2003 Jaguar XK TSBs
86 Technical Service Bulletins across 13 categories
Categories
Other
29 bulletinsDamaged Armrest Liner
Damaged Armrest Liner
Damaged Armrest Liner
Damaged Armrest Liner
Damaged Armrest Liner
Diagnosing the BMS when DTC B11DB-87 is logged.
Comprehensive Component Monitor-
XF Diagnostic process for Day Night Mode Activation
AM Frequency Stuck In FM Preset
AM Frequency Stuck In FM Preset
Title: 5.0L V8 (AJ133) overheating due to incorrect
Diagnostic Concerns.
Diagnostic Concerns.
HLDF Programming - `Candidate Not Available` message.
Title MOST system diagnosis
Attachment.
Attachment.
Attachment.
Unable to access SDD after installation of DVD131.04.
Image.
Image.
Check customers phone compatibility using the Jaguar.
Restricted Seat Travel.
SIM card activation issues
InControl Touch Pro phase 4 customer letter
Jaguar Land Rover Shop Foreman Conference Call
Presentation from Dealer Shop Foreman Conference Call
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
JAGUAR: DIRECTIONAL INDICATOR OPERATING WITH THE STALK IN THE CENTRAL POSITION.
Read full bulletin
IF CONDITION IS FOUND, REPLACE THE DIRECTIONAL INDICATOR SWITCH. NO MODEL YEARS LISTED. *PE
Engine
15 bulletinsJTB00268 engine hard to start after hot soak - fan running Category Driveability.
Door Lock Cylinder Cover - Fitment at PDI / Replacement.
JAGUAR: FUEL INJECTOR CONCERNS 5.O AJ133 GASOLINE, LEADING TO POTENTIAL PROBLEMSSUCH AS POOR RUNNING POOR FUEL ECONOMY,...
Read full bulletin
HARD STARTING, ROUGH IDLE, MISFIRES AND ENGINE DETONATION. *JS
JAGUAR: A FAILURE CAN OCCUR AT THE OUTER CRIMP FACE OF THE OIL COOLER FEED PIPE/HOUSE THAT LEADS FROM THE ENGINE TO THE...
Read full bulletin
INTERMEDIATE CONNECTOR AND RETURN. THESE CONDITIONS CAN RESULT IN THE POSSIBILITY OF ENGINE LOSS AND PERFORMANCE. *PE
JAGUAR: FUEL FILLER CAP DIFFICULT TO INSTALL.
Read full bulletin
CHECK ENGINE MIL ON - REVISED FUEL FILLER CAP. MODEL XJ (X308) AND XK (X100). *PE
FUEL FILLER CAP DIFFICULT TO INSTALL / CHECK ENGINE MALFUNCTION INDICATOR LAMP (MIL) ON - REVISED FUEL FILLER CAP - SERVICE ACTION S509.
Read full bulletin
*TT
ENGINE DETONATION (PINGING) WHEN ACCELERATING FROM STEADY-STATE DRIVING, TYPICALLY AT 70 MPH.
Read full bulletin
*TT
DRIVELINE CLUNK/KNOCK WHEN DOWNSHIFTING - ZF 6HP26 AUTOMATIC TRANSMISSION - REPAIR PROCEDURE.
Read full bulletin
*TT
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATING WITH DIAGNOSTIC TROUBLE CODE (DTC) P0741 (TORQUE CONVERTER CLUTCH STUCK...
Read full bulletin
OPEN) LOGGED IN THE TRANSMISSION CONTROL MODULE (TCM) AND ENGINE CONTROL MODULE (ECM). XK8 AND XKR 2003. *TT
POWER STEERING PUMP VALVE BORE INCORRECT MACHING SERVICE ACTION S506.
Read full bulletin
*EH
TICKING NOISE FROM LEFT SIDE FOOTWELL - EVAP CANISTER PURGE VALVE - REPAIR PROCEDURE.
Read full bulletin
THIS BULLETIN REPLACED BULLETIN 303-62, DATED 11/03. *TT
ENGINE PING - CHECK LONG AND SHORT TERM FUEL TRIM - REPAIR PROCEDURE.
Read full bulletin
*TT
BUZZING/KNOCKING NOISE AFTER START OR WITH IGNITION ON - ADAPATIVE SPEED CONTROL MODULE - REPAIR PROCEDURE.
Read full bulletin
*TT
DRIVE BELT NOISE AFTER COLD START - SUPERCHARGER - REVISED DRIVE BELT AVAILABLE.
Read full bulletin
*TT
POWER STEERING PUMP VALVE BORE - INCORRECT MACHINING - SERVICE ACTION S506.
Read full bulletin
*TT
Electrical
8 bulletinsInstructions for jump starting vehicles with discharged battery?s
New vehicle storage (Transit relay / Transit mode)
Charging a vehicle fitted with Battery monitoring system
Loose battery terminals.
"ISSUE: WHEN INVESTIGATING CUSTOMER REPORTS FOR INCORRECT FUEL GAUGE CONCERNS THE DEALER TECHNICIAN MAY DIAGNOSE THAT...
Read full bulletin
THE FUEL SENDERS ARE OPEN CIRCUIT. THIS DIAGNOSIS MAY BE INCORRECT DEPENDING ON THE MULTIMETER SETTINGS SELECTED BY THE TECHNICIAN DURING MEASUREMENT. CAUSE: THE MULTI METER RANGE MAYBE SET AT 'AUTO' AND DURING A SWEEP OF THE SENDER FROM 50OHMS TO 998OHMS THE MULTI METER HAS TO CHANGE ITS MEASUREMENT RANGE. FOR APPROXIMATELY 1 SECOND, DURING THE RANGE SWITCH OVER POINT, THE MULTI METER DISPLAY INDICATES AN OPEN CIRCUIT. THIS IS INCORRECTLY BEING DIAGNOSED AS A SENDER FAULT"
"ISSUE: 2003-2006 XK (X100) VEHICLES MAY FAIL THE STATE INSPECTION IN SOME STATES WHICH REQUIRE THE COMPLETION OF THE...
Read full bulletin
COMPREHENSIVE COMPONENT MONITOR, SUCH AS IN NEW JERSEY. CAUSE: THE ACCELERATOR PEDAL DEMAND POSITION SENSOR VOLTAGE IS OUT OF RANGE, AT 0% PEDAL ANGLE. THE VOLTAGE FOR PEDAL DEMAND POSITION SENSOR 1 SHOULD BE BETWEEN 0.88V AND 0.99V. THE VOLTAGES FOR PEDAL DEMAND POSITION SENSOR 2 SHOULD BE BETWEEN 3.89V AND 4.18V. IF THE VOLTAGE FOR EITHER SENSOR IS NOT WITHIN THE SPECIFIED RANGE AT 0% PEDAL ANGLE, IT WILL INHIBIT THE COMPREHENSIVE COMPONENT MONITOR FROM RUNNING."
"ISSUE: JAGUAR LAND ROVER NORTH AMERICA SERVICE DIAGNOSTICS WOULD LIKE TO MAKE ALL SDD USERS AWARE OF AN EMERGING...
Read full bulletin
CONCERN BEING TRACKED VIA THE EPQR SYSTEM. USERS REPORT DVD133 IS UNABLE TO FULLY COMMUNICATE WITH PCM ON LEGACY JAGUAR VEHICLES, AND REGARDLESS OF PCM STATUS ICON DISPLAYED ON NETWORK SUMMARY SCREEN, SDD MAY NOT DISPLAY DTCS FROM THE PCM CAUSE: THIS ISSUE IS CURRENTLY UNDER INVESTIGATION IN THE UK AND WILL BE ADDRESSED ON A FUTURE SDD SOFTWARE UPDATE."
DEAD BATTERY - EXCESSIVE QUIESCENT DRAIN WITH AUTO HEADLAMP SYSTEM ON - SERVICE ACTION S840.
Read full bulletin
*TT
Fuel System
8 bulletinsFuel Injector Concerns 5.0 AJ133 Gasoline.
Fuel Injector Concerns 5.0 AJ133 Gasoline.
Fuel Gauge / Pump Diagnostic Aids.
SDD enhancements for fuel gauge and pump issues-10MY onwards.
Fuel System Concerns.
Fuel sender unit fault - incorrect diagnosis.
JAGUAR SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER.
Read full bulletin
CSC LETTER WAS RECEIVED FOR MODELS XJ AND XK, MODEL YEARS 2001-2003. MAY REQUIRE AN INCREASED EFFORT TO TIGHTEN SUFFICIENTLY. REPLACE FUEL FILLER CAP WITH REVISED DESIGNED. *PE
FUEL VAPOR ODOR IN INTERIOR - CONVERTIBLE MODELS ONLY - REPAIR PROCEDURE.
Read full bulletin
*TT
Transmission
6 bulletinsAutomatic transmission, rotary gear selector low level part
Steering Gear Transfer Pipe change
ZF Transmission ? Error message during reprogramming
6 SPEED TRANSMISSION - HARSH SHIFTS - ADAPTIVE SHIFT STRATEGY DRIVE - REPROGRAM TCM & ECM.
Read full bulletin
*TT
HEAD RESTRAINT INOPERATIVE - DRIVE CABLE NOT FULLY ENGAGED IN GEARBOX - REPAIR METHOD.
Read full bulletin
*TT
INABILITY TO SHIFT GEARS - SELECTOR LEVER MOVES FREELY THROUGH J-GATE - REPAIR PROCEDURE.
Read full bulletin
*TT
Software & Calibration
6 bulletinsDVD software update
Mongoose Update.
Mongoose Update
Important firmware update required for the DA Dongle /DA-VINA.
18C - New face of InControl Touch Pro and 18C software improvements
VEHICLE SPECIFICATION CHANGES AND FEATURE ENHANCEMENTS.
Read full bulletin
PRODUCT UPDATE. *TT
Lighting
5 bulletinsCigar Lighter Elements Not Supplied.
Head Lamp / Fog Lamp - Discolouration / Distortion.
ISSUE: A CUSTOMER MAY RAISE A CONCERN OF THEIR VEHICLE NOT PASSING STATE INSPECTION IN CALIFORNIA AND THERE IS NO...
Read full bulletin
WARNING LIGHT OR OTHER SUGGESTION OF A FAULT.
CONDENSATION BUILD-UP IN THE HEADLAMP ASSEMBLIES.
Read full bulletin
INSTALL REVISED LENS. THIS BULLETIN REPLACES BULLETIN 417-06 DATED 07/03. *TT
A BUILD UP OF CONDENSATION IN THE HEADLAMP ASSEMBLY.
Read full bulletin
REPAIR PROCEDURE. THIS BULLETIN REPLACES BULLETIN 417-05 DATED 12/01. *TT
HVAC & Climate
3 bulletinsClimate Controlled Seats Diagnosis & Testing
Lack of Cooling From Air Conditioning
Lack of Cooling From Air Conditioning
Air Bags & Safety
2 bulletinsDiagnostic process for Drivers Airbag Warning Light
SUPPLEMENTAL RESTRAINT SYSTEM (SRS) - FLASH CODES & PID CODE DEFINITIONS - DIAGNOSTICS.
Body & Paint
1 bulletinHood / Bonnet Ajar Switch.
Pre-Delivery & Maintenance
1 bulletinSpecial Service Message.
Infotainment
1 bulletinA customer may report "Hood Open" message displays on IP with hood closed.
Suspension
1 bulletin"ISSUE: DA-DONGLE/DA-VINA/DA-ST512 - J2534 VEHICLE COMMUNICATION INTERFACE DEVICE (VCI) SOFTWARE REQUIRES UPDATING TO THE LATEST LEVEL.
Read full bulletin
DA J2534 SOFTWARE DRIVER LEVEL V4.0 (MUST BE UPDATED TO THIS LEVEL ON ALL SDD MACHINES THAT USE THIS DEVICE) DA APP HUB LEVEL V2.4.0 (MUST BE UPDATED TO THIS LEVEL ON ALL SDD MACHINES THAT USE THIS DEVICE) DA FIRMWARE LEVEL V57. (ONLY NEEDS TO BE UPDATED ONCE TO EACH DEVICE, BECAUSE THIS IS HELD ON THE DEVICE ITSELF)"