2022 Ic Bus Ce TSBs
56 Technical Service Bulletins across 13 categories
Categories
Engine
18 bulletinsThe purpose of this article is to provide updated repair guidelines for the engine oil pan leak on all 8.8L gasoline and...
Read full bulletin
LPG.
How to request a horsepower quote; all International and Cummins engines
CE Bus Engine Cover Sealing
Per agreement with EPA and CARB, Cummins, Inc.
Read full bulletin
provided an emergency calibration for Cummins ISB, B6.7, ISL9, L9, and X15 engines when a DEF Quality Sensor (DQS) was not available. This action addressed the Diesel Exhaust Fluid (DEF) Quality Sensor failures in the field and the unavailability of parts due to the worldwide chip shortage. This recall is step two of this program designed to revert all affected vehicles back to the certified calibration and to provide them with the latest improved DQS and Coolant Control Valve (CCV) designs. Additionally, the emergency calibration and the restoration to the certified calibration with the latest improved DQS and Coolant Control Valve (CCV) designs have no effect on vehicle Emissions.
Cummins Programming guide and fault codes285 & 265; only vehicles built with Cummins B6.7, X15, or L9 engines
Starter diagnostics and warranty claim procedure for all engines and all chassis EXCLUDING vehicles equipped with PSI...
Read full bulletin
engines or Cummins ISB engine with Allison transmissions
QLS Emergency ECM Calibration; only models equipped with Cummins B6.7, X15, L9, or International A26 engines
QLS Emergency Calibration.
Read full bulletin
applies to 2016 and newer Cummins B6.6, X15, and L9 engines and all A26 engines
Bus, DuraStar, and MV air compressor inlet hose chaffing/leaking; equipped with Cummins ISB / B6.7 Engines
With the vehicle in motion, the engine control module (ECM) may set a fault code resulting in engine shut down without warning.
Read full bulletin
Only models equipped with certain PSI engines
QLS Emergency Calibration; Models equipped with 2016 and newer Cummins B6.7, X15 and L9 engines or International A26...
Read full bulletin
engine.
With the vehicle in motion, the engine control module (ECM) may set a fault code resulting in engine shut down without...
Read full bulletin
warning; only models equipped with PSI gasoline or LPG engines.
QLS Emergency Calibration; Models with 2016 Cummins ISX, A26 and EPA 2017 and newer Cummins X15, L9, or B6.7 engines
Engine Oil Capacities.
Read full bulletin
All International electronic engines 1994 to present and Cummins ISB, ISM, or ISX engines
DuraStar and MV Air Compressor Inlet Hose Rub.
Read full bulletin
Only models equipped with Cummins ISB or B6.7 engines
QLS Emergency Calibration.
Read full bulletin
Only models with EPA 2017 and newer Cummins X15, L9, or B6.7 engines
Cummins engine vibration with aftermarket air conditioning installed
Bus with Cummins B6.7 engine and Dual A/C - Cylinder Head Failures
Other
15 bulletinsJ1939 Data Link Source Address Information
Diagnosis of chassis wander complaints.
Luggage rack upholstery repair; only busses equipped with luggage rack.
J1939 Data Link Source Address Information
J1939 Data Link Troubleshooting
Telematics installation guidelines - Only units with 500K data link
J1939 Data link source address information
Pico Scope CCOS (Crankcase Separator Test)
PicoScope Test One Channel RCT
PicoScope Test Resistance and Ohmmeter
PicoScope Test for Datalink (CAN) Health Shorts & opens
J1939 Data Link Source Address Information
Greenhouse Gas Phase 2 Regulatory Compliance Implementation
J1939 Data Link Troubleshooting
How to obtain As built parameter list
Electrical
7 bulletinsThis document details the procedure that must be followed to ensure proper alternator troubleshooting.
Cummins B6.7 Grid Heater Relay
General Wheel Speed Sensor Troubleshooting
PicoScope Test - Battery Loss of Charge - Parasitic Draw Test
New or replacement body control Module (BC,BCM) not detected; Gen 4 BCM
General wheel speed sensor troubleshooting
Cummins B6.7 Grid Heater Relay
Body & Paint
3 bulletinsThese certain buses may have roof water leaks resulting from incorrect assembly described in Roof Joint Recalls 23501...
Read full bulletin
and 23502.
Bus roof leaks
Aftertreatment Clamp Corrosion; Single Can Aftertreatment Systems
Brakes
2 bulletinsThis document is to guide users to eliminate brake pedal rattle noise.
The rear axle brake chambers may be installed in the incorrect mounting slot which could lead to long term durability...
Read full bulletin
issues.
Pre-Delivery & Maintenance
2 bulletinsBus seat back foam inspection guidelines
Webasto Thermo Pro 90 Service and Repair Manual; Only CE bus with feature code 0049JAN or 0049JAP
Software & Calibration
2 bulletinsQLS Emergency Calibration Revert Process
QLS Emergency Calibration Revert Process
Hybrid & EV
2 bulletinsElectric Vehicle Electric Heat Operation
Certain CE series buses may have been programmed with the incorrect parameter setting that may impact regeneration...
Read full bulletin
switch functionality.
Fuel System
1 bulletinBus Diesel fuel Cap Leaks; only models built 11/30/2020 through 05/18/2023
HVAC & Climate
1 bulletinAir Compressor Inlet Hose Chaffing / Leaking
Steering
1 bulletinThe steering wheel retaining nut may not have been torqued properly during assembly and may allow the steering wheel to...
Read full bulletin
loosen, and possibly separate from the steering column shaft.
Transmission
1 bulletinPower Steering Diagnostics Flow / Pressure Specifications For Power Steering Gears and Power Steering Pumps
Infotainment
1 bulletinCE Bus Radio PA not switching to external / internal speakers; only models with feature codes 49CLM or 49CLN