2004 Jaguar S-Type TSBs
64 Technical Service Bulletins across 14 categories
Categories
Other
18 bulletinsDiagnostic Concerns.
Vehicle Communication Device fails to communicate
Diagnostic Concerns.
Error during key programing
Attachment.
Attachment.
Attachment.
Unable to access SDD after installation of DVD131.04.
Image.
Image.
SIM card activation issues
InControl Touch Pro phase 4 customer letter
Jaguar Land Rover Shop Foreman Conference Call
Presentation from Dealer Shop Foreman Conference Call
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
JAGUAR: DIRECTIONAL INDICATOR OPERATING WITH THE STALK IN THE CENTRAL POSITION.
Read full bulletin
IF CONDITION IS FOUND, REPLACE THE DIRECTIONAL INDICATOR SWITCH. NO MODEL YEARS LISTED. *PE
JAGUAR: KEY FOB REMOTE CORRECTIVE MODIFICATION.
Read full bulletin
THE REMOTE CONTROL KEY FOB FAILS TO OPERATE LEADING TO CUSTOMERS USING THE MECHANICAL KEY BLADE TO LOCK/UNLOCK THE VEHICLE, AND TO TURN OFF THE ALARM. CSC LETTER WAS RECEIVED. *PE
THUMP FROM REAR OF VEHICLE DIFFERENTIAL MOUNT BRUSHINGS INSTALL BRUSHING INSERTS.
Read full bulletin
*EH THIS BULLETIN REPLACES S10010 DATED 03/04. *EH
Engine
8 bulletins"RE-ISSUED DEC 2015. ISSUE: FUEL INJECTORS CLOGGED LEADING TO POOR RUNNING / MISFIRES / ENGINE DETONATION ON AJ-V8 ENGINES.
Read full bulletin
CAUSE: POOR FUEL QUALITY OR FUEL CONTAMINANTS BLOCKING THE HOLES IN THE FUEL INJECTOR."
V6 ENGINE MALFUNCTION INDICATOR LAMP (MIL) ON/ WITH DIAGNOSTIC TROUBLE CODE (DTC) P0332 - WATER ENTRY IN KNOCK SENSOR...
Read full bulletin
CONNECTOR - INSTALL SEALING PATCH. *TT
BUZZING KNOCKING NOISE AFTER START OR WITH IGNITION ON ADAPTIVE SPEED CONTROL MODULE REPAIR PROCEDURE.
Read full bulletin
*EH
ROUGH IDLE, RESTRICTED PERFORMANCE, AND POOR HARSH TRANSMISSION SHIFTS.
Read full bulletin
DIAGNOSTIC TROUBLE CODES P0174, P0171, P0301 TO P0308, P1316 AND P1582 MAY BE STORED IN THE ENGINE CONTROL MODULE (ECM). *TT
OIL LEAK FROM ENGINE OIL DRAIN PLUG V8 ENGINE SERVICE ACTION S511.
Read full bulletin
*TT
HARSH TRANSMISSION SHIFTS ADAPTIVE SHIFT STRATEGY DRIFT REPROGRAM TRANSMISSION CONTROL MODULE & ENGINE CONTROL MODULE.
Read full bulletin
*EH UPDATE. *TT
ENGINE IN LIMP HOME/CHECK ENGINE MALFUNCTION INDICATOR LAMP (MIL) - WATER INGRESS INTO THROTTLE POSITION SENSOR - SERVICE ACTION S159.
Read full bulletin
*TT
DRIVE BELT NOISE AFTER COLD START SUPERCHARGER REVISED DRIVE BELT AVAILABLE.
Read full bulletin
*EH
Software & Calibration
7 bulletinsDiagnostic Software Hardware
DVD software update
Mongoose Update.
Mongoose Update
Important firmware update required for the DA Dongle /DA-VINA.
18C - New face of InControl Touch Pro and 18C software improvements
JAGUAR: REAR DIFFERENTIAL REPLACEMENT.
Read full bulletin
DUE TO A CHANGE IN DESIGN, THE REAR DIFFERENTIAL HAS A NEW SERVICE PART. AS A RESULT, SHOULD THE REAR DIFFERENTIAL REQUIRE REPLACEMENT IT WILL BE NECESSARY TO CONVERT THE DRIVELINE SYSTEM TO USE THE NEW DIFFERENTIAL. *PE UPDATED 11/7/11. *PE
Fuel System
6 bulletinsFuel System Concerns.
JAGUAR: NON COMPLIANCE ISSUES RELATING TO ON BOARD DIAGNOSTIC (OBD) SYSTEM FUNCTION COVERING THERMOSTAT DIAGNOSTIC,...
Read full bulletin
CALIBRATION VERIFICATION, IN USE MONITOR PERFORMANCE RATIO, AND AN EMISSION ISSUE RELATING TO OPEN LOOP SMOOTHING HAVE BEEN IDENTIFIED. *PE
FUEL GAUGE FAILURE OR INTERMITTENT OPERATION - FUEL LEVEL SENDER AVAILABLE SEPARATELY - REPLACEMENT PROCEDURE.
Read full bulletin
*TT FUEL LEVEL SENDER-AVAILABLE SEPARATELY FROM PUMP-REPLACEMENT PROCEDURE. *SC
ERRATIC FUEL GAUGE READING FUEL TANK SENDER.
Read full bulletin
*EH
ERRATIC FUEL GAUGE READING FUEL TANK SENDER.
Read full bulletin
*EH
CLIMATE CONTROL SYSTEM LOCKUP 23 DEGREES C DISPLAYED CONTINUOUSLY UPDATE TELEMATICS SOFTWARE.
Read full bulletin
*EH
Brakes
5 bulletins"CONCERN: REPLACEMENT OF ANY ANTI-LOCK BRAKE SYSTEM (ABS) CONTROL MODULE DOES NOT FIX THE CONCERN ISSUE: VARIOUS...
Read full bulletin
WARNING LIGHTS AND MESSAGES APPEAR IN THE (IPK) AND A CONSTANT BEEPING TONE FROM PARK BRAKE WARNING FROM THE (IPK), DIAGNOSTIC TROUBLE CODES (DTCS) RECORDED ARE: POWERTRAIN CONTROL MODULE (PCM) & PARK BRAKE MODULE (PBM)"
JAGUAR: WARNING LIGHTS AND MESSAGES BEING DISPLAYED IN INSTRUMENT PACK (IPK), WITH CONSTANT BEEPING TONE FROM PARK BRAKE WARNING.
Read full bulletin
MODEL S TYPE (X200). NO MODEL YEAR. *PE
JAGUAR: ELECTRONIC PARKING BRAKE RE-CALIBRATION PROCEDURE.
Read full bulletin
*RM UPDATED 10/17/14. *PE
VIBRATION WHEN BRAKING - BREMBO BRAKES DISC THICKNESS VARIATION - DIAGNOSIS/REPAIR.
Read full bulletin
*TT
CREAKING NOISE WHEN BRAKING OVER SPEED BUMPS FRONT CONTROL ARM HYDROBUSH REPLACE CONTROL ARM.
Read full bulletin
*EH THIS SERVICE BULLETIN REPLACES XT20408 DATED 02/04. *EH THIS SERVICE BULLETIN REPLACES XT20408 DATED 03/04. *KB
Lighting
4 bulletinswarning lights and messages in the instrument pack
"RE-ISSUED DEC 2015. PLEASE NOTE THAT AS YET JAGUAR VEHICLES WITH BULB FAILURE MONITORING SYSTEMS FOR TRAILER LIGHT...
Read full bulletin
FAILURE SENSING ARE NOT COMPATIBLE WITH TRAILER LIGHT BOARDS THAT HAVE LED BASED ILLUMINATION. AS A RESULT OF THIS THE LED LIGHTING ON THE TRAILER BOARD MAY FLICKER DURING THE SENSING FUNCTION. (THIS ISSUES WILL ALSO PRESENT ITSELF IF FITTING LED REAR LIGHT CLUSTERS AVAILABLE IN THE AFTERMARKET(NON-JAGUAR APPROVED ACCESSORY) BASED UPON THIS WE RECOMMEND THAT TRAILER LIGHT BOARDS WITH STANDARD INCANDESCENT BULBS ONLY ARE FITTED."
ISSUE: A CUSTOMER MAY RAISE A CONCERN OF THEIR VEHICLE NOT PASSING STATE INSPECTION IN CALIFORNIA AND THERE IS NO...
Read full bulletin
WARNING LIGHT OR OTHER SUGGESTION OF A FAULT.
RESTRICTED PERFORMANCE (REDUCTION IN POWER) BETWEEN 4100 RPM AND 4300 RPM, WITH THE MALFUNCTION INDICATOR LAMP (MIL) ON,...
Read full bulletin
WITH THE POSSIBILITY OF DIAGNOSTIC TROUBLE CODE(S) (DTC) P0300, P0301 TO P0306, P1313, P1314 OR P1316 STORED. *TT
Electrical
3 bulletins"HELP WITH DIAGNOSING ANY ISSUES / FAULTS CAN BE GAINED BY PHONING YOUR JAGUAR TECHNICAL HELPLINE TO HELP US WITH OUR...
Read full bulletin
ANALYSIS PLEASE ENSURE THAT YOU HAVE THE FOLLOWING INFORMATION AVAILABLE BEFORE CONTACTING JAGUAR CARS: VIN VEHICLE TYPE AND MODEL DATE ACM WAS FITTED TO THE VEHICLE A CONCISE DESCRIPTION OF THE PROBLEM AND ITS REGULARITY OF OCCURANCE THE SOFTWARE LEVEL AND BUILD DATE COSE OF THE ACM FITTED. WORK PERFORMED ON THE VEHICLE TO SOLVE THE PROBLEM TO DATE IS THIS A PROBLEM SEEN IMMEDIATELY AFTER INSTALLATION IS IT PERMANENT HOW DOES THE PROBLEM DEMONSTRATE ITSELF WHAT I-POD IS THE CUSTOMER USING...ETC MANY THANKS FOR YOUR HELP TOPIX - SSM39290 - AUDIO CONNECTIVITY MODULE (ACM) PAGE 1 OF 1 HTTP://"
"ISSUE: WHEN INVESTIGATING CUSTOMER REPORTS FOR INCORRECT FUEL GAUGE CONCERNS THE DEALER TECHNICIAN MAY DIAGNOSE THAT...
Read full bulletin
THE FUEL SENDERS ARE OPEN CIRCUIT. THIS DIAGNOSIS MAY BE INCORRECT DEPENDING ON THE MULTIMETER SETTINGS SELECTED BY THE TECHNICIAN DURING MEASUREMENT. CAUSE: THE MULTI METER RANGE MAYBE SET AT 'AUTO' AND DURING A SWEEP OF THE SENDER FROM 50OHMS TO 998OHMS THE MULTI METER HAS TO CHANGE ITS MEASUREMENT RANGE. FOR APPROXIMATELY 1 SECOND, DURING THE RANGE SWITCH OVER POINT, THE MULTI METER DISPLAY INDICATES AN OPEN CIRCUIT. THIS IS INCORRECTLY BEING DIAGNOSED AS A SENDER FAULT"
"ISSUE: JAGUAR LAND ROVER NORTH AMERICA SERVICE DIAGNOSTICS WOULD LIKE TO MAKE ALL SDD USERS AWARE OF AN EMERGING...
Read full bulletin
CONCERN BEING TRACKED VIA THE EPQR SYSTEM. USERS REPORT DVD133 IS UNABLE TO FULLY COMMUNICATE WITH PCM ON LEGACY JAGUAR VEHICLES, AND REGARDLESS OF PCM STATUS ICON DISPLAYED ON NETWORK SUMMARY SCREEN, SDD MAY NOT DISPLAY DTCS FROM THE PCM CAUSE: THIS ISSUE IS CURRENTLY UNDER INVESTIGATION IN THE UK AND WILL BE ADDRESSED ON A FUTURE SDD SOFTWARE UPDATE."
Suspension
3 bulletins"ISSUE: DA-DONGLE/DA-VINA/DA-ST512 - J2534 VEHICLE COMMUNICATION INTERFACE DEVICE (VCI) SOFTWARE REQUIRES UPDATING TO THE LATEST LEVEL.
Read full bulletin
DA J2534 SOFTWARE DRIVER LEVEL V4.0 (MUST BE UPDATED TO THIS LEVEL ON ALL SDD MACHINES THAT USE THIS DEVICE) DA APP HUB LEVEL V2.4.0 (MUST BE UPDATED TO THIS LEVEL ON ALL SDD MACHINES THAT USE THIS DEVICE) DA FIRMWARE LEVEL V57. (ONLY NEEDS TO BE UPDATED ONCE TO EACH DEVICE, BECAUSE THIS IS HELD ON THE DEVICE ITSELF)"
WHINE FROM THE REAR OF THE VEHICLE AT 60 MPH.
Read full bulletin
INSTALL A NEW AXLE ASSEMBLY AND AXLE HOUSING BUSHING. *KB
SLIDING ROOF ONE-TOUGH ISSUES - RESYNCHRONIZE ROOF PANEL & REPROFILE SPRING - REPAIR PROCEDURE.
Read full bulletin
*TT
Tires & Wheels
3 bulletinsPERMANENT HIGH SPOT MARKING TO TIRE INBOARD SIDEWALL.
Read full bulletin
*KB
PREMATURE WEAR ON INNER TREAD EDGE - FRONT TIRES - MODIFIED TOE SPECIFICATION.
Read full bulletin
*KB
PERMANENT HIGH SPOT MARKING ON TIRE INBOARD SIDEWALL - INFORMATION.
Read full bulletin
*TT
Infotainment
2 bulletinsUnable to Login to SDD - Recommended TOPIx browsers screen is displayed.
A customer may report "Hood Open" message displays on IP with hood closed.
Transmission
2 bulletinsZF Transmission ? Error message during reprogramming
INABILITY TO SHIFT GEARS - SELECTOR LEVER MOVES FREELY THROUGH J-GATE - REPAIR PROCEDURE.
Read full bulletin
*TT
Pre-Delivery & Maintenance
1 bulletinV6 COOLANT PUMP OUTLET HOSE REPLACE WITH CORRECT SPECIFICATION.
Read full bulletin
- SERVICE ACTION S518. *EH
Steering
1 bulletinSQUEAKING NOISE MAY BE APPARENT FROM THE POWER ASSISTED STEERING SYSTEM WHEN THE STEERING WHEEL IS ROTATED IN EITHER DIRECTION.
Read full bulletin
*TT
Body & Paint
1 bulletinWIND NOISE FROM ROOF OPENING PANEL - PANEL PROFILE SET INCORRECTLY - SERVICE ACTION S161.
Read full bulletin
*TT