2016 Kenworth T880 TSBs
59 Technical Service Bulletins across 13 categories
Categories
Engine
14 bulletinsE304: PACCAR MX-11 and MX-13 EMY2016 NOx and N2O Exceedance Emissions Recall Certain vehicles with PACCAR MX-11 and...
Read full bulletin
MX-13 EMY2016 engines with less than 300,000 miles (482,803 km) have been shown, in testing, to exceed regulatory limits for NOx and N2O emissions. This bulletin now applies to both Canadian and U.S.-registered vehicles. Software is now available to remedy this emissions non-compliance. NOTE California-registered vehicles that received a letter must have the software updated AND California documentation completed regardless of vehicle mileage.
Certain chassis with Engine Model Year 2016-2021 PACCAR MX-11/MX-13, or EPA13 and EPA21 Cummins ISX12/ISX15/X15 engines...
Read full bulletin
that had a previously failed DEF sensor and with DEF sensor software disabled due to industry DEF sensor shortages will now be able to receive a replacement DEF sensor, DEF tank heater coolant control valve, and re-enabled DEF diagnostic software. Please note that chassis equipped with PACCAR PX engines will be eligible for this repair at a future date when software is available.
E279: PACCAR MX-13/MX-11 Engine MY17 Software Incorrectly Sets DTC P1092 PACCAR MX-13/MX-11 Engine MY17 Software...
Read full bulletin
Incorrectly Sets DTC P1092 Emission Recall - PACCAR MX-13/MX-11 MY2017 software incorrectly sets DTC P1092, which could result in reduced available engine torque and/or engine protection mode. An engine software update is available that corrects the issue.
Certain Model Year 2021-2024 chassis with PACCAR MX engines and optional fuel filter restriction virtual gauge may...
Read full bulletin
display incorrect restriction levels. The virtual gauge will be temporarily disabled until a revised sensor strategy is developed.
Kenworth is providing guidance for PACCAR MX Engine Composite Oil Pan leak troubleshooting to avoid over-repairs and to...
Read full bulletin
provide warrantable repair guidance. Oil leaks, if not repaired, can lead to severe engine damage.
Non-Safety Campaign Vehicles with a Cummins X15 engine and Horton fan drive may set Diagnostic Trouble Code (DTC) 6637...
Read full bulletin
and/or 3838 due to fan speed that results in the fan remaining activated until the power is cycled. A new controller will resolve the issue.
An engine software update is required to resolve OBD system readiness, DEF doser diagnostics, and otherOBD system...
Read full bulletin
software related issues.
Eaton ultrashift plus excessive engine over-speed lamp on.
Emissions Campaign The Engine Overspeed lamp may illuminate during a smoke opacity test.
Read full bulletin
A software update is available to resolve the issue.
Fix-As-Fail The evaporator core may crack in vehicles with the ISX-15 engine.
Read full bulletin
An improved suction line has been released that removes stress transferred to the evaporator core.
Fix-As-Fail - Composite fittings used in the cooling system may crack, resulting in coolant leaks.
Read full bulletin
Brass fittings are available to replace the composite fittings.
Tip for technicians to avoid a conflict with the engine controller when re-programming the transmission
FIX-AS-FAIL - ENGINE OVER-SPEED LAMP COULD COME ON AFTER A DOWNSHIFT WITH THE EATON ULTRASHIFT PLUS TRANSMISSION.
Read full bulletin
THIS DOES NOT AFFECT THE FUNCTION OF THE VEHICLE.
KENWORTH: AN ULTRACAPACITOR ENGINE START MODULES (ESM), IN SOME TRUCKS, ARE NOT TREATED LIKE REGULAR BATTERY, DUE TO...
Read full bulletin
ELECTRICAL ENERGY STORAGE AND INTERNAL RESISTANCE IS EXTREMELY LOW AND ENERGY IS PROVIDED FASTER THAN BATTERY. MODEL T680, 880. NO YEARS LISTED. PE
Electrical
11 bulletinsFix-As-Fail Due to undersupply issues, only a limited supply of Diesel Exhaust Fluid (DEF) sensors are available.
Read full bulletin
As a temporary solution, after PACCAR confirms a DEF sensor is not available, a temporary software update will allow a vehicle to continue operation with a failed DEF sensor by disabling the DEF sensor diagnostics.
Non-Safety Campaign The batteries may drain quickly due to the VECU not going to sleep.
Read full bulletin
Updated VECU software is available to resolve the issue.
Information Only: This bulletin provides dealers with a battery warranty quick reference guide to ensure the...
Read full bulletin
appropriate tests for battery warranty are performed in order to prevent battery warranty claims filed with incorrect or incomplete information.
Information Only Vehicles may have the connector seals on the wheel speed sensor incorrectly installed, which may lead...
Read full bulletin
to water intrusion and corrosion in some vehicles.
Information Only: Proper jump-starting voltage will eliminate high voltage related issues and equipment damage.
Information Only: The AutoStart System Test does not recognize the hood opening and closing when running the test on a...
Read full bulletin
model 579 or 567 chassis equipped with a VECU software version 9.8 and 9.9. The issue will be fixed on a future VECU software update. This bulletin will be updated when the resolution is available.
Fix as Fail: Vehicles built 11/30/15 to 7/18/16 may display an error message in the Service Advised display after...
Read full bulletin
updating CECU software.
Non-Safety Campaign: Vehicles may have a fuse installed in the PDC (Power Distribution Center) in a location unable to...
Read full bulletin
support the amperage.
Fix-as-Fail: CECU3 software P30-1011-139 software has been released.
Read full bulletin
This software update is not mandatory. This software requires MY2017 PCC software when installed on MY2015/2016 vehicles equipped with PCC.
Non Safety Campaign: The circuit for the Trailer Hotline/Trailer Power may not be properly protected on Model T680/T880...
Read full bulletin
vehicles equipped with this option.
Fix-As-Fail: Repair for horizontal exhaust diffuser configurations with broken brackets or cracked diffuser.
Other
5 bulletins"Kenworth: Dealers should check the chassis list and SIR weekly for VIN changes.
Read full bulletin
2 chassis added to the chassis list. Peterbilt: Dealers should check the chassis list and SIR weekly for VIN changes. 10 chassis added to the chassis list."
Predictive Cruise control (PCC) incomplete assembly and programming.
DEF tank covers may become loose and potentially crack on vehicles built before October 2019 with DEF tank part number...
Read full bulletin
M86-6221-003**(TANK-DEF MEDIUM ASSY) and M86-6222-003**(TANK-DEF LARGE, ASSY). Resolution is to resolve the vibration on the tank cover by adding bottom tank washers.
Fix-As-Fail: Two separate causes have been identified as root cause of intermittent low coolant indicator illumination.
Information: J1939 CAN BUS Best Practices
Body & Paint
4 bulletinsTroubleshooting procedures for 2.1m cab power windows are now available.
Information Only Windshield washer pumps have a high No Trouble Found rate.
Read full bulletin
Washer pumps may fail to spray due to a clogged filter.
Sleeper roof panels separating.
Information Only: Proper instructions for closure of power distribution box cover to prevent corrosion.
Brakes
4 bulletinsCertain C500/T440/T470/T660/T680/T800/T880/W900 chassis may have air tank reservoirs that do not meet air volume...
Read full bulletin
requirements per FMVSS/CMVSS 121 Air Brake Systems. This bulletin will be updated when repair parts and procedures are available.
Fix-As-Fail - Bendix New-Gen Lightweight Steer Axle Drum Brake Spider Cracking
Fix-As-Fail: Bendix Wingman radars with ice/snow buildup on the optional PACCAR radar cover may experience false...
Read full bulletin
warnings and mild brake applications from the Wingman System.
Fix-As-Fail: Bendix Wingman radars with ice/snow buildup on the optional PACCAR radar cover may experience false...
Read full bulletin
warnings and mild brake applications from the Wingman System.
HVAC & Climate
4 bulletinsInformation Only: This bulletin provides guidance for repairing an air-conditioning system after internal failure of the...
Read full bulletin
A/C compressor.
Fix as Fail HVAC system may demonstrate inadequate temperature control, be stuck in defrost mode, or have intermittent...
Read full bulletin
changes in fan speed that can be remedied with an updated HVAC software.
FIX-AS-FAIL: KENWORTH T680/T880 HVAC PANEL AND TEMPERATURE MODE DOORS NOT FUNCTIONING PROPERLY
FIX-AS-FAIL: AN INTERNAL ISSUE MAY CAUSE SOME HVAC MODE DOOR ACTUATORS TO FAIL.
Read full bulletin
THIS WILL CAUSE THE HVAC SYSTEM TO ACT ERRATICALLY OR CONSTANTLY TURN ON AND OFF.
Infotainment
3 bulletinsNav+HD MP3 reboot update ane features enable.
FIX-AS-REQUESTED - NAV+ HD SOFTWARE UPDATE FOR RANDOM REBOOT FIX AND MP3 FEATURES ENABLED.
NON-SAFETY CAMPAIGN - CHASSIS BUILT WITH PRE-PRODUCTION QV/VV MODELS OF THE NAV+ HD SYSTEM HARDWARE ARE ELIGIBLE FOR REPLACEMENT.
Read full bulletin
THIS DOES NOT AFFECT THE OPERATION OF THE VEHICLE.
Fuel System
3 bulletinsNon-Safety Campaign- Incorrect GHG emissions identifier label for the tire classification listed on printed label.
Non-Safety Campaign- Incorrect GHG emissions identifier label for the tire classification listed on printed label.
NON-SAFETY CAMPAIGN - POSSIBLE ASSEMBLY AND PROGRAMMING ISSUES WITH THE PCC SYSTEM MAY REDUCE THE FUEL SAVINGS BENEFIT...
Read full bulletin
OF PCC.
Lighting
3 bulletinsInformation only - Customer installed inverters may be wired incorrectly.
Fix-As-Fail - A U1548 fault code is present in the DAVIE log file, with no fault lamp illuminated or other obvious...
Read full bulletin
symptoms.
NON-SAFETY CAMPAIGN: WATSON & CHALIN LIFT AXLE FRAME BRACKETS WITH SLOTTED LOWER MOUNTING HOLES MAY EXHIBIT CRACKING...
Read full bulletin
WHEN FASTENERS ARE POSITIONED AT THE UPPER PORTION OF THE SLOT. INSTALLING A DOUBLER PLATE MAY PREVENT CRACKS FROM DEVELOPING. FOR VEHICLES WHERE CRACKING IS EVIDENT, A NEW UPDATED SIDE PLATE WILL BE INSTALLED.
Software & Calibration
2 bulletinsCARB Chassis Update - Chassis list updated with 5 KW and 31 PB additional chassis.
Information Only - Vehicles built with NAMUX software from 2013 to present may experience accuracy issues with the tachometer.
Read full bulletin
The issue can be temporarily resolved using any one of the included procedures.
Transmission
2 bulletinsFix-As-Fail - Prior versions of Eaton Endurant transmission software may be prone to setting Linear Clutch Actuator...
Read full bulletin
(LCA) fault codes leading to possible LCA hardware replacement.
ALLISON TRANSMISSION: ON SOME TRUCKS, THE PUSH BUTTON SHIFT SELECTOR (PBSS) SKIPS OIL LEVEL READING AND GOES DIRECTLY...
Read full bulletin
TO PROGNOSTICS AND COULD BE MISSING WIRE 116 ON BULKHEAD OTHER SIDE. MODELS T680, T880, 579, 567. *PE UPDATED 2/1/16. *PE
Pre-Delivery & Maintenance
2 bulletinsInformation Only This bulletin provides information about the California Air Resources Board (CARB) Periodic Smoke...
Read full bulletin
Inspection Program (PSIP) and Heavy Duty Vehicle Inspection Program (HDVIP).
Non-Safety Campaign - OBD modem is unable to communicate to telematics systems.
Suspension
2 bulletinsFix-As-Fail ? There is an updated plug to fix leaking steer axle hubcaps.
Fix-As-Fail ? There is an updated plug to fix leaking steer axle hubcaps.