2010 Ic Bus Besb TSBs
169 Technical Service Bulletins across 16 categories
Categories
Other
44 bulletinsIC Bus Operator's Manuals
This document will guide the user through understanding Prop Shaft Codes and understanding the variations of prop codes.
Read full bulletin
(Metric Prop codes start with the number a 4 and Non metric Prop codes start with a 2.)
Title: Driveline Information Center and Troubleshooting Procedures Applies To: All Vehicles
Title: Fan belt replacement guidelines for frayed edges Applies To: All Models
J1939 Data Link Source Address Information
Diagnosis of chassis wander complaints.
J1939 Data Link Source Address Information
J1939 Data Link Troubleshooting
J1939 Data link source address information
Pico Scope CCOS (Crankcase Separator Test)
PicoScope Test One Channel RCT
PicoScope Test Resistance and Ohmmeter
PicoScope Test for Datalink (CAN) Health Shorts & opens
J1939 Data Link Source Address Information
J1939 Data Link Troubleshooting
Driveline Information Center and Troubleshooting Procedures
Cleaning and Disinfecting Trucks and Buses
J1939 Data Link Troubleshooting
How To Get A Helios Capture; only 1939 and 1708 multiplexed buses and trucks
J1939 Data Link Source Address Information
Diagnosis and repair of intermittent operation of the Child Checkmate reset button.
Medium duty cole weather operation / solid winter front; EXCLUDING High Cab DuraStar
Ethylene Glycol Coolant Color Change to be Phased-In Approximately April 1, 2004
J1939 Data Link Troubleshooting; Only Models with 250k Baud Data Link (Black 9 Pin Diagnostic Connector)
J1939 Data Link Troubleshooting
NEW Ultrasonic DEF Tank Sending Unit; only models with SCR Aftertreatment system.
J1939 Data Link Troubleshooting
Cooling System Flush Procedure
J1939 Data Link Source Address Information
Updating OnCommand Link with Accelerator
OnCommand EZ-Tech
Winter Front Usage
Diagnostic Interface Cable Reference Guide
OnCommand EZ-Tech Download Center
EZ-Tech Download Center
Using Vehicle Health Report Faults
How To Get A Helios Capture
OnCommand EZTech
OnCommand EZ-Tech Download Center
SCR Vehicles Setting 3363-16 (FC1713) due to Crossed DEF Tank Coolant Lines or Inverted DEFTHV
1939 Data Link Troubleshooting
ESPAR AirTronic Low Run Time.
RADIATOR INTERNAL RESTRICTION AND FLUSH PROCEDURE
TORQUE CHANGE FOR 5/8 INCH REAR AXLE SHAFT FLANGE MOUNTING STUD WITH CONE LOCKS AND FLAT WASHER TYPE HARDWARE.
Engine
29 bulletinsNew CARB Idle Reduction Change Request
Engine replacements for all International engines will need to follow this procedure.
In some geographic areas, ambient temperatures reaching below 15F (-10 C), including high levels of humidity, an...
Read full bulletin
operator may experience engine stalling, low performance, and or poor aftertreatment performance. This is caused by condensation accumulating and freezing within the Charge Air Cooler (CAC); affecting air flow into the engine. This article lists all the currently available winter front covers that can be installed on the front grille and bumper to reduce cold air flow to the engine compartment.
Title: How to Request a Horsepower Quote Applies To: All International and Cummins Electronic engines
How to request a horsepower quote; all International and Cummins engines
Starter diagnostics and warranty claim procedure for all engines and all chassis EXCLUDING vehicles equipped with PSI...
Read full bulletin
engines or Cummins ISB engine with Allison transmissions
Calculating pulses per mile (speedometer setting); only models equipped with International engines
ECM Calibration for DPF Replacement; Applies to MaxxForce Engines
Engine Oil Capacities.
Read full bulletin
All International electronic engines 1994 to present and Cummins ISB, ISM, or ISX engines
ECM Calibration for DPF Replacement; only trucks and busses built with 2007- 2009 MaxxForce DT/9/10.
Read full bulletin
2010-2012 MaxxForce DT/9/10, 2007-2009 MaxxForce V8, 2008-2009 MaxxForce 11/13 engines
Service and Support Information For The ESPAR Auxiliary Fuel Fired Heater Field Service Kit (P/N 2592385C91); only bus...
Read full bulletin
models equipped with VT365 or MaxxForce 7 engines.
Oil Capacities; All Electronic International Engines 1994 - Present.
Read full bulletin
Cummins ISB, ISM & ISX
Engine Emission Label Replacement, Certificate of Conformance and Clean Idle Sticker Addition Procedure
Cylinder Performance Analyzer (CPA) Resource Center
Engine Oil Capacities All Electronic International Engines 1994 - Present.
Read full bulletin
Cummins ISB, ISM & ISX
Fuel Fired Engine Coolant Heaters may require the fuel system to be primed prior to use.
ECM recalibration and cleaning of the diesel oxidation catalyst (DOC) to Prevent possible Diesel Oxidation Catalyst...
Read full bulletin
(DOC) face plugging resulting in excessive fuel dilution of the engine oil. Retired
Aftertreatment Resource Center; All models equipped with EPA 2007 and newer engines
Fuel Cooler Valve (FCV) Screen Removal to Reduce High Fuel Temperature; only Vehicles Built Prior to 01 September 2011...
Read full bulletin
with EPA 2010 MaxxForce 7 engines
Urea Quality Sensor (UQS) Supplemental Diagnostic and Service Information; only models with SCR Aftertreatment system...
Read full bulletin
and N9, N10, N13, A26 or Cummins ISB, ISL, ISX engines built from January 2016
Bus with ISB Frequent Regeneration; only models with Cummins ISB engine
Engine Oil Capacities
Engine Oil Capacities
2010 MaxxForce 7 engine DPF Cracking
Dash Cluster Lamp Operation, Functions and Regeneration Instructions, With International engines
CPA Injector Misfire Detection; Only models with 2004 thru 2017 International engines.
Cylinder Performance Analyzer (CPA) Resource Center; Only models with 2004 thru 2017 International engines.
Front Blower Motor Runs Breifly At Initial Power Up
Engine Won?t Shut Off with the Key 5 amp Fuse Blowing
Brakes
23 bulletinsThis document will guide the user through a step-by-step procedure for detecting water leaks in vehicle cabs and...
Read full bulletin
windshields using an ultrasonic sound detector.
WABCO Full Power Brake Diagnostic Code (DTC) Index
How to program parameters after changing WABCO FPB ECU (Parking brake shows N/A)
Wabco FPB/Quadraulic Brake Uneven Wear
Proper Brake Bleeding Procedure For Vehicles With Wabco Full Power Brakes; only models with Wabco Full Power Hydraulic...
Read full bulletin
Brakes
Brake Light Operation; only models equipped with Meritor Wabco Full Power Brakes
The lower outside corners of the passenger seat back may not have sufficient padding to conform to all requirements of...
Read full bulletin
FMVSS 222 or CMVSS 222; only School bus models equipped with IC Bus passenger seats.
Wabco FPB/ Quadraulic Brake Lining Replacement and uneven wear
Wabco Toolbox Error Message When Downloading Wabco File; only models equipped with WABCO Full Power Brakes.
2007 and Newer Brake Light Operation; only equipped with Air Brakes
How to Program Parameters After Changing a WABCO FPB ECU ( Park Brake Shows NA ); only models equipped with WABCO Full...
Read full bulletin
Power Brakes
Hydraulic Brake System Park Brake Inspection and Adjustment Procedures; only models with Hydraulic Brake system equipped...
Read full bulletin
with 04GBJ Park Brake
IC Bus Service Brake Switch Inspection
Brake Light Operation on HPV with Full Power Brakes; only models equipped with Meritor WABCO Full Power Hydraulic Brakes
Wabco Hydraulic Power Brake cap/grounds diagnostics and repair procedure
Wabco FPB/Quadraulic Brake Uneven Wear
Wabco Full Power Hydraulic Brake Diagnostic Code (DTC) Index
WABCO Full Power Brakes Park Brake Troubleshooting; only with SAHR (hydraulic powered) praking brake
How to Program Parameters After Changing a WABCO FPB ECU ( Park Brake Shows NA )
Wabco FPB/Quadraulic Brake Uneven Wear
Chassis with Quadraulic Brakes; Quadraulic Brake Pads
Wabco Full Power Hydraulic Brake Diagnostic Code (DTC) Index
IKNOWLEDGE: NAVISTAR CE BUS, BE BUS, AND DURASTAR MODELS DUE TO VEHICLE VOCATION, LOADING, OPERATING ENVIRONMENT, AND...
Read full bulletin
DRIVING HABITS, MAY EXPERIENCE BRAKE LINING WEAR RATE THAT WILL VARY. *TA
Electrical
15 bulletinsGeneral Wheel Speed Sensor Troubleshooting
PicoScope Test - Battery Loss of Charge - Parasitic Draw Test
General wheel speed sensor troubleshooting
Sound Off Bus Monitor Lamps Not Illuminating While Circuits and Exterior Lights are Operating and Test Good
Bus Body Electrical Test Points
Applying Advanced Logic Templates; only models equipped with a BCM or ESC
How to Diagnose Electrical Problems with Diamond Logic Builder; only models equipped with a BCM or ESC
How to Get from History and Program a BCM or ESC; only models equipped with a BCM or ESC
Location of 1000 OHM Resistor In the HVAC Wiring
HVAC fault 2609-19 with 4th Gen BCM; Only models equipped with 4th generation BCM
Battery Testing, Diagnostics, and Maintenance information
Ambient Air Temperature (AAT) Sensor Faults/Location/Diagnostics
Urea Quality Sensor (UQS) Supplemental Diagnostic and Service Information
Determine Wheel Speed or Driveline Vibration using a Smart Phone and Free VibSensor Application
Air Conditioning Electrical Diagnostics
HVAC & Climate
13 bulletinsTitle: A/C Refrigerant and Oil Capacities Applies To: All current models
Factory Installed Air Conditioning, EC4.0 System operating instructions and the service manual
Bus Air Conditioning Service Contacts for HVAC Information
Factory Installed Air Conditioning, EC4.0 System operating instructions and service manual; only models built with...
Read full bulletin
feature code 48ADC, 48ADD, 48ADE, 48ADG, 48CVA, 48CVC, 48CVH, 48CVJ, 48CVL, 48CVM, 48UTX, 48VHG, or 48VHH.
A/C Refrigerant and Oil Capacities
Troubleshooting & Resetting HVAC Doors; only vehicles with Feature Codes 0016WCT and 0016WCS
A/C Refrigerant and Oil Capacities
2010 and Newer Vehicle Air Conditioning Diagnostics (Start Here)
2010 and Newer Vehicle Air Conditioning Diagnostics (Start Here)
Factory Installed Air Conditioning, EC4.0 System
2010 and Newer Vehicle Air Conditioning Diagnostics (Start Here)
2010 and Newer Vehicle Air Conditioning Diagnostics (Start Here)
2010 AND NEWER VEHICLE AIR CONDITIONING DIAGNOSTICS (START HERE)
Body & Paint
13 bulletinsThis article addresses chassis lean conditions on all chassis.
Read full bulletin
This does not include any diagnostics for body leans such as a cab lean. Keep in mind that a chassis lean may cause or accentuate a cab lean. Filling out the printable form and using the notes in blue will help you to determine the source of the lean and identify the action and parts required to correct the lean.
Aftertreatment Clamp Corrosion; Single Can Aftertreatment Systems
Updating Body Controller Software
Headlight Condensation or Frost; excludes sealed beam headlights such as on WorkStar, Paystar and 9900i)
Mirror Repair Procedures and Replacement Parts Availability
Body Controller/ESC Software Updates
Bus Door Adjustment procedure for Electric and Air; only Models Built 9/15/11 or later
Bus Entrance Door Adjustment Procedures; only models built prior to 9/15/2011
Bus Passenger Window Troubleshooting; only buses built after 4/17/17
Bus Body Tie Down, Floor Sill Repair
First Check to make when Troubleshooting any Body Controller or ESC Issue
The First Check to make when Troubleshooting any Body Controller or ESC Issue
Headlight Condensation or Frost; excludes sealed beam headlights such as on WorkStar, Paystar and 9900i)
Pre-Delivery & Maintenance
6 bulletinsTitle: Service Portal iKNow Feedback Case Types Applies To: All
Bus seat back foam inspection guidelines
Passenger Seat Back Pan Inspection and Repair
Post Trip Inspection System Will Not Disarm or Does Not Operate Correctly; excludes Child Reminder System or Child Check...
Read full bulletin
Mate.
Ricon Public Use,"S" 2000 and 5500 Series lift recall
Ricon Public Use,"S" 2000 and 5500 Series lift recall
Fuel System
5 bulletinsHow to Change From a 5 Wire Fuel Transfer Pump to a 2 Wire Fuel Transfer Pump
2010 Dash Cluster Lamp Operation with new DPF Lamp Locations , Functions and Regeneration Instructions
2010 Dash Cluster Lamp Operation with new DPF Lamp Locations , Functions and Regeneration Instructions
DPF Snap Accel Test - Quick Test to All vehicles with DPFs
ONLY VEHICLES EQUIPPED WITH DAVCO FUEL PRO 382; TECHNICAL MANUAL INSTALLATION DIAGNOSTICS AND SERVICE
Transmission
4 bulletinsTitle: Steering Gear Seal Repair Guidelines Applies To: Steering gears
Power Steering Diagnostics Flow / Pressure Specifications For Power Steering Gears and Power Steering Pumps
This article is for adding additional protection to the driver's area of the bus to help mitigate the transmission of...
Read full bulletin
germs.
Transmission Upshifting too Fast; Only with Allison Gen 4 LCT (1000 and 2000 series) Transmission
Air Bags & Safety
4 bulletinsLong term cycle fatigue (buckling and unbuckling the seat belt) may cause the plastic fingers on the male portion of the...
Read full bulletin
buckle to crack and break off resulting in an increase in force necessary to latch the seat belt buckle.
Driver?s seat belt tongue button; Only with Seat Belt Part numbers 4091405c1 thru 4091408c1
Change in Seat Belt Manufacturer - Inspection and Replacements
DRIVER AND PASSENGER SEAT BELTS
Tires & Wheels
3 bulletinsThis article describes how to fix a speedometer that does not read accurately.
Read full bulletin
An inaccurate speedometer can be caused by changing the tire size, changing rear axle ratio (RAR), or by parameters being inadvertently changed during a programming event. Use the formulas and calculator below to correct the pulses per mile (PPM).
Suggested alignment target values when performing a vehicle axle alignment.
Suggested alignment target values when performing a vehicle axle alignment
Infotainment
3 bulletinsThis tool is designed to compare Diamond Logic feature data across multiple vehicle configuration files.
Read full bulletin
It allows users to quickly load files either manually or directly from the Diamond Logic Builder Vehicles folder using VIN-based selection. As files are added or removed, the comparison runs automatically with no manual action required. The program presents results in an interactive table that shows feature codes, descriptions, access levels, and whether each feature is present in each selected file. Built-in search, filtering, and sorting make it easy to locate specific features or focus only on differences between files. Column visibility can be customized to show or hide descriptions and access information as needed. Users can remove files individually or clear all files at once, with results updating instantly. The tool also includes reporting and export options that reflect exactly what is visible on screen, allowing results to be printed, copied, saved as text, or exported to CSV for use in Excel or other spreadsheet tools. Overall, the program streamlines the process of comparing vehicle feature configurations, helping users quickly identify differences, validate setups, and document results without manual comparison or external tools.
Radio Diagnostics and Information
RADIO DIAGNOSTICS AND INFORMATION
Lighting
2 bulletinsRepair Procedures for Vehicles Struck by Lightning
Repair Information for Damaged Headlight Connector
Steering
2 bulletinsAdjustment Procedure for Tilt Only Steering Column; only models with Feature code 0005708
Steering Fluids
Software & Calibration
2 bulletinsUsing Supplier Software to Check DTCs
Dealer EZ-Tech and Diagnostic Software Support Resource Center
Suspension
1 bulletinSuspension Lean Diagnostics; All models