1998 Lincoln Navigator TSBs

SOME VEHICLES MAY EXHIBIT DRIVEABILITY CONDITIONS AND / OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE P0455 (GROSS LEAK DETECTED).

ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE.

SUBJECT REGARDING EXAGGERATED ENGINE BRAKING ON DECELERATION.

SOME VEHICLES MAY EXHIBIT DRIVEABILTY CONDITIONS AND/OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE CODE P0455 (GROSS LEAK DETECTED).

SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA.

SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174.

SOME IGNITION SWITCH LOCK CYLINDER ASSEMBLIES MAY EXHIBIT ROUGNESS AND / OR EXCESS EFFORT IN TURNING, KEY DOES NOT FULLY...

A CONDITION MAY EXIST, WHERE THROTTLE STICKING MAY OCCUR ON A FEW VEHICLES IN VERY COLD AMBIENT TEMPERATURES AFTER...

SOME VEHICLES MAY EXHIBIT A VIBRATION AT IDLE AND/OR ENGINE DROANING NOISE ON ACCELERATION FROM A STOP.

SUBJECT REGARDING ENGINE OIL RECOMMENDATIONS FOR USE IN 2001 VEHICLES - SAE 5W-20 MOTOR OIL.

SOME VEHICLES MAY EXHIBIT THE ENGINE OIL SENDING UNIT CONTACTING THE OIL DRIP SHIELD ATTACHED TO THE FRONT AXLE.

SUBJECT REGARDING CERTAIN VEHICLES WITH 4.6L ROMEO ENGINES EXHIBITING AN OIL LEAK FROM THE CYLINDER HEAD GASKET AREA.

SOME VEHICLES EQUIPPED WITH 4.6L ROMEO ENGINE MAY EXHIBIT AN OIL LEAK FROM THE CYLINDER HEAD GASKET AREA.

INFORMATION ON IDLE VIBRATION OR ENGINE DROAN ON ACCELERATION.

THIS BULLETIN ADDRESSES CONCERNS A NOISE AT INTIAL ENGINE STARTUP WHEN COLD FROM THE ACCESSORY DRIVE BELT.

SOME VEHICLES EQUIPPED WITH A 4.6L, 5.4L, OR 6.8L ENGINE MAY EXHIBIT A ROUGH IDLE / MISS AFTER START-UP IN COLD AMBIENT TEMPERATURES.

INFORMATION ON VEHICLES EXHIBITING COLD ENGINE KNOCK.

FOR CERTAIN VEHICLES THE OCTANE SHORTING BAR LOCATED ON THE PASSENGER SIDE OF ENGINE COMPARTMENT NEAR THE BULKHEAD IS...

SOME VEHICLES EQUIPPED WITH 5.4L ENGINES MAY EXHIBIT A COLD START ENGINE KNOCK CONCERN UNTIL WARMED UP.

INFORMATION ON SETTING THE CHECK ENGINE LIGHT AND SETTING DIAGNOSTIC TROUBLE CODE P0455 (EVAPORATIVE EMISSIONS GROSS LEAK).

THIS BULLETIN STATES THAT FOR CERTAIN VEHICLES IT IS NOT POSSIBLE TO SET THE CHECK ENGINE LIGHT AND SET DIAGNOSTIC...

MALFUNCTION INDICATOR LAMP ON, WITH P0300 - P0308 MISFIRE DIAGNOSTIC TROUBLE CODES WITH A 4.6L ENGINE.

SUBJECT REGARDING A/C VACUUM RESERVOIR / CHECK VALVE LOCATION FOR THE AIR CONDITIONING SYSTEM.

SOME VEHICLES MAY EXPERIENCE SPARK KNOCK DURING LIGHT-TO-MODERATE ACCELERATIONS.

INFORMATION CONCERNING THE OCTANE SHORTING BAR LOCATED ON THE PASSENGER SIDE OF ENGINE COMPARTMENT NEAR THE BULKHEAD IS...

SUBJECT REGARDING IDLE VIBRATION (REPEAT MESSAGE).

EXPERIENCING COLD ENGINE KNOCK (REPEAT / REVISED MESSAGE).

SOME VEHICLES EQUIPPED WITH 4.6L OR 6.8L ENGINES MAY EXHIBIT A COLD START ENGINE NOISE UNTIL WARMED UP.

VEHICLES EQUIPPED WITH ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) , MAY EXERIENCE THE BLOWER MOTOR STAYING ON HIGH...

SOME VEHICLES EQUIPPED WITH THE 5.4L ENGINE, 4R100 TRANSMISSION AND AN AUXILIARY TRANSMISSION OIL COOLER MAY EXHIBIT A COASTDOWN MOAN CONCERN.

SUBJECT REGARDING AIR CONDITIONER VACUUM RESERVOIR / CHECK VALVE LOCATION.

SOME VEHICLES EQUIPPED WITH ENGINES PRODUCED BY WINDSOR ENGINE PLANT MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP.

VEHICLES WITH 2.4L, 4.6L, AND 5.4L ENGINES MAY EXHIBIT AN A/C MOAN AT IDLE.

SOME VEHICLES MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP.

SOME VEHICLES EQUIPPED WITH ENGINES PRODUCED BY WINDSOR ENGINE PLANT MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP.

SOME VEHICLES MAY EXHIBIT A IDLE VIBRATION.

SOME VEHICLES MAY DEVELOP A COOLANT LEAK AT THE WORM GEAR CLAMP LOCATED AT THE JOINT BETWEEN THE METAL INTAKE COOLANT...

VEHICLES EQUIPPED WITH WINDSOR ENGINES ONLY MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP.

EXPERIENCING ENGINE KNOCK AT INITIAL COLD STARTUP.

VEHICLES EQUIPPED WITH THE 5.4L ENGINE, 4R100 TRANSMISSION AND AN AUXILIARY TRANSMISSION OIL COOLER MAY EXHIBIT A COASTDOWN MOAN CONCERN.

CONCERNS WITH A HARD TO TURN IGNITION KEY AND / OR A HARD TO REMOVE KEY FROM IGNITION CYLINDER.

OWNER NOTIFICATION FOR REPLACEMENT OF ENGINE CYLINDER HEADS.

COLD ENGINE KNOCK 5.4L ACTION.

SOME VEHICLES EQUIPPED WITH ENGINES PRODUCED BY WINDSOR ENGINE PLANT MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP.

SOME VEHICLES MAY EXPERIENCE AN IDLE VIBRATION.

SOME VEHICLES MAY DEVELOP A COOLANT LEAK AT THE WORM GEAR CLAMP LOCATED AT THE JOINT BETWEEN THE METAL INTAKE COOLANT...

EXPERIENCING A ENGINE KNOCK AT COLD START-UP.

FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS.

FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR.

BRIEF INFORMATION REGARDING CYLINDER HEAD TEMPERATURE (CHT) AND FAIL SAFE COOLING.

SOME VEHICLES EQUIPPED WITH THE 5.4L ENGINE, 4R100 TRANSMISSION AN AUXILIARY TRANSMISSION OIL COOLER MAY EXHIBIT A COASTDOWN MOANING NOISE.

FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS.

CONCERNS OF ENGINE CHECKLIGHT ON AND DTC P1506 ( IDLE AIR CONTROL OVER SPEED ERROR ) AND/OR FAST IDLE.

SYMPTOMS REGARDING P0300-P0308 MISFIRE DTCS WITH 4.6L ENGINES.

CONCERNS WITH HESITATION, STUMBLE, SURGE, MISS, ROUGH IDLE, STALL AT IDLE.

SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT...

WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING.

USE OF STAINLESS STEEL EXHAUST STUDS IN SERVICE FOR 5.4L 2V ENGINE.

INTERMITTENT ROUGH IDLE - NON-COMMANDED EGR (EXHAUST GAS RECIRCULATION VALVE) FLOW.

ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS.

ENGINE-CYLINDER HEAD DECK LEAK-4.6 AND 5.4L ENGINES-NEW SERVICE-ONLY GASKET AND CYLINDER HEAD KITS AVAILABILITY.

BROKEN EXHAUST MANIFOLD STUDS.

ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED...

FALSE FAILURE OF THE VAPOR MANAGEMENT VALVE (VMV).

SUBJECT REGARDING DRIVELINE ANGLE-RELATED VIBRATION AT VARIOUS SPEEDS AND LOAD CONDITIONS.

SOME VEHICLES MAY EXHIBIT A SQUEAK, SNAP, RATTLE, OR CLUNK IN THE FRONT END WHEN TURNING OR GOING OVER BUMPS.

SOME VEHICLES MAY EXHIBIT A DRIVELINE VIBRATION AT SPEEDS BETWEEN 60-70 MPH.

VEHICLES EQUIPPED WITH PASSIVE ANTI-THEFT SYSTEM (PATS) MAY NOT START OR CRANK.

SOME VEHICLES MAY EXHIBIT HESITATION ON ACCELERATION OR WHILE TURNING.

SOME VEHICLES MAY EXHIBIT A REAR WIPER THAT DOES NOT FUNCTION PROPERLY (JAMMED).

SOME VEHICLES MAY EXHIBIT A REAR WIPER THAT DOES NOT FUNCTION PROPERLY (JAMMED).

INFORMATION ON VEHICLES EXHIBITING VIBRATION AT CRUISE OVER 50 MPH.

REAR WIPER ARM INSTALLATION.

SUBJECT REGARDING VEHICLES EQUIPPED WITH COMPACT DISC PLAYERS.

VEHICLES BUILT FROM 5/15/98 THROUGH 7/24/98 THAT ARE EQUIPPED WITH COMPACT DISC PLAYERS SHOULD HAVE THE YELLOW SHIPPING...

BRIEF INFORMATION ON VEHICLES EXHIBIT VIBRATION AT CRUISE OVER 50 MPH.

SOME VEHICLES MAY EXHIBIT REAR AXLE NOISE.

EFFECTIVE NOVEMBER 2, 1998 CERTAIN VEHICLES OF THE 4R100 ARE ADDED TO THE FQR (FORD QUALITY RENEWAL) ASSEMBLY PROGRAM.

SUBJECT REGARDING VEHICLES EXHIBITING VIBRATION AT CRUISE OVER 50 MPH.

INFORMATION REGARDING VEHICLES MODELS OF THE 4R100 THAT ARE ADDED TO THE FQR (FORD QUALITY RENEWAL) ASSEMBLY PROGRAM.

SOME VEHICLES MAY EXHIBIT A FRONT WASHER OPERATING WITHOUT COMMAND.

INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA.

SOME 4X4 VEHICLES BUILT WITH CENTER DISCONNECT FRONT AXLES MAY EXHIBIT A MOANING NOISE FROM THE FRONT DIFFERENTIAL WHILE OPERATING IN 4X2 MODE.

INFORMATION ON PROGRAMMING / DIAGNOSING ANY PASSIVE ANTI-THEFT SYSTEM (PATS) RELATED ISSUES.

CONCERNS WITH TICKING NOISE ON INITIAL COLD START-UP IN PARK AND NEUTRAL POSITION.

INFORMATION REGARDING PROGRAMMING / DIAGNOSING PASSIVE ANTI-THEFT SYSTEM (PATS) RELATED ISSUES.

SOME CUSTOMER MAY COMPLAIN OF A TICKING NOISE ON INITIAL COLD START-UP IN PARK POSITION AND NEUTRAL POSITION.

EXPERIENCING A CLUNKING NOISE WHILE TURNING.

SOME VEHICLES EXHIBITING INACCURATE COMPASS READINGS.

INFORMATION ON ADDING OR INSTALLING A PULLEY.

CONCERNS WITH AXLE WIND-UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS.

THIS BULLETIN PROVIDES A HOTLINE NUMBER TO REPORT CONCERNS WITH CERTAIN VEHICLES.

SOME 1997-1998 EXPLORER/MOUNTAINEER/EXPEDITION OR NAVIGATOR VEHICLES WITH 4-WD 4X4 SYSTEM MAY EXHIBIT BOTH

INFORMATION ON PROCEDURES TO FOLLOW WHEN INSTALLING A REAR WIPER ARM.

VIBRATION AT CRUISE OVER 50 MPH.

ADDRESSING CONCERNS OF A LOW SPEED (UNDER 35 MPH) CLICKING NOISE CAUSED BY A CAGE NUT ROCKING ON THE COTTER PIN FOR THE FRONT AXLE HALF SHAFT SPINDLE.

EXHIBITING A VIBRATION THAT MAY BE INTERPRETED AS AN NVH CONDITION.

CONCERNS WITH FRONT DIFFERENTIAL NOISE.

EXPERIENCING FRONT DIFFERENTIAL NOISE.

INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS.

VEHICLES MAY EXHIBIT A HIGH SPEED DRIVELINE VIBRATION.

INFORMATION ON REPLACING MULTIFUNCTION SWITCH.

INFORMATION REGARDING REPLACEMENT AND / OR REPAIRS ON ANY LOCK COMPONENT.

ISSUES REGAREDING DIAGNOSTIC TROUBLE CODES ( DTCS ) P0705, P0708, P1704, AND / OR P1705 MAY BE STORED IN MEMORY.

CONCERNS WITH THE POWER SEAT CONTROL BUTTON ( KNOB ) MAY DETACH FROM THE SWITCH ACTUATOR.

WHEN INSTALLING A REAR WIPER ARM ON SOME VEHICLES, BE SURE TO FOLLOW THE PROCEDURE IN THE 1999 WORKSHOP MANUAL SECTION 501-16-92.

SOME VEHICLES MAY EXHIBIT A LOW SPEED ( UNDER 35MPH ) CLICKING NOISE.

VEHICLES WITH THE E4OD ARE ADDED TO THE FQR ( FORD QUALITY RENEWAL ) ASSEMBLY PROGRAM.

BRIEF INFORMATION GIVING THE CORRECT PART NUMBER FOR TSB 98-3-12.

ANY VEHICLE CONCERNS CALL THE JOB 1 HOTLINE AT 1-800-322-JOB1 (5621).

EXPERIENCING VIBRATION AT CRUISE OVER 50 MPH.

SUBJECT REGARDING COLD AIR FELT ON THE FLOOR WHILE IN HEAT MODE.

SOME DIFFICULTY IN MATCHING THE TEXTURE OF THE OEM ANTI-CHIP STONE ABRASION MATERIAL TO RPAIR MATERIALS WHEN SERVICING.

SOME COMPONENTS OF THE FRAME MAY REQUIRE SERVICING DUE TO COLLISION DAMAGE.

REPAIRS TO VINYL COVERED SURFACES.

NEW VOLUME CONTROL/ON-OFF SWITCH.

REAR AXLE NOISE REPAIR.

REAR AXLE NOISE REPAIR.

BRAKE SHIFT INTERLOCK.*JB

INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS.

EXHIBITING AN UNCOMMANDED SHIFT WHEEL LOW DURING LOW SPEED MANEUVERING.

SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM.

ALL 4X4 VEHICLES WITH ELECTRONIC SHIFT ONTHE FLY TRANSFER CASES WILL DISPLAY CONTACT PLATE PIDS OPPOSITE OF THE 1999 OR...

WHEN DIAGNOSING CRANK / NO START ON CERTAIN VEHICLES EQUIPPED WITH PASSIVE ANTI-THEFT (PATS) CHECK THE CUSTOMERS KEY...

FOR CERTAIN MODEL VEHICLES, THE 4R70W TRANSMISSION SOLENOID MOLDED LEADFRAME MUST BE REPLACED WHEN REMOVED.

VEHICLES MAY EXPERIENCE SOLID PARTICLE CONTAMINANTS FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR, MAY BE TRAPPED IN...

VEHICLES MAY EXPERIENCE PARTICLE CONTAMINANTS, FROM PRIOR TRANSMISSIION CONCERNS OR EXCESS WEAR, MAY BE TRAPPED IN THE...

INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP.

INFORMATION REGARDING E40D/4R100 TRANSMISSION FLUID COOLER FLOW TEST SPECIFICATION.

INFORMATION REGARDING TRANSMISSION TROUBLE CODES.

SUBJECT REGARDING E40D / 4R100 TRANSMISSION FLUID COOLER FLOW TEST SPECIFICATION.

THE 4R100 TRANSMISSION WILL HAVE AN ORANGE "PRIOR TO REPAIR" TAG ON THE FLUID PAN.

INFORMATION ON THE NEW 4R100 TRANSMISSION.

CONCERNS WITH CODES P0500, P0503, P1501 OR P1503 WHICH MAY BE CAUSED MY A LOOSE SPEEDOMETER DRIVE GEAR.

INFORMATION REGARDING NEW SERVICE STEERING GEAR.

CONCERNS WITH TRANSMISSION FLUID LEAKING AT THE RADIATOR.

CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK.

SERVICE PROCEDURE FOR ORANGE SERVICE TAGGED TRANSMISSIONS.

SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62,...

CONCERNS WITH TRANSMISSION FLUID LEAKING AT RADIATOR.

A " TICKING " NOISE ON INITIAL STARTUP WITH SHIFT SELECTOR IN " P " OR " N " POSITION MAY OCCUR ON SOME VEHICLES.

SERVICE PROCEDURE FOR ORANGE SERVICE TAGGED TRANSMISSIONS.

SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62,628, AND/OR 1728.

THE 4R70W TRANSMISSION INSTALLED IN SOME VEHICLES WILL HAVE AN ORANGE

A NEW DESIGN TRANSMISSION CASE AND EXTENSION HOUSING HAS BEEN RELEASED.

LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK.

NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS.

CONCERNS WITH SPEED BODY BOOM.

INFORMATION REGARDING POP/THUMP NOISE FROM POWER WINDOW.

CONCERNS WITH THE SIGNAL MIRROR REFLECTIVE SURFACE DETERIORATING OVER TIME, DEVELOPING DARK SPOTS DUE TO CHROME PLATING DELAMINATION.

CONCERNS WITH VEHICLES EXHIBITING A WINDSHIELD CREAK / SQUEAK.

EXHIBITING JERKY OR UNEVEN WINDSHIELD WIPER ARM MOVEMENT.

EXPERIENCING WINDNOISE AT THE TOP OF THE DOOR GLASS SEAL / WEATHERSTRIP MOLDING AREA.

THIS ONLINE SERVICE BULLETIN INVOLVES VEHICLES EXHIBITING WINDNOISE AT THE TOP OF THE DOOR GLASS SEAL / WEATHERSTRIP MOLDING AREA.

SOME VEHICLES MAY EXHIBIT VIBRATION, SHIMMY AND BODY BOOM AT SPEEDS ABOVE 72 KM/H (45 MPH).

SOME VEHICLES MAY EXPERIENCE AN AUDIBLE 50 HZ BODY BOOM.

CONDITIONS ON BROKENT DOOR PULL HANDLES.

INFORMATION ON USING 1999 PROCEDURES MANUAL FOR SIDE MIRROR REPLACEMENT.

SUBJECT REGARDING THE REAR DOOR POWER WINDOW SWITCH BEZEL.

SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP.

CONCERNS WITH THE POTENTIAL EFFECTS OF ADHESIVES USED FOR BODY PANEL REPAIRS.

CONCERNS WITH ADHENSIVES NOT RECOMMENDED FOR BODY PANEL REPAIRS.

SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF,...

A NEW SILICONE GASKET AND SEALANT.

SERVICE TIPS FOR SURFACE DEFECT REMOVAL WITHOUT REPAINTING.

POP/THUMP NOISE AT END OF WINDOW MOVEMENT AND/OR DRIVER'S WINDOW BOUNCE BACK AND REVERSE TO MID-POSITION.

INFORMATION REGARDING DISCHARGED BATTERY CHARGING SERVICE TIPS AND GUIDELINES.

FOR ALL VEHICLES WITH GENERIC ELECTRONIC MODULE (GEM) CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST...

SUBJECT REGARDING THE NAGATIVE BATTERY TERMINAL COVER ON SOME VEHICLES.

SOME VEHICLES EQUIPPED WITH PATS (SECURILOCK) EXCEPT CERTAIN MODELS NOW HAVE AVAILABILITY OF FLEET KEYS THROUGH ROTUNDA.

THIS BULLETINS STATES THAT THE WIRING SCHEMATIC FOR THE HEATED SEATS WAS INADVERTENTLY OMITTED FROM THE ELECTRICAL...

SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO DIAGNOSTIC...

THIS BULLETIN MENTIONS THE WIRING SCHEMATIC FOR VEHICLES WITH HEATED SEATS WAS INADVERTENTLY OMITTED FROM THE ELECTRICAL...

INFORMATION ON REPLACING AND REMOVING THE GENERIC ELECTRONIC MODULE (GEM).

INFORMATION ON REMOVING AND / OR REPLACING THE GENERIC ELECTRONIC MODULE (GEM).

INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS.

SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES.

EXHIBITING MALFUNCTION INDICATOR LAMP (MIL) WITH DIAGNOSTIC TROUBLE CODES (DTC(S) PO351 AND / OR P0356 (COIL PRIMARY CIRCUIT MALFUNCTION).

INFORMATION ON SETTING COMPASS MODULE AT PRE-DELIVERY.

INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS).

GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES.

GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES.

COURTESY RAIL LAMPS DO NOT OPERATE CORRECTLY OR CAUSE A BATTERY DRAW.

SOME VEHICLES MAY EXHIBIT WHEELS THAT SEIZE TO THE HUBS AND ARE DIFFICULT TO REMOVE DURING SERVICE.

SOME VEHICLES WITH AIR SUSPENSION MAY EXHIBIT AN INITIAL OR REPEAT COMPRESSOR DRYER FAILURE.

SOME VEHICLES EQUIPPED WITH AIR SUSPENSION MAY EXHIBIT AN AIR LEAK AND/OR OVERNIGHT BLEED DOWN OF THE AIR SUSPENSION.

SOME VEHICLES MAY EXHIBIT AIR SUSPENSION MALFUNCTION.

SUBJECT REGARDING AIR SUSPENSION COMPRESSOR QUALITY.

SOME VEHICLES MAY EXHIBIT A CHECK SUSPENSION LAMP ON WITH DIAGNOSTIC TROUBLE CODES B2140 OR C2140 EVEN AFTER THE AIR...

SUBJECT PERTAINING TO AIR SUSPENSION LEAKS.

A CLUNKING NOISE HEARD FROM FRONT ENDCAUSED BY FRONT STABILIZER BAR CONTACTING THE FRAME.

SOME VEHICLES EQUIPPED WITH FOUR WHEEL AIR SUSPENSION MAY REQUIRE A RIDE HEIGHT ADJUSTMENT PROCEDURE BE PERFORMED BEFORE SETTING ALIGNMENT.

SUBJECT REGARDING VEHICLES WITH FOUR WHEEL AIR SUSPENSION MAY REQUIRE A RIDE HEIGHT ADJUSTMENT PROCEDURE PERFORMED BEFORE SETTING ALIGNMENT.

THIS BULLETIN MENTIONS HOW SOME HUB O-RINGS MAY BE CUT DURING THE INSTALLATION OF THE WHEELS.

SOME VEHICLES EQUIPPED WITH AIR SUSPENSION MAY EXHIBIT AN INTERMITTENT CHECK SUSPENSION LAMP ON AND DIAGNOSTIC TROUBLE...

IF YOU ENCOUNTER A VEHICLE WITH A MISSING WHEEL HUB O-RING, DO NOT INSTALL A NEW O-RING.

AIR SUSPENSION COMPRESSOR NOISE.

REPEAT AIR SUSPENSION COMPRESSOR DRIER FAILURES.

REPEAT AIR SUSPENSION COMPRESSOR DRIER FAILURES.

SOME VEHICLES MAY EXHIBIT AMBER ANTI-LOCK BRAKE SYSTEM (ABS) LAMP ON WITH UNDEFINED DIAGNOSTIC TROUBLE CODES (DTCS) STORED.

FOR ALL VEHICLES WITH ANTILOCK BRAKE MODULE CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR...

SUBJECT REGARDING A MISSING RUBBER STOP BUMPER FROM THE PARKING BRAKE COTNROL.

ON SOME VEHICLES, THE RUBBER STOP BUMPER MAY BE MISSING FROM THE PARKING BRAKE CONTROL, A REPLACEMENT SERVICE PART IS NOW AVAILABLE.

INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT.

A SQUEAKING NOISE FROM THE REAR WHILE LIGHTLY BRAKING FROM 64-32 KM/H (40-20 MPH) MAY OCCUR ON SOME VEHICLES.

SOME VEHICLES MAY EXHIBIT AN ANTI-LOCK BRAKE SYSTEM (ABS) INDICATOR LAMP ON WITH NO DIAGNOSTIC TROUBLE CODES (DTC) DETECTED.

SOME VHICLES MAY EXHIBIT AN ANTI-LOCK BRAKE SYSTEM (ABS) INDICATOR LAMP WITH NO DIAGNOSTIC TROUBLE CODES (DTC).

VEHICLES MAY EXHIBIT AN ANTI-LOCK BRAKE SYSTEM (ABS) INDICATOR LAMP WITH NO DIAGNOSTIC TROUBLE CODE (DTC) DETECTED.

SUBJECT REGARDING ANTI-LOCK BRAKE LAMP ILLUMINATION, INCREASED BREAK PEDAL EFFORT AND / OR FALSE ANTI-LOCK BRAKE SYSTEM (ABS) CYCLING AT LOW SPEEDS.

SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT.

VEHICLES EXPERIENCING INCREASED BRAKE PEDAL EFFORT AND / OR FALSE ABS CYCLING AT LOW SPEEDS, OR ABS LAMP ILLUMINATION.

A NEW PARKING BRAKE CONTROL RUBBER BUMPER STOP IS NOW AVAILABLE FOR SERVICE.

AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT.

HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE.

SOME VEHICLES MAY EXHIBIT A SLOW FUEL FILL CONDITION AND/OR PREMATURE SHUTOFF OF THE GAS PUMP WHEN THE VEHICLE IS BEING REFUELED.

SOME VEHICLES MAY EXHIBIT A SLOW FUEL FILL CONDITION AND/OR PREMATURE SHUTOFF OF THE GAS PUMP WHEN THE VEHICLE IS BEING RE-FUELED.

SOME VEHICLES MAY EXHIBIT MALFUNCTION INDICATOR LIGHT ON WITH EVAPORATIVE DIAGNOSTIC TROUBLE CODES P0442, P0455 SET.

SOME VEHICLES MAY EXHIBIT A SLOW FUEL FILL CONDITION.

VEHIUCLES WITH 4.0L OHV/SOHC, 5.0L, 4.6L, 5.4L MAY EXHIBIT A MALFUNCTION INDICATOR LAMP ON WITH EVAP SYSTEM DIAGNOSTIC...

A DIRECT REPLACEMENT PART FOR THE EVAPORATIVE EMISSION CANISTER AND BRACKET ASSEMBLY.

MIL LIGHT ON WITH EVAPORATIVE DTC P0442, P0455

EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP.

EXPERIENCING DIFFICULTY DIAGNOSING VEHICLES WITH EVAPORATIVE FUEL SYSTEM DIAGNOSTIC TROUBLE CODES.

FUEL PUMP REPLACEMENT PROCEDURE - SERVICE TIP.

EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM.

MALFUNCTION INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0442, P0455, P0456, P0457 OR P1442 OR A...

MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK...

SOME 4X2 VEHICLES EQUIPPED WITH P275/60/R17 CONTINENTAL-GENERAL TIRES MAY EXHIBIT A HIGHWAY SPEED TIRE VIBRATION.

SOME 4X2 VEHICLES EQUIPPED WITH P275/60/R17 CONTINENTAL GENERAL TIRES MAY EXHIBIT A HIGHWAY SPEED TIRE VIBRATION.

SOME VEHICLES MAY EXHIBIT A DIFFICULT TO REMOVE WHEEL RIM CONDITION.

CONTINENTAL GENERAL TIRE COMPANY ANNOUNCED A CUSTOMER SATISFACTION PROGRAM ON 16-INCH P245 / 75 R16 CONTITRAC AS TIRES.

SAFETY RECALL UPDATE TO REPLACE LOCKING LUG NUTS.

SOME VEHICLES MAY EXHIBIT LOOSE LUGNUTS AND / OR BROKEN WHEEL STUDS.

SOME VEHICLES MAY EXPERIENCE AXLE WIND UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING...

INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE.

SUBJECT REGARDING INOPERATIVE RUNNING BOARD LIGHTS.*YD

SOME FACTURY INSTALLED CD CHANGERS MAY HAVE REVISED SHIPPING LOCATIONS FOR THE CD MAGAZINE.

INFORMATION ON VEHICLES EXHIBITING AND O/D OFF LAMP FLASHING WITH DIAGNOSTIC TROUBLE CODE 62 / 628 / 1728.

SUBJECT ON THE MALFUNCTION INDICATOR LAMP (MIL) MAY ILLUMINATE AND DIAGNOSTIC TROUBLE CODES MAY APPEAR.

INFORMATION ON DIAGNOSING A VEHICLE WITH MALFUNCTION INDICATOR LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODES P0442 AND...

SUBJECT REGARDING VEHICLES WITH FACTORY INSTALLED CD CHANGERS HAVING REVISED SHIPPING LOCATIONS FOR THE CD MAGAZINE.

THE MALFUCNTION INDICATOR LAMP ( MIL ) MAY ILLUMINATE AND DIAGNOSTIC TROUBLE CODE (DTC) P0455 MAY BE STORED IN MEMORY.

THE MALFUNCTION INDICATOR LAMP (MIL) MAY ILLUMINATE AND DIAGNOSTIC TROUBLE CODE (DTC) P0503 MAY BE STORED IN MEMORY.

SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS.

INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS.

SERVICE INFORMATION FOR MUSTY AND MILDEW TYPE ODORS COMING FROM THE AIR CONDITIONING / HEATING SYSTEM.

SOME VEHICLES MAY EXHIBIT A WHISTLING NOISE WHILE DRIVING WITH A/C IN THE OFF POSITION AT SPEEDS ABOVE 64 KM/H (40 MPH).

EXPERIENCING NO OR INTERMITTENT AUXILLARY A/C MODE / BLOWER CONTROL ON SOME VEHICLES.

CLIMATE CONTROL A/C SERVICE TECH TIPS.

SOME VEHICLES EQUIPPED WITH 4 WHEEL DRIVE MAY EXHIBIT A NOTCHY OR STICKING FEELING IN SLOW SPEED TURNS WITH NO EFFECT ON...

CUSTOMER MAINTENANCE REMINDER - LITERATURE PROGRAM 04L19 - TIE ROD INSPECTION PROCEDURE.

TIE ROD END INSPECTION PROCEDURE.

TIE ROD END INSPECTION PROCEDURE.

TIE ROD END INSPECTION PROCEDURE.

EXHIBITING AN INACCURATE COMPASS READINGS IF NOT SET AT PRE-DELIVERY INSPECTION (PDI).

SOME VEHICLES MAY EXHIBIT INACCURATE COMPASS READINGS IF NOT SET AT PRE-DELIVERY INSPECTION (PDI).

SUBJECT REGARDING PASSIVE ANTI THEFT SYSTEM (PATS) DIAGNOSTIC SERVICE TIPS.

DIAGNOSTIC SERVICE TIPS ON PASSIVE ANTI THEFT SYSTEM ( PATS ).

REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS.

EXHIBITING AN AIR BAG LAMP ON INTERMITTENTLY WITH LAMP FAULT CODE (LFC) 24, OR DIAGNOSTIC TROUBLE CODE B1924 AND / OR B1342 STORED IN MEMORY.

SOME VEHICLES MAY EXHIBIT AN AIR BAG LIGHT ON INTERMITTENTLY WITH DIAGNOSTIC TROUBLE CODE B1924.

VEHICLES EXHIBITING INTERMITTENT ILLUMINATION OF AIR BAG LIGHT WITH DIAGNOSTIC TROUBLE CODE B1924.

INFORMATION ON REMOVING THE RADIO CHASSIS FROM SOME VEHICLES.

VEHICLES WITH PREMIUM RADIOS WILL BE EQUIPPED WITH VOLUME CONTROL/ON-OFF SWITCH.