2015 Freightliner Business Class M2 TSBs
633 Technical Service Bulletins across 17 categories
Categories
Other
196 bulletinsCX Advocate for NOx conversion low faults
CX Advocate for NOx conversion low faults
CX Advocate for NOx conversion low faults
CX Advocate for CARB tightening the Readiness Criteria applied to On-Board Diagnostic (OBD) test submissions for the...
Read full bulletin
Clean Truck Check.
CX Advocate for CARB tightening the Readiness Criteria applied to On-Board Diagnostic (OBD) test submissions for the...
Read full bulletin
Clean Truck Check.
CX Advocate for CARB tightening the Readiness Criteria applied to On-Board Diagnostic (OBD) test submissions for the...
Read full bulletin
Clean Truck Check.
CX Advocate for Oil Suction manifolds
CX Advocate communication for NOx conversion low faults
Tech Talk discussion on M-2 gauges inoperative at times.
Tech Talk discussion on repair verification for codes like 'low air flow' when a trailer is not available.
Tool Letter for ICC5 Programming Cable
PowerNet Assessment Tool Repair Procedure
ICI19-011 FL782 - Revised Bulletin
fp00024 Cable-Tie Reference
Letter to customer on Coverage Extension GHG17 After Treatment
Technical Publications Ordering
Instructions for CSC Diagnostic Support
SPN 3556 (ACM) (GHG14)
FL724 ? Third Revised Bulletin
Towing Procedures
ICU3 to ICU3S Replacement Guidelines
Operating Hours for the Customer Assistance Center
Vehicles with Meritor drivelines bene from a softer durometer center bearing support.
Read full bulletin
Vehicle will continue to have a 1st order driveline vibration after the driveline assembly was rebalanced.
0505-18 SPN 3563 HDEP Inlet manifold pressure Too Low
sb54299 ICU3 to ICU3S Replacement Guidelines
fp00020 Replacing Gross Vehicle Weight Rating (GVWR) Certification Labels
Trucks were flooded
SS1033446 Driveline Support Bearing - Meritor Driveline
0505-18 SPN 3563 HDEP Inlet manifold pressure Too Low
MY18M1a 05-MAR-2018 Vocational
sb4932 DEF Gauge Reading Incorrectly
0105-15 SPN 102 (MCM) (GHG14)
0108-15 SPN 1323 through 1328 (MCM) (GHG14)
0106-15 SPN 3251 (ACM) (EPA10) and (GHG14)
0104-15 SPN 3464/ FMI 16, 18 (MCM) (GHG14)
0101-15 SPN 4364 (ACM) (EPA10)
0107-15 Enhanced Steam Clean
(CPC)(EPA10-GHG14) and SPN 98 (CPC)(GHG17)
0301-17 Contaminated Fluids
Replacing or Upgrading Airliner 40K Transverse Torque Rods
324-15 External Component Repair
304-15 Diagnostic Tests
303-15 Contaminated Fluids
325-15 Symptom Diagnosis - ATD Checklist
323-15 Symptom Diagnostics ? Noise
306-15 SPN 3246 (ACM)(EPA10;GHG14)
307-15 SPN 3480 (MCM) (EPA07;EPA10;GHG14)
321-15 SPN 4364 (ACM) (GHG14)
320-15 SPN 4374 (ACM) (GHG14)
301-15 SPN 3251 (ACM) (EPA10) and (ACM) (GHG14), 3936 (ACM)
sb4937 2013 OBD GHG14, 6-Gallon DEF Header Suction Line
14TS15 Issues with PTO and Remote Throttle Combinations
518-14 FMI 1, 18: Regen Temperature- Out Of Range Low
519-14 FMI 1: SCR NOx Conversion Efficiency Very Low
517-14 FMI 18: SCR NOx Conversion efficiency low
0402-18 SPN 625 (CPC) (GHG14)
0401-18 SPN 1231 (MCM) (EPA10 GHG14)
sb31034 Towing ProceduresB
sb3251 Replacing or Upgrading Airliner 40K Transverse Torque RodsB
sb2083 FluidXchange Tool and FittingsB
sb2067 Surge Tank Leaks
sb2053 New Stainless Steel Lower Radiator Tubes
sb2042 Coolant Overflow Hose
sb00042 Flood Damage Repair GuidelinesB
sb0039 New Natural Gas Vehicle Information WebpageB
fsb42072 Diagnostic de fuite d'air
sb3131 Huck-Spin 2 Changeover
0201-15 SPN 3250 FMI 31 - GHG14
0204-15 Symptom Diagnostics: Noisy One-Box Aftertreatment
0203-15 Oil Filter Stand Pipe
20-82 - Premature Belt Wear, Cummins ISC/ISL
704-15 SPN 4364 (ACM)(EPA10)
706-15 SPN 1323 (MCM) (GHG14) SPN 1324 (MCM) (GHG14) SPN 1325
sb54292 Nexiq USB-Link Upgrade and Diagnostic Connector
805-15 FMI 0: Selective Catalyst Reduction Outlet Temperature High
SPN 157 (MCM) (GHG17)
ICI15-010 FL677 Revised Bulletin
DD Heavy Duty Platform Belt and Belt Tensioner
SPN 1663 (CPC) (EPA07 10 GHG14 GHG17)
0137-17 SPN 3361 FMI 5 (ACM) (GHG17) SPN 3361 FMI 5 (ACM) (GHG14)
0130-17 SPN 520211 (IPPC) (GHG14) SPN 520211 (IPPC) (GHG17)
0127-17 SPN 1077 FMI 14 (GHG14) (GHG17) (MCM)
0115-17 SPN 3226 (ACM) (EPA10;GHG14)
0106-17 SPN 520296 (MCM) (GHG14) and SPN 520296 (MCM) (GHG17)
1207-16 SPN 4363 (ACM) (EPA10 GHG14)
1213-16 SPN 3480 (MCM) (EPA07;EPA10 GHG14)
15TS16Rev1 EPA10 Reman MCM Improvement for Fault Codes SPN 651 to 656
1202-15 Symptom Diagnostics - ATD Checklist
12-022-DLR Daimler Trucks Remarketing Corporation (DTR) Now Requires Pre-approval for Repairs $1,200 (USD) and Greater
15TS3 Detroit? Coolant Change From Nitrite Organic Acid Technology
405-15 Symptom Diagnostics - Hard Start/No Start - Two-Filter System
406-15 SPN 97 (MCM) (EPA10) / SPN 97 (MCM) (GHG14)
403-15 SPN 677 (MCM)(EPA07)
402-15 SPN 2630 (MCM)(EPA10) and SPN 2630 (MCM)(GHG14)
404-15 SPN 4364 (ACM) (EPA10)
15CSA10 The Detroit CSC announcing a new feature ? Ability to attach files to an existing CSC
15CSA9 Release of DiagnosticLink 8.02
510-15 SID 057 04 - PWM Driver #1 Shorted to Ground
505-15 SPN 3361 (ACM) (EPA10)
507-15 SPN 1590( CPC)(GHG14) and SPN 1590 (CPC)(EPA07;EPA10)
508-15 SPN 625 (MCM)( EPA10;GHG14)
sb2083 FluidXchange Tool and Fittings
15-009_Detroit_New_SDTs
15TL5 DAVCO Shop Pro FXP 95
324-15 External Component Repair
304-15 Diagnostic Tests
303-15 Contaminated Fluids
325-15 Symptom Diagnosis - ATD Checklist
323-15 Symptom Diagnostics ? Noise
306-15 SPN 3246 (ACM)(EPA10;GHG14)
307-15 SPN 3480 (MCM) (EPA07;EPA10;GHG14)
321-15 SPN 4364 (ACM) (GHG14)
320-15 SPN 4374 (ACM) (GHG14)
301-15 SPN 3251 (ACM) (EPA10) and (ACM) (GHG14), 3936 (ACM)
15CSA4 Holiday Schedule for the Detroit Customer Support Center
sb4937 2013 OBD GHG14, 6-Gallon DEF Header Suction Line
713-14 Symptom Diagnostics - Combustion Gas in Coolant
715-14 Symptom Diagnostics - Coolant Los
719-14 SPN 84 (CPC) (GHG14)
710-14 SPN 96 (CPC) (GHG14)
711-14 SPN 107 (CPC) (GHG14
701-14 SPN 168 FMI 0 and 1 (IPPC)(GHG14
706-14 SPN 171 FMI 3, 4 (CPC)(GHG14)
709-14 SPN 3216 (MCM) (GHG14)
704-14 SPN 520200 FMI 6 (IPPC)(GHG14)
705-14 SPN 520203 FMI 6 (IPPC)(GHG14)
708-14 SPN 520219 (IPPC) (GHG14)
707-14 SPN 520229 FMI 3 (IPPC) (GHG14
702-14 SPN 520230FMI 5 (IPPC)(GHG14)
14-028 Remy Extended Coverage Direct File
14-027 Detroit's New Consolidated Labor Operations (CLOs
14-023 Detroit Axles Pre-Approval Changes
14-022 Pre-Approval Threshold Increase From $2,500 to $5,000 USD
16TL4 DOC Face Cleaning Tool P N W470589239100
16TS5 Release of the DD Platform Bearing Failure Guide
0304-16 SPN 2791 (MCM) ( GHG14) and SPN 2791 (MCM) ( GHG17)
0307-16 SPN 723 (MCM) March
0301-16 SPN 625 (CPC) (EPA07) and SPN 625 (CPC) (EPA10 GHG14)
Contaminated Fluids
Hydrocarbon Doser Coolant Lines
16-009R_OWL Enhancements
New Detroit Bearing Failure Analysis Standard Diagnostic Time
FL676 Second Revised Bulletin
17-026 Holiday Closure 2017
17TL27 Injector Cup Tool DSN930E17001
17TL26 Injector Heat Sleeve Removal Tool DSN930E17002
17CSA25 New Method for Uploading Diagnostic Log Files to the CSC
17CSA24 Holiday Schedule for the Detroit Customer Support Center
17CSA23r Detroit CSC closed December 14, 2017 from 11:15 am - 1:15 pm Eastern Time
12-039-DLR OWL Pre-approval's Time Frame Increases to 60 Days
15-028 New Detroit Coolant Line SRTs
Detroit Data Summaries Application and Kits Are No Longer Available Through PDC
_NewDetroitCoolantLineSRTs
13wo3rev2_final Actual Labor Hours on Detroit Claims
0229-14 Symptom Based Diagnostics - Oil Separator
0233-14 SPN 51 FMI 2 - All Years
0224-14 SPN 1590 FMI 9 - CPC- All Years February 2014
49-31 - New DEF Injector Guard
14TS20 GHG14 Auto-Elevate Feature
801-14 FMI 19: RCM Message Not Received or Stopped Arriving
14-017R Revised: Detroit Addition of Admin Time
14-029 New Detroit Standard Diagnostic Times
FL662.-DLR Meritor MSF12 Non-Conforming Front Axle Beams
14-038_New_SRTs Additional Detroit Standard Repair Times.
14-039_additional_SDTs New Detroit Standard Diagnostic Times
14TL8 TorcUP? Non-Impacting Torque Tool.
14TS28 DD Platform Belt Drive System - Belt Part Numbers and diagnostics
1003-14 Rough Running or Stalling.
1009-14 SPN 5016 (ACM) (GHG14)
1007-14 SPN 5016/FMI 3, 4 (ACM) (EPA10)
1006-14 SPN 4374 (ACM) (GHG14)
1008-14 SPN 3510FMI 4,7, and 8 (CPC)(GHG14)
1010-14 SPN 2623 (CPC) (GHG14)
14CSA23 CSC Announces ?Tech Tips? ? DDCSN
14CSA21 Holiday Schedule for the Detroit Customer Support Center ?
14-039 New Detroit Standard Diagnostic Times
14-038 Additional Detroit Standard Repair Times
sb2080 Australian CST M1400 Isolated Radiator Retrofit
sb0039 New "Natural Gas Vehicles Information" Webpage
1108-14 SPN 636 (MCM) (EPA07;EPA10;GHG14)
18SP711 DD15 and DD16 Axial Power Turbine Bracket Ki
912-14 Coolant in Oil
914-14 Ambient and Inlet Manifold Pressure Difference (High Box)
920-14 Additional Cleaning and Preparing
906-14 Installation of the Oil Pan
917-14 Installation and Removal of the Oil Filter Stand Pipe
54-267 Business Class M2 and 108SD114SD Virtual Technician
16TS25 Single-Speed Fan Operation
COPY OF TO_BE_POSTED_15M3_SNL_11-NOV-2015
1021-16 SPN 110 (MCM)(EPA07EPA07;GHG14), SPN 110 (CPC)(GHG14)
1018-16 SYMPTOM DIAGNOSTICS - NOISE
16TS18 EPA10 AND LATER DD AUTO-ELEVATE FEATURE
0810-16 SYMPTOM DIAGNOSTIC NOISE
0809-16 SYMPTOM DIAGNOSTICS : NOISY 1- BOX AFTERTREATMENT
FREIGHTLINER: TRUCK PARKED AND TURNED OFF FOR EXTENDED TIME WILL HAVE ICE EXPANSION BREAKING DEF HEADER, IF FREEZES, UNDER EXTREME COLD CONDITIONS.
Read full bulletin
MODEL BUSINESS CLASS M2, 108SD/114SD. NO YEARS LISTED. *PE
FREIGHTLINER: DEMAND FOR NATURAL GAS IS BEING RESPONDED TO AND A NEW RESOURCE WAS ESTABLISHED WHERE AN ACCESSED TO...
Read full bulletin
VARIETY OF MATERIALS WILL BE FROM ONE CONVENIENT LOCATION. MODEL BUSINESS CLASS M2, CASCADIA, 108SD/114SD. *PE
Engine
104 bulletinsCX Advocate for turbo oil drain cracking
CX Advocate for turbo oil drain cracking
CX Advocate for DD13 Gen 5 engines operating at high altitude experience EGR slow response fault.
CX Advocate for Legacy M2 Misrated Engines in Emergency Vehicles (SF695)
Important Campaign Information Letter for SF695 Cummins Engine Emergency Vehicle Calibration
Daimler Trucks North America LLC (DTNA), on behalf of its Freightliner Trucks Division, has decided that a defect that...
Read full bulletin
relates to motor vehicle safety exists on specific model year 2014 through 2019 Freightliner Business Class M2 vehicles manufactured October 17, 2013, through September 25, 2018 and equipped with a Mahle-Bahr radiator. Contact your DTNA dealer to schedule a service date to perform the recall. Refer to the included communication from DTNA for additional information.
Detroit Emission Recall for GHG14 DETROIT DD13 with Two-Box Aftertreatment Software Reprogramming.
Read full bulletin
Certain Detroit Model Year 2013 to 2015 GHG14 DD13 engines that are registered in the state of California will require reprogramming to a minimum of the MCM and ACM software versions.
Detroit Technical Service Letter for DD13 Cylinder Head and Cylinder Head Gasket Change.
FL740 Brake Check Valve
DDC Field Service Campaign for GHG14 DETROIT DD13 with One-Box Aftertreatment Software Reprogramming.
Read full bulletin
Certain Detroit Model Year 2013 to 2015 GHG14 DD13 engines that are registered in California will require reprogramming to a minimum of the MCM software version and fuel map version listed below: MCM Software Version 4.7.0.0 ZGS 005.
Training Solutions for Fuel Leak Found at High Pressure Fuel Pump Weep Hole for Heavy Duty DD Engines.
Read full bulletin
Occasionally we see trucks come in with fuel leaking from the high pressure fuel pump weep hole. This is NOT a defect in the pump and further diagnostics need to be performed to find the root cause.
Updated DDC Field Service Campaign for GHG14 DETROIT DD13 with Two-Box Aftertreatment Software Reprogramming.
Read full bulletin
Certain Detroit Model Year 2013 to 2015 GHG14 DD13 engines that are registered in California will require reprogramming to a minimum of the MCM software version and fuel map version listed below: MCM Software Version 4.7.0.0 ZGS 005. Certain sections have been updated for clarity.
Warranty Information Letter for Warranty Long Block Program Change.
Read full bulletin
The Detroit Reman Long Block Program has expanded. The expansion reduces complexity in ordering reman engines and promotes stocking reman engines to meet uptime commitments.
Service Systems Development provided document to service locations on price list reflects current charges to engine...
Read full bulletin
horsepower ratings for HDEP and MDEG engine platforms.
Service Information Bulletin to updated the Fuel Injector Harness sections and relocated to Engine Electrical section.
Service Bulletin to testing of EGR Cooler Water Manifold Assembly in DD13 engines.
HDEP GHG17 engines are not equipped with turbo wastegates.
Read full bulletin
Steps in this troubleshooting involving wastegates were removed.
This service kit includes all necessary parts to replace the high pressure fuel rail feed lines, mounting bracket,...
Read full bulletin
P-clips and mounting hardware in the event one of these parts are loosened, removed or missing from the engine.
Service Information Bulletin- Oil Present at the Turbocharger Compressor Housing
New Detroit Diesel Cylinder Liner Upper O-Ring Leak Test Standard Repair Time
Engine Manufacturer Diagnostics
aeo18M1 GHG14 Heavy Duty Engine Platform Vocational Application Programming
15TS4 EPA07 DD15 Piston Kits
15TS2 EPA07 and EPA10 DD Platform Engines With Low Oil Pressure Codes
15TS1 GHG14 DD Platform Engines With Codes SPN: 1323 through SPN: 1328, FMI: 31, Idle Smoothness Control/Cylinder...
Read full bulletin
Misfire At Idle
GHG14 - Intake Manifold Pressure Too Low
GHG14 Intake Manifold Pressure Too Low
0202-17 DD13, DD15, and DD16 Cylinder Head Assembly Removal and Installation
308-15 Symptom Diagnostics - Oil Present at the Turbocharger Compressor
302-15 Crankshaft Oil Seals
18SP706 Replacement of the High Pressure Fuel Pump Camshaft Oil Seal
14TS16 Excessive Overhead Engine Noise on DD Platform Engines
524-14 FMI 0: Engine Speed High
SS 1033425 Cruise Control Not Working When Replacing ICU3 With ICU3S M2 Vehicles With Caterpillar Engine Only
18SP705Rev4 18SP701Rev GHG14 Two-Filter Fuel System KM63 GEN2 DD15AT Engines High Pressure Fuel Feed Lines, Mounting...
Read full bulletin
Bracket and P-clip
18SP701Rev GHG14 Two-Filter Fuel System KM63 GEN2 DD15AT Engines High Pressure Fuel Feed Lines, Mounting Bracket and...
Read full bulletin
P-clips
sb2084 OAT Coolant Replaces NOAT Coolant in Detroit Engines
sb0175 Replacing Drive Belts on MBE4000 EnginesB
sb0164 MBE Engine Support Information
sb0006 Freightliner Courtesy Engineering PolicyB
15TS6 Replacement of the High Pressure Fuel Pump Camshaft Oil Seal
FL672-DLR Auto-Apply Park Brake Solenoid Valves
15TS14 GHG14 DD Engine Cylinder Liner Seal Replacement
708-15 High Pressure Fuel Pump Camshaft Oil Seal - Two-Filter System
711-15 High Pressure Fuel Pump Camshaft Oil Seal - Three-Filter System
702-15 DD15 and DD16 Delphi Exhaust Gas Recirculation Valve Actuator
703-15 GHG14 DD15 AT Exhaust Gas Recirculation Valve Actuator
803-15 Removal of the Camshaft Housing
Brake Check Valve
Heavy Duty Engine Wastegate Repair Kit DKI470E16019
0120-17 Diagnostic Test - Engine Oil Leaks - Oil Developer Method
0118-17 Symptom Diagnostics - Oil Leaks
15TL24 OTC 1750 Revolver Engine Stand
15TS4_Rev2_ EPA07 DD15 Piston Kits
1210-14 Cylinder Head
1201-15 Crankshaft and Bearings
15TS10Rev DD Engine Platform Coolant Filter
401-15 Cylinder Block
15TS13 DD Platform Oil Filter Bypass Valve
15TS12 DD Platform Cylinder Block Oil Gallery Cup Plug Replacement
501-15 Engine Lifter Brackets
504-15 DD13 Exhaust Gas Recirculation Valve Actuator Pull Rod
511-15 DD15 and DD16 Exhaust Gas Recirculation Valve Actuator Pull Rod
503-15 DD13 Exhaust Gas Recirculation Valve Actuator
sb2084 OAT Coolant Replaces NOAT Coolant in Detroit Engines
15TL4 W470589050900 ? 3/8? Drive GEN2 Two-Stage Valve Socket
308-15 Symptom Diagnostics - Oil Present at the Turbocharger Compressor
302-15 Crankshaft Oil Seals
18SP706 Replacement of the High Pressure Fuel Pump Camshaft Oil Seal
sb01101 Pilot Bearing Spacer for Detroit Engines with Eaton transmissions
14TL2 DD Platform Engine Stand Adapter W060589023100
14TS18 GHG14 DD Engine EGR System Fault Code
714-14 Symptom Diagnostics - Low Engine Compression
712-14 Engine Coolant Temperature
20-73 - CANCELED: Cascadia Radiator Update?EPA10 with DDC Engines
20-75 - CANCELED: Cascadia Radiator Update?EPA10 with Cummins ISX Engines
16TS8 DD13 Cylinder Head and Cylinder Head Gasket Change
16-011 New Detroit Camshaft Housing Seal Standard Repair Time
sb4724 Crank No Start, Loss of Engine Prime on Decked Vehicles
12-038-DLR - No Problem Found - Policy Claims - During Basic Vehicle Chassis or Base Engine Coverage
14TS4 Valve and Liner Installation Tool Issue
0228-14 Engine Oil Leaks - Oil Dye Method
0237-14 Engine Brake Solenoid
14TS21 HDEP Camshaft Position Sensor Change
804-14 FMI 16, 18 Intake Manifold Pressure Too high and low (Restricted Mode)
803-14 FMI 16,18: Intake Manifold Pressure Too High and Low
812-14 FMI 3, 4: Engine Aux.
Read full bulletin
Shutdown Input Failed High and Low
14-040_Additional_CLOs Additional Detroit CLOs for the Heavy Duty Engine Platform
14CSA20 EGR Valve Actuator Kit P/N E23539699
14-040 Additional Detroit CLOs for the Heavy Duty Engine Platform
1102-14 DD13 Cylinder Head R&R
1101-14 DD15 and DD16 Cylinder Head
14TS26 Replacement of the High Pressure Fuel Pump Camshaft Oil Seal
913-14 Checking for Poor Engine Brake Performance
915-14 Backwards Running Engine Detecte
18SP706 Replacement of the High Pressure Fuel Pump Camshaft Oil Seal
18SP701Rev3 GHG14 Two-Filter Fuel System KM63 GEN2 DD15AT Engines High Pressure Fuel Feed Lines, Mounting Bracket and...
Read full bulletin
P-clips Service Kit
16TS24 GHG14 DD Platform Engines With Code SPN: 3216/FMI 18, SCR Inlet NOx Sensor Drift Low
14TS16REV EXCESSIVE OVERHEAD ENGINE NOISE ON GHG14 DD PLATFORM ENGINES
SB0006 FREIGHTLINER COURTESY ENGINEERING POLICY
1017-16 ENGINE MODEL AND SERIAL NUMBER DESIGNATION
16TL20 HEAVY DUTY ENGINE VALVE STEM SEAL INSTALLING DRIFT AND SLEEVE
0909-16 EXCESSIVE OIL CONSUMPTION
FREIGHTLINER: ON THE FORWARD REAR DIFFERENTIAL, WITH EXTERNAL BREATHER, IS AN OIL LEAK, AND NOW AN INTERNAL BREATHER...
Read full bulletin
REMEDY IS AVAILABLE FOR INSTALLATION. MODEL FLD CONVENTIONAL, CENTURY CLASS CONVENTIONAL, ARGOSY COE, COLUMBIA, BUSINESS CLASS M2, CASCADIA. *PE
Fuel System
79 bulletinsWarranty Information letter announcing that DTNA is increasing the Standard Diagnostic Times (SDTs) shown.
Read full bulletin
The updated after treatment system (ATS) diesel exhaust fluid (DEF) pump times will be applied to repair orders opened on or after April 12, 2021.
Revised letter is to announce a reimbursement available to dealers for travel to a customer's location to perform a recall or field service campaign.
Read full bulletin
Potential travel reimbursement applies to DTNA truck dealers and Detroit Diesel distributors. Thomas Built Buses will be addressed separately.
Technical Service Letter for EPA10, GHG14, GHG17 Diesel Particulate Filter (DPF) Compatibility.
Read full bulletin
Note: This document supersedes 14 TS-25 and 15 TS-8. Detroit Diesel has determined that some, Diesel Particulate Filters (DPFs) are compatible in pairs and or can be mixed together within EPA10 and GHG14 Systems. For 1-BOX and Two-Box Configuration Aftertreatment Systems (ATS), this is only possible when the filters are used in accordance with Tables 1 and 2 shown below. All other DPFs, NOT mentioned below, are NOT compatible.
Customer Service Announcement informing that Service Pack (SP) 1 for DiagnosticLink 8.12 Standard and Professional is...
Read full bulletin
available to download from the Detroit Diesel server.
Customer Service Announcement saying that Service Pack (SP) 3 for DiagnosticLink 8.11 Standard and Professional will be...
Read full bulletin
available for download from the Detroit Diesel server.
Service Bulletin for Equiflo Fuel System Breather Tube Inspection
Service Information Bulletin for Symptom Diagnostics - Fluid in the Aftertreatment - Diesel Fuel Contamination.
Fuel Level Sending Unit Retrofit
Fuel Level Sending Unit Retrofit
Service Information Bulletin- Exhaust Gas Recirculation Crossover Pipe
owner18R3 Emission Recall D18R3
GHG14_18R3_bulletin_07-MAY-2018a Emission Recall D18R3
owner18R3 Emission Recall D18R3
GHG14-18R3 bulletin-07-MAY-2018a-Emission Recall D18R3
102-15 High Pressure Fuel Pump - Two-Filter System
18SP687 DD15 16 EGR Actuator Replacement
FL721 CNG Fuel Tank and CPDM Mounting Location
18SP712 EPA07 DD15/16 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel System Conversion Service Kit
18SP713 EPA10 DD13 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel System Conversion Service Kit
18SP714 EPA10 DD15/16 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel System Conversion Service Kit
14TS13Rev EPA10/GHG14 Diesel Exhaust Fluid (DEF) in Fuel System/Diesel Fuel in DEF System Contamination
505-14 Fuel Cooler Leak Test Procedure - Three-Filter Fuel System
504-14 Test-E - Three-Filter Fuel System
513-14 FMI 0: Diesel Particulate Filter Outlet Temperature - Very High
515-14 FMI 1: Over Pressurized Diesel Exhaust Fluid System
501-14 Removal and Installation of the DD13 Exhaust Flanged Manifold
sb54296 Fuel Level Sending Unit RetrofitB
sb54148 Radio and Integrated Thin-Film Antenna Troubleshooting, and Field Service UpdatesB
sb49040 Diesel Exhaust Fluid (DEF) Pressure Line Disconnected at the Doser ConnectionB
fsb49040 Conduite sous pression de fluide pour chappement diesel (DEF) dbranche au niveau du raccordement du doseur
15TS8 EPA10 and GHG14 Diesel Particulate Filter (DPF) Compatibility
0202-15 EPA10 and GHG14 Diesel Oxidation Catalyst Face Cleaning
FL671-DLR Exhaust Discharge Location
EPA10, GHG14 and GHG17 Diesel Particulate Filters
Exhaust and Exhaust Gas Recirculation
Diesel Exhaust Fluid (DEF) Pressure Line Disconnected at the Doser Connection
SPN 4765 FMI 0 - Exhaust Temperature Out Of Range High
15TL6 W470589129100 ? HDEP HP Fuel Rail Test Caps
18SP717 DD13 EGR Actuator Replacement
509-15 Symptom Diagnostics - Hard Start/No Start - Three-Filter Fuel
512-15 GHG14 DD15 AT Exhaust Gas Recirculation Actuator Pull Rod
502-15 Exhaust Gas Recirculation Actuator Lever
18SP716 Installation/Replacement of the Fuel Cooler Delete Bypass Plate for the Two-Filter Fuel System
15-017 Detroit: Updated Fuel Injector SDTs
18SP712 EPA07 DD15/16 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel System Conversion Service Kit
18SP713 EPA10 DD13 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel System Conversion Service Kit
18SP714 EPA10 DD15/16 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel System Conversion Service Kit
14TS19 DD Platform High Pressure Fuel Lines
18SP701Rev2 18SP701Rev2? GHG14 Two-Filter Fuel System
16TS9 DD Platform High Pressure Fuel Lines
16TS7 Reman Diesel Particulate Filter Serial Number
17TL28 Fuel Injector Removal Tool DSN930E17004
0239-14 High Pressure Fuel Injector Lines - Three-Filter System
0238-14 Removal of the High Pressure Fuel Injector Lines - Two-Filter
0210-14 High Pressure Fuel Rail Feed Lines - Three-Filter System
0209-14 High Pressure Fuel Rail Feed Lines - Two-Filter System
0219-14 Metal in Fuel
0202-14 Symptom Diagnostics - Hard Start No Start - Two-Filter Fuel System
0215-14 Check for Rough Running or Stalling - Three-Filter Fuel System
54-281 - Fuel Level Sender Guard Installation
18SP703 18SP703 - GHG14 KM63 GEN2 Low Pressure Fuel Pump-Two-Filter Fuel System Ki
14TS19Rev DD Platform High Pressure Fuel Lines
1104-14 Metal in the Fuel System
18SP707Rev EPA07/10 Three-Filter Fuel System DD13 High Pressure Fuel Feed Lines, Mounting Bracket and P-clips Service...
Read full bulletin
Kit
18SP708Rev EPA07 10 Three-Filter Fuel
14TS25 EPA10 and GHG14 Diesel Particulate Filter (DPF) Compatibility
910-14 Installation of the High Pressure Fuel Rail Feed Lines - Two-Filter System
918-14 Removal and Installation and Inspection of the Fuel Cooler Delete Bypass Plate - Two Filter System
916-14 Fuel Cooler Leak Test Procedure - Two-Filter Fuel System
908-14 908-14 EGR Differential Pressure Failed (High Box)
919-14 Exhaust Gas Recirculation Flow Target Error Diagnostic - High Flow
18SP687 18SP687 DD15/16 EGR Actuator Replacement Service Kit
18SP719Rev EPA10 DD13 Three-Filter ESOC Fuel System to Two-Filter KM59 GEN1 Fuel
18SP714Rev EPA10 DD1516 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel
18SP725 TWO-FILTER FUEL SYSTEM KM63 GEN2 DD13 HIGH PRESSURE FUEL FEED LINES, MOUNTING BRACKET AND P-CLIPS SERVICE KIT
18SP722 DD13 KM59 GEN1 BUS TWO-FILTER SYSTEM AMPLIFIER, NEEDLE AND PLV RETURN FUEL LINE CLEARANCE PACKAGE SERVICE KIT
1020-16 CHASSIS FUEL SYSTEM ISOLATION TEST
18SP720REV 18SP720 EPA10 DD15/16 THREE-FILTER ESOC FUEL SYSTEM TO TWO-FILTER KM59 GEN1 FUEL SYSTEM CONVERSION SERVICE...
Read full bulletin
KIT
0906-16 LOW PRESSURE FUEL PUMP
Electrical
67 bulletinsService Solution for M2, 108SD, 114SD - Unable to Program Replacement Bulkhead Module - Certain Model Years
Service Solution for Legacy M2 Bulkhead Module (BHM) Replacement and DiagnosticLink Issues
Service Solution for Legacy M2 Bulkhead Module (BHM) Replacement and Diagnosticlink Issue
Parts Bulletin for Powertrain Power Distribution Module (PTPDM) Kit Replacement
CX Advocate for bulkhead module reprogramming (SS 3146-FTL)
Service Solution for M2, 108SD, 114SD - Unable to Program Replacement Bulkhead Module - Certain Model Years
Service Solution for M2, 108SD, 114SD - Unable to Program Replacement Bulkhead Module - Certain Model Years
SS 1032728 Bulkhead Module Fault Codes 524280 thru 524286 with FMI 7 Clarification
Service Solution SS 1033047 M2 Battery Drain Problem Mismatched I...
Service Solution SS 1033094 KUS Float Tube Fuel Level Sensor Inform...
Warranty Policy Letter for battery tags.
Read full bulletin
DTNA determined that since adopting the AutoMeter BCT-460DTNA Powernet Assessment Tool (AutoMeter) as the required powernet system tester, not all battery tags have to be retained support Warranty-related claims.
Freightliner Service Bulletin for Programming Chassis Electronic Control Units (ECUs) With DiagnosticLink.
Warranty Information Letter for Detroit NOx Sensor Circuit Fault Codes - Claim Guidelines.
Tech Talk discussion on ECM not seeing PTO On signal.
Updated Freightliner Service Bulletin for Powernet Troubleshooting Guide - Batteries, Path, Alternator, and Starter.
Read full bulletin
This bulletin replaces the version dated 5/31/2017. Information is added about the BCT-460DTNA PowerNet Assessment Tool. When troubleshooting Powernet issues, use the BCT-460DTNA PowerNet Assessment Tool. As of May 29, 2018, the AutoMeter is the only Daimler-approved tool for troubleshooting vehicle Powernet issues.
Customer Advisory Letter for inspection of the M2 chassis module.
Read full bulletin
Inspecting for heat damage on Pin J and Pin S.
Service Bulletin for Guidelines for Repairing or Replacing an Electrical Harness.
Read full bulletin
Use the guidelines in this bulletin to determine if a damaged electrical harness should be repaired or replaced.
Service Bulletin on guidelines for repairing or replacing an electrical harness.
Warranty Information Letter announcing Detroit NOx Sensor Circuit Improvements for GHG17 After Treatment Systems
Service Bulletin about the powertrain PDM and Main PDM bracket being modified to reduce stress and vibration to the...
Read full bulletin
Powertrain Power Distribution Module (PTPDM).
Service bulletin describing that the DiagnoticLink screen images for Chassis ECU programming have ben updated.
Service Bulletin to provide instructions to replace Ignition Control System.The ICU3 is no longer installed in...
Read full bulletin
production, and has been superseded by the ICU3S. When replacing an ICU3, the ICU3S must be installed in its place.
Service Information Bulletin for Communication Loss with a Common Powertrain Controller (CPC) Module (CPC Heartbeat...
Read full bulletin
Message is no Longer Arriving)
DiagnosticLink support programming of both chassis and powertrain ECUs
SS 1034220 SSI Ultrasonic Fuel Level Sensor Information
sb54308 Chassis ECU Programming
Service Bulletin- Chassis ECU Programming
Alternator Remote Sense Wiring
0311-18 Installation of the Main Shaft Speed Sensor
15TS9 Hydrocarbon Doser Block Fuel Compensation Pressure Sensor
326-15 Main Shaft Speed Sensor
503-14 FMI 3, 4: High Side Digital Output 3 Circuit Failed High
511-14 FMI 9 Soot Sensor Communication Error
520-14 FMI 2 Soot Sensor Heater Faul
523-14 FMI 18: Soot Sensor Temperature Low
sb15020 Alternator Remote Sense WiringB
54-275 - Chassis-Mounted Trailer PDM, Battery Power Cable Terminal Corrosion
sb54278 Powernet Troubleshooting Guide: Batteries, Path, Alternator
802-15 SPN 520970 FMI 7 (TCM)
801-15 SPN 520999 FMI 7 (TCM)
0311-18 Installation of the Main Shaft Speed Sensor
SPN 521221 (TCM)
SPN 521222 (TCM)
1205-15 Selective Catalyst Reduction (SCR) Inlet Temperature Sensor
FMI 3,4,5 Digital Output 2 10 Circuit
15-016-DLR New Essential Tool For CPWA, CPPRA, Ltd CPPRA, & DSDWC Parties: Cadex CA-12 Battery Tester
15TS9 Hydrocarbon Doser Block Fuel Compensation Pressure Sensor
326-15 Main Shaft Speed Sensor
54-285 - Cracked Fuses on Powertrain Power Distribution Modules
16TL5 DD Platform Aftertreatment Soot Sensor Socket DSN0ATZ16001
16_TL-2 DD Platform Aftertreatment NOx Sensor Socket W470589060900
14TS5 Replacing Damaged Aftertreatment Sensor Bosses
809-14 FMI 3, 4, 5, 31: Diesel Exhaust Fluid System Circuit Failed
802-14 FMI 3, 4: Diesel Exhaust Fluid Pressure Sensor Circuit Failed High and low
1005-14 Oil Coolant Module
14CSA22 DTNA Chassis Wiring Diagrams
18SP684Rev4 18SP684Rev4 ? EPA07 and EPA10 DD Platform EGR Delta Pressure Sensor Update
18SP705Rev5 18SP705Rev5 ? DD Platform Delta Pressure Sensor
sb54287 Powernet Distribution Box Fuse Retention on the Keep-Alive
sbw5460 Powernet Distribution Box Fuse Retention on the Keep-Alive
905-14 Coolant Level Circuit Failed
903-14 Selective Catalyst Reduction Inlet NOx Sensor Circuit Failed High and Low
904-14 Selective Catalyst Reduction Outlet NOx Sensor Circuit Failed High and Low
911-14 5V Sensor Supply Bank 2 Circuit Failed High
909-14 Diesel Exhaust Fluid Metering Unit Air Pressure Sensor Circuit Failed High and Low
16TL17 LABEL UPDATE FOR GHG14 TEST AFTERTREATMENT CONTROL MODULE (ACM)
FREIGHTLINER: DUE TO POOR FUSE RETENTION FOR POWERNET DISTRIBUTION BOX (PNDB) MODULES ON KEEP ALIVE CIRCUITS, AN...
Read full bulletin
OPERATION ON ANY DEVICES SUPPLIED BY THESE CIRCUITS WILL BE INTERMITTENT. MODEL 122SD/CORONADO, BUSINESS CLASS M2, CASCADIA, 108SD/114SD. *PE
Pre-Delivery & Maintenance
49 bulletinsImportant Campaign Information letter for SF695 Campaign Replaced by F1012
Revised Important Campaign Inofrmation letter for SF671 - Bulletin Revision.
Read full bulletin
REVISION: 3 new SRTs and repair procedures have been created to address specific issues that arise during the repair.
Important Campaign Information letter for SF671 Campaign Suspended
Important Campaign Information letter for SF671 - Bulletin Revision.
Read full bulletin
REVISION: If you find modifications to the chassis, please submit a WSC Inquiry before beginning any additional work.
Freightliner Service Bulletin for DEF Connector Reinforcement Caps.
Service Solution SS 1032989 BHM Fault Code Changes
Service Solution SS 1033180 BHM Fault Code SPN 524251 FMI 7 - Extr...
Service Solution SS 1033289 BHM Fault Code SPN 524249 / FMI 7
Revised Warranty Information Letter for OWL and Warranty Manual Improvement: Sublets and Travel Time/Distance.
Read full bulletin
In the spirit of continuous improvement, DTNA reviewed sublet-related policies and procedures. The goal was to improve language clarity and optimize processes. Revisions are in blue font.
Service Bulletin for Powertrain PDM and Main PDM Bracket Modication.
Read full bulletin
This bulletin replaces the version dated 10/31/2019. The build date section has been added.
Important Campaign Information letter announcing Dealer Travel for Campaign Performance.
Read full bulletin
This letter is to announce a reimbursement available to dealers for travel to a customers location to perform a recall or field service campaign.
Warranty Information Letter for OWL and Warranty Manual Improvement: Sublets and Travel Time/Distance.
Read full bulletin
In the spirit of continuous improvement, DTNA reviewed sublet-related policies and procedures. The goal was to improve language clarity and optimize processes.
Warranty Information Letter informing that to ensure that DTNA policies and service network practices align, the...
Read full bulletin
Warranty Department will be revising the Warranty Manual.
Service Bulletin for Guidelines for Cleaning and Disinfecting Cab Surfaces.
Read full bulletin
The following guidelines are for cleaning and disinfecting commonly touched surfaces on the inside and outside of a vehicle. For best results, follow cleaning and disinfecting procedures fully and consistently. Ensure there is adequate ventilation when using chemicals. NOTICE: Wipe down fragile components carefully to avoid damaging the vehicle.
Warranty Information Letter for Warranty Training Online.
Read full bulletin
DTNA is pleased to announce the release of new Warranty-related training videos. The videos provide Warranty content in short instructional videos that are available on demand through the AftermarkeTV Video Channel icon on the Aftermarket Resource Center (ARC) home page.
Warranty Policy Letter for Handling for Authorized Service Location Part Transfers.
Read full bulletin
To promote 24-hour throughput and maximum efficiency, DTNA is adjusting multiple handling policies: Launching a new handling allowance for parts ordered from another Authorized Service Location because the facing Part Distribution Center (PDC) is out of stock Retiring Detroit's Customer First Program
Open recall and Field service Campaigns report send out to Dealers, General Managers, Service managers and warranty...
Read full bulletin
managers.
Freightliner Service Bulletin for vibration troubleshooting - finding the cause.
Read full bulletin
This version replaces the version dated 5/1/14 and adds New Cascadia.
Warranty Policy Letter explaining the Warranty Department is aligning with the frame rail repair policy, published in...
Read full bulletin
DTNA Workshop Manuals, which states that there are very few cases in which welding a heat-treated frame rail is allowed. Therefore, before welding anything on a frame rail, contact the applicable regional service representative for approval.
Open recall and Field service Campaigns report send out to Dealers, General Managers, Service managers and warranty...
Read full bulletin
managers
Important Campaign Information Letter announcing that a revision for D19M4 as a REV2 exists and is available on...
Read full bulletin
DTNAConnect.
Service Bulletin for severe duty main PDM installation for vehicles operating in severe moisture and/or corrosive...
Read full bulletin
environments.
Technical Service Letter communicating that information on DD Heavy Duty Platform Belt and Belt Tensioner can be found...
Read full bulletin
on TechLit.
Communication to assist the field with service vibration issues on DTNA vehicles
Warranty Policy Letter to communicate Detroit Return Changes
Warranty Information Letter to announce addition of Thomas Built Bus as a brand with an Authorized Demonstrator Program
Warranty Information Letter sent to customers regarding new refrigerator supplier for returning parts.
Service Bulletin provided to customers regarding ICU3 to ICU3S Replacement
Training Solution created by DTNA to provide guidance to customers when searching for service information for components...
Read full bulletin
and systems not owned by Daimler Trucks North America (DTNA).
Service Bulletin- sb54311 ICU Odometer Programming
Service Information Bulletin
Service Bulletin New "Natural Gas Vehicle Information" Webpage
Warranty Bulletin for charge back exemtions
Release of DiagnosticLink 8.08 Service Pack 2
If a GVWR certification label is lost or damaged, Freightliner will supply a duplicate label.
Read full bulletin
Log on to DTNAConnect.com and under "DTNAConnect Resources", select the "Tool and Services" plus sign. Select "Request for Certification Label or OWI." Fillout the form, then select "Review."
sb83155 Espar Service Information
sb54194 Required Maintenance for Freightliner-Branded and Delco Cassette Players
sb54122 ICU3 Service Cluster AvailableB
Transport Dealer Air Leak Inspection
15-015 Warranty Exclusions Reminder
14-026-DLR SelecTruck Warranty Enhancements
Canadian Warranty Parts Return Address Change
OWL Enhancement Service Model Field
Warranty Classroom Training in 2018
12-041-DLR Over the Counter No Hassle Warranty (OTC)
_Warranty Recognition Program - Coming Soon
14WO-9_Warranty_Access Detroit New User Warranty Access Request
14TL9 Special Tool Warranty Program.
16TS14 EPA10 AND GHG14 SERVICE REPLACEMENT 1-BOX DOC INLET CHANGE
Brakes
24 bulletinsRear Brake Calipers and Anchor Plates.
Tech Talk continuing discussion on HSA pulses on and off when brake is pressed.
Tech Talk discussion on HSA pulses on and off when brake is pressed.
Service Solution for M2 ABS Wiring Harness Rubs On Forward Cab Mount.
Read full bulletin
ABS chassis harness is rubbing on the rear of the driver side forward cab mounting bracket on M2 106 trucks with a 160 MM Cab Hgt. This may cause open or shorted circuits in multiple wires in the harness transitioning from the chassis to the cab. Noticeable symptoms include illumination of the ABS and ATC indictor lamps.
FL724 ICU3S Instrument Cluster Hydraulic Brake Telltale
Service Solution 1033889- Hydromax Hydraulic Brake Booster Pump Function Logic
SS 1033322 ABS light illuminating in ICU, ABS solenoids will not self-check
FL705 Bendix Rear Brake Calipers
sb60157 Roof Noise, M2 and 108SD/114SD Day Cabs
sb60157 Roof Noise, M2 and 108SD 114SD Day CabsB
sb4256 Enabling M2 Exhaust Brake Lights
fsb42073 Inspection d'absence de fuites d'air par les transporteurs concessionnaires
FL705 Bendix Rear Brake Calipers
FL677 Bosch Hydro-Max Park Brake Interlock Switch
SS 1033322 ABS light illuminating in ICU, ABS solenoids will not self-check
Roof Noise, M2 and 108SD 114SD Day Cabs
sb4267 Brake Shimmy - Meritor SteeLite X30 Brake Drum with Excessive Runout
FL677-DLR Bosch Hydro-Max Park Brake Interlock Switch
sb60157 Roof Noise, M2 and 108SD/114SD Day Cabs
14TL5 ABS Power Line Carrier Converter Available Through PDC
Haldex Life Seal Brake Chambers
16TL3 Pocket iQ? ABS Product Family Kit is Available at PDC
BENDIX REAR BRAKE CALIPERS
FREIGHTLINER: WHEN ADDING COMPONENTS, MOST OFTEN NEED ACCESS TO 12 VOLT BRAKE SIGNAL LIGHT, TO VEHICLE.
Read full bulletin
*PE
Body & Paint
23 bulletinsRevised Field Service Campaign for Beverage Body Frame Rail 50 KSI
Revised Field Service Campaign for Beverage Body Frame Rail 50 KSI
Revised Field Service Campaign for Beverage Body Frame Rail 50 KSI.
Read full bulletin
REVISION: 3 new SRTs and repair procedures have been created to address specific issues that arise during the repair.
Revised Field Service Campaign for Beverage Body Frame Rail 50 KSI.
Read full bulletin
REVISION: 3 new SRTs and repair procedures have been created to address specific issues that arise during the repair.
Revised Field Service Campaign for Beverage Body Frame Rail 50 KSI.
Read full bulletin
REVISION: If you find modifications to the chassis, please submit a WSC Inquiry before beginning any additional work.
Field Service Campaign for Beverage Body Frame Rail 50 KSI
Service Solution SS 1032998 M2 mirror wind noise
Service Bulletin for Front Lighting Ground Splice Pack Failure.
Read full bulletin
The left and right hood lighting of these vehicles have separate ground paths to the frame and use the same splice pack parts. The splice packs are part of the hood commodity and located near the headlight assemblies. These splice packs can fail, resulting in either the left or right lighting becoming intermittent or inoperative.
Customer Service Announcement Letter Revision for Dealers/Distributors Accessing DDEC Backdoor Passwords
Warranty Information Letter - Expanded guidelines for paint-related claims sent out to Freightliner, Western star,...
Read full bulletin
Thomas Built Bus, Export and Direct warranty customers
Service Bulletin M2 Heated Windshield Modification
Service Bulletin 9810- Chassis Paint Usage
Service Bulletin 9819- Body Paint Repair Process
Freightliner M2 Roof Repair
A new design for the M2 grille went into prduction on February 5, 2018.
Read full bulletin
The hood design has also changed slightly to accommodate a different grille fastening strategy. The old grille and hood part part numbers will no longer be produced, and will supersede to the new design with new part numbers.
The right-hand cab panel on New Cascadia can come into contact with the right-hand chassis-side fairing when making a left turn.
Read full bulletin
This contact can result in an audible popping noise, paint-damage to the rocker panel and damage to the back-side of the chassis-side fairing.
0312-18 Installation Output Shaft Seal
sb9815 Paint Finish Standards
54-280 - Video Available for Servicing APEX 150 Sealed 16-Pin Connectors
sb98020 Axalta Paint Finish CareB
sb9815 Paint Finish StandardsB
0312-18 Installation Output Shaft Seal
12-040-DLR Roof Fairing Removal Program
Suspension
21 bulletinsService Solution for Thread Spring Pin Suspension Alignment & Installation
Revised Freightliner Service Bulletin for Axle Flange Gasket Replaced with O-Ring.
Read full bulletin
Revision removed steps instructing removal and installation of wheels. Daimler Trucks North America has released a new axle shaft to hub rubber O-ring (part number 11-30728-000) as a replacement for the paper gasket (part number 11-14418-000). The new O-ring will provide better sealing and is reusable. It is quicker and easier to use compared to the paper gasket, because using a paper gasket requires cleaning the hub when the axle shaft is removed.
Freightliner Service Bulletin for Axle Flange Gasket Replaced with O-Ring.
Read full bulletin
Daimler Trucks North America has released a new axle shaft to hub rubber O-ring (part number 11-30728-000) as a replacement for the paper gasket (part number 11-14418-000). The new O-ring will provide better sealing and is reusable. It is quicker and easier to use compared to the paper gasket, because using a paper gasket requires cleaning the hub when the axle shaft is removed.
Freightliner Service Bulletin for Non-Airliner Rear Suspension Crossmember Fastener Change.
Read full bulletin
With the start of production on March 2, 2020, the fasteners used to assemble the non-Airliner rear suspension (bogie) crossmember have changed. The rear suspension bogie crossmember gussets to the C-channel will be assembled with 5/8 - 18 fasteners. This change includes a revision to a higher friction nut that requires an increase in tightening torque. The new higher friction nut can be identified by its green color.
Customer Advisory Letter revision for 80KSI Frame Reinforcement Installation for certain vehicles equipped with 80KSI...
Read full bulletin
frame rails and Airliner 21,000LB rear suspensions. This version adds Model Year 2020.
Freightliner Service Bulletin for Front Axle Spacer Replacement.
Read full bulletin
This service bulletin replaces the version dated 05/01/2016. This bulletin is updated to include the parts list. Some vehicles may exhibit a lean (right or left) due to weight difference on the front suspension. While this does not affect the operation of the vehicle, it may be visually unpleasing to many customers. To correct this condition, replace the existing front axle spacer on the low side of the vehicle with a thicker one.
Customer Advisory Letter revision for 80KSI Frame Reinforcement Installation for certain vehicles equipped with 80KSI...
Read full bulletin
frame rails and Airliner 21,000LB rear suspensions. This version updates information from prior submission, 20MC5482, CAL80KSIFRAME.
Field Service Campaign revision for Detroit Axle M2 Chassis Stabilizer Bracket Inspection.
Read full bulletin
Additional information added to Parts Information.
Field Service Campaign revision for Detroit Axle M2 Chassis Stabilizer Bracket Inspection.
Service Campaign to inspect and fix stabilizer brackets for damage.
Field Service Campaign Bulletin for DetroitTM Axle M2 Chassis Stabilizer Bracket Inspection
Service Bulletin for Hendrickson HaulMaax Rear Suspension Transverse Torque Rod Tower Bracket Replacement
Service Bulletin to fix vehicles which may have an incorrect transverse torque rod tower bracket installed on the rear drive axles at the factory.
Read full bulletin
This can result in cracking at the transverse rod tower where it is welded to the axle housing, premature wearing of the transverse torque rod tapered pin and bushings, and damage to the transverse torque rod frame bracket.
SS 1034171 Airliner Rear Suspension Chassis Lean Troubleshooting
Service Bulletin: AirLiner Suspension Six-Piece Bolted Service Crossmember
With the start of production on February 12, 2018, the fasteners used to assemble Airliner rear suspension crossmembers changed.
Read full bulletin
The forward-suspension crossmember will assembled with 5/8-18 fasteners and the rear-suspension (bogie) crossmember will be assembled with 3/4-16 fasteners.
33-28 - Bearing Spacer Replacement, ConMet PreSet Steer Hubs
35-30 - Bearing Spacer Replacement, ConMet PreSet Drive Hubs
Detroit? DT12? Split Rod Bushing Repair
Warranty Recognition Program Suspension
FL718 FRONT AXLE HUB RATING
Transmission
20 bulletinsRevised Warranty Policy Letter for Alliance/Mascot Aftermarket Warranty and Claim Filing.
Read full bulletin
Revisions are in blue. With Mascot now in partnership with Detroit Reman and Alliance Parts, DTNA is pleased to announce that Mascot coverage has been added to OWL. Remanufactured Alliance/Mascot parts include transmission, differential, steering gear, and steering pump used in an on-highway vehicle applications. The Alliance/Mascot aftermarket warranty coverage period has not changed: depending on the part, coverage is for one (1) or two (2) years and current parts, labor, and reimbursement policies apply.
Warranty Policy Letter for Alliance/Mascot Aftermarket Warranty and Claim Filing.
Read full bulletin
With Mascot now in partnership with Detroit Reman and Alliance Parts, DTNA is pleased to announce that Mascot coverage has been added to OWL. Remanufactured Alliance/Mascot parts include transmission, differential, steering gear, and steering pump used in an on-highway vehicle applications. The Alliance/Mascot aftermarket warranty coverage period has not changed: depending on the part, coverage is for one (1) or two (2) years and current parts, labor, and reimbursement policies apply.
Service Bulletin for Lengthening the Backup Light Harness.
Read full bulletin
Though the backup light harness is long enough to connect to the backup light switch, it may be short enough that the wire seals in the connector can be stressed. Moisture entering through the seals can cause corrosion, resulting in a bad connection and/or failure of the switch. As a result, backup lights and, if equipped, the backup alarm, may not function when the vehicle is shifted into reverse.
Warranty Policy Letter to communicate remarketing handling cap for Detroit DT12 Transmission.
Service Bulletin- Allison Transmission Cooler Quick-Connect Fittings
26-50 - M2 Shift Cable Noise, Allison Transmissions
sb2650 M2 Shift Cable Noise, Allison Transmissions
0405-18 Symptom Diagnostics - Range Up or Down Shift Issue
sb2074 Kysor Fan Clutch Rocking Runout Inspection
sb2052 Horton Drivemaster Fan Clutch Hub Bearings
15TS15Rev Detroit? DT12? Transmission Proper Towing Procedure
sb2650 M2 Shift Cable Noise, Allison Transmissions
Detroit? DT12? Transmission Proper Moving Procedure
FMI 2- Automatic Gear Selection - Incompatible or missing dataset
Clutch Release Bearing Grease Hose
15-010-DLR Transmission Cooler Line Photos
810-14 Clutch Position Sensor
811-14 FMI 7: Internal Error with the DT12 Shift Stalk Lever
1105-14 Flywheel, Ring Gear and Flywheel Housing
FL693 EATON FR TRANSMISSION
Software & Calibration
16 bulletinsCX Advocate for NOx conversion low faults.
Read full bulletin
Update to CXA 6_24_NOx submission.
Warranty Information Letter announcing DTNA is adjusting the Standard Repair Times (SRTs) shown.
Read full bulletin
The updated times will be applied to repair orders opened on or after April 5, 2021.
Updated Freightliner Service Bulletin for Espar Service Information.
Read full bulletin
This bulletin replaces the version dated January 1, 2015. New Cascadia has been added to the model list.
Starting on November 23, 2020, DiagnosticLink 8.13 (Build 4527) was made available.
Read full bulletin
Current subscribers of DiagnosticLink 8.11 or 8.12 may upgrade to DiagnosticLink 8.13 at no cost. All DTNA Service shops & OEM locations are required to maintain the latest version of software on each of their stations.
OEM and distributor announcement for DiagnosticLink 8.12 (Build 4527) was made available.
Read full bulletin
All DTNA Service shops & OEM locations are required to maintain the latest version of software on each of their stations.
Customer Service Announcement for Release of DiagnosticLink 8.12.
Read full bulletin
On Wednesday, June 10, 2020, DiagnosticLink 8.12 will be made available for download from the ordering system. Current subscribers of DiagnosticLink 8.xx can upgrade to DiagnosticLink 8.12 at no cost. All DTNA service shops are required to maintain the latest version of software on each of their stations.
Important Campaign Information letter announcing a revision to D19M4 exists and can be found on DTNAConnect and updates...
Read full bulletin
the section on Warranty Information.
Warranty Information Letter updated to communicate warranty system updates.
Updates to troubleshooting guides in Diagnostic Link with newest version
Instrument Cluster Update
1207-15 Updated procedures with adding EPA10 to the GHG14 title
Computer Hook-Up Standard Diagnostic Time Update
FINAL_15M1_BULLETIN GHG14 DD PLATFORM SOFTWARE REPROGRAMMING FOR AUTO ELEVATE
AEO15M3 GHG14 DD PLATFORM MODEL YEAR 2015 SOFTWARE REPROGRAMMING
AEO15M1 GHG14 DD PLATFORM SOFTWARE REPROGRAMMING FOR AUTO ELEVATE
16-032_DETROIT STANDARD DIAGNOSTIC TIME FOR GHG14 AFTERTREATMENT DEVICE CHECKLIST UPDATED
Lighting
10 bulletinsCustomer Service Announcement for DiagnosticLink Software Update Reminder.
Read full bulletin
Due to various software changes and fixes, vehicles will require DiagnosticLink 8.12 to perform functional programming. Failure to use this version may cause errors, incomplete programming, and poor vehicle performance. Because of this, all DiagnosticLink 8.09 installed versions will be disabled as of Thursday, July 23, 2020.
Warranty Policy Letter for Chassis Progressive Damage Policy Change.
Read full bulletin
Effective for repair orders opened on or after April 27, 2020, if an Authorized Service Location installed a part which later has a warrantable failure, progressive damage and labor may be covered under the Aftermarket Parts Limited Parts Warranty (Parts Warranty).
Warranty Policy Letter for Handling Change: Over the Counter Aftermarket Parts Replacement Program.
Read full bulletin
DTNA is pleased to announce that handling will increase to 33% for Misc. Replacement Part type claims filed under the Over the Counter (OTC) Aftermarket Parts Replacement Program.
Customer Service Announcement for a policy change regarding Detroit Service Information Bulletins (SIBs) will now have a...
Read full bulletin
60-day expiration, starting on the release day of the bulletin. The intent of a SIB is to notify the service network of a major change to one or more service procedures. Do not save SIBs nor reference them for repairs, as they are uncontrolled and never updated.
sb2046 ABA Hose Clamp Torque Values
Some vehicles may have been incorrectly shimmed at the factory, and may lean slightly to the right or left.
Read full bulletin
While this does not affect the operation of the vehicle, it may be visually unpleasing to many customers.
sb3133 Step Clamps Are Not Reusable
14-024-DLR DTNA & JAD Highlights - Q1 & Q2
14-036-DLR DTNA & JAD Highlights - Q3
FREIGHTLINER: INFORMATION ON THE OPTION OF ADDING, TO BUSINESS CLASS M2 TRUCKS, THE DAYTIME RUNNING LIGHTS (DRL), DEPENDING ON TYPE OF TRUCK.
Read full bulletin
*PE
Tires & Wheels
9 bulletinsFL782 Interim Recall Ending - Final Recall Beginning
FL721 Interim Recall Ending ? Final Recall to Begin
14TL-7Rev DD Platform Flywheel Housing Runout Tool W470589032100
17TL25 TruckCam? Alignment System
ICI12-028-DLR FL632 - Interim Notice
14TL7 DD Platform Flywheel Housing Runout Tool W470589032100
907-14 Installation and Removal of the Flywheel Housing
0902-16 SYMPTOM DIAGNOSTICS - BELT COMING OFF, SHREDDING OR MISALIGNMENT
FREIGHTLINER: INFORMATION REGARDING THE PREVENTION OF TIRE FAILURES ON AUTO HAULERS DUE TO OVERLOADED OR INCORRECTLY...
Read full bulletin
INFLATED AND/OR EXCESSIVE SPEEDS AND TEMPERATURE. MODEL COLUMBIA, 108SD/114SD, 122SD AND CORONADO, BUSINESS CLASS M2. *PE
Steering
5 bulletinsTech Talk discussion about power steering fluid.
Steering Intermediate Shaft Replacement
FL782 Detroit Steer Axle Tie Rods
Recall FL782- Detroit Steer Axle Tie Rods
Dealer Bulletin- FL782 Detroit Steer Axle Tie Rods
Infotainment
3 bulletinsSS 1032974 High Oil Pressure on 2017 DTNA Vehicles Instrument Cluster Display
Service Bulletin revision to an earlier submission of SB54-308 for October 2019 (19MC2968).
Read full bulletin
The prior submission added new screenshots. This revision adds clarification for vehicle programming.
DTNA Special Tools Group has approved the use of Haweka Axis4000 aftermarket alignment system for use on DTNA products at DTNA service locations.
Read full bulletin
The Axis4000 system uses the reference points required by DTNA for precise, accurate, and repeatable measurements. Axis4000 is a sophisticated, user-friendly system that utilizes computer based camera-radio technology and references the center line of the frame for measuring and providing alignment results to DTNA specifications.
HVAC & Climate
3 bulletinsService Bulletin for A/C system receiver-drier replacement guidelines.
sb4725 DAVCO Preheater Fault Code SA 33 SPN 6897 FMI 6B
506-15 Air Compressor Coolant Lines
Hybrid & EV
3 bulletinsThe modified parked regeneration strategy has been standard on GHG17 units since the start of GHG17 production and was...
Read full bulletin
added to EPA10 and GHG14 units with a software update. The modified regeneration utilizes an improved strategy to clean the DOC inlet face and reduce downtime due to DOC face plugging.
15TS5Rev GHG14 DD Platform DEF Pump Leaks and Code 4374 FMI 0 Under Pressurized DEF System
SPN 3556 FMI 0, 1, 18 - Regeneration Temperature Update Procedures
Air Bags & Safety
1 bulletinJoyson Safety Systems letter informing DTNA about Hikone Webbing Investigation.
Read full bulletin
JSS is near completion of an initial investigation regarding data integrity issues at the seatbelt webbing manufacturing facility in Hikone, Japan acquired from Takata in April of 2018.