2011 Freightliner Century Class TSBs

fp00024 Cable-Tie Reference

Technical Publications Ordering

Towing Procedures

Operating Hours for the Customer Assistance Center

fp00020 Replacing Gross Vehicle Weight Rating (GVWR) Certification Labels

Issues with PTO and Remote Throttle Combinations

0105-15 SPN 102 (MCM) (GHG14)

0108-15 SPN 1323 through 1328 (MCM) (GHG14)

0106-15 SPN 3251 (ACM) (EPA10) and (GHG14)

0104-15 SPN 3464/ FMI 16, 18 (MCM) (GHG14)

0101-15 SPN 4364 (ACM) (EPA10)

0107-15 Enhanced Steam Clean

sb54215 ICU4M Missing VORAD Information or Reporting Fault SA 42 SPN FMI 07

ssb3312 Tapacubos flojos en ejes Rockwell FF?981

sb54109 RAMI Antenna

sb54105 Fresh Air Warning Buzzer Disable

sb31034 Towing ProceduresB

sb2080 Australian CST M1400 Isolated Radiator RetrofitB

sb2068 Conventional Fully-Formulated Coolant with SCA Color Change

sb2053 New Stainless Steel Lower Radiator Tubes

sb1512 Accessories On When Key is OffB

sb00042 Flood Damage Repair GuidelinesB

13WO-2-New Standard Rpr Times orgl 11WO2 New Standard Repair Times for EPA07-10 DD13-15 Diagnostic Tests

311-13 SPN 651-FMI 3 - EPA10 - GHG14

303-13 SPN 3242-FMI 4 -EPA10 - GHG14

301-13 SPN 5018- FMI 18 -GHG14

808-13 FMI 0 Under Pressurized DEF System

802-13 FMI 18 Coolant Level Low

803-13 FMI 10,18: Intake Throttle Position Abnormal Rate of Change, Position Data Valid but Below Normal Operating Range...

803-13 FMI 2: Intake Throttle Position Deviation Error

1118-12 SPN 705-FMI 5 - GHG14

1113-12 SPN 3226/FMI 20 - GHG14

sb3131 Huck-Spin 2 Changeover

102-13 SPN 84-FMI 13, 19, 21 (MCM) EPA10-GHG14

107-13 SPN 84-FMI 7 - GHG14

106-13 SPN 100-FMI 10 - GHG14

105-13 SPN 625-FMI 13 - GHG14

135-13 SPN 1243-FMI 14 - GHG14

104-13 SPN 1592-FMI 13 and 19 - GHG14

137-13 SPN 2798-FMI 4 - EPA10 - GHG14

109-13 SPN 3250-FMI 31 (ACM2.1) GHG14

139-13 SPN 3251-FMI 0, 16, 20, 21 GHG14

108-13 SPN 3364-FMI 18 - GHG14

101-13 SPN 3563 FMI 21 - GHG14

132-13 SPN 3597-FMI 4 - EPA10

146-13 SPN 4335-FMI 1 EPA10

133-13 SPN 4375-FMI 4 and 5 - GHG14

112-13 SPN 4364-FMI 18 - GHG14

111-13 SPN 4374/FMI 0, 1, 3, 4 - GHG14

110-13 SPN 5435-FMI 7 - GHG14

128-13 SPN 511403-FMI 0,1,2,3,4,5,6,8,9,10,11,12,13,14

103-13 SPN 520328-FMI 7 - GHG14

sb54292 Nexiq USB-Link Upgrade and Diagnostic Connector

ICU2M to ICU4M Conversion

15TS16Rev1 EPA10 Reman MCM Improvement for Fault Codes SPN 651 to 656

12-022-DLR Daimler Trucks Remarketing Corporation (DTR) Now Requires Pre-approval for Repairs $1,200 (USD) and Greater

15TS3 Detroit? Coolant Change From Nitrite Organic Acid Technology

405-15 Symptom Diagnostics - Hard Start/No Start - Two-Filter System

406-15 SPN 97 (MCM) (EPA10) / SPN 97 (MCM) (GHG14)

403-15 SPN 677 (MCM)(EPA07)

402-15 SPN 2630 (MCM)(EPA10) and SPN 2630 (MCM)(GHG14)

404-15 SPN 4364 (ACM) (EPA10)

15CSA10 The Detroit CSC announcing a new feature ? Ability to attach files to an existing CSC

15CSA9 Release of DiagnosticLink 8.02

505-15 SPN 3361 (ACM) (EPA10)

507-15 SPN 1590( CPC)(GHG14) and SPN 1590 (CPC)(EPA07;EPA10)

508-15 SPN 625 (MCM)( EPA10;GHG14)

15-009_Detroit_New_SDTs

15TL5 DAVCO Shop Pro FXP 95

306-15 SPN 3246 (ACM)(EPA10;GHG14)

309-15 SPN 3251 (ACM)(EPA10)

307-15 SPN 3480 (MCM) (EPA07;EPA10;GHG14)

301-15 SPN 3251 (ACM) (EPA10) and (ACM) (GHG14), 3936 (ACM)

15CSA4 Holiday Schedule for the Detroit Customer Support Center

713-14 Symptom Diagnostics - Combustion Gas in Coolant

715-14 Symptom Diagnostics - Coolant Los

703-14 SPN 3556 (ACM) (EPA10)

14-028 Remy Extended Coverage Direct File

14-027 Detroit's New Consolidated Labor Operations (CLOs

14-023 Detroit Axles Pre-Approval Changes

14-022 Pre-Approval Threshold Increase From $2,500 to $5,000 USD

54-215 - ICU4M Missing VORAD Information or Reporting Fault SA 42 SPN 639 FMI 07

16TL4 DOC Face Cleaning Tool P N W470589239100

16TS5 Release of the DD Platform Bearing Failure Guide

0307-16 SPN 723 (MCM) March

0301-16 SPN 625 (CPC) (EPA07) and SPN 625 (CPC) (EPA10 GHG14)

Contaminated Fluids

Hydrocarbon Doser Coolant Lines

16-009R_OWL Enhancements

New Detroit Bearing Failure Analysis Standard Diagnostic Time

17-026 Holiday Closure 2017

17CSA25 New Method for Uploading Diagnostic Log Files to the CSC

17CSA24 Holiday Schedule for the Detroit Customer Support Center

17CSA23r Detroit CSC closed December 14, 2017 from 11:15 am - 1:15 pm Eastern Time

12-039-DLR OWL Pre-approval's Time Frame Increases to 60 Days

15-028 New Detroit Coolant Line SRTs

Detroit Data Summaries Application and Kits Are No Longer Available Through PDC

_NewDetroitCoolantLineSRTs

13wo3rev2_final Actual Labor Hours on Detroit Claims

0229-14 Symptom Based Diagnostics - Oil Separator

0233-14 SPN 51 FMI 2 - All Years

0224-14 SPN 1590 FMI 9 - CPC- All Years February 2014

14-017R Revised: Detroit Addition of Admin Time

14-029 New Detroit Standard Diagnostic Times

14-038_New_SRTs Additional Detroit Standard Repair Times.

14-039_additional_SDTs New Detroit Standard Diagnostic Times

14TL8 TorcUP? Non-Impacting Torque Tool.

14TS28 DD Platform Belt Drive System - Belt Part Numbers and diagnostics

1003-14 Rough Running or Stalling.

1009-14 SPN 5016 (ACM) (GHG14)

1007-14 SPN 5016/FMI 3, 4 (ACM) (EPA10)

1006-14 SPN 4374 (ACM) (GHG14)

1008-14 SPN 3510FMI 4,7, and 8 (CPC)(GHG14)

1010-14 SPN 2623 (CPC) (GHG14)

14CSA23 CSC Announces ?Tech Tips? ? DDCSN

14CSA21 Holiday Schedule for the Detroit Customer Support Center ?

14-039 New Detroit Standard Diagnostic Times

14-038 Additional Detroit Standard Repair Times

sb2080 Australian CST M1400 Isolated Radiator Retrofit

Technical Service Letter for DDC Series 60 engines concerning Series 60 Cylinder Head Resurfacing/Finish.

GHG14 DD Engine EGR System Fault Codes

GHG14 472906S Turbocharger Compressor Inlet

15TS4 EPA07 DD15 Piston Kits

15TS2 EPA07 and EPA10 DD Platform Engines With Low Oil Pressure Codes

15TS1 GHG14 DD Platform Engines With Codes SPN: 1323 through SPN: 1328, FMI: 31, Idle Smoothness Control/Cylinder...

sb0935 Replacing the Engine Air Filter Element, Donaldson Air Cleaner (03-33648-001-002)

sb5471 Vehicle Speed Sensor Optimized Idle FeatureB

sb0175 Replacing Drive Belts on MBE4000 EnginesB

sb0164 MBE Engine Support Information

207-13 Removal and Installation of the Camshaft Housing

18SP693 EPA07-10 Fuel Rail Clamp Service Kit (P-N A4720780335) for DD Platform-Three-Filter Fuel System Engines

18SP701 GHG14 Two-Filter Fuel System KM63 GEN2 DD15AT Engines High Pressure Fuel Feed Lines PN A4730704432

148-13 GHG14 DD15 Asymmetrical Turbocharger Exhaust Manifold

15TS6 Replacement of the High Pressure Fuel Pump Camshaft Oil Seal

15TL24 OTC 1750 Revolver Engine Stand

15TS4_Rev2_ EPA07 DD15 Piston Kits

1210-14 Cylinder Head

1201-15 Crankshaft and Bearings

15TS10Rev DD Engine Platform Coolant Filter

401-15 Cylinder Block

501-15 Engine Lifter Brackets

504-15 DD13 Exhaust Gas Recirculation Valve Actuator Pull Rod

511-15 DD15 and DD16 Exhaust Gas Recirculation Valve Actuator Pull Rod

503-15 DD13 Exhaust Gas Recirculation Valve Actuator

sb2084 OAT Coolant Replaces NOAT Coolant in Detroit Engines

15TL4 W470589050900 ? 3/8? Drive GEN2 Two-Stage Valve Socket

18SP706 Replacement of the High Pressure Fuel Pump Camshaft Oil Seal

sb01101 Pilot Bearing Spacer for Detroit Engines with Eaton transmissions

14TL2 DD Platform Engine Stand Adapter W060589023100

714-14 Symptom Diagnostics - Low Engine Compression

712-14 Engine Coolant Temperature

20-73 - CANCELED: Cascadia Radiator Update?EPA10 with DDC Engines

20-75 - CANCELED: Cascadia Radiator Update?EPA10 with Cummins ISX Engines

16TS8 DD13 Cylinder Head and Cylinder Head Gasket Change

16-011 New Detroit Camshaft Housing Seal Standard Repair Time

sb4724 Crank No Start, Loss of Engine Prime on Decked Vehicles

12-038-DLR - No Problem Found - Policy Claims - During Basic Vehicle Chassis or Base Engine Coverage

14TS4 Valve and Liner Installation Tool Issue

0228-14 Engine Oil Leaks - Oil Dye Method

0237-14 Engine Brake Solenoid

14-040_Additional_CLOs Additional Detroit CLOs for the Heavy Duty Engine Platform

14CSA20 EGR Valve Actuator Kit P/N E23539699

14-040 Additional Detroit CLOs for the Heavy Duty Engine Platform

35-23 - Breather Oil Leak on Freightliner Tandem Rear Axles

FREIGHTLINER: INFORMATION REGARDING THE REPLACEMENT LINE WITH A NEW ASSEMBLY CONNECTING THE MANIFOLD WITH A HOSE AND...

Fuel Level Sending Unit Retrofit

Rev DD Platform Fuel Injector Cup Seal

102-15 High Pressure Fuel Pump - Two-Filter System

18SP687 DD15 16 EGR Actuator Replacement

sb54296 Fuel Level Sending Unit RetrofitB

sb54148 Radio and Integrated Thin-Film Antenna Troubleshooting, and Field Service UpdatesB

fp47019 25-Inch Diameter Fuel Tanks

310-13 Draining the Fuel System Using J-48710 Prior to Repairs

13TS-24 DD Platform High Pressure Fuel Lines

18SP700 EPA10,GHG14 Two-Filter Fuel System KM59 GEN1 DD15,16 High Pressure Fuel Feed Lines PN:A4720708032

18SP699 EPA10 GHG14 Two-Filter Fuel System KM59 GEN1 DD13 High Pressure Fuel Feed Lines PN A4710706035

18SP698 EPA07-10 Three-Filter Fuel System DD15,16 High Pressure Fuel Feed Lines PN A4720707932

18SP697 EPA07/10 Three-Filter Fuel System DD13 High Pressure Fuel Feed Lines PN A4710705935

1112-12 Test C -Two-Filter Fuel System

1101-12 Test B -Two-Filter Fuel System

1102-12 Test A - Two-Filter Fuel System

143-13 Low Pressure Fuel System - Measuring Fuel Pressure Using Fuel System Integrity Check, Two-Filter Fuel System

119-13 Exhaust Gas Recirculation System - Cleaning

126-13 Description and Operation of the DD15 and DD16 Exhaust Gas Recirculaton Cooler

124-13 Installation of the DD Platform EGR Actuator Pull Rod

144-13 Removal and Installation of the GHG14 Diesel Exhaust Fluid Lines

0202-15 EPA10 and GHG14 Diesel Oxidation Catalyst Face Cleaning

18SP730 ? EPA07 10 Three-Filter Fuel System DD13 High Pressure Fuel Feed Lines, Mounting Bracket and P-clips Service...

18SP729 ? EPA07 10 Three-Filter Fuel

15TL6 W470589129100 ? HDEP HP Fuel Rail Test Caps

18SP717 DD13 EGR Actuator Replacement

509-15 Symptom Diagnostics - Hard Start/No Start - Three-Filter Fuel

512-15 GHG14 DD15 AT Exhaust Gas Recirculation Actuator Pull Rod

502-15 Exhaust Gas Recirculation Actuator Lever

15-017 Detroit: Updated Fuel Injector SDTs

18SP712 EPA07 DD15/16 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel System Conversion Service Kit

18SP713 EPA10 DD13 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel System Conversion Service Kit

18SP714 EPA10 DD15/16 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel System Conversion Service Kit

14TS19 DD Platform High Pressure Fuel Lines

18SP710Rev 18SP710Rev ? EPA10 GHG14 Two-Filter Fuel

16TS9 DD Platform High Pressure Fuel Lines

16TS7 Reman Diesel Particulate Filter Serial Number

0239-14 High Pressure Fuel Injector Lines - Three-Filter System

0238-14 Removal of the High Pressure Fuel Injector Lines - Two-Filter

0210-14 High Pressure Fuel Rail Feed Lines - Three-Filter System

0209-14 High Pressure Fuel Rail Feed Lines - Two-Filter System

0219-14 Metal in Fuel

0202-14 Symptom Diagnostics - Hard Start No Start - Two-Filter Fuel System

0215-14 Check for Rough Running or Stalling - Three-Filter Fuel System

SS 1033638 - Power Window Express Down Module Discontinued

13TS15Rev EPA10 Diesel Oxidation Catalyst (DOC) Face Plugging And Code SPN 3251/FMI 2 - DOC Inlet Pressure Sensor Not...

54-277 - Resetting Erroneous Learned Roll Call ECUs on Vehicles with ICU4M

54-278 - Powernet Troubleshooting Guide: Batteries, Path, Alternator, and Starter

54-274 - Plastic Battery Box Cover Retainer Clip

sb54290 Guidelines for Repairing or Replacing an Electrical Harness

sb54202 Rerouting the DDEC IV Relative-Humidity-Sensor Harness

13TS5 DD Platform Fuel Filter Module

13TS10 DD Platform Oil Coolant Module Plugs

13TL2 GHG14 Test Electronic Control Units (ECUs).\

sb54278 Powernet Troubleshooting Guide: Batteries, Path, Alternator

15-016-DLR New Essential Tool For CPWA, CPPRA, Ltd CPPRA, & DSDWC Parties: Cadex CA-12 Battery Tester

15TS9 Hydrocarbon Doser Block Fuel Compensation Pressure Sensor

305-15 EPA10 Diesel Oxidation Catalyst Inlet Pressure Sensor

sb54290 Guidelines for Repairing or Replacing an Electrical Harness

54-285 - Cracked Fuses on Powertrain Power Distribution Modules

16TL5 DD Platform Aftertreatment Soot Sensor Socket DSN0ATZ16001

16_TL-2 DD Platform Aftertreatment NOx Sensor Socket W470589060900

14TS5 Replacing Damaged Aftertreatment Sensor Bosses

1005-14 Oil Coolant Module

14CSA22 DTNA Chassis Wiring Diagrams

18SP684Rev4 18SP684Rev4 ? EPA07 and EPA10 DD Platform EGR Delta Pressure Sensor Update

18SP705Rev5 18SP705Rev5 ? DD Platform Delta Pressure Sensor

sb54287 Powernet Distribution Box Fuse Retention on the Keep-Alive

sbw5460 Powernet Distribution Box Fuse Retention on the Keep-Alive

FREIGHTLINER: DUE TO ROLL CALL ECUS NOT PRESENT ON TRUCKS, ROLL CALL FAULTS MAY SHOWN IN ICU4M MESSAGE CENTER AND...

FREIGHTLINER: THE PLASTIC BATTERY BOX COVER CAN BECOME LOOSE OR LOST DUE TO AN INADEQUATE RETENTION CLIP.

DAIMLER TRUCKS: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER.

Service Bulletin for Guidelines for Cleaning and Disinfecting Cab Surfaces.

Warranty Information Letter sent to customers regarding new refrigerator supplier for returning parts.

Service Bulletin 9812- Cab Surface Repair

Service Bulletin 9816- DuPont? Imron Elite

If a GVWR certification label is lost or damaged, Freightliner will supply a duplicate label.

ICI18-014 Owner Notice ? Kidde Fire Extinguisher Recall

13m2- Equipment Owner Field Service Campaign - 13M2

13m2 -Final-23-SEP-2013 Field Service Campaign 13M2

ICI18-014 Owner Notice ? Kidde Fire Extinguisher Recall

sb54194 Required Maintenance for Freightliner-Branded and Delco Cassette Players

sb54122 ICU3 Service Cluster AvailableB

sb2063 Coolant Filter Inspection Procedure, DD13 DD15 DD16 Only

15-015 Warranty Exclusions Reminder

14-026-DLR SelecTruck Warranty Enhancements

Canadian Warranty Parts Return Address Change

OWL Enhancement Service Model Field

Warranty Classroom Training in 2018

12-041-DLR Over the Counter No Hassle Warranty (OTC)

_Warranty Recognition Program - Coming Soon

14WO-9_Warranty_Access Detroit New User Warranty Access Request

14TL9 Special Tool Warranty Program.

Service Bulletin revision that adds Century Class and Columbia models to the affected list for a Door Window and...

Warranty Information Letter - Expanded guidelines for paint-related claims sent out to Freightliner, Western star,...

Service Bulletin 9810- Chassis Paint Usage

Service Bulletin 9817- Paint Supplier Change

Service Bulletin 9818- Repainting Plastic Bumper Components

sb9815 Paint Finish Standards

sb98020 Axalta Paint Finish CareB

sb6083 Roof Seam Seal Repair

12-040-DLR Roof Fairing Removal Program

FREIGHTLINER: AT THE DOOR CHECK MOUNTING AREA, CRACKS MAY DEVELOP ON DOOR FRAME ON DRIVER SIDE, DUE TO USAGE AND AGE OF TRUCK.

sb4267 Brake Shimmy?Meritor SteeLite X30? Brake Drum with Excessive RunoutB

sb4267 Brake Shimmy - Meritor SteeLite X30 Brake Drum with Excessive Runout

14TL5 ABS Power Line Carrier Converter Available Through PDC

16TL3 Pocket iQ? ABS Product Family Kit is Available at PDC

sb4268 Brake S-Cam Tube Lubrication Interval Change

FREIGHTLINER: BRAKE S-CAM TUBE LUBRICATION INTERVAL CHANGE.

FREIGHTLINER: DUE TO POSSIBLE THERMAL OVERLOAD ON BENDIX AIR DISC BRAKES: THE ABS SENSOR WIRES MELTED; BRAKE ACTUATOR...

FREIGHTLINER: ON SOME TRUCKS, WHENEVER BRAKES ARE APPLIED, THE TRUCK WOULD EXPERIENCE SEVERE SHIMMY OR SHAKING.

Revised Freightliner Service Bulletin for Axle Flange Gasket Replaced with O-Ring.

Freightliner Service Bulletin for Axle Flange Gasket Replaced with O-Ring.

SS 1034171 Airliner Rear Suspension Chassis Lean Troubleshooting

Warranty Recognition Program Suspension

FREIGHTLINER: ON RECOMMENDATION OF CONMET, THE BEARING SPACER SHOULD BE REPLACED, WITH A NEW ONE, WHEN HUB IS REMOVED.

FREIGHTLINER: FOR SOME MODEL TRUCKS, RECOMMENDATION OF PREVENTIVE MAINTENANCE INTERVALS FOR REAR HEAVY DUTY SUSPENSION...

Service Bulletin for Lengthening the Backup Light Harness.

sb2069 Kysor Fan Clutch Sticking

sb2052 Horton Drivemaster Fan Clutch Hub Bearings

145-13 Description and Operation of Gear Train and Related Parts

sb4654 Rack and Pinion Steering Gear Retrofit Guide

15-010-DLR Transmission Cooler Line Photos

Steering Intermediate Shaft Replacement

Adjusting Tilt Lock Force on TRW Steering Columns

Adjusting Tilt Lock Force on TRW Steering Columns

Adjusting Tilt Lock Force on TRW Steering Columns

Adjusting Tilt Lock Force on TRW Steering Columns

FREIGHTLINER: ADJUSTING THE CORRECT TILT LOCK FORCE ON TRW STEERING COLUMNS.

Some vehicles may have been incorrectly shimmed at the factory, and may lean slightly to the right or left.

sb3133 Step Clamps Are Not Reusable

14-024-DLR DTNA & JAD Highlights - Q1 & Q2

14-036-DLR DTNA & JAD Highlights - Q3

DAIMLER TRUCKS: THERE MAY BE A RATTLE IN THE SWIVEL TYPE UTILITY LAMP.

Warranty Information Letter announcing DTNA is adjusting the Standard Repair Times (SRTs) shown.

129-13 DD Platform GHG 14 SPN 3361 FMI 3, 4, 5 UPDATE

1207-15 Updated procedures with adding EPA10 to the GHG14 title

Computer Hook-Up Standard Diagnostic Time Update

14TL-7Rev DD Platform Flywheel Housing Runout Tool W470589032100

17TL25 TruckCam? Alignment System

14TL7 DD Platform Flywheel Housing Runout Tool W470589032100

506-15 Air Compressor Coolant Lines

FREIGHTLINER: BULLETIN PERTAINING TO THE REPLACEMENT OF AIR CONDITION HIGH PRESSURE (FAN CYCLING) SWITCH ON CERTAIN MODEL TRUCKS.

SS 1032974 High Oil Pressure on 2017 DTNA Vehicles Instrument Cluster Display

15TS5Rev GHG14 DD Platform DEF Pump Leaks and Code 4374 FMI 0 Under Pressurized DEF System