2013 Mack Pinnacle (cxu) TSBs

CBR: Telematics Gateway ( TGW, MID 142 ) Losing Communication With The Instrument Cluster ( IC ) - Counts Of Fault Code...

Barksdale Leveling Valve, Leak Test

Mack Chassis - Fault Code List / Engine Control Module (ECM), Aftertreatment Control Module (ACM), Electrical System...

Programming Failure - Chassis With Cummins Engine And An Allison Transmission

US10 Emission Engines - Diagnostic Trouble Code ( DTC ) SPN 1231 FMI 9 Troubleshooting.

Vehicles Equipped With An Automated Manual Transmission Model D or F ( AMT-D, AMT-F ) - Transmission Oil Leakage From...

Emcon (Spark Assist) Engine Aftertreatment System Troubleshooting Check Sheet - US07 Emissions

Low Oil Pressure Diagnostic Process For 11 Liter Engines

Manual Compression Test Adapter For Engines With Stainless Steel Injector Sleeves (Conical Tip Injectors) - US07 And...

Mack Low Oil Pressure Diagnostic Process For 11 Liter Engines

Mack Chassis - Diagnostic Trouble Codes ( DTC's ) - P020113, P020213, P020313, P020413, P020513, P020613, Cylinders 1...

Mack Chassis - Equipped With An Automated Manual Transmission Model D or F (mDrive, AMT-D, AMT-F) - Transmission Oil...

Engine Oil Analysis Specifications - US10 And Newer Emissions

Automated Manual Transmission( AMT ) ( I-Shift, mDRIVE ) Equipped Chassis, OBD13 And Newer - Light Turbo Surge ( Chuff )...

Automated Manual Transmission( AMT ) ( I-Shift, mDRIVE ) Equipped Chassis, OBD13 And Newer - Light Turbo Surge ( Chuff )...

Diagnostic Trouble Codes (DTC) For The Engine Pre-Heat Relay: Supplementary Instructions

Mack Chassis - Pinnacle (CHU,CXU,PI), Anthem (AN), Granite (GU,GR) With Mack Engine ONLY - Power Take Off ( PTO ) Engine...

Diagnostic Trouble Code ( DTC ) P471 Illuminating The Malfunction Indicator Lamp (MIL) - US17+OBD16, US17+OBD18 (GHG17,...

Fuel Injector Offset Learning Diagnostic Trouble Codes ( DTC ) / Fault Codes Logged In Engine Control Module ( EMS );...

MACK TRUCK: SHOULD REPROGRAMMED ENGINE ECU AND AFTERTREATMENT CONTROL MODULE (ACM) DUE TO PREMIUM TECH TOOL EXPERIENCE...

MACK: WHEN SUSPENSION, ON SOME TRUCKS, IS LEFT DUMPED, THERE ARE NO WARNING LIGHT, BUZZER OR ROAD SPEED LIMIT, DUE TO...

MACK: WHEN SUSPENSION IS LEFT DUMPED, NO WARNING LIGHT, ROAD SPEED LIMIT OR BUZZER DUE TO SOFTWARE IN VEHICLE...

MACK TRUCK: DUE TO OIL CONTAMINATION INTO ENGINE WIRE HARNESS, MAIN OIL GALLERY PRESSURE SENSOR OR PISTON COOLING JET...

MACK TRUCKS: THE HDMS COOL LOGIC ENGINE COOLING FAN DRIVE IS LEAKING FLUID FROM REAR DRIVE AND HDMS FAN DRIVE WAS...

MACK TRUCKS: INFORMATION AVAILABLE REGARDING THE ENHANCEMENTS FOR ENGINE CONTROL MODULE (ECM) SOFTWARE UPDATES TO...

MACK: UNDER CERTAIN CONDITIONS, HIGHER THAN EXPECTED TURBOCHARGER WHEEL SPEED, UNEVEN ENGINE SPEED, LOW T2...

MACK TRUCKS: UNDER CERTAIN CONDITIONS, SOME TRUCKS MAY HAVE EXPERIENCE REGENERATION SERVICE FAILURES, THAT INCLUDE...

MACK: TRUCKS WITHOUT HAND CONTROL VALVES, WERE BUILT WITH DOUBLE CHECK VALVE INSTALLED TO TRACTOR PROTECTION VALVE...

MACK: DIAGNOSTIC TROUBLE CODES (DTCS), P1086, P0420, P205B, P202, LOW TEMPERATURE, WILL BE RESOLVED WITH SOFTWARE...

MACK: UPDATE SOFTWARE INFORMATION REGARDING ENHANCEMENTS FOR ENGINE CONTROL MODULE (ECM) AND AFTERTREATMENT CONTROL...

MACK: ON SOME TRUCKS, OIL CONTAMINATION INTO ENGINE WIRE HARNESS, MAY BE FROM OIL LEVEL SENSOR FAILURE AND AN ANTI...

MACK TRUCKS:DUE TO EXCESSIVE MOISTURE IN THE CLIMATE UNIT, SOME VEHICLES MAY DEVELOP A BLOWER MOTOR FAILURE.

MACK TRUCK: REGARDING THE BREAKING OR CRACKING, AT STARTER SOLENOID STUD, OF 90 DEGREE POSITIVE BATTERY CABLE LUG; THE...

MACK TRUCK: WHILE DRIVING, AND FOOT BRAKE DEACTIVATES CRUISE CONTROL, ENGINE BRAKE FAILS TO FUNCTION PROPERLY UNTIL MANUALLY TURNED OFF AND THEN ON.

MACK TRUCK: THE OLD OIL SUPPLY LINE, FOR EXHAUST GAS RECIRCULATION (EGR) VALVE, WAS REPLACED WITH NEW OIL SUPPLY LINE...

Mack Chassis - TerraPro (MRU) And Low Entry (LEU) Models - Field Service Bulletin FSB 381-042, Warning Light Bar (WLB)...

Mack DEF Pump Troubleshooting Guide - US10+OBD13 And Newer Emissions

Selective Catalytic Reduction (SCR) Muffler Troubleshooting Guide - US10+OBD13 And Newer Emissions.

DEF Pump Troubleshooting Guide - US10+OBD13 And Newer Emissions.

Premium Tech Tool (PTT) - Message For Data Mismatch, Product Configuration Mismatch; Instruction To Run An Accessory Kit...

DEF Pump Troubleshooting Guide - US10+OBD13 And Newer Emissions

Selective Catalytic Reduction (SCR) Muffler Troubleshooting Guide - US10+OBD13 And Newer Emissions

USE FOR NEW VEHICLES (US21+OBD22 Emissions) - Intermittent Diagnostic Trouble Codes U02A3, U029D, U029E

Mack Chassis - Diesel Exhaust Fluid ( DEF ) System Cleaning/Flush After DEF Pump Failure Or System Contamination

Aftertreatment Hydrocarbon Injector (AHI) Troubleshooting Guide - US10+OBD13 And Newer Emissions

Regen Fails to Start/Initiate Or Starts And Immediately Stops - US10 And US10+OBD13 Emissions

System Date And Time, Information; Diagnostic Tool ( J-Pro, Premium Tech Tool ( PTT ) ) Displays Incorrect Timestamp For...

Diagnostic Trouble Code (DTC) P04DB - Crankcase Ventilation Disconnected; US10+OBD13 To US14+OBD16 Emissions

Aftertreatment Hydrocarbon Injector (AHI) Troubleshooting Guide - US10+OBD13 And Newer Emissions

Volvo Chassis - Diesel Exhaust Fluid ( DEF ) Contamination In Fuel System, Inspection And Repair - US10 to US14 (...

Volvo Chassis - Diagnostic Trouble Code (DTC) SA 0 FMI 0 or SPN 0 FMI 0 Present On Fault Code Readout - US10 And Newer...

Mack Chassis - Where To Find The Body Builder Portal - Body Builder Manual ( BBM ) Information - US04 And Newer...

Diesel Fuel Information - Acceptable Biodiesel, Fuel Blend For Summer And Winter - US07 And Newer Emissions, Model Year...

Mack Chassis - Disabling The Driver ID; Removing the Driver ID Prompt - US07 To US14+OBD16 Emissions, Model Years 2008...

Mack Chassis - Diagnsotic Trouble Code P026D-00, Fuel Injection Quantity Higher Than Expected; Diagnosis And Information...

Fuel Tank Strap Insulator Design Update; Fuel Tank Strap Appearance Changed

Aftertreatment Hydrocarbon Injector (AHI, 7th Injector) Changes Between US10 And US17 (GHG17, Common Rail Fuel System) -...

Diagnostic Trouble Code ( DTC ) P02FA Illuminating The Malfunction Indicator Lamp (MIL) - US17 (GHG17, Common Rail Fuel...

Diagnostic Trouble Code ( DTC ) P0471 Illuminating The Malfunction Indicator Lamp (MIL) - US17 (GHG17, Common Rail Fuel...

Diagnostic Trouble Code ( DTC ) P0420 Illuminating The Malfunction Indicator Lamp (MIL) - US17 (GHG17, Common Rail Fuel...

MACK TRUCK: TO INCREASED PROTECTION AGAINST FUEL INJECTOR TIP EROSION, A NEW FUEL TANK VENTILATION FILTER WAS...

MACK TRUCK: MOUNTED OUTSIDE OF FRAME RAIL, IS NEW FUEL TANK VENTILATION FILTER MOUNTING SLEEVE, USING FUEL TANK J...

Aftertreatment Diesel Exhaust Fluid (DEF) Tank, Level Sensor, Replacement

CBR: Mack NOx Sensor Troubleshooting Guide - US10+OBD13 And Newer Emissions

NOx Sensor Troubleshooting Guide - US10+OBD13 And Newer Emissions.

(Back Office) - Cruise Control Inoperative After Updating Software VECU5 Without ESP Package (UESP).

Sensor And Parameter Value Monitor - Template Parameter List For Pre-OBD (9-Pin Diagnostic Connector) Chassis In Premium...

No Start Condition After Over The Air Programing - VECU5 No Start "Safe State"

Temperature Sensor Troubleshooting Guide - US10+OBD13 And Newer

Low Voltage Disconnect (LVD), Function Description

NOx Sensor Troubleshooting Guide - US10+OBD13 And Newer Emissions

Aftertreatment Control Module ( ACM ) Diagnostic Trouble Codes ( DTC ) U0001-88 and U0010-88 Lighting The Malfunction...

Intake Pre-heater Electrical Schematics (Diagrams) - US10+OBD13, US14+OBD13 To US14+OBD16 Emissions

Exhaust Gas Temperature Sensor Circuit Range/Performance

Lighting Control Module ( LCM ) Replacement - Refer To Technical Parts Information ( TPI ) 364 - 034 Control Unit

Aftertreatment Control Module (ACM) Offline/Not Visible/Missing From Control Unit Information in Premium Tech Tool (PTT)...

ECM and ACM Reprogramming, OBD2015

MACK: WHEN THE OUTPUT FROM THE VECU GETS SHORTED OUT TO GND, THERE IS NO WARNING AND CAUSES 5TH WHEEL TO SLIDE WITHOUT...

MACK: WHEN THRESHOLD OF HIGH VOLTAGE HAS BEEN MET, THE LIFEGUARD BATTERY PROTECTION SYSTEM (LVD) RELAY MAY NOT TURN...

MACK: SOFTWARE IN FUEL MANAGEMENT MODULE (FMM) HAD INCORRECT CALIBRATION AND OPEN CIRCUIT FAULT CRITERIA, CAUSING LOW...

MACK TRUCK: IN THE WIRE HARNESS THAT CONNECTS THE CHASSIS TO TANK, SOME WIRE SEALS MAY BE MISSING, AND CAN CAUSE CORROSION AT CONNECTIONS.

CBR -Telematics Gateway (TGW) Connect Ability Issues

CBR: TGW Will Not Connect After SIM Card Replacement

Mack Trucks now offer an improved HD Inter-Axle Through Shaft for the CRD 125, 150, 180, and 200 family carriers.

Air Restriction Indicator

CBR: Diagnostic Trouble Code (DTC) P215A-64, Fault Code SPN 84 FMI 19

Vibration Diagnostics

New Vehicle Safety Certification Requirements for Vehicles, U.S.

2009 Document reformatted to be published as a TSB in Impact.

Premium Tech Tool ( PTT ) Training Materials And Support Tools

DEF Pump Cycling periodically Hours After Key Off

Mack - PTO Pump Speed Calculator

(Back Office Only) Mack Chassis - Cruise Control Inoperative After Disabling The Electronic Stability Program (ESP)

Mack Chassis - CXU - Lane Departure Warning System ( LDWS ) More Sensitive To The Right-hand ( Passenger ) Side Of The...

Mack Chassis - FSB 563-008 Plugs, Pressure Protection Manifold - New Brass Plugs For Noregon Pressure Protection...

Mack Chassis - FSB 237 - 020, Unit Injector Yoke Hold - Down Bolt Torque Specification

Diagnostic Trouble Codes (DTC) P20EE And P103C, Diagnostic Procedure; REPLACES GUIDED DIAGNOSTICS IN PREMIUM TECH TOOL (...

Mack Chassis - Fault Code SID 158 FMI 0 Logging In Instrument Cluster ( MID 140, IC ), No Code Description Or Diagnostic...

MACK TRUCKS: LOW OIL PRESSURE.

CBR - Automated Manual Transmission ( AMT ) Flywheel Pilot Bearing Wear On Input Shaft.

2009 Document reformatted to be published as a TSB in Impact.

Warranty Automated Manual Transmission ( AMT, I-Shift, mDrive ) Control Housing Assembly; Guidelines For Filing A Claim...

Automated Manual Transmission ( AMT ) I-Shift / mDRIVE - Ribbon Harness Replacement - Speed Sensor Bolts, Possible Fault...

Mack Chassis - Vehicles Equipped With An Automated Manual Transmission Model F ( AMT-F, mDrive ), Premium Tech Tool (...

Automated Manual Transmission (AMT) (Spigot Bearing) Input Shaft Repair Kit And Shim Kit, Part Number Information,...

Mack Chassis - Equipped With An Automated Manual Transmission (mDrive, AMT) AMT-C, AMT-D Or AMT-F - Transmission Oil...

Automated Manual Transmission Gearbox Will Not Shift To High Range After Gearbox Repair; MID 130 PSID 24 FMI 1, P1072-92...

Transmission Oil Cooler Hose, Replacement

Expired - Refer To K45673535 - Mack Chassis SNM15-002b mDRIVE Transmission Service Strategy ( Revised failure mode...

Automated Manual Transmission Gearbox Will Not Shift To High Range After Gearbox Repair; MID 130 PSID 24 FMI 1, P1072-92...

MACK: ON SOME TRUCKS, MORE LEG AND KNEE ROOM WAS PROVIDED FOR OPERATOR COMFORT DUE TO AIR OPERATED CLUTCH ASSIST SYSTEM...

MACK: DUE TO SUPPLIER MANUFACTURING ISSUE WITH CONNECTOR, SOME TRUCKS MAY EXPERIENCE MULTIPLE OPEN CIRCUITS IN 31 WAY...

MACK TRUCKS: THE AIR ASSISTED CLUTCH CABLE ON SOME VEHICLES MAY FRAY AT THE CLEVIS.

Mack Chassis - No Gauge Cluster Backlight

TSB-Charge Air Cooler t-clamp install.

Mack Chassis - Models - Anthem (AN), Pinnacle (PI, CXU, CHU) - Headlamp Aiming Instructions;

MACK TRUCKS: THE CHASSIS FAIRING SKIRT NEEDS TO BE INSTALLED.

MACK TRUCKS: NEW SWITCH MOUNTING BRACKET WAS DEVELOPED TO REPLACE EXISTING TURN SIGNAL SWITCH MOUNTING BRACKET, DUE TO...

MACK TRUCK: THE SUPPORT BRACKETS, USED WITH WIDE BASE WHEEL/TIRE COMBINATIONS EQUIPMENT, PROVIDE ADDITIONAL STRENGTH...

Electronically Controlled Suspension (ECS) Losing Air Pressure

Mack Chassis - Front Hub With Unit-Bearings ( Unitized Wheel Bearings ), Inspection Information And Guidelines -...

MACK: INFORMATION PROCEDURE REGARDING THE INSPECTION AND REPLACEMENT OF TOP PLATE AND SPRING SEAT, DUE TO DEFECTIVE...

MACK TRUCKS: REAR SUSPENSION HARDWARE TORQUE.

MACK TRUCKS: REAR SUSPENSION ADJUSTMENT WASHERS.

CBR - Active "Set Park Brake" Message On Drivers Information Display (DID).

MACK: THE PROTRUSION OF BRAKE SHOES BEYOND BRAKE DRUM IS BEING REPLACED WITH NEW 152MM (6.0 IN) BRAKES SHOES, 178 MM...

MACK: BRAKE SHOES PROTRUDES BEYOND BRAKE DRUM AND CAN BE RESOLVED BY INSTALLING BRAKE SHOES 152MM (6.0 IN) AND WIDE BRAKE DRUMS 18MM (7.0 IN).

MACK: AIR DISC BRAKE EXPERIENCING THERMAL OVERLOAD CONDITION THAT OVER ADJUSTMENT OF NORMAL PAD WEAR COMPENSATION THAT...

Mack Chassis - Bendix Vendor Configuration Program ( VCP ) Software Download Information

MACK: DUE TO A SOFTWARE BUG, MULTIPLE COUNTS OF INACTIVE FAULTS WERE FOUND, AFFECTING THE ACCELERATOR PEDAL (STANDARD OR KICKDOWN PEDAL).

MACK TRUCK: FLASHERS ARE TO BE REMOVED DUE TO DURABILITY ISSUES.

2009 Document reformatted to be published as a TSB in Impact.

MACK TRUCK: THE GRADE GRIPPER FEATURE, ON SOME TRUCKS, ARE PRONE TO HARSH ENVIRONMENTS WITH INTERNAL CONTAMINATION,...

Hood Insulation Separating From Hood, Insulation Installation Instructions

MACK: THE DOOR STOP BRACKET WILL FAIL, ON SOME TRUCKS, DUE TO AN OVER EXTENSION OF DOOR, BUT A NEW DOOR DESIGN ASSEMBLY IS AVAILABLE.

Stock Vehicle Storage and Maintenance