1999 Jaguar XK TSBs
79 Technical Service Bulletins across 14 categories
Categories
Other
32 bulletinsTHE ANTIFREEZE SOLUTION IN THE COOLING SYSTEM MAY DETERIORATE.
Read full bulletin
THIS PROCEDURE HAS BEEN PRODUCED TO ELIMINATE THIS PROBLEM. *TT
INFORMATION REGARDING DAMAGED J-GATE GASKET AVAILABLE SEPARATELY REPAIR PROCEDURE.
Read full bulletin
ON CERTAIN MODELS INCLUDING 1998. *YH
Damaged Armrest Liner
Damaged Armrest Liner
Damaged Armrest Liner
Damaged Armrest Liner
Damaged Armrest Liner
Diagnosing the BMS when DTC B11DB-87 is logged.
Comprehensive Component Monitor-
XF Diagnostic process for Day Night Mode Activation
AM Frequency Stuck In FM Preset
AM Frequency Stuck In FM Preset
Title: 5.0L V8 (AJ133) overheating due to incorrect
Diagnostic Concerns.
Diagnostic Concerns.
HLDF Programming - `Candidate Not Available` message.
Title MOST system diagnosis
Attachment.
Attachment.
Attachment.
Unable to access SDD after installation of DVD131.04.
Image.
Image.
Check customers phone compatibility using the Jaguar.
Restricted Seat Travel.
SIM card activation issues
InControl Touch Pro phase 4 customer letter
Jaguar Land Rover Shop Foreman Conference Call
Presentation from Dealer Shop Foreman Conference Call
JAGUAR: DIRECTIONAL INDICATOR OPERATING WITH THE STALK IN THE CENTRAL POSITION.
Read full bulletin
IF CONDITION IS FOUND, REPLACE THE DIRECTIONAL INDICATOR SWITCH. NO MODEL YEARS LISTED. *PE
SLOW OPERATION OF THE CONVERTIBLE TOP, OR SLOW OR ERRATIC OPERATION OF THE LATCH.
Read full bulletin
SUPERSEDES BULLETIN 303-33, DATED 08/99. *TT
OVERHEATING - THERMOSTAT STUCK CLOSED - REVISED THERMOSTAT AVAILABLE.
Read full bulletin
*TT
Engine
9 bulletinsCUSTOMERS MAY COMPLAIN OF COOLANT LEAKING FROM THE HEATER HOSE.
Read full bulletin
*JB THIS BULLETIN REPLACED BULLETIN 303-48, DATED 02/02. *TT
JTB00268 engine hard to start after hot soak - fan running Category Driveability.
Door Lock Cylinder Cover - Fitment at PDI / Replacement.
JAGUAR: FUEL INJECTOR CONCERNS 5.O AJ133 GASOLINE, LEADING TO POTENTIAL PROBLEMSSUCH AS POOR RUNNING POOR FUEL ECONOMY,...
Read full bulletin
HARD STARTING, ROUGH IDLE, MISFIRES AND ENGINE DETONATION. *JS
JAGUAR SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER.
Read full bulletin
OPERATION OF THROTTLE WHILE IN CLOSED POSITION. CERTAIN VEHICLES HAVE BEEN IDENTIFIED WITH THE OPERATION OF THE THROTTLE. UNDER EXCEPTIONAL CIRCUMSTANCES THIS CONCERN COULD CAUSE THE ENGINE TO CUT OUT, ALTHOUGH THE ENGINE WILL CONTINUE TO BE DRIVEN BY THE ROAD WHEELS THROUGH THE TRANSMISSION DRIVE THE ANCILLARIES, SO THERE WILL BE NO LOSS OF POWER STEERING, BRAKES, AIR CONDITIONING, ETC. MODELS XJ AND XK. CSC LETTER WAS RECEIVED._x000D_ *PE
A RATTLE EMANATING FROM THE ENGINE ON START-UP AND IDLE.
Read full bulletin
*TT
CANISTER CLOSE VALVE (CCV) TO FILTER VAPOR PIPE HAS BEEN INTERNALLY CORRODING.
Read full bulletin
THIS SERVICE ACTION S841 SUPERSEDES SERVICE ACTION S837. *TT
DIFFICULT OR NON-START/HESITATION - NORMALLY ASPIRATED AJ 27 ENGINES - REFLASH ECM.
Read full bulletin
*TT
CHECK ENGINE MALFUNCTION INDICATOR LAMP - DIAGNOSTIC TROUBLE CODE P0121 FLAGGED - CONNECTOR MATERIAL MISMATCH - AJ27 ENGINES - MODIFY HARNESS.
Read full bulletin
*TT
Fuel System
8 bulletinsFuel Injector Concerns 5.0 AJ133 Gasoline.
Fuel Injector Concerns 5.0 AJ133 Gasoline.
Fuel Gauge / Pump Diagnostic Aids.
SDD enhancements for fuel gauge and pump issues-10MY onwards.
Fuel System Concerns.
Fuel sender unit fault - incorrect diagnosis.
EVAP DIAGNOSTIC TROUBLE CODE P0455 (GROSS LEAK) PRESENT - XK VEHICLES ONLY - BACKGROUND INFORMATION DIAGNOSIS.
Read full bulletin
*TT
FUEL VAPOR ODOR IN INTERIOR - CONVERTIBLE MODELS ONLY - REPAIR PROCEDURE.
Read full bulletin
*TT
Electrical
7 bulletinsCUSTOMERS MAY COMPLAIN OF AN INTERMITTENT FULLY DISCHARGED BATTERY.
Read full bulletin
*SLC
IN THE EVENT OF CUSTOMER COMPLAINTS OF INCIDENTS OF AN INTERMITTENT FULLY DISCHARGED BATTERY, A DIAGNOSTIC PROCEDURE MAY...
Read full bulletin
BE REQUIRED TO DETERMINE THE SOURCE OF POSSIBLE INTERMITTENT CURRENT DRAIN ON 1999 XK AND XJ MODELS. *TT
Instructions for jump starting vehicles with discharged battery?s
New vehicle storage (Transit relay / Transit mode)
Charging a vehicle fitted with Battery monitoring system
Loose battery terminals.
"ISSUE: WHEN INVESTIGATING CUSTOMER REPORTS FOR INCORRECT FUEL GAUGE CONCERNS THE DEALER TECHNICIAN MAY DIAGNOSE THAT...
Read full bulletin
THE FUEL SENDERS ARE OPEN CIRCUIT. THIS DIAGNOSIS MAY BE INCORRECT DEPENDING ON THE MULTIMETER SETTINGS SELECTED BY THE TECHNICIAN DURING MEASUREMENT. CAUSE: THE MULTI METER RANGE MAYBE SET AT 'AUTO' AND DURING A SWEEP OF THE SENDER FROM 50OHMS TO 998OHMS THE MULTI METER HAS TO CHANGE ITS MEASUREMENT RANGE. FOR APPROXIMATELY 1 SECOND, DURING THE RANGE SWITCH OVER POINT, THE MULTI METER DISPLAY INDICATES AN OPEN CIRCUIT. THIS IS INCORRECTLY BEING DIAGNOSED AS A SENDER FAULT"
Lighting
6 bulletinsTHIS BULLETIN INVOLVES REVISED CHMSL INSTALLATION PROCEDURE FOR THE CENTER HIGH MOUNTED STOP LAMP COVER ON CERTAIN CONVERTIBLE MODELS.
Read full bulletin
*JB
Cigar Lighter Elements Not Supplied.
Head Lamp / Fog Lamp - Discolouration / Distortion.
ISSUE: A CUSTOMER MAY RAISE A CONCERN OF THEIR VEHICLE NOT PASSING STATE INSPECTION IN CALIFORNIA AND THERE IS NO...
Read full bulletin
WARNING LIGHT OR OTHER SUGGESTION OF A FAULT.
CONDENSATION BUILD-UP IN THE HEADLAMP ASSEMBLIES.
Read full bulletin
INSTALL REVISED LENS. THIS BULLETIN REPLACES BULLETIN 417-06 DATED 07/03. *TT
A BUILD UP OF CONDENSATION IN THE HEADLAMP ASSEMBLY.
Read full bulletin
REPAIR PROCEDURE. THIS BULLETIN REPLACES BULLETIN 417-05 DATED 12/01. *TT
Software & Calibration
5 bulletinsDVD software update
Mongoose Update.
Mongoose Update
Important firmware update required for the DA Dongle /DA-VINA.
18C - New face of InControl Touch Pro and 18C software improvements
Transmission
4 bulletinsSELECTOR LEVER DIFFICULT TO SHIFT FROM PARK, BRAKE LAMP REMAINS LIT, REVISED BRAKE PEDAL AND SWITCH.*JB
Automatic transmission, rotary gear selector low level part
Steering Gear Transfer Pipe change
ZF Transmission ? Error message during reprogramming
Suspension
2 bulletins"ISSUE: DA-DONGLE/DA-VINA/DA-ST512 - J2534 VEHICLE COMMUNICATION INTERFACE DEVICE (VCI) SOFTWARE REQUIRES UPDATING TO THE LATEST LEVEL.
Read full bulletin
DA J2534 SOFTWARE DRIVER LEVEL V4.0 (MUST BE UPDATED TO THIS LEVEL ON ALL SDD MACHINES THAT USE THIS DEVICE) DA APP HUB LEVEL V2.4.0 (MUST BE UPDATED TO THIS LEVEL ON ALL SDD MACHINES THAT USE THIS DEVICE) DA FIRMWARE LEVEL V57. (ONLY NEEDS TO BE UPDATED ONCE TO EACH DEVICE, BECAUSE THIS IS HELD ON THE DEVICE ITSELF)"
LOWER WISHBONE FRONT BUSHING - CHANGE OF SPECIFICATION - SERVICE ACTION S499.
Read full bulletin
SUPERSEDES BULLETIN 204-S499, DATED 04/03. *TT
Tires & Wheels
1 bulletinVEHICLES MAY EXPERIENCE VIBRATION/SHIMMY IN THE TIRE ASSEMBLY, MODEL XK 2002 AND 2003.*JB
Steering
1 bulletinHIGH-PITCHED OR METALLIC NOISES FROM THE STEERING RACK AREA.
Read full bulletin
*TT
Air Bags & Safety
1 bulletinDiagnostic process for Drivers Airbag Warning Light
HVAC & Climate
1 bulletinClimate Controlled Seats Diagnosis & Testing
Body & Paint
1 bulletinHood / Bonnet Ajar Switch.
Infotainment
1 bulletinA customer may report "Hood Open" message displays on IP with hood closed.