2002 Lincoln Town Car TSBs
59 Technical Service Bulletins across 12 categories
Categories
Engine
13 bulletinsSOME VEHICLES MAY EXHIBIT AN INOPERATIVE ENGINE COOLING FAN.
Read full bulletin
*TT
ON SOME VEHICLES EQUIPPED WITH THE 4.6L ENGINE, THE FRONT END ACCESSORY DRIVE (FEAD) BELT MAY HYDROPLANE ON THE WATER...
Read full bulletin
PUMP PULLEY WHENTHE BELT IS SPLASHED WITH WATER. *TT
SOME VEHICLES MAY DEVELOP AN INOPERATIVE CLIMATE CONTROL BLOWER MOTOR.
Read full bulletin
*TT
ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE.
Read full bulletin
*TT
SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA.
Read full bulletin
*TT
SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174.
Read full bulletin
*TT
SOME IGNITION SWITCH LOCK CYLINDER ASSEMBLIES MAY EXHIBIT ROUGNESS AND / OR EXCESS EFFORT IN TURNING, KEY DOES NOT FULLY...
Read full bulletin
RETURN FROM START, A MALFUNCTION INDICATOR LAMP MAY ILLUMINATE WITH P0500, P1502 AND U1039 STORED IN POWERTRIAN CONTROL MODULE (PCM). *TT
SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT...
Read full bulletin
COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. *PE
WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING.
Read full bulletin
*TT
ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS.
Read full bulletin
TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04.
SERVICE CYLINDER HEAD GASKET FOR 4.6L APPLICATIONS.
Read full bulletin
*TT
ENGINE-ROMEO BUILT 4.6L 2V-TICK NOISE FROM ENGINE-ENGINES BUILT BEFORE 9/17/2003.
Read full bulletin
*MJ
SOME VEHICLES, EQUIPPED WITH THE 4.6L 2V ENGINE, WITH AN ENGINE BUILD DATE PRIOR TO 8/29/03 MAY EXHIBIT AN ENGINE TICK...
Read full bulletin
NOISE THAT IS PRESENT AT ALL TEMPERATURES DURING IDLE. 2004 MODELS INCLUDED. *TT
Fuel System
10 bulletinsCUSTOMER SATISFACTION PROGRAM 05B31 - INFORMATION ONLY.
Read full bulletin
A POSSIBILITY THAT DURING A HIGH SPEED / HIGH ENERGY REAR COLLISION, CERTAIN COMPONENTS HAVE AN INCREASED RISK OF PUNCTURING THE FUEL TANK ON VEHICLES WITH LIMO PREP PACKAGE LIMO PACKAGE UPGRADE KIT OFFERING. *TT SUPPLEMENT #1. *TT UPDATED SUPPLEMENT #2. *TT
REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR.
Read full bulletin
*TT
REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR.
Read full bulletin
*TT
INOPERATIVE ELECTRIC REAR WINDOW DEFROSTER (HEATED BACKLITE) GRID LINES, INTEGRAL ANTENNA CONCERNS.
Read full bulletin
*TT
STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES...
Read full bulletin
(DTCS) P0401, P0402, P1400 OR P1401. ADDITIONAL SYMPTOMS MAY INCLUDE RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY. *TT
STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401.
Read full bulletin
ADDITIONAL SYMPTOMS MAY INCLUDE RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY. *TT
MALFUNCTION INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0442, P0455, P0456, P0457 OR P1442 OR A...
Read full bulletin
CHECK FUEL CAP LAMP ILLUMINATED WITH DTC P0457 FOR THE EVAPORATIVE EMISSION SYSTEM. *TT
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK...
Read full bulletin
FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT
STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES...
Read full bulletin
(DTCS) P0401, P0402, P1400 OR P1401, OR RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY, AND THE ABOVE LISTED DTCS WITHOUT MIL. *TT
MALFUNCTION INDICATOR LAMP ON WITH OR WITHOUT ROUGH RUNNING, LACK OF POWER, SURGE OR POOR FUEL ECONOMY WITH DIAGNOSTIC...
Read full bulletin
TROUBLE CODES P0401, P0402, P1400, P1401. *TT *JB
Electrical
8 bulletinsINFORMATION REGARDING DISCHARGED BATTERY CHARGING SERVICE TIPS AND GUIDELINES.
Read full bulletin
*TT
ILLUMINATED AIR BAG WARNING LAMP WITH DIAGNOSTIC TROUBLE CODE B2295 WITH LIGHT FLASHING CODE 22 (DRIVER SEAT SIDE AIR...
Read full bulletin
BAG CIRCUIT FAULT), OR LIGHT FLASHING CODE 23 (PASSENGER SEAT SIDE AIR BAG CIRCUIT FAULT). *TT
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES.
Read full bulletin
*TT
GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES.
Read full bulletin
*TT
VARIOUS INTERMITTENT/CONSTANT ELECTRICAL CONCERNS.
Read full bulletin
*TT
MULTIPLE DRIVEABILITY CONCERNS UNDER ACCELERATION CAUSED BY IGNITION COIL.
Read full bulletin
*TT
AIR BAG LIGHT ON WITH DIAGNOSTIC TROUBLE CODE (DTC) B2477 - PROGRAMMABLE MODULE INSTALLATION (PMI) SERVICE TIP.
Read full bulletin
*MJ
CUSTOMER SATISFACTION PROGRAM 02M01 SUPPLEMENT #4.
Read full bulletin
CERTAIN FORD 2000 THROUGH 2003 VEHICLES EQUIPPED WITH A TUBE-MOUNTED EGR PRESSURE SENSOR - ADDITIONAL EGR PRESSURE SENSOR WARRANTY COVERAGE. *TT SUPPLEMENT #3. *MJ SUPPLEMENT #6. *TT
Other
6 bulletinsSUBJECT REGARDING WIPER BLADE EDGE GUARD PROTECTORS.
Read full bulletin
*TT
SOME VEHICLES MAY EXHIBIT A FEAD BELT JUMP-OFF TOSS.
Read full bulletin
*YH
SAFETY BELT RETRACTION SPEED.
Read full bulletin
*TT
LIMITED SLIP AXLE CHATTER, SHUDDER, BINDING SENSATION, OR VIBRATION DURING LOW SPEED TURNING MANEUVERS.
Read full bulletin
*TT
AM FM AND CELLULAR PHONE RECEPTION INTERFERENCE .
Read full bulletin
*EH
LOSS OF AUTOLOCK AND/OR RKE HORN CHIRP CONFIRMATION.
Read full bulletin
* AR
Transmission
5 bulletinsON SOME VEHICLES, THE BRAKE SHIFT INTERLOCK MAY BE INOPERATIVE, NOW ALLOWING THE OPERATOR TO MOVE THE SHIFT LEVER FROM THE PARK POSITION.
Read full bulletin
STOP LAMP OPERATION MAY ALSO BE AFFECTED. *TT
BRAKE SHIFT INTERLOCK.*JB
INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS.
Read full bulletin
*SLC
TRANSMISSION FAILURE WHERE THERE IS A LARGE AMOUNT OF METAL OR DEBRIS IN THE PAN.
Read full bulletin
*TT
NEW SERVICE PART - NUMBER 5 NEEDLE BEARING AND RACE KIT - 4R70W TRANSMISSION - SERVICE TIP.
Read full bulletin
*TT
Body & Paint
5 bulletinsThis article supersedes TSB 19-2026 to update the vehicle model years affected.
Read full bulletin
Some 2000 and newer Ford/Lincoln/Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended.
Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns...
Read full bulletin
appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Follow the Service Procedure steps to correct the condition
Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns...
Read full bulletin
appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Follow the Service Procedure steps to correct the condition
ALUMINUM CORROSION - SERVICE TIP.
Read full bulletin
*TT
FRONT DOOR GLASS THAT MOVES SLOWLY OR BINDS - GLASS STOPS 1/2 WAY DOWN.
Read full bulletin
*TT
Air Bags & Safety
3 bulletinsSUBJECT REGARDING AIR BAG WARNING LAMP ILLUMINATION WITH DIAGNOSTIC TROUBLE CODE B2290 / LAMP FAULT CODE 16.
Read full bulletin
*TT
EXHBITING AN ILLUMINATED AIR BAG WARNING LAMP WITH DIAGNOSTIC TROUBLE CODE B2295 OR LIGHT FLASHING CODE 22.
Read full bulletin
*TT
CONCERNS WITH AIR BAG WARNING LAMP WITH DIAGNOSTIC TROUBLE CODE B2290/ LAMP FAULT CODE 16.
Read full bulletin
*TT
Pre-Delivery & Maintenance
3 bulletinsAM/FM AND CELLULAR PHONE RECEPTION INTERFERENCE - SERVICE TIP.
Read full bulletin
*TT
SAFETY BELT WEB STOP BUTTON SERVICE.
Read full bulletin
*EH
REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS.
Read full bulletin
*TT
Lighting
2 bulletinsINOPERATIVE OR INACURRATE SPEEDOMETER, 4X4 LAMP ILLUMINATD, AND / OR DIAGNOSTIC TROUBLE CODE P1635 OR P1639.
Read full bulletin
*TT
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS.
Read full bulletin
VARIOUS MODELS INCLUDING 2004 F-SERIES. *TT
HVAC & Climate
2 bulletinsSOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS.
Read full bulletin
*SLC
CLIMATE CONTROL A/C SERVICE TECH TIPS.
Read full bulletin
*EH
Tires & Wheels
1 bulletinTHIS BULLETIN INVOLVES PROPER PROCEDURES FOR PREPARATION OF SERVICE SHEET METAL PARTS COATED WITH ELECTRO DEPOSITION PRIMER (E-COAT).
Read full bulletin
*TT
Brakes
1 bulletinDOOR LOCKS BEING INOPERATIVE WHEN USING THE KEYPAD AND/OR REMOTE KEYLESS ENTRY (RKE) FOB - FUSE 2.30 OPENING...
Read full bulletin
INTERMITTENTLY.