1999 Jeep Wrangler TSBs

SUBJECT REGARDING WIRE SPLICE REPAIRS.

THIS BULLETIN PROVIDES A REVISED WIRE SPLICE PROCEDURE AND RELATED PARTS.

SUBJECT REGARDING MISDIAGNOSED LEAK DETECTION PUMP SYSTEMS WITH DIAGNOSTIC TROUBLE CODES P1494, P0442 P0455, OR P0456.

THIS BULLETIN EXPLAINS THE OPERATION AND APPLICATION OF THE LEAK DETECTION PUMP (LDP) MONITOR TEST.

CONDITIONS WITH VEHICLE START AND STALL OR VEHICLE NO-START.

APPROVAL OF USING OF IN- TRANSIT PROTECTIVE FILM.

Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry...

Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to...

Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry...

Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to...

INFORMATION ON ERRONEOUS ENGINE MISS WHILE PERFORMING DIAGNOSTICS WITH THE DIAGNOSTIC SCAN TOOL (DRB III).

SOME VEHICLES MAY EXHIBIT AN IDLE UNDERSHOOT CONDITION WHIL ETHE VEHICLE IS SLOWLY MOVING AT 1-2 MPH IN LOW RANGE FOUR...

SOME VEHICLES MAY EXHIBIT HIGH IDLE RPM DURING DECELERATION AND/ OR PARKING LOT MANEUVERS WHEN THE ENGINE COOLANT...

SOME VEHICLES MAY EXHIBIT AN IDLE UNDERSHOOT OR DRIVEWAY DIE OUT WHEN THE TRANSMISSION IS PLACED FROM PARK OR NEUTRAL INTO DRIVE OR REVERSE.

SOME VEHICLES MAY EXHIBIT AN ENGINE SAG WHEN THE A/C COMPRESSOR CYCLES.

SOME CONSUMERS THAT INADVERTENTLY FLOOD THEIR ENGINES DURING STARTING MAY TRY TO PERFORM A CLEAR FLOOD PROCEDURE TO HELP START THEIR VEHICLES.

SOME VEHICLES MAY EXHIBIT AN IDLE UNDERSHOOT OR DIE OUT DURING ENGINE STARTING AND MAY BE CAUSED BY IAC LOST STEPS.

OUTER EXHAUST MANIFOLD STUDS MAY FATIGUE/BREAK.

Valve Body. These may cause over drive cycling.

4.0L MULTIPLE CYLINDER MISFIRE.

SOFT TOP ZIPPER CLEANER AND LUBRICANT - FOR DIFFICULT TO OPERATE WINDOW ZIPPERS.

INFORMATION REGARDING THE IMPROVED DOOR WEATHER STRIP.

SUBJECT ON VEHICLES EXPERIENCING SOLFT TOP WINDOWS WHICH APPEAR FOGGY OR HAZY.

SUBJECT ON WATER LEAK DIAGNOSTIC / REPAIR PROCEDURES.

DIPAP Requirements - Addition of Jeep Wrangler (JL/JK) and Jeep Gladiator (JT) Hard Top and Targa Top Panel Replacements - All Dealers (Rev.

PRIMARY DOOR WEATHERSTRIP WATER LEAK AT A-PILLAR BELT LINE.

SOFT TOP ZIPPER CLEANER AND LUBRICANT - FOR DIFFICULT TO OPERATE WINDOW ZIPPERS.

DIRT AND DEBRIS ACCUMULATION AT REAR MAIN SEAL.

INFORMATION PERTAINING TO COMMON DIAGNOSTIC TROUBLE CODES CAUSED BY AN OPEN FUSE.

EXHIBITING ERRONEOUS MALFUNCTION INDICATOR LAMP ILLUMINATION WITH DIAGNOSTIC TROUBLE CODE $A8 (P1763) GOVERNOR PRESSURE SENSOR VOLTS TOO HIGH.

EMISSIONS RECALLS 8061 AND 8062 REGARDIG SPARK PLUG REPLACEMENT.

EXHIBITING MIL ILLUMINATION WITH DTC $ 12 (P0443) - EVAPORATIVE PURGE SOLENOID CIRCUIT FAILURE, CAN BE CAUSED BY...

SUBJECT REGARDING IGNITION OFF DRAW FUSE LOCATION.

Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test...

AIR CONDITIONING (A/C) COOLING COIL ODOR.

POWERTRAIN CONTROL MODULE INITIALIZATION.

SUBJECT REGARDING GENERIC SCAN TOOL (GST), PUBLICATION NO.

SERVICE ACTION REGARDING MISSING TOW HOOKS.

SERVICE ACTION , TJ MISSING TOW HOOKS.

INFORMATION REGARDING POWER DISTRIBUTION CENTER (PDC) SERVICE.

SUBJECT REGARDING I/M ( INSPECTION MAINTENANCE ) TESTING - OBD II "CARB" READINESS MONITOR INFORMATION.

KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number.

KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number.

AUTOMATIC TRANSMISSION FLUID USAGE ATF+4.

VEHICLES EXHIBITING BUZZ, WHINING, OR MOANING LIKE NOISE FROM COLD TRANSMISSION WHEN REVERSE GEAR IS SELECTED.

SUBJECT ON KINKED TRANSMISSION COOLER FLEX LINE.

A THUMPING OR CREAKING NOISE MAY BE HEARD COMING FROM THE TRANSMISSION TUNNEL AREA ON ACCELERATION OR WHILE DRIVING OVER BUMPY ROADS.

AUTOMATIC TRANSMISSION DIAGNOSTIC TEARDOWN PROCEDURE.

SUBJECT REGARDING NON-DEPLOYED AIRBAG HANDLING PROCEDURES.

DAIMLERCHRYSLER CORPORATION IS NOW OFFERINB AIRBAG ON / OFF SWITCHES FOR SELECTED VEHICLES.

SOME VEHICLES MAY EXHIBIT AN ERRATIC, INTERMITTENT CLUSTER OPERATION / INTERMITTENT AIR BAG WARNING LIGHT.

SUBJECT REGARDING AIRBAG ON - OFF SWITCHES.

FLASH PROGRAMMING FAILURE RECOVERY.

SUBJECT ON FLASH PROGRAMMING FAILURE RECOVERY.

CUSTOMERS MAY COMPLAIN THAT THE HVAC DRAIN WATER LEAKS UNDER PASSENGER SIDE CARPET.

HVAC DRIVE WATER LEAKS UNDER PASSENGER SIDE FRONT CARPET.

SUBJECT REGARDING ADDITIONAL DIAGNOSTIC FOR DIAGNOSTIC TROUBLE CODES CAUSED BY AN EVAPORATIVE SYSTEM LEAK.

VEHICLES MAY EXPERIENCE WATER DRIPPING FROM THE BOTTOM OF THE EVAPORATOR DRAIN TUBE AND ENTER THE PASSENGER COMPARTMENT...

SUBJECT REGARDING AIRBAG / CLOCK SPRING SERVICE FOR VARIOUS MODELS INCLUDING 2002 MODEL YEAR JEEP LIBERTY.

THIS BULLETIN PERTAINS TO FRONT END ALIGNMENT - ADJUSTABLE / OFFSET BALL JOINTS.

Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair...

Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair...

EXHIBITING MINOR BRAKE PEDAL PULSTION WHICH MAY BE CAUSED BY ROUGH DISC ROTORS.

INFORMATION ON INSTALLATION OF RADIO TRANSMITTING EQUIPMENT.

STEERING SHIMMY. *TT