2012 Freightliner Cascadia TSBs
812 Technical Service Bulletins across 17 categories
Categories
Other
296 bulletinsSAM Cab & SAM Chassis Wall Charts
Cascadia Fault codes 6.0
Odometer racks up mileage when the vehicle is stationary - Cascadia
SS 469068 Cascadia SAM Cab, SAM Chassis, MSF and CGW Hardware Compatibility
SS 1033121 Adding a Fan Override Switch (Legacy Cascadia)
Freightliner Action Bulletin FAB158 Cummins Eaton SmartAdvantage
Freightliner Action Bulletin FAB154 New options for Cascadia
Tech Talk discussion on P3 Intermittent 250k J1939 Failure.
Tech Talk discussion on repair verification for codes like 'low air flow' when a trailer is not available.
Tool Letter for ICC5 Programming Cable
Installation of Vortex Generators
Revised Bulletin
Rear PTO Pump Support CA
ICI19-011 FL782 - Revised Bulletin
fp00024 Cable-Tie Reference
Letter to customer on Coverage Extension GHG17 After Treatment
SPN 3226 (ACM) (GHG17)
SPN 96 (MCM) (GHG17)
SPN 3226 (ACM) (GHG17)
Diagnostic tests - Two Filter System - FSIC Leak Test
SPN 3464 (MCM) (GHG14)
SPN 712 (CPC) (GHG17)
Letter to customer on Coverage Extension GHG17 After Treatment
SPN 3226 (ACM) (GHG17)
SPN 96 (MCM) (GHG17)
SPN 3226 (ACM) (GHG17)
Diagnostic tests - Two Filter System - FSIC Leak Test
SPN 3464 (MCM) (GHG14)
SPN 712 (CPC) (GHG17)
Technical Publications Ordering
DT12 PTO Upfit
SPN 3226 (ACM) (GHG17)
SPN 96 (MCM) (GHG17)
Diagnostic tests - Two Filter System - FSIC Leak Test
SPN 3464 (MCM) (GHG14)
SPN 712 (CPC) (GHG17)
Meritor Wabco Bench Programming Kit DWA4008509600
Instructions for CSC Diagnostic Support
Towing Procedures
ICU3 to ICU3S Replacement Guidelines
Operating Hours for the Customer Assistance Center
Vehicles with Meritor drivelines bene from a softer durometer center bearing support.
Read full bulletin
Vehicle will continue to have a 1st order driveline vibration after the driveline assembly was rebalanced.
0505-18 SPN 3563 HDEP Inlet manifold pressure Too Low
sb54299 ICU3 to ICU3S Replacement Guidelines
fp00020 Replacing Gross Vehicle Weight Rating (GVWR) Certification Labels
SS1033446 Driveline Support Bearing - Meritor Driveline
0505-18 SPN 3563 HDEP Inlet manifold pressure Too Low
0401-18 SPN 1231 (MCM) (EPA10 GHG14)
sb4932 DEF Gauge Reading Incorrectly
528-13 SPN 3246-FMI 0 - EPA10 - GHG14
527-13 SPN 190-FMI 15,17 GHG14
525-13 SPN 2791-FMI 7 ? ALL YEARS
518-13 SPN 4334-FMI 4 - GHG14
Issues with PTO and Remote Throttle Combinations
0105-15 SPN 102 (MCM) (GHG14)
0108-15 SPN 1323 through 1328 (MCM) (GHG14)
0106-15 SPN 3251 (ACM) (EPA10) and (GHG14)
0104-15 SPN 3464/ FMI 16, 18 (MCM) (GHG14)
0101-15 SPN 4364 (ACM) (EPA10)
0107-15 Enhanced Steam Clean
ICI15-002-DLR SF503 Revised Bulletin
54-279 - Intermittent Communication Between the TrailerTRACS Transmitter and the Qualcomm Unit
(CPC)(EPA10-GHG14) and SPN 98 (CPC)(GHG17)
sb54215 ICU4M Missing VORAD Information or Reporting Fault SA 42 SPN FMI 07
418-13 SPN 2791-FMI 12 - GHG14
603-13 SPN 84 -FMI 6 - EPA07-GHG14
706-13 SPN 157-FMI 10, 15, 17, 18 - GHG14
709-13 SPN 2798-FMI 4-EPA10-GHG14
716-13 SPN 3226-FMI 13 - EPA10 - GHG14, SPN 3216-FMI 13 ? EPA10, SPN 3216-FMI 13 - GHG14
713-13 SPN 4334-FMI 7 - EPA10
sb4269 Excessive Moisture in the Air System
Replacing or Upgrading Airliner 40K Transverse Torque Rods
DT12 PTO Upfit
324-15 External Component Repair
304-15 Diagnostic Tests
303-15 Contaminated Fluids
323-15 Symptom Diagnostics ? Noise
306-15 SPN 3246 (ACM)(EPA10;GHG14)
309-15 SPN 3251 (ACM)(EPA10)
307-15 SPN 3480 (MCM) (EPA07;EPA10;GHG14)
301-15 SPN 3251 (ACM) (EPA10) and (ACM) (GHG14), 3936 (ACM)
522-14 Removal and Installation of the Oil Pump Cover
518-14 FMI 1, 18: Regen Temperature- Out Of Range Low
519-14 FMI 1: SCR NOx Conversion Efficiency Very Low
502-14 FMI 4 SCR Inlet Temperature High
607-13 SPN 3361-FMI 7- EPA10
sb4269 Excessive Moisture in the Air System
0401-18 SPN 1231 (MCM) (EPA10 GHG14)
sb54215 54-215 - ICU4M Missing VORAD Information or Reporting Fault SA 42 SPN 639 FMI 07
sb31034 Towing ProceduresB
sb3329 Caster Angle Specifications, Cascadia vs.
Read full bulletin
New CascadiaB
sb3251 Replacing or Upgrading Airliner 40K Transverse Torque RodsB
sb2652 DT12 PTO UpfitB
sb2083 FluidXchange Tool and FittingsB
sb00042 Flood Damage Repair GuidelinesB
sb0039 New Natural Gas Vehicle Information WebpageB
fsb4269 Humidit excessive dans le systme d'air
13WO-2-New Standard Rpr Times orgl 11WO2 New Standard Repair Times for EPA07-10 DD13-15 Diagnostic Tests
FL631-DLR Perpendicular Aluminum Air Tank Mounting Brackets
ICI13-001-DLR FL631 - Revised Bulletin
13TS12 HDEP Wastegate Solenoid Air Leaks
13TS8 GHG14 Throttle Codes SPN 91-FMI 7 and SPN 91-FMI 10
311-13 SPN 651-FMI 3 - EPA10 - GHG14
303-13 SPN 3242-FMI 4 -EPA10 - GHG14
301-13 SPN 5018- FMI 18 -GHG14
sb3132 Cascadia Chassis Side Fairing Lower Air Deflector Retention
808-13 FMI 0 Under Pressurized DEF System
802-13 FMI 18 Coolant Level Low
803-13 FMI 10,18: Intake Throttle Position Abnormal Rate of Change, Position Data Valid but Below Normal Operating Range...
Read full bulletin
- Moderately Severe Level
803-13 FMI 2: Intake Throttle Position Deviation Error
1118-12 SPN 705-FMI 5 - GHG14
1113-12 SPN 3226/FMI 20 - GHG14
ICI12-026-DLR SF471 - Second Revised Bulletin
ICI12-025-DLR SF471 - Revised Bulletin
sb3131 Huck-Spin 2 Changeover
13TS2 Single-Speed Fan Operation on Cascadia Vehicles
102-13 SPN 84-FMI 13, 19, 21 (MCM) EPA10-GHG14
107-13 SPN 84-FMI 7 - GHG14
106-13 SPN 100-FMI 10 - GHG14
105-13 SPN 625-FMI 13 - GHG14
135-13 SPN 1243-FMI 14 - GHG14
104-13 SPN 1592-FMI 13 and 19 - GHG14
137-13 SPN 2798-FMI 4 - EPA10 - GHG14
109-13 SPN 3250-FMI 31 (ACM2.1) GHG14
139-13 SPN 3251-FMI 0, 16, 20, 21 GHG14
108-13 SPN 3364-FMI 18 - GHG14
101-13 SPN 3563 FMI 21 - GHG14
132-13 SPN 3597-FMI 4 - EPA10
146-13 SPN 4335-FMI 1 EPA10
133-13 SPN 4375-FMI 4 and 5 - GHG14
112-13 SPN 4364-FMI 18 - GHG14
111-13 SPN 4374/FMI 0, 1, 3, 4 - GHG14
110-13 SPN 5435-FMI 7 - GHG14
128-13 SPN 511403-FMI 0,1,2,3,4,5,6,8,9,10,11,12,13,14
103-13 SPN 520328-FMI 7 - GHG14
sb8844 Braces for Cascadia Cab-Mounted Splash Shields
sb0934 EPA10 Cummins ISX Air Intake Heat Shield Removal
0204-15 Symptom Diagnostics: Noisy One-Box Aftertreatment
0203-15 Oil Filter Stand Pipe
704-15 SPN 4364 (ACM)(EPA10)
706-15 SPN 1323 (MCM) (GHG14) SPN 1324 (MCM) (GHG14) SPN 1325
sb54291 Detroit Assurance Lane Departure Warning Camera
sb54292 Nexiq USB-Link Upgrade and Diagnostic Connector
sb3531 Differential Lubrication, Detroit Model 6 Axles
805-15 FMI 0: Selective Catalyst Reduction Outlet Temperature High
sb4932 DEF Gauge Reading Incorrectly
Power Take-Off
Power Take-Off
SPN 157 (MCM) (GHG17)
DD Heavy Duty Platform Belt and Belt Tensioner
SPN 1663 (CPC) (EPA07 10 GHG14 GHG17)
0141-17 SPN 2659 (MCM) (EPA10)
0115-17 SPN 3226 (ACM) (EPA10;GHG14)
0114-17 SPN 2791 (MCM) (EPA07;EPA10)
0113-17 SPN 3361 (ACM) (EPA10)
1207-16 SPN 4363 (ACM) (EPA10 GHG14)
1213-16 SPN 3480 (MCM) (EPA07;EPA10 GHG14)
15TS16Rev1 EPA10 Reman MCM Improvement for Fault Codes SPN 651 to 656
1202-15 Symptom Diagnostics - ATD Checklist
SPN 2623 (CPC)(GHG17), SPN 2623 (CPC)(GHG14), and SPN 2623 (CPC)(EPA07 EPA10 GHG14)
aeo12C3-DocTrac -Final
849-12 SPN 3873-FMI 3 and 4
848-12 SPN 3872-FMI 3 and 4
847-12 SPN 3870-FMI 3 and 4
846-12 SPN 3869-FMI 3 and 4
845-12 SPN 3868-FMI 3 and 4
844-12 SPN 3867-FMI 3 and 4
843-12 SPN 3866-FMI 3 and 4
842-12 SPN 3864-FMI 3 and 4 - GHG14
830-12 SPN 520326-FMI 4 - GHG14
818-12 SPN 520296-FMI 19 and 31 - GHG14
815-12 Installation of the Oil Cooler
811-12 SPN 411-FMI 3
810-12 SPN 3842-FMI 3, 4, and 5 (CPC4)
809-12 Removal and Installation of the GHG14 1-BOX From the Vehicle
805-12 SPN 4354-FMI 5, 4356-FMI 5, 4355-FMI 5, 4357-FMI 5
804-12 SPNs 4354-FMI 5, 4355-FMI 5, 4356-FMI 5, 4357-FMI 5
803-12 SPN 4360-FMI 10, 15 (ACM2.1)
802-12 SPN 520328-FMI 7 - GHG14
801-12 SPN 1761-FMI 9 - GHG14
12C3bul-DocTrac - Final
12C3 - Instructions-DocTrac -Final
12-022-DLR Daimler Trucks Remarketing Corporation (DTR) Now Requires Pre-approval for Repairs $1,200 (USD) and Greater
15TS3 Detroit? Coolant Change From Nitrite Organic Acid Technology
405-15 Symptom Diagnostics - Hard Start/No Start - Two-Filter System
406-15 SPN 97 (MCM) (EPA10) / SPN 97 (MCM) (GHG14)
403-15 SPN 677 (MCM)(EPA07)
402-15 SPN 2630 (MCM)(EPA10) and SPN 2630 (MCM)(GHG14)
404-15 SPN 4364 (ACM) (EPA10)
15CSA10 The Detroit CSC announcing a new feature ? Ability to attach files to an existing CSC
15CSA9 Release of DiagnosticLink 8.02
sb54291 Detroit Assurance Lane Departure Warning Camera
505-15 SPN 3361 (ACM) (EPA10)
507-15 SPN 1590( CPC)(GHG14) and SPN 1590 (CPC)(EPA07;EPA10)
508-15 SPN 625 (MCM)( EPA10;GHG14)
sb8217 82-17 - Wiper Blade Replacement to Reduce Ice Accumulation On Passenger-Side Wiper, Cascadia Vehicles
sb2083 FluidXchange Tool and Fittings
15-009_Detroit_New_SDTs
15TL5 DAVCO Shop Pro FXP 95
324-15 External Component Repair
304-15 Diagnostic Tests
303-15 Contaminated Fluids
323-15 Symptom Diagnostics ? Noise
306-15 SPN 3246 (ACM)(EPA10;GHG14)
309-15 SPN 3251 (ACM)(EPA10)
307-15 SPN 3480 (MCM) (EPA07;EPA10;GHG14)
301-15 SPN 3251 (ACM) (EPA10) and (ACM) (GHG14), 3936 (ACM)
15CSA4 Holiday Schedule for the Detroit Customer Support Center
713-14 Symptom Diagnostics - Combustion Gas in Coolant
715-14 Symptom Diagnostics - Coolant Los
14-028 Remy Extended Coverage Direct File
14-027 Detroit's New Consolidated Labor Operations (CLOs
14-023 Detroit Axles Pre-Approval Changes
14-022 Pre-Approval Threshold Increase From $2,500 to $5,000 USD
54-215 - ICU4M Missing VORAD Information or Reporting Fault SA 42 SPN 639 FMI 07
16TL4 DOC Face Cleaning Tool P N W470589239100
16TS6 Variable-Speed Fan Operation on Cascadia Vehicles
16TS5 Release of the DD Platform Bearing Failure Guide
0304-16 SPN 2791 (MCM) ( GHG14) and SPN 2791 (MCM) ( GHG17)
0307-16 SPN 723 (MCM) March
0301-16 SPN 625 (CPC) (EPA07) and SPN 625 (CPC) (EPA10 GHG14)
Contaminated Fluids
Hydrocarbon Doser Coolant Lines
16-009R_OWL Enhancements
New Detroit Bearing Failure Analysis Standard Diagnostic Time
17-026 Holiday Closure 2017
17TL27 Injector Cup Tool DSN930E17001
17TL26 Injector Heat Sleeve Removal Tool DSN930E17002
17CSA25 New Method for Uploading Diagnostic Log Files to the CSC
17CSA24 Holiday Schedule for the Detroit Customer Support Center
17CSA23r Detroit CSC closed December 14, 2017 from 11:15 am - 1:15 pm Eastern Time
SF551 ? Revised Bulletin
Cascadia 2020 DRM Air Tank Mounting Brackets
sb83149 ParkSmart Interconnect Controller Logic Loss
12-039-DLR OWL Pre-approval's Time Frame Increases to 60 Days
15-028 New Detroit Coolant Line SRTs
Detroit Data Summaries Application and Kits Are No Longer Available Through PDC
901-15 Oil Breather Vent
_NewDetroitCoolantLineSRTs
- Detroit Assurance Lane Departure Warning Camera Installation
13wo3rev2_final Actual Labor Hours on Detroit Claims
0229-14 Symptom Based Diagnostics - Oil Separator
0233-14 SPN 51 FMI 2 - All Years
0224-14 SPN 1590 FMI 9 - CPC- All Years February 2014
0201-14 SPN 1761 FMI 3, 4 (ACM2-EPA10) (ACM2.1-GHG14)
0207-14 SPN 3031 FMI 3, 4 (ACM) (EPA10 - GHG14)
0226-14 SPN 3216 FMI 3, 4 (ACM2)(EPA10)
0216-14 SPN 3363 FMI 1 - ACM - EPA10 - GHG14
0222-14 SPN 4334 FMI 7 (ACM) (EPA10)
0227-14 SPN 4335 FMI 7 - EPA10
0230-14 SPN 4375 FMI 6 - EPA10
14-017R Revised: Detroit Addition of Admin Time
14-029 New Detroit Standard Diagnostic Times
FL662.-DLR Meritor MSF12 Non-Conforming Front Axle Beams
54-264 - Cascadia Virtual Technician Retrofit
14-038_New_SRTs Additional Detroit Standard Repair Times.
14-039_additional_SDTs New Detroit Standard Diagnostic Times
14TL8 TorcUP? Non-Impacting Torque Tool.
14TS28 DD Platform Belt Drive System - Belt Part Numbers and diagnostics
1003-14 Rough Running or Stalling.
1009-14 SPN 5016 (ACM) (GHG14)
1007-14 SPN 5016/FMI 3, 4 (ACM) (EPA10)
1006-14 SPN 4374 (ACM) (GHG14)
1008-14 SPN 3510FMI 4,7, and 8 (CPC)(GHG14)
1010-14 SPN 2623 (CPC) (GHG14)
14CSA23 CSC Announces ?Tech Tips? ? DDCSN
14CSA21 Holiday Schedule for the Detroit Customer Support Center ?
14-039 New Detroit Standard Diagnostic Times
14-038 Additional Detroit Standard Repair Times
sb2080 Australian CST M1400 Isolated Radiator Retrofit
sb0039 New "Natural Gas Vehicles Information" Webpage
1108-14 SPN 636 (MCM) (EPA07;EPA10;GHG14)
18SP711 DD15 and DD16 Axial Power Turbine Bracket Ki
SF501-DLR Perpendicular Steel Air Tank Mounting Brackets
sb4271 Rear Axle S-Cam Support Bracket Replacement
912-14 Coolant in Oil
920-14 Additional Cleaning and Preparing
906-14 Installation of the Oil Pan
917-14 Installation and Removal of the Oil Filter Stand Pipe
SB54291 DETROIT ASSURANCE LANE DEPARTURE WARNING CAMERA INSTALLATION
1021-16 SPN 110 (MCM)(EPA07EPA07;GHG14), SPN 110 (CPC)(GHG14)
1018-16 SYMPTOM DIAGNOSTICS - NOISE
16TS18 EPA10 AND LATER DD AUTO-ELEVATE FEATURE
0810-16 SYMPTOM DIAGNOSTIC NOISE
0809-16 SYMPTOM DIAGNOSTICS : NOISY 1- BOX AFTERTREATMENT
CASCADIA VIRTUAL TECHNICIAN RETROFIT
0612-16 SPN 175 (MCM) (GHG17) AND SPN 175 (MCM); ( EPA07;EPA10;GHG14) DIAGNOSTIC PROCEDURE
0611-16 SPN 110 (MCM) (GHG17) AND SPN 110 (MCM); (EPA07;EPA10;GHG14) DIAGNOSTIC PROCEDURE
0610-16 SPN 111 (CPC) (GHG17) AND SPN 111 (CPC); (EPA07;EPA10;GHG14) DIAGNOSTIC PROCEDURE
0609-16 SPN 174 (MCM) (GHG17), SPN 174 (MCM) (EPA07), SPN 174; (MCM) (EPA10), AND SPN 174 DIAGNOSTIC PROCEDURE
0605-16 SPN 625 (CPC)(GHG17) AND SPN 625 (CPC) (EPA10;GHG14) DIAGNOSTIC PROCEDURE
0601-16 SPN 103 (MCM) (GHG17) AND SPN 103 (MCM); (EPA07;EPA10;GHG14) DIAGNOSTIC PROCEDURE
DAIMLER TRUCKS: RADIATOR RESONANCE RESULTS IN TUBE FRACTURES COOLING AND LEAKAGES AND OCCURS IN TRUCKS CONFIGURATIONS AT CERTAIN OPERATIONAL SPEEDS.
Read full bulletin
*PE
FREIGHTLINER: THE CHASSIS SIDE FAIRING LOWER DEFLECTOR RETENTION.
Read full bulletin
THE C-CLIPS THAT ARE ATTACHED TO THE CHASSIS SIDE FARING LOWER AIR DEFLECTORS MAY BECOME LOOSE. *JS
FREIGHTLINER: ISRINGHAUSEN SEAT SLIDE STOPS.
Read full bulletin
THIS IS CAUSING THE SEAT TO RIDE UP OVER THE STOP. THIS COULD CAUSE THE SEAT TO GET STUCK IN THE AFT POSITION AND CANNOT BE ADJUSTED FORWARD. *KB
FREIGHTLINER: INFORMATION PROVIDED FOR REPLACEMENT HARDWARE PARTS FOR A SAM CHASSIS OR A SAM CAB.
Read full bulletin
*PE
Engine
106 bulletinsCascadia - Engine Will Not Crank (No Starter Output from SAM Cab)
Warranty Information Letter for Detroit New Service Replacement Engine SRT Update.
Read full bulletin
While validating Standard Repair Times (SRTs) for Detroit's new Gen 5 engine series, DTNA discovered an error in a pre-Gen 5 SRT for the New Service Replacement Engine Program. As a result, DTNA re-studied the SRT and concluded that time for removing/re-installing multiple components (e.g., exhaust manifold/turbo, engine sensor harness, rocker arm assemblies, etc.) should not be included.
Tech Talk discussion on truck came in with check engine light.
Read full bulletin
spn 4334/fmi 7 def pressure low.
Service Solution for P3 - CEL On and Engine de-rate due to ATD Chassis Harness Circuit 532M5+ at DEF Heater Supply location is shorted.
Read full bulletin
Harness part number A66-03217-002 has been reported experiencing failures due to damages to 532M5+ circuit shorting /or corrosion in terminals at Connector (23-13053-200) harness location "ATD_CHAS_F_O_HTR_LINE_DEF_5B" .
Training Solutions for Fuel Leak Found at High Pressure Fuel Pump Weep Hole for Heavy Duty DD Engines.
Read full bulletin
Occasionally we see trucks come in with fuel leaking from the high pressure fuel pump weep hole. This is NOT a defect in the pump and further diagnostics need to be performed to find the root cause.
Warranty Information Letter for Warranty Long Block Program Change.
Read full bulletin
The Detroit Reman Long Block Program has expanded. The expansion reduces complexity in ordering reman engines and promotes stocking reman engines to meet uptime commitments.
Service Bulletin to fix wiper motor issue.
Read full bulletin
On some Cascadia wiper park brush that rides against the brush plate may wear and may result in a diminished wiper park signal.
This service kit includes all necessary parts to replace the high pressure fuel rail feed lines, mounting bracket,...
Read full bulletin
P-clips and mounting hardware in the event one of these parts are loosened, removed or missing from the engine.
Service Solution: 1034298 - New Cascadia Engine Harness Chafe at A06-95037-000 Bracket
Cylinder Liner - Testing of the Cylinder Liner Upper O-Ring
Cylinder Liner - Testing of the Cylinder Liner Upper O-Ring
Cylinder Liner - Testing of the Cylinder Liner Upper O-Ring
Service Information Bulletin- Oil Present at the Turbocharger Compressor Housing
New Detroit Diesel Cylinder Liner Upper O-Ring Leak Test Standard Repair Time
Engine Manufacturer Diagnostics
DD13, DD15, DD16 Check Engine Light Flashing or Blinking
532-13 Description and Operation of the Two-Stage Valve - Two-Filter Systems
531-13 GHG14 DD15 Asymmetrical Turbocharger
520-13 Cylinder Block
GHG14 DD Engine EGR System Fault Codes
GHG14 472906S Turbocharger Compressor Inlet
15TS4 EPA07 DD15 Piston Kits
15TS2 EPA07 and EPA10 DD Platform Engines With Low Oil Pressure Codes
15TS1 GHG14 DD Platform Engines With Codes SPN: 1323 through SPN: 1328, FMI: 31, Idle Smoothness Control/Cylinder...
Read full bulletin
Misfire At Idle
GHG14 - Intake Manifold Pressure Too Low
GHG14 Intake Manifold Pressure Too Low
sb0935 Replacing the Engine Air Filter Element, Donaldson Air Cleaner (03-33648-001-002)
0202-17 DD13, DD15, and DD16 Cylinder Head Assembly Removal and Installation
308-15 Symptom Diagnostics - Oil Present at the Turbocharger Compressor
302-15 Crankshaft Oil Seals
18SP706 Replacement of the High Pressure Fuel Pump Camshaft Oil Seal
524-14 FMI 0: Engine Speed High
506-14 506-14 Removal and Installation and Inspection of the Exhaust Gas Recirculation Valve Actuator Pull Rod
sb0006 Freightliner Courtesy Engineering PolicyB
13TS6 DD Platform Engine Oil Filter.pdf
207-13 Removal and Installation of the Camshaft Housing
18SP693 EPA07-10 Fuel Rail Clamp Service Kit (P-N A4720780335) for DD Platform-Three-Filter Fuel System Engines
305-13 GHG14 DD15 Asymmetrical Turbocharger Flanged Exhaust Manifold
18SP701 GHG14 Two-Filter Fuel System KM63 GEN2 DD15AT Engines High Pressure Fuel Feed Lines PN A4730704432
83-144 - Optimized Idle and Auxiliary Cab Heater Concurrent Operation
148-13 GHG14 DD15 Asymmetrical Turbocharger Exhaust Manifold
15TS6 Replacement of the High Pressure Fuel Pump Camshaft Oil Seal
83-144 - Optimized Idle and Auxiliary Cab Heater Concurrent Operation
15TS14 GHG14 DD Engine Cylinder Liner Seal Replacement
708-15 High Pressure Fuel Pump Camshaft Oil Seal - Two-Filter System
711-15 High Pressure Fuel Pump Camshaft Oil Seal - Three-Filter System
702-15 DD15 and DD16 Delphi Exhaust Gas Recirculation Valve Actuator
703-15 GHG14 DD15 AT Exhaust Gas Recirculation Valve Actuator
803-15 Removal of the Camshaft Housing
0120-17 Diagnostic Test - Engine Oil Leaks - Oil Developer Method
0118-17 Symptom Diagnostics - Oil Leaks
15TL24 OTC 1750 Revolver Engine Stand
15TS4_Rev2_ EPA07 DD15 Piston Kits
1210-14 Cylinder Head
1201-15 Crankshaft and Bearings
FMI 3 Engine Oil Pressure Sensor Circuit Failed High
Inspection of the DD13 Turbocharger
12TS14 Repair Facility Input on GHG14 Engine and Aftertreatment System Issues
15TS10Rev DD Engine Platform Coolant Filter
401-15 Cylinder Block
501-15 Engine Lifter Brackets
504-15 DD13 Exhaust Gas Recirculation Valve Actuator Pull Rod
511-15 DD15 and DD16 Exhaust Gas Recirculation Valve Actuator Pull Rod
503-15 DD13 Exhaust Gas Recirculation Valve Actuator
sb2084 OAT Coolant Replaces NOAT Coolant in Detroit Engines
15TL4 W470589050900 ? 3/8? Drive GEN2 Two-Stage Valve Socket
308-15 Symptom Diagnostics - Oil Present at the Turbocharger Compressor
302-15 Crankshaft Oil Seals
18SP706 Replacement of the High Pressure Fuel Pump Camshaft Oil Seal
sb01101 Pilot Bearing Spacer for Detroit Engines with Eaton transmissions
14TL2 DD Platform Engine Stand Adapter W060589023100
714-14 Symptom Diagnostics - Low Engine Compression
712-14 Engine Coolant Temperature
20-73 - CANCELED: Cascadia Radiator Update?EPA10 with DDC Engines
20-75 - CANCELED: Cascadia Radiator Update?EPA10 with Cummins ISX Engines
16TS8 DD13 Cylinder Head and Cylinder Head Gasket Change
16-011 New Detroit Camshaft Housing Seal Standard Repair Time
903-12 Installation of the Intake Throttle Valve and Adaptor.pdf
sb4724 Crank No Start, Loss of Engine Prime on Decked Vehicles
12-038-DLR - No Problem Found - Policy Claims - During Basic Vehicle Chassis or Base Engine Coverage
14TS4 Valve and Liner Installation Tool Issue
0228-14 Engine Oil Leaks - Oil Dye Method
0237-14 Engine Brake Solenoid
14TS21 HDEP Camshaft Position Sensor Change
14-040_Additional_CLOs Additional Detroit CLOs for the Heavy Duty Engine Platform
14CSA20 EGR Valve Actuator Kit P/N E23539699
14-040 Additional Detroit CLOs for the Heavy Duty Engine Platform
1102-14 DD13 Cylinder Head R&R
1101-14 DD15 and DD16 Cylinder Head
14TS26 Replacement of the High Pressure Fuel Pump Camshaft Oil Seal
913-14 Checking for Poor Engine Brake Performance
915-14 Backwards Running Engine Detecte
18SP706 Replacement of the High Pressure Fuel Pump Camshaft Oil Seal
18SP701Rev3 GHG14 Two-Filter Fuel System KM63 GEN2 DD15AT Engines High Pressure Fuel Feed Lines, Mounting Bracket and...
Read full bulletin
P-clips Service Kit
35-23 - Breather Oil Leak on Freightliner Tandem Rear Axles
16TS24 GHG14 DD Platform Engines With Code SPN: 3216/FMI 18, SCR Inlet NOx Sensor Drift Low
SB0006 FREIGHTLINER COURTESY ENGINEERING POLICY
1017-16 ENGINE MODEL AND SERIAL NUMBER DESIGNATION
16TL20 HEAVY DUTY ENGINE VALVE STEM SEAL INSTALLING DRIFT AND SLEEVE
0909-16 EXCESSIVE OIL CONSUMPTION
DAIMLER TRUCKS: EXHAUST TAILPIPE TERMINATING NEAR CNG TANK PROTECTOR RELIEF VALVE AND CONTINUAL HEATING OF EXHAUST...
Read full bulletin
DISCHARGE RESULTS IN CNG VENTING AND HAVING TAILPIPE EXTENSION INSTALLED, AND AWAY FROM CNG TANK PROTECTION RELIEF VALVE. MODEL 2012-14 CASCADIA.
FREIGHTLINER: INFORMATION REGARDING THE REPLACEMENT LINE WITH A NEW ASSEMBLY CONNECTING THE MANIFOLD WITH A HOSE AND...
Read full bulletin
HOSE BARB, IN THE EVENT HEATER RETURN PIPE (HT2 LINE) FAILS ON THE ENGINE. MODEL CENTURY CLASS CONVENTIONAL, COLUMBIA, CASCADIA. NO YEARS LISTED. *PE
FREIGHTLINER: REPLACEMENT OF THE ENGINE AIR FILTER ELEMENT.
Read full bulletin
IF THE AIR FILTER IS INSTALLED IMPORPERLY IT COULD CAUSE ENGINE DAMAGE OR FAILURE. *KB
FREIGHTLINER: SOME VEHICLES WERE NOT DESIGNED TO ALLOW THE OPTIMIZED IDLE AND THE AUXILIARY CAB HEATER TO OPERATE AT THE SAME TIME.
Read full bulletin
MODEL CASCADIA BUILT AFTER APRIL 2, 2010. *JS
FREIGHTLINER: BECAUSE OF A CRACK IN THE COOLANT TUBE, SOME VEHICLES MAY HAVE A RADIATOR FAILURE CAUSING A COOLANT LEAK.
Read full bulletin
THE RADIATOR NEEDS TO BE REPLACED. *JS
FREIGHTLINER: PARKSMART WITH DDC OPTIMIZED IDLE.
Read full bulletin
DETROIT DIESEL OPTIMIZED IDLE AFFECTS THE WAY PARKSMART OPERATES. *JS
Fuel System
106 bulletinsWarranty Information letter announcing that DTNA is increasing the Standard Diagnostic Times (SDTs) shown.
Read full bulletin
The updated after treatment system (ATS) diesel exhaust fluid (DEF) pump times will be applied to repair orders opened on or after April 12, 2021.
Special Publication Letter for EPA07 EPA10 Three-Filter Fuel System DD15 DD16 Severe Duty High Pressure Fuel Rail Feed...
Read full bulletin
Lines Service Kit
Special Publication letter for Two-Filter Fuel System KM59 GEN1 DD15 DD16 Severe Duty High Pressure Fuel Rail Feed Lines...
Read full bulletin
Service Kit.
Customer Service Announcement for Release of DiagnosticLink 8.12 Service Pack 2.
Read full bulletin
On Thursday, September 3, 2020, Service Pack (SP) 2 for DiagnosticLink 8.12 Standard and Professional will be made available to download from the Detroit Diesel server.
Technical Service Letter for EPA10, GHG14, GHG17 Diesel Particulate Filter (DPF) Compatibility.
Read full bulletin
Note: This document supersedes 14 TS-25 and 15 TS-8. Detroit Diesel has determined that some, Diesel Particulate Filters (DPFs) are compatible in pairs and or can be mixed together within EPA10 and GHG14 Systems. For 1-BOX and Two-Box Configuration Aftertreatment Systems (ATS), this is only possible when the filters are used in accordance with Tables 1 and 2 shown below. All other DPFs, NOT mentioned below, are NOT compatible.
Service Bulletin for Equiflo Fuel System Breather Tube Inspection
Service Information Bulletin for Symptom Diagnostics - Fluid in the Aftertreatment - Diesel Fuel Contamination.
SS 1034231 New Cascadia Fuel Gauge Not Indicating Full When Fuel Tank(s) Are Filled
Service Bulletin-sb60165 Exhauster Splash Covers Do Not Fully Latch
Fuel System Integrity Check Routine - Two-Filter Fuel System
Fuel Level Sending Unit Retrofit
Fuel System Integrity Check Routine - Two-Filter Fuel System
Fuel System Integrity Check Routine - Two-Filter Fuel System
Service Information Bulletin- Exhaust Gas Recirculation Crossover Pipe
530-13 Low Pressure Fuel Pump ? Two-Filter Fuel System
529-13 Operation of the Fuel System - Two-Filter Fuel System
13TS17 EPA10-GHG14 Diesel Exhaust Fluid (DEF) in Fuel System-Diesel Fuel in DEF System Contamination
Rev DD Platform Fuel Injector Cup Seal
102-15 High Pressure Fuel Pump - Two-Filter System
18SP687 DD15 16 EGR Actuator Replacement
414-13 Removal and Installation of the GHG14 13 and 23 Gallon Diesel Exhaust Fluid Tank Header Unit
413-13 GHG14 13 and 23 Gallon Diesel Exhaust Fluid Tank
407-13 EGR Actuator Slow Learn
708-13 Fuel System Diagram Update
714-13 Fuel Filter Maintenance Intervals
FL721 CNG Fuel Tank and CPDM Mounting Location
18SP712 EPA07 DD15/16 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel System Conversion Service Kit
18SP713 EPA10 DD13 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel System Conversion Service Kit
18SP714 EPA10 DD15/16 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel System Conversion Service Kit
14TS13Rev EPA10/GHG14 Diesel Exhaust Fluid (DEF) in Fuel System/Diesel Fuel in DEF System Contamination
505-14 Fuel Cooler Leak Test Procedure - Three-Filter Fuel System
504-14 Test-E - Three-Filter Fuel System
513-14 FMI 0: Diesel Particulate Filter Outlet Temperature - Very High
611-13 Removal and Installation of the GHG14 Six-Gallon Diesel Exhaust Fluid Tank Header
sb54296 Fuel Level Sending Unit RetrofitB
sb54148 Radio and Integrated Thin-Film Antenna Troubleshooting, and Field Service UpdatesB
310-13 Draining the Fuel System Using J-48710 Prior to Repairs
13TS-24 DD Platform High Pressure Fuel Lines
18SP700 EPA10,GHG14 Two-Filter Fuel System KM59 GEN1 DD15,16 High Pressure Fuel Feed Lines PN:A4720708032
18SP699 EPA10 GHG14 Two-Filter Fuel System KM59 GEN1 DD13 High Pressure Fuel Feed Lines PN A4710706035
18SP698 EPA07-10 Three-Filter Fuel System DD15,16 High Pressure Fuel Feed Lines PN A4720707932
18SP697 EPA07/10 Three-Filter Fuel System DD13 High Pressure Fuel Feed Lines PN A4710705935
1112-12 Test C -Two-Filter Fuel System
1101-12 Test B -Two-Filter Fuel System
1102-12 Test A - Two-Filter Fuel System
143-13 Low Pressure Fuel System - Measuring Fuel Pressure Using Fuel System Integrity Check, Two-Filter Fuel System
119-13 Exhaust Gas Recirculation System - Cleaning
126-13 Description and Operation of the DD15 and DD16 Exhaust Gas Recirculaton Cooler
124-13 Installation of the DD Platform EGR Actuator Pull Rod
144-13 Removal and Installation of the GHG14 Diesel Exhaust Fluid Lines
15TS8 EPA10 and GHG14 Diesel Particulate Filter (DPF) Compatibility
0202-15 EPA10 and GHG14 Diesel Oxidation Catalyst Face Cleaning
FL671-DLR Exhaust Discharge Location
EPA10, GHG14 and GHG17 Diesel Particulate Filters
Exhaust and Exhaust Gas Recirculation
SPN 4765 FMI 0 - Exhaust Temperature Out Of Range High
Metal in the Fuel - Three- Filter Fuel System
18SP726 ? EPA10 GHG14 Two-Filter Fuel System KM59 GEN1 DD13 High Pressure Fuel Fee
807-12 Removal and Installation of the GHG14 Diesel Exhaust Fluid Dosing Unit Inlet Screen
15TL6 W470589129100 ? HDEP HP Fuel Rail Test Caps
18SP717 DD13 EGR Actuator Replacement
509-15 Symptom Diagnostics - Hard Start/No Start - Three-Filter Fuel
512-15 GHG14 DD15 AT Exhaust Gas Recirculation Actuator Pull Rod
502-15 Exhaust Gas Recirculation Actuator Lever
18SP716 Installation/Replacement of the Fuel Cooler Delete Bypass Plate for the Two-Filter Fuel System
15-017 Detroit: Updated Fuel Injector SDTs
18SP712 EPA07 DD15/16 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel System Conversion Service Kit
18SP713 EPA10 DD13 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel System Conversion Service Kit
18SP714 EPA10 DD15/16 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel System Conversion Service Kit
14TS19 DD Platform High Pressure Fuel Lines
16TS9 DD Platform High Pressure Fuel Lines
16TS7 Reman Diesel Particulate Filter Serial Number
17TL28 Fuel Injector Removal Tool DSN930E17004
914-12 GHG14 Two-Box Diesel Oxidation Catalyst.pdf
0239-14 High Pressure Fuel Injector Lines - Three-Filter System
0238-14 Removal of the High Pressure Fuel Injector Lines - Two-Filter
0210-14 High Pressure Fuel Rail Feed Lines - Three-Filter System
0209-14 High Pressure Fuel Rail Feed Lines - Two-Filter System
0217-14 Installation of the Fuel Injector Cup
0219-14 Metal in Fuel
0202-14 Symptom Diagnostics - Hard Start No Start - Two-Filter Fuel System
0215-14 Check for Rough Running or Stalling - Three-Filter Fuel System
54-281 - Fuel Level Sender Guard Installation
14TS19Rev DD Platform High Pressure Fuel Lines
1104-14 Metal in the Fuel System
18SP707Rev EPA07/10 Three-Filter Fuel System DD13 High Pressure Fuel Feed Lines, Mounting Bracket and P-clips Service...
Read full bulletin
Kit
18SP708Rev EPA07 10 Three-Filter Fuel
14TS25 EPA10 and GHG14 Diesel Particulate Filter (DPF) Compatibility
910-14 Installation of the High Pressure Fuel Rail Feed Lines - Two-Filter System
918-14 Removal and Installation and Inspection of the Fuel Cooler Delete Bypass Plate - Two Filter System
916-14 Fuel Cooler Leak Test Procedure - Two-Filter Fuel System
908-14 908-14 EGR Differential Pressure Failed (High Box)
919-14 Exhaust Gas Recirculation Flow Target Error Diagnostic - High Flow
18SP687 18SP687 DD15/16 EGR Actuator Replacement Service Kit
18SP719Rev EPA10 DD13 Three-Filter ESOC Fuel System to Two-Filter KM59 GEN1 Fuel
18SP714Rev EPA10 DD1516 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel
18SP725 TWO-FILTER FUEL SYSTEM KM63 GEN2 DD13 HIGH PRESSURE FUEL FEED LINES, MOUNTING BRACKET AND P-CLIPS SERVICE KIT
18SP722 DD13 KM59 GEN1 BUS TWO-FILTER SYSTEM AMPLIFIER, NEEDLE AND PLV RETURN FUEL LINE CLEARANCE PACKAGE SERVICE KIT
18SP720 EPA10 DD15/16 THREE-FILTER ESOC FUEL SYSTEM TO TWO-FILTER KM59 GEN1 FUEL SYSTEM CONVERSION SERVICE KIT
18SP720 EPA10 DD15/16 THREE-FILTER ESOC FUEL SYSTEM TO TWO-FILTER KM59 GEN1 FUEL SYSTEM CONVERSION SERVICE KIT 2
18SP718 EPA07 DD15/16 THREE-FILTER ESOC FUEL SYSTEM TO TWO-FILTER KM59 GEN1 FUEL SYSTEM CONVERSION SERVICE KIT
1020-16 CHASSIS FUEL SYSTEM ISOLATION TEST
18SP720REV 18SP720 EPA10 DD15/16 THREE-FILTER ESOC FUEL SYSTEM TO TWO-FILTER KM59 GEN1 FUEL SYSTEM CONVERSION SERVICE...
Read full bulletin
KIT
18SP713REV 18SP713 EPA10 DD13 THREE-FILTER FUEL SYSTEM TO TWO-FILTER KM59 GEN1 FUEL SYSTEM CONVERSION SERVICE KIT
0906-16 LOW PRESSURE FUEL PUMP
FREIGHTLINER: EXCESSIVE WHITE CRYSTAL OR POWDER AROUND DEF FITTING, CAUSED BY EVAPORATION OF DEF WHEN EXPOSED TO AIR...
Read full bulletin
AND/OR DAMPNESS, INDICATES A LEAK IN DIESEL EXHAUST FLUID OR IMPROPER INSTALLATION OR DAMAGED CONNECTORS WOULD HAVE LEAKS IN COOLANT LINES. *PE
Electrical
92 bulletinsService Solution SS 1033047 M2 Battery Drain Problem Mismatched I...
Service Solution SS 1033094 KUS Float Tube Fuel Level Sensor Inform...
SS 1033638 - Power Window Express Down Module Discontinued
Freightliner Action Bulletin FAB153 New Harness Highway for Cascadia
Freightliner Service Bulletin for Programming Chassis Electronic Control Units (ECUs) With DiagnosticLink.
Updated Freightliner Service Bulletin for Powernet Troubleshooting Guide - Batteries, Path, Alternator, and Starter.
Read full bulletin
This bulletin replaces the version dated 5/31/2017. Information is added about the BCT-460DTNA PowerNet Assessment Tool. When troubleshooting Powernet issues, use the BCT-460DTNA PowerNet Assessment Tool. As of May 29, 2018, the AutoMeter is the only Daimler-approved tool for troubleshooting vehicle Powernet issues.
Service Solution for Meritor Wabco OnGuard Radar Service Alignment.
Read full bulletin
If the radar sensor needs to be aligned, the radar sensor mounting system has become damaged or has loosened, or new radar sensor software has been installed, a Radar Sensor Service Alignment will need to be performed.
Service Solution for Legacy Cascadia, where trailer turn signals or 4-way flashers used in applications with high duty...
Read full bulletin
cycles, the left and right turn signals may experience shortened relay life.
Service Bulletin for Cascadia Cabin CAN ECU Compatibility.
Read full bulletin
Compatible software levels are required for the proper operation of the vehicle.
Service Bulletin describing Cascadia cabin CAN ECU compatibility.
Read full bulletin
This document replaces version from July 2015.
Service bulletin describing that the DiagnoticLink screen images for Chassis ECU programming have ben updated.
Service Bulletin to provide instructions to replace Ignition Control System.The ICU3 is no longer installed in...
Read full bulletin
production, and has been superseded by the ICU3S. When replacing an ICU3, the ICU3S must be installed in its place.
SS 1034220 SSI Ultrasonic Fuel Level Sensor Information
sb54308 Chassis ECU Programming
Service Bulletin- Chassis ECU Programming
Aftertreatment Systems - Diesel Exhaust Fluid Pump Module and Components
Eaton 1800-Watt Inverter With Low Voltage communication
SS 1033833- Service Solution for Cascadia Parksmart 100 amp Durakool relay upgrade
Indel B Refrigerator Loose Circuit Board
0311-18 Installation of the Main Shaft Speed Sensor
SF480-DLR Qualcomm TrailerTRACS Wiring
13TS15 EPA10 Diesel Oxidation Catalyst (DOC) Face Plugging And Code SPN 3251-FMI2 - DOC Inlet Pressure Sensor Not...
Read full bulletin
Plausible
13TS15Rev EPA10 Diesel Oxidation Catalyst (DOC) Face Plugging And Code SPN 3251/FMI 2 - DOC Inlet Pressure Sensor Not...
Read full bulletin
Plausible
54-277 - Resetting Erroneous Learned Roll Call ECUs on Vehicles with ICU4M
54-278 - Powernet Troubleshooting Guide: Batteries, Path, Alternator, and Starter
54-274 - Plastic Battery Box Cover Retainer Clip
15TS9 Hydrocarbon Doser Block Fuel Compensation Pressure Sensor
326-15 Main Shaft Speed Sensor
305-15 EPA10 Diesel Oxidation Catalyst Inlet Pressure Sensor
sb54288 Aftertreatment Harness Modification
503-14 FMI 3, 4: High Side Digital Output 3 Circuit Failed High
516-14 FMI 3, 4: DEF pressure sensor circuit failed hig
SF480-DLR Qualcomm TrailerTRACS Wiring
18SP684Rev3 EPA07 and EPA10 DD Platform EGR Delta Pressure Sensor Update
sb83158 ParkSmart Control Module Cover Modification for a New Phase HarnessB
sb3250 Incorrect ECAS Ride Height Sensor and Linkage InstallationB
sb2066 Gentech Low Coolant Level Sensor
fp54031 Ordering Service Wiring Harnesses for Cascadia
13TS5 DD Platform Fuel Filter Module
13TS10 DD Platform Oil Coolant Module Plugs
13TS7 GHG14 CPC4 Vehicle Speed Sensor Code SPN 84-FMI 6
54-275 - Chassis-Mounted Trailer PDM, Battery Power Cable Terminal Corrosion
13TL2 GHG14 Test Electronic Control Units (ECUs).\
sb54278 Powernet Troubleshooting Guide: Batteries, Path, Alternator
sb54239 Cascadia Cabin CAN ECU Compatibility
802-15 SPN 520970 FMI 7 (TCM)
801-15 SPN 520999 FMI 7 (TCM)
SPN 520960 (TCM)
SS 1033334 ICU3S Displays "Electrical System Problem Detected - Shutdown in Progress"
0311-18 Installation of the Main Shaft Speed Sensor
SPN 521221 (TCM)
SPN 521222 (TCM)
1205-15 Selective Catalyst Reduction (SCR) Inlet Temperature Sensor
Cleaning of the Exhaust Gas Recirculation Venturi Pipe Delta P Sensor Ports
FMI 5 Oil Pressure Sensor Stuck High
FMI 2, 3, 4 Remote Accelerator Pedal Supply Voltage
15-016-DLR New Essential Tool For CPWA, CPPRA, Ltd CPPRA, & DSDWC Parties: Cadex CA-12 Battery Tester
15TS9 Hydrocarbon Doser Block Fuel Compensation Pressure Sensor
326-15 Main Shaft Speed Sensor
305-15 EPA10 Diesel Oxidation Catalyst Inlet Pressure Sensor
sb54288 Aftertreatment Harness Modification
54-285 - Cracked Fuses on Powertrain Power Distribution Modules
16TL5 DD Platform Aftertreatment Soot Sensor Socket DSN0ATZ16001
16_TL-2 DD Platform Aftertreatment NOx Sensor Socket W470589060900
0308-16 TCM Programming Instruction
0305-16 TCM SPN 520999 FMI 7 March
0306-16 TCM SPN 520970 FMI 7
14TS5 Replacing Damaged Aftertreatment Sensor Bosses
0218-14 GHG14 Diesel Exhaust Fluid Pump Module Filter
54-278 - Powernet Troubleshooting Guide: Batteries, Path, Alternator, and Starter
1005-14 Oil Coolant Module
14CSA22 DTNA Chassis Wiring Diagrams
18SP684Rev4 18SP684Rev4 ? EPA07 and EPA10 DD Platform EGR Delta Pressure Sensor Update
18SP705Rev5 18SP705Rev5 ? DD Platform Delta Pressure Sensor
sb54287 Powernet Distribution Box Fuse Retention on the Keep-Alive
sbw5460 Powernet Distribution Box Fuse Retention on the Keep-Alive
sb3250 Incorrect ECAS Ride Height Sensor and Linkage Installation
1110-14 EPA10 DOC Inlet Pressure Sensor
sb54288 Aftertreatment Harness Modification
905-14 Coolant Level Circuit Failed
903-14 Selective Catalyst Reduction Inlet NOx Sensor Circuit Failed High and Low
904-14 Selective Catalyst Reduction Outlet NOx Sensor Circuit Failed High and Low
911-14 5V Sensor Supply Bank 2 Circuit Failed High
909-14 Diesel Exhaust Fluid Metering Unit Air Pressure Sensor Circuit Failed High and Low
32-50 - Incorrect ECAS Ride Height Sensor and Linkage Installation
SB54297 LOOSE IGNITION SWITCH ON CASCADIA VEHICLES
16TL17 LABEL UPDATE FOR GHG14 TEST AFTERTREATMENT CONTROL MODULE (ACM)
FREIGHTLINER: INFORMATION PROVIDED REGARDING WATER INTRUSION AND FOREIGN DEBRIS CAN ENTER SAM CHASSIS AND ELECTRICAL...
Read full bulletin
COMPONENT, WHEN COVER IS NOT SHUT SECURELY AND SWINGS OPEN. MODEL CASCADIA. NO MODEL YEARS LISTED. *PE
FREIGHTLINER: DUE TO VIBRATION, ON HORIZONTALLY MOUNTED POWERTRAIN POWER DISTRIBUTION MODULES (PDM), THE FUSES WILL...
Read full bulletin
CRACK AND INSTRUCTIONS ARE PROVIDED TO HELP REDUCE VIBRATION LEVEL. *PE UPDATED 03/02/15*LJ
DAIMLER TRUCKS: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER.
Read full bulletin
ON CERTAIN TRUCKS, BETWEEN THE QUALCOMM UNIT AND TRAILER TRACS TRANSMITTER, COMMUNICATION IS INTERMITTENT, DUE TO LACK OF RELIABLE SIGNAL STRENGTH AND A MORE ROBUST WIRING WILL BE INSTALLED TO CORRECT ISSUE. MODELS 2010-2013 CASCADIA. *PE
FREIGHTLINER: TO PROTECT AGAINST HIGH VOLTAGE DAMAGE, A NEW DESIGN CHANGE TO THE PARKSMART INTERNAL CONTROLLER CIRCUIT BOARD WAS MADE.
Read full bulletin
MODEL 2012 CASCADIA. *PE
FREIGHTLINER: PARKSMART, SPLIT UNIT, CONTROLLER AND HARNESS CHANGES.
Read full bulletin
A DESIGN CHANGE HAS BEEN MADE TO THE PARKSMART INTERNAL CONTROLLER CIRCUIT BOARD TO PROTECT AGAINST HIGH VOLTAGE DAMAGE. *JS
Pre-Delivery & Maintenance
43 bulletinsTechnical Service Letter for SPN 3711 FMI 31 on GHG17 DD15 Trucks.
Service Bulletin for Guidelines for Cleaning and Disinfecting Cab Surfaces.
Read full bulletin
The following guidelines are for cleaning and disinfecting commonly touched surfaces on the inside and outside of a vehicle. For best results, follow cleaning and disinfecting procedures fully and consistently. Ensure there is adequate ventilation when using chemicals. NOTICE: Wipe down fragile components carefully to avoid damaging the vehicle.
Service Bulletin for Chassis Side-Fairing Kickplate Magnet Replacement.
Read full bulletin
On Freightliner Cascadia and New Cascadia vehicles manufactured before May 20, 2019, and equipped with side-fairings, the magnets that hold the kickplate closed may corrode and prevent the kickplate from staying in the closed position.
Warranty Information Letter for Warranty Training Online.
Read full bulletin
DTNA is pleased to announce the release of new Warranty-related training videos. The videos provide Warranty content in short instructional videos that are available on demand through the AftermarkeTV Video Channel icon on the Aftermarket Resource Center (ARC) home page.
Warranty Policy Letter for Handling for Authorized Service Location Part Transfers.
Read full bulletin
To promote 24-hour throughput and maximum efficiency, DTNA is adjusting multiple handling policies: Launching a new handling allowance for parts ordered from another Authorized Service Location because the facing Part Distribution Center (PDC) is out of stock Retiring Detroit's Customer First Program
Open recall and Field service Campaigns report send out to Dealers, General Managers, Service managers and warranty...
Read full bulletin
managers
Customer Advisory Letter that an inspection to determine if the high current breaker has been bypassed.
Technical Service Letter communicating that information on DD Heavy Duty Platform Belt and Belt Tensioner can be found...
Read full bulletin
on TechLit.
Service Bulletin to address wiper issue.
Read full bulletin
On some Cascadia vehicles, when a request for wiper activation is made the wipers may not function. This can result from an overcurrent condition, which causes the wipers to stop functioning and immediately set fault code SPN 522215 FMI 6.
Service Bulletin to replace the white drip shield and secondary SAM cover on the SAM Cabin, with a new one-piece drip...
Read full bulletin
shield.
Warranty Information Letter sent to customers regarding new refrigerator supplier for returning parts.
Service Bulletin sent out customers describing procedure is to replace the white drip shield and secondary SAM cover on...
Read full bulletin
the SAM Cabin, with a new one-piece drip shield.
Service Bulletin provided to customers regarding ICU3 to ICU3S Replacement
Service Bulletin- sb54311 ICU Odometer Programming
Reminder: Paper Service Bulletin Mailings Are Discontinued
Service Information Bulletin
Important Campaign Information on FL614 Recall
Service Information Bulletin- Input Shaft Pilot Bearing Measurement Specification
Service Bulletin New "Natural Gas Vehicle Information" Webpage
Service information Bulletin -HDEP PLV Return Line Tool DSN470E17006
Service Information Bulletin for Aftertreamtent Failure Guide
Service Information Bulletin
Release of DiagnosticLink 8.08 Service Pack 2
If a GVWR certification label is lost or damaged, Freightliner will supply a duplicate label.
Read full bulletin
Log on to DTNAConnect.com and under "DTNAConnect Resources", select the "Tool and Services" plus sign. Select "Request for Certification Label or OWI." Fillout the form, then select "Review."
ICI18-014 Owner Notice ? Kidde Fire Extinguisher Recall
13m2- Equipment Owner Field Service Campaign - 13M2
13m2 -Final-23-SEP-2013 Field Service Campaign 13M2
sb83155 Espar Service Information
507-14 Inspection of the DD15 and DD16 Axial Power Turbine
ICI18-014 Owner Notice ? Kidde Fire Extinguisher Recall
12-033-DLR Over the Counter No Hassle Warranty (OTC)
12CSA19 GHG14 Rapid Warranty Parts Return.
15-015 Warranty Exclusions Reminder
14-026-DLR SelecTruck Warranty Enhancements
Canadian Warranty Parts Return Address Change
OWL Enhancement Service Model Field
Warranty Classroom Training in 2018
12-041-DLR Over the Counter No Hassle Warranty (OTC)
_Warranty Recognition Program - Coming Soon
14WO-9_Warranty_Access Detroit New User Warranty Access Request
14TL9 Special Tool Warranty Program.
16TS14 EPA10 AND GHG14 SERVICE REPLACEMENT 1-BOX DOC INLET CHANGE
DAIMLER TRUCKS: REVISIONS TO A PREVIOUS SERVICE CAMPAIGN.
Read full bulletin
*RM
Transmission
32 bulletinsImportant Campaign Information Letter for DDC D21M1 Termination Date Extended.
Read full bulletin
This letter is to inform you that a revised bulletin for Detroit Diesel Field Service Campaign D21M1, DT12 Transmission Drive Shaft Cover Plug Reseal has been EXTENDED for an additional three months. Please use the extended termination date for all work under D21M1 from this point forward. REVISION: D21M1 termination date extended to July 1, 2022.
Service Solution for FTL DT12 Trans Control Harness Chaffing - PT Can faults.
Read full bulletin
Transmission will not shift into Gear while driving or will not start and trigger multiple PT CAN Fault Codes.
Detroit Field Service Campaign for DT12 Transmission Drive Shaft Cover Plug Reseal.
Read full bulletin
Daimler Trucks North America LLC, on behalf of its DETROIT Powertrain Division, is initiating Field Service Campaign D21M1 on certain DT12 transmissions in order to reseal the bypass plugs of the drive shaft cover located in front housing.
Tech Talk discussion on not being able to do a forced regen because clutch is depressed.
Tech talk continued discussion on 2021 Cascadia SOLO clutch not adjusting.
Tech Talk discussion on Cascadia no power to clutch switch.
Revised Warranty Policy Letter for Alliance/Mascot Aftermarket Warranty and Claim Filing.
Read full bulletin
Revisions are in blue. With Mascot now in partnership with Detroit Reman and Alliance Parts, DTNA is pleased to announce that Mascot coverage has been added to OWL. Remanufactured Alliance/Mascot parts include transmission, differential, steering gear, and steering pump used in an on-highway vehicle applications. The Alliance/Mascot aftermarket warranty coverage period has not changed: depending on the part, coverage is for one (1) or two (2) years and current parts, labor, and reimbursement policies apply.
Warranty Policy Letter for Alliance/Mascot Aftermarket Warranty and Claim Filing.
Read full bulletin
With Mascot now in partnership with Detroit Reman and Alliance Parts, DTNA is pleased to announce that Mascot coverage has been added to OWL. Remanufactured Alliance/Mascot parts include transmission, differential, steering gear, and steering pump used in an on-highway vehicle applications. The Alliance/Mascot aftermarket warranty coverage period has not changed: depending on the part, coverage is for one (1) or two (2) years and current parts, labor, and reimbursement policies apply.
Tech Talk discussion on 2012 Cascadia SOLO Clutch not adjusting.
Service Bulletin for Lengthening the Backup Light Harness.
Read full bulletin
Though the backup light harness is long enough to connect to the backup light switch, it may be short enough that the wire seals in the connector can be stressed. Moisture entering through the seals can cause corrosion, resulting in a bad connection and/or failure of the switch. As a result, backup lights and, if equipped, the backup alarm, may not function when the vehicle is shifted into reverse.
D12 Transmission issue communication on Cascadia
TS 1033699: DT12 Transmission Driver Interview: Shifting Complaint Questionnaire
0405-18 Symptom Diagnostics - Range Up or Down Shift Issue
25-34 - Clutch-Related No-Start Diagnostics
0405-18 Symptom Diagnostics - Range Up or Down Shift Issue
sb60159 Shifter Adapter Plate for Replacement Cab or Cab FloorB
sb2074 Kysor Fan Clutch Rocking Runout Inspection
145-13 Description and Operation of Gear Train and Related Parts
15TS15Rev Detroit? DT12? Transmission Proper Towing Procedure
sb2074 Kysor Fan Clutch Rocking Runout Inspection
Installation of the Transmission
Removal of the Transmission
Detroit? DT12? Transmission Proper Moving Procedure
FMI 2- Automatic Gear Selection - Incompatible or missing dataset
sb4654 Rack and Pinion Steering Gear Retrofit Guide
15-010-DLR Transmission Cooler Line Photos
sb2534 Clutch-Related No-Start Diagnostics
810-14 Clutch Position Sensor
1105-14 Flywheel, Ring Gear and Flywheel Housing
FREIGHTLINER: THERE MAY BE A NO START FAULT ASSOCIATED WITH CLUTCH POSITION COMBINATION SWITCH ON MANUAL TRANSMISSION...
Read full bulletin
AND INVESTIGATION WILL DETERMINE CAUSE OF PROBLEM. MODEL CASCADIA. NO YEARS LISTED. *PE
FREIGHTLINER: BENDIX AIR DRYERS ARE EXPERIENCING EXCESSIVE MOISTURE IN THE AIR SYSTEM.
Read full bulletin
THIS COULD POSSIBLY LEAD TO TRANSMISSION SOLENOID FAILURE. *KB
DAIMLER TRUCK: THICKNESS AND EXCESS MATERIAL FROM DIE PUNCHING MAY PREVENT RETAINING SNAP RINGS FROM FULLY SEATING IN...
Read full bulletin
DIFFERENTIAL LOCK SHIFT FORK ASSEMBLIES, CAUSING DIFFERENTIAL LOCK TO REMAIN UNENGAGED OR ENGAGED. MODELS 2011-2012 BUSINESS CLASS M2, CASCADIA, COLUMBIA, CORONADO, WESTERN STAR 4900. *PE
Body & Paint
24 bulletinsRevised Freightliner Service Bulletin for Hood-Mounted Splash Shield Rivet Replacement.
Read full bulletin
Minor note: added an update of document previously submitted. The related VMRS codes are added
Freightliner Action Bulletin FAB145 New Cascadia Roof Fairing
Service Bulletin for Draining Water Trapped in the Upper A-Pillar.
Read full bulletin
A water leak in the seams between the cab roof and cab side wall or back wall can result in water becoming trapped in the upper A-pillar area in some Cascadia and New Cascadia vehicles. This water may migrate inside the cab and eventually spill through the marker light fastener clearance holes and drip on the dash.
Service Bulletin for Replacing Windshield Gasket.
Read full bulletin
Different types of cab leaks can result in water dripping from the top of the windshield, onto the dash. Replacing a windshield gasket unnecessarily may create new leak issues. Do not replace a windshield gasket unless it has been confirmed to leak, using the cab pressure test.
Warranty Information Letter - Expanded guidelines for paint-related claims sent out to Freightliner, Western star,...
Read full bulletin
Thomas Built Bus, Export and Direct warranty customers
Service Bulletin 9818- Repainting Plastic Bumper Components
The right-hand cab panel on New Cascadia can come into contact with the right-hand chassis-side fairing when making a left turn.
Read full bulletin
This contact can result in an audible popping noise, paint-damage to the rocker panel and damage to the back-side of the chassis-side fairing.
0312-18 Installation Output Shaft Seal
sb9815 Paint Finish Standards
sb60156 FE13 Roof Fairing Brace Cracking, Cascadia Daycab
54-280 - Video Available for Servicing APEX 150 Sealed 16-Pin Connectors
sb60144 New Cascadia Windshield Seal, Adhesive, and Preparation
sb98020 Axalta Paint Finish CareB
fp31028 Cascadia 14.5-Inch Hendrickson Aero-Clad Stainless-Steel Bumpers
60-156 - FE13 Roof Fairing Brace Cracking, Cascadia Daycab
sb54293 SAM Chassis Water Intrusion Prevention
sb9815 Paint Finish Standards
0312-18 Installation Output Shaft Seal
Cascadia Windshield Improvements
sb3130 Quarter Fender Reinforcement
12-040-DLR Roof Fairing Removal Program
60-144 - New Cascadia Windshield Seal, Adhesive, and Preparation
sb60155 Water Leak at the Top of a Cab Door, Cascadia Day Cab
DAIMLER TRUCKS: THERE ARE HOOD MOUNTED SPLASH SHIELDS THAT CAN FAIL ON SOME CASCADIA VEHICLES.
Read full bulletin
RIVETS ON THE SHIELD MAY BREAK, LOOSEN, OR FALL OUT. *RM
Suspension
23 bulletinsRevised Freightliner Service Bulletin for Axle Flange Gasket Replaced with O-Ring.
Read full bulletin
Revision removed steps instructing removal and installation of wheels. Daimler Trucks North America has released a new axle shaft to hub rubber O-ring (part number 11-30728-000) as a replacement for the paper gasket (part number 11-14418-000). The new O-ring will provide better sealing and is reusable. It is quicker and easier to use compared to the paper gasket, because using a paper gasket requires cleaning the hub when the axle shaft is removed.
Freightliner Service Bulletin for Axle Flange Gasket Replaced with O-Ring.
Read full bulletin
Daimler Trucks North America has released a new axle shaft to hub rubber O-ring (part number 11-30728-000) as a replacement for the paper gasket (part number 11-14418-000). The new O-ring will provide better sealing and is reusable. It is quicker and easier to use compared to the paper gasket, because using a paper gasket requires cleaning the hub when the axle shaft is removed.
Freightliner Service Bulletin for Non-Airliner Rear Suspension Crossmember Fastener Change.
Read full bulletin
With the start of production on March 2, 2020, the fasteners used to assemble the non-Airliner rear suspension (bogie) crossmember have changed. The rear suspension bogie crossmember gussets to the C-channel will be assembled with 5/8 - 18 fasteners. This change includes a revision to a higher friction nut that requires an increase in tightening torque. The new higher friction nut can be identified by its green color.
Cascadia Radiator Strut Rod Rubbing on Upper Radiator Hose
Cascadia Radiator Strut Rod Rubbing on Upper Radiator Hose
Cascadia Radiator Strut Rod Rubbing on Upper Radiator Hose
Cascadia Radiator Strut Rod Rubbing on Upper Radiator Hose
SS 1034171 Airliner Rear Suspension Chassis Lean Troubleshooting
Detroit DT12 Split Rod Bushing Repair letter to customer
Technical Service Note: Airliner Rear Suspension Main Crossmember Fastener Replacement.
Service Bulletin: AirLiner Suspension Six-Piece Bolted Service Crossmember
With the start of production on February 12, 2018, the fasteners used to assemble Airliner rear suspension crossmembers changed.
Read full bulletin
The forward-suspension crossmember will assembled with 5/8-18 fasteners and the rear-suspension (bogie) crossmember will be assembled with 3/4-16 fasteners.
33-28 - Bearing Spacer Replacement, ConMet PreSet Steer Hubs
35-30 - Bearing Spacer Replacement, ConMet PreSet Drive Hubs
sb2078 Cascadia Radiator Strut Rod Rubbing on Upper RadiatorHose
FL624-DLR National Seating Seat Suspension Welds
Detroit? DT12? Split Rod Bushing Repair
Warranty Recognition Program Suspension
ELECTRONICALLY CONTROLLED AIR SUSPENSION IS BEING REPLACED.
Read full bulletin
*LJ UPDATED 6/26/14. *PE UPDATED 7/3/14. *PE
FREIGHTLINER: ON RECOMMENDATION OF CONMET, REPLACEMENT OF BEARING SPACER, WITH A NEW ONE, IS REQUIRED WHEN A HUB IS REMOVED.
Read full bulletin
*PE
FREIGHTLINER: FOR SOME MODEL TRUCKS, RECOMMENDATION OF PREVENTIVE MAINTENANCE INTERVALS FOR REAR HEAVY DUTY SUSPENSION...
Read full bulletin
AND OFF HIGHWAY AND SEVERE SERVICE OPERATING CONDITIONS REQUIRES FREQUENT INSPECTIONS. *PE
FREIGHTLINER: THE REAR SUSPENSION AIR SPRING HAS BEEN REDESIGNED.
Read full bulletin
*RM
DAIMLER TRUCKS: TROUBLESHOOTING FOR A MISALIGNMENT OF THE SUSPENSION AIR SPRINGS.
Read full bulletin
*RM
Brakes
20 bulletinsABS Light illuminating in the ICU.
Revised Freightliner Service Bulletin for Insulating Pad for Solid Cast-Aluminum Rear Hood Support.
Read full bulletin
Minor note: added an update of document previously submitted. The related VMRS codes are added
End of Production for the Freightliner P3 Cascadia Sales Cabs.
Read full bulletin
Due to low production volumes, DTNA will be discontinuing the production of the Freightliner Cascadia P3 Sales Cabs.
Freightliner Service Bulletin for Meritor Steer Axle Drum Brake Squeal.
Read full bulletin
Some Cascadia and New Cascadia vehicles equipped with Meritor steer axle drum brakes with a front axle rating less than 13,300 lb (6038 kg) have experienced brake squealing noise when the service brakes are applied at lower speeds. NOTE: This is a nuisance noise issue and not a failure. The solution given in this service bulletin may fix this issue.
sb42077 Steer Axle Brake Chatter
Steer Axle Brake Chatter
Service Bulletin- ABS Light Illuminating in the ICU, ABS Solenoids Not Self Checking
SS 1033322 ABS light illuminating in ICU, ABS solenoids will not self-check
FL756 Brake Light Pressure Switches
SF503-DLR Cascadia 1625 Radiator Tuned Mass Absorbers
FL642-DLR ICU4Me Park Brake Warning Message
sb2077 Tuned Mass Absorber Installation, Cascadia with 1625 sq in Radiator
FL756 Brake Light Pressure Switches
SS 1033322 ABS light illuminating in ICU, ABS solenoids will not self-check
sb4267 Brake Shimmy - Meritor SteeLite X30 Brake Drum with Excessive Runout
14TL5 ABS Power Line Carrier Converter Available Through PDC
16TL3 Pocket iQ? ABS Product Family Kit is Available at PDC
sb4268 Brake S-Cam Tube Lubrication Interval Change
FREIGHTLINER: BRAKE S-CAM TUBE LUBRICATION INTERVAL CHANGE.
Read full bulletin
TO ENSURE OPTIMUM SERVICE LIFE AND TROUBLE-FREE OPERATION, THE RECOMMENDED MAINTENANCE INTERVAL FOR LUBRICATING MERITOR S-CAM BRAKE TUBES ON CENTURY CLASS, COLUMBIA, CASCADIA AND CORONADO OVER-THE-ROAD VEHICLES IS CHANGED FROM M2 TO THE M1 MAINTENANCE INTERVAL. *JS
FREIGHTLINER: ON SOME TRUCKS, WHENEVER BRAKES ARE APPLIED, THE TRUCK WOULD EXPERIENCE SEVERE SHIMMY OR SHAKING.
Read full bulletin
MODELS FLD CONVENTIONAL, CENTURY CLASS CONVENTIONAL, ARGOSY COE, COLUMBIA, CORONADO, BUSINESS CLASS M2, CASCADIA, 108SD/114SD. NO MODEL YEARS LISTED. *PE UPDATED 11/1/12. *PE
Lighting
19 bulletinsICUC Bulb check function.
Freightliner Action Bulletin FAB146 Cascadia LED headlights
Service Bulletin for Reflective Tape Installation.
Read full bulletin
If a truck tractor is ordered without mudflaps and/or mudflap support brackets, the rear reflective tape applied to the mudflaps or mudflap brackets during production is delivered loose with the vehicle. FMVSS/CMVSS 108 S5.7.1.4.3 requires reflective tape on all truck tractors domiciled in the United States and Canada.
Service Bulletin for Marker Light Gasket Leaks, Cascadia.
Read full bulletin
This bulletin replaces the version dated June 17, 2019. A procedure has been added for inspection, repair, and replacement of damaged or spun rivet nuts.
Warranty Policy Letter for Chassis Progressive Damage Policy Change.
Read full bulletin
Effective for repair orders opened on or after April 27, 2020, if an Authorized Service Location installed a part which later has a warrantable failure, progressive damage and labor may be covered under the Aftermarket Parts Limited Parts Warranty (Parts Warranty).
Warranty Policy Letter for Handling Change: Over the Counter Aftermarket Parts Replacement Program.
Read full bulletin
DTNA is pleased to announce that handling will increase to 33% for Misc. Replacement Part type claims filed under the Over the Counter (OTC) Aftermarket Parts Replacement Program.
Marker Light Gasket Leaks, Cascadia
Accent / Park Light Function Disable Accent / Park Light Function Disable
SS1034234 Cascadia ICU4Me - Low Air Warning Light Not Coming On
Service Bulletin- Marker Light Leaks
SF471-DLR Detroit Axles Driver-Controlled Differential Locks
SF471-DLR Detroit Axles Driver-Controlled Differential Locks
Some vehicles may have been incorrectly shimmed at the factory, and may lean slightly to the right or left.
Read full bulletin
While this does not affect the operation of the vehicle, it may be visually unpleasing to many customers.
sb3133 Step Clamps Are Not Reusable
14-024-DLR DTNA & JAD Highlights - Q1 & Q2
54-218 - Adding Daytime Running Lights (DRL)Option to Business Class M2 Vehicles
14-036-DLR DTNA & JAD Highlights - Q3
MARKER LIGHT LEAKS
DAIMLER (FREIGHTLINER): INFORMATION CONCERNING MASTER HEADLIGHT SWITCH IN MARKER LIGHTS POSITION CAUSING DAYTIME...
Read full bulletin
RUNNING LIGHTS TO FAIL, AND NOT TO USE MARKER LIGHTS POSITION WHEN DRIVING. MODEL 2007-2014 CASCADIA. *PE
Software & Calibration
13 bulletinsRevised Freightliner Service Bulletin for Braces for Cascadia Cab-Mounted Splash Shields.
Read full bulletin
Minor note: added an update of document previously submitted. The related VMRS codes are added
Warranty Information Letter announcing DTNA is adjusting the Standard Repair Times (SRTs) shown.
Read full bulletin
The updated times will be applied to repair orders opened on or after April 5, 2021.
Updated Freightliner Service Bulletin for Espar Service Information.
Read full bulletin
This bulletin replaces the version dated January 1, 2015. New Cascadia has been added to the model list.
129-13 DD Platform GHG 14 SPN 3361 FMI 3, 4, 5 UPDATE
1207-15 Updated procedures with adding EPA10 to the GHG14 title
12CSA18 Update to Fix Internet Explorer - A Script on this Page is causing Internet Explorer to Run Slowly Issue
Computer Hook-Up Standard Diagnostic Time Update
sb2073 Cascadia Radiator Update - EPA10
14-035_SRT_Update_for_Cascadia Detroit Standard Repair Time Updates for Cascadia Truck Models
14-035 Detroit Standard Repair Time Updates for Cascadia Truck Models
AEO15M1 GHG14 DD PLATFORM SOFTWARE REPROGRAMMING FOR AUTO ELEVATE
DAIMLER TRUCK: CERTAIN TRUCKS, UNDER ALL CONDITIONS, HAVE ONGUARD SYSTEM THAT FAILS TO PERFORM OPTIMALLY AND SPECIFIC...
Read full bulletin
UPDATES WILL BE MADE ON UNIT TO ENHANCE PERFORMANCE, AS NECESSARY AND WORK INSTRUCTIONS ARE PROVIDED. MODEL CASCADIA 2012-14. *PE UPDATED 2/26/15. *PE
DAIMLER TRUCKS: THERE ARE NEW CGI BELLOWS, BECAUSE THE OLD ONES ARE PRONE TO FATIGUE AND MAY FAIL.
Read full bulletin
*RM UPDATED 4/24/12. *PE
Steering
10 bulletinsTech Talk discussion about power steering fluid.
Hendrickson 5 Inch Drop Axle Tie Rods Recall Bulletin
Hendrickson 5 Inch Drop Axle Tie Rods Recall ICI letter
FL782 Detroit Steer Axle Tie Rods
Adjusting Tilt Lock Force on TRW Steering Columns
Adjusting Tilt Lock Force on TRW Steering Columns
Adjusting Tilt Lock Force on TRW Steering Columns
Adjusting Tilt Lock Force on TRW Steering Columns
Recall FL782- Detroit Steer Axle Tie Rods
Dealer Bulletin- FL782 Detroit Steer Axle Tie Rods
Tires & Wheels
9 bulletinsFL782 Interim Recall Ending - Final Recall Beginning
sb3529 Axle Alignment Specifications
FL721 Interim Recall Ending ? Final Recall to Begin
14TL-7Rev DD Platform Flywheel Housing Runout Tool W470589032100
17TL25 TruckCam? Alignment System
ICI12-028-DLR FL632 - Interim Notice
14TL7 DD Platform Flywheel Housing Runout Tool W470589032100
907-14 Installation and Removal of the Flywheel Housing
0902-16 SYMPTOM DIAGNOSTICS - BELT COMING OFF, SHREDDING OR MISALIGNMENT
HVAC & Climate
8 bulletinsRevised Freightliner Service Bulletin for ParkSmart Eberspaecher Auxiliary Heater Service.
Read full bulletin
This bulletin replaces the version dated May 2015. The note in General Information has been revised to include New Cascadia. Espar information has been changed to reflect a company name change to Eberspaecher.
sb83160 HVAC Blend Door Retrofit
sb83145 ParkSmart Refrigerant Loop Service Kits
sb83114 Approved Leak Detection Methods for Air Conditioning
sb83145 ParkSmart Refrigerant Loop Service Kits
506-15 Air Compressor Coolant Lines
sb83137 ParkSmart?/Espar Auxiliary Heater Servic
49-35 - DEF Return Line Fitting Heater, 6-Gallon Tanks
Infotainment
6 bulletinsSS 1032974 High Oil Pressure on 2017 DTNA Vehicles Instrument Cluster Display
Service Bulletin revision to an earlier submission of SB54-308 for October 2019 (19MC2968).
Read full bulletin
The prior submission added new screenshots. This revision adds clarification for vehicle programming.
sb4269 DEF Metering Unit Inlet Screen Clogging Due to Excessive Moisture in the Air System
sb4269 DEF Metering Unit Inlet Screen Clogging Due to Excessive Moisture in the Air System
sb4269 DEF Metering Unit Inlet Screen Clogging Due to Excessive Moisture in the Air System
- Tire Pressure Monitoring System (TPMS) Display Firmware Update
Hybrid & EV
4 bulletinsThe modified parked regeneration strategy has been standard on GHG17 units since the start of GHG17 production and was...
Read full bulletin
added to EPA10 and GHG14 units with a software update. The modified regeneration utilizes an improved strategy to clean the DOC inlet face and reduce downtime due to DOC face plugging.
18TS4Rev DD Heavy Duty Platform Accessory Drive Belt
15TS5Rev GHG14 DD Platform DEF Pump Leaks and Code 4374 FMI 0 Under Pressurized DEF System
604-13 Performing a Parked Regeneration
Air Bags & Safety
1 bulletinDAIMLER TRUCKS: THE HOOD RESTRAINT CABLE MAY INTERFERE WITH THE A/C LINES.
Read full bulletin
*RM