2007 Jaguar XJ TSBs
80 Technical Service Bulletins across 15 categories
Categories
Other
31 bulletinsRear transport tow eye being left in place or not discarded
Diagnostic Concerns.
Title: 5.0L V8 (AJ133) overheating due to incorrect
Instrument Clusters require replacement.
Charge Air Hose assy detachment.
X351 Seat Memory Switch Number 1 Stuck High
Diagnostic Concerns.
HLDF Programming - `Candidate Not Available` message.
Error during key programing
Title MOST system diagnosis
Attachment.
Attachment.
Attachment.
Entertainment Systems.
Unable to access SDD after installation of DVD131.04.
Image.
Image.
SIM card activation issues
InControl Touch Pro phase 4 customer letter
Jaguar Land Rover Shop Foreman Conference Call
Presentation from Dealer Shop Foreman Conference Call
"ISSUE: COOLANT EXPANSION TANK STUB PIPE LEAKING ON XJ (X350), XK (X150) OR XF (X250) UP TO THE END OF 2009 MY.
Read full bulletin
CAUSE: THE DESIGN OF THE STUB PIPE WAS NOT ADEQUATE AND COULD RESULT IN THE PIPE SPLITTING."
"SITUATION: AN EARTH STUD MAY BE BROKEN OR CROSS THREADED.
Read full bulletin
CAUSE: THIS MAY BE CAUSED BY DAMAGE IN PRODUCTION OR DURING A REPAIR."
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
JAGUAR: DAMAGE DURING A REPAIR OR TIME OF PRODUCTION, CAUSED THE EARTH STUD, ON SOME VEHICLES, TO BECOME BROKEN OR CROSS THREADED.
Read full bulletin
MODEL 2003-2009 XJ (X350), 206/ONWARDS XK (X150), 2010/ONWARDS XJ (X351), 2014/ONWARDS F-TYPE (X152). *PE
JAGUAR: DIRECTIONAL INDICATOR OPERATING WITH THE STALK IN THE CENTRAL POSITION.
Read full bulletin
IF CONDITION IS FOUND, REPLACE THE DIRECTIONAL INDICATOR SWITCH. NO MODEL YEARS LISTED. *PE
Electrical
7 bulletinsCharging a vehicle fitted with Battery monitoring system
Loose battery terminals.
Front Control Display Interface Module Re-configuration.
"HELP WITH DIAGNOSING ANY ISSUES / FAULTS CAN BE GAINED BY PHONING YOUR JAGUAR TECHNICAL HELPLINE TO HELP US WITH OUR...
Read full bulletin
ANALYSIS PLEASE ENSURE THAT YOU HAVE THE FOLLOWING INFORMATION AVAILABLE BEFORE CONTACTING JAGUAR CARS: VIN VEHICLE TYPE AND MODEL DATE ACM WAS FITTED TO THE VEHICLE A CONCISE DESCRIPTION OF THE PROBLEM AND ITS REGULARITY OF OCCURANCE THE SOFTWARE LEVEL AND BUILD DATE COSE OF THE ACM FITTED. WORK PERFORMED ON THE VEHICLE TO SOLVE THE PROBLEM TO DATE IS THIS A PROBLEM SEEN IMMEDIATELY AFTER INSTALLATION IS IT PERMANENT HOW DOES THE PROBLEM DEMONSTRATE ITSELF WHAT I-POD IS THE CUSTOMER USING...ETC MANY THANKS FOR YOUR HELP TOPIX - SSM39290 - AUDIO CONNECTIVITY MODULE (ACM) PAGE 1 OF 1 HTTP://"
"ISSUE: JAGUAR LAND ROVER NORTH AMERICA SERVICE DIAGNOSTICS WOULD LIKE TO MAKE ALL SDD USERS AWARE OF AN EMERGING...
Read full bulletin
CONCERN BEING TRACKED VIA THE EPQR SYSTEM. USERS REPORT DVD133 IS UNABLE TO FULLY COMMUNICATE WITH PCM ON LEGACY JAGUAR VEHICLES, AND REGARDLESS OF PCM STATUS ICON DISPLAYED ON NETWORK SUMMARY SCREEN, SDD MAY NOT DISPLAY DTCS FROM THE PCM CAUSE: THIS ISSUE IS CURRENTLY UNDER INVESTIGATION IN THE UK AND WILL BE ADDRESSED ON A FUTURE SDD SOFTWARE UPDATE."
JAGUAR: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER.
Read full bulletin
INSTRUMENT CLUSTER (IC) NEEDS REPLACING DUE TO A FAULT WITH AIR SUSPENSION UNIT SPIKING AND CAUSING INSTRUMENT CLUSTER TO STAY AWAKE AND DRAIN BATTERY. MODELS 2005-2009 XJ. *PE
JAGUAR: INSTRUMENT CLUSTER NEEDS TO BE REPLACE DUE TO FAULT IN PREVIOUS INSTALLED INSTRUMENT CLUSTER THAT CAUSES A...
Read full bulletin
DRAINAGE IN BATTERY, APPROXIMATELY EVERY 30 MINUTES, IN CERTAIN VEHICLES. MODEL 2005-2009 XJ. *PE
Fuel System
7 bulletinsFuel Injector Concerns 5.0 AJ133 Gasoline.
Fuel Injector Concerns 5.0 AJ133 Gasoline.
Fuel Gauge / Pump Diagnostic Aids.
SDD enhancements for fuel gauge and pump issues-10MY onwards.
Fuel System Concerns.
VEHICLE QUARANTINE NOTICE.
Read full bulletin
FUEL TANK LEAK. RECALL R726. *KB
VEHICLE QUARANTINE NOTICE.
Read full bulletin
FUEL ODOR. FUEL TANK SYSTEM FLUID LEAK. CONSUMERS ARE ADVISED NOT TO DRIVE THERE VEHICLES. *KB
Infotainment
6 bulletinsUnable to Login to SDD - Recommended TOPIx browsers screen is displayed.
Infotainment System AV button greyed out.
Audio Amplifier Quiescent drain
Touch Screen Remote Control.
A customer may report "Hood Open" message displays on IP with hood closed.
NAVIGATION GPS ICON DRIFT.
Read full bulletin
*KB
Software & Calibration
6 bulletinsDVD software update
Mongoose Update.
Mongoose Update
Important firmware update required for the DA Dongle /DA-VINA.
18C - New face of InControl Touch Pro and 18C software improvements
JAGUAR: REAR DIFFERENTIAL REPLACEMENT.
Read full bulletin
DUE TO A CHANGE IN DESIGN, THE REAR DIFFERENTIAL HAS A NEW SERVICE PART. AS A RESULT, SHOULD THE REAR DIFFERENTIAL REQUIRE REPLACEMENT IT WILL BE NECESSARY TO CONVERT THE DRIVELINE SYSTEM TO USE THE NEW DIFFERENTIAL. *PE UPDATED 11/7/11. *PE
Engine
6 bulletinsJTB00268 engine hard to start after hot soak - fan running Category Driveability.
Engine-Compartment Lid Ajar Switch.
"SITUATION: ON VEHICLES FITTED WITH THE 4.2L NATURALLY ASPIRATED ENGINE ONLY, THE ENGINE MAY EXPERIENCE A ROUGH START...
Read full bulletin
OR STALL FOLLOWING A HOT SOAK OF 15-20 MINUTES. CAUSE: THIS MAY BE CAUSED BY THE FUELING CALIBRATION NOT BEING ROBUST FOR WINTER BLEND 10% ETHANOL FUEL."
"RE-ISSUED DEC 2015. ISSUE: FUEL INJECTORS CLOGGED LEADING TO POOR RUNNING / MISFIRES / ENGINE DETONATION ON AJ-V8 ENGINES.
Read full bulletin
CAUSE: POOR FUEL QUALITY OR FUEL CONTAMINANTS BLOCKING THE HOLES IN THE FUEL INJECTOR."
"SITUATION: ON VEHICLES FITTED WITH THE 4.2L NATURALLY ASPIRATED ENGINE ONLY, THE ENGINE MAY EXPERIENCE A ROUGH START OR...
Read full bulletin
STALL FOLLOWING A HOT SOAK OF 15-20 MINUTES. CAUSE: THIS MAY BE CAUSED BY THE FUELING CALIBRATION NOT BEING ROBUST FOR WINTER BLEND 10% ETHANOL FUEL."
JAGUAR: TIRE VALVE STEM DAMAGE DURING MANUAL TIRE PRESSURE CHECKING OR LOW TIRE PRESSURE WARNINGS ILLUMINATED-REPAIR PROCEDURE.
Read full bulletin
ON VEHICLES FITTED WITH TIRE PRESSURE MONITORING SYSTEM (TPMS) ONLY, THE FOLLOWING ISSUES HAVE BEEN IDENTIFIED-VALVE STEM MAY BE DAMAGED DURING MANUAL TIRE PRESSURE CHECKING WHEN EITHER THE VALVE CAP IS REMOVED OR WHEN AN AIRLINE IS ATTACHED; THE LOW TIRE PRESSURE WARNING WILL BE ILLUMINATED AND ASSOCIATED INSTRUMENT PACK MESSAGES DISPLAYED. MODELS XF, XJ, XK. *PE
Lighting
5 bulletinsCigar Lighter Elements Not Supplied.
Head Lamp / Fog Lamp - Discolouration / Distortion.
"RE-ISSUED DEC 2015. PLEASE NOTE THAT AS YET JAGUAR VEHICLES WITH BULB FAILURE MONITORING SYSTEMS FOR TRAILER LIGHT...
Read full bulletin
FAILURE SENSING ARE NOT COMPATIBLE WITH TRAILER LIGHT BOARDS THAT HAVE LED BASED ILLUMINATION. AS A RESULT OF THIS THE LED LIGHTING ON THE TRAILER BOARD MAY FLICKER DURING THE SENSING FUNCTION. (THIS ISSUES WILL ALSO PRESENT ITSELF IF FITTING LED REAR LIGHT CLUSTERS AVAILABLE IN THE AFTERMARKET(NON-JAGUAR APPROVED ACCESSORY) BASED UPON THIS WE RECOMMEND THAT TRAILER LIGHT BOARDS WITH STANDARD INCANDESCENT BULBS ONLY ARE FITTED."
ISSUE: A CUSTOMER MAY RAISE A CONCERN OF THEIR VEHICLE NOT PASSING STATE INSPECTION IN CALIFORNIA AND THERE IS NO...
Read full bulletin
WARNING LIGHT OR OTHER SUGGESTION OF A FAULT.
CONCERNS OF THE TAIL LAMP BEZEL COMING AWAY FROM THE TAIL LAMP.
Read full bulletin
*TT ADHESIVE REPAIR PROCEDURE. UPDATED 11/07/07. *NJ
HVAC & Climate
3 bulletinsClimate Controlled Seats Diagnosis & Testing
Lack of Cooling From Air Conditioning
Lack of Cooling From Air Conditioning
Body & Paint
2 bulletinsEarth Stud Repair on Aluminum Body
Hood / Bonnet Ajar Switch.
Pre-Delivery & Maintenance
2 bulletinsService Action: Instrument Cluster Replacement
JAGUAR: THERE ARE NEW PRE-DELIVERY INSPECTION ITEMS FOR ALL XJ MODELS.
Read full bulletin
*RM
Transmission
1 bulletinZF Transmission ? Error message during reprogramming
Suspension
1 bulletin"ISSUE: DA-DONGLE/DA-VINA/DA-ST512 - J2534 VEHICLE COMMUNICATION INTERFACE DEVICE (VCI) SOFTWARE REQUIRES UPDATING TO THE LATEST LEVEL.
Read full bulletin
DA J2534 SOFTWARE DRIVER LEVEL V4.0 (MUST BE UPDATED TO THIS LEVEL ON ALL SDD MACHINES THAT USE THIS DEVICE) DA APP HUB LEVEL V2.4.0 (MUST BE UPDATED TO THIS LEVEL ON ALL SDD MACHINES THAT USE THIS DEVICE) DA FIRMWARE LEVEL V57. (ONLY NEEDS TO BE UPDATED ONCE TO EACH DEVICE, BECAUSE THIS IS HELD ON THE DEVICE ITSELF)"
Steering
1 bulletinSITUATION: A STEERING WHEEL SHIMMY MAY BE EVIDENT DURING THE PRE-DELIVERY INSPECTION (PDI) ROAD TEST DUE TO TEMPORARY...
Read full bulletin
FLAT SPOTS ON THE ROLLING SURFACE OF THE TIRE. CAUSE: TEMPORARY FLAT SPOTS NATURALLY DEVELOP ON THE ROLLING SURFACE OF A TIRE WHEN THE WHEELS OF THE VEHICLE ARE STATIONARY OVER A PERIOD OF TIME.
Brakes
1 bulletinJAGUAR: ELECTRONIC PARKING BRAKE RE-CALIBRATION PROCEDURE.
Read full bulletin
*RM UPDATED 10/17/14. *PE
Tires & Wheels
1 bulletinPERMANENT HIGH SPOT MARKING TO TIRE INBOARD SIDEWALL.
Read full bulletin
*KB