2023 Kia Carnival TSBs

conducting an important Product Improvement Campaign to install covers onto the 2nd row seat rails in all 2022-2024 MY Kia Carnival vehicles and certain 2025 MY Carnival vehicles.

the most frequently asked questions regarding the Product Improvement Campaign PI2501.

dealer Parts and Service managers advising that Kia is conducting an important Product Improvement Campaign to install covers onto the 2nd row seat rails in all 2022-2024 MY Kia Carnival vehicles and certain 2025 MY Carnival vehicles manufactured from January 4, 2021 through March 31, 2025.

principals advising that Kia is conducting an important Product Improvement Campaign to install covers onto the 2nd row seat rails in all 2022-2024 MY Kia Carnival vehicles and certain 2025 MY Carnival vehicles manufactured from January 4, 2021 through March 31, 2025.

conducting a Product Improvement Campaign to install steel reinforcement plates on the second-row seat outer rails in certain 2022-2024 MY Kia Carnival vehicles equipped with sliding and removable second-row seats (excluding SX-Prestige equipped with the second-row lounge seats). Customers receiving this letter have already had this product improvement campaign performed. Since then, there have been additional improvements to the mounting bolts used for the installation of the steel reinforcement plates. Kia is requesting that customers contact an authorized Kia dealer to replace the four (4) subject mounting bolts with improved ones.

bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to install steel reinforcement plates on the second-row seat outer rails in certain 2022-2024MY Carnival (KA4) vehicles (excluding SX-Prestige with the second-row lounge seats) produced from January 4, 2021 through August 21, 2023. This campaign is to reinforce the mounting points of the 2nd-row seat to the floor and minimize potential seat rail detachment, should a certain rare crash event occur.

bulletin provides information to install steel reinforcement plates on the second-row seat outer rails in certain 2022-2024MY Carnival (KA4) LX/LXS/EX/SX vehicles (without relaxation/power seat feature) produced from January 4, 2021 through August 9, 2023. This campaign is to reinforce the mounting points of the 2nd-row seat to the floor and minimize potential seat rail detachment, should a certain rare crash event occur.

conducting an important Product Improvement Campaign to install steel reinforcement plates on the second-row seat outer rails in certain 2022-2024 MY Kia Carnival LX/LXS/EX/SX vehicles equipped with sliding and removable second-row seats (excluding SX-Prestige).

frequently asked questions regarding the Product Improvement Campaign (PI2301).

Parts and Service Managers that Kia is conducting an important Product Improvement Campaign to install steel reinforcement plates on the second-row seat outer rails in certain 2022-2024 MY Kia Carnival LX/LXS/EX/SX vehicles equipped with sliding and removable second-row seats (excluding SX-Prestige).

Kia is conducting an important Product Improvement Campaign to install steel reinforcement plates on the second-row seat outer rails in certain 2022-2024 MY Kia Carnival LX/LXS/EX/SX vehicles equipped with sliding and removable second-row seats (excluding SX-Prestige).

New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to replace both the low and high pitch horns on some 2022-2023MY Carnival (KA4) vehicles produced from January 4, 2021 through May 2, 2022, which may exhibit an inoperative low or high pitch horn.

the low and high pitch horns on some 2022-2023MY Carnival (KA4) vehicles produced from January 4, 2021 through May 2, 2022, which may exhibit and inoperative low or high pitch horn. If either horn is inoperative, then follow the procedure outlined in this publication to replace BOTH low and high pitch horns.

revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to update the software on Display Audio 2.0 (D2V) and AVN 5.0 Wide (AVN5W) head units on certain 2022-2023MY Kia vehicles (refer to model list on page 9). The affected vehicles may experience various concerns related to Apple CarPlay/Android Auto phone projection connectivity.

New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to update the software on Display Audio 2.0 (D2V) and AVN 5.0 Wide (AVN5W) head units on certain 2021-2023MY Kia vehicles (refer to pages 5 and 16). The affected vehicles may experience Apple CarPlay/Android Auto phone projection connectivity-related concerns.

New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to update the software on 5th Generation AVN wide on certain 2020-2024MY Kia vehicles (refer to model list on page 8) to remedy a non-responsive or inoperative radio (FM, AM, SXM, etc.) concern. The affected AVN unit on the vehicles may not respond when pressing the RADIO hard key/button on the AVN unit or when selecting the RADIO icon on the AVN menu screen.

software on Display Audio 2.0 (D2V) and 5th Generation AVN Wide (AVN5W) head units on certain 2021-2023MY Kia vehicles. The affected vehicles may experience Apple CarPlay/Android Auto phone projection connectivity-related concerns.

information to update the software on Display Audio 2.0 (D2V) and 5th Generation AVN Wide (AVN5W) head units on certain 2022-2023MY Kia vehicles (refer to model list on page 9). The affected vehicles may experience various concerns related to Apple CarPlay/Android Auto phone projection connectivity.

New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to update the software on 5th Generation AVN wide on certain 2020-2024MY Kia vehicles (refer to model list on page 3) to remedy a 'non-responsive' or 'inoperative' radio (FM, AM, SXM, etc. ) concern. The affected AVN unit on the vehicles may not respond when pressing the 'RADIO' hard key/button on the AVN unit or when selecting the 'RADIO' icon on the AVN menu screen.

information to update the software on 5th Generation AVN wide on certain 2020-2023MY Kia vehicles (refer to model list on page 3) to remedy a warning sound accompanied by a 'Slippery road ahead. Drive carefully' or 'Uneven road ahead. Drive carefully' warning which is displayed on the instrument cluster. The current AVN software causes the warning sound and message to repeat approximately every ten (10) seconds, if the vehicle is not in motion, in 'PARK' or driving on even surfaces.

(refer to model list on page 3) to remedy a 'non-responsive' or 'inoperative' radio (FM, AM, SXM, etc. ) concern. The affected AVN unit on the vehicles may not respond when pressing the 'RADIO' hard key/button on the AVN unit or when selecting the 'RADIO' icon on the AVN menu screen.

update the software on 5th Generation AVN wide on certain 2020-2023MY Kia vehicles to remedy a 'non-responsive' or 'inoperative' radio (FM, AM, SXM, etc.) concern. The affected AVN unit on the vehicles may not respond when pressing the 'RADIO' hard key/button on the AVN unit or when selecting the 'RADIO' icon on the AVN menu screen. Follow the procedure outlined in this publication to update the software on 5th Generation AVN wide units using the applicable USB Flash Drive A or B for the applicable vehicle.

the service reminder lamp, at the first service interval reminder alert that will display on the instrument cluster. The KDS is required to change the setting from "Workshop" to "Customer Mode."

IMPROVEMENT (SC290) - This bulletin provides the procedure to update the software logic of the Engine Control Module (ECM) system on some 2022-2024MY Carnival (KA4) vehicles produced from January 4, 2021 through November 6, 2023. The subject vehicles may have engine calibrations that were not optimized for emissions standards under certain specific conditions, which may cause the vehicle to release air pollution which exceed Federal and California standards. As a result, the subject vehicles may exhibit an illumination of Malfunction Indicator Lamp (MIL) with DTC P00B7.

the dealer Parts and Service Managers that Kia is conducting a Voluntary Emissions Service Campaign on certain 2022-2024 MY Kia Carnival vehicles equipped with Lambda 3.5L engines manufactured from January 4, 2021 to November 6, 2023 to improve the emissions logic in the Electronic Control Module (ECM) to ensure compliance with emissions regulations.

principals that Kia is conducting g a Voluntary Emissions Service Campaign on certain 2022-2024 MY Kia Carnival vehicles equipped with Lambda 3.5L engines manufactured from January 4, 2021 to November 6, 2023 to improve the emissions logic in the Electronic Control Module (ECM) to ensure compliance with emissions regulations.

bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides the procedure to update the software logic of the Engine Control Module (ECM) system on some 2022-2024MY Carnival (KA4) vehicles produced from January 4, 2021 through November 6, 2023, which may exhibit an MIL "ON" with DTC P2118. The throttle body plate may freeze after a cold soak in very cold temperatures, possibly causing the vehicle to go into "limp-home" mode. Once the vehicle is warmed up, the throttle body performs normally.

bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides the procedure to update the software logic of the Engine Control Module (ECM) system on some 2022-2024MY Carnival (KA4) vehicles produced from January 4, 2021 through October 26, 2022, which may exhibit an MIL "ON" with DTC P2118. The throttle body plate may freeze after a cold soak in very cold temperatures, possibly causing the vehicle to go into "limp-home" mode. Once the vehicle is warmed up, the throttle body performs normally.

revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information related to extracting "in use performance tracking" emissions data from the Engine Control Unit (ECU) of certain vehicles sold in California. The California Air Resources Board (CARB) requires the emissions data from vehicles with a minimum of 3,000 accumulated miles without reprogramming or resetting. To facilitate collection of this data at the dealer level, KDS screenshots will allow the capture of relevant parameters.

information to tighten the two (2) ignition ground bracket bolts on certain 2023MY Carnival (KA4) vehicles produced from November 8, 2022 through November 11, 2022, which may not have been properly torqued during assembly and cause the vehicle to exhibit an intermittent engine hesitation and/or poor starting condition.

bulletin provides the procedure to update the software logic of the Engine Control Module (ECM) system on some 2022-2023MY Carnival (KA4) vehicles produced from January 4, 2021 through October 26, 2022, which may exhibit an MIL 'ON' with DTC P2118. The throttle body plate may freeze after a cold soak in very cold temperatures, possibly causing the vehicle to go into 'limp-home' mode. Once the vehicle is warmed up, the throttle body performs normally.

procedure to update the software logic of the Engine Control Module (ECM) on some 2023MY Carnival (KA4) vehicles produced from March 24, 2022 through July 14, 2022, that may experience a temporary, lower than expected engine speed while decelerating or idling, while applying torque converter dampening.

information related to extracting in use performance tracking emissions data from the Engine Control Unit (ECU) of certain vehicles sold in California. The California Air Resources Board (CARB) requires the emissions data from vehicles with a minimum of 3,000 accumulated miles without reprogramming or resetting. To facilitate collection of this data at the dealer level, KDS screenshots will allow the capture of relevant parameters.

owner notification advising Kia's ongoing commitment to providing vehicle owners with a superior ownership experience. We would like to remind vehicle owners about the proper use of the power sliding door and its automatic stop and reversal feature in the Kia Carnival. The power sliding door feature is designed to enhance accessibility and ease of use, but its important to understand its functions and limitations to ensure safe and reliable operation.

owner notification advising Kia's ongoing commitment to providing Kia Carnival vehicle owners with a superior ownership experience. This is reminder about the proper use of the power sliding door and its automatic stop and reversal feature in your Kia Carnival. The power sliding door feature is designed to enhance accessibility and ease of use, but its important to understand its functions and limitations to ensure safe and reliable operation.

notification advising Kia's ongoing to providing you with a superior ownership experience, wed like to remind you about the proper use of the power sliding door and its automatic stop and reversal feature in your Kia Carnival. The power sliding door feature is designed to enhance accessibility and ease of use, but its important to understand its functions and limitations to ensure safe and reliable operation.

provides information to inspect and, if necessary, replace the front door weatherstrip on some 2023MY Carnival (KA4) vehicles produced from July 14, 2022 through September 8, 2022, which may exhibit a deformation of the weatherstrip in the upper rear corner area (center 'B' pillar) of the front door. Kia is requesting the completion of this Service Action on all affected vehicles in dealer stock, prior to delivery. If deformation is present, replace the front door weatherstrip on the affected side(s).

TEMPORARILY ON HOLD PENDING UPDATED PARTS.

conducting a Product Improvement Campaign to install steel reinforcement plates on the second-row seat outer rails in certain 2022-2024 MY Kia Carnival vehicles equipped with sliding and removable second-row seats (excluding SX-Prestige equipped with the second-row lounge seats). This is an update following a notice that was issued in August 2023. Kia is currently experiencing an unexpected parts supply issue which is expected to continue until the first week of October 2023. Kia is requesting that customers wait until after the first week of October before contacting an authorized Kia dealer to schedule a service appointment for this Product Improvement Campaign to be performed.

Parts and Service Managers that Kia is conducting a Product Improvement Campaign to install steel reinforcement plates on the second-row seat outer rails in certain 2022-2024 MY Kia Carnival vehicles equipped with sliding and removable second-row seats (excluding SX-Prestige equipped with the second-row lounge seats). This is an update following a notice that was issued to Kia dealers in August 2023. Kia is currently experiencing an unexpected parts supply issue which is expected to continue until the first week of October 2023. Since the remedy is not going to be available during this period, Kia is requesting that customers wait until after the first week of October before contacting an authorized Kia dealer to schedule a service appointment for this Product Improvement Campaign to be performed.

Kia is conducting a Product Improvement Campaign to install steel reinforcement plates on the second-row seat outer rails in certain 2022-2024 MY Kia Carnival vehicles equipped with sliding and removable second-row seats (excluding SX-Prestige equipped with the second-row lounge seats). This is an update following a notice that was issued to Kia dealers in August 2023. Kia is currently experiencing an unexpected parts supply issue which is expected to continue until the first week of October 2023. Since the remedy is not going to be available during this period, Kia is requesting that customers wait until after the first week of October before contacting an authorized Kia dealer to schedule a service appointment for this Product Improvement Campaign to be performed.

provides information to update the AVN 5 Wide software to improve Netflix and Wi-Fi functionality on some 2022-2023MY Carnival (KA4) vehicles, produced from January 4, 2021 through August 12, 2022, which may have issues with Netflix not working or Wi-Fi Hotspot not connecting on the Rear Seat Entertainment (RSE) system.

Parking Distance Warning (PDW) alerts and repairs involving ultrasonic sensors. The PDW system alerts the driver while parking, by calculating distance based on the difference in signal transmission and reception times between the vehicle (ultrasonic sensor) and an object. The membrane film of the ultrasonic sensor is used for object detention and can be damaged by stone chips or foreign substances while driving. Damage to the cover of the ultrasonic sensor can also lead to damage to the internal circuit. As a result of this external damage, the PDW system may not receive the proper signal from the ultrasonic sensor. In some cases, the system may cause a false alarm, no alert, or phantom warnings by a Warning Lamp to be displayed on the cluster. The ultrasonic sensor membrane film should be always inspected for external damage and if any part replacement should be treated as a general repair, not as a warranty claim repair for this concern. (Please note that this Pitstop only applies to models/trims that are equipped with the ultrasonic sensors.)

New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information relating to the correct transmission fluid type and fill quantity requirement for each Kia model. A flush is required ONLY when a transmission is replaced, and the transmission oil cooler is transferred to the new transmission.

A flush is required ONLY when a transmission is replaced.

correct transmission fluid type and fill quantity requirement for each Kia model. A flush is required ONLY when a transmission is replaced, refer to applicable vehicles in the chart starting on page 2.

replacement of the fuel filler door actuator and wiring harness on 2022-2024MY Carnival (KA4) vehicles. When replacing a faulty fuel filler door actuator, ensure to order the corresponding replacement part number (shown below) for the applicable vehicle production date. Selecting the incorrect part may result in a vehicle comeback with a customer complaint of the drivers side sliding door not operating with the power feature; however, the door can still be operated manually.

Kia is conducting a Voluntary Emissions Service Campaign to improve the emissions logic in the Electronic Control Module (ECM) to ensure compliance with emissions regulations.

provides information to install new 2nd -row seat rail covers on all 2022-2024MY, and certain 2025MY Carnival (KA4) vehicles manufactured from January 4, 2021 through March 31, 2025. The subject vehicles are equipped with seat rails on the interior floor of the passenger compartment which allow for the adjustment of the 2nd -row seats. Under certain operating conditions in high temperature environments, the 2nd -row seat rails may become warm or hot to the touch. A hot seat rail can result in discomfort if an occupant touches the seat rail with their bare skin. This campaign is to install covers on the 2nd -row seat rails that reduce the surface temperature of the rails and improve the vehicle occupants experience.

New/revised sections of this bulletin are indicated by a black bar in the margin area. This Pitstop provides information regarding the Rear Occupant Alert (ROA) with Rear Door Logic system on all 21MY~ models equipped with this feature. This system is designed to help prevent a rear passenger from being left inside the vehicle when exiting. The "Check Rear Seats" message will display on the cluster when driver opens the front door, if during vehicle operation the rear doors (one or both) were opened and closed.

the most frequently asked questions regarding the Voluntary Emissions Service Campaign SC290.

resetting the modem in certain 2016-2025MY Kia vehicles listed on page 3 that are equipped with Kia Connect Services. The affected vehicles may encounter the following issues: remote Start/Climate Control function not working, vehicle Status on the Kia Access App not updating, connected routing not functioning properly.