Read full bulletin
*KB
CONTINUOUSLY VARIABLE TRANSAXLE (CVT) NOISE DIAGNOSIS.
Read full bulletin
*TT
HARSH/ERRATIC/SLOW DOWNSHIFTS OR TIP-IN HESITATION -- 6 SPEED AUTOMATIC TRANSAXLE -- VEHICLES BUILT BEFORE 10/17/2005.
Read full bulletin
*TT
Engine
3 bulletinsFORD: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER.
Read full bulletin
MOMENTARY ENGINE IDLE RPM SURGE MAY BE INTERMITTENT AND MAY OCCUR, DUE TO DEPOSITS BUILDUP IN THROTTLE BODY, AT LOW SPEEDS, WHILE PARKING OR ENTERING DRIVEWAY AND CHECK ENGINE LAMP MAY ILLUMINATE. MODELS 2005-07 FREESTYLE, 500, MONTEGO. *PE
WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING.
Read full bulletin
*TT
ENGINE RPM FLUCTUATION AT HIGHWAY CRUISING SPEEDS - VEHICLES BUILT PRIOR TO 8/2/2005.
Read full bulletin
*TT
Brakes
2 bulletinsFORD\MERCURY SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER.
Read full bulletin
CERTAIN 2005 THROUGH 2007 FWD AND AWD FORD FIVE HUNDRED, FREESTYLE AND MERCURY MONTEGO VEHICLES - REAR BRAKE WEAR. ALSO HAVE AN OWNER'S LETTER. *NJ UPDATED 1/25/08. *NJ
REAR BRAKE DRAG, NOISE, DUST, AND/OR PREMATURE PAD WEAR.
Read full bulletin
*KB
Lighting
2 bulletinsINTERMITTENT INSTRUMENT CLUSTER OPERATION - INCLUDING GAUGES SWEEP/RESET - MULTIPLE WARNING LIGHTS ILLUMINATED AND/OR REVERSE LIGHTS STAY ON.
Read full bulletin
THIS APPLIES TO VEHICLES BUILT BEFORE 02-17-06. *KB
INTERMITTENT INSTRUMENT CLUSTER GAUGE SWEEP/RESET - MULTIPLE WARNING LIGHTS ON - REVERSE LIGHTS ON - VEHICLES BUILT BEFORE 2/17/2006.
Read full bulletin
*TT
Body & Paint
2 bulletinsINTERMITTENT BOUNCE-BACK OF THE DRIVER'S WINDOW DURING ONE TOUCH UP OPERATION.
Read full bulletin
*TT
NOISE IN RIGHT FRONT OF PASSENGER COMPARTMENT - AIR INLET DOOR ACTUATOR INOPERATIVE (RECIRCULATION).
Read full bulletin
*TT
Suspension
2 bulletinsGRUNT OR SQUEAK FROM FRONT SUSPENSION DURING FULL LOCK TURNS - SERVICE TIP.
Read full bulletin
*TT
NOISE FROM REAR SUSPENSION - COLD ONLY.
Read full bulletin
*TT
Other
1 bulletinMIL WITH DTC P0106 AND/OR P0109.
Read full bulletin
*KB
Fuel System
1 bulletinFUEL GAUGE ERRATIC/INACCURATE AND/OR MIL ON WITH DTC P0463, B1202, B2627, B2879, AND/OR P2068.
Read full bulletin
*KB
Air Bags & Safety
1 bulletinAIR BAG LIGHT ON WITH DTC B2290 - DIFFICULT TO DUPLICATE.
Read full bulletin
*KB
Infotainment
1 bulletinTENTHS DIGIT NOT DISPLAYED ON ODOMETER AFTER 10,000 MILES/KILOMETERS.
Read full bulletin
*TT