2003 Jaguar S-Type TSBs
95 Technical Service Bulletins across 15 categories
Categories
Other
23 bulletinsINFORMATION REGARDING REMOTE KEY FOB, FACTORY PROGRAMMED TO MEMORY POSITION, FOR MODEL 2003 MY - ON.*JB
Diagnostic Concerns.
Vehicle Communication Device fails to communicate
Diagnostic Concerns.
Error during key programing
Attachment.
Attachment.
Attachment.
Unable to access SDD after installation of DVD131.04.
Image.
Image.
SIM card activation issues
InControl Touch Pro phase 4 customer letter
Jaguar Land Rover Shop Foreman Conference Call
Presentation from Dealer Shop Foreman Conference Call
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
JAGUAR: DIRECTIONAL INDICATOR OPERATING WITH THE STALK IN THE CENTRAL POSITION.
Read full bulletin
IF CONDITION IS FOUND, REPLACE THE DIRECTIONAL INDICATOR SWITCH. NO MODEL YEARS LISTED. *PE
FRONT SEATS THAT ARE INOPERATIVE, NOISY OR JUDDER.
Read full bulletin
*TT
LOCKING OR UNLATCHING ISSUES - DIAGNOSTIC INFORMATION.
Read full bulletin
*TT
REAR DRIVE HALFSHAFT CHANGE IN SPECIFICATION FROM HOLLOW TO SOLID SHAFTS.
Read full bulletin
*EH
PASSIVE ANTI THEFT SYSTEM (PATS) DIAGNOSTIC FLOWCHARTS.
Read full bulletin
*EH
INSTALLATION OF NEW FEM, REM, AND DDM - INCORRECT VID BLOCK - USE MANUAL CONFIGURATION OPTION.
Read full bulletin
*TT
THUMP FROM REAR OF VEHICLE DIFFERENTIAL MOUNT BRUSHINGS INSTALL BRUSHING INSERTS.
Read full bulletin
*EH THIS BULLETIN REPLACES S10010 DATED 03/04. *EH
Engine
17 bulletins"RE-ISSUED DEC 2015. ISSUE: FUEL INJECTORS CLOGGED LEADING TO POOR RUNNING / MISFIRES / ENGINE DETONATION ON AJ-V8 ENGINES.
Read full bulletin
CAUSE: POOR FUEL QUALITY OR FUEL CONTAMINANTS BLOCKING THE HOLES IN THE FUEL INJECTOR."
V6 ENGINE MALFUNCTION INDICATOR LAMP (MIL) ON/ WITH DIAGNOSTIC TROUBLE CODE (DTC) P0332 - WATER ENTRY IN KNOCK SENSOR...
Read full bulletin
CONNECTOR - INSTALL SEALING PATCH. *TT
ENGINE DETONATION/PINGING DURING ACCELERATION FROM STEADY-STATE DRIVING - RECONFIGURE ECM.
Read full bulletin
*TT
BUZZING KNOCKING NOISE AFTER START OR WITH IGNITION ON ADAPTIVE SPEED CONTROL MODULE REPAIR PROCEDURE.
Read full bulletin
*EH
GROWLING NOISE IN 4TH GEAR DURING WARMUP - V6 ENGINES - ZF6HP26 TRANSMISSION - RECONFIGURE TRANSMISSION CONTROL MODULE (TCM).
Read full bulletin
*TT
ROUGH IDLE, RESTRICTED PERFORMANCE, AND POOR HARSH TRANSMISSION SHIFTS.
Read full bulletin
DIAGNOSTIC TROUBLE CODES P0174, P0171, P0301 TO P0308, P1316 AND P1582 MAY BE STORED IN THE ENGINE CONTROL MODULE (ECM). *TT
ROUGH IDLE/HESITATION - CONTAMINATED FUEL INJECTORS - CLEANING PROCEDURE.
Read full bulletin
*TT
HARSH TRANSMISSION SHIFTS ADAPTIVE SHIFT STRATEGY DRIFT REPROGRAM TRANSMISSION CONTROL MODULE & ENGINE CONTROL MODULE.
Read full bulletin
*EH UPDATE. *TT
DRIVELINE CLUNK/KNOCK WHEN DOWNSHIFTING - ZF 6HP26 AUTOMATIC TRANSMISSION - REPAIR PROCEDURE.
Read full bulletin
*TT
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATING WITH DIAGNOSTIC TROUBLE CODE (DTC) P0741 (TORQUE CONVERTER CLUTCH STUCK...
Read full bulletin
OPEN) LOGGED IN THE TRANSMISSION CONTROL MODULE (TCM) AND ENGINE CONTROL MODULE (ECM). *TT
MALFUNCTION INDICATOR LAMP - V6 V8 ENGINE MANAGEMENT DIAGNOSTIC - FLOWCHARTS.
Read full bulletin
*EH
RETORQUE PULLEY SUPERCHARGED VEHICLES SERIVCE ACTION S151.
Read full bulletin
*EH
SLIDING ROOF DOES NOT CLOSE PROPERLY BOUNCES OPEN LOSS OF CALIBRATION REPLACE SLIDING ROOF MOTOR.
Read full bulletin
*EH
SLIDING ROOF DOES NOT CLOSE PROPERLY BOUNCES OPEN LOSS OF CALIBRATION REPLACE SLIDING ROOF MOTOR.
Read full bulletin
THIS SERVICE BULLETIN REPLACES S50116 DATED 06/02. *EH
ENGINE IN LIMP HOME/CHECK ENGINE MALFUNCTION INDICATOR LAMP (MIL) - WATER INGRESS INTO THROTTLE POSITION SENSOR - SERVICE ACTION S159.
Read full bulletin
*TT
CHECK ENGINE MALFUCTION INDICATOR LAMP (MIL)/DIAGNOSTIC TROUBLE CODE (DTC) P0341 AND P0346.
Read full bulletin
*TT
DRIVE BELT NOISE AFTER COLD START SUPERCHARGER REVISED DRIVE BELT AVAILABLE.
Read full bulletin
*EH
Software & Calibration
8 bulletinsDiagnostic Software Hardware
DVD software update
Mongoose Update.
Mongoose Update
Important firmware update required for the DA Dongle /DA-VINA.
18C - New face of InControl Touch Pro and 18C software improvements
JAGUAR: REAR DIFFERENTIAL REPLACEMENT.
Read full bulletin
DUE TO A CHANGE IN DESIGN, THE REAR DIFFERENTIAL HAS A NEW SERVICE PART. AS A RESULT, SHOULD THE REAR DIFFERENTIAL REQUIRE REPLACEMENT IT WILL BE NECESSARY TO CONVERT THE DRIVELINE SYSTEM TO USE THE NEW DIFFERENTIAL. *PE UPDATED 11/7/11. *PE
LOSS OF SEAT MEMORY - REPROGRAM OR REPLACE DSM - REPAIR PROCEDURE.
Read full bulletin
*TT
Brakes
8 bulletins"CONCERN: REPLACEMENT OF ANY ANTI-LOCK BRAKE SYSTEM (ABS) CONTROL MODULE DOES NOT FIX THE CONCERN ISSUE: VARIOUS...
Read full bulletin
WARNING LIGHTS AND MESSAGES APPEAR IN THE (IPK) AND A CONSTANT BEEPING TONE FROM PARK BRAKE WARNING FROM THE (IPK), DIAGNOSTIC TROUBLE CODES (DTCS) RECORDED ARE: POWERTRAIN CONTROL MODULE (PCM) & PARK BRAKE MODULE (PBM)"
JAGUAR: WARNING LIGHTS AND MESSAGES BEING DISPLAYED IN INSTRUMENT PACK (IPK), WITH CONSTANT BEEPING TONE FROM PARK BRAKE WARNING.
Read full bulletin
MODEL S TYPE (X200). NO MODEL YEAR. *PE
JAGUAR: ELECTRONIC PARKING BRAKE RE-CALIBRATION PROCEDURE.
Read full bulletin
*RM UPDATED 10/17/14. *PE
VIBRATION WHEN BRAKING - BREMBO BRAKES DISC THICKNESS VARIATION - DIAGNOSIS/REPAIR.
Read full bulletin
*TT
ELECTRIC PARKING BRAKE (EPB) ACTUATOR - DTCS C1784, C1785, C1786, C1799, C1801, C1802, C1803 - DIAGNOSTICS.
Read full bulletin
*TT
PREMATURE PARKING BRAKE PAD WEAR OR THE BRAKES BINDING.
Read full bulletin
ELECTRONIC PARK BRAKE (EPB) - RE-CALIBRATION PROCEDURE. *TT
SHIELD FOR ROOF OPENING PANEL SLIDES FORWARD WHILE BRAKING - LOOSE FIT.
Read full bulletin
*TT
CREAKING NOISE WHEN BRAKING OVER SPEED BUMPS FRONT CONTROL ARM HYDROBUSH REPLACE CONTROL ARM.
Read full bulletin
*EH THIS SERVICE BULLETIN REPLACES XT20408 DATED 02/04. *EH THIS SERVICE BULLETIN REPLACES XT20408 DATED 03/04. *KB
Lighting
7 bulletinswarning lights and messages in the instrument pack
"RE-ISSUED DEC 2015. PLEASE NOTE THAT AS YET JAGUAR VEHICLES WITH BULB FAILURE MONITORING SYSTEMS FOR TRAILER LIGHT...
Read full bulletin
FAILURE SENSING ARE NOT COMPATIBLE WITH TRAILER LIGHT BOARDS THAT HAVE LED BASED ILLUMINATION. AS A RESULT OF THIS THE LED LIGHTING ON THE TRAILER BOARD MAY FLICKER DURING THE SENSING FUNCTION. (THIS ISSUES WILL ALSO PRESENT ITSELF IF FITTING LED REAR LIGHT CLUSTERS AVAILABLE IN THE AFTERMARKET(NON-JAGUAR APPROVED ACCESSORY) BASED UPON THIS WE RECOMMEND THAT TRAILER LIGHT BOARDS WITH STANDARD INCANDESCENT BULBS ONLY ARE FITTED."
ISSUE: A CUSTOMER MAY RAISE A CONCERN OF THEIR VEHICLE NOT PASSING STATE INSPECTION IN CALIFORNIA AND THERE IS NO...
Read full bulletin
WARNING LIGHT OR OTHER SUGGESTION OF A FAULT.
HEADLAMP INTERNAL CONDENSATION.
Read full bulletin
ACCEPTABLE LEVELS. REPAIR GUIDELINES. *TT
RESTRICTED PERFORMANCE (REDUCTION IN POWER) BETWEEN 4100 RPM AND 4300 RPM, WITH THE MALFUNCTION INDICATOR LAMP (MIL) ON,...
Read full bulletin
WITH THE POSSIBILITY OF DIAGNOSTIC TROUBLE CODE(S) (DTC) P0300, P0301 TO P0306, P1313, P1314 OR P1316 STORED. *TT
MALFUNCTION INDICATOR LAMP ILLUMINATION DIAGNOSTIC TROUBLE CODE.
Read full bulletin
*EH
FALSE WARNING LAMP ILLUMINATION REVISED INSTRUMENT CLUSTER.
Read full bulletin
THIS SERVICE BULLETIN REPLACES S41302 DATED 11/02. *EH
Fuel System
5 bulletinsFuel System Concerns.
FUEL GAUGE FAILURE OR INTERMITTENT OPERATION - FUEL LEVEL SENDER AVAILABLE SEPARATELY - REPLACEMENT PROCEDURE.
Read full bulletin
*TT FUEL LEVEL SENDER-AVAILABLE SEPARATELY FROM PUMP-REPLACEMENT PROCEDURE. *SC
ERRATIC FUEL GAUGE READING FUEL TANK SENDER.
Read full bulletin
*EH
ERRATIC FUEL GAUGE READING FUEL TANK SENDER.
Read full bulletin
*EH
CLIMATE CONTROL SYSTEM LOCKUP 23 DEGREES C DISPLAYED CONTINUOUSLY UPDATE TELEMATICS SOFTWARE.
Read full bulletin
*EH
Transmission
5 bulletinsZF Transmission ? Error message during reprogramming
INABILITY TO SHIFT GEARS - SELECTOR LEVER MOVES FREELY THROUGH J-GATE - REPAIR PROCEDURE.
Read full bulletin
*TT
HARSH SHIFTS - TRANSMISSION MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED WITH REVERSE SELECTED - DTC P0736 STORED.
Read full bulletin
*TT
SQUEAL/SQUEAK NOISE DURING ACCELERATION - FLUSH AND REPLACE ZF TRANSMISSION FLUID - REPAIR PROCEDURE.
Read full bulletin
*TT
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED/DIAGNOSTIC TROUBLE CODE (DTC) P0606 - SHIFT QUALITY/DRIVEABILITY ISSUES.
Read full bulletin
*TT
Electrical
5 bulletins"HELP WITH DIAGNOSING ANY ISSUES / FAULTS CAN BE GAINED BY PHONING YOUR JAGUAR TECHNICAL HELPLINE TO HELP US WITH OUR...
Read full bulletin
ANALYSIS PLEASE ENSURE THAT YOU HAVE THE FOLLOWING INFORMATION AVAILABLE BEFORE CONTACTING JAGUAR CARS: VIN VEHICLE TYPE AND MODEL DATE ACM WAS FITTED TO THE VEHICLE A CONCISE DESCRIPTION OF THE PROBLEM AND ITS REGULARITY OF OCCURANCE THE SOFTWARE LEVEL AND BUILD DATE COSE OF THE ACM FITTED. WORK PERFORMED ON THE VEHICLE TO SOLVE THE PROBLEM TO DATE IS THIS A PROBLEM SEEN IMMEDIATELY AFTER INSTALLATION IS IT PERMANENT HOW DOES THE PROBLEM DEMONSTRATE ITSELF WHAT I-POD IS THE CUSTOMER USING...ETC MANY THANKS FOR YOUR HELP TOPIX - SSM39290 - AUDIO CONNECTIVITY MODULE (ACM) PAGE 1 OF 1 HTTP://"
"ISSUE: WHEN INVESTIGATING CUSTOMER REPORTS FOR INCORRECT FUEL GAUGE CONCERNS THE DEALER TECHNICIAN MAY DIAGNOSE THAT...
Read full bulletin
THE FUEL SENDERS ARE OPEN CIRCUIT. THIS DIAGNOSIS MAY BE INCORRECT DEPENDING ON THE MULTIMETER SETTINGS SELECTED BY THE TECHNICIAN DURING MEASUREMENT. CAUSE: THE MULTI METER RANGE MAYBE SET AT 'AUTO' AND DURING A SWEEP OF THE SENDER FROM 50OHMS TO 998OHMS THE MULTI METER HAS TO CHANGE ITS MEASUREMENT RANGE. FOR APPROXIMATELY 1 SECOND, DURING THE RANGE SWITCH OVER POINT, THE MULTI METER DISPLAY INDICATES AN OPEN CIRCUIT. THIS IS INCORRECTLY BEING DIAGNOSED AS A SENDER FAULT"
"ISSUE: JAGUAR LAND ROVER NORTH AMERICA SERVICE DIAGNOSTICS WOULD LIKE TO MAKE ALL SDD USERS AWARE OF AN EMERGING...
Read full bulletin
CONCERN BEING TRACKED VIA THE EPQR SYSTEM. USERS REPORT DVD133 IS UNABLE TO FULLY COMMUNICATE WITH PCM ON LEGACY JAGUAR VEHICLES, AND REGARDLESS OF PCM STATUS ICON DISPLAYED ON NETWORK SUMMARY SCREEN, SDD MAY NOT DISPLAY DTCS FROM THE PCM CAUSE: THIS ISSUE IS CURRENTLY UNDER INVESTIGATION IN THE UK AND WILL BE ADDRESSED ON A FUTURE SDD SOFTWARE UPDATE."
USING WDS TO PROGRAM CONFIGURE CONTROL MODULES COMMON ISSUES SOLUTIONS VID BLOCK BACKGROUND INFORMATION.
Read full bulletin
THIS ALSO INCLUDES 2003 XJ SERIES. *EH
REMOTE TRANSMITTER DOES NOT UNLOCK VEHICLE.
Read full bulletin
VEHICLE LOCKED FOR EXTENDED PERIOD. INSTALL REVISED DRIVER DOOR MODULE. THIS SERVICE BULLETIN REPLACES S50118 DATED 03/03. *EH
Infotainment
4 bulletinsUnable to Login to SDD - Recommended TOPIx browsers screen is displayed.
A customer may report "Hood Open" message displays on IP with hood closed.
NAVIGATION SYSTEM DIAGNOSTIC PROCEDURES.
Read full bulletin
*EH
TELEMATICS CONCERNS NAVIGATION SYSTEM SOFTWARE INSTALLING LATEST LEVEL.
Read full bulletin
*EH
Suspension
4 bulletins"ISSUE: DA-DONGLE/DA-VINA/DA-ST512 - J2534 VEHICLE COMMUNICATION INTERFACE DEVICE (VCI) SOFTWARE REQUIRES UPDATING TO THE LATEST LEVEL.
Read full bulletin
DA J2534 SOFTWARE DRIVER LEVEL V4.0 (MUST BE UPDATED TO THIS LEVEL ON ALL SDD MACHINES THAT USE THIS DEVICE) DA APP HUB LEVEL V2.4.0 (MUST BE UPDATED TO THIS LEVEL ON ALL SDD MACHINES THAT USE THIS DEVICE) DA FIRMWARE LEVEL V57. (ONLY NEEDS TO BE UPDATED ONCE TO EACH DEVICE, BECAUSE THIS IS HELD ON THE DEVICE ITSELF)"
WHINE FROM THE REAR OF THE VEHICLE AT 60 MPH.
Read full bulletin
INSTALL A NEW AXLE ASSEMBLY AND AXLE HOUSING BUSHING. *KB
REAR SUSPENSION - CHECK RESET REAR TOE - SERVICE ACTION S 150.
Read full bulletin
*EH
SLIDING ROOF ONE-TOUGH ISSUES - RESYNCHRONIZE ROOF PANEL & REPROFILE SPRING - REPAIR PROCEDURE.
Read full bulletin
*TT
Pre-Delivery & Maintenance
3 bulletinsOVERHEATING THERMOSTAT STUCK CLOSED REVISED V8 THERMOSTAT AVAILABLE.
Read full bulletin
THIS SERVICE BULLETIN REPLACES S303-11 DATED 08/02. *EH
ENHANCED DEALER PDI PROCESS 3 MONTH TRIAL PERIOD.
Read full bulletin
SERVICE ACTION S503. THIS SERVICE BULLETIN REPLACES S100S503 DATED 10/02. *EH
TELEPHONE ECHO ON VEHICLES WITH PREMIUM IN-CAR ENTERTAINMENT (ICE) - SERVICE ACTION S155.
Read full bulletin
*TT
Tires & Wheels
2 bulletinsPREMATURE WEAR ON INNER TREAD EDGE - FRONT TIRES - MODIFIED TOE SPECIFICATION.
Read full bulletin
*KB
EXCESS WEAR ON THE INNER EDGE OF THE FRONT TIRE TREADS.
Read full bulletin
MODIFIED TOE SPECIFICATION. *TT
Body & Paint
2 bulletinsPOTENTIAL TRUST BEARING FAILURE.
Read full bulletin
SERVICE ACTION S157. *EH
LOOSE REARVIEW MIRROR REINSTALLING MIRROR MOUNTING BLOCK ON WINDSHIELD INSTALLION PROCEDURE.
Read full bulletin
*EH
Air Bags & Safety
1 bulletinSUPPLEMENTAL RESTRAINT SYSTEM (SRS) - FLASH CODES & PID CODE DEFINITIONS - DIAGNOSTICS.
Read full bulletin
*TT
Steering
1 bulletinSQUEAKING NOISE MAY BE APPARENT FROM THE POWER ASSISTED STEERING SYSTEM WHEN THE STEERING WHEEL IS ROTATED IN EITHER DIRECTION.
Read full bulletin
*TT