2012 Freightliner Coronado TSBs

Tech Talk discussion on repair verification for codes like 'low air flow' when a trailer is not available.

ICI19-011 FL782 - Revised Bulletin

fp00024 Cable-Tie Reference

Letter to customer on Coverage Extension GHG17 After Treatment

SPN 3226 (ACM) (GHG17)

SPN 96 (MCM) (GHG17)

SPN 3226 (ACM) (GHG17)

Diagnostic tests - Two Filter System - FSIC Leak Test

SPN 3464 (MCM) (GHG14)

SPN 712 (CPC) (GHG17)

Letter to customer on Coverage Extension GHG17 After Treatment

SPN 3226 (ACM) (GHG17)

SPN 96 (MCM) (GHG17)

SPN 3226 (ACM) (GHG17)

Diagnostic tests - Two Filter System - FSIC Leak Test

SPN 3464 (MCM) (GHG14)

SPN 712 (CPC) (GHG17)

Technical Publications Ordering

sb54268 122SD and Coronado Virtual Technician Retrofit

SPN 3226 (ACM) (GHG17)

SPN 96 (MCM) (GHG17)

Diagnostic tests - Two Filter System - FSIC Leak Test

SPN 3464 (MCM) (GHG14)

SPN 712 (CPC) (GHG17)

Instructions for CSC Diagnostic Support

Towing Procedures

Operating Hours for the Customer Assistance Center

fp00020 Replacing Gross Vehicle Weight Rating (GVWR) Certification Labels

sb4932 DEF Gauge Reading Incorrectly

528-13 SPN 3246-FMI 0 - EPA10 - GHG14

527-13 SPN 190-FMI 15,17 GHG14

525-13 SPN 2791-FMI 7 ? ALL YEARS

518-13 SPN 4334-FMI 4 - GHG14

Issues with PTO and Remote Throttle Combinations

0105-15 SPN 102 (MCM) (GHG14)

0108-15 SPN 1323 through 1328 (MCM) (GHG14)

0106-15 SPN 3251 (ACM) (EPA10) and (GHG14)

0104-15 SPN 3464/ FMI 16, 18 (MCM) (GHG14)

0101-15 SPN 4364 (ACM) (EPA10)

0107-15 Enhanced Steam Clean

(CPC)(EPA10-GHG14) and SPN 98 (CPC)(GHG17)

sb54215 ICU4M Missing VORAD Information or Reporting Fault SA 42 SPN FMI 07

418-13 SPN 2791-FMI 12 - GHG14

603-13 SPN 84 -FMI 6 - EPA07-GHG14

706-13 SPN 157-FMI 10, 15, 17, 18 - GHG14

709-13 SPN 2798-FMI 4-EPA10-GHG14

716-13 SPN 3226-FMI 13 - EPA10 - GHG14, SPN 3216-FMI 13 ? EPA10, SPN 3216-FMI 13 - GHG14

713-13 SPN 4334-FMI 7 - EPA10

Replacing or Upgrading Airliner 40K Transverse Torque Rods

324-15 External Component Repair

304-15 Diagnostic Tests

303-15 Contaminated Fluids

323-15 Symptom Diagnostics ? Noise

306-15 SPN 3246 (ACM)(EPA10;GHG14)

309-15 SPN 3251 (ACM)(EPA10)

307-15 SPN 3480 (MCM) (EPA07;EPA10;GHG14)

301-15 SPN 3251 (ACM) (EPA10) and (ACM) (GHG14), 3936 (ACM)

522-14 Removal and Installation of the Oil Pump Cover

518-14 FMI 1, 18: Regen Temperature- Out Of Range Low

519-14 FMI 1: SCR NOx Conversion Efficiency Very Low

502-14 FMI 4 SCR Inlet Temperature High

sb54215 54-215 - ICU4M Missing VORAD Information or Reporting Fault SA 42 SPN 639 FMI 07

sb31034 Towing ProceduresB

sb3251 Replacing or Upgrading Airliner 40K Transverse Torque RodsB

sb2083 FluidXchange Tool and FittingsB

sb2053 New Stainless Steel Lower Radiator Tubes

sb1512 Accessories On When Key is OffB

sb00042 Flood Damage Repair GuidelinesB

13WO-2-New Standard Rpr Times orgl 11WO2 New Standard Repair Times for EPA07-10 DD13-15 Diagnostic Tests

FL631-DLR Perpendicular Aluminum Air Tank Mounting Brackets

ICI13-001-DLR FL631 - Revised Bulletin

13TS12 HDEP Wastegate Solenoid Air Leaks

13TS8 GHG14 Throttle Codes SPN 91-FMI 7 and SPN 91-FMI 10

311-13 SPN 651-FMI 3 - EPA10 - GHG14

303-13 SPN 3242-FMI 4 -EPA10 - GHG14

301-13 SPN 5018- FMI 18 -GHG14

808-13 FMI 0 Under Pressurized DEF System

802-13 FMI 18 Coolant Level Low

803-13 FMI 10,18: Intake Throttle Position Abnormal Rate of Change, Position Data Valid but Below Normal Operating Range...

803-13 FMI 2: Intake Throttle Position Deviation Error

1118-12 SPN 705-FMI 5 - GHG14

1113-12 SPN 3226/FMI 20 - GHG14

ICI12-026-DLR SF471 - Second Revised Bulletin

ICI12-025-DLR SF471 - Revised Bulletin

sb3131 Huck-Spin 2 Changeover

102-13 SPN 84-FMI 13, 19, 21 (MCM) EPA10-GHG14

107-13 SPN 84-FMI 7 - GHG14

106-13 SPN 100-FMI 10 - GHG14

105-13 SPN 625-FMI 13 - GHG14

135-13 SPN 1243-FMI 14 - GHG14

104-13 SPN 1592-FMI 13 and 19 - GHG14

137-13 SPN 2798-FMI 4 - EPA10 - GHG14

109-13 SPN 3250-FMI 31 (ACM2.1) GHG14

139-13 SPN 3251-FMI 0, 16, 20, 21 GHG14

108-13 SPN 3364-FMI 18 - GHG14

101-13 SPN 3563 FMI 21 - GHG14

132-13 SPN 3597-FMI 4 - EPA10

146-13 SPN 4335-FMI 1 EPA10

133-13 SPN 4375-FMI 4 and 5 - GHG14

112-13 SPN 4364-FMI 18 - GHG14

111-13 SPN 4374/FMI 0, 1, 3, 4 - GHG14

110-13 SPN 5435-FMI 7 - GHG14

128-13 SPN 511403-FMI 0,1,2,3,4,5,6,8,9,10,11,12,13,14

103-13 SPN 520328-FMI 7 - GHG14

sb0934 EPA10 Cummins ISX Air Intake Heat Shield Removal

0204-15 Symptom Diagnostics: Noisy One-Box Aftertreatment

0203-15 Oil Filter Stand Pipe

704-15 SPN 4364 (ACM)(EPA10)

706-15 SPN 1323 (MCM) (GHG14) SPN 1324 (MCM) (GHG14) SPN 1325

sb54292 Nexiq USB-Link Upgrade and Diagnostic Connector

805-15 FMI 0: Selective Catalyst Reduction Outlet Temperature High

DD Heavy Duty Platform Belt and Belt Tensioner

SPN 1663 (CPC) (EPA07 10 GHG14 GHG17)

0141-17 SPN 2659 (MCM) (EPA10)

0115-17 SPN 3226 (ACM) (EPA10;GHG14)

0114-17 SPN 2791 (MCM) (EPA07;EPA10)

0113-17 SPN 3361 (ACM) (EPA10)

1207-16 SPN 4363 (ACM) (EPA10 GHG14)

1213-16 SPN 3480 (MCM) (EPA07;EPA10 GHG14)

15TS16Rev1 EPA10 Reman MCM Improvement for Fault Codes SPN 651 to 656

1202-15 Symptom Diagnostics - ATD Checklist

849-12 SPN 3873-FMI 3 and 4

848-12 SPN 3872-FMI 3 and 4

847-12 SPN 3870-FMI 3 and 4

846-12 SPN 3869-FMI 3 and 4

845-12 SPN 3868-FMI 3 and 4

844-12 SPN 3867-FMI 3 and 4

843-12 SPN 3866-FMI 3 and 4

842-12 SPN 3864-FMI 3 and 4 - GHG14

830-12 SPN 520326-FMI 4 - GHG14

818-12 SPN 520296-FMI 19 and 31 - GHG14

815-12 Installation of the Oil Cooler

811-12 SPN 411-FMI 3

810-12 SPN 3842-FMI 3, 4, and 5 (CPC4)

809-12 Removal and Installation of the GHG14 1-BOX From the Vehicle

805-12 SPN 4354-FMI 5, 4356-FMI 5, 4355-FMI 5, 4357-FMI 5

804-12 SPNs 4354-FMI 5, 4355-FMI 5, 4356-FMI 5, 4357-FMI 5

803-12 SPN 4360-FMI 10, 15 (ACM2.1)

802-12 SPN 520328-FMI 7 - GHG14

801-12 SPN 1761-FMI 9 - GHG14

12-022-DLR Daimler Trucks Remarketing Corporation (DTR) Now Requires Pre-approval for Repairs $1,200 (USD) and Greater

15TS3 Detroit? Coolant Change From Nitrite Organic Acid Technology

405-15 Symptom Diagnostics - Hard Start/No Start - Two-Filter System

406-15 SPN 97 (MCM) (EPA10) / SPN 97 (MCM) (GHG14)

403-15 SPN 677 (MCM)(EPA07)

402-15 SPN 2630 (MCM)(EPA10) and SPN 2630 (MCM)(GHG14)

404-15 SPN 4364 (ACM) (EPA10)

15CSA10 The Detroit CSC announcing a new feature ? Ability to attach files to an existing CSC

15CSA9 Release of DiagnosticLink 8.02

505-15 SPN 3361 (ACM) (EPA10)

507-15 SPN 1590( CPC)(GHG14) and SPN 1590 (CPC)(EPA07;EPA10)

508-15 SPN 625 (MCM)( EPA10;GHG14)

sb2083 FluidXchange Tool and Fittings

15-009_Detroit_New_SDTs

15TL5 DAVCO Shop Pro FXP 95

324-15 External Component Repair

304-15 Diagnostic Tests

303-15 Contaminated Fluids

323-15 Symptom Diagnostics ? Noise

306-15 SPN 3246 (ACM)(EPA10;GHG14)

309-15 SPN 3251 (ACM)(EPA10)

307-15 SPN 3480 (MCM) (EPA07;EPA10;GHG14)

301-15 SPN 3251 (ACM) (EPA10) and (ACM) (GHG14), 3936 (ACM)

15CSA4 Holiday Schedule for the Detroit Customer Support Center

713-14 Symptom Diagnostics - Combustion Gas in Coolant

715-14 Symptom Diagnostics - Coolant Los

719-14 SPN 84 (CPC) (GHG14)

710-14 SPN 96 (CPC) (GHG14)

711-14 SPN 107 (CPC) (GHG14

701-14 SPN 168 FMI 0 and 1 (IPPC)(GHG14

706-14 SPN 171 FMI 3, 4 (CPC)(GHG14)

709-14 SPN 3216 (MCM) (GHG14)

703-14 SPN 3556 (ACM) (EPA10)

704-14 SPN 520200 FMI 6 (IPPC)(GHG14)

705-14 SPN 520203 FMI 6 (IPPC)(GHG14)

708-14 SPN 520219 (IPPC) (GHG14)

707-14 SPN 520229 FMI 3 (IPPC) (GHG14

702-14 SPN 520230FMI 5 (IPPC)(GHG14)

14-028 Remy Extended Coverage Direct File

14-027 Detroit's New Consolidated Labor Operations (CLOs

14-023 Detroit Axles Pre-Approval Changes

14-022 Pre-Approval Threshold Increase From $2,500 to $5,000 USD

54-215 - ICU4M Missing VORAD Information or Reporting Fault SA 42 SPN 639 FMI 07

16TL4 DOC Face Cleaning Tool P N W470589239100

16TS5 Release of the DD Platform Bearing Failure Guide

0304-16 SPN 2791 (MCM) ( GHG14) and SPN 2791 (MCM) ( GHG17)

0307-16 SPN 723 (MCM) March

0301-16 SPN 625 (CPC) (EPA07) and SPN 625 (CPC) (EPA10 GHG14)

Contaminated Fluids

Hydrocarbon Doser Coolant Lines

16-009R_OWL Enhancements

New Detroit Bearing Failure Analysis Standard Diagnostic Time

17-026 Holiday Closure 2017

17TL27 Injector Cup Tool DSN930E17001

17TL26 Injector Heat Sleeve Removal Tool DSN930E17002

17CSA25 New Method for Uploading Diagnostic Log Files to the CSC

17CSA24 Holiday Schedule for the Detroit Customer Support Center

17CSA23r Detroit CSC closed December 14, 2017 from 11:15 am - 1:15 pm Eastern Time

PAB053, USA-ONLY GM CHASSIS PRICE INCREASE

FL631-DLR Perpendicular Aluminum Air Tank Mounting Brackets

12-039-DLR OWL Pre-approval's Time Frame Increases to 60 Days

15-028 New Detroit Coolant Line SRTs

Detroit Data Summaries Application and Kits Are No Longer Available Through PDC

_NewDetroitCoolantLineSRTs

13wo3rev2_final Actual Labor Hours on Detroit Claims

0229-14 Symptom Based Diagnostics - Oil Separator

0233-14 SPN 51 FMI 2 - All Years

0224-14 SPN 1590 FMI 9 - CPC- All Years February 2014

0201-14 SPN 1761 FMI 3, 4 (ACM2-EPA10) (ACM2.1-GHG14)

0207-14 SPN 3031 FMI 3, 4 (ACM) (EPA10 - GHG14)

0226-14 SPN 3216 FMI 3, 4 (ACM2)(EPA10)

0216-14 SPN 3363 FMI 1 - ACM - EPA10 - GHG14

0222-14 SPN 4334 FMI 7 (ACM) (EPA10)

0227-14 SPN 4335 FMI 7 - EPA10

0230-14 SPN 4375 FMI 6 - EPA10

807-14 FMI 8 SCR Inlet Temperature Signal Spike

801-14 FMI 19: RCM Message Not Received or Stopped Arriving

14-017R Revised: Detroit Addition of Admin Time

14-029 New Detroit Standard Diagnostic Times

54-268 - Coronado Virtual Technician Retrofit

14-038_New_SRTs Additional Detroit Standard Repair Times.

14-039_additional_SDTs New Detroit Standard Diagnostic Times

14TL8 TorcUP? Non-Impacting Torque Tool.

14TS28 DD Platform Belt Drive System - Belt Part Numbers and diagnostics

1003-14 Rough Running or Stalling.

1009-14 SPN 5016 (ACM) (GHG14)

1007-14 SPN 5016/FMI 3, 4 (ACM) (EPA10)

1006-14 SPN 4374 (ACM) (GHG14)

1008-14 SPN 3510FMI 4,7, and 8 (CPC)(GHG14)

1010-14 SPN 2623 (CPC) (GHG14)

14CSA23 CSC Announces ?Tech Tips? ? DDCSN

14CSA21 Holiday Schedule for the Detroit Customer Support Center ?

14-039 New Detroit Standard Diagnostic Times

14-038 Additional Detroit Standard Repair Times

sb2080 Australian CST M1400 Isolated Radiator Retrofit

1108-14 SPN 636 (MCM) (EPA07;EPA10;GHG14)

18SP711 DD15 and DD16 Axial Power Turbine Bracket Ki

SF501-DLR Perpendicular Steel Air Tank Mounting Brackets

912-14 Coolant in Oil

920-14 Additional Cleaning and Preparing

906-14 Installation of the Oil Pan

917-14 Installation and Removal of the Oil Filter Stand Pipe

1021-16 SPN 110 (MCM)(EPA07EPA07;GHG14), SPN 110 (CPC)(GHG14)

1018-16 SYMPTOM DIAGNOSTICS - NOISE

SB54268 122SD AND CORONADO VIRTUAL TECHNICIAN RETROFIT

0810-16 SYMPTOM DIAGNOSTIC NOISE

0809-16 SYMPTOM DIAGNOSTICS : NOISY 1- BOX AFTERTREATMENT

Warranty Information letter announcing that DTNA is increasing the Standard Diagnostic Times (SDTs) shown.

Special Publication Letter for EPA07 EPA10 Three-Filter Fuel System DD15 DD16 Severe Duty High Pressure Fuel Rail Feed...

Special Publication letter for Two-Filter Fuel System KM59 GEN1 DD15 DD16 Severe Duty High Pressure Fuel Rail Feed Lines...

Service Bulletin for Equiflo Fuel System Breather Tube Inspection

Service Information Bulletin for Symptom Diagnostics - Fluid in the Aftertreatment - Diesel Fuel Contamination.

Fuel System Integrity Check Routine - Two-Filter Fuel System

Fuel Level Sending Unit Retrofit

Fuel System Integrity Check Routine - Two-Filter Fuel System

Fuel Level Sending Unit Retrofit

Fuel System Integrity Check Routine - Two-Filter Fuel System

13TS17 EPA10-GHG14 Diesel Exhaust Fluid (DEF) in Fuel System-Diesel Fuel in DEF System Contamination

Rev DD Platform Fuel Injector Cup Seal

102-15 High Pressure Fuel Pump - Two-Filter System

18SP687 DD15 16 EGR Actuator Replacement

414-13 Removal and Installation of the GHG14 13 and 23 Gallon Diesel Exhaust Fluid Tank Header Unit

413-13 GHG14 13 and 23 Gallon Diesel Exhaust Fluid Tank

407-13 EGR Actuator Slow Learn

708-13 Fuel System Diagram Update

714-13 Fuel Filter Maintenance Intervals

18SP712 EPA07 DD15/16 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel System Conversion Service Kit

18SP713 EPA10 DD13 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel System Conversion Service Kit

18SP714 EPA10 DD15/16 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel System Conversion Service Kit

14TS13Rev EPA10/GHG14 Diesel Exhaust Fluid (DEF) in Fuel System/Diesel Fuel in DEF System Contamination

505-14 Fuel Cooler Leak Test Procedure - Three-Filter Fuel System

504-14 Test-E - Three-Filter Fuel System

513-14 FMI 0: Diesel Particulate Filter Outlet Temperature - Very High

611-13 Removal and Installation of the GHG14 Six-Gallon Diesel Exhaust Fluid Tank Header

sb54296 Fuel Level Sending Unit RetrofitB

sb54148 Radio and Integrated Thin-Film Antenna Troubleshooting, and Field Service UpdatesB

310-13 Draining the Fuel System Using J-48710 Prior to Repairs

13TS-24 DD Platform High Pressure Fuel Lines

18SP700 EPA10,GHG14 Two-Filter Fuel System KM59 GEN1 DD15,16 High Pressure Fuel Feed Lines PN:A4720708032

18SP699 EPA10 GHG14 Two-Filter Fuel System KM59 GEN1 DD13 High Pressure Fuel Feed Lines PN A4710706035

18SP698 EPA07-10 Three-Filter Fuel System DD15,16 High Pressure Fuel Feed Lines PN A4720707932

18SP697 EPA07/10 Three-Filter Fuel System DD13 High Pressure Fuel Feed Lines PN A4710705935

1112-12 Test C -Two-Filter Fuel System

1101-12 Test B -Two-Filter Fuel System

1102-12 Test A - Two-Filter Fuel System

143-13 Low Pressure Fuel System - Measuring Fuel Pressure Using Fuel System Integrity Check, Two-Filter Fuel System

119-13 Exhaust Gas Recirculation System - Cleaning

126-13 Description and Operation of the DD15 and DD16 Exhaust Gas Recirculaton Cooler

124-13 Installation of the DD Platform EGR Actuator Pull Rod

144-13 Removal and Installation of the GHG14 Diesel Exhaust Fluid Lines

15TS8 EPA10 and GHG14 Diesel Particulate Filter (DPF) Compatibility

0202-15 EPA10 and GHG14 Diesel Oxidation Catalyst Face Cleaning

SPN 4765 FMI 0 - Exhaust Temperature Out Of Range High

807-12 Removal and Installation of the GHG14 Diesel Exhaust Fluid Dosing Unit Inlet Screen

15TL6 W470589129100 ? HDEP HP Fuel Rail Test Caps

18SP717 DD13 EGR Actuator Replacement

509-15 Symptom Diagnostics - Hard Start/No Start - Three-Filter Fuel

512-15 GHG14 DD15 AT Exhaust Gas Recirculation Actuator Pull Rod

502-15 Exhaust Gas Recirculation Actuator Lever

18SP716 Installation/Replacement of the Fuel Cooler Delete Bypass Plate for the Two-Filter Fuel System

15-017 Detroit: Updated Fuel Injector SDTs

18SP712 EPA07 DD15/16 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel System Conversion Service Kit

18SP713 EPA10 DD13 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel System Conversion Service Kit

18SP714 EPA10 DD15/16 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel System Conversion Service Kit

14TS19 DD Platform High Pressure Fuel Lines

18SP710Rev 18SP710Rev ? EPA10 GHG14 Two-Filter Fuel

18SP709Rev 18SP709Rev ? EPA10/GHG14 Two-Filter Fuel

18SP701Rev2 18SP701Rev2? GHG14 Two-Filter Fuel System

16TS9 DD Platform High Pressure Fuel Lines

16TS7 Reman Diesel Particulate Filter Serial Number

17TL28 Fuel Injector Removal Tool DSN930E17004

914-12 GHG14 Two-Box Diesel Oxidation Catalyst.pdf

0239-14 High Pressure Fuel Injector Lines - Three-Filter System

0238-14 Removal of the High Pressure Fuel Injector Lines - Two-Filter

0210-14 High Pressure Fuel Rail Feed Lines - Three-Filter System

0209-14 High Pressure Fuel Rail Feed Lines - Two-Filter System

0217-14 Installation of the Fuel Injector Cup

0219-14 Metal in Fuel

0202-14 Symptom Diagnostics - Hard Start No Start - Two-Filter Fuel System

0215-14 Check for Rough Running or Stalling - Three-Filter Fuel System

18SP703 18SP703 - GHG14 KM63 GEN2 Low Pressure Fuel Pump-Two-Filter Fuel System Ki

14TS19Rev DD Platform High Pressure Fuel Lines

1104-14 Metal in the Fuel System

18SP707Rev EPA07/10 Three-Filter Fuel System DD13 High Pressure Fuel Feed Lines, Mounting Bracket and P-clips Service...

18SP708Rev EPA07 10 Three-Filter Fuel

910-14 Installation of the High Pressure Fuel Rail Feed Lines - Two-Filter System

918-14 Removal and Installation and Inspection of the Fuel Cooler Delete Bypass Plate - Two Filter System

916-14 Fuel Cooler Leak Test Procedure - Two-Filter Fuel System

908-14 908-14 EGR Differential Pressure Failed (High Box)

919-14 Exhaust Gas Recirculation Flow Target Error Diagnostic - High Flow

18SP687 18SP687 DD15/16 EGR Actuator Replacement Service Kit

18SP719Rev EPA10 DD13 Three-Filter ESOC Fuel System to Two-Filter KM59 GEN1 Fuel

18SP714Rev EPA10 DD1516 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel

18SP725 TWO-FILTER FUEL SYSTEM KM63 GEN2 DD13 HIGH PRESSURE FUEL FEED LINES, MOUNTING BRACKET AND P-CLIPS SERVICE KIT

18SP722 DD13 KM59 GEN1 BUS TWO-FILTER SYSTEM AMPLIFIER, NEEDLE AND PLV RETURN FUEL LINE CLEARANCE PACKAGE SERVICE KIT

18SP720 EPA10 DD15/16 THREE-FILTER ESOC FUEL SYSTEM TO TWO-FILTER KM59 GEN1 FUEL SYSTEM CONVERSION SERVICE KIT

18SP720 EPA10 DD15/16 THREE-FILTER ESOC FUEL SYSTEM TO TWO-FILTER KM59 GEN1 FUEL SYSTEM CONVERSION SERVICE KIT 2

18SP718 EPA07 DD15/16 THREE-FILTER ESOC FUEL SYSTEM TO TWO-FILTER KM59 GEN1 FUEL SYSTEM CONVERSION SERVICE KIT

1020-16 CHASSIS FUEL SYSTEM ISOLATION TEST

18SP720REV 18SP720 EPA10 DD15/16 THREE-FILTER ESOC FUEL SYSTEM TO TWO-FILTER KM59 GEN1 FUEL SYSTEM CONVERSION SERVICE...

18SP713REV 18SP713 EPA10 DD13 THREE-FILTER FUEL SYSTEM TO TWO-FILTER KM59 GEN1 FUEL SYSTEM CONVERSION SERVICE KIT

FREIGHTLINER: EXCESSIVE WHITE CRYSTAL OR POWDER AROUND DEF FITTING, CAUSED BY EVAPORATION OF DEF WHEN EXPOSED TO AIR...

DEF Tank Coolant Valve O-Ring Kit

Training Solutions for Fuel Leak Found at High Pressure Fuel Pump Weep Hole for Heavy Duty DD Engines.

Updated Recall Safety Bulletin for vehicles in Australia and New Zealand with DD15 engines regarding high pressure fuel lines.

Export Recall Safety Bulletin for vehicles in Australia and New Zealand with DD15 engines regarding high pressure fuel...

Cylinder Liner - Testing of the Cylinder Liner Upper O-Ring

Cylinder Liner - Testing of the Cylinder Liner Upper O-Ring

Cylinder Liner - Testing of the Cylinder Liner Upper O-Ring

New Detroit Diesel Cylinder Liner Upper O-Ring Leak Test Standard Repair Time

Engine Manufacturer Diagnostics

DD13, DD15, DD16 Check Engine Light Flashing or Blinking

531-13 GHG14 DD15 Asymmetrical Turbocharger

520-13 Cylinder Block

GHG14 DD Engine EGR System Fault Codes

GHG14 472906S Turbocharger Compressor Inlet

15TS4 EPA07 DD15 Piston Kits

15TS2 EPA07 and EPA10 DD Platform Engines With Low Oil Pressure Codes

15TS1 GHG14 DD Platform Engines With Codes SPN: 1323 through SPN: 1328, FMI: 31, Idle Smoothness Control/Cylinder...

GHG14 - Intake Manifold Pressure Too Low

GHG14 Intake Manifold Pressure Too Low

0202-17 DD13, DD15, and DD16 Cylinder Head Assembly Removal and Installation

308-15 Symptom Diagnostics - Oil Present at the Turbocharger Compressor

302-15 Crankshaft Oil Seals

18SP706 Replacement of the High Pressure Fuel Pump Camshaft Oil Seal

524-14 FMI 0: Engine Speed High

506-14 506-14 Removal and Installation and Inspection of the Exhaust Gas Recirculation Valve Actuator Pull Rod

sb0175 Replacing Drive Belts on MBE4000 EnginesB

sb0006 Freightliner Courtesy Engineering PolicyB

13TS6 DD Platform Engine Oil Filter.pdf

207-13 Removal and Installation of the Camshaft Housing

18SP693 EPA07-10 Fuel Rail Clamp Service Kit (P-N A4720780335) for DD Platform-Three-Filter Fuel System Engines

305-13 GHG14 DD15 Asymmetrical Turbocharger Flanged Exhaust Manifold

18SP701 GHG14 Two-Filter Fuel System KM63 GEN2 DD15AT Engines High Pressure Fuel Feed Lines PN A4730704432

148-13 GHG14 DD15 Asymmetrical Turbocharger Exhaust Manifold

15TS6 Replacement of the High Pressure Fuel Pump Camshaft Oil Seal

15TS14 GHG14 DD Engine Cylinder Liner Seal Replacement

708-15 High Pressure Fuel Pump Camshaft Oil Seal - Two-Filter System

711-15 High Pressure Fuel Pump Camshaft Oil Seal - Three-Filter System

702-15 DD15 and DD16 Delphi Exhaust Gas Recirculation Valve Actuator

703-15 GHG14 DD15 AT Exhaust Gas Recirculation Valve Actuator

803-15 Removal of the Camshaft Housing

0120-17 Diagnostic Test - Engine Oil Leaks - Oil Developer Method

0118-17 Symptom Diagnostics - Oil Leaks

15TL24 OTC 1750 Revolver Engine Stand

15TS4_Rev2_ EPA07 DD15 Piston Kits

1210-14 Cylinder Head

1201-15 Crankshaft and Bearings

12TS14 Repair Facility Input on GHG14 Engine and Aftertreatment System Issues

15TS10Rev DD Engine Platform Coolant Filter

401-15 Cylinder Block

501-15 Engine Lifter Brackets

504-15 DD13 Exhaust Gas Recirculation Valve Actuator Pull Rod

511-15 DD15 and DD16 Exhaust Gas Recirculation Valve Actuator Pull Rod

503-15 DD13 Exhaust Gas Recirculation Valve Actuator

sb2084 OAT Coolant Replaces NOAT Coolant in Detroit Engines

15TL4 W470589050900 ? 3/8? Drive GEN2 Two-Stage Valve Socket

308-15 Symptom Diagnostics - Oil Present at the Turbocharger Compressor

302-15 Crankshaft Oil Seals

18SP706 Replacement of the High Pressure Fuel Pump Camshaft Oil Seal

sb01101 Pilot Bearing Spacer for Detroit Engines with Eaton transmissions

14TL2 DD Platform Engine Stand Adapter W060589023100

14TS18 GHG14 DD Engine EGR System Fault Code

714-14 Symptom Diagnostics - Low Engine Compression

712-14 Engine Coolant Temperature

20-73 - CANCELED: Cascadia Radiator Update?EPA10 with DDC Engines

20-75 - CANCELED: Cascadia Radiator Update?EPA10 with Cummins ISX Engines

16TS8 DD13 Cylinder Head and Cylinder Head Gasket Change

16-011 New Detroit Camshaft Housing Seal Standard Repair Time

903-12 Installation of the Intake Throttle Valve and Adaptor.pdf

sb4724 Crank No Start, Loss of Engine Prime on Decked Vehicles

12-038-DLR - No Problem Found - Policy Claims - During Basic Vehicle Chassis or Base Engine Coverage

14TS4 Valve and Liner Installation Tool Issue

0228-14 Engine Oil Leaks - Oil Dye Method

0237-14 Engine Brake Solenoid

14TS21 HDEP Camshaft Position Sensor Change

804-14 FMI 16, 18 Intake Manifold Pressure Too high and low (Restricted Mode)

803-14 FMI 16,18: Intake Manifold Pressure Too High and Low

812-14 FMI 3, 4: Engine Aux.

14-040_Additional_CLOs Additional Detroit CLOs for the Heavy Duty Engine Platform

14CSA20 EGR Valve Actuator Kit P/N E23539699

14-040 Additional Detroit CLOs for the Heavy Duty Engine Platform

1102-14 DD13 Cylinder Head R&R

1101-14 DD15 and DD16 Cylinder Head

14TS26 Replacement of the High Pressure Fuel Pump Camshaft Oil Seal

913-14 Checking for Poor Engine Brake Performance

18SP706 Replacement of the High Pressure Fuel Pump Camshaft Oil Seal

18SP701Rev3 GHG14 Two-Filter Fuel System KM63 GEN2 DD15AT Engines High Pressure Fuel Feed Lines, Mounting Bracket and...

16TS24 GHG14 DD Platform Engines With Code SPN: 3216/FMI 18, SCR Inlet NOx Sensor Drift Low

SB0006 FREIGHTLINER COURTESY ENGINEERING POLICY

1017-16 ENGINE MODEL AND SERIAL NUMBER DESIGNATION

16TL20 HEAVY DUTY ENGINE VALVE STEM SEAL INSTALLING DRIFT AND SLEEVE

0909-16 EXCESSIVE OIL CONSUMPTION

FREIGHTLINER: CORONADO RADIATOR MOUNTS, UPDATE -EPA10.

Service Solution SS 1033094 KUS Float Tube Fuel Level Sensor Inform...

Updated Freightliner Service Bulletin for Powernet Troubleshooting Guide - Batteries, Path, Alternator, and Starter.

SS 1034220 SSI Ultrasonic Fuel Level Sensor Information

13TS15 EPA10 Diesel Oxidation Catalyst (DOC) Face Plugging And Code SPN 3251-FMI2 - DOC Inlet Pressure Sensor Not...

13TS15Rev EPA10 Diesel Oxidation Catalyst (DOC) Face Plugging And Code SPN 3251/FMI 2 - DOC Inlet Pressure Sensor Not...

54-277 - Resetting Erroneous Learned Roll Call ECUs on Vehicles with ICU4M

54-278 - Powernet Troubleshooting Guide: Batteries, Path, Alternator, and Starter

54-274 - Plastic Battery Box Cover Retainer Clip

15TS9 Hydrocarbon Doser Block Fuel Compensation Pressure Sensor

326-15 Main Shaft Speed Sensor

305-15 EPA10 Diesel Oxidation Catalyst Inlet Pressure Sensor

503-14 FMI 3, 4: High Side Digital Output 3 Circuit Failed High

516-14 FMI 3, 4: DEF pressure sensor circuit failed hig

18SP684Rev3 EPA07 and EPA10 DD Platform EGR Delta Pressure Sensor Update

sb54202 Rerouting the DDEC IV Relative-Humidity-Sensor Harness

sb2066 Gentech Low Coolant Level Sensor

13TS5 DD Platform Fuel Filter Module

13TS10 DD Platform Oil Coolant Module Plugs

13TS7 GHG14 CPC4 Vehicle Speed Sensor Code SPN 84-FMI 6

13TL2 GHG14 Test Electronic Control Units (ECUs).\

sb54278 Powernet Troubleshooting Guide: Batteries, Path, Alternator

802-15 SPN 520970 FMI 7 (TCM)

801-15 SPN 520999 FMI 7 (TCM)

SPN 521221 (TCM)

SPN 521222 (TCM)

1205-15 Selective Catalyst Reduction (SCR) Inlet Temperature Sensor

15-016-DLR New Essential Tool For CPWA, CPPRA, Ltd CPPRA, & DSDWC Parties: Cadex CA-12 Battery Tester

15TS9 Hydrocarbon Doser Block Fuel Compensation Pressure Sensor

326-15 Main Shaft Speed Sensor

305-15 EPA10 Diesel Oxidation Catalyst Inlet Pressure Sensor

54-285 - Cracked Fuses on Powertrain Power Distribution Modules

16TL5 DD Platform Aftertreatment Soot Sensor Socket DSN0ATZ16001

16_TL-2 DD Platform Aftertreatment NOx Sensor Socket W470589060900

14TS5 Replacing Damaged Aftertreatment Sensor Bosses

0218-14 GHG14 Diesel Exhaust Fluid Pump Module Filter

54-278 - Powernet Troubleshooting Guide: Batteries, Path, Alternator, and Starter

809-14 FMI 3, 4, 5, 31: Diesel Exhaust Fluid System Circuit Failed

802-14 FMI 3, 4: Diesel Exhaust Fluid Pressure Sensor Circuit Failed High and low

14TS30 Aftertreatment Harness Diagnostics

1005-14 Oil Coolant Module

14CSA22 DTNA Chassis Wiring Diagrams

18SP684Rev4 18SP684Rev4 ? EPA07 and EPA10 DD Platform EGR Delta Pressure Sensor Update

18SP705Rev5 18SP705Rev5 ? DD Platform Delta Pressure Sensor

sb54287 Powernet Distribution Box Fuse Retention on the Keep-Alive

sbw5460 Powernet Distribution Box Fuse Retention on the Keep-Alive

905-14 Coolant Level Circuit Failed

903-14 Selective Catalyst Reduction Inlet NOx Sensor Circuit Failed High and Low

904-14 Selective Catalyst Reduction Outlet NOx Sensor Circuit Failed High and Low

911-14 5V Sensor Supply Bank 2 Circuit Failed High

909-14 Diesel Exhaust Fluid Metering Unit Air Pressure Sensor Circuit Failed High and Low

FREIGHTLINER: POWER WINDOWS MAY BE INOPERATIVE OR MAY OPERATE SLOWLY AND THIS MAY CAUSE A FUSE TO BLOW.

Technical Service Letter for SPN 3711 FMI 31 on GHG17 DD15 Trucks.

Service Bulletin for Guidelines for Cleaning and Disinfecting Cab Surfaces.

Open recall and Field service Campaigns report send out to Dealers, General Managers, Service managers and warranty...

Warranty Information Letter sent to customers regarding new refrigerator supplier for returning parts.

Service Bulletin- sb54311 ICU Odometer Programming

Reminder: Paper Service Bulletin Mailings Are Discontinued

Important Campaign Information on FL614 Recall

Service information Bulletin -HDEP PLV Return Line Tool DSN470E17006

Service Information Bulletin for Aftertreamtent Failure Guide

Release of DiagnosticLink 8.08 Service Pack 2

If a GVWR certification label is lost or damaged, Freightliner will supply a duplicate label.

ICI18-014 Owner Notice ? Kidde Fire Extinguisher Recall

13m2- Equipment Owner Field Service Campaign - 13M2

13m2 -Final-23-SEP-2013 Field Service Campaign 13M2

507-14 Inspection of the DD15 and DD16 Axial Power Turbine

ICI18-014 Owner Notice ? Kidde Fire Extinguisher Recall

sb54194 Required Maintenance for Freightliner-Branded and Delco Cassette Players

sb54122 ICU3 Service Cluster AvailableB

12-033-DLR Over the Counter No Hassle Warranty (OTC)

12CSA19 GHG14 Rapid Warranty Parts Return.

15-015 Warranty Exclusions Reminder

14-026-DLR SelecTruck Warranty Enhancements

Canadian Warranty Parts Return Address Change

OWL Enhancement Service Model Field

Warranty Classroom Training in 2018

12-041-DLR Over the Counter No Hassle Warranty (OTC)

_Warranty Recognition Program - Coming Soon

14WO-9_Warranty_Access Detroit New User Warranty Access Request

14TL9 Special Tool Warranty Program.

sb0936 Fastener Inspection, Coronado Air-Cleaner Covers

16TS14 EPA10 AND GHG14 SERVICE REPLACEMENT 1-BOX DOC INLET CHANGE

Revised Freightliner Service Bulletin for Axle Flange Gasket Replaced with O-Ring.

Freightliner Service Bulletin for Axle Flange Gasket Replaced with O-Ring.

Freightliner Service Bulletin for Non-Airliner Rear Suspension Crossmember Fastener Change.

Service Bulletin for Hendrickson HaulMaax Rear Suspension Transverse Torque Rod Tower Bracket Replacement

Service Bulletin to fix vehicles which may have an incorrect transverse torque rod tower bracket installed on the rear drive axles at the factory.

SS 1034171 Airliner Rear Suspension Chassis Lean Troubleshooting

Service Bulletin: AirLiner Suspension Six-Piece Bolted Service Crossmember

With the start of production on February 12, 2018, the fasteners used to assemble Airliner rear suspension crossmembers changed.

33-28 - Bearing Spacer Replacement, ConMet PreSet Steer Hubs

35-30 - Bearing Spacer Replacement, ConMet PreSet Drive Hubs

Detroit? DT12? Split Rod Bushing Repair

sb8846 Upgrading to Hood Tilt-Assist Struts With 10-mm Rod Ends, Coronado

Warranty Recognition Program Suspension

Freightliner Argosy and Coronado Axle Tower Brackets.

Freightliner Argosy and Coronado Axle Tower Brackets Certain vehicles may have an incorrect transverse torque rod...

FREIGHTLINER: ON RECOMMENDATION OF CONMET, REPLACEMENT OF BEARING SPACER, WITH A NEW ONE, IS REQUIRED WHEN A HUB IS REMOVED.

FREIGHTLINER: FOR SOME MODEL TRUCKS, RECOMMENDATION OF PREVENTIVE MAINTENANCE INTERVALS FOR REAR HEAVY DUTY SUSPENSION...

FREIGHTLINER: THE REAR SUSPENSION AIR SPRING HAS BEEN REDESIGNED.

Service Bulletin for Lengthening the Backup Light Harness.

sb2074 Kysor Fan Clutch Rocking Runout Inspection

sb2052 Horton Drivemaster Fan Clutch Hub Bearings

145-13 Description and Operation of Gear Train and Related Parts

15TS15Rev Detroit? DT12? Transmission Proper Towing Procedure

Detroit? DT12? Transmission Proper Moving Procedure

FMI 2- Automatic Gear Selection - Incompatible or missing dataset

15-010-DLR Transmission Cooler Line Photos

811-14 FMI 7: Internal Error with the DT12 Shift Stalk Lever

1105-14 Flywheel, Ring Gear and Flywheel Housing

DAIMLER TRUCK: THICKNESS AND EXCESS MATERIAL FROM DIE PUNCHING MAY PREVENT RETAINING SNAP RINGS FROM FULLY SEATING IN...

Steering Intermediate Shaft Replacement

FL782 Detroit Steer Axle Tie Rods

Adjusting Tilt Lock Force on TRW Steering Columns

Adjusting Tilt Lock Force on TRW Steering Columns

Adjusting Tilt Lock Force on TRW Steering Columns

Adjusting Tilt Lock Force on TRW Steering Columns

Recall FL782- Detroit Steer Axle Tie Rods

Dealer Bulletin- FL782 Detroit Steer Axle Tie Rods

fp46907 Steering Intermediate Shaft ReplacementB

FREIGHTLINER: ADJUSTING THE CORRECT TILT LOCK FORCE ON TRW STEERING COLUMNS.

Tech Talk discussion on Coronado LBCU ICU replaced and failed again.

sb2046 ABA Hose Clamp Torque Values

SF471-DLR Detroit Axles Driver-Controlled Differential Locks

SF471-DLR Detroit Axles Driver-Controlled Differential Locks

Some vehicles may have been incorrectly shimmed at the factory, and may lean slightly to the right or left.

sb3133 Step Clamps Are Not Reusable

14-024-DLR DTNA & JAD Highlights - Q1 & Q2

54-218 - Adding Daytime Running Lights (DRL)Option to Business Class M2 Vehicles

14-036-DLR DTNA & JAD Highlights - Q3

Service Bulletin for Window Regulator Retrofit

Service Bulletin 9817- Paint Supplier Change

The right-hand cab panel on New Cascadia can come into contact with the right-hand chassis-side fairing when making a left turn.

sb9815 Paint Finish Standards

sb98020 Axalta Paint Finish CareB

sb2043 Radiator Fan Shroud Seal

Body SRT Updates -2012.12.12

12-040-DLR Roof Fairing Removal Program

Warranty Information Letter announcing DTNA is adjusting the Standard Repair Times (SRTs) shown.

129-13 DD Platform GHG 14 SPN 3361 FMI 3, 4, 5 UPDATE

1207-15 Updated procedures with adding EPA10 to the GHG14 title

Computer Hook-Up Standard Diagnostic Time Update

sb2072 Coronado Radiator Mounts, Update-EPA10

AEO15M1 GHG14 DD PLATFORM SOFTWARE REPROGRAMMING FOR AUTO ELEVATE

FL782 Interim Recall Ending - Final Recall Beginning

14TL-7Rev DD Platform Flywheel Housing Runout Tool W470589032100

17TL25 TruckCam? Alignment System

ICI12-027-DLR Interim FL631 Ending - Final Recall to Begin

14TL7 DD Platform Flywheel Housing Runout Tool W470589032100

907-14 Installation and Removal of the Flywheel Housing

FL642-DLR ICU4Me Park Brake Warning Message

sb4267 Brake Shimmy - Meritor SteeLite X30 Brake Drum with Excessive Runout

14TL5 ABS Power Line Carrier Converter Available Through PDC

16TL3 Pocket iQ? ABS Product Family Kit is Available at PDC

sb4268 Brake S-Cam Tube Lubrication Interval Change

FREIGHTLINER: ON SOME TRUCKS, WHENEVER BRAKES ARE APPLIED, THE TRUCK WOULD EXPERIENCE SEVERE SHIMMY OR SHAKING.

The modified parked regeneration strategy has been standard on GHG17 units since the start of GHG17 production and was...

18TS4Rev DD Heavy Duty Platform Accessory Drive Belt

15TS5Rev GHG14 DD Platform DEF Pump Leaks and Code 4374 FMI 0 Under Pressurized DEF System

604-13 Performing a Parked Regeneration

New H02 and H03 A/C lines.

506-15 Air Compressor Coolant Lines

49-35 - DEF Return Line Fitting Heater, 6-Gallon Tanks

SS 1032974 High Oil Pressure on 2017 DTNA Vehicles Instrument Cluster Display