2004 Lincoln LS TSBs
68 Technical Service Bulletins across 13 categories
Categories
Engine
12 bulletinsFORD/LINCOLN/MERCURY: MAY HAVE SLUDGE BUILDUP IN THROTTLE BODY LEADING TO LESS AIRFLOW OR ENGINE IDLING RPM...
Read full bulletin
FLUCTUATION AND HARD STARTS OR BATTERY DISCONNECT OR DEAD BATTERY AFTER KEEP ALIVE MEMORY (KAM) CLEAR. MODELS 2003-05 THUNDERBIRD, 05-06 MUSTANG, 06-08 FUSION, 04-05 EXPLORER, 05-06 EXPEDITION, 05-07 F-150; 2003-06 LS, 06 ZEPHYR, 05-06 NAVIGATOR; 06-08 MILAN. *PE
FORD/LINCOLN MERCURY: CERTAIN 2003-2005 MODEL YEAR LINCOLN LS AND FORD THUNDERBIRD VEHICLES EQUIPPED WITH 3.9L ENGINE...
Read full bulletin
WITH EXTENDED WARRANTY COVERAGE ON IGNITION COIL ASSEMBLIES AND ON 2003 MY VEHICLES ONLY , ENGINE VALVE COVER GASKETS. *PE
LINCOLN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER.
Read full bulletin
CERTAIN 2003-2005 LINCOLN LS VEHICLES EQUIPPED WITH DURATEC 3.0L 4V ENGINE. PCV HOSE ASSEMBLY REPLACEMENT. CSC WAS RECEIVED. *PE
WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING.
Read full bulletin
*TT
WATER/MOISTURE IN COP WELLS - DTC P0301-P0308 - 3.9L ENGINE - VEHICLES BUILT THROUGH 5/1/2004.
Read full bulletin
*TT
UNUSUAL ENGINE NOISE OR ENGINE KNOCK CONCERNS DUE TO REGULAR FUEL.
Read full bulletin
*TT
NO START, ROUGH IDLE, OR MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0171, P0174, P0173,...
Read full bulletin
P2195, P2197, P0420, P0301, P0302, P0303, P0304, P0305, P0306. *TT
ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS.
Read full bulletin
TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04.
HARSH 2-3 UPSHIFT ON VEHICLES EQUIPPED WITH A 3.0L ENGINE AND 5R55S AUTOMATIC TRANSMISSION.
Read full bulletin
*TT
HIGH AND/OR ROLLING IDLE AT LOW MILEAGE.
Read full bulletin
*TT
ELECTRONIC THROTTLE CONTROL (ETC) WARNING LAMP ON OR ETC ENGINE FAILSAFE MODE MESSAGE DISPLAYED WITH MULTIPLE...
Read full bulletin
DRIVEABILITY SYMPTOMS AND DIAGNOSTIC TROUBLE CODES (DTCS). *TT
HIGH AND/OR ROLLING IDLE AT LOW MILEAGE.
Read full bulletin
*TT
Electrical
11 bulletinsEXCESSIVE ELECTRICAL SYSTEM CURRENT DRAW WHICH COULD RESULT IN A DISCHARGED BATTERY AND A NO CRANK CONDITION.
Read full bulletin
*TT SERVICE TIPS. *TT
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs).
Read full bulletin
The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate when reading these PIDs and cannot display quickly enough to validate a concern. The PCM automatically monitors these inputs more accurately and will set diagnostic trouble codes (DTCs) when appropriate. Using these PIDs for diagnostics will lead to inaccurate results and improper ETB replacements. If a concern is intermittent and no DTCs are present, refer to historical DTCs and the PC/ED, Section 3 No DTCs Present Index chart for further information.
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES.
Read full bulletin
*TT
GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES.
Read full bulletin
*TT
MAF DIAGNOSTIC SERVICE TIP - VEHICLES EQUIPPED WITH EGR SYSTEM MODULE (ESM).
Read full bulletin
*TT
KEY-IN-IGNITION WARNING CHIME SOUND WHENEVER THE DRIVER'S DOOR IS OPEN (EVEN WITH NO KEY IN THE IGNITION), THE EASY EXIT...
Read full bulletin
FEATURE INOPERATIVE WHEN THE KEY IS REMOVED FROM THE IGNITION, OR THE STEERING COLUMN (AND SEAT IF APPLICABLE) MOVING BACK AND FORTH WHEN THE KEY IS REMOVED FROM THE IGNITION ON VEHICLES WITH A FORD ACCESSORY REMOTE START KIT. *TT
DIAGNOSTIC TROUBLE CODE (DTC) P2106 STORED IN THE PCM (POWERTRAIN CONTROL MODULE).
Read full bulletin
*TT
DIAGNOSTIC TROUBLE CODE (DTC) U0300 (INTERNAL CONTROL MODULE SOFTWARE INCOMPATIBILITY) STORED IN THE PCM WITH NO OTHER DTC'S PRESENT.
Read full bulletin
*TT
AN INTERMITTENT MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODE (DTC) P0462 (FUEL LEVEL SENSOR A...
Read full bulletin
CIRCUIT LOW) OR P2067 (FUEL LEVEL SENSOR B CIRCUIT LOW) CAUSED BY AN IMPROPERLY INSTALLED REMOTE START SYSTEM. *TT
MALFUNCTION INDICATOR LAMP (MIL) ON WITH IGNITION COIL RELATED DIAGNOSTIC TROUBLE CODES (P035X).
Read full bulletin
*TT
ELECTRICAL FEATURE ENABLE/DISABLE - SERVICE TIP.
Read full bulletin
*TT
Other
10 bulletinsPARKING AID SYSTEM IS INOPERATIVE - DTC C1983.
Read full bulletin
*KB
PARKING AID SYSTEM INOPERATIVE - DTC C1983.
Read full bulletin
*KB
PARKING AID SYSTEM INOPERATIVE.
Read full bulletin
*AK
INTERMITTENT STUMBLE ON RAPID TIP-IN FROM STEADY SPEED, GENERALLY BETWEEN 20-50 MPH (32-80 KM/H) ACCOMPANIED BY A INDUCTIVE BACKFIRE AFTER THE TIP-IN.
Read full bulletin
*TT
CUSTOMER SATISFACTION PROGRAM 04B20.
Read full bulletin
REAR SEAT LATCHES AND OWNER GUIDE LABEL FOR VEHICLES THAT MAY HAVE A REAR SEAT LATCH THAT IS DIFFICULT TO LATCH AND SUPPLEMENTAL LATCH VERIFICATION INSTRUCTION LABEL WHICH SHOULD BE AFFIXED TO THE OWNER GUIDE. *TT
VIBRATION FELT FOR A FEW MILES OF DRIVING AFTER PARKING.
Read full bulletin
*EH
SAFETY BELT RETRACTION SPEED.
Read full bulletin
*TT
AM FM AND CELLULAR PHONE RECEPTION INTERFERENCE .
Read full bulletin
*EH
CUSTOMER SATISFACTION PROGRAM 04B21.
Read full bulletin
WATER PUMP HOSE REPLACEMENT. THE WATER PUMP HOSE MAY HAVE BEEN MANUFACTURED WITH AN INCORRECT NUMBER OF WOVEN REINFORCEMENT LOOPS, POTENTIALLY CAUSING THE HOSE TO BURST AT LOW MILEAGE, CAUSING A LOSS OF COOLANT. *TT
DIAGNOSTIC TROUBLE CODE (DTC) P0300-P0308 OR P0350-P0358.
Read full bulletin
*TT
Body & Paint
7 bulletinsThis article supersedes TSB 19-2026 to update the vehicle model years affected.
Read full bulletin
Some 2000 and newer Ford/Lincoln/Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended.
Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns...
Read full bulletin
appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Follow the Service Procedure steps to correct the condition
Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns...
Read full bulletin
appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Follow the Service Procedure steps to correct the condition
ALUMINUM CORROSION - SERVICE TIP.
Read full bulletin
*TT
UNINTENDED OPENING OF THE SIDE DOOR WINDOW GLASS AND MOONROOF WHILE VEHICLE IS PARKED (FALSE GLOBAL OPEN).
Read full bulletin
*TT
UNINTENDED OPENING OF THE SIDE DOOR WINDOW GLASS AND MOONROOF WHILE VEHICLE IS PARKED.
Read full bulletin
*TT
FRONT SEATBACK TRIM PANEL J-HOOK FAILURE IN HIGH AMBIENT TEMPERATURES.
Read full bulletin
*MJ
Lighting
6 bulletinsDAY TIME RUNNING LAMPS.
Read full bulletin
*EH
MALFUNCTION INDICATOR LAMP (MIL) AND ELECTRONIC THROTTLE CONTROL (ETC) LAMPS ON WITH BOTH DIAGNOSTIC TROUBLE CODE (DTC) P2106 AND P2135.
Read full bulletin
*TT
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS.
Read full bulletin
VARIOUS MODELS INCLUDING 2004 F-SERIES. *TT
MOSITURE IN REVERSE LAMP.
Read full bulletin
*TT
ELECTTRONIC THROTTLE CONTROL WARNING MESSAGE OR LAMP ON - MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE...
Read full bulletin
CODE (DTC) P2106 - POSSIBLE DRIVEABILITY SYMPTOMS. *TT
HEADLINER DROPPING DOWN OR BECOMING UNATTACHED AT THE REAR OF THE VEHICLE NEAR THE CENTER HIGH MOUNT STOP LAMP (CHMSL).
Read full bulletin
*TT
Transmission
5 bulletinsDELAYED OR HARSH REVERSE ENGAGEMENTS - 5R55S TRANSMISSION - VEHICLES BUILT PRIOR TO 09/23/2004.
Read full bulletin
*TT
IMPROPERLY FORMULATED TRANSMISSION FLUID THAT, OVER TIME, MAY CAUSE DELAYED/HARSH REVERSE ENGAGEMENTS.
Read full bulletin
CUSTOMER SATISFACTION PROGRAM 04B22. 5R55S/E & 5R44E TRANSMISSION FLUID ADDITIVE. *TT SUPPLEMENT #1. *TT SUPPLEMENT #2. *TT SUPPLEMENT #3. *TT
STEERING GEAR SQUEAK WHEN TURNING THE STEERING WHEEL, ESPECIALLY DURING LOW SPEED PARKING MANEUVERS.
Read full bulletin
*TT
MALFUNCTION INDICATOR LAMP (MIL) ON, E DISPLAYED FOR GEAR POSITION, HARSH SHIFTS, AND DIAGNOSTIC TROUBLE CODES (DTCS)...
Read full bulletin
P0705 AND P1702 AFTER POWERTRAIN CONTROL MODULE (PCM) REPROGRAMMING. *TT
STEERING GEAR NOISE. *TT
Brakes
5 bulletinsDIAGNOSTIC TROUBLE CODE (DTC) C1145 AND/OR C1155 STORED IN ANTI-LOCK BRAKE SYSTEM (ABS) MODULE.
Read full bulletin
*TT
ABS WARNING INDICATOR ON WITH DIAGNOSTIC TROUBLE CODE C1145 AND/OR C1155.
Read full bulletin
*TT
SERVICE PARK BRAKE MESSAGE WITH DIAGNOSTIC TROUBLE CODE (DTC) B2477 IN THE ELCTRONIC PARK BRAKE MODULE.
Read full bulletin
*TT
PARKING BRAKE WARNING MESSAGE AND DIAGNOSTIC TROUBLE CODE (DTC) U1040.
Read full bulletin
*TT
KEYLESS ENTRY KEYPAD INOPERATIVE.
Read full bulletin
*TT
Fuel System
3 bulletinsREAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR.
Read full bulletin
*TT
REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR.
Read full bulletin
*TT
INOPERATIVE ELECTRIC REAR WINDOW DEFROSTER (HEATED BACKLITE) GRID LINES, INTEGRAL ANTENNA CONCERNS.
Read full bulletin
*TT
Pre-Delivery & Maintenance
3 bulletinsAM/FM AND CELLULAR PHONE RECEPTION INTERFERENCE - SERVICE TIP.
Read full bulletin
*TT
SAFETY BELT WEB STOP BUTTON SERVICE.
Read full bulletin
*EH
REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS.
Read full bulletin
*TT
HVAC & Climate
2 bulletinsCLIMATE CONTROLLED SEATS TURNING OFF SHORTLY AFTER INITIALIZATION - DIAGNOSTIC TROUBLE CODES B2729, B2730, B2731.
Read full bulletin
*TT
SQUEAKING NOISE WHEN SWITCHING CLIMATE CONTROL BETWEEN PANEL, FLOOR AND PANEL/FLOOR MODES.
Read full bulletin
*TT
Tires & Wheels
2 bulletinsP225/55R16 CONTINENTAL TIRES MAY EXHIBIT EXCESSIVE TIRE CUPPING/FEATHER EDGE WEAR AT LOW TIRE MILEAGE (UNDER 24,000 MILES/39,000 KM).
Read full bulletin
OASIS. *TT
16-INCH CONTINENTAL TIRES MAY EXHIBIT TIRE VIBRATION CAUSED BY FLAT SPOTTING.
Read full bulletin
*TT
Infotainment
1 bulletinPOPPING OR QUAVERING FROM RADIO ON THE AM BAND.
Read full bulletin
*TT
Software & Calibration
1 bulletinNGS SERVICE CARD VERSION 11.0 OR HIGHER MUST BE USED FOR ADVANCETRAC (IVD) CALIBRATION.
Read full bulletin
*TT