2019 Mack Anthem (an) TSBs
331 Technical Service Bulletins across 14 categories
Categories
Engine
81 bulletinsMack Trucks Equipped With A Cummins Engine - Engine Preheat Icon Does Not Illuminate In The Instrument Cluster (IC)...
Read full bulletin
During Engine Pre-heat (Intake Air Heater) Operation - Vehicles With 2018Instrument Cluster Update, Model Year2018 And Newer
Mack Trucks has determined that certain vehicles equipped with a model year (MY) 2017-2018 MP8 Turbo Compound (TC)...
Read full bulletin
engine may not meet California and Federal Regulations (CARB). This Recall is for updated software that will reduce the amount of time necessary for the system to operate in a cold engine warm-up strategy and provide health monitoring of the Selective Catalyst Reduction (SCR).
CBR - The purpose of this solution is to give information on Engine Control Module (EMS) Software content.
CBR - Mack Chassis - Engine Brake Only Works With The Brake Pedal, No Function During Cruise.
Read full bulletin
US07 And Newer Emissions, Model Year 2008 And Newer.
Vehicles affected by this issue will show coolant runoff on the front rights side of the engine.
CBR - 13 Liter Engines ONLY - Engine Coolant Pump Housing Leak; Coolant Found Around The Oil Cooler Duct Cover Or In...
Read full bulletin
Between The Coolant Pump Housing And Oil Cooler Housing.
Inactive Code P25AE00 Being Generated After A Hard Pull And A Momentary Drop In Engine Oil Pressure (Low Oil Pressure)...
Read full bulletin
(Possible Related Codes - SPN4811 , SPN 100 , PID 100)
Vehicles may present with oil leak coming from the clutch/flywheel housing and observation of burned clutch smell or clutch slipping.
Read full bulletin
These symptoms can be mistaken as a crankshaft rear main seal leak, when the actual cause is the crankshaft adaptor O-ring.
CBR: Automated Manual Transmission (AMT) Model D or F (mDrive and I-Shift, AMT-D, AMT-F) - Transmission Oil Leakage From...
Read full bulletin
Transmission Input Shaft Seal Or Output Shaft Seal - US10 And Newer Emissions, Common Model Years 2010 And Newer
CBR: 11L, 13L, And 16L Engine Oil Analysis Specifications - US10 And Newer Emissions
CBR: Vehicles built with an 11 liter engine may experience a complaint of excessive fuel in the oil.
Read full bulletin
It is possible that the source of the fuel is the rear fuel galley plug in the cylinder head. A new and improved fuel galley plug has been developed to resolve this issue.
CBR: Turbo Compound (TC) Hot Side Noise, Diagnostic Information.
CBR: Vehicles built with an 11 liter engine may experience a complaint of excessive fuel in the oil.
Read full bulletin
It is possible that the source of the fuel is the rear fuel galley plug in the cylinder head.
Service Campaign: Mack trucks has determined that certain AN model trucks built with an MP8 Turbo Compound engine that...
Read full bulletin
have had a reman TC unit installed could experience a failure with the reman TC unit.
CBR: For vehicles equipped with an 11L engine, the plastic saddle bracket holding the a/c line on the left side of the...
Read full bulletin
engine may move excessively and rub the area where it secures the line.
Service Campaign: Electronic Pressure Relief Valve (EPRV) Delete & Fuel Rail Pressure Sensor Update
Barksdale Leveling Valve, Leak Test
CBR: Mack DEF Dosing Valve Diagnostic Trouble Codes (DTC) P202D00, P208E00, P103B00 - US10+OBD13 And Newer Emissions
CBR: Model Year 2017 to Current - Fuel Filter Change ( Primary And Secondary ) For The EM - USA17 Emission Engines
Electronic Pressure Releif Valve (EPRV) Delete & Fuel Rail Pressure Sensor
Barksdale Height Control Valve Troubleshooting Guide
Barksdale Height Control Valve Troubleshooting Guide
TBS- Jumper Harness,Wiper Motor,Replacement
Programming Failure - Chassis With Cummins Engine And An Allison Transmission
11L, 13L, And 16L Engine Oil Analysis Specifications - US10 And Newer Emissions
(Back Office Only) - Engine Brake Vibration When In High Setting - 13L Engine With Variable Geometry Turbo ( VGT ) -...
Read full bulletin
US17 And Newer Emissions (Common Rail Fuel System).
US10 Emission Engines - Diagnostic Trouble Code ( DTC ) SPN 1231 FMI 9 Troubleshooting.
Vehicles Equipped With An Automated Manual Transmission Model D or F ( AMT-D, AMT-F ) - Transmission Oil Leakage From...
Read full bulletin
Transmission Input Shaft Seal Or Output Shaft Seal - US10 And Newer Emissions, Common Model Years 2010 And Newer.
Emcon (Spark Assist) Engine Aftertreatment System Troubleshooting Check Sheet - US07 Emissions
Manual Compression Test Adapter For Engines With Stainless Steel Injector Sleeves (Conical Tip Injectors) - US07 And...
Read full bulletin
Newer Emissions, Model Year 2008 And Newer
Mack Low Oil Pressure Diagnostic Process For 11 Liter Engines
Mack Chassis - Diagnostic Trouble Codes ( DTC's ) - P020113, P020213, P020313, P020413, P020513, P020613, Cylinders 1...
Read full bulletin
Through 6 Injector A Open Circuit
Mack Chassis - Equipped With An Automated Manual Transmission Model D or F (mDrive, AMT-D, AMT-F) - Transmission Oil...
Read full bulletin
Leakage From Transmission Input Shaft Seal Or Output Shaft Seal - US10 And Newer Emissions, Common Model Years 2010 And Newer
Model Year 2017, 2018 - US17 Emission Engines - The ( Donaldson ) Fuel Filter - Part Number P550529 - " Cannot " Be Used
Mack Chassis - Technical Service Bulletin M-728-005, Leveling Valve, Leak Test, Air Leaks From The Leveling Valve After...
Read full bulletin
The Vehicle Is Parked (Shut Off)
Engine Oil Analysis Specifications - US10 And Newer Emissions
Variable Geometry Turbocharger ( VGT ) Function Test ( 2551-08-03-02 ), OBD13 Model Year ( MY ) 2014 And Newer
Chassis Equipped With An AMT-F (I-Shift, mDrive) - Idle Drive Function Activates When Vehicle Is Reversing/Backing Up At...
Read full bulletin
Low Speed; Information And Repair - Build Date Beginning Of Production 2017 To February 2018
13 Liter Engines ONLY - Engine Coolant Pump Housing Leak; Coolant Found Around The Oil Cooler Duct Cover Or In Between...
Read full bulletin
The Coolant Pump Housing And Oil Cooler Housing - Model Years 2019 And 2020
(Back Office Only) Vehicles Equipped With A Turbo Compound Engine - Report Of Frequent Air Compressor Cycling.
Read full bulletin
Secondary Air System Air Pressure Decreases Slowly When Engine Is At Low Idle - US17+OBD16 And Newer Emissions, Model Year 2018 And Newer
13 Liter Engines ONLY - Engine Coolant Pump Housing Leak; Coolant Found Around The Oil Cooler Duct Cover Or In Between...
Read full bulletin
The Coolant Pump Housing And Oil Cooler Housing - Model Years 2019 And 2020
Trucks Equipped With A Cummins Engine - Engine Preheat Icon Does Not Illuminate In The Instrument Cluster (IC) During...
Read full bulletin
Engine Pre-heat (Intake Air Heater) Operation - Vehicles With 2018 Instrument Cluster Update, Model Year 2018 And Newer
Engine Control Module (EMS)Software (MSW) Information - November 2019; Improvement List (Change Log) And Explanations...
Read full bulletin
For Issues And Diagnostic Trouble Codes (DTC, Fault Codes) US17+OBD2016 And US17+OBD18 Emissions, Model Years 2018 And 2019
Automated Manual Transmission( AMT ) ( I-Shift, mDRIVE ) Equipped Chassis, OBD13 And Newer - Light Turbo Surge ( Chuff )...
Read full bulletin
During Skip Shifting
Valve Cover Oil Leak at T Joint
Diagnostic Trouble Codes (DTC) For The Engine Pre-Heat Relay: Supplementary Instructions
Diesel Exhaust Fluid (DEF) Crystallisation, Dosing valve, Clean
Diagnostic Trouble Codes (DTC) For The Engine Pre-Heat Relay: Supplementary Instructions - US10+OBD13 And Newer...
Read full bulletin
Emissions, Model Year 2014 And Newer
IGNITION CYLINDER REPLACEMENT-CUMMINS ENGINE
Engine Control Module (EMS) Software (MSW) Information - November 2019; Improvement List (Change Log) And Explanations...
Read full bulletin
For Issues And Diagnostic Trouble Codes (DTC, Fault Codes) US17+OBD2016 And US17+OBD18 Emissions, Model Years 2018 And 2019
Mack Chassis - Equipped With A Cummins Engine - Engine Preheat Icon Does Not Illuminate In The Instrument Cluster (IC)...
Read full bulletin
During Engine Pre-heat (Intake Air Heater) Operation - Vehicles With 2018 Instrument Cluster Update, Model Year 2018 And Newer
Assembled Camshaft - Injector Lobe Rotation Inspection For Possible Spun Camshaft Lobe; Diagnostic Trouble Codes (DTC)...
Read full bulletin
P0257-00, P2A17-00, Or P2A1F-00, Possible Lack Of Power - US17+OBD16 and Newer Emissions
Mack Chassis - Equipped With An MP8 Engine - Diagnostic Trouble Code ( DTC ) P04DB - Crankcase Ventilation Disconnected;...
Read full bulletin
US17+OBD16 And US17+OBD18 Emissions (Common Rail Fuel System), Model Years 2018 And 2019
Diagnostic Trouble Codes ( DTC ) P0016-76 - Crankshaft Position - Camshaft Position Correlation - Turbo Compound ( TC )...
Read full bulletin
- Model Year 2018 and Newer
13 Liter Engines ONLY - Engine Coolant Pump Housing Leak; Coolant Found Around The Oil Cooler Duct Cover Or In Between...
Read full bulletin
The Coolant Pump Housing And Oil Cooler Housing - Model Years 2019 And 2020
Mack Chassis - Equipped With An Automated Manual Transmission Model D or F (mDrive, AMT-D, AMT-F) - Transmission Oil...
Read full bulletin
Leakage From Transmission Input Shaft Seal Or Output Shaft Seal - US10 And Newer Emissions, Common Model Years 2010 And Newer
Engine Brake - Diagnostic Trouble Code (DTC) P1021-11 Volvo Compression Brake (VCB) Control Circuit Short To Ground -...
Read full bulletin
US17+OBD16 Through US17+OBD19 Emissions, Model Years 2018 To 2020
Leveling Valve, Leak Test
Mack Chassis - Equipped With An Automated Manual Transmission Model D or F ( mDrive, AMT-D, AMT-F ) - Transmission Oil...
Read full bulletin
Leakage From Transmission Input Shaft Seal Or Output Shaft Seal - US10 And Newer Emissions, Common Model Years 2010 And Newer
Mack Chassis - Brake Lamps Do Not Illuminate During Engine Brake Activation - US17+OBD16 and Newer Emissions
Engine Preheat Icon Does Not Illuminate In The Instrument Cluster (IC) During Engine Pre-heat (Intake Air Heater)...
Read full bulletin
Operation - Post-Facelift Vehicles, Model Year 2018 And Newer
Diagnostic / Troubleshooting Procedures For Exhaust Gas Recirculation (EGR) System Components; Covers Most EGR System...
Read full bulletin
Diagnostic Trouble Codes (DTC), See List In Solution - US10, US10+OBD13, US14+OBD*, US17+OBD* With A Variable Geometry Turbocharger (VGT)
13L Engines - High Engine Oil Pressure, Frequently Accompanied By P0521-64 Oil Pressure Sensor - Plausibility Fault
Mack Chassis - Equipped With A Cummins 9 Liter Engine - Serpentine Belt Excessively Worn Or Damaged; Fan Belt Shredding...
Read full bulletin
Or Fraying Repeatedly
Diagnostic / Troubleshooting Procedures For EGR System Components; Diagnostic Trouble Codes (DTC) P0401-00, P0402-00,...
Read full bulletin
P04DD-00, P1121-00, P1121-98 Or SPN 2659 FMI 16, SPN 2659 FMI 18, SPN 412 FMI 0, SPN 412 FMI 15 - US10, US10+OBD13, US14+OBD*, US17+OBD* With A Variable Geometry Turbocharger (VGT)
Diagnostic Trouble Code (DTC) P24F6-00, Exhaust Aftertreatment Fuel Air Purge Valve Stuck Open Or DTC P24F7-00, Exhaust...
Read full bulletin
Aftertreatment Fuel Air Purge Valve Stuck Closed - US14+OBD15 Emissions And Newer, Model Year 2016 And Newer
Mack Chassis - Crankcase Ventilation ( CCV ) Oil Leaks - FSB 257 - 004, FSB 257 - 006 - US14 And US15 Emissions
Mack Chassis - Pinnacle (CHU,CXU,PI), Anthem (AN), Granite (GU,GR) With Mack Engine ONLY - Power Take Off ( PTO ) Engine...
Read full bulletin
Speed Control Inoperative; Engine Speed Does Not Ramp When PTO Is Activated - Model Year 2007 And Newer
Leveling Valve, Leak Test
EXPIRED - Refer to Solution K42766159 - Turbo Compound - Customer Report Of Excessive Air Purging Or Air Compressor...
Read full bulletin
Cycling With Vehicle At Idle; Acceptable Secondary Air System Leakdown Time Frame During Extended Idle - US17+OBD16 And Newer Emissions, Common Model Year 2018 And Newer
Fault Code SPN 1081 FMI 31 - Engine Wait to Start Lamp, Condition Exists - Model Year 2018
Mack Chassis - Automated Manual Transmission Model F (AMT-F, mDrive) - Possible Infrequent Hiccup/Stumble During Steady...
Read full bulletin
Engine/Vehicle Speed; Diagnostic Trouble Code P1074-92 Logging, Appears As Inactive - Common Model Years 2018 And 2019
Common Rail Fuel System - Engine Wiring Harness Will Not Reach / Is Not Long Enough To Connect To Electronic Pressure...
Read full bulletin
Relief Valve (EPRV) Connector, Wiring Harness Pulled Tight At EPRV; Correct Clocking, Symptoms, Repair - US17+OBD16 And Newer Emissions, Common Model Years 2018 And Newer
Variable Geometry Turbo (VGT) Calibration: Premium Tech Tool (PTT) Displays "Motor Disabled" Message, Operation Will...
Read full bulletin
Not Run, Will Not Complete When Running Operation; Poor Performance Following Calibration - US10 And Newer Emissions, Common Model Years 2014 And Newer
Engine Preheat Icon Does Not Illuminate In The Instrument Cluster (IC) During Engine Pre-heat (Intake Air Heater)...
Read full bulletin
Operation - Post-Facelift Vehicles, Model Year 2018 And Newer
Equipped With An MP8 Engine - Diagnostic Trouble Code ( DTC ) P04DB - Crankcase Ventilation Disconnected; US17+OBD16 And...
Read full bulletin
US17+OBD18 Emissions (Common Rail Fuel System), Model Years 2018 And 2019
Diagnostic Trouble Code (DTC) P0087-00 Illuminating The Malfunction Indicator Lamp (MIL) Or Stop Engine Light; Possible...
Read full bulletin
Engine Power/Torque Derate - US17+OBD16 And US17+OBD18 Emissions, Common Model Years 2018 And 2019
Diagnostic Trouble Code ( DTC ) P471 Illuminating The Malfunction Indicator Lamp (MIL) - US17+OBD16, US17+OBD18 (GHG17,...
Read full bulletin
Common Rail Fuel System) Chassis With Turbo Compound ONLY
Intermittent Occurrences Of Very Brief Loss Of Power, Engine Stumble Or Hiccup Lasting Much Less Than A Second, Most...
Read full bulletin
Frequently Between 1500 And 1700 RPM, No Diagnostic Trouble Codes ( DTC ) Generated - All Common Rail Fuel System Chassis - US17+OBD16 And Newer Emissions, Commonly Model Year 2018 And Newer
Mack Chassis - Equipped With An Automated Manual Transmission Model D or F ( mDrive, AMT-D, AMT-F ) - Transmission Oil...
Read full bulletin
Leakage From Transmission Input Shaft Seal Or Output Shaft Seal - US10 And Newer Emissions, Common Model Years 2010 And Newer
Chassis Equipped With An AMT-F (mDrive) - Idle Drive Function Activates When Vehicle Is Reversing/Backing Up At Low...
Read full bulletin
Speed; Information And Repair - Build Date Beginning Of Production 2017 To February 2018
Fuel System
70 bulletinsEmissions - EC0039 MST21 Failure to Detect P20EE - AN, CHU.
Vehicles Equipped With a Common Rail Fuel System - Aftermarket Secondary Fuel Filters, Important Information On Approved...
Read full bulletin
Filters - US17+OBD16 toUS21+OBD23
Cummins Exhaust Aftertreatment System (EATS) catalysts may experience cracking, which may be attributed to excessive...
Read full bulletin
vertical vibration in the exhaust stack. To mitigate this issue, a modification to the exhaust stack length is required.
If oil dilution is suspected refer to the applicable CBR solution below: CBR-659Mack Chassis - Oil Diluted With Fuel;...
Read full bulletin
Fuel In Oil, Diagnostic Information - All Emissions, All Model Years
Emission Recall: EC0033-M0311 SCR Recall
Emission Recall: EC0033-M0304 SCR Recall
CBR: Overhead Wear Overview - Model Year2018 To Current (Common Rail Fuel System ONLY)
CBR: Vehicle Speed Factor (K-Factor) Programming - Speed Factor Value Incorrect When Calculated In Premium Tech Tool...
Read full bulletin
(PTT); Speedometer Reading Incorrectly Following A Change To Vehicle Speed Factor - US17+OBD16 And Newer Emissions, Common Model Year 2018.
CBR - Mack Selective Catalytic Reduction (SCR) Muffler Troubleshooting Guide - US10+OBD13 And Newer Emissions
Mack DEF Pump Troubleshooting Guide - US10+OBD13 And Newer Emissions
Aftertreatment Hydrocarbon Injector (AHI) Troubleshooting Guide - US10+OBD13 And Newer Emissions.
Selective Catalytic Reduction (SCR) Muffler Troubleshooting Guide - US10+OBD13 And Newer Emissions.
DEF Pump Troubleshooting Guide - US10+OBD13 And Newer Emissions.
Premium Tech Tool (PTT) - Message For Data Mismatch, Product Configuration Mismatch; Instruction To Run An Accessory Kit...
Read full bulletin
Displayed When Attempting To Run Diagnostics For Diagnostic Trouble Codes (DTC) Or Programming - US10+OBD13 And Newer Emissions,
Diagnostic Trouble Codes ( DTC ) P2080, P2084, P242B Lighting The Malfunction Indicator Lamp ( MIL ) - US14+OBD16,...
Read full bulletin
US17+OBD16, And US17+OBD18 Emissions, Model Years 2017 To 2019
DEF Pump Troubleshooting Guide - US10+OBD13 And Newer Emissions
Selective Catalytic Reduction (SCR) Muffler Troubleshooting Guide - US10+OBD13 And Newer Emissions
Aftertreatment Hydrocarbon Injector (AHI) Troubleshooting Guide - US10+OBD13 And Newer Emissions
USE FOR NEW VEHICLES (US21+OBD22 Emissions) - Intermittent Diagnostic Trouble Codes U02A3, U029D, U029E
Mack Chassis -Oil Diluted With Fuel; Fuel In Oil, Diagnostic Information - All Emissions Prior To US17+OBD16 (Common...
Read full bulletin
Rail Fuel System), Model Year 2017 And Older
Mack Chassis - Diesel Exhaust Fluid ( DEF ) System Cleaning/Flush After DEF Pump Failure Or System Contamination
Mack Chassis - Diagnostic Trouble Code ( DTC ) P0420 Illuminating The Malfunction Indicator Lamp (MIL) - US17+OBD16 And...
Read full bulletin
US17+OBD18 (GHG17) Emissions (Common Rail Fuel System) - Commonly Model Years 2018 And 2019
Mack Chassis - Diagnostic Trouble Code ( DTC ) P009E-73 - Fuel Pressure Relief Control Performance / Stuck Off -...
Read full bulletin
US17+OBD16 And US17+OBD18 ( GHG17 ) Emissions (With Common Rail Fuel System), Commonly Model Years 2018 And 2019
Diagnostic Trouble Code ( DTC ) P26E8 Intermittently Lighting The Malfunction Indicator Lamp ( MIL ); Possible Derate...
Read full bulletin
Warning - US10+OBD13 And Newer Emissions, Model Year 2014 And Newer
Dye Test Procedure; Fuel System Leak Check - Common Rail Fuel System - US17+OBD16 And Newer Emissions, Common Model Year...
Read full bulletin
2018 And Newer
Diagnostic Trouble Codes (DTC) P24F600 Or P24F700 - US14+OBD15 Emissions And Newer, Model Year 2016 And Newer
Dye Test Procedure; Fuel System Leak Check - Common Rail Fuel System - US17+OBD16 And Newer Emissions, Common Model Year...
Read full bulletin
2018 And Newer
Volvo Chassis - Diagnostic Trouble Code (DTC) SA 0 FMI 0 or SPN 0 FMI 0 Present On Fault Code Readout - US10 And Newer...
Read full bulletin
Emissions, Model Year 2011 And Newer
Diagnostic Trouble Code ( DTC ) P0422 Lighting The Malfunction Indicator Light ( MIL ) - US17 (GHG17), Common Rail Fuel...
Read full bulletin
System ONLY
Mack Chassis - Anthem ( AN ) - Hood Assembly; Crack Repair - US17+OBD16 and Newer Emissions
Diagnostic Trouble Codes (DTC) P0069-64, P10EC-00, P0191-64 and P240F-00 In Different Combinations, Occurrences, And...
Read full bulletin
Time Stamps (Two To Four Codes), Possible Vehicle Derate - US17+OBD16, US17+OBD18 Emissions, Common Model Years 2018 And 2019
Mack Chassis - Where To Find The Body Builder Portal - Body Builder Manual ( BBM ) Information - US04 And Newer...
Read full bulletin
Emissions, Model Year 2008 And Newer
Mack Chassis - Diagnostic Trouble Code ( DTC ) P0420 Illuminating The Malfunction Indicator Lamp (MIL) - US17+OBD16 And...
Read full bulletin
US17+OBD18 (GHG17) Emissions (Common Rail Fuel System) - Commonly Model Years 2018 And 2019
Premium Tech Tool (PTT) Error Code 43: Service Regeneration Fails To Start; Service Regen Does Not Complete With Error...
Read full bulletin
43 Displayed - US10+OBD13 And Newer Emissions, Common Model Year 2014 And Newer
Diesel Fuel Information - Acceptable Biodiesel, Fuel Blend For Summer And Winter - US07 And Newer Emissions, Model Year...
Read full bulletin
2008 And Newer
Mack Chassis - Diagnostic Trouble Code ( DTC ) P009E-73 - Fuel Pressure Relief Control Performance / Stuck Off -...
Read full bulletin
US17+OBD16 And US17+OBD18 ( GHG17 ) Emissions (With Common Rail Fuel System), Commonly Model Years 2018 And 2019
Air In The Fuel System Tests, Common Rail Fuel System - US17+OBD16 and Newer Emissions
Secondary Fuel Filter replacement
Diagnostic Trouble Codes ( DTC ) P2080, P2084, P242B Lighting The Malfunction Indicator Lamp ( MIL ) - US14+OBD16,...
Read full bulletin
US17+OBD16, And US17+OBD18 Emissions, Model Years 2017 To 2019
FSB 233-007, Fuel Filter Housing, Replacement; Extra Port On Fuel Filter Housing When Replacing With New Part - Vehicles...
Read full bulletin
Manufactured Between 14 November 2016 And 31 December 2019
Diagnostic Trouble Codes (DTC) P20EE And P103C, Diagnostic Procedure; REPLACES GUIDED DIAGNOSTICS IN PREMIUM TECH TOOL (...
Read full bulletin
PTT ) - US17+OBD16 Through US17+OBD2018 Emissions, Model Years 2018 And 2019
Fuel Filter Housing, Replacement
Diagnostic Trouble Codes (DTC) P20EE And P103C, Diagnostic Procedure; - US17+OBD16 And US17+OBD19 Emissions
Correct Aftermarket Installation Of Permanent Electronic Log Devices ( ELD )( Qualcomm, PeopleNet, Omnitracs, GPS,...
Read full bulletin
Location Tracker, Etc.) RP1226 connection On The Data Link; Installation Instructions And Information For Third Party ( Aftermarket ) Devices Connected To The Data Link - US17+OBD16 And Newer Emissions, Models Built up to Week 37 (9/13) 2019.
Diagnostic Trouble Codes (DTC) P20EE And P103C, Diagnostic Procedure; REPLACES GUIDED DIAGNOSTICS IN PREMIUM TECH TOOL (...
Read full bulletin
PTT ) - US17+OBD16 And US17+OBD2018 Emissions, Model Years 2018 And 2019
Common Rail Fuel System Faults - Diagnostic Trouble Codes (DTC) P0094, P228F, P016F, P0087,P00C6, P0257, P2A17, P2A1F,...
Read full bulletin
P008A; Repair Information - US17+OBD16, US17+OBD18, and US17+OBD19 Emissions, Model Years 2018 To 2020
Diagnostic Trouble Code (DTC) P229F-64; Diagnostic Information - US10+OBD2013 Emissions And Newer
Diagnostic Trouble Codes (DTC) P0069-64, P10EC-00, P0191-64 and P240F-00 In Different Combinations, Occurrences, And...
Read full bulletin
Time Stamps (Two To Four Codes), Possible Vehicle Derate - US17+OBD16, US17+OBD18 Emissions, Common Model Years 2018 And 2019
Diagnostic Trouble Codes (DTC) P0069-64, P10EC-00, P0191-00 and P240F-00 In Different Combinations, Occurrences, And...
Read full bulletin
Time Stamps (Two To Four Codes), Possible Vehicle Derate - US17+OBD16, US17+OBD18 Emissions, Common Model Years 2018 And 2019
Diagnostic Trouble Codes (DTC) P0087 Fuel Rail/System Pressure To Low, P016F Closed Loop Fuel Pressure Control At Limit...
Read full bulletin
- Pressure Too Low, P228F Fuel Pressure Regulator Exceeded Learning Limits - Too High; Damaged Lip Seal On Secondary Fuel Filter; Possible Uneven Operation - US17+OBD16 And Newer Emissions (Common Rail Fuel System), Model Year 2018 And Newer
Diagnostic Trouble Codes (DTC) P0087 Fuel Rail/System Pressure To Low, P016F Closed Loop Fuel Pressure Control At Limit...
Read full bulletin
- Pressure Too Low, P228F Fuel Pressure Regulator Exceeded Learning Limits - Too High; Damaged Lip Seal On Secondary Fuel Filter; Possible Uneven Operation - US17+OBD16 And Newer Emissions (Common Rail Fuel System), Model Year 2018 And Newer
Fuel Tank Strap Insulator Design Update; Fuel Tank Strap Appearance Changed
Diagnostic Trouble Codes (DTC) P0069-64, P10EC-00, P0191-00 and P240F-00 In Different Combinations, Occurrences, And...
Read full bulletin
Time Stamps (Two To Four Codes), Possible Vehicle Derate - US17+OBD16, US17+OBD18 Emissions, Common Model Years 2018 And 2019
Grounding Bus Bar On Frame Rail Stud; Inspection To Be Performed For Power And Ground, Data Link DTCs - US13 And Newer...
Read full bulletin
Emissions, Common Model Year 2018 And Newer
Vehicle Speed Factor (K-Factor) Programming - Speed Factor Value Incorrect When Calculated In Premium Tech Tool (PTT);...
Read full bulletin
Speedometer Reading Incorrectly Following A Change To Vehicle Speed Factor - US17+OBD16 And Newer Emissions, Common Model Year 2018 And Newer
Vehicle Speed Factor (K-Factor) Programming - Speed Factor Value Incorrect When Calculated In Premium Tech Tool (PTT);...
Read full bulletin
Speedometer Reading Incorrectly Following A Change To Vehicle Speed Factor - US17+OBD16 And Newer Emissions, Common Model Year 2018 And Newer
Common Rail Fuel System - Diagnostic Trouble Code ( DTC ) P0094-00 Fuel System Leak Detected, Small Leak, Diagnostic...
Read full bulletin
Information - US17+OBD16 And US17+OBD18 Emissions, Common Model Years 2018 And 2019
Mack Chassis - Diagnostic Trouble Codes ( DTC's ) P24A0 And P249F Lighting The Malfunction Indicator Lamp ( MIL ) -...
Read full bulletin
US14+OBD15, US14+OBD16 (Common Model Years 2016 And 2017), US17+OBD16 And Newer ( Common Rail Fuel System, Model Year 2018)
Mack Chassis - Diagnostic Trouble Code ( DTC ) P009E-73 - Fuel Pressure Relief Control Performance / Stuck Off -...
Read full bulletin
US17+OBD16 And US17+OBD18 ( GHG17 ) Emissions (With Common Rail Fuel System), Commonly Model Years 2018 And 2019
Mack Chassis - Diagnostic Trouble Code ( DTC ) P02FA Illuminating The Malfunction Indicator Lamp (MIL) - US17+OBD16 And...
Read full bulletin
US17+OBD18 (GHG17) Emissions (With Common Rail Fuel System), Commonly Model Years 2018 And 2019
Mack Chassis - Diagnostic Trouble Code ( DTC ) P0420 Illuminating The Malfunction Indicator Lamp (MIL) - US17+OBD16 And...
Read full bulletin
US17+OBD18 (GHG17) Emissions (Common Rail Fuel System) - Commonly Model Years 2018 And 2019
Secondary Fuel Filter Damaged Lip Seal; High Pressure Fuel System Learning And Control Limit and System Pressure...
Read full bulletin
Diagnostic Trouble Codes (DTC), Possible Uneven Operation - US17+OBD16 And Newer Emissions (Common Rail Fuel System), Commonly Model Year 2018 And Newer
Mack Chassis - Diagnostic Trouble Code ( DTC ) P0420 Illuminating The Malfunction Indicator Lamp (MIL) - US17+OBD16 And...
Read full bulletin
US17+OBD18 (GHG17) Emissions (Common Rail Fuel System) - Commonly Model Years 2018 And 2019
Mack Chassis - Diagnostic Trouble Code ( DTC ) P0471 Illuminating The Malfunction Indicator Lamp (MIL) - US17+OBD16...
Read full bulletin
(GHG17, Common Rail Fuel System) Chassis ONLY
Mack Chassis - Diagnostic Trouble Code ( DTC ) P009E-73 - Fuel Pressure Relief Control Performance / Stuck Off -...
Read full bulletin
US17+OBD16 And US17+OBD18 ( GHG17 ) Emissions (With Common Rail Fuel System), Commonly Model Years 2018 And 2019
Mack Chassis - Diagnostic Trouble Code ( DTC ) P02FA Illuminating The Malfunction Indicator Lamp (MIL) - US17+OBD16 And...
Read full bulletin
US17+OBD18 (GHG17) Emissions (With Common Rail Fuel System), Commonly Model Years 2018 And 2019
Mack Chassis - Diagnostic Trouble Code ( DTC ) P0420 Illuminating The Malfunction Indicator Lamp (MIL) - US17+OBD16 And...
Read full bulletin
US17+OBD18 (GHG17) Emissions (Common Rail Fuel System) - Commonly Model Years 2018 And 2019
Mack Chassis - Diagnostic Trouble Code ( DTC ) P009E-73 - Fuel Pressure Relief Control Performance / Stuck Off -...
Read full bulletin
US17+OBD16 And US17+OBD18 ( GHG17 ) Emissions (With Common Rail Fuel System), Commonly Model Years 2018 And 2019
Mack Chassis - Diagnostic Trouble Code ( DTC ) P02FA Illuminating The Malfunction Indicator Lamp (MIL) - US17+OBD16 And...
Read full bulletin
US17+OBD18 (GHG17) Emissions (With Common Rail Fuel System), Commonly Model Years 2018 And 2019
REQUEST REGEN Button Missing From EATS Status and DPF Status Screens In Instrument Cluster (IC) - Chassis Equipped With...
Read full bulletin
New (Updated) Cluster Design - Model Year 2018 And Newer
Electrical
51 bulletinsCBR - Mack DEF Level (UQLS) Sensor Troubleshooting Guide - US17+OBD16 Emissions to US22+OBD2023 (DOES NOT APPLY TO AN(4)...
Read full bulletin
and PR(4)).
CBR - Mack Temperature Sensor Troubleshooting Guide
Mack DEF Level (UQLS) Sensor Troubleshooting Guide - US17+OBD16 Emissions and Newer
CBR: US17 GHG Common Rail Fuel System Component Electrical Faults - Model Year 2017 To 2024
CBR: Diagnostic Trouble Code (DTC) U010187- Lost Communication With TECU
Aftertreatment Diesel Exhaust Fluid (DEF) Tank, Level Sensor, Replacement
Mack NOx Sensor Troubleshooting Guide - US10+OBD13 And Newer Emissions
Mack NOx Sensor Troubleshooting Guide - US10+OBD13 And Newer Emissions
Mack MMD Alternator Pulley
Diagnostic Trouble Code ( DTC ) P10AE Logged In TECU With ACTIVE Or INACTIVE Status, Fault Code Cannot Be Cleared;...
Read full bulletin
Possibly Accompanied By P105817 And P105818 - US10+OBD13 And Newer Emissions (16-Pin Diagnostic Connector), Commonly Model Year 2014
DEF Level (UQLS) Sensor Troubleshooting Guide - US17+OBD16 Emissions and Newer.
NOx Sensor Troubleshooting Guide - US10+OBD13 And Newer Emissions.
(Back Office) - Cruise Control Inoperative After Updating Software VECU5 Without ESP Package (UESP).
No Start Condition After Over The Air Programing - VECU5 No Start "Safe State"
Temperature Sensor Troubleshooting Guide - US10+OBD13 And Newer
Low Voltage Disconnect (LVD), Function Description
NOx Sensor Troubleshooting Guide - US10+OBD13 And Newer Emissions
Mack Chassis - Diagnostic Trouble Code (DTC) P009B13 Fuel Pressure Relief Control Circuit Open; Possible Derate -...
Read full bulletin
US17+OBD16 And US17+OBD18 Emissions, Model Years 2018 And 2019
DEF Level (UQLS) Sensor Troubleshooting Guide - US17+OBD16 Emissions and Newer
Aftertreatment Control Module ( ACM ) Diagnostic Trouble Codes ( DTC ) U0001-88 and U0010-88 Lighting The Malfunction...
Read full bulletin
Indicator Lamp ( MIL ); Possible Derate Warning US10 And Newer Chassis
DEF Level (UQLS) Sensor Troubleshooting Guide - US17+OBD16 Emissions and Newer
EPRV Delete & Fuel Rail Pressure Sensor Update
Diagnostic Trouble Code ( DTC ) P10AE Logged In TECU With ACTIVE Or INACTIVE Status, Fault Code Cannot Be Cleared;...
Read full bulletin
Possibly Accompanied By P105817 And P105818 - US10+OBD13 And Newer Emissions (16-Pin Diagnostic Connector), Commonly Model Year 2014 An
Mack Chassis - Particulate Matter (PM) Sensor Diagnostic Trouble Codes (DTC) Illuminating The Malfunction Indicator Lamp...
Read full bulletin
(MIL); Tech Tip TT-014-2016 - US14+OBD16, US17+OBD16 And Newer Emissions, Common Model Year 2017 And Newer - To Be Used For EVERY
Aftertreatment Control Module (ACM) Offline/Not Visible/Missing From Control Unit Information in Premium Tech Tool (PTT)...
Read full bulletin
- US10+OBD13 And Newer Emissions
TECU SOFTWARE UPDATE
RD: EPRV Delete & Fuel Rail Pressure Sensor Update
RD: EPRV Delete & Fuel Rail Pressure Sensor Update
Mack Chassis - Diagnostic Trouble Code (DTC) P009B-13 Fuel Pressure Relief Control Circuit Open; Possible Derate -...
Read full bulletin
US17+OBD16 And US17+OBD18 Emissions, Model Years 2018 And 2019
VECU Active code and no MIL Lights
DTC P0194-00 and/or P016E-00, Fuel Rail Pressure Sensor (RPS) and wiring harness, Replacement
SCR Fittings, One Box, Replacement PM, NOx and Temperature Sensor Fittings
Remote Diagnostics - ACM and ECM Software Update
Particulate Matter (PM) Sensor Diagnostic Trouble Codes (DTC) Illuminating The Malfunction Indicator Lamp (MIL) -...
Read full bulletin
US14+OBD16, US17+OBD16 And Newer Emissions, Model Year 2017 And Newer - To Be Used For EVERY Visit
EXPIRED - Refer To K47547856 - Debranded Solutions - Mack Chassis - Particulate Matter (PM) Sensor Diagnostic Trouble...
Read full bulletin
Codes (DTC) Illuminating The Malfunction Indicator Lamp (MIL); Tech Tip TT-014-2016 - US14+OBD16, US17+OBD16 And Newer Emissions, Common Model Year 2017 And Newer - To Be Used For EVERY Visit
Front Accessory Drive Noise, Alternator Belt Wear, Alternator Belt Tensioner Failure - Model Year 2017 And Newer
Front Accessory Drive Noise, Alternator Belt Wear, Alternator Belt Tensioner Failure - Model Year 2017 And Newer
Diagnostic Trouble Codes ( DTC ) P205B-64 - Reductant Tank Temperature Sensor Circuit Range/Performance - Model Year...
Read full bulletin
2018 and Newer
AMT-F Oil In Control Housing Or TECU
Mack Chassis - Particulate Matter (PM) Sensor Diagnostic Trouble Codes (DTC) Illuminating The Malfunction Indicator Lamp...
Read full bulletin
(MIL); Tech Tip TT-014-2016 - US14+OBD16, US17+OBD16 And Newer Emissions, Common Model Year 2017 And Newer - To Be Used For EVERY Visit
Mack Chassis - Particulate Matter (PM) Sensor Diagnostic Trouble Codes (DTC) Illuminating The Malfunction Indicator Lamp...
Read full bulletin
(MIL); Tech Tip TT-014-2016 - US14+OBD16, US17+OBD16 And Newer Emissions, Common Model Year 2017 And Newer - To Be Used For EVERY Visit
Exhaust Gas Recirculation (EGR) System - Fault Codes SPN 412 FMI 0,2,5; Diagnostic Trouble Codes (DTC) P040A, P040B,...
Read full bulletin
P1121 - Temperature Sensor Inspection
Adaptive Cruise Control ECU Fault In The Driver Information Display (DID) At Start Up; "Missing Communication From...
Read full bulletin
Adaptive Cruise Control ECU" Message In Cluster (MID 140 PSID 211 FMI 9) - Model Year 2018 And Newer
Unable To Retrieve "On Request" Messages For PeopleNet Or Omnitracs Modules Installed On The DL5 Data Link; Third Party...
Read full bulletin
Electronic Log Device Not Reporting Certain Data
Diagnostic Trouble Code (DTC) P009B-13 Fuel Pressure Relief Control - Circuit Open; Possible Derate - US17+OBD16 And...
Read full bulletin
US17+OBD18 Emissions, Model Years 2018 And 2019
Diagnostic Trouble Codes (DTC) P0194-00 - Fuel Rail Pressure Sensor, Circuit Erratic,
Diagnostic Trouble Codes (DTC) P0194-00 - Fuel Rail Pressure Sensor, Circuit Erratic, Intermittent And/Or P016E-00...
Read full bulletin
Closed Loop Fuel Pressure At Control Limit, Pressure Too High - US17+OBD16 (Common Rail Fuel System) Emissions And Newer; Model Year 2017 And Newer
Diagnostic Trouble Codes (DTC) P0194-00 - Fuel Rail Pressure Sensor, Circuit Erratic, Intermittent And/Or P016E-00...
Read full bulletin
Closed Loop Fuel Pressure At Control Limit, Pressure Too High - US17+OBD16 (Common Rail Fuel System) Emissions And Newer; Model Year 2017 And Newer
Mack Chassis - Particulate Matter (PM) Sensor Diagnostic Trouble Codes (DTC) Illuminating The Malfunction Indicator Lamp...
Read full bulletin
(MIL); Tech Tip TT-014-2016 - US14+OBD16, US17+OBD16 And Newer Emissions, Common Model Year 2017 And Newer - To Be Used For EVERY Visit
ECM and ACM, Reprogramming, OBD2017 and OBD2018
ECM and ACM, Reprogramming, OBD2017 and OBD2018
Other
36 bulletinsCBR - Mack Chassis - Through Shaft Bearing Retainer Breakage On Mack Carriers.
CBR - Mack Carrier Nut Adhesive Change.
CBR - To correct the MID136 SID 66 FMI 7 fault code the latest Bendix VCP file will need to downloaded.
CBR - A significant GPS reporting issue is affecting fleet operations, with trucks maintaining back-office communication...
Read full bulletin
but failing to transmit GPS location data.
Mack Chassis - Rear Axle Overheat
CBR: To correct the MID136 SID 66 FMI 7 fault code the latest Bendix VCP fi le will need to be downloaded.
CBR: Telematics Gateway (TGW) Connect Ability Issues
CBR -Telematics Gateway (TGW) Connect Ability Issues
CBR: TGW Will Not Connect After SIM Card Replacement
CBR: Frame Or Cab Lean
Mack Trucks now offer an improved HD Inter-Axle Through Shaft for the CRD 125, 150, 180, and 200 family carriers.
Read full bulletin
The new HD shaft went into production on January 23rd, 2023 for 2.54 - 3.50 axle ratios and April 1st, 2023 for 3.56 - 3.98 ratios. The new HD through shaft is an upgrade over the current standard shaft and can now be used as a replacement part instead of the standard shaft. The new HD shaft has a new design to increase strength, longevity and life over the standard shaft.
Air Restriction Indicator
CBR: Diagnostic Trouble Code (DTC) P215A-64, Fault Code SPN 84 FMI 19
Frame Or Cab Lean - Gen II Chassis
Back Office Mack Chassis - Secondary Gauge Set Up - Model Year 2018 and Newer.
Premium Tech Tool ( PTT ) Training Materials And Support Tools
DEF Pump Cycling periodically Hours After Key Off
Mack - PTO Pump Speed Calculator
(Back Office Only) Mack Chassis - Cruise Control Inoperative After Disabling The Electronic Stability Program (ESP)
Mack Chassis - Accessory / Auxiliary Connection Points ( Power/Ground Points ) - Anthem, Pinnacle, Granite - Model Year...
Read full bulletin
2018 And Newer
Mack Chassis - Equipped With Bendix Fusion, With Or Without Lane Departure Warning ( LDWS ) - Diagnostic Trouble Code (...
Read full bulletin
DTC ) SPN 70 FMI 9, Bendix Code 64 With Possible "Lane Departure Warning Malfunction" Message - US17 And Newer
Mack Chassis - SNM16 - 043 Mack mRide V Stay Rod Ball And Washer Change
Mack Chassis - FSB 563-008 Plugs, Pressure Protection Manifold - New Brass Plugs For Noregon Pressure Protection...
Read full bulletin
Manifold (PPM)
Mack Chassis - Theft Deterrent System (TDS) Not Working; TDS Does Not Accept Password, Lockout Prevents Vehicle...
Read full bulletin
Operation - Model Years 2018 And 2019
Mack Models CHU, CXU, AN, PI - Troubleshooting And Repair Information For The Indel B Refrigerator - All Model Years
Canada Non-Compliance DRL overide
Improved method for determining which DTC to troubleshoot in a MIL on situation
Mack Chassis - Anthem (AN) - Air Deflector Cover Installation; Cover For Antenna Opening On Back Of Air Deflector -...
Read full bulletin
Model Year 2018 And Newer
Diagnostic Trouble Code (DTC) P215A-64, Fault Code SPN 84 FMI 19; Speedometer Drop-Out, Speedometer Inoperative
Diagnostic Trouble Codes (DTC) P20EE And P103C, Diagnostic Procedure; REPLACES GUIDED DIAGNOSTICS IN PREMIUM TECH TOOL (...
Read full bulletin
PTT ) - US17+OBD16 And Newer Chassis ONLY
For certain MACK CXU and AN trucks built between 08/29/2016 and 01/25/2019, a new improved torque procedure has been...
Read full bulletin
introduced to maintain and distribute torque properly on the hardware attaching the Link auxiliary axle to the frame mounted brackets. Follow the repair instructions outlined in this document for re-torquing the indicated nuts or bolts.
Diagnostic Trouble Codes (DTC) P20EE And P103C, Diagnostic Procedure; REPLACES GUIDED DIAGNOSTICS IN PREMIUM TECH TOOL (...
Read full bulletin
PTT ) - US17+OBD16 And Newer Chassis ONLY
Plugs, Pressure Protection Manifold
Plugs, Pressure Protection Manifold
Mack Chassis - Theft Deterrent System (TDS) Not Working; TDS Does Not Accept Password, Lockout Prevents Vehicle...
Read full bulletin
Operation - Model Years 2018 And 2019
Issues with the Charge Air System may result in the presence of oil in the Charge Air Cooler ( CAC ) or intake piping.
Transmission
30 bulletinsIf the vehicle door is open and the truck is in neutral, a popup message may appear on the Driver Information Display...
Read full bulletin
(DID) instructing the operator to shift into neutral. If this message appears while the vehicle is already in neutral, the Instrument Cluster (IC)requires a software update.
CBR - Mack Chassis - Timing Gear Plate Repair
CBR: Mack chassis with an mDRIVE transmission, there have been reports of complete shift assemblies and TECUs being...
Read full bulletin
replaced due to technicians being unable to pinpoint the source of the air leak.
CBR: ZF/TRW Steering Gear Side Cover Leak
CBR: Equipped With An Automated Manual Transmission Model D or F ( AMT-D, AMT-F, mDrive) Missing X1 Value In VDA And...
Read full bulletin
Default Settings Guidelines, ParameterP1AOB; Fault Code P1052-54, Error 40,Or Error 18 Encountered During Clutch Or Tran.
CBR - Automated Manual Transmission ( AMT ) Flywheel Pilot Bearing Wear On Input Shaft.
CBR: Automated Manual Transmission ( AMT ) -Transmission Electronic Control Unit ( TECU ) MID130 PSID 29 FMI 7 /P10AE81...
Read full bulletin
Fault Codes Being Generated
CBR: Automated Manual Transmission (AMT) Transmission Kickdown Mode
CBR: Timing Gear Plate Repair.
Read full bulletin
This solution provides supplementary information to be used when installing a Timing Gear Plate with Integrated Seal.
Timing Gear Plate Inspection
Warranty Automated Manual Transmission ( AMT, I-Shift, mDrive ) Control Housing Assembly; Guidelines For Filing A Claim...
Read full bulletin
For Chassis Return Visit With Transmission Issues After A Repair Requiring Control Housing Removal And Reinstallation - US07 And N.
Automated Manual Transmission ( AMT ) I-Shift / mDRIVE - Ribbon Harness Replacement - Speed Sensor Bolts, Possible Fault...
Read full bulletin
Codes P1058 - 21 Or MID 130 PID 161 FMI 1
Mack Chassis - Vehicles Equipped With An Automated Manual Transmission Model F ( AMT-F, mDrive ), Premium Tech Tool (...
Read full bulletin
PTT ) Gearbox Calibration Failure; Gearbox Calibration Operation Stops And Fails At 33% When Run With Transmission Removed
Mack Chassis - Automated Manual Transmission Model F ( AMT-F, mDrive ) - Short Transmission Replacement; Calibration...
Read full bulletin
And/Or Shifting Problems Following Replacement Of A Short Transmission - US17+OBD2016 And Newer Emissions, Model Year 2018 And Newer
(Back Office Only) - Mack Chassis - Equipped With An Automated Manual Transmission (AMT, mDrive) - Features Such As...
Read full bulletin
Predictive Cruise Control ( PCC ), Eco-Roll Inoperative - US17+OBD18 (GHG17, Common Rail Fuel System) Emissions, Model Year 2019
Automated Manual Transmission (AMT) (Spigot Bearing) Input Shaft Repair Kit And Shim Kit, Part Number Information,...
Read full bulletin
Reference Guide - US07 And Newer Emissions, Model Year 2008 And Newer
Mack Chassis - Equipped With An Automated Manual Transmission (mDrive, AMT) AMT-C, AMT-D Or AMT-F - Transmission Oil...
Read full bulletin
Specifications - Model Years 2010 To 2020
Automated Manual Transmission Gearbox Will Not Shift To High Range After Gearbox Repair; MID 130 PSID 24 FMI 1, P1072-92...
Read full bulletin
Unintentional Disengagement Of High Range - US07 And Newer Emissions, Model Year 2008 And Newer
Transmission Oil Cooler Hose, Replacement
Transmission Oil Cooler Hose, Replacement
Mack Chassis - Equipped With An Allison Transmission: Enable 6th Speed - All Emissions, All Model Years
** Tech Tip ** - TT-019-2016 Automated Manual Transmission ( AMT ) Bearing And Gear Shaft Inspection
Mack Chassis - Equipped With An I-Shift Transmission - Transmission Bucking While in Reverse Gear; Vehicle Jerks In...
Read full bulletin
Reverse
Automated Manual Transmission (AMT) Clutch Failures At Service Replacement; New Clutch Found To Be Damaged When Unboxed...
Read full bulletin
Or Fails Soon After Replacement
Automated Manual Transmission (AMT) Faults - Diagnostic Trouble Codes (DTC) P1052-18 Or MID 130 PID 33 FMI 5...
Read full bulletin
Intermittent Fault In Cold Weather - US07 And Newer Emissions, Model Year 2008 And Newer
Automated Manual Transmission Gearbox Will Not Shift To High Range After Gearbox Repair; MID 130 PSID 24 FMI 1, P1072-92...
Read full bulletin
Unintentional Disengagement Of High Range - US07 And Newer Emissions, Model Year 2008 And Newer
Mack Chassis - Automated Manual Transmission Model F ( AMT-F, mDrive ) - Short Transmission Replacement; Calibration...
Read full bulletin
And/Or Shifting Problems Following Replacement Of A Short Transmission - US17+OBD2016 And Newer Emissions, Model Year 2018 And Newer
Mack Chassis - Automated Manual Transmission Model F (AMT-F, mDrive) Power Take-off (PTO) Does Not Engage Or Grinds...
Read full bulletin
Intermittently During Engagement Or During Operation; Symptoms Present For PTO That Was Previously Working Properly - US17+OBD16 And Newer Emissions, Common Model Years 2018 And Newer
Mack Chassis - Equipped With An Automated Manual Transmission Model F (AMT-F, mDrive) With Crawler Gears - Setting The...
Read full bulletin
Maximum Gear That Can Be (Temporarily) Selected For Starting From Stop In Automatic And Manual Modes; New Parameters For Maximum Adjustable Gear In Automatic And Manual Modes; US17+OBD16 And Newer Emissions, Commonly Model Year 2018 And Newer
Mack Chassis - Vehicles Equipped With An Automated Manual Transmission Model F ( AMT-F, mDrive ), Premium Tech Tool (...
Read full bulletin
PTT ) Gearbox Calibration Failure; Gearbox Calibration Operation Stops And Fails At 33% - US17+OBD16 (GHG17) And Newer Emissions, Common Model Years 2018 And Newer
Body & Paint
18 bulletinsCBR - Mack Chassis - Dash Panel Cracking at Mounting to BIW.
CBR - Mack Chassis - AN And GR Models - Door Glass Shattering.
Remote Control Central Door Lock, Programming; Key Fob Cannot Be Programmed Or Does Not Work After Programming - Model...
Read full bulletin
Year 2018 And Newer
This CBR solution provides detailed instructions for diagnosing and addressing window glass shattering issues, including...
Read full bulletin
replacement specifications, interference checks, fastener verification, and reinforcement tab adjustments to ensure proper installation and functionality.
Hood Latch Assembly, Retrofit
Hood Latch Assembly, Retrofit
Mack Chassis - Anthem (AN) - Hood Mounted Mirror Repair; Mirror Covers Loose, Rattling, Vibrating
Mack Chassis - Anthem (AN) Water Leak Around Door
Mack Chassis - Anthem (AN) Water Leak Around Door
Mack Chassis - Hood Mirror Vibration - Model AN
Mack Chassis - Hood Mirror Vibration - Model AN
Mack Chassis - Model Anthem (AN) - Hood Latch/Cable Sticking Or Binding
Mack Anthem - Hood Latch Striker Rattle
Mack Chassis - SNM16 - 015 Updated Wiper Mechanism for One Piece Windshield; Windshield Wipers Leaving Streaks Or Not...
Read full bulletin
Clearing Center Of Windshield
Down View Mirror
Hood Insulation Separating From Hood, Insulation Installation Instructions
Remote Control Central Door Lock, Programming; Key Fob Cannot Be Programmed Or Does Not Work After Programming - Model...
Read full bulletin
Year 2018 And Newer
Mack Chassis - Anthem (AN) And Pinnacle (PI) - Cab Water Intrusion, Water Leaking
Lighting
10 bulletinsCBR: The procedure to eliminate the Mack Chassis "Air Restriction Light On" seen in the cluster is to confirm that the...
Read full bulletin
parameter YYT is set to "Enable" with Premium Tech Tool.
TSB-Charge Air Cooler t-clamp install.
Mack Chassis - Incorrect Fog Lamp Electric Terminal Pinning - AN, GR, PI Models
Mack Chassis - Models - Anthem (AN), Pinnacle (PI, CXU, CHU) - Headlamp Aiming Instructions
Mack Chassis - Anthem (AN) Models - Headlight Diagnostics And Replacement; Instructions For Non-Functioning Headlight Or...
Read full bulletin
Turn Signal In Headlight Housing
Mack Chassis - Models - Anthem (AN), Pinnacle (PI, CXU, CHU) - Headlamp Aiming Instructions;
Mack Chassis - Anthem (AN) Models - Headlight Diagnostics And Replacement; Instructions For Non-Functioning Headlight Or...
Read full bulletin
Turn Signal In Headlight Housing
Dignostic Trouble Code (DTC, Fault Code) MID 140 PSID 210 FMI 12, Faulty Unit or Component Present On DTC Readout;...
Read full bulletin
Vehicle Operation Not Affected: No Physical Symptoms Or Warning Lights In Instrument Cluster - Model Year 2018
Diagnostic Trouble Code ( DTC ) P0471 Illuminating The Malfunction Indicator Lamp
Mack Chassis - Diagnostic Trouble Code ( DTC ) P2459 Lighting The Malfunction Indicator Lamp ( MIL ); Possible Frequent...
Read full bulletin
Regeneration Requests - OBD15 And US14+OBD16 (Non-Common Rail) Chassis
Infotainment
10 bulletinsCBR: Vehicle Overspeed Warning Comes Active At A Lower Speed Than Expected; Vehicle Overspeed Warning In Driver...
Read full bulletin
Information Display (DID) - Model Year 2018 And Newer With New Style Instrument Cluster
Infotainment System - Volume Drop During A Phone Call, Phone Connected Via Bluetooth
Vehicle Overspeed Warning Comes Active At A Lower Speed Than Expected; Vehicle Overspeed Warning In Driver Information...
Read full bulletin
Display (DID) - Model Year 2018 And Newer With New Style Instrument Cluster.
Noise On The AM Radio Band; Thumping, Ticking, Fluttering Sound On AM Radio Band - Model Year 2018 And Newer
Volvo Chassis - Certain Volvo Trucks Built After January 11, 2016 May Experience an Issue with the Instrument Cluster...
Read full bulletin
Display
CarPlay SW Update with SEM
CarPlay SW Update with Hardware
CarPlay SW Update
Noise On The AM Radio Band; Poor Or No Reception On AM Radio - Model Year 2018 And Newer
Vehicle Overspeed Warning Comes Active At A Lower Speed Than Expected; Vehicle Overspeed Warning In Driver Information...
Read full bulletin
Display (DID) - Model Year 2018 And Newer With New Style Instrument Cluster
Brakes
9 bulletinsCBR - Active "Set Park Brake" Message On Drivers Information Display (DID).
CBR: Lift Axle Lowers During An Anti-lock Braking System (ABS)Breaking Event Or When Weight Is Added To The 5th...
Read full bulletin
Wheel/Rear Suspension- AN Model
Mack Chassis - Anthem (AN) And Pinnacle (PI) - ABS Modulator Wiring Rubbing Front Shock
Mack Chassis - Conventional Models (Anthem, Pinnacle, Granite) - Service Brakes Fail To Release; Brakes Sticking After...
Read full bulletin
Brake Pedal Is Released - Built Between 1 November 2018 And 31 March 2019
Mack Chassis - Drive Axle Brake Chamber Rubbing Frame Or Brake Drum - Vehicles Built Between 7 July 2014 And 23 August...
Read full bulletin
2019
Mack Chassis - Anthem (AN) And Pinnacle (PI) - ABS Modulator Wiring Rubbing Front Shock
Mack Chassis - Bendix ABS Fault SPN 807 FMI 13 Blink code 19-4
Mack Chassis - Conventional Models (Anthem, Pinnacle, Granite) - Service Brakes Fail To Release; Brakes Sticking After...
Read full bulletin
Brake Pedal Is Released - Built Between 1 November 2018 And 31 March 2019
Bendix ACom - EC80 ESP Controller; ABS And ATC Lights Illuminated, Fault Codes Present After Making Changes, Calibration...
Read full bulletin
Or Programming With Acom
Suspension
7 bulletinsCBR - Z Spring Bracket Wear.
Frame lean can be caused by several seemingly isolated possibilities.
Read full bulletin
The two most common are suspension and frame assembly issues.
CBR - Driveline Noise, Suspension Ride Height Too High, Suspension Will Not Exhaust - Chassis Built 2016w01 And Newer.
Vehicles Equipped With Chalmers Suspension - Frame Bracket Hardware Loose or Interfering
Electronically Controlled Suspension (ECS) Losing Air Pressure
Mack Chassis - Front Hub With Unit-Bearings ( Unitized Wheel Bearings ), Inspection Information And Guidelines -...
Read full bulletin
Commonly Model Year 2008 And Newer
Driveline Noise, Suspension Ride Height Too High, Suspension Will Not Exhaust - Chassis Built 2016w01 And Newer
Pre-Delivery & Maintenance
4 bulletinsCBR - Accelerator Pedal: Inspection Instructions
Service Literature Published and Released in May, 2023
Mack Dealer Support Communication - Selecting The Proper SR Area For Creating An eService
Service Literature Published and Released in April, 2022
Software & Calibration
2 bulletinsFleet Campaign: For certain MDI Mack Trucks an updated adaptive cruise software has been developed.
Mack Chassis - Bendix Vendor Configuration Program ( VCP ) Software Download Information
HVAC & Climate
2 bulletinsMack Chassis - SNM15-027 A/C Compressor Inspection Required For Warranty Repairs
Mack Chassis - Left Hand Drive ( LHD ) - No Airflow From Defrost And Floor Vents - Model Year 2018 And Newer
Tires & Wheels
1 bulletinCBR: Vehicles Equipped With A Lift Axle - Wheel Speed Fault Code SPN 793, SPN 794 Set When Axle Is Up