2003 Jaguar XJ TSBs
73 Technical Service Bulletins across 13 categories
Categories
Other
28 bulletinsRear transport tow eye being left in place or not discarded
Diagnostic Concerns.
Title: 5.0L V8 (AJ133) overheating due to incorrect
Charge Air Hose assy detachment.
X351 Seat Memory Switch Number 1 Stuck High
Diagnostic Concerns.
HLDF Programming - `Candidate Not Available` message.
Error during key programing
Title MOST system diagnosis
Attachment.
Attachment.
Attachment.
Entertainment Systems.
Unable to access SDD after installation of DVD131.04.
Image.
Image.
SIM card activation issues
InControl Touch Pro phase 4 customer letter
Jaguar Land Rover Shop Foreman Conference Call
Presentation from Dealer Shop Foreman Conference Call
"ISSUE: COOLANT EXPANSION TANK STUB PIPE LEAKING ON XJ (X350), XK (X150) OR XF (X250) UP TO THE END OF 2009 MY.
Read full bulletin
CAUSE: THE DESIGN OF THE STUB PIPE WAS NOT ADEQUATE AND COULD RESULT IN THE PIPE SPLITTING."
"SITUATION: AN EARTH STUD MAY BE BROKEN OR CROSS THREADED.
Read full bulletin
CAUSE: THIS MAY BE CAUSED BY DAMAGE IN PRODUCTION OR DURING A REPAIR."
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
JAGUAR: DAMAGE DURING A REPAIR OR TIME OF PRODUCTION, CAUSED THE EARTH STUD, ON SOME VEHICLES, TO BECOME BROKEN OR CROSS THREADED.
Read full bulletin
MODEL 2003-2009 XJ (X350), 206/ONWARDS XK (X150), 2010/ONWARDS XJ (X351), 2014/ONWARDS F-TYPE (X152). *PE
JAGUAR: DIRECTIONAL INDICATOR OPERATING WITH THE STALK IN THE CENTRAL POSITION.
Read full bulletin
IF CONDITION IS FOUND, REPLACE THE DIRECTIONAL INDICATOR SWITCH. NO MODEL YEARS LISTED. *PE
CHIRPING NOISE FROM ACCESSORY DRIVE BELT - MISALIGNED BELT - REPLACE FEAD TENSIONER.
Read full bulletin
*TT
COOLANT PUMPS - IDENTIFYING IMPELLER MATERIAL - PUMP REPLACEMENT GUIDELINES.
Read full bulletin
THIS BULLETIN REPLACES BULLETIN 303-60, DATED 02/03. *TT
Engine
8 bulletinsECM (ENGINE CONTROL MODULE) REPLACEMENT - ENGINE MANAGEMENT QUESTIONAIRE REPORTING REQUIREMENTS.
Read full bulletin
*TT THIS BULLETIN REPLACED BULLETIN 303-34, DATED 10/99. *TT
JTB00268 engine hard to start after hot soak - fan running Category Driveability.
"RE-ISSUED DEC 2015. ISSUE: FUEL INJECTORS CLOGGED LEADING TO POOR RUNNING / MISFIRES / ENGINE DETONATION ON AJ-V8 ENGINES.
Read full bulletin
CAUSE: POOR FUEL QUALITY OR FUEL CONTAMINANTS BLOCKING THE HOLES IN THE FUEL INJECTOR."
JAGUAR: FUEL FILLER CAP DIFFICULT TO INSTALL.
Read full bulletin
CHECK ENGINE MIL ON - REVISED FUEL FILLER CAP. MODEL XJ (X308) AND XK (X100). *PE
FUEL FILLER CAP DIFFICULT TO INSTALL / CHECK ENGINE MALFUNCTION INDICATOR LAMP (MIL) ON - REVISED FUEL FILLER CAP - SERVICE ACTION S509.
Read full bulletin
*TT
SHIFT QUALITY ISSUES/HARSH ENGAGEMENT WITH ENGINE COLD - ZAP - INSTALL NEW TRANSMISSION CONTROL MODULE.
Read full bulletin
*TTT
CORROSION IN ELECTRICAL CONNECTORS, LOCATED IN THE ENGINE COMPARTMENT, THAT SUPPLY POWER TO THE HEATED WINDSHIELD.
Read full bulletin
THIS BULLETIN REPLACES BULLETIN 418-08, AMENDED 02/02. *TT
STEERING RACK KNOCKING OR RATTLING - REVISED LOWER STEERING COLUMN/RACK RETURN LINE - REPAIR PROCEDURE.
Read full bulletin
*TT
Fuel System
7 bulletinsFuel Injector Concerns 5.0 AJ133 Gasoline.
Fuel Injector Concerns 5.0 AJ133 Gasoline.
Fuel Gauge / Pump Diagnostic Aids.
SDD enhancements for fuel gauge and pump issues-10MY onwards.
Fuel System Concerns.
JAGUAR SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER.
Read full bulletin
CSC LETTER WAS RECEIVED FOR MODELS XJ AND XK, MODEL YEARS 2001-2003. MAY REQUIRE AN INCREASED EFFORT TO TIGHTEN SUFFICIENTLY. REPLACE FUEL FILLER CAP WITH REVISED DESIGNED. *PE
DIFFICULTY FILLING FUEL TANK - FUEL GAUGE NOT INDICATING FULL - SPIT BACK/PREMATURE SHUT OFF - DIAGNOSIS.
Read full bulletin
2000-03 MY XJR. *TT
Infotainment
5 bulletinsUnable to Login to SDD - Recommended TOPIx browsers screen is displayed.
Infotainment System AV button greyed out.
Audio Amplifier Quiescent drain
Touch Screen Remote Control.
A customer may report "Hood Open" message displays on IP with hood closed.
Software & Calibration
5 bulletinsDVD software update
Mongoose Update.
Mongoose Update
Important firmware update required for the DA Dongle /DA-VINA.
18C - New face of InControl Touch Pro and 18C software improvements
Electrical
5 bulletinsCharging a vehicle fitted with Battery monitoring system
Loose battery terminals.
Front Control Display Interface Module Re-configuration.
"HELP WITH DIAGNOSING ANY ISSUES / FAULTS CAN BE GAINED BY PHONING YOUR JAGUAR TECHNICAL HELPLINE TO HELP US WITH OUR...
Read full bulletin
ANALYSIS PLEASE ENSURE THAT YOU HAVE THE FOLLOWING INFORMATION AVAILABLE BEFORE CONTACTING JAGUAR CARS: VIN VEHICLE TYPE AND MODEL DATE ACM WAS FITTED TO THE VEHICLE A CONCISE DESCRIPTION OF THE PROBLEM AND ITS REGULARITY OF OCCURANCE THE SOFTWARE LEVEL AND BUILD DATE COSE OF THE ACM FITTED. WORK PERFORMED ON THE VEHICLE TO SOLVE THE PROBLEM TO DATE IS THIS A PROBLEM SEEN IMMEDIATELY AFTER INSTALLATION IS IT PERMANENT HOW DOES THE PROBLEM DEMONSTRATE ITSELF WHAT I-POD IS THE CUSTOMER USING...ETC MANY THANKS FOR YOUR HELP TOPIX - SSM39290 - AUDIO CONNECTIVITY MODULE (ACM) PAGE 1 OF 1 HTTP://"
"ISSUE: JAGUAR LAND ROVER NORTH AMERICA SERVICE DIAGNOSTICS WOULD LIKE TO MAKE ALL SDD USERS AWARE OF AN EMERGING...
Read full bulletin
CONCERN BEING TRACKED VIA THE EPQR SYSTEM. USERS REPORT DVD133 IS UNABLE TO FULLY COMMUNICATE WITH PCM ON LEGACY JAGUAR VEHICLES, AND REGARDLESS OF PCM STATUS ICON DISPLAYED ON NETWORK SUMMARY SCREEN, SDD MAY NOT DISPLAY DTCS FROM THE PCM CAUSE: THIS ISSUE IS CURRENTLY UNDER INVESTIGATION IN THE UK AND WILL BE ADDRESSED ON A FUTURE SDD SOFTWARE UPDATE."
Lighting
4 bulletinsCigar Lighter Elements Not Supplied.
Head Lamp / Fog Lamp - Discolouration / Distortion.
"RE-ISSUED DEC 2015. PLEASE NOTE THAT AS YET JAGUAR VEHICLES WITH BULB FAILURE MONITORING SYSTEMS FOR TRAILER LIGHT...
Read full bulletin
FAILURE SENSING ARE NOT COMPATIBLE WITH TRAILER LIGHT BOARDS THAT HAVE LED BASED ILLUMINATION. AS A RESULT OF THIS THE LED LIGHTING ON THE TRAILER BOARD MAY FLICKER DURING THE SENSING FUNCTION. (THIS ISSUES WILL ALSO PRESENT ITSELF IF FITTING LED REAR LIGHT CLUSTERS AVAILABLE IN THE AFTERMARKET(NON-JAGUAR APPROVED ACCESSORY) BASED UPON THIS WE RECOMMEND THAT TRAILER LIGHT BOARDS WITH STANDARD INCANDESCENT BULBS ONLY ARE FITTED."
ISSUE: A CUSTOMER MAY RAISE A CONCERN OF THEIR VEHICLE NOT PASSING STATE INSPECTION IN CALIFORNIA AND THERE IS NO...
Read full bulletin
WARNING LIGHT OR OTHER SUGGESTION OF A FAULT.
HVAC & Climate
3 bulletinsClimate Controlled Seats Diagnosis & Testing
Lack of Cooling From Air Conditioning
Lack of Cooling From Air Conditioning
Tires & Wheels
2 bulletinsVEHICLES MAY EXPERIENCE VIBRATION/SHIMMY IN THE TIRE ASSEMBLY, MODEL XK 2002 AND 2003.*JB
VIBRATION/SHIMMY - TIRE RADIAL FORCE VARIATION - OPTIMIZING WHEELS AND TIRES.
Read full bulletin
*TT THIS BULLETIN SUPERSEDES BULLETIN 204-17, DATED 4/02. *TT
Body & Paint
2 bulletinsEarth Stud Repair on Aluminum Body
Hood / Bonnet Ajar Switch.
Suspension
2 bulletins"ISSUE: DA-DONGLE/DA-VINA/DA-ST512 - J2534 VEHICLE COMMUNICATION INTERFACE DEVICE (VCI) SOFTWARE REQUIRES UPDATING TO THE LATEST LEVEL.
Read full bulletin
DA J2534 SOFTWARE DRIVER LEVEL V4.0 (MUST BE UPDATED TO THIS LEVEL ON ALL SDD MACHINES THAT USE THIS DEVICE) DA APP HUB LEVEL V2.4.0 (MUST BE UPDATED TO THIS LEVEL ON ALL SDD MACHINES THAT USE THIS DEVICE) DA FIRMWARE LEVEL V57. (ONLY NEEDS TO BE UPDATED ONCE TO EACH DEVICE, BECAUSE THIS IS HELD ON THE DEVICE ITSELF)"
REVISED FRONT BUSHINGS - REVISED SPECIAL TOOLS - REPLACEMENT PROCEDURE.
Read full bulletin
*TT THIS BULLETIN REPLACES BULLETIN 204-11,DATED 02/00. *TT THIS BULLETIN REPLACES BULLETIN 204-11,DATED 02/01. *TT
Transmission
1 bulletinZF Transmission ? Error message during reprogramming
Pre-Delivery & Maintenance
1 bulletinJAGUAR: THERE ARE NEW PRE-DELIVERY INSPECTION ITEMS FOR ALL XJ MODELS.
Read full bulletin
*RM