2015 Freightliner Cascadia TSBs
837 Technical Service Bulletins across 17 categories
Categories
Other
261 bulletinsCX Advocate for NOx conversion low faults
CX Advocate for NOx conversion low faults
CX Advocate for NOx conversion low faults
CX Advocate for GATS2.4 being expanding to DD15
CX Advocate for Oil Suction manifolds
CX Advocate communication for NOx conversion low faults
SAM Cab & SAM Chassis Wall Charts
Cascadia Fault codes 6.0
Odometer racks up mileage when the vehicle is stationary - Cascadia
SS 469068 Cascadia SAM Cab, SAM Chassis, MSF and CGW Hardware Compatibility
SS 1033121 Adding a Fan Override Switch (Legacy Cascadia)
Freightliner Action Bulletin FAB158 Cummins Eaton SmartAdvantage
Freightliner Action Bulletin FAB154 New options for Cascadia
TSN for all Cascadia vehicles equipped with a driveline center bearing midship support.
Read full bulletin
Reference the following illustration - Customer complaints of loose fasteners at the bracket to channel bolted connection.
Tech Talk discussion on DD15 injector cups.
Tech Talk discussion on SCR ADS Self-Check.
Tech Talk discussion on SCR ADS Self-Check.
Tech Talk discussion on 2015 Cascadia dd13 no crank no start.
Tech Talk discussion on a 2015 Cascadia that will not start after replacing APU batteries.
Tech Talk discussion on repair verification for codes like 'low air flow' when a trailer is not available.
Tool Letter for ICC5 Programming Cable
Tool Letter for New Final Drive Pinion Cover Install Tool
Tool Letter for New Tool Kit Replacement Components DDE DKICHA018006 Components 1, 2 and 3
PowerNet Assessment Tool Repair Procedure
Installation of Vortex Generators
Revised Bulletin
Rear PTO Pump Support CA
ICI19-011 FL782 - Revised Bulletin
fp00024 Cable-Tie Reference
Letter to customer on Coverage Extension GHG17 After Treatment
SS 1033951 New Cascadia - Low Air Warning Audible Alert (Buzzer) Operation
FL721 Fifth Revised Bulletin
FL721 Fifth Revised Bulletin
SPN 3226 (ACM) (GHG17)
SPN 96 (MCM) (GHG17)
SPN 3226 (ACM) (GHG17)
Diagnostic tests - Two Filter System - FSIC Leak Test
SPN 3464 (MCM) (GHG14)
SPN 712 (CPC) (GHG17)
DT12 PTO Upfit
Letter to customer on Coverage Extension GHG17 After Treatment
FL721 Fifth Revised Bulletin
FL721 Fifth Revised Bulletin
SPN 3226 (ACM) (GHG17)
SPN 96 (MCM) (GHG17)
SPN 3226 (ACM) (GHG17)
Diagnostic tests - Two Filter System - FSIC Leak Test
SPN 3464 (MCM) (GHG14)
SPN 712 (CPC) (GHG17)
DT12 PTO Upfit
Technical Publications Ordering
DT12 PTO Upfit
SS 1033951 New Cascadia - Low Air Warning Audible Alert (Buzzer) Operation
Proactive Sam Chassis replacement
SPN 3226 (ACM) (GHG17)
SPN 96 (MCM) (GHG17)
Diagnostic tests - Two Filter System - FSIC Leak Test
SPN 3464 (MCM) (GHG14)
SPN 712 (CPC) (GHG17)
DT12 PTO Upfit
SF567C & SF567D ?Temporarily Suspended
Instructions for CSC Diagnostic Support
SPN 3556 (ACM) (GHG14)
ICU4Me Low Air Pressure Warning Change
Towing Procedures
ICU3 to ICU3S Replacement Guidelines
DDE W715589050700 - Pin Drive Wrench
Operating Hours for the Customer Assistance Center
Vehicles with Meritor drivelines bene from a softer durometer center bearing support.
Read full bulletin
Vehicle will continue to have a 1st order driveline vibration after the driveline assembly was rebalanced.
0505-18 SPN 3563 HDEP Inlet manifold pressure Too Low
sb54299 ICU3 to ICU3S Replacement Guidelines
fp00020 Replacing Gross Vehicle Weight Rating (GVWR) Certification Labels
Trucks were flooded
SS1033446 Driveline Support Bearing - Meritor Driveline
0505-18 SPN 3563 HDEP Inlet manifold pressure Too Low
MY18M1a 05-MAR-2018 Vocational
sb4932 DEF Gauge Reading Incorrectly
525-13 SPN 2791-FMI 7 ? ALL YEARS
0105-15 SPN 102 (MCM) (GHG14)
0108-15 SPN 1323 through 1328 (MCM) (GHG14)
0106-15 SPN 3251 (ACM) (EPA10) and (GHG14)
0104-15 SPN 3464/ FMI 16, 18 (MCM) (GHG14)
0101-15 SPN 4364 (ACM) (EPA10)
0107-15 Enhanced Steam Clean
54-279 - Intermittent Communication Between the TrailerTRACS Transmitter and the Qualcomm Unit
(CPC)(EPA10-GHG14) and SPN 98 (CPC)(GHG17)
0301-17 Contaminated Fluids
sb54215 ICU4M Missing VORAD Information or Reporting Fault SA 42 SPN FMI 07
sb4269 Excessive Moisture in the Air System
Replacing or Upgrading Airliner 40K Transverse Torque Rods
DT12 PTO Upfit
324-15 External Component Repair
304-15 Diagnostic Tests
303-15 Contaminated Fluids
325-15 Symptom Diagnosis - ATD Checklist
323-15 Symptom Diagnostics ? Noise
306-15 SPN 3246 (ACM)(EPA10;GHG14)
307-15 SPN 3480 (MCM) (EPA07;EPA10;GHG14)
321-15 SPN 4364 (ACM) (GHG14)
320-15 SPN 4374 (ACM) (GHG14)
301-15 SPN 3251 (ACM) (EPA10) and (ACM) (GHG14), 3936 (ACM)
14TS15 Issues with PTO and Remote Throttle Combinations
518-14 FMI 1, 18: Regen Temperature- Out Of Range Low
519-14 FMI 1: SCR NOx Conversion Efficiency Very Low
517-14 FMI 18: SCR NOx Conversion efficiency low
0402-18 SPN 625 (CPC) (GHG14)
0401-18 SPN 1231 (MCM) (EPA10 GHG14)
sb31034 Towing ProceduresB
sb3329 Caster Angle Specifications, Cascadia vs.
Read full bulletin
New CascadiaB
sb3251 Replacing or Upgrading Airliner 40K Transverse Torque RodsB
sb2652 DT12 PTO UpfitB
sb2083 FluidXchange Tool and FittingsB
sb00042 Flood Damage Repair GuidelinesB
sb0039 New Natural Gas Vehicle Information WebpageB
fsb42072 Diagnostic de fuite d'air
fsb4269 Humidit excessive dans le systme d'air
sb3132 Cascadia Chassis Side Fairing Lower Air Deflector Retention
sb3131 Huck-Spin 2 Changeover
13TS2 Single-Speed Fan Operation on Cascadia Vehicles
sb8844 Braces for Cascadia Cab-Mounted Splash Shields
0201-15 SPN 3250 FMI 31 - GHG14
0204-15 Symptom Diagnostics: Noisy One-Box Aftertreatment
0203-15 Oil Filter Stand Pipe
704-15 SPN 4364 (ACM)(EPA10)
706-15 SPN 1323 (MCM) (GHG14) SPN 1324 (MCM) (GHG14) SPN 1325
ICI15-008R SF499 Termination Date Extended
sb54291 Detroit Assurance Lane Departure Warning Camera
sb54292 Nexiq USB-Link Upgrade and Diagnostic Connector
sb3531 Differential Lubrication, Detroit Model 6 Axles
805-15 FMI 0: Selective Catalyst Reduction Outlet Temperature High
sb4932 DEF Gauge Reading Incorrectly
Power Take-Off
Power Take-Off
SPN 157 (MCM) (GHG17)
DD Heavy Duty Platform Belt and Belt Tensioner
SPN 1663 (CPC) (EPA07 10 GHG14 GHG17)
FL721 Second Revised Bulletin
0137-17 SPN 3361 FMI 5 (ACM) (GHG17) SPN 3361 FMI 5 (ACM) (GHG14)
0130-17 SPN 520211 (IPPC) (GHG14) SPN 520211 (IPPC) (GHG17)
0127-17 SPN 1077 FMI 14 (GHG14) (GHG17) (MCM)
0115-17 SPN 3226 (ACM) (EPA10;GHG14)
0106-17 SPN 520296 (MCM) (GHG14) and SPN 520296 (MCM) (GHG17)
1207-16 SPN 4363 (ACM) (EPA10 GHG14)
1213-16 SPN 3480 (MCM) (EPA07;EPA10 GHG14)
15TS16Rev1 EPA10 Reman MCM Improvement for Fault Codes SPN 651 to 656
1202-15 Symptom Diagnostics - ATD Checklist
FMI 2 CPC Clock Data Invalid
SPN 2623 (CPC)(GHG17), SPN 2623 (CPC)(GHG14), and SPN 2623 (CPC)(EPA07 EPA10 GHG14)
SPN 3226 (ACM) (EPA10;GHG14)
12C3bul-DocTrac - Final
12C3 - Instructions-DocTrac -Final
12-022-DLR Daimler Trucks Remarketing Corporation (DTR) Now Requires Pre-approval for Repairs $1,200 (USD) and Greater
15TS3 Detroit? Coolant Change From Nitrite Organic Acid Technology
405-15 Symptom Diagnostics - Hard Start/No Start - Two-Filter System
406-15 SPN 97 (MCM) (EPA10) / SPN 97 (MCM) (GHG14)
403-15 SPN 677 (MCM)(EPA07)
402-15 SPN 2630 (MCM)(EPA10) and SPN 2630 (MCM)(GHG14)
404-15 SPN 4364 (ACM) (EPA10)
15CSA10 The Detroit CSC announcing a new feature ? Ability to attach files to an existing CSC
15CSA9 Release of DiagnosticLink 8.02
sb54291 Detroit Assurance Lane Departure Warning Camera
505-15 SPN 3361 (ACM) (EPA10)
507-15 SPN 1590( CPC)(GHG14) and SPN 1590 (CPC)(EPA07;EPA10)
508-15 SPN 625 (MCM)( EPA10;GHG14)
sb8217 82-17 - Wiper Blade Replacement to Reduce Ice Accumulation On Passenger-Side Wiper, Cascadia Vehicles
sb2083 FluidXchange Tool and Fittings
15-009_Detroit_New_SDTs
15TL5 DAVCO Shop Pro FXP 95
324-15 External Component Repair
304-15 Diagnostic Tests
303-15 Contaminated Fluids
325-15 Symptom Diagnosis - ATD Checklist
323-15 Symptom Diagnostics ? Noise
306-15 SPN 3246 (ACM)(EPA10;GHG14)
307-15 SPN 3480 (MCM) (EPA07;EPA10;GHG14)
321-15 SPN 4364 (ACM) (GHG14)
320-15 SPN 4374 (ACM) (GHG14)
301-15 SPN 3251 (ACM) (EPA10) and (ACM) (GHG14), 3936 (ACM)
15CSA4 Holiday Schedule for the Detroit Customer Support Center
713-14 Symptom Diagnostics - Combustion Gas in Coolant
715-14 Symptom Diagnostics - Coolant Los
708-14 SPN 520219 (IPPC) (GHG14)
14-028 Remy Extended Coverage Direct File
14-027 Detroit's New Consolidated Labor Operations (CLOs
14-023 Detroit Axles Pre-Approval Changes
14-022 Pre-Approval Threshold Increase From $2,500 to $5,000 USD
54-215 - ICU4M Missing VORAD Information or Reporting Fault SA 42 SPN 639 FMI 07
16TL4 DOC Face Cleaning Tool P N W470589239100
16TS6 Variable-Speed Fan Operation on Cascadia Vehicles
16TS5 Release of the DD Platform Bearing Failure Guide
0304-16 SPN 2791 (MCM) ( GHG14) and SPN 2791 (MCM) ( GHG17)
0307-16 SPN 723 (MCM) March
0301-16 SPN 625 (CPC) (EPA07) and SPN 625 (CPC) (EPA10 GHG14)
Contaminated Fluids
Hydrocarbon Doser Coolant Lines
16-009R_OWL Enhancements
New Detroit Bearing Failure Analysis Standard Diagnostic Time
FL676 Second Revised Bulletin
17-026 Holiday Closure 2017
17TL27 Injector Cup Tool DSN930E17001
17TL26 Injector Heat Sleeve Removal Tool DSN930E17002
17CSA25 New Method for Uploading Diagnostic Log Files to the CSC
17CSA24 Holiday Schedule for the Detroit Customer Support Center
17CSA23r Detroit CSC closed December 14, 2017 from 11:15 am - 1:15 pm Eastern Time
SF551 ? Revised Bulletin
Cascadia 2020 DRM Air Tank Mounting Brackets
12-039-DLR OWL Pre-approval's Time Frame Increases to 60 Days
15-028 New Detroit Coolant Line SRTs
Detroit Data Summaries Application and Kits Are No Longer Available Through PDC
_NewDetroitCoolantLineSRTs
- Detroit Assurance Lane Departure Warning Camera Installation
13wo3rev2_final Actual Labor Hours on Detroit Claims
0229-14 Symptom Based Diagnostics - Oil Separator
0233-14 SPN 51 FMI 2 - All Years
0224-14 SPN 1590 FMI 9 - CPC- All Years February 2014
14-017R Revised: Detroit Addition of Admin Time
14-029 New Detroit Standard Diagnostic Times
FL662.-DLR Meritor MSF12 Non-Conforming Front Axle Beams
14-038_New_SRTs Additional Detroit Standard Repair Times.
14-039_additional_SDTs New Detroit Standard Diagnostic Times
14TL8 TorcUP? Non-Impacting Torque Tool.
14TS28 DD Platform Belt Drive System - Belt Part Numbers and diagnostics
1003-14 Rough Running or Stalling.
1009-14 SPN 5016 (ACM) (GHG14)
1007-14 SPN 5016/FMI 3, 4 (ACM) (EPA10)
1006-14 SPN 4374 (ACM) (GHG14)
1008-14 SPN 3510FMI 4,7, and 8 (CPC)(GHG14)
1010-14 SPN 2623 (CPC) (GHG14)
14CSA23 CSC Announces ?Tech Tips? ? DDCSN
14CSA21 Holiday Schedule for the Detroit Customer Support Center ?
14-039 New Detroit Standard Diagnostic Times
14-038 Additional Detroit Standard Repair Times
sb2080 Australian CST M1400 Isolated Radiator Retrofit
sb0039 New "Natural Gas Vehicles Information" Webpage
1108-14 SPN 636 (MCM) (EPA07;EPA10;GHG14)
18SP711 DD15 and DD16 Axial Power Turbine Bracket Ki
sb4271 Rear Axle S-Cam Support Bracket Replacement
912-14 Coolant in Oil
914-14 Ambient and Inlet Manifold Pressure Difference (High Box)
920-14 Additional Cleaning and Preparing
906-14 Installation of the Oil Pan
917-14 Installation and Removal of the Oil Filter Stand Pipe
ICI14-014-DLR SF499 Revised Bulletin
SF499-DLR Meritor WABCO OnGuard System
SB54291 DETROIT ASSURANCE LANE DEPARTURE WARNING CAMERA INSTALLATION
1021-16 SPN 110 (MCM)(EPA07EPA07;GHG14), SPN 110 (CPC)(GHG14)
1018-16 SYMPTOM DIAGNOSTICS - NOISE
16TS18 EPA10 AND LATER DD AUTO-ELEVATE FEATURE
0810-16 SYMPTOM DIAGNOSTIC NOISE
0809-16 SYMPTOM DIAGNOSTICS : NOISY 1- BOX AFTERTREATMENT
CASCADIA VIRTUAL TECHNICIAN RETROFIT
FL703 Revised Bulletin
0612-16 SPN 175 (MCM) (GHG17) AND SPN 175 (MCM); ( EPA07;EPA10;GHG14) DIAGNOSTIC PROCEDURE
0611-16 SPN 110 (MCM) (GHG17) AND SPN 110 (MCM); (EPA07;EPA10;GHG14) DIAGNOSTIC PROCEDURE
0610-16 SPN 111 (CPC) (GHG17) AND SPN 111 (CPC); (EPA07;EPA10;GHG14) DIAGNOSTIC PROCEDURE
0609-16 SPN 174 (MCM) (GHG17), SPN 174 (MCM) (EPA07), SPN 174; (MCM) (EPA10), AND SPN 174 DIAGNOSTIC PROCEDURE
0608-16 SPN 715 (CPC) (EPA07;EPA10); SPN 715 (CPC) (GHG14); SPN 715 (CPC) (GHG17) DIAGNOSTIC PROCEDURE
0605-16 SPN 625 (CPC)(GHG17) AND SPN 625 (CPC) (EPA10;GHG14) DIAGNOSTIC PROCEDURE
0601-16 SPN 103 (MCM) (GHG17) AND SPN 103 (MCM); (EPA07;EPA10;GHG14) DIAGNOSTIC PROCEDURE
FREIGHTLINER: DEMAND FOR NATURAL GAS IS BEING RESPONDED TO AND A NEW RESOURCE WAS ESTABLISHED WHERE AN ACCESSED TO...
Read full bulletin
VARIETY OF MATERIALS WILL BE FROM ONE CONVENIENT LOCATION. MODEL BUSINESS CLASS M2, CASCADIA, 108SD/114SD. *PE
FREIGHTLINER: DURING EXTREME COLD TEMPERATURES, THE RETURN FITTING OF THE 6 GALLON DEF TANK HAS PROBLEM WITH DEF FREEZING.
Read full bulletin
MODEL 122SD, CORONADO, BUSINESS CLASS M2, CASCADIA, 108SD, 114SD. *PE
Engine
127 bulletinsCX Advocate for turbo oil drain cracking
CX Advocate for turbo oil drain cracking
CX Advocate for DD13 Gen 5 engines operating at high altitude experience EGR slow response fault.
CX Advocate for clean idle label placement
Cascadia - Engine Will Not Crank (No Starter Output from SAM Cab)
Detroit Technical Service Letter for DD13 Cylinder Head and Cylinder Head Gasket Change.
DTNA received a field notification on multiple units regarding diagnostic fault codes that were found to be causing...
Read full bulletin
issues to the After Treatment Control Module (ACM). These fault codes indicated that the ACM communication message was not received by the Motor Control Module (MCM) which in certain cases, led to a 25% engine de-rate situation. Further diagnosis revealed that the DT12 wiring harness was chafing and contacting the transmission TCU case. To reduce potential chafing areas, the proposed short-term containment was to route the wiring harness using additional tie straps. This communication applies to Freightliner and Western Star vehicles built with DT12 transmissions.
Tech Talk discussion on CHECK ENGINE LIGHT AND CHECK TRANS LIGHT ON.
DDC Field Service Campaign for GHG14 DETROIT DD13 with One-Box Aftertreatment Software Reprogramming.
Read full bulletin
Certain Detroit Model Year 2013 to 2015 GHG14 DD13 engines that are registered in California will require reprogramming to a minimum of the MCM software version and fuel map version listed below: MCM Software Version 4.7.0.0 ZGS 005.
Service Solution for P3 - CEL On and Engine de-rate due to ATD Chassis Harness Circuit 532M5+ at DEF Heater Supply...
Read full bulletin
location is shorted.
Tech Talk discussion on Cascadia Engine Brakes Not working.
Warranty Information Letter for Detroit New Service Replacement Engine SRT Update.
Read full bulletin
While validating Standard Repair Times (SRTs) for Detroit's new Gen 5 engine series, DTNA discovered an error in a pre-Gen 5 SRT for the New Service Replacement Engine Program. As a result, DTNA re-studied the SRT and concluded that time for removing/re-installing multiple components (e.g., exhaust manifold/turbo, engine sensor harness, rocker arm assemblies, etc.) should not be included.
Tech Talk discussion on Cascadia Engine Brakes Not working.
Detroit Diesel Field Service Campaign for Engine Emission Label Replacement.
Read full bulletin
Certain DETROIT heavy-duty engines installed in various applications will require reprogramming and engine emission label replacement.
Service Solution for P3 - CEL On and Engine de-rate due to ATD Chassis Harness Circuit 532M5+ at DEF Heater Supply location is shorted.
Read full bulletin
Harness part number A66-03217-002 has been reported experiencing failures due to damages to 532M5+ circuit shorting /or corrosion in terminals at Connector (23-13053-200) harness location "ATD_CHAS_F_O_HTR_LINE_DEF_5B" .
Detroit Diesel Field Service Campaign for DETROIT Reman Built HDEP Engines - Incorrect Gear Train Bolt Torque.
Read full bulletin
The gear train mounting bolts need to be checked for proper torque and adjusted as needed.
Updated Service Bulletin for DT12 Transmission Cooler Retrofit.
Read full bulletin
This bulletin replaces the version dated 09/18/2019. The part number for the oil control valve has been updated in the parts table.
Training Solutions for Fuel Leak Found at High Pressure Fuel Pump Weep Hole for Heavy Duty DD Engines.
Read full bulletin
Occasionally we see trucks come in with fuel leaking from the high pressure fuel pump weep hole. This is NOT a defect in the pump and further diagnostics need to be performed to find the root cause.
Updated DDC Field Service Campaign for GHG14 DETROIT DD13 with Two-Box Aftertreatment Software Reprogramming.
Read full bulletin
Certain Detroit Model Year 2013 to 2015 GHG14 DD13 engines that are registered in California will require reprogramming to a minimum of the MCM software version and fuel map version listed below: MCM Software Version 4.7.0.0 ZGS 005. Certain sections have been updated for clarity.
Warranty Information Letter for Warranty Long Block Program Change.
Read full bulletin
The Detroit Reman Long Block Program has expanded. The expansion reduces complexity in ordering reman engines and promotes stocking reman engines to meet uptime commitments.
Customer Advisory Letter describing that some 2015 Cascadia may not be filtering engine air properly.
Service Systems Development provided document to service locations on price list reflects current charges to engine...
Read full bulletin
horsepower ratings for HDEP and MDEG engine platforms.
Service Bulletin to fix wiper motor issue.
Read full bulletin
On some Cascadia wiper park brush that rides against the brush plate may wear and may result in a diminished wiper park signal.
Service Information Bulletin to updated the Fuel Injector Harness sections and relocated to Engine Electrical section.
Service Bulletin to testing of EGR Cooler Water Manifold Assembly in DD13 engines.
HDEP GHG17 engines are not equipped with turbo wastegates.
Read full bulletin
Steps in this troubleshooting involving wastegates were removed.
This service kit includes all necessary parts to replace the high pressure fuel rail feed lines, mounting bracket,...
Read full bulletin
P-clips and mounting hardware in the event one of these parts are loosened, removed or missing from the engine.
This service kit includes all necessary parts to replace the high pressure fuel rail feed lines, mounting bracket,...
Read full bulletin
P-clips and mounting hardware in the event one of these parts are loosened, removed or missing from the engine.
This service kit includes all necessary parts to replace the high pressure fuel rail feed lines, mounting bracket,...
Read full bulletin
P-clips and mounting hardware in the event one of these parts are loosened, removed or missing from the engine.
This service kit includes all necessary parts to replace the high pressure fuel rail feed lines, mounting bracket,...
Read full bulletin
P-clips and mounting hardware in the event one of these parts are loosened, removed or missing from the engine.
This service kit includes all necessary parts to replace the high pressure fuel rail feed lines, mounting bracket,...
Read full bulletin
P-clips and mounting hardware in the event one of these parts are loosened, removed or missing from the engine.
This service kit includes all necessary parts to replace the high pressure fuel rail feed lines, mounting bracket,...
Read full bulletin
P-clips and mounting hardware in the event one of these parts are loosened, removed or missing from the engine.
Service Solution: 1034298 - New Cascadia Engine Harness Chafe at A06-95037-000 Bracket
Field Service Campaign D18M2 GHG17 GHG17 Detroit DD13 Software Reprogramming and Emission Label Replacement for Motor Coach Industries, Inc.
Read full bulletin
(MCI)
Field Service Campaign-D18M2 - REVISION 1 GHG17 Detroit DD13 Software Reprogramming and Emission Label Replacement for Motor Coach Industries, Inc.
Read full bulletin
(MCI)
Cylinder Liner - Testing of the Cylinder Liner Upper O-Ring
Field Service Campaign D18M2 GHG17 GHG17 Detroit? DD13 Software Reprogramming and Emission Label Replacement for Motor Coach Industries, Inc.
Read full bulletin
(MCI)
Field Service Campaign-D18M2 ? REVISION 1 GHG17 Detroit? DD13 Software Reprogramming and Emission Label Replacement for Motor Coach Industries, Inc.
Read full bulletin
(MCI)
Cylinder Liner - Testing of the Cylinder Liner Upper O-Ring
Cylinder Liner - Testing of the Cylinder Liner Upper O-Ring
Service Information Bulletin- Oil Present at the Turbocharger Compressor Housing
New Detroit Diesel Cylinder Liner Upper O-Ring Leak Test Standard Repair Time
Engine Manufacturer Diagnostics
DD13, DD15, DD16 Check Engine Light Flashing or Blinking
Field Service Campaign D18M3-REV1 Heavy Duty Engine Platform Oil Suction Manifold
Field Service Campaign: GHG14 Heavy Duty Engine Platform Vocational Application Programming
aeo18M1 GHG14 Heavy Duty Engine Platform Vocational Application Programming
532-13 Description and Operation of the Two-Stage Valve - Two-Filter Systems
15TS4 EPA07 DD15 Piston Kits
15TS2 EPA07 and EPA10 DD Platform Engines With Low Oil Pressure Codes
15TS1 GHG14 DD Platform Engines With Codes SPN: 1323 through SPN: 1328, FMI: 31, Idle Smoothness Control/Cylinder...
Read full bulletin
Misfire At Idle
GHG14 - Intake Manifold Pressure Too Low
GHG14 Intake Manifold Pressure Too Low
sb0935 Replacing the Engine Air Filter Element, Donaldson Air Cleaner (03-33648-001-002)
0202-17 DD13, DD15, and DD16 Cylinder Head Assembly Removal and Installation
308-15 Symptom Diagnostics - Oil Present at the Turbocharger Compressor
302-15 Crankshaft Oil Seals
18SP706 Replacement of the High Pressure Fuel Pump Camshaft Oil Seal
14TS16 Excessive Overhead Engine Noise on DD Platform Engines
524-14 FMI 0: Engine Speed High
18SP705Rev4 18SP701Rev GHG14 Two-Filter Fuel System KM63 GEN2 DD15AT Engines High Pressure Fuel Feed Lines, Mounting...
Read full bulletin
Bracket and P-clip
18SP701Rev GHG14 Two-Filter Fuel System KM63 GEN2 DD15AT Engines High Pressure Fuel Feed Lines, Mounting Bracket and...
Read full bulletin
P-clips
sb2084 OAT Coolant Replaces NOAT Coolant in Detroit Engines
sb0006 Freightliner Courtesy Engineering PolicyB
83-144 - Optimized Idle and Auxiliary Cab Heater Concurrent Operation
15TS6 Replacement of the High Pressure Fuel Pump Camshaft Oil Seal
15TS14 GHG14 DD Engine Cylinder Liner Seal Replacement
708-15 High Pressure Fuel Pump Camshaft Oil Seal - Two-Filter System
711-15 High Pressure Fuel Pump Camshaft Oil Seal - Three-Filter System
702-15 DD15 and DD16 Delphi Exhaust Gas Recirculation Valve Actuator
703-15 GHG14 DD15 AT Exhaust Gas Recirculation Valve Actuator
803-15 Removal of the Camshaft Housing
Heavy Duty Engine Wastegate Repair Kit DKI470E16019
0120-17 Diagnostic Test - Engine Oil Leaks - Oil Developer Method
0118-17 Symptom Diagnostics - Oil Leaks
15TL24 OTC 1750 Revolver Engine Stand
15TS4_Rev2_ EPA07 DD15 Piston Kits
1210-14 Cylinder Head
1201-15 Crankshaft and Bearings
FMI 3 Engine Oil Pressure Sensor Circuit Failed High
Inspection of the DD13 Turbocharger
15TS10Rev DD Engine Platform Coolant Filter
401-15 Cylinder Block
15TS13 DD Platform Oil Filter Bypass Valve
15TS12 DD Platform Cylinder Block Oil Gallery Cup Plug Replacement
501-15 Engine Lifter Brackets
504-15 DD13 Exhaust Gas Recirculation Valve Actuator Pull Rod
511-15 DD15 and DD16 Exhaust Gas Recirculation Valve Actuator Pull Rod
503-15 DD13 Exhaust Gas Recirculation Valve Actuator
sb2084 OAT Coolant Replaces NOAT Coolant in Detroit Engines
15TL4 W470589050900 ? 3/8? Drive GEN2 Two-Stage Valve Socket
308-15 Symptom Diagnostics - Oil Present at the Turbocharger Compressor
302-15 Crankshaft Oil Seals
18SP706 Replacement of the High Pressure Fuel Pump Camshaft Oil Seal
sb01101 Pilot Bearing Spacer for Detroit Engines with Eaton transmissions
14TL2 DD Platform Engine Stand Adapter W060589023100
714-14 Symptom Diagnostics - Low Engine Compression
712-14 Engine Coolant Temperature
20-73 - CANCELED: Cascadia Radiator Update?EPA10 with DDC Engines
20-75 - CANCELED: Cascadia Radiator Update?EPA10 with Cummins ISX Engines
16TS8 DD13 Cylinder Head and Cylinder Head Gasket Change
16-011 New Detroit Camshaft Housing Seal Standard Repair Time
sb4724 Crank No Start, Loss of Engine Prime on Decked Vehicles
12-038-DLR - No Problem Found - Policy Claims - During Basic Vehicle Chassis or Base Engine Coverage
14TS4 Valve and Liner Installation Tool Issue
0228-14 Engine Oil Leaks - Oil Dye Method
0237-14 Engine Brake Solenoid
14TS21 HDEP Camshaft Position Sensor Change
14-040_Additional_CLOs Additional Detroit CLOs for the Heavy Duty Engine Platform
14CSA20 EGR Valve Actuator Kit P/N E23539699
14-040 Additional Detroit CLOs for the Heavy Duty Engine Platform
1102-14 DD13 Cylinder Head R&R
1101-14 DD15 and DD16 Cylinder Head
14TS26 Replacement of the High Pressure Fuel Pump Camshaft Oil Seal
913-14 Checking for Poor Engine Brake Performance
915-14 Backwards Running Engine Detecte
18SP706 Replacement of the High Pressure Fuel Pump Camshaft Oil Seal
18SP701Rev3 GHG14 Two-Filter Fuel System KM63 GEN2 DD15AT Engines High Pressure Fuel Feed Lines, Mounting Bracket and...
Read full bulletin
P-clips Service Kit
16TS24 GHG14 DD Platform Engines With Code SPN: 3216/FMI 18, SCR Inlet NOx Sensor Drift Low
14TS16REV EXCESSIVE OVERHEAD ENGINE NOISE ON GHG14 DD PLATFORM ENGINES
SB0006 FREIGHTLINER COURTESY ENGINEERING POLICY
1017-16 ENGINE MODEL AND SERIAL NUMBER DESIGNATION
16TL20 HEAVY DUTY ENGINE VALVE STEM SEAL INSTALLING DRIFT AND SLEEVE
0909-16 EXCESSIVE OIL CONSUMPTION
FREIGHTLINER: THE MALFUNCTION INDICATOR LIGHT (MIL) WILL ILLUMINATE DUE TO DERATE WITH ENGINE RELATED FAULT CODES AND...
Read full bulletin
DETROIT 1-BOX AFTERTREATMENT DEVICE. MODEL CASCADIA. *PE
FREIGHTLINER: ON THE FORWARD REAR DIFFERENTIAL, WITH EXTERNAL BREATHER, IS AN OIL LEAK, AND NOW AN INTERNAL BREATHER...
Read full bulletin
REMEDY IS AVAILABLE FOR INSTALLATION. MODEL FLD CONVENTIONAL, CENTURY CLASS CONVENTIONAL, ARGOSY COE, COLUMBIA, BUSINESS CLASS M2, CASCADIA. *PE
FREIGHTLINER: DUE TO COMPRESSION SET, A LEAKAGE MAY OCCUR DURING EXTREME COLD CONDITIONS, FROM THE O RINGS IN COOLANT...
Read full bulletin
SOLENOID VALVE 13 AND 23 GALLON DEF TANKS. KIT IS AVAILABLE FOR REPLACING O RINGS IN VALVE. *PE
Fuel System
111 bulletinsDetroit Emission recall for GHG14 DETROIT DD16 Software Reprogramming
Detroit Emission recall for GHG14 DETROIT DD16 Software Reprogramming
Detroit Emission recall for GHG14 DETROIT DD16 Software Reprogramming
Warranty Information letter announcing that DTNA is increasing the Standard Diagnostic Times (SDTs) shown.
Read full bulletin
The updated after treatment system (ATS) diesel exhaust fluid (DEF) pump times will be applied to repair orders opened on or after April 12, 2021.
Important Campaign Information Letter announcing that a revision for Detroit Diesel Field Service Campaign D19M7.
Read full bulletin
This letter is to inform you that Detroit Field Service Campaign D19M7 REV2, Pre-Series Cascadia Emission Label Replacement has been EXTENDED for an additional four months and re-activated on DTNA Connect. Please use the extended termination date for all work under D19M7 REV2 from this point forward.
Revision for Field Service Campaign for pre-series Cascadia and New Cascadia Emission Label replacement.
Read full bulletin
Additional sections have been updated.
Superseding Letter to an Important Campaign Information Letter to announce a reimbursement available to dealers for...
Read full bulletin
travel to a customer's location to perform a recall or field service campaign. Potential travel reimbursement applies to DTNA truck dealers and Detroit Diesel distributors. Thomas Built Buses will be addressed separately. This letter supersedes ICI20-022R.
Special Publication letter for Two-Filter Fuel System KM59 GEN1 DD15 DD16 Severe Duty High Pressure Fuel Rail Feed Lines...
Read full bulletin
Service Kit.
Tech Talk Discussion for DD15 GHG14 EGR linkage hex nuts.
Customer Service Announcement for Release of DiagnosticLink 8.12 Service Pack 2.
Read full bulletin
On Thursday, September 3, 2020, Service Pack (SP) 2 for DiagnosticLink 8.12 Standard and Professional will be made available to download from the Detroit Diesel server.
Revised letter is to announce a reimbursement available to dealers for travel to a customer's location to perform a recall or field service campaign.
Read full bulletin
Potential travel reimbursement applies to DTNA truck dealers and Detroit Diesel distributors. Thomas Built Buses will be addressed separately.
Technical Service Letter for EPA10, GHG14, GHG17 Diesel Particulate Filter (DPF) Compatibility.
Read full bulletin
Note: This document supersedes 14 TS-25 and 15 TS-8. Detroit Diesel has determined that some, Diesel Particulate Filters (DPFs) are compatible in pairs and or can be mixed together within EPA10 and GHG14 Systems. For 1-BOX and Two-Box Configuration Aftertreatment Systems (ATS), this is only possible when the filters are used in accordance with Tables 1 and 2 shown below. All other DPFs, NOT mentioned below, are NOT compatible.
Customer Service Announcement informing that Service Pack (SP) 1 for DiagnosticLink 8.12 Standard and Professional is...
Read full bulletin
available to download from the Detroit Diesel server.
Customer Service Announcement saying that Service Pack (SP) 3 for DiagnosticLink 8.11 Standard and Professional will be...
Read full bulletin
available for download from the Detroit Diesel server.
Important Campaign Information Letter announcing that a revision for Detroit Diesel Field Service Campaign D19M7,...
Read full bulletin
Pre-Series Cascadia Emission Label Replacement is available. The Corrective Procedure section of the bulletin has been clarified.
Revision for Field Service Campaign for pre-series Cascadia and New Cascadia Emission Label replacement.
Read full bulletin
The corrective procedure section has been clarified.
Field Service Campaign for pre-series Cascadia and New Cascadia Emission Label Replacement
Service Bulletin for Equiflo Fuel System Breather Tube Inspection
Service Solution to fix incorrect ICUC Fuel Economy Reading
Service Information Bulletin for Symptom Diagnostics - Fluid in the Aftertreatment - Diesel Fuel Contamination.
Service Information Bulletin regarding PTO Dosing.
Read full bulletin
This feature enables Active Regeneration of the DPFs while in PTO mode.
SS 1034231 New Cascadia Fuel Gauge Not Indicating Full When Fuel Tank(s) Are Filled
Service Bulletin-sb60165 Exhauster Splash Covers Do Not Fully Latch
FL721 CNG Fuel Tank and CPDM Mounting Location
FL721 CNG Fuel Tank and CPDM Mounting Location
Fuel System Integrity Check Routine - Two-Filter Fuel System
Fuel Level Sending Unit Retrofit
FL721 CNG Fuel Tank and CPDM Mounting Location
FL721 CNG Fuel Tank and CPDM Mounting Location
Fuel System Integrity Check Routine - Two-Filter Fuel System
Fuel System Integrity Check Routine - Two-Filter Fuel System
Service Information Bulletin- Exhaust Gas Recirculation Crossover Pipe
DT12 Exhaust Port Splash Shield
owner18R3 Emission Recall D18R3
GHG14_18R3_bulletin_07-MAY-2018a Emission Recall D18R3
owner18R3 Emission Recall D18R3
GHG14-18R3 bulletin-07-MAY-2018a-Emission Recall D18R3
530-13 Low Pressure Fuel Pump ? Two-Filter Fuel System
529-13 Operation of the Fuel System - Two-Filter Fuel System
102-15 High Pressure Fuel Pump - Two-Filter System
18SP687 DD15 16 EGR Actuator Replacement
FL721 CNG Fuel Tank and CPDM Mounting Location
18SP712 EPA07 DD15/16 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel System Conversion Service Kit
18SP713 EPA10 DD13 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel System Conversion Service Kit
18SP714 EPA10 DD15/16 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel System Conversion Service Kit
SF504-DLR Cascadia CNG Exhaust Mitigation
14TS13Rev EPA10/GHG14 Diesel Exhaust Fluid (DEF) in Fuel System/Diesel Fuel in DEF System Contamination
505-14 Fuel Cooler Leak Test Procedure - Three-Filter Fuel System
504-14 Test-E - Three-Filter Fuel System
513-14 FMI 0: Diesel Particulate Filter Outlet Temperature - Very High
515-14 FMI 1: Over Pressurized Diesel Exhaust Fluid System
501-14 Removal and Installation of the DD13 Exhaust Flanged Manifold
sb54296 Fuel Level Sending Unit RetrofitB
sb54148 Radio and Integrated Thin-Film Antenna Troubleshooting, and Field Service UpdatesB
sb49040 Diesel Exhaust Fluid (DEF) Pressure Line Disconnected at the Doser ConnectionB
fsb49040 Conduite sous pression de fluide pour chappement diesel (DEF) dbranche au niveau du raccordement du doseur
15TS8 EPA10 and GHG14 Diesel Particulate Filter (DPF) Compatibility
0202-15 EPA10 and GHG14 Diesel Oxidation Catalyst Face Cleaning
FL671-DLR Exhaust Discharge Location
EPA10, GHG14 and GHG17 Diesel Particulate Filters
Exhaust and Exhaust Gas Recirculation
Diesel Exhaust Fluid (DEF) Pressure Line Disconnected at the Doser Connection
SPN 4765 FMI 0 - Exhaust Temperature Out Of Range High
CNG Fuel Tank and CPDM Mounting Location
18SP726 ? EPA10 GHG14 Two-Filter Fuel System KM59 GEN1 DD13 High Pressure Fuel Fee
15TL6 W470589129100 ? HDEP HP Fuel Rail Test Caps
18SP717 DD13 EGR Actuator Replacement
509-15 Symptom Diagnostics - Hard Start/No Start - Three-Filter Fuel
512-15 GHG14 DD15 AT Exhaust Gas Recirculation Actuator Pull Rod
502-15 Exhaust Gas Recirculation Actuator Lever
18SP716 Installation/Replacement of the Fuel Cooler Delete Bypass Plate for the Two-Filter Fuel System
15-017 Detroit: Updated Fuel Injector SDTs
18SP712 EPA07 DD15/16 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel System Conversion Service Kit
18SP713 EPA10 DD13 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel System Conversion Service Kit
18SP714 EPA10 DD15/16 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel System Conversion Service Kit
SF504-DLR Cascadia CNG Exhaust Mitigation
14TS19 DD Platform High Pressure Fuel Lines
16TS9 DD Platform High Pressure Fuel Lines
16TS7 Reman Diesel Particulate Filter Serial Number
17TL28 Fuel Injector Removal Tool DSN930E17004
0239-14 High Pressure Fuel Injector Lines - Three-Filter System
0238-14 Removal of the High Pressure Fuel Injector Lines - Two-Filter
0210-14 High Pressure Fuel Rail Feed Lines - Three-Filter System
0209-14 High Pressure Fuel Rail Feed Lines - Two-Filter System
0219-14 Metal in Fuel
0202-14 Symptom Diagnostics - Hard Start No Start - Two-Filter Fuel System
0215-14 Check for Rough Running or Stalling - Three-Filter Fuel System
54-281 - Fuel Level Sender Guard Installation
14TS19Rev DD Platform High Pressure Fuel Lines
1104-14 Metal in the Fuel System
18SP707Rev EPA07/10 Three-Filter Fuel System DD13 High Pressure Fuel Feed Lines, Mounting Bracket and P-clips Service...
Read full bulletin
Kit
18SP708Rev EPA07 10 Three-Filter Fuel
14TS25 EPA10 and GHG14 Diesel Particulate Filter (DPF) Compatibility
910-14 Installation of the High Pressure Fuel Rail Feed Lines - Two-Filter System
918-14 Removal and Installation and Inspection of the Fuel Cooler Delete Bypass Plate - Two Filter System
916-14 Fuel Cooler Leak Test Procedure - Two-Filter Fuel System
908-14 908-14 EGR Differential Pressure Failed (High Box)
919-14 Exhaust Gas Recirculation Flow Target Error Diagnostic - High Flow
18SP687 18SP687 DD15/16 EGR Actuator Replacement Service Kit
18SP719Rev EPA10 DD13 Three-Filter ESOC Fuel System to Two-Filter KM59 GEN1 Fuel
18SP714Rev EPA10 DD1516 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel
18SP725 TWO-FILTER FUEL SYSTEM KM63 GEN2 DD13 HIGH PRESSURE FUEL FEED LINES, MOUNTING BRACKET AND P-CLIPS SERVICE KIT
18SP722 DD13 KM59 GEN1 BUS TWO-FILTER SYSTEM AMPLIFIER, NEEDLE AND PLV RETURN FUEL LINE CLEARANCE PACKAGE SERVICE KIT
18SP720 EPA10 DD15/16 THREE-FILTER ESOC FUEL SYSTEM TO TWO-FILTER KM59 GEN1 FUEL SYSTEM CONVERSION SERVICE KIT
18SP720 EPA10 DD15/16 THREE-FILTER ESOC FUEL SYSTEM TO TWO-FILTER KM59 GEN1 FUEL SYSTEM CONVERSION SERVICE KIT 2
18SP718 EPA07 DD15/16 THREE-FILTER ESOC FUEL SYSTEM TO TWO-FILTER KM59 GEN1 FUEL SYSTEM CONVERSION SERVICE KIT
1020-16 CHASSIS FUEL SYSTEM ISOLATION TEST
18SP720REV 18SP720 EPA10 DD15/16 THREE-FILTER ESOC FUEL SYSTEM TO TWO-FILTER KM59 GEN1 FUEL SYSTEM CONVERSION SERVICE...
Read full bulletin
KIT
18SP713REV 18SP713 EPA10 DD13 THREE-FILTER FUEL SYSTEM TO TWO-FILTER KM59 GEN1 FUEL SYSTEM CONVERSION SERVICE KIT
0906-16 LOW PRESSURE FUEL PUMP
DETROIT APPROVED PRIMING TOOLS FOR THE KM63 GEN2 FUEL SYSTEMDETROIT APPROVED PRIMING
Electrical
91 bulletinsService Solution SS 1033047 M2 Battery Drain Problem Mismatched I...
Service Solution SS 1033094 KUS Float Tube Fuel Level Sensor Inform...
SS 1033638 - Power Window Express Down Module Discontinued
Freightliner Action Bulletin FAB153 New Harness Highway for Cascadia
Warranty Policy Letter for battery tags.
Read full bulletin
DTNA determined that since adopting the AutoMeter BCT-460DTNA Powernet Assessment Tool (AutoMeter) as the required powernet system tester, not all battery tags have to be retained support Warranty-related claims.
Freightliner Service Bulletin for Programming Chassis Electronic Control Units (ECUs) With DiagnosticLink.
Warranty Information Letter for Detroit NOx Sensor Circuit Fault Codes - Claim Guidelines.
Tech Talk discussion on P3 Coolant level sensor voltage fluctuating.
Updated Freightliner Service Bulletin for Powernet Troubleshooting Guide - Batteries, Path, Alternator, and Starter.
Read full bulletin
This bulletin replaces the version dated 5/31/2017. Information is added about the BCT-460DTNA PowerNet Assessment Tool. When troubleshooting Powernet issues, use the BCT-460DTNA PowerNet Assessment Tool. As of May 29, 2018, the AutoMeter is the only Daimler-approved tool for troubleshooting vehicle Powernet issues.
Service Bulletin for Guidelines for Repairing or Replacing an Electrical Harness.
Read full bulletin
Use the guidelines in this bulletin to determine if a damaged electrical harness should be repaired or replaced.
Service Solution for Meritor Wabco OnGuard Radar Service Alignment.
Read full bulletin
If the radar sensor needs to be aligned, the radar sensor mounting system has become damaged or has loosened, or new radar sensor software has been installed, a Radar Sensor Service Alignment will need to be performed.
Service Bulletin on guidelines for repairing or replacing an electrical harness.
Service Solution for Legacy Cascadia, where trailer turn signals or 4-way flashers used in applications with high duty...
Read full bulletin
cycles, the left and right turn signals may experience shortened relay life.
Customer Advisory Letter for improved battery cable and routing improvements.
Warranty Information Letter announcing Detroit NOx Sensor Circuit Improvements for GHG17 After Treatment Systems
Service Bulletin for Cascadia Cabin CAN ECU Compatibility.
Read full bulletin
Compatible software levels are required for the proper operation of the vehicle.
Service Bulletin describing Cascadia cabin CAN ECU compatibility.
Read full bulletin
This document replaces version from July 2015.
Service bulletin describing that the DiagnoticLink screen images for Chassis ECU programming have ben updated.
Service Solution to fix coolant level wiring damage.
Service Bulletin to provide instructions to replace Ignition Control System.The ICU3 is no longer installed in...
Read full bulletin
production, and has been superseded by the ICU3S. When replacing an ICU3, the ICU3S must be installed in its place.
Service Information Bulletin for Communication Loss with a Common Powertrain Controller (CPC) Module (CPC Heartbeat...
Read full bulletin
Message is no Longer Arriving)
SS 1034220 SSI Ultrasonic Fuel Level Sensor Information
sb54308 Chassis ECU Programming
Service Bulletin- Chassis ECU Programming
Aftertreatment Systems - Diesel Exhaust Fluid Pump Module and Components
Eaton 1800-Watt Inverter With Low Voltage communication
Service Solution 1033911- After Reprogramming CPC04T, Fault Code (VRDU) 232/524000/9-ECU CPC Timeout Comes Active
SS 1033833- Service Solution for Cascadia Parksmart 100 amp Durakool relay upgrade
Indel B Refrigerator Loose Circuit Board
0311-18 Installation of the Main Shaft Speed Sensor
54-277 - Resetting Erroneous Learned Roll Call ECUs on Vehicles with ICU4M
54-278 - Powernet Troubleshooting Guide: Batteries, Path, Alternator, and Starter
54-274 - Plastic Battery Box Cover Retainer Clip
15TS9 Hydrocarbon Doser Block Fuel Compensation Pressure Sensor
326-15 Main Shaft Speed Sensor
503-14 FMI 3, 4: High Side Digital Output 3 Circuit Failed High
511-14 FMI 9 Soot Sensor Communication Error
520-14 FMI 2 Soot Sensor Heater Faul
523-14 FMI 18: Soot Sensor Temperature Low
sb83158 ParkSmart Control Module Cover Modification for a New Phase HarnessB
sb2066 Gentech Low Coolant Level Sensor
fp54031 Ordering Service Wiring Harnesses for Cascadia
54-275 - Chassis-Mounted Trailer PDM, Battery Power Cable Terminal Corrosion
sb54278 Powernet Troubleshooting Guide: Batteries, Path, Alternator
sb54239 Cascadia Cabin CAN ECU Compatibility
802-15 SPN 520970 FMI 7 (TCM)
801-15 SPN 520999 FMI 7 (TCM)
SPN 520960 (TCM)
SS 1033334 ICU3S Displays "Electrical System Problem Detected - Shutdown in Progress"
0311-18 Installation of the Main Shaft Speed Sensor
SPN 521221 (TCM)
SPN 521222 (TCM)
1205-15 Selective Catalyst Reduction (SCR) Inlet Temperature Sensor
Cleaning of the Exhaust Gas Recirculation Venturi Pipe Delta P Sensor Ports
FMI 5 Oil Pressure Sensor Stuck High
FMI 3,4,5 Digital Output 1 13 Circuit
FMI 3,4,5 Digital Output 1 13 Circuit
FMI 3,4,5 Digital Output 3 10 Circuit
FMI 3,4,5 Digital Output 2 10 Circuit
FMI 3,4,5 Digital Output 3 12 Circuit
FMI 2, 3, 4 Remote Accelerator Pedal Supply Voltage
ParkSmart HVAC Modules
15-016-DLR New Essential Tool For CPWA, CPPRA, Ltd CPPRA, & DSDWC Parties: Cadex CA-12 Battery Tester
15TS9 Hydrocarbon Doser Block Fuel Compensation Pressure Sensor
326-15 Main Shaft Speed Sensor
54-285 - Cracked Fuses on Powertrain Power Distribution Modules
16TL5 DD Platform Aftertreatment Soot Sensor Socket DSN0ATZ16001
16_TL-2 DD Platform Aftertreatment NOx Sensor Socket W470589060900
0308-16 TCM Programming Instruction
0305-16 TCM SPN 520999 FMI 7 March
0306-16 TCM SPN 520970 FMI 7
14TS5 Replacing Damaged Aftertreatment Sensor Bosses
1005-14 Oil Coolant Module
14CSA22 DTNA Chassis Wiring Diagrams
18SP684Rev4 18SP684Rev4 ? EPA07 and EPA10 DD Platform EGR Delta Pressure Sensor Update
18SP705Rev5 18SP705Rev5 ? DD Platform Delta Pressure Sensor
sb54287 Powernet Distribution Box Fuse Retention on the Keep-Alive
sbw5460 Powernet Distribution Box Fuse Retention on the Keep-Alive
sb3250 Incorrect ECAS Ride Height Sensor and Linkage Installation
905-14 Coolant Level Circuit Failed
903-14 Selective Catalyst Reduction Inlet NOx Sensor Circuit Failed High and Low
904-14 Selective Catalyst Reduction Outlet NOx Sensor Circuit Failed High and Low
911-14 5V Sensor Supply Bank 2 Circuit Failed High
909-14 Diesel Exhaust Fluid Metering Unit Air Pressure Sensor Circuit Failed High and Low
SB54297 LOOSE IGNITION SWITCH ON CASCADIA VEHICLES
16TL17 LABEL UPDATE FOR GHG14 TEST AFTERTREATMENT CONTROL MODULE (ACM)
PARKSMART HVAC MODULES
FREIGHTLINER: INFORMATION PROVIDED REGARDING WATER INTRUSION AND FOREIGN DEBRIS CAN ENTER SAM CHASSIS AND ELECTRICAL...
Read full bulletin
COMPONENT, WHEN COVER IS NOT SHUT SECURELY AND SWINGS OPEN. MODEL CASCADIA. NO MODEL YEARS LISTED. *PE
FREIGHTLINER: DUE TO POOR FUSE RETENTION FOR POWERNET DISTRIBUTION BOX (PNDB) MODULES ON KEEP ALIVE CIRCUITS, AN...
Read full bulletin
OPERATION ON ANY DEVICES SUPPLIED BY THESE CIRCUITS WILL BE INTERMITTENT. MODEL 122SD/CORONADO, BUSINESS CLASS M2, CASCADIA, 108SD/114SD. *PE
FREIGHTLINER DUE TO INCORRECT INSTALLATION OF SENSOR, LINKAGE, AND/OR Z-BRACKET THE RIDE HEIGHT SENSOR ARMS ARE BROKEN...
Read full bulletin
ON SOME TRUCKS WITH WABCO ELECTRONICALLY CONTROLLED AIR SUSPENSION (ECAS), AND MOUNTED AFT RATHER THAN FORWARD OF BRACKET. *PE UPDATED 3/24/15. *PE
FREIGHTLINER: FOR SOME TRUCKS, AVAILABLE IS NEW AMBIENT AIR TEMPERATURE SENSOR TO BE INSTALLED, USING TIE STRAPS (23-09796-309).
Read full bulletin
MODEL CASCADIA. NO YEARS LISTED. *PE
Pre-Delivery & Maintenance
65 bulletinsTechnical Service Bulletin for Load Dump Switch Inspection and Installation on Dometic Refrigerators
Important Campaign Information letter for DDC D24R4 - Campaign Reactivated
Important Campaign Information letter for DDC D24R4 - Campaign Inactivated
Important Campaign Information letter for DDC D23M3 - Campaign Reactivated and Extended.
Read full bulletin
Field Service Campaign D23M3 - GHG17 DETROITTM DD16 Vibration Damper Replacement has been extended for an additional 6 months.
Service Solution for SSAM Fault 520197/31 - MQ SwitchMalfunction Troubleshooting
Freightliner Service Bulletin for DEF Connector Reinforcement Caps.
Revised Warranty Information Letter for OWL and Warranty Manual Improvement: Sublets and Travel Time/Distance.
Read full bulletin
In the spirit of continuous improvement, DTNA reviewed sublet-related policies and procedures. The goal was to improve language clarity and optimize processes. Revisions are in blue font.
Revised Service Bulletin for DT12 PTO Upfit.
Read full bulletin
This bulletin replaces the version dated 09/13/2019. DDCSN and Power Service Literature references have been removed.
Technical Service Letter for SPN 3711 FMI 31 on GHG17 DD15 Trucks.
Important Campaign Information letter announcing Dealer Travel for Campaign Performance.
Read full bulletin
This letter is to announce a reimbursement available to dealers for travel to a customers location to perform a recall or field service campaign.
Warranty Information Letter for OWL and Warranty Manual Improvement: Sublets and Travel Time/Distance.
Read full bulletin
In the spirit of continuous improvement, DTNA reviewed sublet-related policies and procedures. The goal was to improve language clarity and optimize processes.
Warranty Information Letter informing that to ensure that DTNA policies and service network practices align, the...
Read full bulletin
Warranty Department will be revising the Warranty Manual.
Service Bulletin for Guidelines for Cleaning and Disinfecting Cab Surfaces.
Read full bulletin
The following guidelines are for cleaning and disinfecting commonly touched surfaces on the inside and outside of a vehicle. For best results, follow cleaning and disinfecting procedures fully and consistently. Ensure there is adequate ventilation when using chemicals. NOTICE: Wipe down fragile components carefully to avoid damaging the vehicle.
Service Bulletin for Chassis Side-Fairing Kickplate Magnet Replacement.
Read full bulletin
On Freightliner Cascadia and New Cascadia vehicles manufactured before May 20, 2019, and equipped with side-fairings, the magnets that hold the kickplate closed may corrode and prevent the kickplate from staying in the closed position.
Warranty Information Letter for Warranty Training Online.
Read full bulletin
DTNA is pleased to announce the release of new Warranty-related training videos. The videos provide Warranty content in short instructional videos that are available on demand through the AftermarkeTV Video Channel icon on the Aftermarket Resource Center (ARC) home page.
Warranty Policy Letter for Handling for Authorized Service Location Part Transfers.
Read full bulletin
To promote 24-hour throughput and maximum efficiency, DTNA is adjusting multiple handling policies: Launching a new handling allowance for parts ordered from another Authorized Service Location because the facing Part Distribution Center (PDC) is out of stock Retiring Detroit's Customer First Program
Open recall and Field service Campaigns report send out to Dealers, General Managers, Service managers and warranty...
Read full bulletin
managers.
Freightliner Service Bulletin for vibration troubleshooting - finding the cause.
Read full bulletin
This version replaces the version dated 5/1/14 and adds New Cascadia.
Warranty Policy Letter explaining the Warranty Department is aligning with the frame rail repair policy, published in...
Read full bulletin
DTNA Workshop Manuals, which states that there are very few cases in which welding a heat-treated frame rail is allowed. Therefore, before welding anything on a frame rail, contact the applicable regional service representative for approval.
Open recall and Field service Campaigns report send out to Dealers, General Managers, Service managers and warranty...
Read full bulletin
managers
Customer Advisory Letter that an inspection to determine if the high current breaker has been bypassed.
Service Solution to fix switch malfunction
Tool Letter for updating Cascadia and Western Star 5700 oil-to-air coolers.
Read full bulletin
To be used with service bulletins SB26-051 and SB26004 respectively.
Technical Service Letter communicating that information on DD Heavy Duty Platform Belt and Belt Tensioner can be found...
Read full bulletin
on TechLit.
Service Bulletin for DT12 PTO Upfit
Communication to assist the field with service vibration issues on DTNA vehicles
Warranty Policy Letter to communicate Detroit Return Changes
Warranty Information Letter to announce addition of Thomas Built Bus as a brand with an Authorized Demonstrator Program
Service Bulletin to address wiper issue.
Read full bulletin
On some Cascadia vehicles, when a request for wiper activation is made the wipers may not function. This can result from an overcurrent condition, which causes the wipers to stop functioning and immediately set fault code SPN 522215 FMI 6.
Service Bulletin to replace the white drip shield and secondary SAM cover on the SAM Cabin, with a new one-piece drip...
Read full bulletin
shield.
Service Information Bulletin was released, to add new procedures to address diagnostics near the high pressure pump
Warranty Information Letter sent to customers regarding new refrigerator supplier for returning parts.
Service Bulletin sent out customers describing procedure is to replace the white drip shield and secondary SAM cover on...
Read full bulletin
the SAM Cabin, with a new one-piece drip shield.
Service Bulletin provided to customers regarding ICU3 to ICU3S Replacement
Training Solution created by DTNA to provide guidance to customers when searching for service information for components...
Read full bulletin
and systems not owned by Daimler Trucks North America (DTNA).
Service Bulletin- sb54311 ICU Odometer Programming
Service Solution: 1033995, SPN 523005 FMI 7 and 524042 FMI 19 Fault Codes
Service Bulletin DT12 PTO Upfit
Service Solution: 1033995, SPN 523005 FMI 7 and 524042 FMI 19 Fault Codes
Service Bulletin DT12 PTO Upfit
Reminder: Paper Service Bulletin Mailings Are Discontinued
Service Information Bulletin
Important Campaign Information on FL614 Recall
Service Information Bulletin- Input Shaft Pilot Bearing Measurement Specification
Service Bulletin New "Natural Gas Vehicle Information" Webpage
Warranty Bulletin for charge back exemtions
Service information Bulletin -HDEP PLV Return Line Tool DSN470E17006
Service Information Bulletin for Aftertreamtent Failure Guide
Service Information Bulletin
Release of DiagnosticLink 8.08 Service Pack 2
If a GVWR certification label is lost or damaged, Freightliner will supply a duplicate label.
Read full bulletin
Log on to DTNAConnect.com and under "DTNAConnect Resources", select the "Tool and Services" plus sign. Select "Request for Certification Label or OWI." Fillout the form, then select "Review."
ICI18-014 Owner Notice ? Kidde Fire Extinguisher Recall
sb83155 Espar Service Information
ICI18-014 Owner Notice ? Kidde Fire Extinguisher Recall
Transport Dealer Air Leak Inspection
15-015 Warranty Exclusions Reminder
14-026-DLR SelecTruck Warranty Enhancements
Canadian Warranty Parts Return Address Change
OWL Enhancement Service Model Field
Warranty Classroom Training in 2018
12-041-DLR Over the Counter No Hassle Warranty (OTC)
_Warranty Recognition Program - Coming Soon
14WO-9_Warranty_Access Detroit New User Warranty Access Request
14TL9 Special Tool Warranty Program.
16TS14 EPA10 AND GHG14 SERVICE REPLACEMENT 1-BOX DOC INLET CHANGE
Transmission
32 bulletinsService Solution for DPF Harness Rub-Chafe onTrans-Wire Braided Air Hose.
Important Campaign Information Letter for DDC D21M1 Termination Date Extended.
Read full bulletin
This letter is to inform you that a revised bulletin for Detroit Diesel Field Service Campaign D21M1, DT12 Transmission Drive Shaft Cover Plug Reseal has been EXTENDED for an additional three months. Please use the extended termination date for all work under D21M1 from this point forward. REVISION: D21M1 termination date extended to July 1, 2022.
Technical Service Note on Intermittent loss of power steering assist, LH turn only for Cascadia.
Read full bulletin
Only intended for customers wishing to add a power steering oil cooler. For replacement of the gear reference TSN 46-01
INTERIOR STORAGE - Side Storage Bins Removed from Certain Cascadia Sleepers.
Read full bulletin
SEAT BELTS - Height Adjustment Removed from Cascadia Passenger Side Seat Belt. FUEL TANKS - Fuel Tank Changes for 25" and 23" Tanks for Model Year 2015. TRANSMISSION - Correction to Allison 5th Gen Module 84L Definition Example. ADMINISTRATION - Model Year 2015 Changeover Date Established. APPENDIX A - 25" and 23" Diameter Cylindrical Fuel Tank Changes. APPENDIX B - Revised Allison 5th Gen New Modules and Definitions
Service Solution for FTL DT12 Trans Control Harness Chaffing - PT Can faults.
Read full bulletin
Transmission will not shift into Gear while driving or will not start and trigger multiple PT CAN Fault Codes.
Detroit Field Service Campaign for DT12 Transmission Drive Shaft Cover Plug Reseal.
Read full bulletin
Daimler Trucks North America LLC, on behalf of its DETROIT Powertrain Division, is initiating Field Service Campaign D21M1 on certain DT12 transmissions in order to reseal the bypass plugs of the drive shaft cover located in front housing.
Tech Talk continuing discussion on DT12 TRYING TO DOWN SHIFT.
Discussion on DT12 trying to down shift
Revised Warranty Policy Letter for Alliance/Mascot Aftermarket Warranty and Claim Filing.
Read full bulletin
Revisions are in blue. With Mascot now in partnership with Detroit Reman and Alliance Parts, DTNA is pleased to announce that Mascot coverage has been added to OWL. Remanufactured Alliance/Mascot parts include transmission, differential, steering gear, and steering pump used in an on-highway vehicle applications. The Alliance/Mascot aftermarket warranty coverage period has not changed: depending on the part, coverage is for one (1) or two (2) years and current parts, labor, and reimbursement policies apply.
Warranty Policy Letter for Alliance/Mascot Aftermarket Warranty and Claim Filing.
Read full bulletin
With Mascot now in partnership with Detroit Reman and Alliance Parts, DTNA is pleased to announce that Mascot coverage has been added to OWL. Remanufactured Alliance/Mascot parts include transmission, differential, steering gear, and steering pump used in an on-highway vehicle applications. The Alliance/Mascot aftermarket warranty coverage period has not changed: depending on the part, coverage is for one (1) or two (2) years and current parts, labor, and reimbursement policies apply.
Tech Talk discussion on DT-12 WILL NOT GO INTO GEAR.
Service Bulletin for Lengthening the Backup Light Harness.
Read full bulletin
Though the backup light harness is long enough to connect to the backup light switch, it may be short enough that the wire seals in the connector can be stressed. Moisture entering through the seals can cause corrosion, resulting in a bad connection and/or failure of the switch. As a result, backup lights and, if equipped, the backup alarm, may not function when the vehicle is shifted into reverse.
Service Bulletin for DT12 Transmission Cooler Retrofit
Field Service Campaign for Remanufactured Detroit DT12 Transmissions
Warranty Policy Letter to communicate remarketing handling cap for Detroit DT12 Transmission.
D12 Transmission issue communication on Cascadia
TS 1033699: DT12 Transmission Driver Interview: Shifting Complaint Questionnaire
25-34 - Clutch-Related No-Start Diagnostics
0405-18 Symptom Diagnostics - Range Up or Down Shift Issue
sb60159 Shifter Adapter Plate for Replacement Cab or Cab FloorB
sb2074 Kysor Fan Clutch Rocking Runout Inspection
15TS15Rev Detroit? DT12? Transmission Proper Towing Procedure
sb2074 Kysor Fan Clutch Rocking Runout Inspection
Installation of the Transmission
Removal of the Transmission
Detroit? DT12? Transmission Proper Moving Procedure
FMI 2- Automatic Gear Selection - Incompatible or missing dataset
Clutch Release Bearing Grease Hose
sb4654 Rack and Pinion Steering Gear Retrofit Guide
15-010-DLR Transmission Cooler Line Photos
1105-14 Flywheel, Ring Gear and Flywheel Housing
FL693 EATON FR TRANSMISSION
Body & Paint
24 bulletinsOn Cascadia vehicles built from November 25, 2013, the drain holes at the bottom of the cab doors were enlarged to...
Read full bulletin
improve drainage during the e-coat process in the manufacturing plant. The larger holes allow more cold air to flow through the doors, most noticeably in extreme cold conditions.
On Cascadia vehicles built from November 25, 2013, the drain holes at the bottom of the cab doors were enlarged to...
Read full bulletin
improve drainage during the e-coat process in the manufacturing plant. The larger holes allow more cold air to flow through the doors, most noticeably in extreme cold conditions.
Freightliner Action Bulletin FAB145 New Cascadia Roof Fairing
Service Bulletin for Draining Water Trapped in the Upper A-Pillar.
Read full bulletin
A water leak in the seams between the cab roof and cab side wall or back wall can result in water becoming trapped in the upper A-pillar area in some Cascadia and New Cascadia vehicles. This water may migrate inside the cab and eventually spill through the marker light fastener clearance holes and drip on the dash.
Service Bulletin for Replacing Windshield Gasket.
Read full bulletin
Different types of cab leaks can result in water dripping from the top of the windshield, onto the dash. Replacing a windshield gasket unnecessarily may create new leak issues. Do not replace a windshield gasket unless it has been confirmed to leak, using the cab pressure test.
Customer Service Announcement Letter Revision for Dealers/Distributors Accessing DDEC Backdoor Passwords
Tool Letter for DT12 Seal Protector Sleeve
Warranty Information Letter - Expanded guidelines for paint-related claims sent out to Freightliner, Western star,...
Read full bulletin
Thomas Built Bus, Export and Direct warranty customers
Important Campaign Information- Cascadia Windshield Improvements
Service Bulletin 9818- Repainting Plastic Bumper Components
The right-hand cab panel on New Cascadia can come into contact with the right-hand chassis-side fairing when making a left turn.
Read full bulletin
This contact can result in an audible popping noise, paint-damage to the rocker panel and damage to the back-side of the chassis-side fairing.
0312-18 Installation Output Shaft Seal
sb9815 Paint Finish Standards
54-280 - Video Available for Servicing APEX 150 Sealed 16-Pin Connectors
sb60144 New Cascadia Windshield Seal, Adhesive, and Preparation
sb98020 Axalta Paint Finish CareB
sb9815 Paint Finish StandardsB
fp31028 Cascadia 14.5-Inch Hendrickson Aero-Clad Stainless-Steel Bumpers
sb54293 SAM Chassis Water Intrusion Prevention
sb9815 Paint Finish Standards
0312-18 Installation Output Shaft Seal
Cascadia Windshield Improvements
sb3130 Quarter Fender Reinforcement
12-040-DLR Roof Fairing Removal Program
Suspension
23 bulletinsFreightliner Action Bulletin FAB143 Load Transfer Suspension
TSN for all Cascadia vehicles equipped with an Airliner rear suspension and the HD 6-piece bolted style forward...
Read full bulletin
suspension crossmember - Cascadia vehicles equipped with an Airliner rear suspension and the HD 6-piece bolted style forward suspension crossmember.
Revised Freightliner Service Bulletin for Axle Flange Gasket Replaced with O-Ring.
Read full bulletin
Revision removed steps instructing removal and installation of wheels. Daimler Trucks North America has released a new axle shaft to hub rubber O-ring (part number 11-30728-000) as a replacement for the paper gasket (part number 11-14418-000). The new O-ring will provide better sealing and is reusable. It is quicker and easier to use compared to the paper gasket, because using a paper gasket requires cleaning the hub when the axle shaft is removed.
Freightliner Service Bulletin for Axle Flange Gasket Replaced with O-Ring.
Read full bulletin
Daimler Trucks North America has released a new axle shaft to hub rubber O-ring (part number 11-30728-000) as a replacement for the paper gasket (part number 11-14418-000). The new O-ring will provide better sealing and is reusable. It is quicker and easier to use compared to the paper gasket, because using a paper gasket requires cleaning the hub when the axle shaft is removed.
Freightliner Service Bulletin for Non-Airliner Rear Suspension Crossmember Fastener Change.
Read full bulletin
With the start of production on March 2, 2020, the fasteners used to assemble the non-Airliner rear suspension (bogie) crossmember have changed. The rear suspension bogie crossmember gussets to the C-channel will be assembled with 5/8 - 18 fasteners. This change includes a revision to a higher friction nut that requires an increase in tightening torque. The new higher friction nut can be identified by its green color.
Freightliner Service Bulletin for Front Axle Spacer Replacement.
Read full bulletin
This service bulletin replaces the version dated 05/01/2016. This bulletin is updated to include the parts list. Some vehicles may exhibit a lean (right or left) due to weight difference on the front suspension. While this does not affect the operation of the vehicle, it may be visually unpleasing to many customers. To correct this condition, replace the existing front axle spacer on the low side of the vehicle with a thicker one.
Field Service-New Cascadia Cab Air Shocks
Cascadia Radiator Strut Rod Rubbing on Upper Radiator Hose
Cascadia Radiator Strut Rod Rubbing on Upper Radiator Hose
Cascadia Radiator Strut Rod Rubbing on Upper Radiator Hose
Cascadia Radiator Strut Rod Rubbing on Upper Radiator Hose
Field Service-New Cascadia Cab Air Shocks
SS 1034171 Airliner Rear Suspension Chassis Lean Troubleshooting
Detroit DT12 Split Rod Bushing Repair letter to customer
Technical Service Note: Airliner Rear Suspension Main Crossmember Fastener Replacement.
Service Bulletin: AirLiner Suspension Six-Piece Bolted Service Crossmember
With the start of production on February 12, 2018, the fasteners used to assemble Airliner rear suspension crossmembers changed.
Read full bulletin
The forward-suspension crossmember will assembled with 5/8-18 fasteners and the rear-suspension (bogie) crossmember will be assembled with 3/4-16 fasteners.
33-28 - Bearing Spacer Replacement, ConMet PreSet Steer Hubs
35-30 - Bearing Spacer Replacement, ConMet PreSet Drive Hubs
Detroit? DT12? Split Rod Bushing Repair
Warranty Recognition Program Suspension
FL718 FRONT AXLE HUB RATING
FREIGHTLINER: ON THE UPPER RADIATOR HOSE, THE RADIATOR STRUT ROD IS RUBBING AND IF EVIDENCE OF RUBBING IS PRESENT, HOSE...
Read full bulletin
IS REPLACED, WITH ORIGINAL PART, AND REPLACEMENT STRUT ROD INSTALLED. MODEL CASCADIA. *PE
Brakes
19 bulletinsABS Light illuminating in the ICU.
End of Production for the Freightliner P3 Cascadia Sales Cabs.
Read full bulletin
Due to low production volumes, DTNA will be discontinuing the production of the Freightliner Cascadia P3 Sales Cabs.
Discussion on Cascadia brakes holding on
Freightliner Service Bulletin for Meritor Steer Axle Drum Brake Squeal.
Read full bulletin
Some Cascadia and New Cascadia vehicles equipped with Meritor steer axle drum brakes with a front axle rating less than 13,300 lb (6038 kg) have experienced brake squealing noise when the service brakes are applied at lower speeds. NOTE: This is a nuisance noise issue and not a failure. The solution given in this service bulletin may fix this issue.
Service Bulletin for Water Leak at the Top of a Cab Door, Cascadia Day Cab with FE13 Roof Fairing.
Read full bulletin
Some Cascadia day cabs with FE13 roof fairings may be more susceptible to water intrusion into the cab at the top of the cab door due to the way the air flows around the FE13 fairing. Water is pushed past the door seals while the vehicle is in motion, possibly resulting in water intrusion.
Service Bulletin for Windshield Wiper Repair and Programming on Model Year 2015 Vehicles with 125-inch Sleeper Cabs
sb42077 Steer Axle Brake Chatter
Steer Axle Brake Chatter
Service Bulletin- ABS Light Illuminating in the ICU, ABS Solenoids Not Self Checking
SS 1033322 ABS light illuminating in ICU, ABS solenoids will not self-check
FL756 Brake Light Pressure Switches
fsb42073 Inspection d'absence de fuites d'air par les transporteurs concessionnaires
FL756 Brake Light Pressure Switches
SS 1033322 ABS light illuminating in ICU, ABS solenoids will not self-check
sb4267 Brake Shimmy - Meritor SteeLite X30 Brake Drum with Excessive Runout
14TL5 ABS Power Line Carrier Converter Available Through PDC
Haldex Life Seal Brake Chambers
16TL3 Pocket iQ? ABS Product Family Kit is Available at PDC
sb4268 Brake S-Cam Tube Lubrication Interval Change
Software & Calibration
18 bulletinsCX Advocate for NOx conversion low faults.
Read full bulletin
Update to CXA 6_24_NOx submission.
Warranty Information Letter announcing DTNA is adjusting the Standard Repair Times (SRTs) shown.
Read full bulletin
The updated times will be applied to repair orders opened on or after April 5, 2021.
Updated Freightliner Service Bulletin for Espar Service Information.
Read full bulletin
This bulletin replaces the version dated January 1, 2015. New Cascadia has been added to the model list.
Starting on November 23, 2020, DiagnosticLink 8.13 (Build 4527) was made available.
Read full bulletin
Current subscribers of DiagnosticLink 8.11 or 8.12 may upgrade to DiagnosticLink 8.13 at no cost. All DTNA Service shops & OEM locations are required to maintain the latest version of software on each of their stations.
Tech Talk discussion Cascadia cruise control inop after Detroit software update.
OEM and distributor announcement for DiagnosticLink 8.12 (Build 4527) was made available.
Read full bulletin
All DTNA Service shops & OEM locations are required to maintain the latest version of software on each of their stations.
Customer Service Announcement for Release of DiagnosticLink 8.12.
Read full bulletin
On Wednesday, June 10, 2020, DiagnosticLink 8.12 will be made available for download from the ordering system. Current subscribers of DiagnosticLink 8.xx can upgrade to DiagnosticLink 8.12 at no cost. All DTNA service shops are required to maintain the latest version of software on each of their stations.
Warranty Information Letter updated to communicate warranty system updates.
Updates to troubleshooting guides in Diagnostic Link with newest version
1207-15 Updated procedures with adding EPA10 to the GHG14 title
12CSA18 Update to Fix Internet Explorer - A Script on this Page is causing Internet Explorer to Run Slowly Issue
Computer Hook-Up Standard Diagnostic Time Update
14-035_SRT_Update_for_Cascadia Detroit Standard Repair Time Updates for Cascadia Truck Models
14-035 Detroit Standard Repair Time Updates for Cascadia Truck Models
FINAL_15M1_BULLETIN GHG14 DD PLATFORM SOFTWARE REPROGRAMMING FOR AUTO ELEVATE
AEO15M3 GHG14 DD PLATFORM MODEL YEAR 2015 SOFTWARE REPROGRAMMING
AEO15M1 GHG14 DD PLATFORM SOFTWARE REPROGRAMMING FOR AUTO ELEVATE
16-032_DETROIT STANDARD DIAGNOSTIC TIME FOR GHG14 AFTERTREATMENT DEVICE CHECKLIST UPDATED
Lighting
18 bulletinsICUC Bulb check function.
Freightliner Action Bulletin FAB146 Cascadia LED headlights
Tech Talk discussion on P3 Cascadia tail lights stay on.
Customer Service Announcement for DiagnosticLink Software Update Reminder.
Read full bulletin
Due to various software changes and fixes, vehicles will require DiagnosticLink 8.12 to perform functional programming. Failure to use this version may cause errors, incomplete programming, and poor vehicle performance. Because of this, all DiagnosticLink 8.09 installed versions will be disabled as of Thursday, July 23, 2020.
Service Bulletin for Reflective Tape Installation.
Read full bulletin
If a truck tractor is ordered without mudflaps and/or mudflap support brackets, the rear reflective tape applied to the mudflaps or mudflap brackets during production is delivered loose with the vehicle. FMVSS/CMVSS 108 S5.7.1.4.3 requires reflective tape on all truck tractors domiciled in the United States and Canada.
Service Bulletin for Marker Light Gasket Leaks, Cascadia.
Read full bulletin
This bulletin replaces the version dated June 17, 2019. A procedure has been added for inspection, repair, and replacement of damaged or spun rivet nuts.
Warranty Policy Letter for Chassis Progressive Damage Policy Change.
Read full bulletin
Effective for repair orders opened on or after April 27, 2020, if an Authorized Service Location installed a part which later has a warrantable failure, progressive damage and labor may be covered under the Aftermarket Parts Limited Parts Warranty (Parts Warranty).
Warranty Policy Letter for Handling Change: Over the Counter Aftermarket Parts Replacement Program.
Read full bulletin
DTNA is pleased to announce that handling will increase to 33% for Misc. Replacement Part type claims filed under the Over the Counter (OTC) Aftermarket Parts Replacement Program.
Customer Service Announcement for a policy change regarding Detroit Service Information Bulletins (SIBs) will now have a...
Read full bulletin
60-day expiration, starting on the release day of the bulletin. The intent of a SIB is to notify the service network of a major change to one or more service procedures. Do not save SIBs nor reference them for repairs, as they are uncontrolled and never updated.
Marker Light Gasket Leaks, Cascadia
Accent / Park Light Function Disable Accent / Park Light Function Disable
SS1034234 Cascadia ICU4Me - Low Air Warning Light Not Coming On
Service Bulletin- Marker Light Leaks
Some vehicles may have been incorrectly shimmed at the factory, and may lean slightly to the right or left.
Read full bulletin
While this does not affect the operation of the vehicle, it may be visually unpleasing to many customers.
sb3133 Step Clamps Are Not Reusable
14-024-DLR DTNA & JAD Highlights - Q1 & Q2
14-036-DLR DTNA & JAD Highlights - Q3
MARKER LIGHT LEAKS
Steering
17 bulletinsFleet Communications for Power Steering Resevoir - NTF Replacements
Fleet Communications for Power Steering Reservoir Fill Cap Venting
Service Solution for Power Steering Reservoir Fill Cap Venting
Tech Talk discussion about power steering fluid.
Hendrickson 5 Inch Drop Axle Tie Rods Recall Bulletin
Hendrickson 5 Inch Drop Axle Tie Rods Recall ICI letter
Hendrickson 5 Inch Drop Axle Tie Rods
FL782 Detroit Steer Axle Tie Rods
SS 1033628 New Cascadia Ground Strategy -Steering Wheel Clockspring Failures
Adjusting Tilt Lock Force on TRW Steering Columns
Adjusting Tilt Lock Force on TRW Steering Columns
SS 1033628 New Cascadia Ground Strategy -Steering Wheel Clockspring Failures
Adjusting Tilt Lock Force on TRW Steering Columns
Adjusting Tilt Lock Force on TRW Steering Columns
Recall FL782- Detroit Steer Axle Tie Rods
Dealer Bulletin- FL782 Detroit Steer Axle Tie Rods
sb4641 Adjusting Tilt Lock Force on TRW Steering ColumnsB
Tires & Wheels
10 bulletinsFL782 Interim Recall Ending - Final Recall Beginning
sb3529 Axle Alignment Specifications
ICI15-003-DLR FL676 - Interim Recall Notice
FL721 Interim Recall Ending ? Final Recall to Begin
14TL-7Rev DD Platform Flywheel Housing Runout Tool W470589032100
17TL25 TruckCam? Alignment System
ICI12-028-DLR FL632 - Interim Notice
14TL7 DD Platform Flywheel Housing Runout Tool W470589032100
907-14 Installation and Removal of the Flywheel Housing
0902-16 SYMPTOM DIAGNOSTICS - BELT COMING OFF, SHREDDING OR MISALIGNMENT
HVAC & Climate
8 bulletinsRevised Freightliner Service Bulletin for ParkSmart Eberspaecher Auxiliary Heater Service.
Read full bulletin
This bulletin replaces the version dated May 2015. The note in General Information has been revised to include New Cascadia. Espar information has been changed to reflect a company name change to Eberspaecher.
Service Bulletin for A/C system receiver-drier replacement guidelines.
sb83160 HVAC Blend Door Retrofit
sb83145 ParkSmart Refrigerant Loop Service Kits
sb83114 Approved Leak Detection Methods for Air Conditioning
sb83145 ParkSmart Refrigerant Loop Service Kits
506-15 Air Compressor Coolant Lines
sb83137 ParkSmart?/Espar Auxiliary Heater Servic
Infotainment
7 bulletinsSS 1032974 High Oil Pressure on 2017 DTNA Vehicles Instrument Cluster Display
Service Bulletin revision to an earlier submission of SB54-308 for October 2019 (19MC2968).
Read full bulletin
The prior submission added new screenshots. This revision adds clarification for vehicle programming.
Service Solution to fix radio issues
DTNA Special Tools Group has approved the use of Haweka Axis4000 aftermarket alignment system for use on DTNA products at DTNA service locations.
Read full bulletin
The Axis4000 system uses the reference points required by DTNA for precise, accurate, and repeatable measurements. Axis4000 is a sophisticated, user-friendly system that utilizes computer based camera-radio technology and references the center line of the frame for measuring and providing alignment results to DTNA specifications.
sb4269 DEF Metering Unit Inlet Screen Clogging Due to Excessive Moisture in the Air System
sb4269 DEF Metering Unit Inlet Screen Clogging Due to Excessive Moisture in the Air System
- Tire Pressure Monitoring System (TPMS) Display Firmware Update
Hybrid & EV
5 bulletinsThe modified parked regeneration strategy has been standard on GHG17 units since the start of GHG17 production and was...
Read full bulletin
added to EPA10 and GHG14 units with a software update. The modified regeneration utilizes an improved strategy to clean the DOC inlet face and reduce downtime due to DOC face plugging.
18TS4Rev DD Heavy Duty Platform Accessory Drive Belt
15TS5Rev GHG14 DD Platform DEF Pump Leaks and Code 4374 FMI 0 Under Pressurized DEF System
SPN 3556 FMI 0, 1, 18 - Regeneration Temperature Update Procedures
ICI14-018-DLR Notice for Thermo King Power Inverter Recall
Air Bags & Safety
1 bulletinJoyson Safety Systems letter informing DTNA about Hikone Webbing Investigation.
Read full bulletin
JSS is near completion of an initial investigation regarding data integrity issues at the seatbelt webbing manufacturing facility in Hikone, Japan acquired from Takata in April of 2018.