2005 Mercedes-Benz SL Class TSBs
15 Technical Service Bulletins across 7 categories
Brakes
5 bulletinsMERCEDES: CRACKING NOISE FROM THE AREA OF THE INSTRUMENT PANEL/FIREWALL WHEN CORNERING, DURING THROTTLE LIFT OFF AND ON UNEVEN ROADS.
Read full bulletin
STRESS AT THE SPOT WELDS ON THE FIREWALL TO THE RIGHT OF THE BRAKE BOOSTER CAN RESULT IN CRACKING NOISES. NO RIGHT HAND DRIVE. NO MODEL YEARS LISTED. *PE
MERCEDES: PARKTRONIC INTERMITTENTLY NOT FUNCTIONING.
Read full bulletin
THE FUNCTION WORKS AGAIN AFTER A SHORT TIME OR DISTANCE. WHEN THE FOOT OPERATED PARKING BRAKE IS APPLIED, THE PARKTRONIC SYSTEM IS DEACTIVATED. IF THE FOOT OPERATED PARKING BRAKE IS ON AT THE FIRST NOTCH, THE CONTACT SWITCH MAY REACT WITH A CONSIDERATION DELAY WHEN THE PARKING BRAKE IS RELEASED. NO MODEL YEARS LISTED. *PE
MERCEDES: CORROSION PROTECTION COATINGS FOR BRAKE COMPONENTS AND HARDWARE MAY BE DAMAGED AND OR STRIPPED AWAY IF HIGHLY...
Read full bulletin
CONCENTRATED ACID BASED CLEANERS ARE USED. ONCE THE CORROSION PROTECTION IS DAMAGED OR REMOVED THE BRAKE COMPONENTS AND OR HARDWARE CAN BEGIN TO CORRODE. INCLUDE ALL MODELS AND MODEL YEARS. *PE
STEERING WHEEL TWITCH DURING BRAKE APPLICATION.
Read full bulletin
VARIOUS MODELS INCLUDING MERCEDES BENZ 2006 MODEL 230. *TT
INSPECT SBC SUCTION HOSE, REPLACE IF NECESSARY, TO IMPROVE THE BRAKE BLEEDING PROCESS.
Read full bulletin
*TT
Electrical
3 bulletinsA POTENTIAL MALFUNCTION WHICH COULD RENDER THE SECONDARY AIR INJECTION PUMP RELAY INOPERABLE THEREBY AFFECTING THE...
Read full bulletin
PROPER OPERATION OF THE SECONDARY AIR INJECTION PUMP. *TT
LEARNING IN SELECTION RANGE SENSOR NOT POSSIBLE AFTER EHS REPLACEMENT.
Read full bulletin
*TT
THE ALTERNATOR REGULATOR MAY FAIL TO PREVENT VOLTAGE VALUES RANGING BEYOND THE SPECIFIED TOLERANCE LIMITS.
Read full bulletin
*TT
Transmission
2 bulletinsINSPECT TRANSMISSION PILOT BUSHING AT ELECTROCHYDRAULIC UNIT AND REPLACE IF NECESSARY.
Read full bulletin
THE TRANSMISSION PILOT BUSHING MAY HAVE BEEN INSTALLED ON THE CONTROL UNITS WITH NON-TEMPERED SEALING RINGS WHICH MAY CAUSE A SMALL LEAK TO OCCUR. *TT UPDATED 04-11-07. *KB
ROUGH DOWNSHIFTING WHEN ACCELERATING.
Read full bulletin
*TT VARIOUS MODELS INCLUDING 2005 MERCEDES-BENZ 219 AND 220. *TT
Infotainment
2 bulletinsCOMAND HEAD UNIT DISC DRIVE MALFUNCTIONS AT LOW TEMPERATURES.
Read full bulletin
VARIOUS MODELS INCLUDING MERCEDES-BENZ MODEL 215, AND 220 2004 AND 2005. *TT
COMAND HEAD UNIT SOFTWARE UPDATE.
Read full bulletin
MERCEDES-BENZ. VARIOUS MY2005 MODELS INCLUDING MODEL 220. *TT
Pre-Delivery & Maintenance
1 bulletinMERCEDES: THE LIMITED WARRANTY ON THE SBC HYDRAULIC UNIT FOR MODELS 211, MODEL 219 AND MODELS 230 WAS EXTENDED FROM THE...
Read full bulletin
ORIGINAL 4 YEARS/50,000 MILES TO 10 YEARS WITH NO MILEAGE LIMITATION. THE SBC HYDRAULIC UNIT EXTENDED LIMITED WARRANTY APPLIES TO ALL CONDITIONS THAT JUSTIFY THE REPLACEMENT OF THE SBC HYDRAULIC UNIT UNDER THE STANDARD WARRANTY TERMS AND CONDITIONS. *PE
Lighting
1 bulletinMERCEDES VEHICLES: THE XENON OR BI-XENON HEADLAMP NOT FUNCTIONING.
Read full bulletin
A FUNCTION DESCRIPTION CAN BE FOUND IN WIS DOCUMENT GF8S.10-P-20010 (203), GF82.10-P-0003Q (209); GF82.10-P-3002R (230). MODEL YEARS UKNOWN. *PE
Other
1 bulletinTHUMPING/RUMBLING NOISE FROM FRONT OF VEHICLE.
Read full bulletin
MERCEDES-BENZ MODEL 230. MODEL YEAR 2003-2005. *TT