2003 Mercury Grand Marquis TSBs

SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT...

WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING.

IDLE VIBRATION VEHICLES EQUIPPED WITH SINGLE EXHAUST.

ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS.

ENGINE VIBRATION AT IDLE ON VEHICLES EQUIPPED WITH SINGLE EXHAUST.

COOLING SYSTEM-MOTORCRAFT PREMIUM GOLD ENGINE COOLANT-SERIVCE TIPS.

SERVICE CYLINDER HEAD GASKET FOR 4.6L APPLICATIONS.

FUEL PRESSURE RELIEF VALVE (SCHRADER VALVE) DISCONTINUED.

ENGINE-ROMEO BUILT 4.6L 2V-TICK NOISE FROM ENGINE-ENGINES BUILT BEFORE 9/17/2003.

ENGINE KNOCK DURING INITIAL COLD START, THE KNOCK WILL CEASE AFTER THE ENGINE IS FULLY WARMED UP.

ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED...

GRINDING TYPE NOISE FROM THE TIMING CHAIN AREA.

SOME VEHICLES, EQUIPPED WITH THE 4.6L 2V ENGINE, WITH AN ENGINE BUILD DATE PRIOR TO 8/29/03 MAY EXHIBIT AN ENGINE TICK...

SOME RETAIL CUSTOMERS MAY PERCEIVE THE OPERATION OF THE DASH LIGHT DIMMING FEATURE AS BEING FAULTY.

ON SOME VEHICLES THE HEADLAMPS REMAIN ILLUMINATED WHEN WIPERS ARE ACTIVATED AND THEN DEACTIVATED.

MALFUNCTION INDICATOR LAMPAND P0460 DTC IN MEMORY.

MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS.

MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODE (DTC) P0460 IN CONTINUOUS MEMORY.

MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODE (DTC) P0442 OR P0456.

INTERMITTENT RAPID FLASHING OF THE TURN SIGNALS.

MALFUNCTION INDICATOR LAMP (MIL) LIGHT ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P1405 OR P1406 WITH NO OTHER DTCS.

HESITATION, BUCK OR SURGE DURING STEADY STATE DRIVING OR LIGHT ACCELERATION AT 30-60 MPH.

MALFUNCTION INDICATOR LAMP ON WITH DIAGNOSTIC TROUBLE CODE P0316 (ONLY) STORED IN MEMORY.

MOISTURE IN THE HEADLAMPS.

ERRATIC HEADLAMP OPERATION IN AUTOLAMP MODE.

OVERSPEED WARNING CHIME ACTIVATION WHEN TRAVELLING ABOVE 70 M PH / 110 KPH.

SUMMARY TO BE PROVIDED ON A FUTURE DATE.

SAFETY BELT RETRACTION SPEED.

LIMITED SLIP AXLE CHATTER, SHUDDER, BINDING SENSATION, OR VIBRATION DURING LOW SPEED TURNING MANEUVERS.

AM FM AND CELLULAR PHONE RECEPTION INTERFERENCE .

DIAGNOSTIC TROUBLE CODE (DTC) P0442.

A NO CRANK/NO START. CONNECTOR C192 OR C146 NOT FULLY CONNECTED.

DIAGNOSTIC TROUBLE CODE (DTC) P1233 WITH POSSILE DRIVEABILITY OR NO START CONDITION.

INTERMITTENT HORN SELF-ACTIVATION.

INTERMITTENT HORN SELF-ACTIVATION.

REAR AXLE SHAFT AND/OR AXLE BEARING PREMATURE WEAR.

REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR.

REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR.

EMISSION RELATED SERVICE ACTION 04E12.

INOPERATIVE ELECTRIC REAR WINDOW DEFROSTER (HEATED BACKLITE) GRID LINES, INTEGRAL ANTENNA CONCERNS.

MALFUNCTION INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0442, P0455, P0456, P0457 OR P1442 OR A...

MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK...

FUEL GAUGE READING THAT FLUCTUATES OR READS LOWER THAN THE ACTUAL FUEL TANK LEVEL.

FUEL GAUGE THAT COMES OFF FULL TOO QUICKLY OR READS LOWER THAN THE ACTUAL FUEL TANK LEVEL (ELECTRONIC OR ANALOG CLUSTER).

NEW PUSH TYPE FUEL CLIP AND CONNECTOR REMOVAL INSTRUCTIONS.

A SERVICE PROCEDURE FOR POOR ADHESION OF THE DOOR TRIM PANEL CARPET INSERTS ON CERTAIN VEHICLES INCLUDING THE 2003 MARAUDER.

SOME VEHICLES INCLUDING THE 2003 MARAUDER BUILT FROM JOB1 THROUGH JUNE 11, 2002 MAY HAVE POOR ADHESION OF THE DOOR TRIM...

Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns...

Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns...

UNCOMMANDED WINDSHIELD WIPER OPERATION.

ALUMINUM CORROSION - SERVICE TIP.

BODY-COLLISION REPAIR UPDATES.

SLOW OR BINDING SIDE DOOR GLASS OPERATION.

FORD: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER.

FORD: THE LIGHTING CONTROL MODULE HAS EXTENDED WARRANTY COVERAGE, ON CERTAIN VEHICLES, DUE TO A POSSIBLE CRACK ON...

GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES.

GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES.

MAF DIAGNOSTIC SERVICE TIP - VEHICLES EQUIPPED WITH EGR SYSTEM MODULE (ESM).

BATTERY LAMP ON WITH DIAGNOSTIC TROUBLE CODE (DTC) P1246 UNDER INVESTIGATION (QSF).

BATTERY WARNING LAMP ON WITH A DIAGNOSTIC TROUBLE CODE P1246 (GENERATOR LOAD INPUT FAILED) IN THE POWERTRAIN CONTROL MODULE (PCM).

MALFUNCTION INDICATOR LAMP (MIL) WITH DIAGNOSTIC TROUBLE CODES (DTC'S) P0113 (INTAKE AIR TEMPERATURE SENSOR 1 CIRCUIT...

SQUEAK OR RUBBING NOISE FROM FRONT SUSPENSION - FRONT SPRING INSULATOR REVISED.

REAR AIR SUSPENSION HEIGHT ADJUSTMENT / SERVICE TIPS.

COSMETIC CRACKING OF LOWER CONTROL ARM BUSHING SLEEVE.

HARSH RIDE/SUSPENSION SITS LOW IN FRONT.

VEHICLES EQUIPPED WITH STEEL WHEELS BUILT BETWEEN APRIL 25, 2003 THOUGH MAY 11, 2003 MAY EXHIBIT HARSH RIDE CHARACTERISTICS DUE TO THE FRONT SPRINGS.

POWER STEERING PUMP NOISE THAT MAY DIFFER DEPENDING UPON BODY STYLE.

STEERING NIBBLE - SERVICE TIP.

PASSIVE ANTI-THEFT SYSTEM (PATS) DO NOT COME WITH A STEERING WHEEL LOCK.

EXCESSIVE POWER STEERING PUMP NOISE AT COLD START.

POWER STEERING LOWER ASSIST AT LOW SPEEDS / STEERING LIGHT FEEL AT HIGHER SPEEDS.

SOME VEHICLES EQUIPPED WITH A PASSIVE ANTI-THEFT SYSTEM (PATS) MAY EXHIBIT STEERING WHEEL LOCK AND TRANSMISSION SHIFT...

LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK.

TRANSMISSION FAILURE WHERE THERE IS A LARGE AMOUNT OF METAL OR DEBRIS IN THE PAN.

NEW SERVICE PART - NUMBER 5 NEEDLE BEARING AND RACE KIT - 4R70W TRANSMISSION - SERVICE TIP.

SUBJECT REGARDING REAR PARK BRAKE CLICKING NOISE.

NUMEROUS ANTI-LOCK BRAKE SYSTEM (ABS) WHEEL SPEED SENSOR (WSS) DTCS, SUCH AS C1145, C1155, C1165, C1175, C1296, C1297, C1298, C1299 AND C1222.

NUMEROUS ANTI-LOCK BRAKE SYSTEM (ABS) WHEEL SPEED SENSOR (WSS) DIAGNOSTIC TROUBLE CODES (DTCS).

BRAKE BOOSTER PUSH ROD ADJUSTMENT.

HIGH SIDE PRESSURE FLUCTUATIONS ON VEHICLES EQUIPPED WITH A FIXED SCROLL A/C COMPRESSOR.

CLIMATE CONTROL A/C SERVICE TECH TIPS.

NOISE-CLIMATE CONTROL-REGISTER VENT RATTLE WITH A/C BLOWER ON.

LACK OF AIR CONDITIONER (A/C) COOLING AND RESTRICTED/REDUCED AIR FLOW THROUGH THE A/C VENTS TYPICALLY DURING EXTENDED IDLING CONDITIONS.

AM/FM AND CELLULAR PHONE RECEPTION INTERFERENCE - SERVICE TIP.

REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS.

SPEED CONTROL DEACTIVATION SWITCH ADJUSTMENT SERVICE PROCEDURE.

SOME VEHICLES MAY EXHIBIT A CLICK OR RATTLE NOISE COMING FROM THE FRONT WHEEL AREA.

RADIATOR ALIGNMENT PIN GROUND CLEARANCE.

SUBJECT REGARDING SEAT BELT BELTMINDER DEACTIVATING / ACTIVATING CLARIFICATION.

FLICKERING ELECTRONIC INSTRUMENT CLUSTER DISPLAY, ELECTRONIC AUTOMATIC TEMPERATURE CONTROL DISPLAY, RADIO DISPLAY, AND/OR OVERHEAD CONSOLE DISPLAY.