1994 Jeep Grand Cherokee TSBs
61 Technical Service Bulletins across 14 categories
Categories
Other
12 bulletinsSUBJECT REGARDING WIRE SPLICE REPAIRS.
Read full bulletin
*SB
SUBJECT REGARDING CHILD SEAT TETHER ANCHORS.
Read full bulletin
*TT
SUBJECT ON THE CHILD SEAT TETHER ANCHORS.
Read full bulletin
*MJS
SUBJECT REGARDING CHILD SEAT TETHER ANCHORS.
Read full bulletin
*TT
THIS BULLETIN PROVIDES A REVISED WIRE SPLICE PROCEDURE AND RELATED PARTS.
Read full bulletin
*TT
INFORMATION ON CHILD SEAT TETHER ANCHORS.
Read full bulletin
*TT
2100 RPM DRIVELINE VIBRATION.
Read full bulletin
*TW
UNKNOWN
UNKNOWN
UNKNOWN
Chrysler will offer owners an upgrade to the rear structure of the subject vehicles by the addition of a trailer hitch...
Read full bulletin
to better manage the crash forces in low-speed impacts.
Chrysler will offer owners an upgrade to the rear structure of the subject vehicles by the addition of a trailer hitch...
Read full bulletin
to better manage the crash forces in low-speed impacts.
Engine
11 bulletinsEXPERIENCING SPARK KNOCK AND ENGINE OIL CONSUMPTION DUE TO INTAKE MANIFOLD PAN GASKET OIL LEAK.
Read full bulletin
*TT
CONCERNS WITH ENGINE COOLANT USAGE.
Read full bulletin
*NLM
SUBJECT REGARDING SPARK KNOCK AND ENGINE OIL CONSUMPTION DUE TO INTAKE MANIFOLD PAN GASKET OIL LEAK.
Read full bulletin
*TT
VARIOUS CAR OWNER'S HAVE EXPRESSED INTEREST IN USING ENGINE COOLANTS MADE WITH PROPYLENE GLYCOL INSTEAD OF ETHYLENE GLYCOL.
Read full bulletin
*YC
BULLETIN SUPERSEDES TSB # 18-08-95, DATED FEB.
Read full bulletin
17, 1995. INTERMITTENT POOR PERFORMANCE, NO START, START AND DIE OUT OR VEHICLE WILL IDLE BUT NOT ACCELERATE AFTER THE VEHICLE HAS BEEN EXPLOSED TO TEMPS BELOW FREEZING. WATER MAY BE ACCUMULATING IN THE TAILPIPE AND FREEZING. REMOVE THE MUFFLER AND TAILPIPE ASSY AND INSTALL P/N 4864279.
BULLETIN APPLIES TO VEHICLES EQUIPPED W/ 2.5L, 4.0L OR 5.2L ENGINE BUILT TO 4-1-94 (MDH 4-1-XX).
Read full bulletin
INTERMITTENT ENGINE MISS AND/OR ROUGH IDLE, OR HARD START/NO START MAY BE EXPERIENCED. REPLACE ALL WIRES BY REFERRING TO APPROPRIATE SERVICE MANUAL.
INTERMITTENT POOR ENGINE PERFORMANCE IN BELOW FREEZING TEMPERATURE.
Read full bulletin
*TW
OIL LEAK DIAGNOSIS OF THE REAR MAIN BEARING AREA.
Read full bulletin
*TW
Part Description: Insulator on Lever Assy Manual Valve - Valve Body - RWD Transmission Issue Description: The manual...
Read full bulletin
valve insulator, attaching rivet and instruction sheet are now available as a kit. If the insulator requires replacement please order kit 68253161AA. Insulator only used on Auto-RWD transmission Note: The color of the insulator is not relevant for service.
Valve Body. These may cause over drive cycling.
Part Description: Insulator on Lever Assy Manual Valve - Valve Body - RWD Transmission Issue Description: The manual...
Read full bulletin
valve insulator, attaching rivet and instruction sheet are now available as a kit. If the insulator requires replacement please order kit 68253161AA. Insulator only used on Auto-RWD transmission Note: The color of the insulator is not relevant for service.
Transmission
8 bulletinsAUTOMATIC TRANSMISSION FLUID USAGE ATF+4.
Read full bulletin
*TT *MJ
INFORMATION ON TRANSMISSION COOLER REVERSE FLUSHING WITH COOLER BYPASS KIT INSTALLED.
Read full bulletin
*NLM
THIS BULLETIN INVOLVES TRANSFER CASE SHIFTER NOISE.
Read full bulletin
*NLM
A THUMPING OR CREAKING NOISE MAY BE HEARD COMING FROM THE TRANSMISSION TUNNEL AREA ON ACCELERATION OR WHILE DRIVING OVER BUMPY ROADS.
Read full bulletin
*YC
SUBJECT ON CUSTOMER SATISFACTION NOTIFICATION #733--BRAKE PEDAL SHIFT INTERLOCK.
Read full bulletin
*YC
A THUMPING OR BUMPING NOISE MAY BE HEARD COMING FROM THE TRANSMISSION TUNNEL AREA ON ACCELERATION OR WHILE DRIVING OVER BUMPY ROADS.
Read full bulletin
*YC
RWD AUTOMATIC TRANSMISSION COLD TEMPERATURE COOLER BYPASS KIT.
Read full bulletin
*TW
PCM NOT PROPERLY DISENGAGING A/C CLUTCH VIA THE RELAY ALSO THE PCM MAY NOT ENERGIZE THE A/C CLUTCH RELAY.
Read full bulletin
*TW
Air Bags & Safety
6 bulletinsSUBJECT REGARDING NON-DEPLOYED AIRBAG HANDLING PROCEDURES.
Read full bulletin
*TT
DAIMLERCHRYSLER CORPORATION IS NOW OFFERINB AIRBAG ON / OFF SWITCHES FOR SELECTED VEHICLES.
Read full bulletin
*TT
INFORMATION REGARDING NHTSA AUTHORIZED AIRBAG DEACTIVATION FOR MEDICAL NECESSITY.
Read full bulletin
*NLM
SUBJECT REGARDING AIRBAG ON - OFF SWITCHES.
Read full bulletin
*YC
SUBJECT REGARDING THE AIRBAG ON-OFF SWITCHES.
Read full bulletin
*YC
AUTHORIZED AIRBAG DEACTIVATION FOR MEDICAL NECESSITY.
Read full bulletin
*YC
Body & Paint
6 bulletinsCONCERNS WITH DOOR CHECK ROLLER REPAIR.
Read full bulletin
*NLM
DIFFICULT TO CLEAN LIGHT COLORED "CHALKY" RESIDUE FROM PLASTIC BODY COMPONENTS THAT ARE MOLDED IN BLACK.
Read full bulletin
*TW
ROOF RACK RATTLE OR STANCHION RELEASE BUTTON STICKING OR FALLING OUT.
Read full bulletin
*TW
DOOR OPEN AND CLOSING EFFORTS.
Read full bulletin
*TW
FRONT DOOR SAG. *TW
NEW FRONT OUTPUT SEAL AND OIL SLINGER FOR TRANSFER CASE.
Read full bulletin
*TW
Pre-Delivery & Maintenance
5 bulletinsBULLETIN SUPERSEDES TECHNICAL SERVICE BULLETIN 08-16-95, DATED APR.
Read full bulletin
14, 1995. IF THE VEHICLE OPERATOR **REPEATEDLY** PRESSES AND RELEASES THE SET BUTTON WITH THEIR FOOT OFF OF THE ACCELERATOR (A 'LIFT FOOT SET' TO BEGIN SPEED CONTROL OPERATION), THE VEHICLE MAY ACCELERATE AND EXCEED THE DESIRED SET SPEED BY UP TO 5 MPH (8 KM/H) AND THEN DECELERATE TO LESS THAN THE DESIRED SET SPEED BEFORE FINALLY ACHIEVING THE DESIRED SET SPEED.
Towing Capacity For Vehicles Modified With N45 Or N46 Trailer-Hitch Assembly This bulletin specifies the approved tow...
Read full bulletin
rating for vehicles not equipped with trailer tow package that have received a trailer-hitch assembly as a result of the N45 or N46 Campaign.
Towing Capacity For Vehicles Modified With N45 Or N46 Trailer-Hitch Assembly This bulletin specifies the approved tow...
Read full bulletin
rating for vehicles not equipped with trailer tow package that have received a trailer-hitch assembly as a result of the N45 or N46 Campaign.
Child Seat Tether Anchor Installation This bulletin describes procedures to install Child Seat Tether Anchors based on Customer Request.
Read full bulletin
Retrofits are subject to part availability. Vehicles in the following list that are marked **** for the model year are no longer supported with OEM retrofit kits. NOTE: Dealers are encouraged to honor any customers? request for the installation of the Child Seat Tether Anchors and Dealer reimbursement will be made by FCA US LLC regardless of vehicle age or mileage. See the Warranty Policy and Procedure Manual and/or Warranty Bulletin D-08-33 for reimbursement detail.
Towing Capacity For Vehicles Modified With N45 Or N46 Trailer-Hitch Assembly This bulletin specifies the approved tow...
Read full bulletin
rating for vehicles not equipped with trailer tow package that have received a trailer-hitch assembly as a result of the N45 or N46 Campaign.
Suspension
3 bulletinsSUBJECT REGARDING AIRBAG / CLOCK SPRING SERVICE FOR VARIOUS MODELS INCLUDING 2002 MODEL YEAR JEEP LIBERTY.
Read full bulletin
*TT
THIS BULLETIN PERTAINS TO FRONT END ALIGNMENT - ADJUSTABLE / OFFSET BALL JOINTS.
Read full bulletin
*TT
SNAPPING OR POPPING NOISE IN REAR SUSPENSION.
Read full bulletin
*TW
Electrical
3 bulletinsSUBJECT REGARDING IGNITION SYSTEM CROSS FIRE/ SECONDARY IGNITION WIRE INDUCTION.
Read full bulletin
*AK
FRONT COIL SPRING SQUEAK.
Read full bulletin
*TW
New Safety Recall Advanced Communication ? N45062013 During recent discussions, the National Highway Traffic Safety...
Read full bulletin
Administration (?NHTSA?) and Chrysler Group LLC (?Chrysler?) mutually identified an opportunity to incrementally improve the performance of 1993 through 1998 model year Jeep Grand Cherokee vehicles and 2002 through 2007 model year Jeep Liberty vehicles in certain low-speed impacts. Chrysler has decided to conduct a voluntary safety recall to respond to customer concerns about that assessment. Chrysler will offer owners an upgrade to the rear structure of the subject vehicles by the addition of a trailer hitch to better manage the crash forces in low-speed impacts. Chrysler intends to inspect the involved vehicles and if necessary, install a trailer hitch where appropriate, free of charge (parts and labor). The parts required for this program are currently not available. Chrysler is making all reasonable efforts to obtain the parts as quickly as possible. Chrysler will contact dealers when the parts and repair procedure becomes available. Dealers will be notified of the launch of this safety recall by way of established methods used in the past. We ask that you please take the time to ensure that your personnel are aware of this communication and are prepared to execute a customer friendly process for inquiries on involved vehicles.
HVAC & Climate
2 bulletinsSERVICE MANUAL PROCEDURES TO SERVICE THE HEATER A/C HOUSING.
Read full bulletin
*YC
A REVISED COWL PLENUM SCREEN HAS BEEN RELEASED WHICH CONTAINS A FINE MESH SCREEN TO MINIMIZE DEBRIS FROM ENTERING THE HEATER A/C HOUSING.
Read full bulletin
*YC
Software & Calibration
1 bulletinFLASH PROGRAMMING FAILURE RECOVERY.
Read full bulletin
*SLC
Fuel System
1 bulletinCONCERNS WITH A/C EVAPORATOR ODOR.
Read full bulletin
*NLM
Tires & Wheels
1 bulletinINFORMATION ON TIRE AND WHEEL RUNOUT.
Read full bulletin
*NLM
Infotainment
1 bulletinINFORMATION ON INSTALLATION OF RADIO TRANSMITTING EQUIPMENT.
Read full bulletin
*AK
Brakes
1 bulletinDRIFT LEFT UNDER HARD BRAKING.
Read full bulletin
*TW