2007 Mercury Mariner TSBs
15 Technical Service Bulletins across 7 categories
Engine
4 bulletinsFORD: THERE IS EXCESSIVE ENGINE OR EXHAUST NOISE, OR AN EXHAUST ODOR DUE TO AN EXHAUST LEAK.
Read full bulletin
THERE WILL BE NO WARNING CODES OR LIGHTS. 2007-2008 ESCAPE/MARINER. *RM
ENGINE STALLING ON ENGAGEMENT/STOPPING.
Read full bulletin
*KB
POSSIBLE ENGINE DAMAGE - INSTALL SPECIAL SERVICE TOOLS PRIOR TO REMOVING CRANKSHAFT PULLEY BOLT.
Read full bulletin
*KB
DRIVEABILITY CONCERNS AND/OR DTCP0340 - INSPECT CRANKSHAFT PULLEY.
Read full bulletin
*KB
Electrical
3 bulletinsThe Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs).
Read full bulletin
The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate when reading these PIDs and cannot display quickly enough to validate a concern. The PCM automatically monitors these inputs more accurately and will set diagnostic trouble codes (DTCs) when appropriate. Using these PIDs for diagnostics will lead to inaccurate results and improper ETB replacements. If a concern is intermittent and no DTCs are present, refer to historical DTCs and the PC/ED, Section 3 No DTCs Present Index chart for further information.
2005-08 ESCAPE/ESCAPE HYBRID/MARINER - 2006-08 MARINER HYBRID - WHEEL SPEED SENSOR RING REPLACEMENT PROCEDURE UPDATE TO WORKSHOP MANUAL.
Read full bulletin
*NJ
SERVICE HARNESS INSTALLATION - CORROSION OF A RESISTOR IN THE BATTERY POWER UNIT.
Read full bulletin
ALSO HAVE AN OWNER'S LETTER. *NJ
Fuel System
3 bulletinsSLOW FUEL FILL AND/OR DTC P0451.
Read full bulletin
*NJ
COLD CLIMATE SLOW FUEL FILL.
Read full bulletin
*NJ
SLOW FUEL FILL DUE TO CLOGGED VENT.
Read full bulletin
*KB
Brakes
2 bulletinsMULTIPLE VEHICLE LINES - INTERMITTENT PCM, FUEL PUMP, IGN.
Read full bulletin
COIL, A/C, ABS OR FOG LAMP OPERATION. *NJ
MULTIPLE VEHICLE LINES - INTERMITTENT PCM, FUEL PUMP, IGN, COIL, A/C, ABS OR FOG LAMP OPERATION.
Read full bulletin
*NJ
Pre-Delivery & Maintenance
1 bulletinFORD/MERCURY: NEW SERVICE KIT AVAILABLE FOR ACCELERATOR CABLE TO PEDAL CONNECTION.
Read full bulletin
SOME VEHICLES MAY REQUIRE THE ACCELERATOR CABLE TO ACCELERATOR PEDAL CONNECTION REPAIRED. A NEW SERVICE CLIP HAS BEEN RELEASED FOR USE, IN LIEU OF REPLACING THE CABLE AND/OR PEDAL ASSEMBLIES. *PE
Lighting
1 bulletinMALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODE (DTC) U2062 (HYBRID ONLY).
Read full bulletin
*NJ
Hybrid & EV
1 bulletin2005-2008 ESCAPE HYBRID AND 2006-2008 MARINER HYBRID VEHICLES ARE NOT E-85 COMPATIBLE.
Read full bulletin
*NJ