2004 Jaguar X-Type TSBs
65 Technical Service Bulletins across 14 categories
Categories
Other
20 bulletinsDiagnostic Concerns.
Vehicle Communication Device fails to communicate
Diagnostic Concerns.
Error during key programing
Attachment.
Attachment.
Attachment.
Unable to access SDD after installation of DVD131.04.
Image.
Image.
Check customers phone compatibility using the Jaguar.
SIM card activation issues
InControl Touch Pro phase 4 customer letter
Jaguar Land Rover Shop Foreman Conference Call
Presentation from Dealer Shop Foreman Conference Call
JAGUAR: KEY FOB REMOTE CORRECTIVE MODIFICATION.
Read full bulletin
THE REMOTE CONTROL KEY FOB FAILS TO OPERATE LEADING TO CUSTOMERS USING THE MECHANICAL KEY BLADE TO LOCK/UNLOCK THE VEHICLE, AND TO TURN OFF THE ALARM. CSC LETTER WAS RECEIVED. *PE
TONNEAU COVER BAR- LOCATING PEGS LOOSE/SHEARED.
Read full bulletin
*KB
DRIVELINE WHINE PRELIMINARY CHECKS.
Read full bulletin
*EH
INABILITY TO OPEN CLOSE LUGGAGE COMPARTMENT LID ACTUATOR BINDING REVISED ACTUATOR AVAILABLE.
Read full bulletin
*EH
WASHER FLUID LEAK AT ELBOWS REPAIR PROCEDURE.
Read full bulletin
*EH
Software & Calibration
9 bulletinsSoftware update 06
Diagnostic Software Hardware
DVD software update
Mongoose Update.
Mongoose Update
Important firmware update required for the DA Dongle /DA-VINA.
18C - New face of InControl Touch Pro and 18C software improvements
PREMATURE FRONT SEAT BACKREST WEAR ON CLASSIC STYLE SEATS - OUTER BOLSTER SUPPORT WIRE - MODIFICATION PROCEDURE.
Read full bulletin
UPDATE. *TT ORIGINAL. *TT
DRIVESHAFT VIBRATION DIAGNOSTIC METHOD REPAIR.
Read full bulletin
*EH UPDATE. *TT AMENDED VERSION 09/04. *TT
Electrical
6 bulletinsThis update contains a software update for the HD RADIO? module
"HELP WITH DIAGNOSING ANY ISSUES / FAULTS CAN BE GAINED BY PHONING YOUR JAGUAR TECHNICAL HELPLINE TO HELP US WITH OUR...
Read full bulletin
ANALYSIS PLEASE ENSURE THAT YOU HAVE THE FOLLOWING INFORMATION AVAILABLE BEFORE CONTACTING JAGUAR CARS: VIN VEHICLE TYPE AND MODEL DATE ACM WAS FITTED TO THE VEHICLE A CONCISE DESCRIPTION OF THE PROBLEM AND ITS REGULARITY OF OCCURANCE THE SOFTWARE LEVEL AND BUILD DATE COSE OF THE ACM FITTED. WORK PERFORMED ON THE VEHICLE TO SOLVE THE PROBLEM TO DATE IS THIS A PROBLEM SEEN IMMEDIATELY AFTER INSTALLATION IS IT PERMANENT HOW DOES THE PROBLEM DEMONSTRATE ITSELF WHAT I-POD IS THE CUSTOMER USING...ETC MANY THANKS FOR YOUR HELP TOPIX - SSM39290 - AUDIO CONNECTIVITY MODULE (ACM) PAGE 1 OF 1 HTTP://"
"ISSUE: WHEN INVESTIGATING CUSTOMER REPORTS FOR INCORRECT FUEL GAUGE CONCERNS THE DEALER TECHNICIAN MAY DIAGNOSE THAT...
Read full bulletin
THE FUEL SENDERS ARE OPEN CIRCUIT. THIS DIAGNOSIS MAY BE INCORRECT DEPENDING ON THE MULTIMETER SETTINGS SELECTED BY THE TECHNICIAN DURING MEASUREMENT. CAUSE: THE MULTI METER RANGE MAYBE SET AT 'AUTO' AND DURING A SWEEP OF THE SENDER FROM 50OHMS TO 998OHMS THE MULTI METER HAS TO CHANGE ITS MEASUREMENT RANGE. FOR APPROXIMATELY 1 SECOND, DURING THE RANGE SWITCH OVER POINT, THE MULTI METER DISPLAY INDICATES AN OPEN CIRCUIT. THIS IS INCORRECTLY BEING DIAGNOSED AS A SENDER FAULT"
"ISSUE: JAGUAR LAND ROVER NORTH AMERICA SERVICE DIAGNOSTICS WOULD LIKE TO MAKE ALL SDD USERS AWARE OF AN EMERGING...
Read full bulletin
CONCERN BEING TRACKED VIA THE EPQR SYSTEM. USERS REPORT DVD133 IS UNABLE TO FULLY COMMUNICATE WITH PCM ON LEGACY JAGUAR VEHICLES, AND REGARDLESS OF PCM STATUS ICON DISPLAYED ON NETWORK SUMMARY SCREEN, SDD MAY NOT DISPLAY DTCS FROM THE PCM CAUSE: THIS ISSUE IS CURRENTLY UNDER INVESTIGATION IN THE UK AND WILL BE ADDRESSED ON A FUTURE SDD SOFTWARE UPDATE."
MEMORY SEATS - FRONT SEAT HARNESS INTERFERENCE WITH ADJUSTER MECHANISM - SERVICE ACTION S951.
Read full bulletin
*TT
INSPECTION OF FUEL TANK HARNESS - POSSIBLE CONNECTOR DAMAGE - SERVICE ACTION S947.
Read full bulletin
*TT
Body & Paint
6 bulletinsINSTALLATION OF LATCH FOR LIFTGATE GLASS - LUBRICATE REPLACEMENT LATCHES - LUBRICATION METHOD.
Read full bulletin
*TT
WASHER FLUID LEAKAGE AT FRONT FENDER LEAK AT ELBOWS REPAIR PROCEDURE.
Read full bulletin
*EH
WATER LEAKS IN REAR OF WAGON VEHICLES POSSIBLE CAUSES OF WATER ENTRY REPAIR TECHNIQUES.
Read full bulletin
*EH
LIFTGATE SPOILER CONTACTING ROOF HIGH AMBIENT TEMPERATURES CANADIAN VEHICLES SERVICE ACTION S952.
Read full bulletin
*EH REPLACE SERVICE BULLETIN XT501S952 DATED 06/04. *EH
CREAK SQUEAK WHEN OPENING LIFTGATE OR GLASS LUBRICATE CLEVIS PINS REPAIR PROCEDURE.
Read full bulletin
*EH
LIFTGATE GLASS HARD TO CLOSE REAR WIPER INOPERATIVE CHECK ADJUSTMENT PROCEDURE.
Read full bulletin
*EH
Infotainment
5 bulletinsUnable to Login to SDD - Recommended TOPIx browsers screen is displayed.
Audio System Speaker Diagnosis
A customer may report "Hood Open" message displays on IP with hood closed.
"ISSUE: THIS SSM HAS BEEN RELEASED TO ADDRESS THE HIGH NUMBER OF SPEAKER ASSEMBLIES RETURNED, MANY OF WHICH ARE DEEMED AS NO FAULT FOUND.
Read full bulletin
CAUSE: INCORRECT DIAGNOSIS."
THIS SSM HAS BEEN RELEASED TO ADDRESS THE HIGH NUMBER OF SPEAKER ASSEMBLIES RETURNED, MANY OF WHICH ARE DEEMED AS N FAULT FOUND.
Read full bulletin
CAUSE: INCORRECT DIAGNOSIS."
Lighting
4 bulletins"RE-ISSUED DEC 2015. PLEASE NOTE THAT AS YET JAGUAR VEHICLES WITH BULB FAILURE MONITORING SYSTEMS FOR TRAILER LIGHT...
Read full bulletin
FAILURE SENSING ARE NOT COMPATIBLE WITH TRAILER LIGHT BOARDS THAT HAVE LED BASED ILLUMINATION. AS A RESULT OF THIS THE LED LIGHTING ON THE TRAILER BOARD MAY FLICKER DURING THE SENSING FUNCTION. (THIS ISSUES WILL ALSO PRESENT ITSELF IF FITTING LED REAR LIGHT CLUSTERS AVAILABLE IN THE AFTERMARKET(NON-JAGUAR APPROVED ACCESSORY) BASED UPON THIS WE RECOMMEND THAT TRAILER LIGHT BOARDS WITH STANDARD INCANDESCENT BULBS ONLY ARE FITTED."
ISSUE: A CUSTOMER MAY RAISE A CONCERN OF THEIR VEHICLE NOT PASSING STATE INSPECTION IN CALIFORNIA AND THERE IS NO...
Read full bulletin
WARNING LIGHT OR OTHER SUGGESTION OF A FAULT.
DYNAMIC STABILITY CONTROL (DSC) LAMP ILLUMINATED AFTER CRANKING.
Read full bulletin
*KB UPDATED 4/28/08. *NJ
CONDENSATION IN HEADLAMPS REVISED CAP AVAILABLE REPAIR PROCEDURE.
Read full bulletin
*EH
Fuel System
3 bulletinsFuel System Concerns.
Fuel sender unit fault - incorrect diagnosis.
JAGUAR: NON COMPLIANCE ISSUES RELATING TO ON BOARD DIAGNOSTIC (OBD) SYSTEM FUNCTION COVERING THERMOSTAT DIAGNOSTIC,...
Read full bulletin
CALIBRATION VERIFICATION, IN USE MONITOR PERFORMANCE RATIO, AND AN EMISSION ISSUE RELATING TO OPEN LOOP SMOOTHING HAVE BEEN IDENTIFIED. *PE
Steering
3 bulletinsPOWER ASSIST STEERING LEAK/HEAVY/NOISY - DIAGNOSTIC AID.
Read full bulletin
*NJ
SQUEAKING NOISE POWER STEERING REPAIR PROCEDURE.
Read full bulletin
*AK
SQUEAKING NOISE POWER STEERING SYSTEM FLUSH SYSTEM.
Read full bulletin
*EH
Suspension
2 bulletins"ISSUE: DA-DONGLE/DA-VINA/DA-ST512 - J2534 VEHICLE COMMUNICATION INTERFACE DEVICE (VCI) SOFTWARE REQUIRES UPDATING TO THE LATEST LEVEL.
Read full bulletin
DA J2534 SOFTWARE DRIVER LEVEL V4.0 (MUST BE UPDATED TO THIS LEVEL ON ALL SDD MACHINES THAT USE THIS DEVICE) DA APP HUB LEVEL V2.4.0 (MUST BE UPDATED TO THIS LEVEL ON ALL SDD MACHINES THAT USE THIS DEVICE) DA FIRMWARE LEVEL V57. (ONLY NEEDS TO BE UPDATED ONCE TO EACH DEVICE, BECAUSE THIS IS HELD ON THE DEVICE ITSELF)"
LUGGAGE COMPARTMENT LID NOT OPENING CORRECTLY SPRING ACTUATORS INSTALL REVISED PARTS.
Read full bulletin
*EH
HVAC & Climate
2 bulletinsWINDSHIELD HEATER INOPERATIVE.
Read full bulletin
*KB
VEHICLE FOGGING/CLIMATE CONTROL SLOW TO COOL VEHICLE - AIR BLEND DOOR LOOSE - REPAIR PROCEDURE.
Read full bulletin
*TT
Transmission
2 bulletinsDRIVELINE SHUDDER/HESITATION - 30 - 50 MPH - AUTOMATIC TRANSMISSION VEHICLES - REPROGRAM ECM - SERVICE ACTION S953.
Read full bulletin
*TT
DIFFICULT ENGAGING FIRST OR REVERSE GEAR, ESPECIALLY WHEN THE VEHICLE IS COLD.
Read full bulletin
*TT
Tires & Wheels
1 bulletinPERMANENT HIGH SPOT MARKING TO TIRE INBOARD SIDEWALL.
Read full bulletin
*KB
Engine
1 bulletinCOOLANT LEAK FROM THERMOSTAT HOUSING - SUPPLEMENTAL REPAIR TO SERVICE ACTION S939.
Read full bulletin
*TT
Pre-Delivery & Maintenance
1 bulletinREMOTE TRANSMITTER NOT FUNCTIONING INTERNAL CHIP FAULT REPLACE TRANSMITTER.
Read full bulletin
*EH REPLACE SERVICE BULLETIN XT501-10 DATED 01/04. *EH