2019 Mack Pinnacle (chu) TSBs

CBR: Vehicle Speed Factor (K-Factor) Programming - Speed Factor Value Incorrect When Calculated In Premium Tech Tool...

Mack DEF Pump Troubleshooting Guide - US10+OBD13 And Newer Emissions

Aftertreatment Hydrocarbon Injector (AHI) Troubleshooting Guide - US10+OBD13 And Newer Emissions.

Selective Catalytic Reduction (SCR) Muffler Troubleshooting Guide - US10+OBD13 And Newer Emissions.

DEF Pump Troubleshooting Guide - US10+OBD13 And Newer Emissions.

Premium Tech Tool (PTT) - Message For Data Mismatch, Product Configuration Mismatch; Instruction To Run An Accessory Kit...

Diagnostic Trouble Codes ( DTC ) P2080, P2084, P242B Lighting The Malfunction Indicator Lamp ( MIL ) - US14+OBD16,...

DEF Pump Troubleshooting Guide - US10+OBD13 And Newer Emissions

Selective Catalytic Reduction (SCR) Muffler Troubleshooting Guide - US10+OBD13 And Newer Emissions

Aftertreatment Hydrocarbon Injector (AHI) Troubleshooting Guide - US10+OBD13 And Newer Emissions

USE FOR NEW VEHICLES (US21+OBD22 Emissions) - Intermittent Diagnostic Trouble Codes U02A3, U029D, U029E

Mack Chassis - Diesel Exhaust Fluid ( DEF ) System Cleaning/Flush After DEF Pump Failure Or System Contamination

Diagnostic Trouble Code ( DTC ) P26E8 Intermittently Lighting The Malfunction Indicator Lamp ( MIL ); Possible Derate...

Dye Test Procedure; Fuel System Leak Check - Common Rail Fuel System - US17+OBD16 And Newer Emissions, Common Model Year...

Diagnostic Trouble Codes (DTC) P24F600 Or P24F700 - US14+OBD15 Emissions And Newer, Model Year 2016 And Newer

Dye Test Procedure; Fuel System Leak Check - Common Rail Fuel System - US17+OBD16 And Newer Emissions, Common Model Year...

Volvo Chassis - Diagnostic Trouble Code (DTC) SA 0 FMI 0 or SPN 0 FMI 0 Present On Fault Code Readout - US10 And Newer...

Diagnostic Trouble Codes (DTC) P0069-64, P10EC-00, P0191-64 and P240F-00 In Different Combinations, Occurrences, And...

Mack Chassis - Where To Find The Body Builder Portal - Body Builder Manual ( BBM ) Information - US04 And Newer...

Mack Chassis - Diagnostic Trouble Code ( DTC ) P0420 Illuminating The Malfunction Indicator Lamp (MIL) - US17+OBD16 And...

Premium Tech Tool (PTT) Error Code 43: Service Regeneration Fails To Start; Service Regen Does Not Complete With Error...

Diesel Fuel Information - Acceptable Biodiesel, Fuel Blend For Summer And Winter - US07 And Newer Emissions, Model Year...

Mack Chassis - Diagnostic Trouble Code ( DTC ) P009E-73 - Fuel Pressure Relief Control Performance / Stuck Off -...

Air In The Fuel System Tests, Common Rail Fuel System - US17+OBD16 and Newer Emissions

Vehicles Equipped With A One-Box Emissions Aftertreatment System ( EATS ) - Diagnostic Trouble Codes ( DTC ) P2463 and P2453.

Diagnostic Trouble Codes (DTC) P20EE And P103C, Diagnostic Procedure; REPLACES GUIDED DIAGNOSTICS IN PREMIUM TECH TOOL (...

Common Rail Fuel System Faults - Diagnostic Trouble Codes (DTC) P0094, P228F, P016F, P0087,P00C6, P0257, P2A17, P2A1F,...

Mack Chassis - Oil Diluted With Fuel; Fuel In Oil, Diagnostic Information - All Emissions Prior To US17+OBD16 (Common...

Diagnostic Trouble Codes (DTC) P0069-64, P10EC-00, P0191-64 and P240F-00 In Different Combinations, Occurrences, And...

Mack Chassis - Diagnsotic Trouble Code P026D-00, Fuel Injection Quantity Higher Than Expected; Diagnosis And Information...

Diagnostic Trouble Codes (DTC) P0087 Fuel Rail/System Pressure To Low, P016F Closed Loop Fuel Pressure Control At Limit...

Diagnostic Trouble Codes (DTC) P0087 Fuel Rail/System Pressure To Low, P016F Closed Loop Fuel Pressure Control At Limit...

Fuel Tank Strap Insulator Design Update; Fuel Tank Strap Appearance Changed

Diagnostic Trouble Codes (DTC) P0069-64, P10EC-00, P0191-00 and P240F-00 In Different Combinations, Occurrences, And...

Grounding Bus Bar On Frame Rail Stud; Inspection To Be Performed For Power And Ground, Data Link DTCs - US13 And Newer...

Aftertreatment Hydrocarbon Injector (AHI, 7th Injector) Changes Between US10 And US17 (GHG17, Common Rail Fuel System) -...

Common Rail Fuel System - Diagnostic Trouble Code ( DTC ) P0094-00 Fuel System Leak Detected, Small Leak, Diagnostic...

Mack Chassis - Diagnostic Trouble Codes ( DTC ) P208E And P103B Logging With Possible Derate ( SCR Inducement ) -...

Mack Chassis - Diagnostic Trouble Code ( DTC ) P009E-73 - Fuel Pressure Relief Control Performance / Stuck Off -...

Mack Chassis - Diagnostic Trouble Code ( DTC ) P02FA Illuminating The Malfunction Indicator Lamp (MIL) - US17+OBD16 And...

Mack Chassis - Diagnostic Trouble Code ( DTC ) P0420 Illuminating The Malfunction Indicator Lamp (MIL) - US17+OBD16 And...

Secondary Fuel Filter Damaged Lip Seal; High Pressure Fuel System Learning And Control Limit and System Pressure...

Mack Chassis - Diagnostic Trouble Code ( DTC ) P009E-73 - Fuel Pressure Relief Control Performance / Stuck Off -...

Mack Chassis - Diagnostic Trouble Code ( DTC ) P02FA Illuminating The Malfunction Indicator Lamp (MIL) - US17+OBD16 And...

Mack Chassis - Diagnostic Trouble Code ( DTC ) P0420 Illuminating The Malfunction Indicator Lamp (MIL) - US17+OBD16 And...

Mack Chassis - Diagnostic Trouble Code ( DTC ) P009E-73 - Fuel Pressure Relief Control Performance / Stuck Off -...

Mack Chassis - Diagnostic Trouble Code ( DTC ) P02FA Illuminating The Malfunction Indicator Lamp (MIL) - US17+OBD16 And...

REQUEST REGEN Button Missing From EATS Status and DPF Status Screens In Instrument Cluster (IC) - Chassis Equipped With...

CBR: Turbo Compound (TC) Hot Side Noise, Diagnostic Information.

Service Campaign: Electronic Pressure Relief Valve (EPRV) Delete & Fuel Rail Pressure Sensor Update

Barksdale Leveling Valve, Leak Test

CBR: Mack DEF Dosing Valve Diagnostic Trouble Codes (DTC) P202D00, P208E00, P103B00 - US10+OBD13 And Newer Emissions

CBR: Model Year 2017 to Current - Fuel Filter Change ( Primary And Secondary ) For The EM - USA17 Emission Engines

CBR: 11L Engines, Non-Common Rail - Air Compressor Coolant Pipe, Parts Substitution - US14+OBD13 To US14+OBD16

Electronic Pressure Releif Valve (EPRV) Delete & Fuel Rail Pressure Sensor

Programming Failure - Chassis With Cummins Engine And An Allison Transmission

11L, 13L, And 16L Engine Oil Analysis Specifications - US10 And Newer Emissions

(Back Office Only) - Engine Brake Vibration When In High Setting - 13L Engine With Variable Geometry Turbo ( VGT ) -...

US10 Emission Engines - Diagnostic Trouble Code ( DTC ) SPN 1231 FMI 9 Troubleshooting.

Vehicles Equipped With An Automated Manual Transmission Model D or F ( AMT-D, AMT-F ) - Transmission Oil Leakage From...

Emcon (Spark Assist) Engine Aftertreatment System Troubleshooting Check Sheet - US07 Emissions

Manual Compression Test Adapter For Engines With Stainless Steel Injector Sleeves (Conical Tip Injectors) - US07 And...

Mack Low Oil Pressure Diagnostic Process For 11 Liter Engines

Mack Chassis - Diagnostic Trouble Codes ( DTC's ) - P020113, P020213, P020313, P020413, P020513, P020613, Cylinders 1...

Mack Chassis - Equipped With An Automated Manual Transmission Model D or F (mDrive, AMT-D, AMT-F) - Transmission Oil...

Mack Chassis - Technical Service Bulletin M-728-005, Leveling Valve, Leak Test, Air Leaks From The Leveling Valve After...

Engine Oil Analysis Specifications - US10 And Newer Emissions

Variable Geometry Turbocharger ( VGT ) Function Test ( 2551-08-03-02 ), OBD13 Model Year ( MY ) 2014 And Newer

Chassis Equipped With An AMT-F (I-Shift, mDrive) - Idle Drive Function Activates When Vehicle Is Reversing/Backing Up At...

13 Liter Engines ONLY - Engine Coolant Pump Housing Leak; Coolant Found Around The Oil Cooler Duct Cover Or In Between...

(Back Office Only) Vehicles Equipped With A Turbo Compound Engine - Report Of Frequent Air Compressor Cycling.

Trucks Equipped With A Cummins Engine - Engine Preheat Icon Does Not Illuminate In The Instrument Cluster (IC) During...

Engine Control Module (EMS)Software (MSW) Information - November 2019; Improvement List (Change Log) And Explanations...

Automated Manual Transmission( AMT ) ( I-Shift, mDRIVE ) Equipped Chassis, OBD13 And Newer - Light Turbo Surge ( Chuff )...

Diagnostic Trouble Codes (DTC) For The Engine Pre-Heat Relay: Supplementary Instructions

Diagnostic Trouble Codes (DTC) For The Engine Pre-Heat Relay: Supplementary Instructions

Engine Control Module (EMS) Software (MSW) Information - November 2019; Improvement List (Change Log) And Explanations...

Mack Chassis - Equipped With A Cummins Engine - Engine Preheat Icon Does Not Illuminate In The Instrument Cluster (IC)...

Mack Chassis - Equipped With An MP8 Engine - Diagnostic Trouble Code ( DTC ) P04DB - Crankcase Ventilation Disconnected;...

Engine Brake - Diagnostic Trouble Code (DTC) P1021-11 Volvo Compression Brake (VCB) Control Circuit Short To Ground -...

Leveling Valve, Leak Test

Mack Chassis - Equipped With An Automated Manual Transmission Model D or F ( mDrive, AMT-D, AMT-F ) - Transmission Oil...

Diagnostic Trouble Code (DTC) P24F6-00, Exhaust Aftertreatment Fuel Air Purge Valve Stuck Open Or DTC P24F7-00, Exhaust...

Mack Chassis - Pinnacle (CHU,CXU), Granite (GU) With Mack Engine ONLY - Power Take Off ( PTO ) Engine Speed Control...

Mack Chassis - Pinnacle (CHU,CXU,PI), Anthem (AN), Granite (GU,GR) With Mack Engine ONLY - Power Take Off ( PTO ) Engine...

Leveling Valve, Leak Test

Mack Chassis - Automated Manual Transmission Model F (AMT-F, mDrive) - Possible Infrequent Hiccup/Stumble During Steady...

Common Rail Fuel System - Engine Wiring Harness Will Not Reach / Is Not Long Enough To Connect To Electronic Pressure...

Engine Preheat Icon Does Not Illuminate In The Instrument Cluster (IC) During Engine Pre-heat (Intake Air Heater)...

Equipped With An MP8 Engine - Diagnostic Trouble Code ( DTC ) P04DB - Crankcase Ventilation Disconnected; US17+OBD16 And...

Diagnostic Trouble Code (DTC) P0087-00 Illuminating The Malfunction Indicator Lamp (MIL) Or Stop Engine Light; Possible...

Diagnostic Trouble Code ( DTC ) P471 Illuminating The Malfunction Indicator Lamp (MIL) - US17+OBD16, US17+OBD18 (GHG17,...

Intermittent Occurrences Of Very Brief Loss Of Power, Engine Stumble Or Hiccup Lasting Much Less Than A Second, Most...

Chassis Equipped With An AMT-F (mDrive) - Idle Drive Function Activates When Vehicle Is Reversing/Backing Up At Low...

Aftertreatment Diesel Exhaust Fluid (DEF) Tank, Level Sensor, Replacement

DEF Level (UQLS) Sensor Troubleshooting Guide - US17+OBD16 Emissions and Newer.

NOx Sensor Troubleshooting Guide - US10+OBD13 And Newer Emissions.

(Back Office) - Cruise Control Inoperative After Updating Software VECU5 Without ESP Package (UESP).

No Start Condition After Over The Air Programing - VECU5 No Start "Safe State"

Temperature Sensor Troubleshooting Guide - US10+OBD13 And Newer

Low Voltage Disconnect (LVD), Function Description

NOx Sensor Troubleshooting Guide - US10+OBD13 And Newer Emissions

DEF Level (UQLS) Sensor Troubleshooting Guide - US17+OBD16 Emissions and Newer

Aftertreatment Control Module ( ACM ) Diagnostic Trouble Codes ( DTC ) U0001-88 and U0010-88 Lighting The Malfunction...

DEF Level (UQLS) Sensor Troubleshooting Guide - US17+OBD16 Emissions and Newer

EPRV Delete & Fuel Rail Pressure Sensor Update

Exhaust Gas Temperature Sensor Circuit Range/Performance

Mack Chassis - Particulate Matter (PM) Sensor Diagnostic Trouble Codes (DTC) Illuminating The Malfunction Indicator Lamp...

Aftertreatment Control Module (ACM) Offline/Not Visible/Missing From Control Unit Information in Premium Tech Tool (PTT)...

RD: EPRV Delete & Fuel Rail Pressure Sensor Update

Mack Chassis - Diagnostic Trouble Code (DTC) P009B-13 Fuel Pressure Relief Control Circuit Open; Possible Derate -...

EXPIRED - Refer To K47547856 - Debranded Solutions - Mack Chassis - Particulate Matter (PM) Sensor Diagnostic Trouble...

Front Accessory Drive Noise, Alternator Belt Wear, Alternator Belt Tensioner Failure - Model Year 2017 And Newer

Mack Chassis - Particulate Matter (PM) Sensor Diagnostic Trouble Codes (DTC) Illuminating The Malfunction Indicator Lamp...

Mack Chassis - Particulate Matter (PM) Sensor Diagnostic Trouble Codes (DTC) Illuminating The Malfunction Indicator Lamp...

Diagnostic Trouble Code (DTC) P009B-13 Fuel Pressure Relief Control - Circuit Open; Possible Derate - US17+OBD16 And...

Diagnostic Trouble Codes (DTC) P0194-00 - Fuel Rail Pressure Sensor, Circuit Erratic,

Diagnostic Trouble Codes (DTC) P0194-00 - Fuel Rail Pressure Sensor, Circuit Erratic, Intermittent And/Or P016E-00...

Mack Chassis - Particulate Matter (PM) Sensor Diagnostic Trouble Codes (DTC) Illuminating The Malfunction Indicator Lamp...

ECM and ACM, Software Updates

ECM and ACM, Reprogramming, OBD2017 and OBD2018

ECM and ACM, Reprogramming, OBD2017 and OBD2018

Diagnostic Trouble Code ( DTC ) P0194 - 00 - Fuel Rail Pressure Sensor ( RPS ), Circuit Erratic, Intermittent - US17 (...

CBR -Telematics Gateway (TGW) Connect Ability Issues

CBR: TGW Will Not Connect After SIM Card Replacement

CBR: Frame Or Cab Lean

Mack Trucks now offer an improved HD Inter-Axle Through Shaft for the CRD 125, 150, 180, and 200 family carriers.

Air Restriction Indicator

CBR: Diagnostic Trouble Code (DTC) P215A-64, Fault Code SPN 84 FMI 19

Vibration Diagnostics

New Vehicle Safety Certification Requirements for Vehicles, U.S.

2009 Document reformatted to be published as a TSB in Impact.

Back Office Mack Chassis - Secondary Gauge Set Up - Model Year 2018 and Newer.

Premium Tech Tool ( PTT ) Training Materials And Support Tools

DEF Pump Cycling periodically Hours After Key Off

Mack - PTO Pump Speed Calculator

(Back Office Only) Mack Chassis - Cruise Control Inoperative After Disabling The Electronic Stability Program (ESP)

Mack Chassis - Equipped With Bendix Fusion, With Or Without Lane Departure Warning ( LDWS ) - Diagnostic Trouble Code (...

Mack Chassis - SNM16 - 043 Mack mRide V Stay Rod Ball And Washer Change

Mack Chassis - FSB 563-008 Plugs, Pressure Protection Manifold - New Brass Plugs For Noregon Pressure Protection...

Mack Chassis - Theft Deterrent System (TDS) Not Working; TDS Does Not Accept Password, Lockout Prevents Vehicle...

Diagnostic Trouble Codes (DTC) P20EE And P103C, Diagnostic Procedure; REPLACES GUIDED DIAGNOSTICS IN PREMIUM TECH TOOL (...

Mack Chassis - Fault Code SID 158 FMI 0 Logging In Instrument Cluster ( MID 140, IC ), No Code Description Or Diagnostic...

Oil Fill Adapter, Replacement

CBR: Equipped With An Automated Manual Transmission Model D or F ( AMT-D, AMT-F, mDrive) Missing X1 Value In VDA And...

CBR - Automated Manual Transmission ( AMT ) Flywheel Pilot Bearing Wear On Input Shaft.

CBR: Automated Manual Transmission ( AMT ) -Transmission Electronic Control Unit ( TECU ) MID130 PSID 29 FMI 7 /P10AE81...

CBR: Automated Manual Transmission (AMT) Transmission Kickdown Mode

2009 Document reformatted to be published as a TSB in Impact.

Warranty Automated Manual Transmission ( AMT, I-Shift, mDrive ) Control Housing Assembly; Guidelines For Filing A Claim...

Automated Manual Transmission ( AMT ) I-Shift / mDRIVE - Ribbon Harness Replacement - Speed Sensor Bolts, Possible Fault...

Mack Chassis - Vehicles Equipped With An Automated Manual Transmission Model F ( AMT-F, mDrive ), Premium Tech Tool (...

Mack Chassis - Automated Manual Transmission Model F ( AMT-F, mDrive ) - Short Transmission Replacement; Calibration...

Automated Manual Transmission (AMT) (Spigot Bearing) Input Shaft Repair Kit And Shim Kit, Part Number Information,...

Mack Chassis - Equipped With An Automated Manual Transmission (mDrive, AMT) AMT-C, AMT-D Or AMT-F - Transmission Oil...

Automated Manual Transmission Gearbox Will Not Shift To High Range After Gearbox Repair; MID 130 PSID 24 FMI 1, P1072-92...

Transmission Oil Cooler Hose, Replacement

Automated Manual Transmission (AMT) Faults - Diagnostic Trouble Codes (DTC) P1052-18 Or MID 130 PID 33 FMI 5...

Expired - Refer To K45673535 - Mack Chassis SNM15-002b mDRIVE Transmission Service Strategy ( Revised failure mode...

Automated Manual Transmission Gearbox Will Not Shift To High Range After Gearbox Repair; MID 130 PSID 24 FMI 1, P1072-92...

Mack Chassis - Automated Manual Transmission Model F ( AMT-F, mDrive ) - Short Transmission Replacement; Calibration...

Mack Chassis - Automated Manual Transmission Model F (AMT-F, mDrive) Power Take-off (PTO) Does Not Engage Or Grinds...

Mack Chassis - Equipped With An Automated Manual Transmission Model F (AMT-F, mDrive) With Crawler Gears - Setting The...

Mack Chassis - Vehicles Equipped With An Automated Manual Transmission Model F ( AMT-F, mDrive ), Premium Tech Tool (...

CBR: Vehicle Overspeed Warning Comes Active At A Lower Speed Than Expected; Vehicle Overspeed Warning In Driver...

Vehicle Overspeed Warning Comes Active At A Lower Speed Than Expected; Vehicle Overspeed Warning In Driver Information...

Noise On The AM Radio Band; Thumping, Ticking, Fluttering Sound On AM Radio Band - Model Year 2018 And Newer

Volvo Chassis - Certain Volvo Trucks Built After January 11, 2016 May Experience an Issue with the Instrument Cluster...

Vehicle Overspeed Warning Comes Active At A Lower Speed Than Expected; Vehicle Overspeed Warning In Driver Information...

Mack Chassis - No Gauge Cluster Backlight

TSB-Charge Air Cooler t-clamp install.

Mack Chassis - Incorrect Fog Lamp Electric Terminal Pinning - AN, GR, PI Models

Mack Chassis - Models - Anthem (AN), Pinnacle (PI, CXU, CHU) - Headlamp Aiming Instructions

Mack Chassis - Models - Anthem (AN), Pinnacle (PI, CXU, CHU) - Headlamp Aiming Instructions;

CBR - Driveline Noise, Suspension Ride Height Too High, Suspension Will Not Exhaust - Chassis Built 2016w01 And Newer.

Electronically Controlled Suspension (ECS) Losing Air Pressure

Mack Chassis - Front Hub With Unit-Bearings ( Unitized Wheel Bearings ), Inspection Information And Guidelines -...

Stock Vehicle Storage and Maintenance

Mack Dealer Support Communication - Selecting The Proper SR Area For Creating An eService

Service Literature Published and Released in April, 2022

Hood Insulation Separating From Hood, Insulation Installation Instructions

Remote Control Central Door Lock, Programming; Key Fob Cannot Be Programmed Or Does Not Work After Programming - Model...

Mack Chassis - Anthem (AN) And Pinnacle (PI) - Cab Water Intrusion, Water Leaking

CBR - Active "Set Park Brake" Message On Drivers Information Display (DID).

Mack Chassis - Drive Axle Brake Chamber Rubbing Frame Or Brake Drum - Vehicles Built Between 7 July 2014 And 23 August...

2009 Document reformatted to be published as a TSB in Impact.

Mack Chassis - Bendix Vendor Configuration Program ( VCP ) Software Download Information

Mack Chassis - SNM15-027 A/C Compressor Inspection Required For Warranty Repairs

Mack Chassis - Models GU / CHU Steering Wander