2016 Freightliner Coronado TSBs
483 Technical Service Bulletins across 16 categories
Categories
Other
174 bulletinsCX Advocate for GATS2.4 being expanding to DD15
Tech Talk discussion on repair verification for codes like 'low air flow' when a trailer is not available.
Tool Letter for New Final Drive Pinion Cover Install Tool
PowerNet Assessment Tool Repair Procedure
fp00024 Cable-Tie Reference
Letter to customer on Coverage Extension GHG17 After Treatment
SPN 3226 (ACM) (GHG17)
SPN 96 (MCM) (GHG17)
SPN 3226 (ACM) (GHG17)
Diagnostic tests - Two Filter System - FSIC Leak Test
SPN 712 (CPC) (GHG17)
Letter to customer on Coverage Extension GHG17 After Treatment
SPN 3226 (ACM) (GHG17)
SPN 96 (MCM) (GHG17)
SPN 3226 (ACM) (GHG17)
Diagnostic tests - Two Filter System - FSIC Leak Test
SPN 712 (CPC) (GHG17)
Technical Publications Ordering
sb54268 122SD and Coronado Virtual Technician Retrofit
SPN 3226 (ACM) (GHG17)
SPN 96 (MCM) (GHG17)
Diagnostic tests - Two Filter System - FSIC Leak Test
SPN 712 (CPC) (GHG17)
Instructions for CSC Diagnostic Support
SPN 3556 (ACM) (GHG14)
ICU4Me Low Air Pressure Warning Change
Towing Procedures
Operating Hours for the Customer Assistance Center
fp00020 Replacing Gross Vehicle Weight Rating (GVWR) Certification Labels
sb4932 DEF Gauge Reading Incorrectly
0105-15 SPN 102 (MCM) (GHG14)
0108-15 SPN 1323 through 1328 (MCM) (GHG14)
0106-15 SPN 3251 (ACM) (EPA10) and (GHG14)
0104-15 SPN 3464/ FMI 16, 18 (MCM) (GHG14)
0101-15 SPN 4364 (ACM) (EPA10)
0107-15 Enhanced Steam Clean
(CPC)(EPA10-GHG14) and SPN 98 (CPC)(GHG17)
0301-17 Contaminated Fluids
sb54215 ICU4M Missing VORAD Information or Reporting Fault SA 42 SPN FMI 07
Replacing or Upgrading Airliner 40K Transverse Torque Rods
324-15 External Component Repair
304-15 Diagnostic Tests
303-15 Contaminated Fluids
325-15 Symptom Diagnosis - ATD Checklist
323-15 Symptom Diagnostics ? Noise
306-15 SPN 3246 (ACM)(EPA10;GHG14)
307-15 SPN 3480 (MCM) (EPA07;EPA10;GHG14)
321-15 SPN 4364 (ACM) (GHG14)
320-15 SPN 4374 (ACM) (GHG14)
301-15 SPN 3251 (ACM) (EPA10) and (ACM) (GHG14), 3936 (ACM)
sb0038 00-38 - Vibration Troubleshooting: Finding the Cause
sb31034 Towing ProceduresB
sb3251 Replacing or Upgrading Airliner 40K Transverse Torque RodsB
sb2083 FluidXchange Tool and FittingsB
sb2053 New Stainless Steel Lower Radiator Tubes
sb1512 Accessories On When Key is OffB
sb00042 Flood Damage Repair GuidelinesB
fsb42072 Diagnostic de fuite d'air
sb3131 Huck-Spin 2 Changeover
0201-15 SPN 3250 FMI 31 - GHG14
0204-15 Symptom Diagnostics: Noisy One-Box Aftertreatment
0203-15 Oil Filter Stand Pipe
704-15 SPN 4364 (ACM)(EPA10)
706-15 SPN 1323 (MCM) (GHG14) SPN 1324 (MCM) (GHG14) SPN 1325
sb54292 Nexiq USB-Link Upgrade and Diagnostic Connector
805-15 FMI 0: Selective Catalyst Reduction Outlet Temperature High
DD Heavy Duty Platform Belt and Belt Tensioner
SPN 1663 (CPC) (EPA07 10 GHG14 GHG17)
0137-17 SPN 3361 FMI 5 (ACM) (GHG17) SPN 3361 FMI 5 (ACM) (GHG14)
0130-17 SPN 520211 (IPPC) (GHG14) SPN 520211 (IPPC) (GHG17)
0127-17 SPN 1077 FMI 14 (GHG14) (GHG17) (MCM)
0115-17 SPN 3226 (ACM) (EPA10;GHG14)
1207-16 SPN 4363 (ACM) (EPA10 GHG14)
1213-16 SPN 3480 (MCM) (EPA07;EPA10 GHG14)
15TS16Rev1 EPA10 Reman MCM Improvement for Fault Codes SPN 651 to 656
1202-15 Symptom Diagnostics - ATD Checklist
12-022-DLR Daimler Trucks Remarketing Corporation (DTR) Now Requires Pre-approval for Repairs $1,200 (USD) and Greater
15TS3 Detroit? Coolant Change From Nitrite Organic Acid Technology
405-15 Symptom Diagnostics - Hard Start/No Start - Two-Filter System
406-15 SPN 97 (MCM) (EPA10) / SPN 97 (MCM) (GHG14)
403-15 SPN 677 (MCM)(EPA07)
402-15 SPN 2630 (MCM)(EPA10) and SPN 2630 (MCM)(GHG14)
404-15 SPN 4364 (ACM) (EPA10)
15CSA10 The Detroit CSC announcing a new feature ? Ability to attach files to an existing CSC
15CSA9 Release of DiagnosticLink 8.02
505-15 SPN 3361 (ACM) (EPA10)
507-15 SPN 1590( CPC)(GHG14) and SPN 1590 (CPC)(EPA07;EPA10)
508-15 SPN 625 (MCM)( EPA10;GHG14)
sb2083 FluidXchange Tool and Fittings
15-009_Detroit_New_SDTs
15TL5 DAVCO Shop Pro FXP 95
324-15 External Component Repair
304-15 Diagnostic Tests
303-15 Contaminated Fluids
325-15 Symptom Diagnosis - ATD Checklist
323-15 Symptom Diagnostics ? Noise
306-15 SPN 3246 (ACM)(EPA10;GHG14)
307-15 SPN 3480 (MCM) (EPA07;EPA10;GHG14)
321-15 SPN 4364 (ACM) (GHG14)
320-15 SPN 4374 (ACM) (GHG14)
301-15 SPN 3251 (ACM) (EPA10) and (ACM) (GHG14), 3936 (ACM)
15CSA4 Holiday Schedule for the Detroit Customer Support Center
713-14 Symptom Diagnostics - Combustion Gas in Coolant
715-14 Symptom Diagnostics - Coolant Los
719-14 SPN 84 (CPC) (GHG14)
710-14 SPN 96 (CPC) (GHG14)
711-14 SPN 107 (CPC) (GHG14
701-14 SPN 168 FMI 0 and 1 (IPPC)(GHG14
706-14 SPN 171 FMI 3, 4 (CPC)(GHG14)
709-14 SPN 3216 (MCM) (GHG14)
703-14 SPN 3556 (ACM) (EPA10)
704-14 SPN 520200 FMI 6 (IPPC)(GHG14)
705-14 SPN 520203 FMI 6 (IPPC)(GHG14)
708-14 SPN 520219 (IPPC) (GHG14)
707-14 SPN 520229 FMI 3 (IPPC) (GHG14
702-14 SPN 520230FMI 5 (IPPC)(GHG14)
14-028 Remy Extended Coverage Direct File
14-027 Detroit's New Consolidated Labor Operations (CLOs
14-023 Detroit Axles Pre-Approval Changes
14-022 Pre-Approval Threshold Increase From $2,500 to $5,000 USD
54-215 - ICU4M Missing VORAD Information or Reporting Fault SA 42 SPN 639 FMI 07
16TL4 DOC Face Cleaning Tool P N W470589239100
16TS5 Release of the DD Platform Bearing Failure Guide
0304-16 SPN 2791 (MCM) ( GHG14) and SPN 2791 (MCM) ( GHG17)
0307-16 SPN 723 (MCM) March
0301-16 SPN 625 (CPC) (EPA07) and SPN 625 (CPC) (EPA10 GHG14)
Contaminated Fluids
Hydrocarbon Doser Coolant Lines
16-009R_OWL Enhancements
New Detroit Bearing Failure Analysis Standard Diagnostic Time
17-026 Holiday Closure 2017
17TL27 Injector Cup Tool DSN930E17001
17TL26 Injector Heat Sleeve Removal Tool DSN930E17002
17CSA25 New Method for Uploading Diagnostic Log Files to the CSC
17CSA24 Holiday Schedule for the Detroit Customer Support Center
17CSA23r Detroit CSC closed December 14, 2017 from 11:15 am - 1:15 pm Eastern Time
PAB053, USA-ONLY GM CHASSIS PRICE INCREASE
12-039-DLR OWL Pre-approval's Time Frame Increases to 60 Days
15-028 New Detroit Coolant Line SRTs
Detroit Data Summaries Application and Kits Are No Longer Available Through PDC
_NewDetroitCoolantLineSRTs
13wo3rev2_final Actual Labor Hours on Detroit Claims
0229-14 Symptom Based Diagnostics - Oil Separator
0233-14 SPN 51 FMI 2 - All Years
0224-14 SPN 1590 FMI 9 - CPC- All Years February 2014
807-14 FMI 8 SCR Inlet Temperature Signal Spike
801-14 FMI 19: RCM Message Not Received or Stopped Arriving
14-017R Revised: Detroit Addition of Admin Time
54-268 - Coronado Virtual Technician Retrofit
14-038_New_SRTs Additional Detroit Standard Repair Times.
14-039_additional_SDTs New Detroit Standard Diagnostic Times
14TL8 TorcUP? Non-Impacting Torque Tool.
14TS28 DD Platform Belt Drive System - Belt Part Numbers and diagnostics
1003-14 Rough Running or Stalling.
1009-14 SPN 5016 (ACM) (GHG14)
1007-14 SPN 5016/FMI 3, 4 (ACM) (EPA10)
1006-14 SPN 4374 (ACM) (GHG14)
1008-14 SPN 3510FMI 4,7, and 8 (CPC)(GHG14)
1010-14 SPN 2623 (CPC) (GHG14)
14CSA23 CSC Announces ?Tech Tips? ? DDCSN
14CSA21 Holiday Schedule for the Detroit Customer Support Center ?
14-039 New Detroit Standard Diagnostic Times
14-038 Additional Detroit Standard Repair Times
sb2080 Australian CST M1400 Isolated Radiator Retrofit
1108-14 SPN 636 (MCM) (EPA07;EPA10;GHG14)
18SP711 DD15 and DD16 Axial Power Turbine Bracket Ki
1021-16 SPN 110 (MCM)(EPA07EPA07;GHG14), SPN 110 (CPC)(GHG14)
1018-16 SYMPTOM DIAGNOSTICS - NOISE
0910-16 SPN 3251 (ACM) (GHG17)
0905-16 SPN 100 (MCM) (GHG17)
0901-16 SPN 5927 (MCM) (GHG17)
SB54268 122SD AND CORONADO VIRTUAL TECHNICIAN RETROFIT
0810-16 SYMPTOM DIAGNOSTIC NOISE
0809-16 SYMPTOM DIAGNOSTICS : NOISY 1- BOX AFTERTREATMENT
Engine
85 bulletinsCX Advocate for turbo oil drain cracking
CX Advocate for turbo oil drain cracking
CX Advocate for DD13 Gen 5 engines operating at high altitude experience EGR slow response fault.
Early EPA07 QLD Radiator Replacement.
Read full bulletin
As part of the changes made for early production EPA07 engines, the transmission oil cooler was moved into the radiator, and transmission oil cooler lines equipped with Gates Quick-Detach (QLD) connectors were fitted.
DEF Tank Coolant Valve O-Ring Kit
sb54298 GHG17 Heavy Duty Engine Platform Vehicle Dash Oil
Technical Service Letter for GHG17 1-Box Inlet and Outlet Exhaust Clamps.
Read full bulletin
There is a short supply of exhaust clamps, part number DDE A6809950502, used as inlet and outlet exhaust clamps on GHG17 heavy duty engines (DD13, DD15 and DD16) with a 1-Box aftertreatment configuration. Exhaust clamp part number TCX T130158342AC2 may be used as a substitute for DDE A6809950502, but be aware of the different torque specs between the two parts.
Training Solutions for Fuel Leak Found at High Pressure Fuel Pump Weep Hole for Heavy Duty DD Engines.
Read full bulletin
Occasionally we see trucks come in with fuel leaking from the high pressure fuel pump weep hole. This is NOT a defect in the pump and further diagnostics need to be performed to find the root cause.
Updated Recall Safety Bulletin for vehicles in Australia and New Zealand with DD15 engines regarding high pressure fuel lines.
Read full bulletin
Language was clarified that this only applies to Australia and New Zealand.
Export Recall Safety Bulletin for vehicles in Australia and New Zealand with DD15 engines regarding high pressure fuel...
Read full bulletin
lines.
Service Information Bulletin to updated the Fuel Injector Harness sections and relocated to Engine Electrical section.
Cylinder Liner - Testing of the Cylinder Liner Upper O-Ring
Cylinder Liner - Testing of the Cylinder Liner Upper O-Ring
Cylinder Liner - Testing of the Cylinder Liner Upper O-Ring
New Detroit Diesel Cylinder Liner Upper O-Ring Leak Test Standard Repair Time
Engine Manufacturer Diagnostics
DD13, DD15, DD16 Check Engine Light Flashing or Blinking
15TS4 EPA07 DD15 Piston Kits
15TS2 EPA07 and EPA10 DD Platform Engines With Low Oil Pressure Codes
15TS1 GHG14 DD Platform Engines With Codes SPN: 1323 through SPN: 1328, FMI: 31, Idle Smoothness Control/Cylinder...
Read full bulletin
Misfire At Idle
GHG14 - Intake Manifold Pressure Too Low
GHG14 Intake Manifold Pressure Too Low
GHG17 Heavy Duty Engine Platform Vehicle Dash Oil Pressure Gauge
0202-17 DD13, DD15, and DD16 Cylinder Head Assembly Removal and Installation
308-15 Symptom Diagnostics - Oil Present at the Turbocharger Compressor
302-15 Crankshaft Oil Seals
18SP706 Replacement of the High Pressure Fuel Pump Camshaft Oil Seal
sb2084 OAT Coolant Replaces NOAT Coolant in Detroit Engines
sb0175 Replacing Drive Belts on MBE4000 EnginesB
sb0006 Freightliner Courtesy Engineering PolicyB
15TS6 Replacement of the High Pressure Fuel Pump Camshaft Oil Seal
15TS14 GHG14 DD Engine Cylinder Liner Seal Replacement
708-15 High Pressure Fuel Pump Camshaft Oil Seal - Two-Filter System
711-15 High Pressure Fuel Pump Camshaft Oil Seal - Three-Filter System
702-15 DD15 and DD16 Delphi Exhaust Gas Recirculation Valve Actuator
703-15 GHG14 DD15 AT Exhaust Gas Recirculation Valve Actuator
803-15 Removal of the Camshaft Housing
Heavy Duty Engine Wastegate Repair Kit DKI470E16019
0120-17 Diagnostic Test - Engine Oil Leaks - Oil Developer Method
0118-17 Symptom Diagnostics - Oil Leaks
15TL24 OTC 1750 Revolver Engine Stand
15TS4_Rev2_ EPA07 DD15 Piston Kits
1210-14 Cylinder Head
15TS10Rev DD Engine Platform Coolant Filter
401-15 Cylinder Block
15TS13 DD Platform Oil Filter Bypass Valve
15TS12 DD Platform Cylinder Block Oil Gallery Cup Plug Replacement
501-15 Engine Lifter Brackets
504-15 DD13 Exhaust Gas Recirculation Valve Actuator Pull Rod
511-15 DD15 and DD16 Exhaust Gas Recirculation Valve Actuator Pull Rod
503-15 DD13 Exhaust Gas Recirculation Valve Actuator
sb2084 OAT Coolant Replaces NOAT Coolant in Detroit Engines
15TL4 W470589050900 ? 3/8? Drive GEN2 Two-Stage Valve Socket
308-15 Symptom Diagnostics - Oil Present at the Turbocharger Compressor
302-15 Crankshaft Oil Seals
18SP706 Replacement of the High Pressure Fuel Pump Camshaft Oil Seal
sb01101 Pilot Bearing Spacer for Detroit Engines with Eaton transmissions
14TL2 DD Platform Engine Stand Adapter W060589023100
14TS18 GHG14 DD Engine EGR System Fault Code
714-14 Symptom Diagnostics - Low Engine Compression
712-14 Engine Coolant Temperature
20-73 - CANCELED: Cascadia Radiator Update?EPA10 with DDC Engines
20-75 - CANCELED: Cascadia Radiator Update?EPA10 with Cummins ISX Engines
16TS8 DD13 Cylinder Head and Cylinder Head Gasket Change
16-011 New Detroit Camshaft Housing Seal Standard Repair Time
sb4724 Crank No Start, Loss of Engine Prime on Decked Vehicles
12-038-DLR - No Problem Found - Policy Claims - During Basic Vehicle Chassis or Base Engine Coverage
14TS4 Valve and Liner Installation Tool Issue
0228-14 Engine Oil Leaks - Oil Dye Method
0237-14 Engine Brake Solenoid
14TS21 HDEP Camshaft Position Sensor Change
804-14 FMI 16, 18 Intake Manifold Pressure Too high and low (Restricted Mode)
803-14 FMI 16,18: Intake Manifold Pressure Too High and Low
812-14 FMI 3, 4: Engine Aux.
Read full bulletin
Shutdown Input Failed High and Low
14-040_Additional_CLOs Additional Detroit CLOs for the Heavy Duty Engine Platform
14CSA20 EGR Valve Actuator Kit P/N E23539699
14-040 Additional Detroit CLOs for the Heavy Duty Engine Platform
1102-14 DD13 Cylinder Head R&R
1101-14 DD15 and DD16 Cylinder Head
16TS24 GHG14 DD Platform Engines With Code SPN: 3216/FMI 18, SCR Inlet NOx Sensor Drift Low
14TS16REV EXCESSIVE OVERHEAD ENGINE NOISE ON GHG14 DD PLATFORM ENGINES
SB0006 FREIGHTLINER COURTESY ENGINEERING POLICY
1017-16 ENGINE MODEL AND SERIAL NUMBER DESIGNATION
16TL20 HEAVY DUTY ENGINE VALVE STEM SEAL INSTALLING DRIFT AND SLEEVE
0909-16 EXCESSIVE OIL CONSUMPTION
Fuel System
65 bulletinsDetroit Emission recall for GHG14 DETROIT DD16 Software Reprogramming
Detroit Emission recall for GHG14 DETROIT DD16 Software Reprogramming
Detroit Emission recall for GHG14 DETROIT DD16 Software Reprogramming
Customer Service Announcement saying that Service Pack (SP) 3 for DiagnosticLink 8.11 Standard and Professional will be...
Read full bulletin
available for download from the Detroit Diesel server.
Service Bulletin for Equiflo Fuel System Breather Tube Inspection
Service Information Bulletin for Symptom Diagnostics - Fluid in the Aftertreatment - Diesel Fuel Contamination.
Service Information Bulletin regarding PTO Dosing.
Read full bulletin
This feature enables Active Regeneration of the DPFs while in PTO mode.
Fuel System Integrity Check Routine - Two-Filter Fuel System
Fuel Level Sending Unit Retrofit
Fuel System Integrity Check Routine - Two-Filter Fuel System
Fuel Level Sending Unit Retrofit
Fuel System Integrity Check Routine - Two-Filter Fuel System
Emission Recall D18R5 GHG17 DD Platform Model Years 2016-2018 Software Reprogramming For California Onboard Diagnostics
102-15 High Pressure Fuel Pump - Two-Filter System
18SP687 DD15 16 EGR Actuator Replacement
18SP712 EPA07 DD15/16 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel System Conversion Service Kit
18SP713 EPA10 DD13 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel System Conversion Service Kit
18SP714 EPA10 DD15/16 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel System Conversion Service Kit
sb54296 Fuel Level Sending Unit RetrofitB
sb54148 Radio and Integrated Thin-Film Antenna Troubleshooting, and Field Service UpdatesB
sb49040 Diesel Exhaust Fluid (DEF) Pressure Line Disconnected at the Doser ConnectionB
fsb49040 Conduite sous pression de fluide pour chappement diesel (DEF) dbranche au niveau du raccordement du doseur
15TS8 EPA10 and GHG14 Diesel Particulate Filter (DPF) Compatibility
0202-15 EPA10 and GHG14 Diesel Oxidation Catalyst Face Cleaning
Diesel Exhaust Fluid (DEF) Pressure Line Disconnected at the Doser Connection
SPN 4765 FMI 0 - Exhaust Temperature Out Of Range High
15TL6 W470589129100 ? HDEP HP Fuel Rail Test Caps
18SP717 DD13 EGR Actuator Replacement
509-15 Symptom Diagnostics - Hard Start/No Start - Three-Filter Fuel
512-15 GHG14 DD15 AT Exhaust Gas Recirculation Actuator Pull Rod
502-15 Exhaust Gas Recirculation Actuator Lever
18SP716 Installation/Replacement of the Fuel Cooler Delete Bypass Plate for the Two-Filter Fuel System
15-017 Detroit: Updated Fuel Injector SDTs
18SP712 EPA07 DD15/16 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel System Conversion Service Kit
18SP713 EPA10 DD13 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel System Conversion Service Kit
18SP714 EPA10 DD15/16 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel System Conversion Service Kit
14TS19 DD Platform High Pressure Fuel Lines
18SP710Rev 18SP710Rev ? EPA10 GHG14 Two-Filter Fuel
18SP709Rev 18SP709Rev ? EPA10/GHG14 Two-Filter Fuel
18SP701Rev2 18SP701Rev2? GHG14 Two-Filter Fuel System
16TS9 DD Platform High Pressure Fuel Lines
16TS7 Reman Diesel Particulate Filter Serial Number
17TL28 Fuel Injector Removal Tool DSN930E17004
0239-14 High Pressure Fuel Injector Lines - Three-Filter System
0238-14 Removal of the High Pressure Fuel Injector Lines - Two-Filter
0210-14 High Pressure Fuel Rail Feed Lines - Three-Filter System
0209-14 High Pressure Fuel Rail Feed Lines - Two-Filter System
0219-14 Metal in Fuel
0202-14 Symptom Diagnostics - Hard Start No Start - Two-Filter Fuel System
0215-14 Check for Rough Running or Stalling - Three-Filter Fuel System
18SP703 18SP703 - GHG14 KM63 GEN2 Low Pressure Fuel Pump-Two-Filter Fuel System Ki
14TS19Rev DD Platform High Pressure Fuel Lines
1104-14 Metal in the Fuel System
18SP707Rev EPA07/10 Three-Filter Fuel System DD13 High Pressure Fuel Feed Lines, Mounting Bracket and P-clips Service...
Read full bulletin
Kit
18SP708Rev EPA07 10 Three-Filter Fuel
18SP719Rev EPA10 DD13 Three-Filter ESOC Fuel System to Two-Filter KM59 GEN1 Fuel
18SP714Rev EPA10 DD1516 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel
18SP725 TWO-FILTER FUEL SYSTEM KM63 GEN2 DD13 HIGH PRESSURE FUEL FEED LINES, MOUNTING BRACKET AND P-CLIPS SERVICE KIT
18SP722 DD13 KM59 GEN1 BUS TWO-FILTER SYSTEM AMPLIFIER, NEEDLE AND PLV RETURN FUEL LINE CLEARANCE PACKAGE SERVICE KIT
18SP720 EPA10 DD15/16 THREE-FILTER ESOC FUEL SYSTEM TO TWO-FILTER KM59 GEN1 FUEL SYSTEM CONVERSION SERVICE KIT
18SP720 EPA10 DD15/16 THREE-FILTER ESOC FUEL SYSTEM TO TWO-FILTER KM59 GEN1 FUEL SYSTEM CONVERSION SERVICE KIT 2
18SP718 EPA07 DD15/16 THREE-FILTER ESOC FUEL SYSTEM TO TWO-FILTER KM59 GEN1 FUEL SYSTEM CONVERSION SERVICE KIT
1020-16 CHASSIS FUEL SYSTEM ISOLATION TEST
18SP720REV 18SP720 EPA10 DD15/16 THREE-FILTER ESOC FUEL SYSTEM TO TWO-FILTER KM59 GEN1 FUEL SYSTEM CONVERSION SERVICE...
Read full bulletin
KIT
18SP713REV 18SP713 EPA10 DD13 THREE-FILTER FUEL SYSTEM TO TWO-FILTER KM59 GEN1 FUEL SYSTEM CONVERSION SERVICE KIT
Electrical
41 bulletinsVehicles built in model year 2016 use a bulkhead module (BHM) with a 500k auto baud rate.
Read full bulletin
If a BHM needs replacement, it must be replaced with the new BHM (A66-03086-000) with a 500k auto baud rate.
Service Solution SS 1033094 KUS Float Tube Fuel Level Sensor Inform...
Powernet Troubleshooting Guide: Batteries, Path, Alternator, and Starter
Updated Service Bulletin for upgrading BHM software for switch expansion module fault SPN 698 FMI 7.
Read full bulletin
This bulletin replaces the version dated 11/11/2019. Figure 3 has been updated with a new hardware part number. A procedure was added to the data download process.
Updated Freightliner Service Bulletin for Powernet Troubleshooting Guide - Batteries, Path, Alternator, and Starter.
Read full bulletin
This bulletin replaces the version dated 5/31/2017. Information is added about the BCT-460DTNA PowerNet Assessment Tool. When troubleshooting Powernet issues, use the BCT-460DTNA PowerNet Assessment Tool. As of May 29, 2018, the AutoMeter is the only Daimler-approved tool for troubleshooting vehicle Powernet issues.
Service Bulletin for Guidelines for Repairing or Replacing an Electrical Harness.
Read full bulletin
Use the guidelines in this bulletin to determine if a damaged electrical harness should be repaired or replaced.
Service Bulletin on guidelines for repairing or replacing an electrical harness.
Service Bulletin for upgrading BHM software for switch expansion module fault SPN 698 FMI 7.
Service Information Bulletin for Communication Loss with a Common Powertrain Controller (CPC) Module (CPC Heartbeat...
Read full bulletin
Message is no Longer Arriving)
SS 1034220 SSI Ultrasonic Fuel Level Sensor Information
54-277 - Resetting Erroneous Learned Roll Call ECUs on Vehicles with ICU4M
54-278 - Powernet Troubleshooting Guide: Batteries, Path, Alternator, and Starter
54-274 - Plastic Battery Box Cover Retainer Clip
15TS9 Hydrocarbon Doser Block Fuel Compensation Pressure Sensor
326-15 Main Shaft Speed Sensor
sb54278 Powernet Troubleshooting Guide Batteries, Path, Alternator, and Starter
sb54202 Rerouting the DDEC IV Relative-Humidity-Sensor Harness
sb2066 Gentech Low Coolant Level Sensor
sb54278 Powernet Troubleshooting Guide: Batteries, Path, Alternator
802-15 SPN 520970 FMI 7 (TCM)
801-15 SPN 520999 FMI 7 (TCM)
SPN 521221 (TCM)
SPN 521222 (TCM)
1205-15 Selective Catalyst Reduction (SCR) Inlet Temperature Sensor
FMI 3,4,5 Digital Output 2 10 Circuit
15-016-DLR New Essential Tool For CPWA, CPPRA, Ltd CPPRA, & DSDWC Parties: Cadex CA-12 Battery Tester
15TS9 Hydrocarbon Doser Block Fuel Compensation Pressure Sensor
326-15 Main Shaft Speed Sensor
54-285 - Cracked Fuses on Powertrain Power Distribution Modules
16TL5 DD Platform Aftertreatment Soot Sensor Socket DSN0ATZ16001
16_TL-2 DD Platform Aftertreatment NOx Sensor Socket W470589060900
14TS5 Replacing Damaged Aftertreatment Sensor Bosses
809-14 FMI 3, 4, 5, 31: Diesel Exhaust Fluid System Circuit Failed
802-14 FMI 3, 4: Diesel Exhaust Fluid Pressure Sensor Circuit Failed High and low
14TS30 Aftertreatment Harness Diagnostics
1005-14 Oil Coolant Module
14CSA22 DTNA Chassis Wiring Diagrams
18SP684Rev4 18SP684Rev4 ? EPA07 and EPA10 DD Platform EGR Delta Pressure Sensor Update
18SP705Rev5 18SP705Rev5 ? DD Platform Delta Pressure Sensor
sb54287 Powernet Distribution Box Fuse Retention on the Keep-Alive
sbw5460 Powernet Distribution Box Fuse Retention on the Keep-Alive
Pre-Delivery & Maintenance
36 bulletinsImportant Campaign Information letter for DDC D24R4 - Campaign Reactivated
Important Campaign Information letter for DDC D24R4 - Campaign Inactivated
Freightliner Service Bulletin for DEF Connector Reinforcement Caps.
Service Bulletin for Guidelines for Cleaning and Disinfecting Cab Surfaces.
Read full bulletin
The following guidelines are for cleaning and disinfecting commonly touched surfaces on the inside and outside of a vehicle. For best results, follow cleaning and disinfecting procedures fully and consistently. Ensure there is adequate ventilation when using chemicals. NOTICE: Wipe down fragile components carefully to avoid damaging the vehicle.
Open recall and Field service Campaigns report send out to Dealers, General Managers, Service managers and warranty...
Read full bulletin
managers.
Freightliner Service Bulletin for vibration troubleshooting - finding the cause.
Read full bulletin
This version replaces the version dated 5/1/14 and adds New Cascadia.
Warranty Policy Letter explaining the Warranty Department is aligning with the frame rail repair policy, published in...
Read full bulletin
DTNA Workshop Manuals, which states that there are very few cases in which welding a heat-treated frame rail is allowed. Therefore, before welding anything on a frame rail, contact the applicable regional service representative for approval.
Open recall and Field service Campaigns report send out to Dealers, General Managers, Service managers and warranty...
Read full bulletin
managers
Communication to assist the field with service vibration issues on DTNA vehicles
Warranty Policy Letter to communicate Detroit Return Changes
Warranty Information Letter to announce addition of Thomas Built Bus as a brand with an Authorized Demonstrator Program
Service Information Bulletin was released, to add new procedures to address diagnostics near the high pressure pump
Warranty Information Letter sent to customers regarding new refrigerator supplier for returning parts.
Training Solution created by DTNA to provide guidance to customers when searching for service information for components...
Read full bulletin
and systems not owned by Daimler Trucks North America (DTNA).
Service Bulletin- sb54311 ICU Odometer Programming
Reminder: Paper Service Bulletin Mailings Are Discontinued
Important Campaign Information on FL614 Recall
Service information Bulletin -HDEP PLV Return Line Tool DSN470E17006
Service Information Bulletin for Aftertreamtent Failure Guide
Important Warranty Information on AutoMeter BCT-460DTNA Powernet Assessment Tool: Warranty Requirement and Claim Filing
Release of DiagnosticLink 8.08 Service Pack 2
If a GVWR certification label is lost or damaged, Freightliner will supply a duplicate label.
Read full bulletin
Log on to DTNAConnect.com and under "DTNAConnect Resources", select the "Tool and Services" plus sign. Select "Request for Certification Label or OWI." Fillout the form, then select "Review."
ICI18-014 Owner Notice ? Kidde Fire Extinguisher Recall
ICI18-014 Owner Notice ? Kidde Fire Extinguisher Recall
sb54194 Required Maintenance for Freightliner-Branded and Delco Cassette Players
sb54122 ICU3 Service Cluster AvailableB
15-015 Warranty Exclusions Reminder
14-026-DLR SelecTruck Warranty Enhancements
Canadian Warranty Parts Return Address Change
OWL Enhancement Service Model Field
Warranty Classroom Training in 2018
12-041-DLR Over the Counter No Hassle Warranty (OTC)
_Warranty Recognition Program - Coming Soon
14WO-9_Warranty_Access Detroit New User Warranty Access Request
14TL9 Special Tool Warranty Program.
16TS14 EPA10 AND GHG14 SERVICE REPLACEMENT 1-BOX DOC INLET CHANGE
Suspension
16 bulletinsRevised Freightliner Service Bulletin for Axle Flange Gasket Replaced with O-Ring.
Read full bulletin
Revision removed steps instructing removal and installation of wheels. Daimler Trucks North America has released a new axle shaft to hub rubber O-ring (part number 11-30728-000) as a replacement for the paper gasket (part number 11-14418-000). The new O-ring will provide better sealing and is reusable. It is quicker and easier to use compared to the paper gasket, because using a paper gasket requires cleaning the hub when the axle shaft is removed.
Freightliner Service Bulletin for Axle Flange Gasket Replaced with O-Ring.
Read full bulletin
Daimler Trucks North America has released a new axle shaft to hub rubber O-ring (part number 11-30728-000) as a replacement for the paper gasket (part number 11-14418-000). The new O-ring will provide better sealing and is reusable. It is quicker and easier to use compared to the paper gasket, because using a paper gasket requires cleaning the hub when the axle shaft is removed.
Freightliner Service Bulletin for Non-Airliner Rear Suspension Crossmember Fastener Change.
Read full bulletin
With the start of production on March 2, 2020, the fasteners used to assemble the non-Airliner rear suspension (bogie) crossmember have changed. The rear suspension bogie crossmember gussets to the C-channel will be assembled with 5/8 - 18 fasteners. This change includes a revision to a higher friction nut that requires an increase in tightening torque. The new higher friction nut can be identified by its green color.
Freightliner Service Bulletin for Front Axle Spacer Replacement.
Read full bulletin
This service bulletin replaces the version dated 05/01/2016. This bulletin is updated to include the parts list. Some vehicles may exhibit a lean (right or left) due to weight difference on the front suspension. While this does not affect the operation of the vehicle, it may be visually unpleasing to many customers. To correct this condition, replace the existing front axle spacer on the low side of the vehicle with a thicker one.
Service Bulletin for Hendrickson HaulMaax Rear Suspension Transverse Torque Rod Tower Bracket Replacement
Tool Letter for New Final Drive Driver Controlled Differential Lock Spring Compressor.
Read full bulletin
These new axles require a new tool to compress the Driver Controlled Differential Lock (DCDL) spring. To remove and install the DCDL spring, the tool DSN0FDA17001 is needed.
Service Bulletin to fix vehicles which may have an incorrect transverse torque rod tower bracket installed on the rear drive axles at the factory.
Read full bulletin
This can result in cracking at the transverse rod tower where it is welded to the axle housing, premature wearing of the transverse torque rod tapered pin and bushings, and damage to the transverse torque rod frame bracket.
SS 1034171 Airliner Rear Suspension Chassis Lean Troubleshooting
Service Bulletin: AirLiner Suspension Six-Piece Bolted Service Crossmember
With the start of production on February 12, 2018, the fasteners used to assemble Airliner rear suspension crossmembers changed.
Read full bulletin
The forward-suspension crossmember will assembled with 5/8-18 fasteners and the rear-suspension (bogie) crossmember will be assembled with 3/4-16 fasteners.
33-28 - Bearing Spacer Replacement, ConMet PreSet Steer Hubs
35-30 - Bearing Spacer Replacement, ConMet PreSet Drive Hubs
Detroit? DT12? Split Rod Bushing Repair
sb8846 Upgrading to Hood Tilt-Assist Struts With 10-mm Rod Ends, Coronado
Warranty Recognition Program Suspension
FL718 FRONT AXLE HUB RATING
Transmission
13 bulletinsService Bulletin for Lengthening the Backup Light Harness.
Read full bulletin
Though the backup light harness is long enough to connect to the backup light switch, it may be short enough that the wire seals in the connector can be stressed. Moisture entering through the seals can cause corrosion, resulting in a bad connection and/or failure of the switch. As a result, backup lights and, if equipped, the backup alarm, may not function when the vehicle is shifted into reverse.
Field Service Campaign for Remanufactured Detroit DT12 Transmissions
Warranty Policy Letter to communicate remarketing handling cap for Detroit DT12 Transmission.
sb2074 Kysor Fan Clutch Rocking Runout Inspection
sb2052 Horton Drivemaster Fan Clutch Hub Bearings
15TS15Rev Detroit? DT12? Transmission Proper Towing Procedure
Detroit? DT12? Transmission Proper Moving Procedure
FMI 2- Automatic Gear Selection - Incompatible or missing dataset
Clutch Release Bearing Grease Hose
15-010-DLR Transmission Cooler Line Photos
811-14 FMI 7: Internal Error with the DT12 Shift Stalk Lever
1105-14 Flywheel, Ring Gear and Flywheel Housing
16TS16 DETROIT DT12 TRANSMISSION OIL AND OIL FILL/DRAIN PLUG WASHERS
Body & Paint
12 bulletinsService Bulletin for Window Regulator Retrofit
Customer Service Announcement Letter Revision for Dealers/Distributors Accessing DDEC Backdoor Passwords
Warranty Information Letter - Expanded guidelines for paint-related claims sent out to Freightliner, Western star,...
Read full bulletin
Thomas Built Bus, Export and Direct warranty customers
Service Bulletin 9817- Paint Supplier Change
Service Bulletin 9815- Paint Finish Standards
The right-hand cab panel on New Cascadia can come into contact with the right-hand chassis-side fairing when making a left turn.
Read full bulletin
This contact can result in an audible popping noise, paint-damage to the rocker panel and damage to the back-side of the chassis-side fairing.
sb9815 Paint Finish Standards
sb98020 Axalta Paint Finish CareB
sb9815 Paint Finish StandardsB
sb2043 Radiator Fan Shroud Seal
Body SRT Updates -2012.12.12
12-040-DLR Roof Fairing Removal Program
Steering
10 bulletinsSteering Intermediate Shaft Replacement
Adjusting Tilt Lock Force on TRW Steering Columns
Adjusting Tilt Lock Force on TRW Steering Columns
Adjusting Tilt Lock Force on TRW Steering Columns
Adjusting Tilt Lock Force on TRW Steering Columns
sb4641 Adjusting Tilt Lock Force on TRW Steering ColumnsB
fp46907 Steering Intermediate Shaft ReplacementB
15R2 DETROIT AXLE STEERING ARM CAPSCREW INSPECTION
15R3 DETROIT AXLE STEERING ARM CAPSCREW REPLACEMENT
FP46907 STEERING INTERMEDIATE SHAFT REPLACEMENT
Software & Calibration
8 bulletinsField Service Campaign for GHG17 Detroit DD16 software reprogramming.
Warranty Information Letter updated to communicate warranty system updates.
Updates to troubleshooting guides in Diagnostic Link with newest version
1207-15 Updated procedures with adding EPA10 to the GHG14 title
Computer Hook-Up Standard Diagnostic Time Update
FINAL_15M1_BULLETIN GHG14 DD PLATFORM SOFTWARE REPROGRAMMING FOR AUTO ELEVATE
AEO15M1 GHG14 DD PLATFORM SOFTWARE REPROGRAMMING FOR AUTO ELEVATE
16-032_DETROIT STANDARD DIAGNOSTIC TIME FOR GHG14 AFTERTREATMENT DEVICE CHECKLIST UPDATED
Lighting
6 bulletinsCustomer Service Announcement for a policy change regarding Detroit Service Information Bulletins (SIBs) will now have a...
Read full bulletin
60-day expiration, starting on the release day of the bulletin. The intent of a SIB is to notify the service network of a major change to one or more service procedures. Do not save SIBs nor reference them for repairs, as they are uncontrolled and never updated.
sb2046 ABA Hose Clamp Torque Values
Some vehicles may have been incorrectly shimmed at the factory, and may lean slightly to the right or left.
Read full bulletin
While this does not affect the operation of the vehicle, it may be visually unpleasing to many customers.
sb3133 Step Clamps Are Not Reusable
14-024-DLR DTNA & JAD Highlights - Q1 & Q2
14-036-DLR DTNA & JAD Highlights - Q3
HVAC & Climate
5 bulletins2016 Coronado HVAC Communucation and Troubleshooting
New H02 and H03 A/C lines.
Tech Talk discussion on Coronado HVAC troubleshooting.
Service Bulletin for A/C system receiver-drier replacement guidelines.
506-15 Air Compressor Coolant Lines
Hybrid & EV
4 bulletinsThe modified parked regeneration strategy has been standard on GHG17 units since the start of GHG17 production and was...
Read full bulletin
added to EPA10 and GHG14 units with a software update. The modified regeneration utilizes an improved strategy to clean the DOC inlet face and reduce downtime due to DOC face plugging.
18TS4Rev DD Heavy Duty Platform Accessory Drive Belt
15TS5Rev GHG14 DD Platform DEF Pump Leaks and Code 4374 FMI 0 Under Pressurized DEF System
SPN 3556 FMI 0, 1, 18 - Regeneration Temperature Update Procedures
Brakes
4 bulletinssb4267 Brake Shimmy - Meritor SteeLite X30 Brake Drum with Excessive Runout
14TL5 ABS Power Line Carrier Converter Available Through PDC
16TL3 Pocket iQ? ABS Product Family Kit is Available at PDC
sb4268 Brake S-Cam Tube Lubrication Interval Change
Tires & Wheels
3 bulletins14TL-7Rev DD Platform Flywheel Housing Runout Tool W470589032100
17TL25 TruckCam? Alignment System
14TL7 DD Platform Flywheel Housing Runout Tool W470589032100
Infotainment
1 bulletinSS 1032974 High Oil Pressure on 2017 DTNA Vehicles Instrument Cluster Display