2017 Freightliner Coronado TSBs
386 Technical Service Bulletins across 16 categories
Categories
Other
139 bulletinsCX Advocate for GATS2.4 being expanding to DD15
Customer letter regarding variable speed water pump.
Tech Talk discussion on repair verification for codes like 'low air flow' when a trailer is not available.
Tool Letter for New Final Drive Pinion Cover Install Tool
PowerNet Assessment Tool Repair Procedure
fp00024 Cable-Tie Reference
Letter to customer on Coverage Extension GHG17 After Treatment
SPN 3226 (ACM) (GHG17)
SPN 96 (MCM) (GHG17)
SPN 3226 (ACM) (GHG17)
Diagnostic tests - Two Filter System - FSIC Leak Test
SPN 712 (CPC) (GHG17)
Letter to customer on Coverage Extension GHG17 After Treatment
SPN 3226 (ACM) (GHG17)
SPN 96 (MCM) (GHG17)
SPN 3226 (ACM) (GHG17)
Diagnostic tests - Two Filter System - FSIC Leak Test
SPN 712 (CPC) (GHG17)
Technical Publications Ordering
sb54268 122SD and Coronado Virtual Technician Retrofit
SPN 96 (MCM) (GHG17)
Diagnostic tests - Two Filter System - FSIC Leak Test
SPN 712 (CPC) (GHG17)
Instructions for CSC Diagnostic Support
SPN 3556 (ACM) (GHG14)
ICU4Me Low Air Pressure Warning Change
Towing Procedures
Operating Hours for the Customer Assistance Center
fp00020 Replacing Gross Vehicle Weight Rating (GVWR) Certification Labels
sb4932 DEF Gauge Reading Incorrectly
0107-15 Enhanced Steam Clean
(CPC)(EPA10-GHG14) and SPN 98 (CPC)(GHG17)
0301-17 Contaminated Fluids
sb54215 ICU4M Missing VORAD Information or Reporting Fault SA 42 SPN FMI 07
Replacing or Upgrading Airliner 40K Transverse Torque Rods
324-15 External Component Repair
304-15 Diagnostic Tests
303-15 Contaminated Fluids
323-15 Symptom Diagnostics ? Noise
ssb42072 Diagnstico de fugas de aire
sb54300 ICU4Me Low Air Pressure Warning ChangeB
sb42072 Air Leak DiagnosticsB
sb31034 Towing ProceduresB
sb2053 New Stainless Steel Lower Radiator Tubes
sb1512 Accessories On When Key is OffB
sb00042 Flood Damage Repair GuidelinesB
fsb42072 Diagnostic de fuite d'air
sb3131 Huck-Spin 2 Changeover
704-15 SPN 4364 (ACM)(EPA10)
sb54292 Nexiq USB-Link Upgrade and Diagnostic Connector
DD Heavy Duty Platform Belt and Belt Tensioner
SPN 1663 (CPC) (EPA07 10 GHG14 GHG17)
0137-17 SPN 3361 FMI 5 (ACM) (GHG17) SPN 3361 FMI 5 (ACM) (GHG14)
0130-17 SPN 520211 (IPPC) (GHG14) SPN 520211 (IPPC) (GHG17)
0127-17 SPN 1077 FMI 14 (GHG14) (GHG17) (MCM)
0115-17 SPN 3226 (ACM) (EPA10;GHG14)
1207-16 SPN 4363 (ACM) (EPA10 GHG14)
1213-16 SPN 3480 (MCM) (EPA07;EPA10 GHG14)
15TS16Rev1 EPA10 Reman MCM Improvement for Fault Codes SPN 651 to 656
1202-15 Symptom Diagnostics - ATD Checklist
12-022-DLR Daimler Trucks Remarketing Corporation (DTR) Now Requires Pre-approval for Repairs $1,200 (USD) and Greater
15TS3 Detroit? Coolant Change From Nitrite Organic Acid Technology
15CSA10 The Detroit CSC announcing a new feature ? Ability to attach files to an existing CSC
15CSA9 Release of DiagnosticLink 8.02
15-009_Detroit_New_SDTs
15TL5 DAVCO Shop Pro FXP 95
324-15 External Component Repair
304-15 Diagnostic Tests
303-15 Contaminated Fluids
323-15 Symptom Diagnostics ? Noise
15CSA4 Holiday Schedule for the Detroit Customer Support Center
713-14 Symptom Diagnostics - Combustion Gas in Coolant
715-14 Symptom Diagnostics - Coolant Los
719-14 SPN 84 (CPC) (GHG14)
710-14 SPN 96 (CPC) (GHG14)
711-14 SPN 107 (CPC) (GHG14
701-14 SPN 168 FMI 0 and 1 (IPPC)(GHG14
706-14 SPN 171 FMI 3, 4 (CPC)(GHG14)
709-14 SPN 3216 (MCM) (GHG14)
703-14 SPN 3556 (ACM) (EPA10)
704-14 SPN 520200 FMI 6 (IPPC)(GHG14)
705-14 SPN 520203 FMI 6 (IPPC)(GHG14)
708-14 SPN 520219 (IPPC) (GHG14)
707-14 SPN 520229 FMI 3 (IPPC) (GHG14
702-14 SPN 520230FMI 5 (IPPC)(GHG14)
14-028 Remy Extended Coverage Direct File
14-027 Detroit's New Consolidated Labor Operations (CLOs
14-023 Detroit Axles Pre-Approval Changes
14-022 Pre-Approval Threshold Increase From $2,500 to $5,000 USD
54-215 - ICU4M Missing VORAD Information or Reporting Fault SA 42 SPN 639 FMI 07
16TL4 DOC Face Cleaning Tool P N W470589239100
16TS5 Release of the DD Platform Bearing Failure Guide
0307-16 SPN 723 (MCM) March
Contaminated Fluids
Hydrocarbon Doser Coolant Lines
16-009R_OWL Enhancements
New Detroit Bearing Failure Analysis Standard Diagnostic Time
17-026 Holiday Closure 2017
17TL27 Injector Cup Tool DSN930E17001
17TL26 Injector Heat Sleeve Removal Tool DSN930E17002
17CSA25 New Method for Uploading Diagnostic Log Files to the CSC
17CSA24 Holiday Schedule for the Detroit Customer Support Center
17CSA23r Detroit CSC closed December 14, 2017 from 11:15 am - 1:15 pm Eastern Time
PAB053, USA-ONLY GM CHASSIS PRICE INCREASE
12-039-DLR OWL Pre-approval's Time Frame Increases to 60 Days
15-028 New Detroit Coolant Line SRTs
Detroit Data Summaries Application and Kits Are No Longer Available Through PDC
_NewDetroitCoolantLineSRTs
13wo3rev2_final Actual Labor Hours on Detroit Claims
0229-14 Symptom Based Diagnostics - Oil Separator
0233-14 SPN 51 FMI 2 - All Years
0224-14 SPN 1590 FMI 9 - CPC- All Years February 2014
807-14 FMI 8 SCR Inlet Temperature Signal Spike
801-14 FMI 19: RCM Message Not Received or Stopped Arriving
14-017R Revised: Detroit Addition of Admin Time
54-268 - Coronado Virtual Technician Retrofit
14-038_New_SRTs Additional Detroit Standard Repair Times.
14-039_additional_SDTs New Detroit Standard Diagnostic Times
14TL8 TorcUP? Non-Impacting Torque Tool.
14TS28 DD Platform Belt Drive System - Belt Part Numbers and diagnostics
1003-14 Rough Running or Stalling.
1009-14 SPN 5016 (ACM) (GHG14)
1007-14 SPN 5016/FMI 3, 4 (ACM) (EPA10)
1006-14 SPN 4374 (ACM) (GHG14)
1008-14 SPN 3510FMI 4,7, and 8 (CPC)(GHG14)
1010-14 SPN 2623 (CPC) (GHG14)
14CSA23 CSC Announces ?Tech Tips? ? DDCSN
14CSA21 Holiday Schedule for the Detroit Customer Support Center ?
14-039 New Detroit Standard Diagnostic Times
14-038 Additional Detroit Standard Repair Times
sb2080 Australian CST M1400 Isolated Radiator Retrofit
1021-16 SPN 110 (MCM)(EPA07EPA07;GHG14), SPN 110 (CPC)(GHG14)
1018-16 SYMPTOM DIAGNOSTICS - NOISE
0910-16 SPN 3251 (ACM) (GHG17)
0905-16 SPN 100 (MCM) (GHG17)
0901-16 SPN 5927 (MCM) (GHG17)
SB54268 122SD AND CORONADO VIRTUAL TECHNICIAN RETROFIT
0810-16 SYMPTOM DIAGNOSTIC NOISE
0809-16 SYMPTOM DIAGNOSTICS : NOISY 1- BOX AFTERTREATMENT
Engine
65 bulletinsCX Advocate for turbo oil drain cracking
CX Advocate for turbo oil drain cracking
CX Advocate for DD13 Gen 5 engines operating at high altitude experience EGR slow response fault.
DEF Tank Coolant Valve O-Ring Kit
sb54298 GHG17 Heavy Duty Engine Platform Vehicle Dash Oil
Technical Service Letter for GHG17 1-Box Inlet and Outlet Exhaust Clamps.
Read full bulletin
There is a short supply of exhaust clamps, part number DDE A6809950502, used as inlet and outlet exhaust clamps on GHG17 heavy duty engines (DD13, DD15 and DD16) with a 1-Box aftertreatment configuration. Exhaust clamp part number TCX T130158342AC2 may be used as a substitute for DDE A6809950502, but be aware of the different torque specs between the two parts.
Training Solutions for Fuel Leak Found at High Pressure Fuel Pump Weep Hole for Heavy Duty DD Engines.
Read full bulletin
Occasionally we see trucks come in with fuel leaking from the high pressure fuel pump weep hole. This is NOT a defect in the pump and further diagnostics need to be performed to find the root cause.
Updated Recall Safety Bulletin for vehicles in Australia and New Zealand with DD15 engines regarding high pressure fuel lines.
Read full bulletin
Language was clarified that this only applies to Australia and New Zealand.
Export Recall Safety Bulletin for vehicles in Australia and New Zealand with DD15 engines regarding high pressure fuel...
Read full bulletin
lines.
Service Information Bulletin to updated the Fuel Injector Harness sections and relocated to Engine Electrical section.
Cylinder Liner - Testing of the Cylinder Liner Upper O-Ring
Field Service Campaign D18M2 GHG17 GHG17 Detroit? DD13 Software Reprogramming and Emission Label Replacement for Motor Coach Industries, Inc.
Read full bulletin
(MCI)
Cylinder Liner - Testing of the Cylinder Liner Upper O-Ring
Cylinder Liner - Testing of the Cylinder Liner Upper O-Ring
New Detroit Diesel Cylinder Liner Upper O-Ring Leak Test Standard Repair Time
Engine Manufacturer Diagnostics
DD13, DD15, DD16 Check Engine Light Flashing or Blinking
GHG14 - Intake Manifold Pressure Too Low
GHG14 Intake Manifold Pressure Too Low
GHG17 Heavy Duty Engine Platform Vehicle Dash Oil Pressure Gauge
308-15 Symptom Diagnostics - Oil Present at the Turbocharger Compressor
302-15 Crankshaft Oil Seals
sb54298 GHG17 Heavy Duty Engine Platform Vehicle Dash Oil Pressure GaugeB
sb2084 OAT Coolant Replaces NOAT Coolant in Detroit Engines
sb0175 Replacing Drive Belts on MBE4000 EnginesB
sb0006 Freightliner Courtesy Engineering PolicyB
708-15 High Pressure Fuel Pump Camshaft Oil Seal - Two-Filter System
711-15 High Pressure Fuel Pump Camshaft Oil Seal - Three-Filter System
702-15 DD15 and DD16 Delphi Exhaust Gas Recirculation Valve Actuator
703-15 GHG14 DD15 AT Exhaust Gas Recirculation Valve Actuator
Heavy Duty Engine Wastegate Repair Kit DKI470E16019
0120-17 Diagnostic Test - Engine Oil Leaks - Oil Developer Method
0118-17 Symptom Diagnostics - Oil Leaks
Retrofitting Trelleborg Engine Mounts for EPA07 and Newer
15TL24 OTC 1750 Revolver Engine Stand
15TS4_Rev2_ EPA07 DD15 Piston Kits
1210-14 Cylinder Head
15TS10Rev DD Engine Platform Coolant Filter
15TL4 W470589050900 ? 3/8? Drive GEN2 Two-Stage Valve Socket
308-15 Symptom Diagnostics - Oil Present at the Turbocharger Compressor
302-15 Crankshaft Oil Seals
sb01101 Pilot Bearing Spacer for Detroit Engines with Eaton transmissions
14TL2 DD Platform Engine Stand Adapter W060589023100
14TS18 GHG14 DD Engine EGR System Fault Code
714-14 Symptom Diagnostics - Low Engine Compression
712-14 Engine Coolant Temperature
20-73 - CANCELED: Cascadia Radiator Update?EPA10 with DDC Engines
20-75 - CANCELED: Cascadia Radiator Update?EPA10 with Cummins ISX Engines
16TS8 DD13 Cylinder Head and Cylinder Head Gasket Change
16-011 New Detroit Camshaft Housing Seal Standard Repair Time
sb4724 Crank No Start, Loss of Engine Prime on Decked Vehicles
12-038-DLR - No Problem Found - Policy Claims - During Basic Vehicle Chassis or Base Engine Coverage
14TS4 Valve and Liner Installation Tool Issue
0228-14 Engine Oil Leaks - Oil Dye Method
0237-14 Engine Brake Solenoid
14TS21 HDEP Camshaft Position Sensor Change
804-14 FMI 16, 18 Intake Manifold Pressure Too high and low (Restricted Mode)
803-14 FMI 16,18: Intake Manifold Pressure Too High and Low
812-14 FMI 3, 4: Engine Aux.
Read full bulletin
Shutdown Input Failed High and Low
14-040_Additional_CLOs Additional Detroit CLOs for the Heavy Duty Engine Platform
14CSA20 EGR Valve Actuator Kit P/N E23539699
14-040 Additional Detroit CLOs for the Heavy Duty Engine Platform
1017-16 ENGINE MODEL AND SERIAL NUMBER DESIGNATION
16TL20 HEAVY DUTY ENGINE VALVE STEM SEAL INSTALLING DRIFT AND SLEEVE
0909-16 EXCESSIVE OIL CONSUMPTION
Fuel System
42 bulletinsCustomer Service Announcement saying that Service Pack (SP) 3 for DiagnosticLink 8.11 Standard and Professional will be...
Read full bulletin
available for download from the Detroit Diesel server.
Service Bulletin for Equiflo Fuel System Breather Tube Inspection
Service Information Bulletin for Symptom Diagnostics - Fluid in the Aftertreatment - Diesel Fuel Contamination.
Service Information Bulletin regarding PTO Dosing.
Read full bulletin
This feature enables Active Regeneration of the DPFs while in PTO mode.
Fuel System Integrity Check Routine - Two-Filter Fuel System
Fuel Level Sending Unit Retrofit
Fuel System Integrity Check Routine - Two-Filter Fuel System
Fuel Level Sending Unit Retrofit
Fuel System Integrity Check Routine - Two-Filter Fuel System
Emission Recall D18R5 GHG17 DD Platform Model Years 2016-2018 Software Reprogramming For California Onboard Diagnostics
102-15 High Pressure Fuel Pump - Two-Filter System
sb54296 Fuel Level Sending Unit RetrofitB
sb54148 Radio and Integrated Thin-Film Antenna Troubleshooting, and Field Service UpdatesB
sb49040 Diesel Exhaust Fluid (DEF) Pressure Line Disconnected at the Doser ConnectionB
fsb49040 Conduite sous pression de fluide pour chappement diesel (DEF) dbranche au niveau du raccordement du doseur
Diesel Exhaust Fluid (DEF) Pressure Line Disconnected at the Doser Connection
SPN 4765 FMI 0 - Exhaust Temperature Out Of Range High
15TL6 W470589129100 ? HDEP HP Fuel Rail Test Caps
15-017 Detroit: Updated Fuel Injector SDTs
14TS19 DD Platform High Pressure Fuel Lines
18SP710Rev 18SP710Rev ? EPA10 GHG14 Two-Filter Fuel
18SP709Rev 18SP709Rev ? EPA10/GHG14 Two-Filter Fuel
18SP701Rev2 18SP701Rev2? GHG14 Two-Filter Fuel System
16TS9 DD Platform High Pressure Fuel Lines
16TS7 Reman Diesel Particulate Filter Serial Number
17TL28 Fuel Injector Removal Tool DSN930E17004
0239-14 High Pressure Fuel Injector Lines - Three-Filter System
0238-14 Removal of the High Pressure Fuel Injector Lines - Two-Filter
0210-14 High Pressure Fuel Rail Feed Lines - Three-Filter System
0209-14 High Pressure Fuel Rail Feed Lines - Two-Filter System
0219-14 Metal in Fuel
0202-14 Symptom Diagnostics - Hard Start No Start - Two-Filter Fuel System
0215-14 Check for Rough Running or Stalling - Three-Filter Fuel System
18SP703 18SP703 - GHG14 KM63 GEN2 Low Pressure Fuel Pump-Two-Filter Fuel System Ki
18SP725 TWO-FILTER FUEL SYSTEM KM63 GEN2 DD13 HIGH PRESSURE FUEL FEED LINES, MOUNTING BRACKET AND P-CLIPS SERVICE KIT
18SP722 DD13 KM59 GEN1 BUS TWO-FILTER SYSTEM AMPLIFIER, NEEDLE AND PLV RETURN FUEL LINE CLEARANCE PACKAGE SERVICE KIT
18SP720 EPA10 DD15/16 THREE-FILTER ESOC FUEL SYSTEM TO TWO-FILTER KM59 GEN1 FUEL SYSTEM CONVERSION SERVICE KIT
18SP720 EPA10 DD15/16 THREE-FILTER ESOC FUEL SYSTEM TO TWO-FILTER KM59 GEN1 FUEL SYSTEM CONVERSION SERVICE KIT 2
18SP718 EPA07 DD15/16 THREE-FILTER ESOC FUEL SYSTEM TO TWO-FILTER KM59 GEN1 FUEL SYSTEM CONVERSION SERVICE KIT
1020-16 CHASSIS FUEL SYSTEM ISOLATION TEST
18SP720REV 18SP720 EPA10 DD15/16 THREE-FILTER ESOC FUEL SYSTEM TO TWO-FILTER KM59 GEN1 FUEL SYSTEM CONVERSION SERVICE...
Read full bulletin
KIT
18SP713REV 18SP713 EPA10 DD13 THREE-FILTER FUEL SYSTEM TO TWO-FILTER KM59 GEN1 FUEL SYSTEM CONVERSION SERVICE KIT
Pre-Delivery & Maintenance
35 bulletinsFreightliner Service Bulletin for DEF Connector Reinforcement Caps.
Service Bulletin for Guidelines for Cleaning and Disinfecting Cab Surfaces.
Read full bulletin
The following guidelines are for cleaning and disinfecting commonly touched surfaces on the inside and outside of a vehicle. For best results, follow cleaning and disinfecting procedures fully and consistently. Ensure there is adequate ventilation when using chemicals. NOTICE: Wipe down fragile components carefully to avoid damaging the vehicle.
Open recall and Field service Campaigns report send out to Dealers, General Managers, Service managers and warranty...
Read full bulletin
managers.
Freightliner Service Bulletin for vibration troubleshooting - finding the cause.
Read full bulletin
This version replaces the version dated 5/1/14 and adds New Cascadia.
Freightliner Service Bulletin for Midship Bearing Replacement for built vehicles with driveshafts SPL140, SPL170 or...
Read full bulletin
SPL250 with first order driveline vibration.
Warranty Policy Letter explaining the Warranty Department is aligning with the frame rail repair policy, published in...
Read full bulletin
DTNA Workshop Manuals, which states that there are very few cases in which welding a heat-treated frame rail is allowed. Therefore, before welding anything on a frame rail, contact the applicable regional service representative for approval.
Open recall and Field service Campaigns report send out to Dealers, General Managers, Service managers and warranty...
Read full bulletin
managers
Communication to assist the field with service vibration issues on DTNA vehicles
Warranty Policy Letter to communicate Detroit Return Changes
Warranty Information Letter to announce addition of Thomas Built Bus as a brand with an Authorized Demonstrator Program
Service Information Bulletin was released, to add new procedures to address diagnostics near the high pressure pump
Warranty Information Letter sent to customers regarding new refrigerator supplier for returning parts.
Training Solution created by DTNA to provide guidance to customers when searching for service information for components...
Read full bulletin
and systems not owned by Daimler Trucks North America (DTNA).
Service Bulletin- sb54311 ICU Odometer Programming
Reminder: Paper Service Bulletin Mailings Are Discontinued
Important Campaign Information on FL614 Recall
Service information Bulletin -HDEP PLV Return Line Tool DSN470E17006
Service Information Bulletin for Aftertreamtent Failure Guide
Important Warranty Information on AutoMeter BCT-460DTNA Powernet Assessment Tool: Warranty Requirement and Claim Filing
Release of DiagnosticLink 8.08 Service Pack 2
If a GVWR certification label is lost or damaged, Freightliner will supply a duplicate label.
Read full bulletin
Log on to DTNAConnect.com and under "DTNAConnect Resources", select the "Tool and Services" plus sign. Select "Request for Certification Label or OWI." Fillout the form, then select "Review."
ICI18-014 Owner Notice ? Kidde Fire Extinguisher Recall
ICI18-014 Owner Notice ? Kidde Fire Extinguisher Recall
sb54194 Required Maintenance for Freightliner-Branded and Delco Cassette Players
sb54122 ICU3 Service Cluster AvailableB
15-015 Warranty Exclusions Reminder
14-026-DLR SelecTruck Warranty Enhancements
Canadian Warranty Parts Return Address Change
OWL Enhancement Service Model Field
Warranty Classroom Training in 2018
12-041-DLR Over the Counter No Hassle Warranty (OTC)
_Warranty Recognition Program - Coming Soon
14WO-9_Warranty_Access Detroit New User Warranty Access Request
14TL9 Special Tool Warranty Program.
15CSA24 GHG17 RAPID WARRANTY PARTS RETURN
Electrical
35 bulletinsService Solution SS 1033094 KUS Float Tube Fuel Level Sensor Inform...
Updated Service Bulletin for upgrading BHM software for switch expansion module fault SPN 698 FMI 7.
Read full bulletin
This bulletin replaces the version dated 11/11/2019. Figure 3 has been updated with a new hardware part number. A procedure was added to the data download process.
Updated Freightliner Service Bulletin for Powernet Troubleshooting Guide - Batteries, Path, Alternator, and Starter.
Read full bulletin
This bulletin replaces the version dated 5/31/2017. Information is added about the BCT-460DTNA PowerNet Assessment Tool. When troubleshooting Powernet issues, use the BCT-460DTNA PowerNet Assessment Tool. As of May 29, 2018, the AutoMeter is the only Daimler-approved tool for troubleshooting vehicle Powernet issues.
Service Bulletin for Guidelines for Repairing or Replacing an Electrical Harness.
Read full bulletin
Use the guidelines in this bulletin to determine if a damaged electrical harness should be repaired or replaced.
Service Bulletin on guidelines for repairing or replacing an electrical harness.
Service Bulletin for upgrading BHM software for switch expansion module fault SPN 698 FMI 7.
Service Bulletin describing changes made to the Powernet Distribution Box (PNDB) for better fuse retention.
Service Information Bulletin for Communication Loss with a Common Powertrain Controller (CPC) Module (CPC Heartbeat...
Read full bulletin
Message is no Longer Arriving)
Forward Chassis Wiring Harness
SS 1034220 SSI Ultrasonic Fuel Level Sensor Information
54-277 - Resetting Erroneous Learned Roll Call ECUs on Vehicles with ICU4M
54-278 - Powernet Troubleshooting Guide: Batteries, Path, Alternator, and Starter
54-274 - Plastic Battery Box Cover Retainer Clip
326-15 Main Shaft Speed Sensor
sb54278 Powernet Troubleshooting Guide Batteries, Path, Alternator, and Starter
sb54202 Rerouting the DDEC IV Relative-Humidity-Sensor Harness
sb2066 Gentech Low Coolant Level Sensor
sb54278 Powernet Troubleshooting Guide: Batteries, Path, Alternator
SPN 521221 (TCM)
SPN 521222 (TCM)
1205-15 Selective Catalyst Reduction (SCR) Inlet Temperature Sensor
FMI 3,4,5 Digital Output 2 10 Circuit
15-016-DLR New Essential Tool For CPWA, CPPRA, Ltd CPPRA, & DSDWC Parties: Cadex CA-12 Battery Tester
326-15 Main Shaft Speed Sensor
54-285 - Cracked Fuses on Powertrain Power Distribution Modules
16TL5 DD Platform Aftertreatment Soot Sensor Socket DSN0ATZ16001
16_TL-2 DD Platform Aftertreatment NOx Sensor Socket W470589060900
14TS5 Replacing Damaged Aftertreatment Sensor Bosses
809-14 FMI 3, 4, 5, 31: Diesel Exhaust Fluid System Circuit Failed
802-14 FMI 3, 4: Diesel Exhaust Fluid Pressure Sensor Circuit Failed High and low
14TS30 Aftertreatment Harness Diagnostics
1005-14 Oil Coolant Module
14CSA22 DTNA Chassis Wiring Diagrams
18SP684Rev4 18SP684Rev4 ? EPA07 and EPA10 DD Platform EGR Delta Pressure Sensor Update
18SP705Rev5 18SP705Rev5 ? DD Platform Delta Pressure Sensor
Suspension
15 bulletinsRevised Freightliner Service Bulletin for Axle Flange Gasket Replaced with O-Ring.
Read full bulletin
Revision removed steps instructing removal and installation of wheels. Daimler Trucks North America has released a new axle shaft to hub rubber O-ring (part number 11-30728-000) as a replacement for the paper gasket (part number 11-14418-000). The new O-ring will provide better sealing and is reusable. It is quicker and easier to use compared to the paper gasket, because using a paper gasket requires cleaning the hub when the axle shaft is removed.
Freightliner Service Bulletin for Axle Flange Gasket Replaced with O-Ring.
Read full bulletin
Daimler Trucks North America has released a new axle shaft to hub rubber O-ring (part number 11-30728-000) as a replacement for the paper gasket (part number 11-14418-000). The new O-ring will provide better sealing and is reusable. It is quicker and easier to use compared to the paper gasket, because using a paper gasket requires cleaning the hub when the axle shaft is removed.
Freightliner Service Bulletin for Non-Airliner Rear Suspension Crossmember Fastener Change.
Read full bulletin
With the start of production on March 2, 2020, the fasteners used to assemble the non-Airliner rear suspension (bogie) crossmember have changed. The rear suspension bogie crossmember gussets to the C-channel will be assembled with 5/8 - 18 fasteners. This change includes a revision to a higher friction nut that requires an increase in tightening torque. The new higher friction nut can be identified by its green color.
Freightliner Service Bulletin for Front Axle Spacer Replacement.
Read full bulletin
This service bulletin replaces the version dated 05/01/2016. This bulletin is updated to include the parts list. Some vehicles may exhibit a lean (right or left) due to weight difference on the front suspension. While this does not affect the operation of the vehicle, it may be visually unpleasing to many customers. To correct this condition, replace the existing front axle spacer on the low side of the vehicle with a thicker one.
Service Bulletin for Hendrickson HaulMaax Rear Suspension Transverse Torque Rod Tower Bracket Replacement
Tool Letter for New Final Drive Driver Controlled Differential Lock Spring Compressor.
Read full bulletin
These new axles require a new tool to compress the Driver Controlled Differential Lock (DCDL) spring. To remove and install the DCDL spring, the tool DSN0FDA17001 is needed.
Service Bulletin to fix vehicles which may have an incorrect transverse torque rod tower bracket installed on the rear drive axles at the factory.
Read full bulletin
This can result in cracking at the transverse rod tower where it is welded to the axle housing, premature wearing of the transverse torque rod tapered pin and bushings, and damage to the transverse torque rod frame bracket.
SS 1034171 Airliner Rear Suspension Chassis Lean Troubleshooting
Service Bulletin: AirLiner Suspension Six-Piece Bolted Service Crossmember
With the start of production on February 12, 2018, the fasteners used to assemble Airliner rear suspension crossmembers changed.
Read full bulletin
The forward-suspension crossmember will assembled with 5/8-18 fasteners and the rear-suspension (bogie) crossmember will be assembled with 3/4-16 fasteners.
33-28 - Bearing Spacer Replacement, ConMet PreSet Steer Hubs
35-30 - Bearing Spacer Replacement, ConMet PreSet Drive Hubs
Detroit? DT12? Split Rod Bushing Repair
Warranty Recognition Program Suspension
FL718 FRONT AXLE HUB RATING
Body & Paint
12 bulletinsService Bulletin for Window Regulator Retrofit
Customer Service Announcement Letter Revision for Dealers/Distributors Accessing DDEC Backdoor Passwords
Warranty Information Letter - Expanded guidelines for paint-related claims sent out to Freightliner, Western star,...
Read full bulletin
Thomas Built Bus, Export and Direct warranty customers
Service Bulletin 9817- Paint Supplier Change
Service Bulletin 9815- Paint Finish Standards
The right-hand cab panel on New Cascadia can come into contact with the right-hand chassis-side fairing when making a left turn.
Read full bulletin
This contact can result in an audible popping noise, paint-damage to the rocker panel and damage to the back-side of the chassis-side fairing.
sb9815 Paint Finish Standards
sb98020 Axalta Paint Finish CareB
sb9815 Paint Finish StandardsB
sb2043 Radiator Fan Shroud Seal
Body SRT Updates -2012.12.12
12-040-DLR Roof Fairing Removal Program
Transmission
10 bulletinsService Bulletin for Lengthening the Backup Light Harness.
Read full bulletin
Though the backup light harness is long enough to connect to the backup light switch, it may be short enough that the wire seals in the connector can be stressed. Moisture entering through the seals can cause corrosion, resulting in a bad connection and/or failure of the switch. As a result, backup lights and, if equipped, the backup alarm, may not function when the vehicle is shifted into reverse.
Field Service Campaign for Remanufactured Detroit DT12 Transmissions
Warranty Policy Letter to communicate remarketing handling cap for Detroit DT12 Transmission.
sb2074 Kysor Fan Clutch Rocking Runout Inspection
sb2052 Horton Drivemaster Fan Clutch Hub Bearings
Detroit? DT12? Transmission Proper Moving Procedure
FMI 2- Automatic Gear Selection - Incompatible or missing dataset
15-010-DLR Transmission Cooler Line Photos
811-14 FMI 7: Internal Error with the DT12 Shift Stalk Lever
16TS16 DETROIT DT12 TRANSMISSION OIL AND OIL FILL/DRAIN PLUG WASHERS
Steering
8 bulletinsSteering Intermediate Shaft Replacement
Adjusting Tilt Lock Force on TRW Steering Columns
Adjusting Tilt Lock Force on TRW Steering Columns
Adjusting Tilt Lock Force on TRW Steering Columns
Adjusting Tilt Lock Force on TRW Steering Columns
sb4641 Adjusting Tilt Lock Force on TRW Steering ColumnsB
fp46907 Steering Intermediate Shaft ReplacementB
FP46907 STEERING INTERMEDIATE SHAFT REPLACEMENT
Lighting
6 bulletinsCustomer Service Announcement for a policy change regarding Detroit Service Information Bulletins (SIBs) will now have a...
Read full bulletin
60-day expiration, starting on the release day of the bulletin. The intent of a SIB is to notify the service network of a major change to one or more service procedures. Do not save SIBs nor reference them for repairs, as they are uncontrolled and never updated.
sb2046 ABA Hose Clamp Torque Values
Some vehicles may have been incorrectly shimmed at the factory, and may lean slightly to the right or left.
Read full bulletin
While this does not affect the operation of the vehicle, it may be visually unpleasing to many customers.
sb3133 Step Clamps Are Not Reusable
14-024-DLR DTNA & JAD Highlights - Q1 & Q2
14-036-DLR DTNA & JAD Highlights - Q3
Software & Calibration
6 bulletinsField Service Campaign for GHG17 Detroit DD16 software reprogramming.
Warranty Information Letter updated to communicate warranty system updates.
Updates to troubleshooting guides in Diagnostic Link with newest version
1207-15 Updated procedures with adding EPA10 to the GHG14 title
Computer Hook-Up Standard Diagnostic Time Update
AEO15M1 GHG14 DD PLATFORM SOFTWARE REPROGRAMMING FOR AUTO ELEVATE
Brakes
4 bulletinssb4267 Brake Shimmy - Meritor SteeLite X30 Brake Drum with Excessive Runout
14TL5 ABS Power Line Carrier Converter Available Through PDC
16TL3 Pocket iQ? ABS Product Family Kit is Available at PDC
sb4268 Brake S-Cam Tube Lubrication Interval Change
Hybrid & EV
3 bulletinsThe modified parked regeneration strategy has been standard on GHG17 units since the start of GHG17 production and was...
Read full bulletin
added to EPA10 and GHG14 units with a software update. The modified regeneration utilizes an improved strategy to clean the DOC inlet face and reduce downtime due to DOC face plugging.
18TS4Rev DD Heavy Duty Platform Accessory Drive Belt
SPN 3556 FMI 0, 1, 18 - Regeneration Temperature Update Procedures
Tires & Wheels
3 bulletins14TL-7Rev DD Platform Flywheel Housing Runout Tool W470589032100
17TL25 TruckCam? Alignment System
14TL7 DD Platform Flywheel Housing Runout Tool W470589032100
HVAC & Climate
2 bulletinsNew H02 and H03 A/C lines.
Service Bulletin for A/C system receiver-drier replacement guidelines.
Infotainment
1 bulletinSS 1032974 High Oil Pressure on 2017 DTNA Vehicles Instrument Cluster Display