2005 Lincoln Aviator TSBs
29 Technical Service Bulletins across 10 categories
Categories
Electrical
6 bulletinsThe Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs).
Read full bulletin
The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate when reading these PIDs and cannot display quickly enough to validate a concern. The PCM automatically monitors these inputs more accurately and will set diagnostic trouble codes (DTCs) when appropriate. Using these PIDs for diagnostics will lead to inaccurate results and improper ETB replacements. If a concern is intermittent and no DTCs are present, refer to historical DTCs and the PC/ED, Section 3 No DTCs Present Index chart for further information.
LOW TIRE INDICATOR ON - TPMS SYSTEM SENSOR WAKE UP.
Read full bulletin
*TT
MALFUNCTION INDICATOR LAMP ON WITH PCM DIAGNOSTIC TROUBLE CODE P0463 AND/OR IC DIAGNOSTIC TROUBLE CODE B1201 - FUEL...
Read full bulletin
GAUGE DROPS TO EMPTY OR SLOW TO UPDATE AFTER REFUELING. *TT
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES.
Read full bulletin
*TT
GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES.
Read full bulletin
*TT
MAF DIAGNOSTIC SERVICE TIP - VEHICLES EQUIPPED WITH EGR SYSTEM MODULE (ESM).
Read full bulletin
*TT
Body & Paint
6 bulletinsFORD: SOME VEHICLES MAY EXHIBIT OIL SEPARATION FROM THE INTERNAL LUBE FOUND IN THE UNITIZED CARTRIDGE SEAL.
Read full bulletin
OIL SEPARATION APPEARS TO BE AND IS OFTEN MISDIAGNOSED, AS AN AXLE LUBE LEAK. *PE
DRIVER WINDOW INITIALIZATION PROCEDURE.
Read full bulletin
DRIVER WINDOW WILL NOT TRAVEL ALL THE WAY DOWN, OR MAY BOUNCE BACK WHEN REACHING IT'S UPPER TRAVEL LIMIT. *TT
BACKGLASS DIFFICULT TO CLOSE AND AN INTERMITTENT DOOR AJAR LAMP.
Read full bulletin
*TT
AXLE SEAL LEAKS. *EH
AXLE SEAL LEAKS. LEAKS FROM REAR HALFSHAFT AXLE SEAL.
Read full bulletin
SERVICE TIPS. *TT
LIFTGATE GLASS APPLIQUE DAMAGED/CRACKED.
Read full bulletin
SERVICE PROCEDURE. *TT
Other
6 bulletinsA TINY CRACK, OR CRACKS, AROUND THE TRANSFER CASE DRAIN PLUG HOLE.
Read full bulletin
*TT
REAR AXLE NOISE REPAIR.
Read full bulletin
*TT
WELD BONDING PROCEDURE.
Read full bulletin
*TT
SAFETY BELT RETRACTION SPEED.
Read full bulletin
*TT
DRIVELINE 1ST ORDER VIBRATION/BOOM/DRONE.
Read full bulletin
*TT
NO CRANK/NO START CONDITION WHEN VEHICLE TEMPERATURE IS BELOW FREEZING (32F/0C).
Read full bulletin
*TT
Engine
3 bulletinsENGINE MISFIRE WITH DIAGNOSTIC TROUBLE CODE (DTC) PEWEE, P0302, P0303, P0304, P0305, P0306, P0307, P0308, AND P0316.
Read full bulletin
*TT
WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING.
Read full bulletin
*TT
ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS.
Read full bulletin
TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04.
Transmission
2 bulletinsDELAYED OR HARSH REVERSE ENGAGEMENTS - 5R55S TRANSMISSION - VEHICLES BUILT PRIOR TO 09/23/2004.
Read full bulletin
*TT
IMPROPERLY FORMULATED TRANSMISSION FLUID THAT, OVER TIME, MAY CAUSE DELAYED/HARSH REVERSE ENGAGEMENTS.
Read full bulletin
CUSTOMER SATISFACTION PROGRAM 04B22. 5R55S/E & 5R44E TRANSMISSION FLUID ADDITIVE. *TT SUPPLEMENT #1. *TT SUPPLEMENT #2. *TT SUPPLEMENT #3. *TT
Pre-Delivery & Maintenance
2 bulletinsAXLE WHINE HOWL SERVICE WITH INDIVIDUAL PARTS INSTEAD OF AN AXLE ASSEMBLY.
Read full bulletin
*EH
SAFETY BELT WEB STOP BUTTON SERVICE.
Read full bulletin
*EH
Suspension
1 bulletinNOISE FROM REAR WHEEL HUB BEARINGS.
Read full bulletin
*TT
Steering
1 bulletinLOW SPEED STEERING SHUDDER DURING LOW-SPEED TURNING MANEUVERS.
Read full bulletin
*TT
Lighting
1 bulletinFRONT SEAT(S) SLIGHT MOVEMENT WHEN ACCELERATING AND/OR DECELERATING.
Read full bulletin
*TT
Fuel System
1 bulletinREAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR.
Read full bulletin
*TT