2022 Mack Lrbe (electric) TSBs
47 Technical Service Bulletins across 9 categories
Categories
Electrical
19 bulletinsCBR - When an OTA (Over-The-Air) job starts to program the VECU blocks the starter relay out, if the job ends in a...
Read full bulletin
Critical failure, the vehicle will remain in Safe State.
CBR - Mack Trucks has identified that certain LRBe model trucks may have an undersized fuse used in the coolant pump...
Read full bulletin
circuit.
Battery Electric Vehicle (BEV) - DTC P109D8A Following Energy Storage Control Module (ESCM) Software Update
Mack Chassis - Battery Electric Vehicle (BEV) Cab Heater Diagnostics.
Read full bulletin
Fault code C102571 and C102572 can be a result of insufficient coolant flowthrough the cab heater system.
CBR: Battery Electric Vehicle (BEV) Faults When Charging
CBR: Battery Electric Vehicle (BEV) DTCP108664 - Charging Switch Unit B, Voltage Supply, Signal Plausibility Failure
CBR - Battery Electric Vehicle (BEV) Post Programing Faults
CBR: Battery Electric Vehicle (BEV) DTC P108664 - Charging Switch Unit B, Voltage Supply, Signal Plausibility Failure
CBR - BEV Fault Code C102571 - Hybrid/EV System, Cooling Heater Relays - Actuator Stuck
Service Campaign: Mack trucks has determined that the CCCM (Combined Charging system Control Module) on certain LRBe...
Read full bulletin
model trucks could experience water intrusion causing damage to the CCCM.
Service Campaign: Mack Trucks has determined that certain LRBe trucks could exhibited insufficient cab heat.
Read full bulletin
To improve cab heat a retro fit of trucks coolant circuit is needed. Please follow the instructions below to complete the needed retro fit of the coolant circuit.
CBR: Battery Electric Vehicle (BEV) - Hybrid Powertrain Control Unit (HPCU) Programing
CBR: Battery Electric Vehicle (BEV) - Diagnostic Trouble Code (DTC) Troubleshooting Ending In No Fault Found
Service Campaign: Phase 1 Heater Relay Monitoring Accessory Kit
Battery Electric Vehicle (BEV) - Diagnostic Trouble Code (DTC) Troubleshooting Ending In No Fault Found
Battery Electric Vehicle (BEV) Post Programing Faults
CBR: Battery Electric Vehicle (BEV) Sub Hardware Programming
CBR: Battery Electric Vehicle (BEV) Cab Heater Diagnostics
Battery Electric Vehicle (BEV) - Charging Issues Worksheet For eService
Other
11 bulletinsCBR - Mack Chassis - Through Shaft Bearing Retainer Breakage On Mack Carriers.
CBR - Mack Carrier Nut Adhesive Change.
CBR - To correct the MID136 SID 66 FMI 7 fault code the latest Bendix VCP file will need to downloaded.
CBR - A significant GPS reporting issue is affecting fleet operations, with trucks maintaining back-office communication...
Read full bulletin
but failing to transmit GPS location data.
CBR: To correct the MID136 SID 66 FMI 7 fault code the latest Bendix VCP fi le will need to be downloaded.
CBR: Telematics Gateway (TGW) Connect Ability Issues
CBR: There has been a rise in questions regarding (DTC) - P11561A, P11571A, P115684, P115784 due to the limited amount...
Read full bulletin
of diagnostic information available.
CBR: TGW Will Not Connect After SIM Card Replacement
CBR: Active DTC P0A6649, P08F049, OR P0A5D49 fault code with ambient temperatures lower than 20C / 68F
Electromobility Required Special Tools
CBR: Diagnostic Trouble Code (DTC) P215A-64, Fault Code SPN 84 FMI 19
Engine
4 bulletinsCBR - Engine Control Module (EMS) Software Information - Improvement List (Change Log), US21+OBD2021 Emissions ONLY
It has been identified that the crossbar on the cooling package crash structure is indirect contact with the static coolant fill hose.
Read full bulletin
This interference creates a risk of hose chafing, which may result in coolant leakage over time.
CBR: Battery Electric Vehicle (BEV) 3-WayValve Calibration Failure
Barksdale Leveling Valve, Leak Test
Pre-Delivery & Maintenance
4 bulletinsCBR - Accelerator Pedal: Inspection Instructions
Service Campaign: LRBE Coolant Tank Cap Replacement
Campaign - Mack LRBE Cooling Box Refit
Service Literature Published and Released in May, 2023
Suspension
3 bulletinsFrame lean can be caused by several seemingly isolated possibilities.
Read full bulletin
The two most common are suspension and frame assembly issues.
Hub Cap, Leaking
New TSB- Hub cap leaking
Transmission
2 bulletinsCertain BEV vehicles may present one or more of the symptoms below: Vehicle Turns On but wont start Vehicle will not...
Read full bulletin
go into any gear Cluster and Gear Selector display show neutral after a gear is selected, but the vehicle does select and moveForward/Reverse Truck is limited to fi rst gear when Forward is selected Speed limited to ~25 MPH (~40 KPH) Low Power Truck will not charge
CBR: Battery Electric Vehicle (BEV) - Vehicle Will Not "Start", Limited Speed, Instrument Cluster Showing Neutral After...
Read full bulletin
Gear Selected
Infotainment
2 bulletinsCBR: Drivers Information Display (DID) Inoperative/Goes Blank During Vehicle Operation
CBR - Drivers Information Display (DID) Inoperative/Goes Blank During Vehicle Operation
HVAC & Climate
1 bulletinAir compressors may be observed cycling continuously at intervals of 10 to 30 seconds.
Read full bulletin
This behavior persists even when no air leaks are present in the system.
Steering
1 bulletinService Campaign: Electric-Hydraulic Power Steering System Improvement