2007 Freightliner Cascadia TSBs
450 Technical Service Bulletins across 16 categories
Categories
Other
156 bulletinsSAM Cab & SAM Chassis Wall Charts
Cascadia Fault codes 6.0
Odometer racks up mileage when the vehicle is stationary - Cascadia
SS 469068 Cascadia SAM Cab, SAM Chassis, MSF and CGW Hardware Compatibility
SS 1033121 Adding a Fan Override Switch (Legacy Cascadia)
Freightliner Action Bulletin FAB158 Cummins Eaton SmartAdvantage
Freightliner Action Bulletin FAB154 New options for Cascadia
Freightliner Action Bulletin FAB144 Smartway Certification
Tool Letter for ICC5 Programming Cable
Technical Solution for finding Bill of Material
Installation of Vortex Generators
Revised Bulletin
Rear PTO Pump Support CA
fp00024 Cable-Tie Reference
Letter to customer on Coverage Extension GHG17 After Treatment
SPN 3226 (ACM) (GHG17)
SPN 96 (MCM) (GHG17)
SPN 3226 (ACM) (GHG17)
Diagnostic tests - Two Filter System - FSIC Leak Test
SPN 3464 (MCM) (GHG14)
SPN 712 (CPC) (GHG17)
Letter to customer on Coverage Extension GHG17 After Treatment
SPN 3226 (ACM) (GHG17)
SPN 96 (MCM) (GHG17)
SPN 3226 (ACM) (GHG17)
Diagnostic tests - Two Filter System - FSIC Leak Test
SPN 3464 (MCM) (GHG14)
SPN 712 (CPC) (GHG17)
Technical Publications Ordering
DT12 PTO Upfit
SPN 3226 (ACM) (GHG17)
SPN 96 (MCM) (GHG17)
SPN 3226 (ACM) (GHG17)
Diagnostic tests - Two Filter System - FSIC Leak Test
SPN 3464 (MCM) (GHG14)
SPN 712 (CPC) (GHG17)
Instructions for CSC Diagnostic Support
Towing Procedures
Operating Hours for the Customer Assistance Center
0505-18 SPN 3563 HDEP Inlet manifold pressure Too Low
sb54299 ICU3 to ICU3S Replacement Guidelines
fp00020 Replacing Gross Vehicle Weight Rating (GVWR) Certification Labels
0505-18 SPN 3563 HDEP Inlet manifold pressure Too Low
sb4932 DEF Gauge Reading Incorrectly
525-13 SPN 2791-FMI 7 ? ALL YEARS
0104-15 SPN 3464/ FMI 16, 18 (MCM) (GHG14)
54-279 - Intermittent Communication Between the TrailerTRACS Transmitter and the Qualcomm Unit
sb54215 ICU4M Missing VORAD Information or Reporting Fault SA 42 SPN FMI 07
603-13 SPN 84 -FMI 6 - EPA07-GHG14
sb4269 Excessive Moisture in the Air System
Replacing or Upgrading Airliner 40K Transverse Torque Rods
DT12 PTO Upfit
307-15 SPN 3480 (MCM) (EPA07;EPA10;GHG14)
sb4930 49-30 - Gentech DEF Coolant-Flow Solenoid, Testing and Replacement
sb31034 Towing ProceduresB
sb2083 FluidXchange Tool and FittingsB
sb2068 Conventional Fully-Formulated Coolant with SCA Color Change
sb2059 Replacing Push-to-Connect Air Line Fittings with Brass Compression Fittings
sb2058 Early EPA07 QLD Radiator Replacement
sb2057 New Surge Tank Design
fsb4269 Humidit excessive dans le systme d'air
13WO-2-New Standard Rpr Times orgl 11WO2 New Standard Repair Times for EPA07-10 DD13-15 Diagnostic Tests
307-13 SPN 652-FMI 14 - EPA07
sb3132 Cascadia Chassis Side Fairing Lower Air Deflector Retention
sb3131 Huck-Spin 2 Changeover
13TS2 Single-Speed Fan Operation on Cascadia Vehicles
sb8844 Braces for Cascadia Cab-Mounted Splash Shields
706-15 SPN 1323 (MCM) (GHG14) SPN 1324 (MCM) (GHG14) SPN 1325
sb54291 Detroit Assurance Lane Departure Warning Camera
sb54292 Nexiq USB-Link Upgrade and Diagnostic Connector
sb3531 Differential Lubrication, Detroit Model 6 Axles
sb4932 DEF Gauge Reading Incorrectly
SPN 1663 (CPC) (EPA07 10 GHG14 GHG17)
0114-17 SPN 2791 (MCM) (EPA07;EPA10)
1213-16 SPN 3480 (MCM) (EPA07;EPA10 GHG14)
15TS16Rev1 EPA10 Reman MCM Improvement for Fault Codes SPN 651 to 656
1202-15 Symptom Diagnostics - ATD Checklist
SPN 2623 (CPC)(GHG17), SPN 2623 (CPC)(GHG14), and SPN 2623 (CPC)(EPA07 EPA10 GHG14)
aeo12C3-DocTrac -Final
12C3bul-DocTrac - Final
12C3 - Instructions-DocTrac -Final
12-022-DLR Daimler Trucks Remarketing Corporation (DTR) Now Requires Pre-approval for Repairs $1,200 (USD) and Greater
15TS3 Detroit? Coolant Change From Nitrite Organic Acid Technology
15CSA10 The Detroit CSC announcing a new feature ? Ability to attach files to an existing CSC
15CSA9 Release of DiagnosticLink 8.02
sb54291 Detroit Assurance Lane Departure Warning Camera
507-15 SPN 1590( CPC)(GHG14) and SPN 1590 (CPC)(EPA07;EPA10)
15-009_Detroit_New_SDTs
15TL5 DAVCO Shop Pro FXP 95
307-15 SPN 3480 (MCM) (EPA07;EPA10;GHG14)
15CSA4 Holiday Schedule for the Detroit Customer Support Center
713-14 Symptom Diagnostics - Combustion Gas in Coolant
715-14 Symptom Diagnostics - Coolant Los
14-028 Remy Extended Coverage Direct File
14-027 Detroit's New Consolidated Labor Operations (CLOs
14-023 Detroit Axles Pre-Approval Changes
14-022 Pre-Approval Threshold Increase From $2,500 to $5,000 USD
54-215 - ICU4M Missing VORAD Information or Reporting Fault SA 42 SPN 639 FMI 07
16TL4 DOC Face Cleaning Tool P N W470589239100
16TS6 Variable-Speed Fan Operation on Cascadia Vehicles
16TS5 Release of the DD Platform Bearing Failure Guide
0307-16 SPN 723 (MCM) March
0301-16 SPN 625 (CPC) (EPA07) and SPN 625 (CPC) (EPA10 GHG14)
Contaminated Fluids
Hydrocarbon Doser Coolant Lines
16-009R_OWL Enhancements
New Detroit Bearing Failure Analysis Standard Diagnostic Time
17-026 Holiday Closure 2017
17TL27 Injector Cup Tool DSN930E17001
17TL26 Injector Heat Sleeve Removal Tool DSN930E17002
17CSA25 New Method for Uploading Diagnostic Log Files to the CSC
17CSA24 Holiday Schedule for the Detroit Customer Support Center
17CSA23r Detroit CSC closed December 14, 2017 from 11:15 am - 1:15 pm Eastern Time
12-039-DLR OWL Pre-approval's Time Frame Increases to 60 Days
15-028 New Detroit Coolant Line SRTs
Detroit Data Summaries Application and Kits Are No Longer Available Through PDC
_NewDetroitCoolantLineSRTs
- Detroit Assurance Lane Departure Warning Camera Installation
13wo3rev2_final Actual Labor Hours on Detroit Claims
0229-14 Symptom Based Diagnostics - Oil Separator
0233-14 SPN 51 FMI 2 - All Years
0224-14 SPN 1590 FMI 9 - CPC- All Years February 2014
14-017R Revised: Detroit Addition of Admin Time
14-029 New Detroit Standard Diagnostic Times
FL662.-DLR Meritor MSF12 Non-Conforming Front Axle Beams
14-038_New_SRTs Additional Detroit Standard Repair Times.
14-039_additional_SDTs New Detroit Standard Diagnostic Times
14TL8 TorcUP? Non-Impacting Torque Tool.
14TS28 DD Platform Belt Drive System - Belt Part Numbers and diagnostics
1003-14 Rough Running or Stalling.
1009-14 SPN 5016 (ACM) (GHG14)
1007-14 SPN 5016/FMI 3, 4 (ACM) (EPA10)
1006-14 SPN 4374 (ACM) (GHG14)
1008-14 SPN 3510FMI 4,7, and 8 (CPC)(GHG14)
1010-14 SPN 2623 (CPC) (GHG14)
14CSA23 CSC Announces ?Tech Tips? ? DDCSN
14CSA21 Holiday Schedule for the Detroit Customer Support Center ?
14-039 New Detroit Standard Diagnostic Times
14-038 Additional Detroit Standard Repair Times
sb2080 Australian CST M1400 Isolated Radiator Retrofit
sb0039 New "Natural Gas Vehicles Information" Webpage
1108-14 SPN 636 (MCM) (EPA07;EPA10;GHG14)
912-14 Coolant in Oil
920-14 Additional Cleaning and Preparing
917-14 Installation and Removal of the Oil Filter Stand Pipe
1021-16 SPN 110 (MCM)(EPA07EPA07;GHG14), SPN 110 (CPC)(GHG14)
1018-16 SYMPTOM DIAGNOSTICS - NOISE
0810-16 SYMPTOM DIAGNOSTIC NOISE
0809-16 SYMPTOM DIAGNOSTICS : NOISY 1- BOX AFTERTREATMENT
0612-16 SPN 175 (MCM) (GHG17) AND SPN 175 (MCM); ( EPA07;EPA10;GHG14) DIAGNOSTIC PROCEDURE
0611-16 SPN 110 (MCM) (GHG17) AND SPN 110 (MCM); (EPA07;EPA10;GHG14) DIAGNOSTIC PROCEDURE
0610-16 SPN 111 (CPC) (GHG17) AND SPN 111 (CPC); (EPA07;EPA10;GHG14) DIAGNOSTIC PROCEDURE
0609-16 SPN 174 (MCM) (GHG17), SPN 174 (MCM) (EPA07), SPN 174; (MCM) (EPA10), AND SPN 174 DIAGNOSTIC PROCEDURE
0601-16 SPN 103 (MCM) (GHG17) AND SPN 103 (MCM); (EPA07;EPA10;GHG14) DIAGNOSTIC PROCEDURE
FREIGHTLINER: THE CHASSIS SIDE FAIRING LOWER DEFLECTOR RETENTION.
Read full bulletin
THE C-CLIPS THAT ARE ATTACHED TO THE CHASSIS SIDE FARING LOWER AIR DEFLECTORS MAY BECOME LOOSE. *JS
FREIGHTLINER: INFORMATION PROVIDED FOR REPLACEMENT HARDWARE PARTS FOR A SAM CHASSIS OR A SAM CAB.
Read full bulletin
*PE
Engine
70 bulletinsCascadia - Engine Will Not Crank (No Starter Output from SAM Cab)
Warranty Information Letter for Detroit New Service Replacement Engine SRT Update.
Read full bulletin
While validating Standard Repair Times (SRTs) for Detroit's new Gen 5 engine series, DTNA discovered an error in a pre-Gen 5 SRT for the New Service Replacement Engine Program. As a result, DTNA re-studied the SRT and concluded that time for removing/re-installing multiple components (e.g., exhaust manifold/turbo, engine sensor harness, rocker arm assemblies, etc.) should not be included.
Service Solution for P3 - CEL On and Engine de-rate due to ATD Chassis Harness Circuit 532M5+ at DEF Heater Supply location is shorted.
Read full bulletin
Harness part number A66-03217-002 has been reported experiencing failures due to damages to 532M5+ circuit shorting /or corrosion in terminals at Connector (23-13053-200) harness location "ATD_CHAS_F_O_HTR_LINE_DEF_5B" .
Technical Service Letter for DDC Series 60 engines concerning Series 60 Cylinder Head Resurfacing/Finish.
Read full bulletin
Detroit Diesel does not recommend third party resurfacing of Series 60 cylinder heads (outside of Detroit and Detroit Reman).
This service kit includes all necessary parts to replace the high pressure fuel rail feed lines, mounting bracket,...
Read full bulletin
P-clips and mounting hardware in the event one of these parts are loosened, removed or missing from the engine.
Service Solution: 1034298 - New Cascadia Engine Harness Chafe at A06-95037-000 Bracket
Cylinder Liner - Testing of the Cylinder Liner Upper O-Ring
Cylinder Liner - Testing of the Cylinder Liner Upper O-Ring
Cylinder Liner - Testing of the Cylinder Liner Upper O-Ring
Service Information Bulletin- Oil Present at the Turbocharger Compressor Housing
New Detroit Diesel Cylinder Liner Upper O-Ring Leak Test Standard Repair Time
Engine Manufacturer Diagnostics
DD13, DD15, DD16 Check Engine Light Flashing or Blinking
532-13 Description and Operation of the Two-Stage Valve - Two-Filter Systems
15TS4 EPA07 DD15 Piston Kits
15TS2 EPA07 and EPA10 DD Platform Engines With Low Oil Pressure Codes
15TS1 GHG14 DD Platform Engines With Codes SPN: 1323 through SPN: 1328, FMI: 31, Idle Smoothness Control/Cylinder...
Read full bulletin
Misfire At Idle
sb0935 Replacing the Engine Air Filter Element, Donaldson Air Cleaner (03-33648-001-002)
0202-17 DD13, DD15, and DD16 Cylinder Head Assembly Removal and Installation
13TS6 DD Platform Engine Oil Filter.pdf
207-13 Removal and Installation of the Camshaft Housing
18SP693 EPA07-10 Fuel Rail Clamp Service Kit (P-N A4720780335) for DD Platform-Three-Filter Fuel System Engines
83-144 - Optimized Idle and Auxiliary Cab Heater Concurrent Operation
15TS6 Replacement of the High Pressure Fuel Pump Camshaft Oil Seal
15TS14 GHG14 DD Engine Cylinder Liner Seal Replacement
708-15 High Pressure Fuel Pump Camshaft Oil Seal - Two-Filter System
711-15 High Pressure Fuel Pump Camshaft Oil Seal - Three-Filter System
0120-17 Diagnostic Test - Engine Oil Leaks - Oil Developer Method
0118-17 Symptom Diagnostics - Oil Leaks
15TL24 OTC 1750 Revolver Engine Stand
15TS4_Rev2_ EPA07 DD15 Piston Kits
1210-14 Cylinder Head
1201-15 Crankshaft and Bearings
FMI 3 Engine Oil Pressure Sensor Circuit Failed High
Inspection of the DD13 Turbocharger
15TS10Rev DD Engine Platform Coolant Filter
511-15 DD15 and DD16 Exhaust Gas Recirculation Valve Actuator Pull Rod
15TL4 W470589050900 ? 3/8? Drive GEN2 Two-Stage Valve Socket
sb01101 Pilot Bearing Spacer for Detroit Engines with Eaton transmissions
14TL2 DD Platform Engine Stand Adapter W060589023100
714-14 Symptom Diagnostics - Low Engine Compression
712-14 Engine Coolant Temperature
20-73 - CANCELED: Cascadia Radiator Update?EPA10 with DDC Engines
20-75 - CANCELED: Cascadia Radiator Update?EPA10 with Cummins ISX Engines
16TS8 DD13 Cylinder Head and Cylinder Head Gasket Change
16-011 New Detroit Camshaft Housing Seal Standard Repair Time
sb4724 Crank No Start, Loss of Engine Prime on Decked Vehicles
12-038-DLR - No Problem Found - Policy Claims - During Basic Vehicle Chassis or Base Engine Coverage
GHG14 DD Platform Engines With Code SPN: 3216 FMI: 18, SCR Inlet NOx Sensor Drift Low
14TS4 Valve and Liner Installation Tool Issue
0228-14 Engine Oil Leaks - Oil Dye Method
0237-14 Engine Brake Solenoid
14TS21 HDEP Camshaft Position Sensor Change
14-040_Additional_CLOs Additional Detroit CLOs for the Heavy Duty Engine Platform
14CSA20 EGR Valve Actuator Kit P/N E23539699
14-040 Additional Detroit CLOs for the Heavy Duty Engine Platform
1102-14 DD13 Cylinder Head R&R
14TS26 Replacement of the High Pressure Fuel Pump Camshaft Oil Seal
913-14 Checking for Poor Engine Brake Performance
915-14 Backwards Running Engine Detecte
18SP706 Replacement of the High Pressure Fuel Pump Camshaft Oil Seal
35-23 - Breather Oil Leak on Freightliner Tandem Rear Axles
SB0006 FREIGHTLINER COURTESY ENGINEERING POLICY
1017-16 ENGINE MODEL AND SERIAL NUMBER DESIGNATION
16TL20 HEAVY DUTY ENGINE VALVE STEM SEAL INSTALLING DRIFT AND SLEEVE
0909-16 EXCESSIVE OIL CONSUMPTION
FREIGHTLINER: PARKSMART WITH DDC OPTIMIZED IDLE.
Read full bulletin
DETROIT DIESEL OPTIMIZED IDLE AFFECTS THE WAY PARKSMART OPERATES. *JS
FREIGHTLINER: TRW TAS85 STEERING GEAR INTERNAL LEAKAGE TEST.
Read full bulletin
SOME TRW TAS85 STEERING GEARS HAVE BEEN EQUIPPED WITH AN INTERNAL RELIEF VALVE. THESE STEERING GEARS ARE TYPICALLY INSTALLED WITH POWER STEERING PUMPS THAT HAVE A PRESSURE RELIEF RATING GREATER THAN 2175 PSI (150 BAR). THE INTERNAL RELIEF VALVE LIMITS MAXIMUM SUPPLY PRESSURE TO PROTECT THE STEERING GEAR. MODELS FLD CONVENTIONAL, CENTURY CLASS CONVENTIONAL, COLUMBIA, CORONADO, BUSINESS CLASS M2 AND CASCADIA. NO MODEL YEARS LISTED. *PE
FREIGHTLINER: HOOD TILT ASSIST STRUT OIL LEAKS CAN BE PREVENTED BY FLIPPING THE STRUT ORIENTATION TO KEEP OIL IN THE...
Read full bulletin
CYLINDER, WHICH CONTRIBUTES TO LONG STRUT LIFE. MODEL YEARS UNKNOWN. *PE
DAIMLER TRUCKS-FREIGHTLINER: ON CERTAIN VEHICLES, THE AIR FILTER HOUSING AND/OR THE AIR INTAKE DUCT MAY NOT SEAL...
Read full bulletin
CORRECTLY, ALLOWING DUST AND DIRT TO ENTER THE ENGINE. THE AIR FILTER HOUSING AND/AIR INTAKE DUCT WILL BE REPLACED, AS APPROPRIATE. *PE UPDATED 7/6/09. *PE
Fuel System
52 bulletinsWarranty Information letter announcing that DTNA is increasing the Standard Diagnostic Times (SDTs) shown.
Read full bulletin
The updated after treatment system (ATS) diesel exhaust fluid (DEF) pump times will be applied to repair orders opened on or after April 12, 2021.
Service Bulletin for Equiflo Fuel System Breather Tube Inspection
SS 1034231 New Cascadia Fuel Gauge Not Indicating Full When Fuel Tank(s) Are Filled
Fuel System Integrity Check Routine - Two-Filter Fuel System
Fuel Level Sending Unit Retrofit
Fuel System Integrity Check Routine - Two-Filter Fuel System
Fuel System Integrity Check Routine - Two-Filter Fuel System
Service Information Bulletin- Exhaust Gas Recirculation Crossover Pipe
530-13 Low Pressure Fuel Pump ? Two-Filter Fuel System
529-13 Operation of the Fuel System - Two-Filter Fuel System
18SP694 EPA07 DD Platform High Pressure Fuel Flange Service Kit (P-N- A4720785844)
Rev DD Platform Fuel Injector Cup Seal
18SP687 DD15 16 EGR Actuator Replacement
18SP712 EPA07 DD15/16 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel System Conversion Service Kit
512-14 FMI 0: DPF Outlet Temperature Very High
sb54296 Fuel Level Sending Unit RetrofitB
sb54148 Radio and Integrated Thin-Film Antenna Troubleshooting, and Field Service UpdatesB
13TS-24 DD Platform High Pressure Fuel Lines
18SP698 EPA07-10 Three-Filter Fuel System DD15,16 High Pressure Fuel Feed Lines PN A4720707932
18SP697 EPA07/10 Three-Filter Fuel System DD13 High Pressure Fuel Feed Lines PN A4710705935
15TS8 EPA10 and GHG14 Diesel Particulate Filter (DPF) Compatibility
0202-15 EPA10 and GHG14 Diesel Oxidation Catalyst Face Cleaning
18SP730 ? EPA07 10 Three-Filter Fuel System DD13 High Pressure Fuel Feed Lines, Mounting Bracket and P-clips Service...
Read full bulletin
Kit
18SP729 ? EPA07 10 Three-Filter Fuel
18SP726 ? EPA10 GHG14 Two-Filter Fuel System KM59 GEN1 DD13 High Pressure Fuel Fee
15TL6 W470589129100 ? HDEP HP Fuel Rail Test Caps
509-15 Symptom Diagnostics - Hard Start/No Start - Three-Filter Fuel
15-017 Detroit: Updated Fuel Injector SDTs
18SP712 EPA07 DD15/16 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel System Conversion Service Kit
14TS19 DD Platform High Pressure Fuel Lines
16TS9 DD Platform High Pressure Fuel Lines
16TS7 Reman Diesel Particulate Filter Serial Number
17TL28 Fuel Injector Removal Tool DSN930E17004
GHG14 EGR Slow Learn Routine
0239-14 High Pressure Fuel Injector Lines - Three-Filter System
0238-14 Removal of the High Pressure Fuel Injector Lines - Two-Filter
0210-14 High Pressure Fuel Rail Feed Lines - Three-Filter System
0209-14 High Pressure Fuel Rail Feed Lines - Two-Filter System
0219-14 Metal in Fuel
0202-14 Symptom Diagnostics - Hard Start No Start - Two-Filter Fuel System
0215-14 Check for Rough Running or Stalling - Three-Filter Fuel System
54-281 - Fuel Level Sender Guard Installation
1104-14 Metal in the Fuel System
18SP707Rev EPA07/10 Three-Filter Fuel System DD13 High Pressure Fuel Feed Lines, Mounting Bracket and P-clips Service...
Read full bulletin
Kit
18SP708Rev EPA07 10 Three-Filter Fuel
910-14 Installation of the High Pressure Fuel Rail Feed Lines - Two-Filter System
916-14 Fuel Cooler Leak Test Procedure - Two-Filter Fuel System
18SP687 18SP687 DD15/16 EGR Actuator Replacement Service Kit
18SP718Rev EPA07 DD1516 Three-Filter ESOC Fuel System to Two-Filter KM59 GEN1 Fuel
1020-16 CHASSIS FUEL SYSTEM ISOLATION TEST
0906-16 LOW PRESSURE FUEL PUMP
FREIGHTLINER: EXCESSIVE WHITE CRYSTAL OR POWDER AROUND DEF FITTING, CAUSED BY EVAPORATION OF DEF WHEN EXPOSED TO AIR...
Read full bulletin
AND/OR DAMPNESS, INDICATES A LEAK IN DIESEL EXHAUST FLUID OR IMPROPER INSTALLATION OR DAMAGED CONNECTORS WOULD HAVE LEAKS IN COOLANT LINES. *PE
Electrical
50 bulletinsService Solution SS 1033047 M2 Battery Drain Problem Mismatched I...
Service Solution SS 1033094 KUS Float Tube Fuel Level Sensor Inform...
SS 1033638 - Power Window Express Down Module Discontinued
Freightliner Action Bulletin FAB153 New Harness Highway for Cascadia
Updated Freightliner Service Bulletin for Powernet Troubleshooting Guide - Batteries, Path, Alternator, and Starter.
Read full bulletin
This bulletin replaces the version dated 5/31/2017. Information is added about the BCT-460DTNA PowerNet Assessment Tool. When troubleshooting Powernet issues, use the BCT-460DTNA PowerNet Assessment Tool. As of May 29, 2018, the AutoMeter is the only Daimler-approved tool for troubleshooting vehicle Powernet issues.
Service Solution for Meritor Wabco OnGuard Radar Service Alignment.
Read full bulletin
If the radar sensor needs to be aligned, the radar sensor mounting system has become damaged or has loosened, or new radar sensor software has been installed, a Radar Sensor Service Alignment will need to be performed.
Service Solution for Legacy Cascadia, where trailer turn signals or 4-way flashers used in applications with high duty...
Read full bulletin
cycles, the left and right turn signals may experience shortened relay life.
Service Bulletin for Cascadia Cabin CAN ECU Compatibility.
Read full bulletin
Compatible software levels are required for the proper operation of the vehicle.
Service Bulletin describing Cascadia cabin CAN ECU compatibility.
Read full bulletin
This document replaces version from July 2015.
SS 1034220 SSI Ultrasonic Fuel Level Sensor Information
sb54308 Chassis ECU Programming
Service Bulletin- Chassis ECU Programming
Aftertreatment Systems - Diesel Exhaust Fluid Pump Module and Components
Eaton 1800-Watt Inverter With Low Voltage communication
SS 1033833- Service Solution for Cascadia Parksmart 100 amp Durakool relay upgrade
Indel B Refrigerator Loose Circuit Board
54-277 - Resetting Erroneous Learned Roll Call ECUs on Vehicles with ICU4M
54-278 - Powernet Troubleshooting Guide: Batteries, Path, Alternator, and Starter
54-274 - Plastic Battery Box Cover Retainer Clip
15TS9 Hydrocarbon Doser Block Fuel Compensation Pressure Sensor
18SP684Rev3 EPA07 and EPA10 DD Platform EGR Delta Pressure Sensor Update
sb83130 83-130 - Ambient Air Temperature Sensor Harness Chafing
sb2070 EPA07 and Newer Gentech Coolant-Level Sensor Testing
fp54031 Ordering Service Wiring Harnesses for Cascadia
13TS5 DD Platform Fuel Filter Module
54-275 - Chassis-Mounted Trailer PDM, Battery Power Cable Terminal Corrosion
sb54278 Powernet Troubleshooting Guide: Batteries, Path, Alternator
sb54239 Cascadia Cabin CAN ECU Compatibility
SS 1033334 ICU3S Displays "Electrical System Problem Detected - Shutdown in Progress"
1205-15 Selective Catalyst Reduction (SCR) Inlet Temperature Sensor
Cleaning of the Exhaust Gas Recirculation Venturi Pipe Delta P Sensor Ports
FMI 2, 3, 4 Remote Accelerator Pedal Supply Voltage
15-016-DLR New Essential Tool For CPWA, CPPRA, Ltd CPPRA, & DSDWC Parties: Cadex CA-12 Battery Tester
15TS9 Hydrocarbon Doser Block Fuel Compensation Pressure Sensor
54-285 - Cracked Fuses on Powertrain Power Distribution Modules
16TL5 DD Platform Aftertreatment Soot Sensor Socket DSN0ATZ16001
16_TL-2 DD Platform Aftertreatment NOx Sensor Socket W470589060900
14TS5 Replacing Damaged Aftertreatment Sensor Bosses
1005-14 Oil Coolant Module
14CSA22 DTNA Chassis Wiring Diagrams
18SP684Rev4 18SP684Rev4 ? EPA07 and EPA10 DD Platform EGR Delta Pressure Sensor Update
18SP705Rev5 18SP705Rev5 ? DD Platform Delta Pressure Sensor
sb3250 Incorrect ECAS Ride Height Sensor and Linkage Installation
1110-14 EPA10 DOC Inlet Pressure Sensor
905-14 Coolant Level Circuit Failed
909-14 Diesel Exhaust Fluid Metering Unit Air Pressure Sensor Circuit Failed High and Low
FREIGHTLINER: CASCADIA BATTERY BOX COVER.
Read full bulletin
IN SOME CLIMATES, IT IS HELPFUL TO HAVE THE BATTERIES COVERED TO PREVENT ICE AND SNOW BUILD UP WHEN THE CASCADIA IS EQUIPPED WITH CHASSIS SIDE FAIRINGS. IF DESIRED, A BATTERY BOX INSTALLATION KIT IS AVAILABLE FROM FREIGHTLINER FOR THIS PURPOSE. NO MODEL YEARS LISTED. *PE
DAIMLER (FREIGHTLINER) TRUCK: CERTAIN TRUCKS MAY NOT HAVE UPDATED SOFTWARE FOR THE FOLLOWING ELECTRONIC CONTROL UNITS...
Read full bulletin
(ECUS): SIGNAL DETECT AND ACTIVATION MODULE (SAM) CABIN, SAM CHASSIS, MODULAR SWITCH FIELD (MSF), AND THE CENTRAL GATEWAY (CGW). AN ACTIVE FAULT MAY ALSO REPORT CONSTANTLY ON SOME TRUCKS. *PE UPDATED 6/21/11. *PE
FREIGHTLINER: SOME TRUCKS MAY HAVE THE AMBIENT AIR TEMPERATURE SENSOR HARNESS ROUTED SUCH THAT IT CAN BE CHAFFED ON A RADIATOR BAFFLE.
Read full bulletin
IF THE HARNESS IS RUBBED THROUGH, THE AC MAY NOT FUNCTION. NO MODEL YEARS LISTED. *PE
FREIGHTLINER: SEVERAL ISSUES HAVE BEEN DISCOVERED WHEN USING SERVICELINK WITH THE LIFEGUARD ROLLTEK SYSTEM ON CASCADIA TRUCKS.
Read full bulletin
THE SERVICELINK ISSUES INCLUDE-MISSING ROLLTEK ECU DESCRIPTIONS; MISSING ROLLTEK ECU FAULT DESCRIPTIONS; THE INABILITY TO CLEAR HISTORIC J1708 ROLLTEK FAULT CODES. A SOLUTION IS IN PROCESS FOR SERVICELINK, AND IS EXPECTED TO BE AVAILABLE BY FALL 2009. NO MODEL YEARS LISTED. *PE
Pre-Delivery & Maintenance
27 bulletinsService Bulletin for Chassis Side-Fairing Kickplate Magnet Replacement.
Read full bulletin
On Freightliner Cascadia and New Cascadia vehicles manufactured before May 20, 2019, and equipped with side-fairings, the magnets that hold the kickplate closed may corrode and prevent the kickplate from staying in the closed position.
Technical Service Letter communicating that information on DD Heavy Duty Platform Belt and Belt Tensioner can be found...
Read full bulletin
on TechLit.
Warranty Information Letter sent to customers regarding new refrigerator supplier for returning parts.
Service Bulletin- sb54311 ICU Odometer Programming
Reminder: Paper Service Bulletin Mailings Are Discontinued
Service Information Bulletin
Important Campaign Information on FL614 Recall
Service Information Bulletin- Input Shaft Pilot Bearing Measurement Specification
Service Bulletin New "Natural Gas Vehicle Information" Webpage
Service information Bulletin -HDEP PLV Return Line Tool DSN470E17006
Service Information Bulletin for Aftertreamtent Failure Guide
If a GVWR certification label is lost or damaged, Freightliner will supply a duplicate label.
Read full bulletin
Log on to DTNAConnect.com and under "DTNAConnect Resources", select the "Tool and Services" plus sign. Select "Request for Certification Label or OWI." Fillout the form, then select "Review."
13m2- Equipment Owner Field Service Campaign - 13M2
13m2 -Final-23-SEP-2013 Field Service Campaign 13M2
sb83155 Espar Service Information
sb2063 20-63 - Coolant Filter Inspection Procedure, DD13/DD15/DD16 Only
sb2063 Coolant Filter Inspection Procedure, DD13 DD15 DD16 Only
15-015 Warranty Exclusions Reminder
14-026-DLR SelecTruck Warranty Enhancements
Canadian Warranty Parts Return Address Change
OWL Enhancement Service Model Field
Warranty Classroom Training in 2018
12-041-DLR Over the Counter No Hassle Warranty (OTC)
_Warranty Recognition Program - Coming Soon
14WO-9_Warranty_Access Detroit New User Warranty Access Request
14TL9 Special Tool Warranty Program.
DAIMLER TRUCKS: REVISIONS TO A PREVIOUS SERVICE CAMPAIGN.
Read full bulletin
*RM
Body & Paint
17 bulletinsFreightliner Action Bulletin FAB145 New Cascadia Roof Fairing
Service Bulletin for Draining Water Trapped in the Upper A-Pillar.
Read full bulletin
A water leak in the seams between the cab roof and cab side wall or back wall can result in water becoming trapped in the upper A-pillar area in some Cascadia and New Cascadia vehicles. This water may migrate inside the cab and eventually spill through the marker light fastener clearance holes and drip on the dash.
Service Bulletin for Replacing Windshield Gasket.
Read full bulletin
Different types of cab leaks can result in water dripping from the top of the windshield, onto the dash. Replacing a windshield gasket unnecessarily may create new leak issues. Do not replace a windshield gasket unless it has been confirmed to leak, using the cab pressure test.
Warranty Information Letter - Expanded guidelines for paint-related claims sent out to Freightliner, Western star,...
Read full bulletin
Thomas Built Bus, Export and Direct warranty customers
Service Bulletin 9818- Repainting Plastic Bumper Components
The right-hand cab panel on New Cascadia can come into contact with the right-hand chassis-side fairing when making a left turn.
Read full bulletin
This contact can result in an audible popping noise, paint-damage to the rocker panel and damage to the back-side of the chassis-side fairing.
sb9815 Paint Finish Standards
54-280 - Video Available for Servicing APEX 150 Sealed 16-Pin Connectors
sb60144 New Cascadia Windshield Seal, Adhesive, and Preparation
sb98020 Axalta Paint Finish CareB
fp31028 Cascadia 14.5-Inch Hendrickson Aero-Clad Stainless-Steel Bumpers
sb54293 SAM Chassis Water Intrusion Prevention
sb9815 Paint Finish Standards
Cascadia Windshield Improvements
sb3130 Quarter Fender Reinforcement
12-040-DLR Roof Fairing Removal Program
FREIGHTLINER: SOME VEHICLES MAY HAVE BEEN BUILT WITH CLAMPS USED TO CONNECT THE CLEAN GAS INDUCTION (CGI) PLUMBING THAT...
Read full bulletin
MAY NOT PROVIDE AN ADEQUATE SEAL, ALLOWING UNFILTER AIR INTO THE SYSTEM. THE CLAMPS WILL BE REPLACED. *PE
Suspension
15 bulletinsRevised Freightliner Service Bulletin for Axle Flange Gasket Replaced with O-Ring.
Read full bulletin
Revision removed steps instructing removal and installation of wheels. Daimler Trucks North America has released a new axle shaft to hub rubber O-ring (part number 11-30728-000) as a replacement for the paper gasket (part number 11-14418-000). The new O-ring will provide better sealing and is reusable. It is quicker and easier to use compared to the paper gasket, because using a paper gasket requires cleaning the hub when the axle shaft is removed.
Freightliner Service Bulletin for Axle Flange Gasket Replaced with O-Ring.
Read full bulletin
Daimler Trucks North America has released a new axle shaft to hub rubber O-ring (part number 11-30728-000) as a replacement for the paper gasket (part number 11-14418-000). The new O-ring will provide better sealing and is reusable. It is quicker and easier to use compared to the paper gasket, because using a paper gasket requires cleaning the hub when the axle shaft is removed.
Freightliner Service Bulletin for Non-Airliner Rear Suspension Crossmember Fastener Change.
Read full bulletin
With the start of production on March 2, 2020, the fasteners used to assemble the non-Airliner rear suspension (bogie) crossmember have changed. The rear suspension bogie crossmember gussets to the C-channel will be assembled with 5/8 - 18 fasteners. This change includes a revision to a higher friction nut that requires an increase in tightening torque. The new higher friction nut can be identified by its green color.
Cascadia Radiator Strut Rod Rubbing on Upper Radiator Hose
Cascadia Radiator Strut Rod Rubbing on Upper Radiator Hose
Cascadia Radiator Strut Rod Rubbing on Upper Radiator Hose
Cascadia Radiator Strut Rod Rubbing on Upper Radiator Hose
Detroit DT12 Split Rod Bushing Repair letter to customer
Technical Service Note: Airliner Rear Suspension Main Crossmember Fastener Replacement.
Service Bulletin: AirLiner Suspension Six-Piece Bolted Service Crossmember
With the start of production on February 12, 2018, the fasteners used to assemble Airliner rear suspension crossmembers changed.
Read full bulletin
The forward-suspension crossmember will assembled with 5/8-18 fasteners and the rear-suspension (bogie) crossmember will be assembled with 3/4-16 fasteners.
33-28 - Bearing Spacer Replacement, ConMet PreSet Steer Hubs
35-30 - Bearing Spacer Replacement, ConMet PreSet Drive Hubs
Warranty Recognition Program Suspension
DAIMLER TRUCK (FREIGHTLINER): KICK PLATE DOOR HINGES.
Read full bulletin
THE KICK PLATE DOOR HINGE SPRINGS ON SOME TRUCKS MAY BE MISSING OR FRACTURE. A FAILURE OF BOTH SPRINGS MAY RESULT IN KICK PLATE DOOR NOT REMAINING SHUT. KICK PLATE DOOR HINGE SPRINGS WILL BE REPLACED WITH MORE ROBUST SPRINGS. *PE
Lighting
14 bulletinsICUC Bulb check function.
Freightliner Action Bulletin FAB146 Cascadia LED headlights
Service Bulletin for Reflective Tape Installation.
Read full bulletin
If a truck tractor is ordered without mudflaps and/or mudflap support brackets, the rear reflective tape applied to the mudflaps or mudflap brackets during production is delivered loose with the vehicle. FMVSS/CMVSS 108 S5.7.1.4.3 requires reflective tape on all truck tractors domiciled in the United States and Canada.
Service Bulletin for Marker Light Gasket Leaks, Cascadia.
Read full bulletin
This bulletin replaces the version dated June 17, 2019. A procedure has been added for inspection, repair, and replacement of damaged or spun rivet nuts.
Accent / Park Light Function Disable Accent / Park Light Function Disable
SS1034234 Cascadia ICU4Me - Low Air Warning Light Not Coming On
Service Bulletin- Marker Light Leaks
Some vehicles may have been incorrectly shimmed at the factory, and may lean slightly to the right or left.
Read full bulletin
While this does not affect the operation of the vehicle, it may be visually unpleasing to many customers.
sb3133 Step Clamps Are Not Reusable
14-024-DLR DTNA & JAD Highlights - Q1 & Q2
14-036-DLR DTNA & JAD Highlights - Q3
DAIMLER (FREIGHTLINER): INFORMATION CONCERNING MASTER HEADLIGHT SWITCH IN MARKER LIGHTS POSITION CAUSING DAYTIME...
Read full bulletin
RUNNING LIGHTS TO FAIL, AND NOT TO USE MARKER LIGHTS POSITION WHEN DRIVING. MODEL 2007-2014 CASCADIA. *PE
FREIGHTLINER: FLEX EXTENDER INSTALLATION ON DELIVERED VEHICLES.
Read full bulletin
TRUCKS FROM ORIGINAL EQUIPMENT MANUFACTURER ARE TRANSPORTED WITH THE RUBBER FLEX EXTENDERS (IF SO EQUIPPED) REMOVED FROM THE TRAILING EDGE OF THE CAB SIDE EXTENDERS. TRANSPORTING THE TRUCK BACKWARDS AT HIGH SPEEDS COULD CAUSE INSTALLED FLEX EXTENDERS TO COME LOOSE AND FALL OFF. NO MODEL YEARS LISTED. *PE
FREIGHTLINER: A NEW BULB SOCKET IS AVAILABLE FOR TURN/PARK LIGHTS THAT IS METALIZED TO WITHSTAND HIGH HEAT WITHOUT OUT GASSING.
Read full bulletin
MODEL YEARS UNKNOWN. MODELS COLUMBIA, BUSINESS CLASS M2 AND CASCADIA. *PE UPDATED ON 6/14/2011. *KB
Brakes
13 bulletinsABS Light illuminating in the ICU.
End of Production for the Freightliner P3 Cascadia Sales Cabs.
Read full bulletin
Due to low production volumes, DTNA will be discontinuing the production of the Freightliner Cascadia P3 Sales Cabs.
sb42077 Steer Axle Brake Chatter
Steer Axle Brake Chatter
Service Bulletin- ABS Light Illuminating in the ICU, ABS Solenoids Not Self Checking
SS 1033322 ABS light illuminating in ICU, ABS solenoids will not self-check
sb4267 Brake Shimmy?Meritor SteeLite X30? Brake Drum with Excessive RunoutB
SS 1033322 ABS light illuminating in ICU, ABS solenoids will not self-check
sb4267 Brake Shimmy - Meritor SteeLite X30 Brake Drum with Excessive Runout
14TL5 ABS Power Line Carrier Converter Available Through PDC
16TL3 Pocket iQ? ABS Product Family Kit is Available at PDC
sb4268 Brake S-Cam Tube Lubrication Interval Change
FREIGHTLINER: BRAKE S-CAM TUBE LUBRICATION INTERVAL CHANGE.
Read full bulletin
TO ENSURE OPTIMUM SERVICE LIFE AND TROUBLE-FREE OPERATION, THE RECOMMENDED MAINTENANCE INTERVAL FOR LUBRICATING MERITOR S-CAM BRAKE TUBES ON CENTURY CLASS, COLUMBIA, CASCADIA AND CORONADO OVER-THE-ROAD VEHICLES IS CHANGED FROM M2 TO THE M1 MAINTENANCE INTERVAL. *JS
Software & Calibration
7 bulletinsWarranty Information Letter announcing DTNA is adjusting the Standard Repair Times (SRTs) shown.
Read full bulletin
The updated times will be applied to repair orders opened on or after April 5, 2021.
1207-15 Updated procedures with adding EPA10 to the GHG14 title
12CSA18 Update to Fix Internet Explorer - A Script on this Page is causing Internet Explorer to Run Slowly Issue
Computer Hook-Up Standard Diagnostic Time Update
14-035_SRT_Update_for_Cascadia Detroit Standard Repair Time Updates for Cascadia Truck Models
14-035 Detroit Standard Repair Time Updates for Cascadia Truck Models
DAIMLER TRUCKS: THERE ARE NEW CGI BELLOWS, BECAUSE THE OLD ONES ARE PRONE TO FATIGUE AND MAY FAIL.
Read full bulletin
*RM UPDATED 4/24/12. *PE
Transmission
7 bulletins25-34 - Clutch-Related No-Start Diagnostics
Shifter Adapter Plate for Replacement Cab or Cab Floor
sb2074 Kysor Fan Clutch Rocking Runout Inspection
sb2069 Kysor Fan Clutch Sticking
sb2074 Kysor Fan Clutch Rocking Runout Inspection
15-010-DLR Transmission Cooler Line Photos
1105-14 Flywheel, Ring Gear and Flywheel Housing
HVAC & Climate
6 bulletinsRevised Freightliner Service Bulletin for ParkSmart Eberspaecher Auxiliary Heater Service.
Read full bulletin
This bulletin replaces the version dated May 2015. The note in General Information has been revised to include New Cascadia. Espar information has been changed to reflect a company name change to Eberspaecher.
sb83160 HVAC Blend Door Retrofit
ParkSmart/Espar Auxiliary Heater Service
sb83145 ParkSmart Refrigerant Loop Service Kits
sb83114 Approved Leak Detection Methods for Air Conditioning
sb83145 ParkSmart Refrigerant Loop Service Kits
Tires & Wheels
6 bulletinssb3529 Axle Alignment Specifications
14TL-7Rev DD Platform Flywheel Housing Runout Tool W470589032100
17TL25 TruckCam? Alignment System
ICI12-028-DLR FL632 - Interim Notice
14TL7 DD Platform Flywheel Housing Runout Tool W470589032100
0902-16 SYMPTOM DIAGNOSTICS - BELT COMING OFF, SHREDDING OR MISALIGNMENT
Infotainment
4 bulletinsSS 1032974 High Oil Pressure on 2017 DTNA Vehicles Instrument Cluster Display
sb4269 DEF Metering Unit Inlet Screen Clogging Due to Excessive Moisture in the Air System
sb4269 DEF Metering Unit Inlet Screen Clogging Due to Excessive Moisture in the Air System
- Tire Pressure Monitoring System (TPMS) Display Firmware Update
Steering
4 bulletinsAdjusting Tilt Lock Force on TRW Steering Columns
Adjusting Tilt Lock Force on TRW Steering Columns
Adjusting Tilt Lock Force on TRW Steering Columns
Adjusting Tilt Lock Force on TRW Steering Columns
Hybrid & EV
2 bulletins18TS4Rev DD Heavy Duty Platform Accessory Drive Belt
15TS5Rev GHG14 DD Platform DEF Pump Leaks and Code 4374 FMI 0 Under Pressurized DEF System