2006 Freightliner Coronado TSBs
213 Technical Service Bulletins across 16 categories
Categories
Other
81 bulletinsfp00024 Cable-Tie Reference
Letter to customer on Coverage Extension GHG17 After Treatment
Letter to customer on Coverage Extension GHG17 After Treatment
Technical Publications Ordering
sb54268 122SD and Coronado Virtual Technician Retrofit
Towing Procedures
Operating Hours for the Customer Assistance Center
sb4932 DEF Gauge Reading Incorrectly
sb54215 ICU4M Missing VORAD Information or Reporting Fault SA 42 SPN FMI 07
Replacing or Upgrading Airliner 40K Transverse Torque Rods
sb31034 Towing ProceduresB
sb2083 FluidXchange Tool and FittingsB
sb2068 Conventional Fully-Formulated Coolant with SCA Color Change
sb2059 Replacing Push-to-Connect Air Line Fittings with Brass Compression Fittings
sb2058 Early EPA07 QLD Radiator Replacement
sb2057 New Surge Tank Design
sb2053 New Stainless Steel Lower Radiator Tubes
sb2045 New Surge Tank Cap
sb3131 Huck-Spin 2 Changeover
12-022-DLR Daimler Trucks Remarketing Corporation (DTR) Now Requires Pre-approval for Repairs $1,200 (USD) and Greater
15TS3 Detroit? Coolant Change From Nitrite Organic Acid Technology
15CSA10 The Detroit CSC announcing a new feature ? Ability to attach files to an existing CSC
15CSA9 Release of DiagnosticLink 8.02
15-009_Detroit_New_SDTs
15TL5 DAVCO Shop Pro FXP 95
15CSA4 Holiday Schedule for the Detroit Customer Support Center
713-14 Symptom Diagnostics - Combustion Gas in Coolant
715-14 Symptom Diagnostics - Coolant Los
719-14 SPN 84 (CPC) (GHG14)
710-14 SPN 96 (CPC) (GHG14)
711-14 SPN 107 (CPC) (GHG14
701-14 SPN 168 FMI 0 and 1 (IPPC)(GHG14
706-14 SPN 171 FMI 3, 4 (CPC)(GHG14)
709-14 SPN 3216 (MCM) (GHG14)
703-14 SPN 3556 (ACM) (EPA10)
704-14 SPN 520200 FMI 6 (IPPC)(GHG14)
705-14 SPN 520203 FMI 6 (IPPC)(GHG14)
708-14 SPN 520219 (IPPC) (GHG14)
707-14 SPN 520229 FMI 3 (IPPC) (GHG14
702-14 SPN 520230FMI 5 (IPPC)(GHG14)
14-028 Remy Extended Coverage Direct File
14-027 Detroit's New Consolidated Labor Operations (CLOs
14-023 Detroit Axles Pre-Approval Changes
14-022 Pre-Approval Threshold Increase From $2,500 to $5,000 USD
54-215 - ICU4M Missing VORAD Information or Reporting Fault SA 42 SPN 639 FMI 07
16-009R_OWL Enhancements
New Detroit Bearing Failure Analysis Standard Diagnostic Time
17-026 Holiday Closure 2017
17CSA25 New Method for Uploading Diagnostic Log Files to the CSC
17CSA24 Holiday Schedule for the Detroit Customer Support Center
17CSA23r Detroit CSC closed December 14, 2017 from 11:15 am - 1:15 pm Eastern Time
PAB053, USA-ONLY GM CHASSIS PRICE INCREASE
12-039-DLR OWL Pre-approval's Time Frame Increases to 60 Days
15-028 New Detroit Coolant Line SRTs
Detroit Data Summaries Application and Kits Are No Longer Available Through PDC
_NewDetroitCoolantLineSRTs
13wo3rev2_final Actual Labor Hours on Detroit Claims
0229-14 Symptom Based Diagnostics - Oil Separator
0233-14 SPN 51 FMI 2 - All Years
0224-14 SPN 1590 FMI 9 - CPC- All Years February 2014
807-14 FMI 8 SCR Inlet Temperature Signal Spike
801-14 FMI 19: RCM Message Not Received or Stopped Arriving
14-017R Revised: Detroit Addition of Admin Time
14-029 New Detroit Standard Diagnostic Times
54-268 - Coronado Virtual Technician Retrofit
14-038_New_SRTs Additional Detroit Standard Repair Times.
14-039_additional_SDTs New Detroit Standard Diagnostic Times
14TL8 TorcUP? Non-Impacting Torque Tool.
14TS28 DD Platform Belt Drive System - Belt Part Numbers and diagnostics
1003-14 Rough Running or Stalling.
1009-14 SPN 5016 (ACM) (GHG14)
1007-14 SPN 5016/FMI 3, 4 (ACM) (EPA10)
1006-14 SPN 4374 (ACM) (GHG14)
1008-14 SPN 3510FMI 4,7, and 8 (CPC)(GHG14)
1010-14 SPN 2623 (CPC) (GHG14)
14CSA23 CSC Announces ?Tech Tips? ? DDCSN
14CSA21 Holiday Schedule for the Detroit Customer Support Center ?
14-039 New Detroit Standard Diagnostic Times
14-038 Additional Detroit Standard Repair Times
sb2080 Australian CST M1400 Isolated Radiator Retrofit
ARVINMERITOR REAR DRIVE AXLE LOCK SCREWS.
Read full bulletin
*KB
Engine
28 bulletinsDEF Tank Coolant Valve O-Ring Kit
Revised Technical Service Letter for Series 60 and Series 50 Camshaft Timing Specifications.
Read full bulletin
Camshaft timing, valve lash, injector height, and Jake Brake lash are all very important specifications that must be followed closely in order to optimize the performance and service life of any Detroit Diesel engine.
Technical Service Letter for DDC Series 60 engines concerning Series 60 Cylinder Head Resurfacing/Finish.
Read full bulletin
Detroit Diesel does not recommend third party resurfacing of Series 60 cylinder heads (outside of Detroit and Detroit Reman).
15TS10Rev DD Engine Platform Coolant Filter
15TL4 W470589050900 ? 3/8? Drive GEN2 Two-Stage Valve Socket
sb01101 Pilot Bearing Spacer for Detroit Engines with Eaton transmissions
14TL2 DD Platform Engine Stand Adapter W060589023100
14TS18 GHG14 DD Engine EGR System Fault Code
714-14 Symptom Diagnostics - Low Engine Compression
712-14 Engine Coolant Temperature
20-73 - CANCELED: Cascadia Radiator Update?EPA10 with DDC Engines
20-75 - CANCELED: Cascadia Radiator Update?EPA10 with Cummins ISX Engines
16-011 New Detroit Camshaft Housing Seal Standard Repair Time
sb4724 Crank No Start, Loss of Engine Prime on Decked Vehicles
12-038-DLR - No Problem Found - Policy Claims - During Basic Vehicle Chassis or Base Engine Coverage
14TS4 Valve and Liner Installation Tool Issue
0228-14 Engine Oil Leaks - Oil Dye Method
0237-14 Engine Brake Solenoid
14TS21 HDEP Camshaft Position Sensor Change
804-14 FMI 16, 18 Intake Manifold Pressure Too high and low (Restricted Mode)
803-14 FMI 16,18: Intake Manifold Pressure Too High and Low
812-14 FMI 3, 4: Engine Aux.
Read full bulletin
Shutdown Input Failed High and Low
14-040_Additional_CLOs Additional Detroit CLOs for the Heavy Duty Engine Platform
14CSA20 EGR Valve Actuator Kit P/N E23539699
14-040 Additional Detroit CLOs for the Heavy Duty Engine Platform
SB0006 FREIGHTLINER COURTESY ENGINEERING POLICY
FREIGHTLINER: SOMETIMES THE IDLE INTERMITTENTLY FAILS TO START THE VEHICLE DUE TO A SENSITIVE VEHICLE SPEED SENSOR.
Read full bulletin
*RM
FREIGHTLINER: TRW TAS85 STEERING GEAR INTERNAL LEAKAGE TEST.
Read full bulletin
SOME TRW TAS85 STEERING GEARS HAVE BEEN EQUIPPED WITH AN INTERNAL RELIEF VALVE. THESE STEERING GEARS ARE TYPICALLY INSTALLED WITH POWER STEERING PUMPS THAT HAVE A PRESSURE RELIEF RATING GREATER THAN 2175 PSI (150 BAR). THE INTERNAL RELIEF VALVE LIMITS MAXIMUM SUPPLY PRESSURE TO PROTECT THE STEERING GEAR. MODELS FLD CONVENTIONAL, CENTURY CLASS CONVENTIONAL, COLUMBIA, CORONADO, BUSINESS CLASS M2 AND CASCADIA. NO MODEL YEARS LISTED. *PE
Fuel System
21 bulletinsService Bulletin for Equiflo Fuel System Breather Tube Inspection
Fuel Level Sending Unit Retrofit
Fuel Level Sending Unit Retrofit
sb54296 Fuel Level Sending Unit RetrofitB
sb54148 Radio and Integrated Thin-Film Antenna Troubleshooting, and Field Service UpdatesB
15TL6 W470589129100 ? HDEP HP Fuel Rail Test Caps
15-017 Detroit: Updated Fuel Injector SDTs
14TS19 DD Platform High Pressure Fuel Lines
18SP710Rev 18SP710Rev ? EPA10 GHG14 Two-Filter Fuel
18SP709Rev 18SP709Rev ? EPA10/GHG14 Two-Filter Fuel
18SP701Rev2 18SP701Rev2? GHG14 Two-Filter Fuel System
16TS7 Reman Diesel Particulate Filter Serial Number
0239-14 High Pressure Fuel Injector Lines - Three-Filter System
0238-14 Removal of the High Pressure Fuel Injector Lines - Two-Filter
0210-14 High Pressure Fuel Rail Feed Lines - Three-Filter System
0209-14 High Pressure Fuel Rail Feed Lines - Two-Filter System
0219-14 Metal in Fuel
0202-14 Symptom Diagnostics - Hard Start No Start - Two-Filter Fuel System
0215-14 Check for Rough Running or Stalling - Three-Filter Fuel System
18SP703 18SP703 - GHG14 KM63 GEN2 Low Pressure Fuel Pump-Two-Filter Fuel System Ki
FREIGHTLINER: EXCESSIVE WHITE CRYSTAL OR POWDER AROUND DEF FITTING, CAUSED BY EVAPORATION OF DEF WHEN EXPOSED TO AIR...
Read full bulletin
AND/OR DAMPNESS, INDICATES A LEAK IN DIESEL EXHAUST FLUID OR IMPROPER INSTALLATION OR DAMAGED CONNECTORS WOULD HAVE LEAKS IN COOLANT LINES. *PE
Electrical
18 bulletinsService Solution SS 1033094 KUS Float Tube Fuel Level Sensor Inform...
Updated Freightliner Service Bulletin for Powernet Troubleshooting Guide - Batteries, Path, Alternator, and Starter.
Read full bulletin
This bulletin replaces the version dated 5/31/2017. Information is added about the BCT-460DTNA PowerNet Assessment Tool. When troubleshooting Powernet issues, use the BCT-460DTNA PowerNet Assessment Tool. As of May 29, 2018, the AutoMeter is the only Daimler-approved tool for troubleshooting vehicle Powernet issues.
SS 1034220 SSI Ultrasonic Fuel Level Sensor Information
54-277 - Resetting Erroneous Learned Roll Call ECUs on Vehicles with ICU4M
54-278 - Powernet Troubleshooting Guide: Batteries, Path, Alternator, and Starter
54-274 - Plastic Battery Box Cover Retainer Clip
sb54202 Rerouting the DDEC IV Relative-Humidity-Sensor Harness
sb2070 EPA07 and Newer Gentech Coolant-Level Sensor Testing
15-016-DLR New Essential Tool For CPWA, CPPRA, Ltd CPPRA, & DSDWC Parties: Cadex CA-12 Battery Tester
54-285 - Cracked Fuses on Powertrain Power Distribution Modules
14TS5 Replacing Damaged Aftertreatment Sensor Bosses
809-14 FMI 3, 4, 5, 31: Diesel Exhaust Fluid System Circuit Failed
802-14 FMI 3, 4: Diesel Exhaust Fluid Pressure Sensor Circuit Failed High and low
14TS30 Aftertreatment Harness Diagnostics
1005-14 Oil Coolant Module
14CSA22 DTNA Chassis Wiring Diagrams
18SP684Rev4 18SP684Rev4 ? EPA07 and EPA10 DD Platform EGR Delta Pressure Sensor Update
18SP705Rev5 18SP705Rev5 ? DD Platform Delta Pressure Sensor
Pre-Delivery & Maintenance
17 bulletinsWarranty Information Letter sent to customers regarding new refrigerator supplier for returning parts.
Service Bulletin- sb54311 ICU Odometer Programming
Reminder: Paper Service Bulletin Mailings Are Discontinued
Important Campaign Information on FL614 Recall
sb54194 Required Maintenance for Freightliner-Branded and Delco Cassette Players
sb54122 ICU3 Service Cluster AvailableB
sb2063 Coolant Filter Inspection Procedure, DD13 DD15 DD16 Only
15-015 Warranty Exclusions Reminder
14-026-DLR SelecTruck Warranty Enhancements
Canadian Warranty Parts Return Address Change
OWL Enhancement Service Model Field
Warranty Classroom Training in 2018
12-041-DLR Over the Counter No Hassle Warranty (OTC)
_Warranty Recognition Program - Coming Soon
14WO-9_Warranty_Access Detroit New User Warranty Access Request
14TL9 Special Tool Warranty Program.
DAIMLER TRUCKS: THE 294 BOLT IS DEEMED SERVICEABLE AND THERE IS A PROCEDURE FOR REPLACING IT.
Read full bulletin
*RM
Suspension
9 bulletinsRevised Freightliner Service Bulletin for Axle Flange Gasket Replaced with O-Ring.
Read full bulletin
Revision removed steps instructing removal and installation of wheels. Daimler Trucks North America has released a new axle shaft to hub rubber O-ring (part number 11-30728-000) as a replacement for the paper gasket (part number 11-14418-000). The new O-ring will provide better sealing and is reusable. It is quicker and easier to use compared to the paper gasket, because using a paper gasket requires cleaning the hub when the axle shaft is removed.
Freightliner Service Bulletin for Axle Flange Gasket Replaced with O-Ring.
Read full bulletin
Daimler Trucks North America has released a new axle shaft to hub rubber O-ring (part number 11-30728-000) as a replacement for the paper gasket (part number 11-14418-000). The new O-ring will provide better sealing and is reusable. It is quicker and easier to use compared to the paper gasket, because using a paper gasket requires cleaning the hub when the axle shaft is removed.
Service Bulletin for Hendrickson HaulMaax Rear Suspension Transverse Torque Rod Tower Bracket Replacement
Service Bulletin: AirLiner Suspension Six-Piece Bolted Service Crossmember
With the start of production on February 12, 2018, the fasteners used to assemble Airliner rear suspension crossmembers changed.
Read full bulletin
The forward-suspension crossmember will assembled with 5/8-18 fasteners and the rear-suspension (bogie) crossmember will be assembled with 3/4-16 fasteners.
33-28 - Bearing Spacer Replacement, ConMet PreSet Steer Hubs
35-30 - Bearing Spacer Replacement, ConMet PreSet Drive Hubs
Warranty Recognition Program Suspension
FREIGHTLINER: INFORMATION ON LUBRICATING THE WHEEL BEARINGS OF THE REAR DRIVE AXLES.
Read full bulletin
*RM
Body & Paint
9 bulletinsService Bulletin 9817- Paint Supplier Change
The right-hand cab panel on New Cascadia can come into contact with the right-hand chassis-side fairing when making a left turn.
Read full bulletin
This contact can result in an audible popping noise, paint-damage to the rocker panel and damage to the back-side of the chassis-side fairing.
sb9815 Paint Finish Standards
sb98020 Axalta Paint Finish CareB
sb2043 Radiator Fan Shroud Seal
Body SRT Updates -2012.12.12
12-040-DLR Roof Fairing Removal Program
FREIGHTLINER: PROCEDURE OF REMOVING A LOWER PINION COVER IN THE REAR AXLES AND HOW TO RESEAL IT.
Read full bulletin
*RM
FREIGHTLINER: SOME VEHICLES MAY HAVE BEEN BUILT WITH CLAMPS USED TO CONNECT THE CLEAN GAS INDUCTION (CGI) PLUMBING THAT...
Read full bulletin
MAY NOT PROVIDE AN ADEQUATE SEAL, ALLOWING UNFILTER AIR INTO THE SYSTEM. THE CLAMPS WILL BE REPLACED. *PE
Steering
6 bulletinsSteering Intermediate Shaft Replacement
Adjusting Tilt Lock Force on TRW Steering Columns
Adjusting Tilt Lock Force on TRW Steering Columns
Adjusting Tilt Lock Force on TRW Steering Columns
Adjusting Tilt Lock Force on TRW Steering Columns
fp46907 Steering Intermediate Shaft ReplacementB
Transmission
6 bulletinssb2074 Kysor Fan Clutch Rocking Runout Inspection
sb2069 Kysor Fan Clutch Sticking
sb2056 Transmission Oil Line Removal and Installation
sb2052 Horton Drivemaster Fan Clutch Hub Bearings
15-010-DLR Transmission Cooler Line Photos
811-14 FMI 7: Internal Error with the DT12 Shift Stalk Lever
Brakes
5 bulletinssb4267 Brake Shimmy?Meritor SteeLite X30? Brake Drum with Excessive RunoutB
sb4267 Brake Shimmy - Meritor SteeLite X30 Brake Drum with Excessive Runout
14TL5 ABS Power Line Carrier Converter Available Through PDC
sb4268 Brake S-Cam Tube Lubrication Interval Change
FREIGHTLINER: BRAKE S-CAM TUBE LUBRICATION INTERVAL CHANGE.
Read full bulletin
TO ENSURE OPTIMUM SERVICE LIFE AND TROUBLE-FREE OPERATION, THE RECOMMENDED MAINTENANCE INTERVAL FOR LUBRICATING MERITOR S-CAM BRAKE TUBES ON CENTURY CLASS, COLUMBIA, CASCADIA AND CORONADO OVER-THE-ROAD VEHICLES IS CHANGED FROM M2 TO THE M1 MAINTENANCE INTERVAL. *JS
Lighting
5 bulletinssb2046 ABA Hose Clamp Torque Values
Some vehicles may have been incorrectly shimmed at the factory, and may lean slightly to the right or left.
Read full bulletin
While this does not affect the operation of the vehicle, it may be visually unpleasing to many customers.
sb3133 Step Clamps Are Not Reusable
14-024-DLR DTNA & JAD Highlights - Q1 & Q2
14-036-DLR DTNA & JAD Highlights - Q3
Tires & Wheels
3 bulletins14TL-7Rev DD Platform Flywheel Housing Runout Tool W470589032100
17TL25 TruckCam? Alignment System
14TL7 DD Platform Flywheel Housing Runout Tool W470589032100
Software & Calibration
2 bulletinsComputer Hook-Up Standard Diagnostic Time Update
DAIMLER TRUCKS: THERE ARE NEW CGI BELLOWS, BECAUSE THE OLD ONES ARE PRONE TO FATIGUE AND MAY FAIL.
Read full bulletin
*RM UPDATED 4/24/12. *PE
Infotainment
1 bulletinSS 1032974 High Oil Pressure on 2017 DTNA Vehicles Instrument Cluster Display
HVAC & Climate
1 bulletinNew H02 and H03 A/C lines.
Hybrid & EV
1 bulletin18TS4Rev DD Heavy Duty Platform Accessory Drive Belt