2013 International Terrastar TSBs
184 Technical Service Bulletins across 16 categories
Categories
Other
55 bulletinsThis document will guide the user through understanding Prop Shaft Codes and understanding the variations of prop codes.
Read full bulletin
(Metric Prop codes start with the number a 4 and Non metric Prop codes start with a 2.)
Title: Driveline Information Center and Troubleshooting Procedures Applies To: All Vehicles
Title: Fan belt replacement guidelines for frayed edges Applies To: All Models
J1939 Data Link Source Address Information
Diagnosis of chassis wander complaints.
J1939 Data Link Source Address Information
J1939 Data Link Troubleshooting
J1939 Data link source address information
Pico Scope CCOS (Crankcase Separator Test)
PicoScope Test One Channel RCT
PicoScope Test Resistance and Ohmmeter
PicoScope Test for Datalink (CAN) Health Shorts & opens
J1939 Data Link Source Address Information
J1939 Data Link Troubleshooting
Cab Lean Concern
Driveline Information Center and Troubleshooting Procedures
Cleaning and Disinfecting Trucks and Buses
J1939 Data Link Troubleshooting
How To Get A Helios Capture; only 1939 and 1708 multiplexed buses and trucks
Transfer Case Diagnostic and Operational Information; Only 4x4 Models
TerraStar Frame Reinforcement Excessive Gap Variance
J1939 Data Link Source Address Information
Driveline Information Center and Troubleshooting Procedures
Transfer Case Diagnostic and Operational Information; Only 4x4 Models
Medium duty cole weather operation / solid winter front; EXCLUDING High Cab DuraStar
Torsion Bar Retention Cotter Pin Design Change; only models built before 1/31/2013
Complaint of a new chassis with a frame bow; only chassis equipped with "dogbone" style crossmembers
TerraStar Transfer Case Diagnostic and Operational Information; only TerraStar 4x4 Models
Ethylene Glycol Coolant Color Change to be Phased-In Approximately April 1, 2004
Horn Sounds On Its Own While Vehicle Parked - OR - Horn Inoperative
To Get A Helios Capture; All 1939 and 1708 multiplexed trucks only
J1939 Data Link Troubleshooting; Only Models with 250k Baud Data Link (Black 9 Pin Diagnostic Connector)
J1939 Data Link Troubleshooting
NEW Ultrasonic DEF Tank Sending Unit; only models with SCR Aftertreatment system.
J1939 Data Link Troubleshooting
SCR Vehicles Setting 3363-16 (FC1713) due to Crossed DEF Tank Coolant Lines or Inverted DEFTHV
Horn Sounds On Its Own While Vehicle Parked - OR - Horn Inoperative
Retrieving Fault Codes Through the Cluster Doesn?t Work
Cooling System Flush Procedure
J1939 Data Link Source Address Information
J1939 Data Link Troubleshooting
Updating OnCommand Link with Accelerator
OnCommand EZ-Tech
Winter Front Usage
ISX, N13, and N9 / N10 Aftertreatment Private Data Link Troubleshooting
J1939 Data Link Troubleshooting
OnCommand EZTech
OnCommand EZ-Tech Download Center
Cluster Issues
1939 Data Link Troubleshooting
TerraStar Transfer Case Diagnostic and Operational Information
RADIATOR INTERNAL RESTRICTION AND FLUSH PROCEDURE
GEOTAB WITH WYE CABLE INSTALLATION
INTERNATIONAL: INFORMATION PROVIDED REGARDING THE OPERATIONAL AND DIAGNOSTIC OF TRANSFER CASE WITH 4 FEEDBACK SWITCHES AND 2 ELECTRIC ACTUATORS.
Read full bulletin
MODEL TERRASTAR. *PE
INTERNATIONAL: THIS IS A COSMETIC ISSUE, ON SOME TRUCKS, WHERE A DESIGN CHANGE FOR THE TORSION BAR RETENTION PIN, DUE...
Read full bulletin
TO POSSIBLE ROTATING AND WEARING AGAINST AND/OR CRACKING GRILLE OPENING REINFORCEMENT (GOR). MODELS 2011-2013 TERRASTAR. *PE
Engine
36 bulletinsThis document provides guidance for assessing the feasibility of implementing a customer-requested change to an engine or vehicle parameter/feature.
Read full bulletin
Customer requested changes will be approved in accordance with the requirements specified in 40 CFR Part 1037 to ensure continued compliance with greenhouse gas (GHG) regulations.
New CARB Idle Reduction Change Request
Engine replacements for all International engines will need to follow this procedure.
In some geographic areas, ambient temperatures reaching below 15F (-10 C), including high levels of humidity, an...
Read full bulletin
operator may experience engine stalling, low performance, and or poor aftertreatment performance. This is caused by condensation accumulating and freezing within the Charge Air Cooler (CAC); affecting air flow into the engine. This article lists all the currently available winter front covers that can be installed on the front grille and bumper to reduce cold air flow to the engine compartment.
Title: Engine Emission Label Replacement, Certificate of Conformance and Clean Idle Sticker Addition Procedure Applies...
Read full bulletin
To: All Navistar Powered Trucks Requesting Engine Emission Label Replacement, Certificate of Conformance and/or Clean Idle Sticker, Clean Truck Check
Title: How to Request a Horsepower Quote Applies To: All International and Cummins Electronic engines
Applies To: All Navistar Powered Trucks Requesting Engine Emission Label Replacement, Certificate of Conformance and/or...
Read full bulletin
Clean Idle Sticker, Clean Truck Check
Starter Diagnostics and warranty claim procedure; all engines EXCLUDING Cummins ISB engine with Allison transmission or...
Read full bulletin
PSI engine.
How to request a horsepower quote; all International and Cummins engines
Starter diagnostics and warranty claim procedure for all engines and all chassis EXCLUDING vehicles equipped with PSI...
Read full bulletin
engines or Cummins ISB engine with Allison transmissions
Calculating pulses per mile (speedometer setting); only models equipped with International engines
Engine Oil Capacities.
Read full bulletin
All International electronic engines 1994 to present and Cummins ISB, ISM, or ISX engines
Oil Capacities; All Electronic International Engines 1994 - Present.
Read full bulletin
Cummins ISB, ISM & ISX
Engine Emission Label Replacement, Certificate of Conformance and Clean Idle Sticker Addition Procedure
ISB Starting System Diagnostics; Only models built with cummins ISB engines
Engine Oil Capacities All Electronic International Engines 1994 - Present.
Read full bulletin
Cummins ISB, ISM & ISX
Engine Emission Label Replacement, Certificate of Conformance and Clean Idle Sticker Addition Procedure; only Navistar...
Read full bulletin
Powered Trucks
Aftertreatment Resource Center; All models equipped with EPA 2007 and newer engines
EPA 2010 MaxxForce 7 Engine Calibration Releases
Remote Engine Speed Control Module (RESCM) Troubleshooting; Only trucks equipped with RESCM
Engine Warning Light with fault codes or engine misfire due to open injector circuits caused by spread terminals on the...
Read full bulletin
Under Valve Cover (UVC) Injector Harness.
Exhaust Leak Repair at Turbocharger Adapter to Down Pipe Joint
Remote Throttle Control Options for Vehicles with ESC?s or Body Controllers and International Engines
Urea Quality Sensor (UQS) Supplemental Diagnostic and Service Information; only models with SCR Aftertreatment system...
Read full bulletin
and N9, N10, N13, A26 or Cummins ISB, ISL, ISX engines built from January 2016
The fire extinguishers may become clogged or require excessive force to activate.
Read full bulletin
In certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. Only equipped with Kidde model FC5 and FC10 fire extinguishers identified by International part numbers 1696423C2 and 1696423C3 and installed post production at Navistar?s Truck Sales Processing Center (TSPC).
Engine Oil Capacities
Dash Cluster Lamp Operation, Functions and Regeneration Instructions, With International engines
CPA Injector Misfire Detection; Only models with 2004 thru 2017 International engines.
Cylinder Performance Analyzer (CPA) Resource Center; Only models with 2004 thru 2017 International engines.
Emergency vehicle applications that originally left the assembly plant with Engine Warning Protection Shutdown (EWPS)...
Read full bulletin
disabled may have inadvertently had the EWPS enabled, when programmed in the field for other programming changes.
REMOTE ENGINE SPEED CONTROL MODULE (RESCM) TROUBLESHOOTING
IK1201326 - SERVICE PARTS DAMAGED NEW TURBOCHARGER OIL SUPPLY TUBE
PERFORMING RELATIVE COMPRESSION TEST AND MISFIRE TEST WITH CPA TOOL
IK1201253 - EXHAUST MANIFOLD SERVICE PROCEDURES
IK1201157 - UPDATE FOR EXCESSIVE LUBRICATION OIL CONSUMPTION
IKNOW: SOME VEHICLES MAY EXPERIENCE AN EXHAUST LEAK.
Read full bulletin
THIS BULLETIN IS THE REPAIR PROCEDURE FOR THE LEAK BETWEEN THE TURBOCHARGER ADAPTER AND THE TURBOCHARGER DOWN PIPE. NO MODEL YEARS WERE PROVIDED.*JS UPDATED 02/07/2013 *JS
Body & Paint
27 bulletinsThis article addresses chassis lean conditions on all chassis.
Read full bulletin
This does not include any diagnostics for body leans such as a cab lean. Keep in mind that a chassis lean may cause or accentuate a cab lean. Filling out the printable form and using the notes in blue will help you to determine the source of the lean and identify the action and parts required to correct the lean.
Cab water leak troubleshooting tips
Aftertreatment Clamp Corrosion; Single Can Aftertreatment Systems
Power Windows Stop Randomly or are Inoperative, Power Door Locks are inoperative
Interior door handle seal
Power Windows Stop Randomly or are Inoperative, Power Door Locks are inoperative
Cab Water Leak Troubleshooting Tips; Excluding 9000i, PayStar(HX), CityStar, or LoadStar
The First Check to make when Troubleshooting any Body Controller or ESC Issue
Wind noise at upper side of cab door
Headlight Operation and Troubleshooting; only Post 2007 Vehicles Built with a Body Controller
Body Controller Resource Center
Water entry into the cab / Adding Cowl tray seal; models built prior to 11/11/2013
Power Windows Stop Randomly or are Inoperative, Power Door Locks are inoperative
Power Windows randomly stop
Power Windows Stop Randomly or are Inoperative, Power Door Locks are inoperative
Power Windows Stop Randomly or are Inoperative, Power Door Locks are inoperative
Body Controller/ESC Software Updates
City Horn Blows When Driver Shuts off Truck and Walks Away; only equipped with with ESC or Body Controller
The First Check to make when Troubleshooting any Body Controller or ESC Issue
Windows Stop Randomly or are Inoperative, Power Door Locks are inoperative
Power Window Binding
Wind noise at upper side door
WIND NOISE AT UPPER SIDE DOOR
COWL TRAY SEAL; ONLY BUILT PRIOR TO 11/11/2013
WIND NOISE AT UPPER SIDE DOOR
POWER WINDOW BINDING
INTERNATIONAL: INFORMATION REGARDING ISSUE WITH POWER WINDOWS FAILING TO OPERATE PROPERLY OR POWER DOORS FAILING TO...
Read full bulletin
LOCK OR WHEN WINDOW STOPS, BUTTON PRESSED AND WINDOW RESUMES OPERATION. MODELS TERRASTAR, DURASTAR, WORKSTAR, TRANSSTAR, PROSTAR AND LONESTAR. NO MODEL YEARS LISTED. *PE UPDATED 12/16/13. *PE UPDATED 12/18/13. *PE UPDATED 9/14/15 *CN
Electrical
15 bulletinsCummins B6.7 Grid Heater Relay
General Wheel Speed Sensor Troubleshooting
PicoScope Wheel Speed Sensor Test
PicoScope Test - Battery Loss of Charge - Parasitic Draw Test
PicoScope Test 12V Electrical Noise Detection
PicoScope Test 5V & 12V Intermittent Open and Short circuit diagnostics
General wheel speed sensor troubleshooting
Ambient Air Temperature (AAT) Sensor Faults/Location/Diagnostics
Tool Instruction - BCM Programming Harness
Location of 1000 OHM Resistor In the HVAC Wiring
HVAC fault 2609-19 with 4th Gen BCM; Only models equipped with 4th generation BCM
Seat occupant sensor; Emergency applications only
A jump start or electrical load dump event could result in an overvoltage condition of the cab Linear Power Module (LPM).
Read full bulletin
The overvoltage condition could eventually cause overheating of the LPM circuit board.
Air Conditioning Electrical Diagnostics
HIGH OR SPIKING VOLTAGE ONLY WITH LEECE-NEVILLE ALTERNATOR USING REMOTE VOLTAGE SENSE
HVAC & Climate
11 bulletinsTitle: A/C Refrigerant and Oil Capacities Applies To: All current models
A/C Refrigerant and Oil Capacities
A/C Refrigerant and Oil Capacities
HVAC faults 520211 and 520465; only Models with Body Controllers
A/C Refrigerant and Oil Capacities
HVAC faults 520211 and 520465
2010 and Newer Vehicle Air Conditioning Diagnostics (Start Here)
2010 and Newer Vehicle Air Conditioning Diagnostics (Start Here)
Air Conditioning Control Head Diagnostics
Air Conditioning Mechanical Pressures Diagnostics
NAVISTAR: SOME VEHICLES MAY HAVE LOOSE OR BROKEN BOLTS ON THE AC COMPRESSOR SUPPORT.
Read full bulletin
MODELS INCLUDE CE C BUS, DURASTAR, HC C BUS, AND TERRASTAR BUILT FROM JULY 12, 2007 TO MAY 29, 2013. AE S BUS, BE S BUS, AND CE S BUS BUILT FROM JUNE 12,2007 TO MAY 30,2013. *JS
Infotainment
7 bulletinsThis tool is designed to compare Diamond Logic feature data across multiple vehicle configuration files.
Read full bulletin
It allows users to quickly load files either manually or directly from the Diamond Logic Builder Vehicles folder using VIN-based selection. As files are added or removed, the comparison runs automatically with no manual action required. The program presents results in an interactive table that shows feature codes, descriptions, access levels, and whether each feature is present in each selected file. Built-in search, filtering, and sorting make it easy to locate specific features or focus only on differences between files. Column visibility can be customized to show or hide descriptions and access information as needed. Users can remove files individually or clear all files at once, with results updating instantly. The tool also includes reporting and export options that reflect exactly what is visible on screen, allowing results to be printed, copied, saved as text, or exported to CSV for use in Excel or other spreadsheet tools. Overall, the program streamlines the process of comparing vehicle feature configurations, helping users quickly identify differences, validate setups, and document results without manual comparison or external tools.
NEW Ultrasonic DEF Head Unit; All SCR vehicles
NEW Ultrasonic DEF Head Unit available; Only models equipped with SCR Aftertreatment.
NEW Ultrasonic DEF Head Unit; only models equipped with SCR Aftertreatment
NEW Ultrasonic DEF Head Unit
Radio Diagnostics and Information
RADIO DIAGNOSTICS AND INFORMATION
Brakes
5 bulletinsThis document will guide the user through a step-by-step procedure for detecting water leaks in vehicle cabs and...
Read full bulletin
windshields using an ultrasonic sound detector.
ABS Fault After ECM Calibration or Incorrectly changing a parameter
Brake Light Operation on TerraStar with HydroMax brakes
INTERNATIONAL: AN IMPROPERLY CHANGING PARAMETER IN AN ABS MODULE OR AN ECM CALIBRATION UPDATE, CAN CAUSE ONE OR MORE FAULTS.
Read full bulletin
*PE
IKNOW: AFTER REPLACEMENT, PROGRAM TRW 355 ABS MODULE.
Read full bulletin
MODEL TERRASTAR. NO MODEL YEARS GIVEN.*JS
Transmission
5 bulletinsTitle: Steering Gear Seal Repair Guidelines Applies To: Steering gears
Power Steering Diagnostics Flow / Pressure Specifications For Power Steering Gears and Power Steering Pumps
TerraStar Transmission Shift Cable Routing
6th Gear Disable Information and Diagnostics
Vehicles with Thandle Shifters; 6th Gear Disable Information and Diagnostics
Suspension
4 bulletinsThis document reminds technicians of the critical relationship between the truck's suspension and the driveline operating angles.
Read full bulletin
The information applies to diesel, gas, and electric vehicles.
Suspension Lean Diagnostics; All models
8,000 LBS Front Suspension Lean Correction
8,000 LBS Front Suspension Lean Correction
Steering
4 bulletinsAdjustment Procedure for Tilt Only Steering Column; only models with Feature code 0005708
Diagnosis of Noise Originating from Steering System
Steering Fluids
Steering Shake, Shimmy, Shudder, or Steering Vibration; only with 14k front weight rated axles and below
Fuel System
4 bulletins2010 Dash Cluster Lamp Operation with new DPF Lamp Locations , Functions and Regeneration Instructions
2010 Dash Cluster Lamp Operation with new DPF Lamp Locations , Functions and Regeneration Instructions
DPF Snap Accel Test - Quick Test to All vehicles with DPFs
IK1500051 - DAVCO FUEL PRO 382 TECHNICAL MANUAL, INSTALLATION, DIAGNOSTICS, AND SERVICE
Tires & Wheels
3 bulletinsSuggested alignment target values when performing a vehicle axle alignment.
FLR-10 Bendix Wingman Misalignment Issues; only models with Feature Code 08TKY Wingman FLR-10 Radars
FLR-10 Bendix Wingman Misalignment Issues; only models with Feature Code 08TKY Wingman FLR-10 Radars
Lighting
3 bulletinsRepair Procedures for Vehicles Struck by Lightning
Trailer Auxiliary Switch Lamp Burning Out; Only Vehicles Equipped with Feature Code 0008TTH or 0008THG
COMBINED OR SEPARATE, TURN AND STOP LIGHTS
Software & Calibration
3 bulletinsCluster Software Update Instructions
Using Supplier Software to Check DTCs
Dealer EZ-Tech and Diagnostic Software Support Resource Center
Pre-Delivery & Maintenance
1 bulletinTitle: Service Portal iKNow Feedback Case Types Applies To: All
Air Bags & Safety
1 bulletinChange in Seat Belt Manufacturer - Inspection and Replacements