2011 Freightliner Business Class M2 TSBs
579 Technical Service Bulletins across 16 categories
Categories
Other
197 bulletinsTech Talk discussion on M-2 gauges inoperative at times.
Tech Talk discussion on repair verification for codes like 'low air flow' when a trailer is not available.
Tool Letter for ICC5 Programming Cable
fp00024 Cable-Tie Reference
Letter to customer on Coverage Extension GHG17 After Treatment
Technical Publications Ordering
Instructions for CSC Diagnostic Support
Towing Procedures
Operating Hours for the Customer Assistance Center
Vehicles with Meritor drivelines bene from a softer durometer center bearing support.
Read full bulletin
Vehicle will continue to have a 1st order driveline vibration after the driveline assembly was rebalanced.
0505-18 SPN 3563 HDEP Inlet manifold pressure Too Low
sb54299 ICU3 to ICU3S Replacement Guidelines
fp00020 Replacing Gross Vehicle Weight Rating (GVWR) Certification Labels
SS1033446 Driveline Support Bearing - Meritor Driveline
0505-18 SPN 3563 HDEP Inlet manifold pressure Too Low
0401-18 SPN 1231 (MCM) (EPA10 GHG14)
sb4932 DEF Gauge Reading Incorrectly
528-13 SPN 3246-FMI 0 - EPA10 - GHG14
527-13 SPN 190-FMI 15,17 GHG14
525-13 SPN 2791-FMI 7 ? ALL YEARS
518-13 SPN 4334-FMI 4 - GHG14
Issues with PTO and Remote Throttle Combinations
0105-15 SPN 102 (MCM) (GHG14)
0108-15 SPN 1323 through 1328 (MCM) (GHG14)
0106-15 SPN 3251 (ACM) (EPA10) and (GHG14)
0104-15 SPN 3464/ FMI 16, 18 (MCM) (GHG14)
0101-15 SPN 4364 (ACM) (EPA10)
0107-15 Enhanced Steam Clean
(CPC)(EPA10-GHG14) and SPN 98 (CPC)(GHG17)
418-13 SPN 2791-FMI 12 - GHG14
603-13 SPN 84 -FMI 6 - EPA07-GHG14
706-13 SPN 157-FMI 10, 15, 17, 18 - GHG14
709-13 SPN 2798-FMI 4-EPA10-GHG14
716-13 SPN 3226-FMI 13 - EPA10 - GHG14, SPN 3216-FMI 13 ? EPA10, SPN 3216-FMI 13 - GHG14
713-13 SPN 4334-FMI 7 - EPA10
Replacing or Upgrading Airliner 40K Transverse Torque Rods
306-15 SPN 3246 (ACM)(EPA10;GHG14)
309-15 SPN 3251 (ACM)(EPA10)
307-15 SPN 3480 (MCM) (EPA07;EPA10;GHG14)
301-15 SPN 3251 (ACM) (EPA10) and (ACM) (GHG14), 3936 (ACM)
518-14 FMI 1, 18: Regen Temperature- Out Of Range Low
519-14 FMI 1: SCR NOx Conversion Efficiency Very Low
502-14 FMI 4 SCR Inlet Temperature High
607-13 SPN 3361-FMI 7- EPA10
0401-18 SPN 1231 (MCM) (EPA10 GHG14)
sb31034 Towing ProceduresB
sb3251 Replacing or Upgrading Airliner 40K Transverse Torque RodsB
sb2083 FluidXchange Tool and FittingsB
sb2079 Premature Belt Wear on Cummins ISC ISL
sb2071 FEPTO Snowplow, Isolated Radiator Retrofit, EPA07, DD-13B
sb2068 Conventional Fully-Formulated Coolant with SCA Color Change
sb2067 Surge Tank Leaks
sb2053 New Stainless Steel Lower Radiator Tubes
sb2042 Coolant Overflow Hose
sb00042 Flood Damage Repair GuidelinesB
sb0039 New Natural Gas Vehicle Information WebpageB
13WO-2-New Standard Rpr Times orgl 11WO2 New Standard Repair Times for EPA07-10 DD13-15 Diagnostic Tests
FL631-DLR Perpendicular Aluminum Air Tank Mounting Brackets
ICI13-001-DLR FL631 - Revised Bulletin
311-13 SPN 651-FMI 3 - EPA10 - GHG14
303-13 SPN 3242-FMI 4 -EPA10 - GHG14
301-13 SPN 5018- FMI 18 -GHG14
808-13 FMI 0 Under Pressurized DEF System
802-13 FMI 18 Coolant Level Low
803-13 FMI 10,18: Intake Throttle Position Abnormal Rate of Change, Position Data Valid but Below Normal Operating Range...
Read full bulletin
- Moderately Severe Level
803-13 FMI 2: Intake Throttle Position Deviation Error
1118-12 SPN 705-FMI 5 - GHG14
1113-12 SPN 3226/FMI 20 - GHG14
sb3131 Huck-Spin 2 Changeover
102-13 SPN 84-FMI 13, 19, 21 (MCM) EPA10-GHG14
107-13 SPN 84-FMI 7 - GHG14
106-13 SPN 100-FMI 10 - GHG14
105-13 SPN 625-FMI 13 - GHG14
135-13 SPN 1243-FMI 14 - GHG14
104-13 SPN 1592-FMI 13 and 19 - GHG14
137-13 SPN 2798-FMI 4 - EPA10 - GHG14
109-13 SPN 3250-FMI 31 (ACM2.1) GHG14
139-13 SPN 3251-FMI 0, 16, 20, 21 GHG14
108-13 SPN 3364-FMI 18 - GHG14
101-13 SPN 3563 FMI 21 - GHG14
132-13 SPN 3597-FMI 4 - EPA10
146-13 SPN 4335-FMI 1 EPA10
133-13 SPN 4375-FMI 4 and 5 - GHG14
112-13 SPN 4364-FMI 18 - GHG14
111-13 SPN 4374/FMI 0, 1, 3, 4 - GHG14
110-13 SPN 5435-FMI 7 - GHG14
128-13 SPN 511403-FMI 0,1,2,3,4,5,6,8,9,10,11,12,13,14
103-13 SPN 520328-FMI 7 - GHG14
0204-15 Symptom Diagnostics: Noisy One-Box Aftertreatment
0203-15 Oil Filter Stand Pipe
704-15 SPN 4364 (ACM)(EPA10)
706-15 SPN 1323 (MCM) (GHG14) SPN 1324 (MCM) (GHG14) SPN 1325
sb54292 Nexiq USB-Link Upgrade and Diagnostic Connector
805-15 FMI 0: Selective Catalyst Reduction Outlet Temperature High
DD Heavy Duty Platform Belt and Belt Tensioner
SPN 1663 (CPC) (EPA07 10 GHG14 GHG17)
0141-17 SPN 2659 (MCM) (EPA10)
0115-17 SPN 3226 (ACM) (EPA10;GHG14)
0114-17 SPN 2791 (MCM) (EPA07;EPA10)
0113-17 SPN 3361 (ACM) (EPA10)
1207-16 SPN 4363 (ACM) (EPA10 GHG14)
1213-16 SPN 3480 (MCM) (EPA07;EPA10 GHG14)
15TS16Rev1 EPA10 Reman MCM Improvement for Fault Codes SPN 651 to 656
1202-15 Symptom Diagnostics - ATD Checklist
12-022-DLR Daimler Trucks Remarketing Corporation (DTR) Now Requires Pre-approval for Repairs $1,200 (USD) and Greater
15TS3 Detroit? Coolant Change From Nitrite Organic Acid Technology
405-15 Symptom Diagnostics - Hard Start/No Start - Two-Filter System
406-15 SPN 97 (MCM) (EPA10) / SPN 97 (MCM) (GHG14)
403-15 SPN 677 (MCM)(EPA07)
402-15 SPN 2630 (MCM)(EPA10) and SPN 2630 (MCM)(GHG14)
404-15 SPN 4364 (ACM) (EPA10)
15CSA10 The Detroit CSC announcing a new feature ? Ability to attach files to an existing CSC
15CSA9 Release of DiagnosticLink 8.02
510-15 SID 057 04 - PWM Driver #1 Shorted to Ground
505-15 SPN 3361 (ACM) (EPA10)
507-15 SPN 1590( CPC)(GHG14) and SPN 1590 (CPC)(EPA07;EPA10)
508-15 SPN 625 (MCM)( EPA10;GHG14)
sb2083 FluidXchange Tool and Fittings
15-009_Detroit_New_SDTs
15TL5 DAVCO Shop Pro FXP 95
306-15 SPN 3246 (ACM)(EPA10;GHG14)
309-15 SPN 3251 (ACM)(EPA10)
307-15 SPN 3480 (MCM) (EPA07;EPA10;GHG14)
301-15 SPN 3251 (ACM) (EPA10) and (ACM) (GHG14), 3936 (ACM)
15CSA4 Holiday Schedule for the Detroit Customer Support Center
713-14 Symptom Diagnostics - Combustion Gas in Coolant
715-14 Symptom Diagnostics - Coolant Los
716-14 SPN 4077 (MCM)(EPA07 EPA10;GHG14
14-028 Remy Extended Coverage Direct File
14-027 Detroit's New Consolidated Labor Operations (CLOs
14-023 Detroit Axles Pre-Approval Changes
14-022 Pre-Approval Threshold Increase From $2,500 to $5,000 USD
16TL4 DOC Face Cleaning Tool P N W470589239100
16TS5 Release of the DD Platform Bearing Failure Guide
0304-16 SPN 2791 (MCM) ( GHG14) and SPN 2791 (MCM) ( GHG17)
0307-16 SPN 723 (MCM) March
0301-16 SPN 625 (CPC) (EPA07) and SPN 625 (CPC) (EPA10 GHG14)
Contaminated Fluids
Hydrocarbon Doser Coolant Lines
16-009R_OWL Enhancements
New Detroit Bearing Failure Analysis Standard Diagnostic Time
17-026 Holiday Closure 2017
17TL27 Injector Cup Tool DSN930E17001
17TL26 Injector Heat Sleeve Removal Tool DSN930E17002
17CSA25 New Method for Uploading Diagnostic Log Files to the CSC
17CSA24 Holiday Schedule for the Detroit Customer Support Center
17CSA23r Detroit CSC closed December 14, 2017 from 11:15 am - 1:15 pm Eastern Time
12-039-DLR OWL Pre-approval's Time Frame Increases to 60 Days
15-028 New Detroit Coolant Line SRTs
Detroit Data Summaries Application and Kits Are No Longer Available Through PDC
_NewDetroitCoolantLineSRTs
13wo3rev2_final Actual Labor Hours on Detroit Claims
0229-14 Symptom Based Diagnostics - Oil Separator
0233-14 SPN 51 FMI 2 - All Years
0224-14 SPN 1590 FMI 9 - CPC- All Years February 2014
0201-14 SPN 1761 FMI 3, 4 (ACM2-EPA10) (ACM2.1-GHG14)
0207-14 SPN 3031 FMI 3, 4 (ACM) (EPA10 - GHG14)
0226-14 SPN 3216 FMI 3, 4 (ACM2)(EPA10)
0216-14 SPN 3363 FMI 1 - ACM - EPA10 - GHG14
0222-14 SPN 4334 FMI 7 (ACM) (EPA10)
0227-14 SPN 4335 FMI 7 - EPA10
0230-14 SPN 4375 FMI 6 - EPA10
49-31 - New DEF Injector Guard
14TS20 GHG14 Auto-Elevate Feature
14-017R Revised: Detroit Addition of Admin Time
14-029 New Detroit Standard Diagnostic Times
FL662.-DLR Meritor MSF12 Non-Conforming Front Axle Beams
54-267 - Business Class M2 and 108SD/114SD Virtual Technician Retrofit
14-038_New_SRTs Additional Detroit Standard Repair Times.
14-039_additional_SDTs New Detroit Standard Diagnostic Times
14TL8 TorcUP? Non-Impacting Torque Tool.
14TS28 DD Platform Belt Drive System - Belt Part Numbers and diagnostics
1003-14 Rough Running or Stalling.
1009-14 SPN 5016 (ACM) (GHG14)
1007-14 SPN 5016/FMI 3, 4 (ACM) (EPA10)
1006-14 SPN 4374 (ACM) (GHG14)
1008-14 SPN 3510FMI 4,7, and 8 (CPC)(GHG14)
1010-14 SPN 2623 (CPC) (GHG14)
14CSA23 CSC Announces ?Tech Tips? ? DDCSN
14CSA21 Holiday Schedule for the Detroit Customer Support Center ?
14-039 New Detroit Standard Diagnostic Times
14-038 Additional Detroit Standard Repair Times
sb2080 Australian CST M1400 Isolated Radiator Retrofit
sb0039 New "Natural Gas Vehicles Information" Webpage
1108-14 SPN 636 (MCM) (EPA07;EPA10;GHG14)
18SP711 DD15 and DD16 Axial Power Turbine Bracket Ki
912-14 Coolant in Oil
920-14 Additional Cleaning and Preparing
906-14 Installation of the Oil Pan
917-14 Installation and Removal of the Oil Filter Stand Pipe
1021-16 SPN 110 (MCM)(EPA07EPA07;GHG14), SPN 110 (CPC)(GHG14)
1018-16 SYMPTOM DIAGNOSTICS - NOISE
16TS18 EPA10 AND LATER DD AUTO-ELEVATE FEATURE
0810-16 SYMPTOM DIAGNOSTIC NOISE
0809-16 SYMPTOM DIAGNOSTICS : NOISY 1- BOX AFTERTREATMENT
16TS15 EPA07 AND LATER POWER TAKE-OFF (PTO) DOSING FEATURE
FREIGHTLINER: WARNING LABELS.
Read full bulletin
WARNING LABELS HAVE BEEN SENT DIRECTLY TO CUSTOMERS. *PE
Fuel System
93 bulletinsWarranty Information letter announcing that DTNA is increasing the Standard Diagnostic Times (SDTs) shown.
Read full bulletin
The updated after treatment system (ATS) diesel exhaust fluid (DEF) pump times will be applied to repair orders opened on or after April 12, 2021.
Technical Service Letter for EPA10, GHG14, GHG17 Diesel Particulate Filter (DPF) Compatibility.
Read full bulletin
Note: This document supersedes 14 TS-25 and 15 TS-8. Detroit Diesel has determined that some, Diesel Particulate Filters (DPFs) are compatible in pairs and or can be mixed together within EPA10 and GHG14 Systems. For 1-BOX and Two-Box Configuration Aftertreatment Systems (ATS), this is only possible when the filters are used in accordance with Tables 1 and 2 shown below. All other DPFs, NOT mentioned below, are NOT compatible.
Service Bulletin for Equiflo Fuel System Breather Tube Inspection
Service Information Bulletin for Symptom Diagnostics - Fluid in the Aftertreatment - Diesel Fuel Contamination.
Fuel Level Sending Unit Retrofit
Fuel Level Sending Unit Retrofit
Service Information Bulletin- Exhaust Gas Recirculation Crossover Pipe
13TS17 EPA10-GHG14 Diesel Exhaust Fluid (DEF) in Fuel System-Diesel Fuel in DEF System Contamination
Rev DD Platform Fuel Injector Cup Seal
102-15 High Pressure Fuel Pump - Two-Filter System
18SP687 DD15 16 EGR Actuator Replacement
414-13 Removal and Installation of the GHG14 13 and 23 Gallon Diesel Exhaust Fluid Tank Header Unit
413-13 GHG14 13 and 23 Gallon Diesel Exhaust Fluid Tank
407-13 EGR Actuator Slow Learn
708-13 Fuel System Diagram Update
714-13 Fuel Filter Maintenance Intervals
18SP712 EPA07 DD15/16 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel System Conversion Service Kit
18SP713 EPA10 DD13 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel System Conversion Service Kit
18SP714 EPA10 DD15/16 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel System Conversion Service Kit
14TS13Rev EPA10/GHG14 Diesel Exhaust Fluid (DEF) in Fuel System/Diesel Fuel in DEF System Contamination
505-14 Fuel Cooler Leak Test Procedure - Three-Filter Fuel System
504-14 Test-E - Three-Filter Fuel System
513-14 FMI 0: Diesel Particulate Filter Outlet Temperature - Very High
611-13 Removal and Installation of the GHG14 Six-Gallon Diesel Exhaust Fluid Tank Header
sb54296 Fuel Level Sending Unit RetrofitB
sb54148 Radio and Integrated Thin-Film Antenna Troubleshooting, and Field Service UpdatesB
310-13 Draining the Fuel System Using J-48710 Prior to Repairs
13TS-24 DD Platform High Pressure Fuel Lines
18SP700 EPA10,GHG14 Two-Filter Fuel System KM59 GEN1 DD15,16 High Pressure Fuel Feed Lines PN:A4720708032
18SP699 EPA10 GHG14 Two-Filter Fuel System KM59 GEN1 DD13 High Pressure Fuel Feed Lines PN A4710706035
18SP698 EPA07-10 Three-Filter Fuel System DD15,16 High Pressure Fuel Feed Lines PN A4720707932
18SP697 EPA07/10 Three-Filter Fuel System DD13 High Pressure Fuel Feed Lines PN A4710705935
1112-12 Test C -Two-Filter Fuel System
1101-12 Test B -Two-Filter Fuel System
1102-12 Test A - Two-Filter Fuel System
143-13 Low Pressure Fuel System - Measuring Fuel Pressure Using Fuel System Integrity Check, Two-Filter Fuel System
119-13 Exhaust Gas Recirculation System - Cleaning
126-13 Description and Operation of the DD15 and DD16 Exhaust Gas Recirculaton Cooler
124-13 Installation of the DD Platform EGR Actuator Pull Rod
144-13 Removal and Installation of the GHG14 Diesel Exhaust Fluid Lines
15TS8 EPA10 and GHG14 Diesel Particulate Filter (DPF) Compatibility
0202-15 EPA10 and GHG14 Diesel Oxidation Catalyst Face Cleaning
EPA10, GHG14 and GHG17 Diesel Particulate Filters
Exhaust and Exhaust Gas Recirculation
18SP730 ? EPA07 10 Three-Filter Fuel System DD13 High Pressure Fuel Feed Lines, Mounting Bracket and P-clips Service...
Read full bulletin
Kit
18SP729 ? EPA07 10 Three-Filter Fuel
15TL6 W470589129100 ? HDEP HP Fuel Rail Test Caps
18SP717 DD13 EGR Actuator Replacement
509-15 Symptom Diagnostics - Hard Start/No Start - Three-Filter Fuel
512-15 GHG14 DD15 AT Exhaust Gas Recirculation Actuator Pull Rod
502-15 Exhaust Gas Recirculation Actuator Lever
18SP716 Installation/Replacement of the Fuel Cooler Delete Bypass Plate for the Two-Filter Fuel System
15-017 Detroit: Updated Fuel Injector SDTs
18SP712 EPA07 DD15/16 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel System Conversion Service Kit
18SP713 EPA10 DD13 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel System Conversion Service Kit
18SP714 EPA10 DD15/16 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel System Conversion Service Kit
14TS19 DD Platform High Pressure Fuel Lines
16TS9 DD Platform High Pressure Fuel Lines
16TS7 Reman Diesel Particulate Filter Serial Number
17TL28 Fuel Injector Removal Tool DSN930E17004
0239-14 High Pressure Fuel Injector Lines - Three-Filter System
0238-14 Removal of the High Pressure Fuel Injector Lines - Two-Filter
0210-14 High Pressure Fuel Rail Feed Lines - Three-Filter System
0209-14 High Pressure Fuel Rail Feed Lines - Two-Filter System
0217-14 Installation of the Fuel Injector Cup
0219-14 Metal in Fuel
0202-14 Symptom Diagnostics - Hard Start No Start - Two-Filter Fuel System
0215-14 Check for Rough Running or Stalling - Three-Filter Fuel System
54-281 - Fuel Level Sender Guard Installation
14TS19Rev DD Platform High Pressure Fuel Lines
1104-14 Metal in the Fuel System
18SP707Rev EPA07/10 Three-Filter Fuel System DD13 High Pressure Fuel Feed Lines, Mounting Bracket and P-clips Service...
Read full bulletin
Kit
18SP708Rev EPA07 10 Three-Filter Fuel
14TS25 EPA10 and GHG14 Diesel Particulate Filter (DPF) Compatibility
910-14 Installation of the High Pressure Fuel Rail Feed Lines - Two-Filter System
918-14 Removal and Installation and Inspection of the Fuel Cooler Delete Bypass Plate - Two Filter System
916-14 Fuel Cooler Leak Test Procedure - Two-Filter Fuel System
908-14 908-14 EGR Differential Pressure Failed (High Box)
919-14 Exhaust Gas Recirculation Flow Target Error Diagnostic - High Flow
18SP687 18SP687 DD15/16 EGR Actuator Replacement Service Kit
18SP719Rev EPA10 DD13 Three-Filter ESOC Fuel System to Two-Filter KM59 GEN1 Fuel
18SP718Rev EPA07 DD1516 Three-Filter ESOC Fuel System to Two-Filter KM59 GEN1 Fuel
18SP714Rev EPA10 DD1516 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel
18SP725 TWO-FILTER FUEL SYSTEM KM63 GEN2 DD13 HIGH PRESSURE FUEL FEED LINES, MOUNTING BRACKET AND P-CLIPS SERVICE KIT
18SP722 DD13 KM59 GEN1 BUS TWO-FILTER SYSTEM AMPLIFIER, NEEDLE AND PLV RETURN FUEL LINE CLEARANCE PACKAGE SERVICE KIT
1020-16 CHASSIS FUEL SYSTEM ISOLATION TEST
18SP720REV 18SP720 EPA10 DD15/16 THREE-FILTER ESOC FUEL SYSTEM TO TWO-FILTER KM59 GEN1 FUEL SYSTEM CONVERSION SERVICE...
Read full bulletin
KIT
0906-16 LOW PRESSURE FUEL PUMP
FREIGHTLINER: THE TANK MAY CRYSTALLIZE AROUND FLOAT IF THE DIESEL EXHAUST FLUID (DEF) SYSTEM SITS FOR ANY EXTENDED...
Read full bulletin
LENGTH OF TIME, CAUSING FLOAT TO STICK AND REQUIRES CLEANING OF LEVEL SENDING UNIT TUBE BEFORE AN INACCURATE READING IS DISPLAYED ON LEVEL INDICATOR. MODELS CORONADO, BUSINESS CLASS M2, CASCADIA, 108SD/114SD. NO MODEL YEARS LISTED. *PE UPDATED 2/18/14. *PE UPDATED 6/3/14. *PE
FREIGHTLINER: EXCESSIVE WHITE CRYSTAL OR POWDER AROUND DEF FITTING, CAUSED BY EVAPORATION OF DEF WHEN EXPOSED TO AIR...
Read full bulletin
AND/OR DAMPNESS, INDICATES A LEAK IN DIESEL EXHAUST FLUID OR IMPROPER INSTALLATION OR DAMAGED CONNECTORS WOULD HAVE LEAKS IN COOLANT LINES. *PE
DAIMLER TRUCK SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER.
Read full bulletin
THE EXHAUST TEMPERATURES DO NOT MEET SPECIFICATIONS. *RM
FREIGHTLINER LLC: ON VEHICLES WITH A FUEL TANK COVER INSTALLED THERE MAY BE COVER MOUNTING FASTENERS THAT ARE TOO LONG.
Read full bulletin
THEY MAY DIG INTO THE TANK. *RM
FREIGHTLINER: EXHAUST STACK CLAMP FAILURE; EPA07 VERTICAL ATD.
Read full bulletin
A DUAL BAND EXHAUST STACK CLAMP, FAILS ON AN EPA07 VEHICLE WITH A VERTICAL ATD, REPLACE IT WITH SINGLE BAND CLAMP. *PE
Engine
85 bulletinsTraining Solutions for Fuel Leak Found at High Pressure Fuel Pump Weep Hole for Heavy Duty DD Engines.
Read full bulletin
Occasionally we see trucks come in with fuel leaking from the high pressure fuel pump weep hole. This is NOT a defect in the pump and further diagnostics need to be performed to find the root cause.
Warranty Information Letter for Warranty Long Block Program Change.
Read full bulletin
The Detroit Reman Long Block Program has expanded. The expansion reduces complexity in ordering reman engines and promotes stocking reman engines to meet uptime commitments.
This service kit includes all necessary parts to replace the high pressure fuel rail feed lines, mounting bracket,...
Read full bulletin
P-clips and mounting hardware in the event one of these parts are loosened, removed or missing from the engine.
Service Information Bulletin- Oil Present at the Turbocharger Compressor Housing
Service Bulletin- sb0006 Freightliner Courtesy Engineering Policy
New Detroit Diesel Cylinder Liner Upper O-Ring Leak Test Standard Repair Time
Engine Manufacturer Diagnostics
531-13 GHG14 DD15 Asymmetrical Turbocharger
520-13 Cylinder Block
GHG14 DD Engine EGR System Fault Codes
GHG14 472906S Turbocharger Compressor Inlet
15TS4 EPA07 DD15 Piston Kits
15TS2 EPA07 and EPA10 DD Platform Engines With Low Oil Pressure Codes
15TS1 GHG14 DD Platform Engines With Codes SPN: 1323 through SPN: 1328, FMI: 31, Idle Smoothness Control/Cylinder...
Read full bulletin
Misfire At Idle
GHG14 - Intake Manifold Pressure Too Low
GHG14 Intake Manifold Pressure Too Low
0202-17 DD13, DD15, and DD16 Cylinder Head Assembly Removal and Installation
18SP706 Replacement of the High Pressure Fuel Pump Camshaft Oil Seal
524-14 FMI 0: Engine Speed High
506-14 506-14 Removal and Installation and Inspection of the Exhaust Gas Recirculation Valve Actuator Pull Rod
sb0175 Replacing Drive Belts on MBE4000 EnginesB
sb0164 MBE Engine Support Information
sb0006 Freightliner Courtesy Engineering PolicyB
13TS6 DD Platform Engine Oil Filter.pdf
207-13 Removal and Installation of the Camshaft Housing
18SP693 EPA07-10 Fuel Rail Clamp Service Kit (P-N A4720780335) for DD Platform-Three-Filter Fuel System Engines
18SP701 GHG14 Two-Filter Fuel System KM63 GEN2 DD15AT Engines High Pressure Fuel Feed Lines PN A4730704432
148-13 GHG14 DD15 Asymmetrical Turbocharger Exhaust Manifold
15TS6 Replacement of the High Pressure Fuel Pump Camshaft Oil Seal
15TS14 GHG14 DD Engine Cylinder Liner Seal Replacement
708-15 High Pressure Fuel Pump Camshaft Oil Seal - Two-Filter System
711-15 High Pressure Fuel Pump Camshaft Oil Seal - Three-Filter System
702-15 DD15 and DD16 Delphi Exhaust Gas Recirculation Valve Actuator
703-15 GHG14 DD15 AT Exhaust Gas Recirculation Valve Actuator
803-15 Removal of the Camshaft Housing
0120-17 Diagnostic Test - Engine Oil Leaks - Oil Developer Method
0118-17 Symptom Diagnostics - Oil Leaks
15TL24 OTC 1750 Revolver Engine Stand
15TS4_Rev2_ EPA07 DD15 Piston Kits
1210-14 Cylinder Head
1201-15 Crankshaft and Bearings
15TS10Rev DD Engine Platform Coolant Filter
401-15 Cylinder Block
501-15 Engine Lifter Brackets
504-15 DD13 Exhaust Gas Recirculation Valve Actuator Pull Rod
511-15 DD15 and DD16 Exhaust Gas Recirculation Valve Actuator Pull Rod
503-15 DD13 Exhaust Gas Recirculation Valve Actuator
sb2084 OAT Coolant Replaces NOAT Coolant in Detroit Engines
15TL4 W470589050900 ? 3/8? Drive GEN2 Two-Stage Valve Socket
18SP706 Replacement of the High Pressure Fuel Pump Camshaft Oil Seal
sb01101 Pilot Bearing Spacer for Detroit Engines with Eaton transmissions
14TL2 DD Platform Engine Stand Adapter W060589023100
714-14 Symptom Diagnostics - Low Engine Compression
712-14 Engine Coolant Temperature
20-73 - CANCELED: Cascadia Radiator Update?EPA10 with DDC Engines
20-75 - CANCELED: Cascadia Radiator Update?EPA10 with Cummins ISX Engines
16TS8 DD13 Cylinder Head and Cylinder Head Gasket Change
16-011 New Detroit Camshaft Housing Seal Standard Repair Time
903-12 Installation of the Intake Throttle Valve and Adaptor.pdf
sb4724 Crank No Start, Loss of Engine Prime on Decked Vehicles
12-038-DLR - No Problem Found - Policy Claims - During Basic Vehicle Chassis or Base Engine Coverage
14TS4 Valve and Liner Installation Tool Issue
0228-14 Engine Oil Leaks - Oil Dye Method
0237-14 Engine Brake Solenoid
14TS21 HDEP Camshaft Position Sensor Change
14-040_Additional_CLOs Additional Detroit CLOs for the Heavy Duty Engine Platform
14CSA20 EGR Valve Actuator Kit P/N E23539699
14-040 Additional Detroit CLOs for the Heavy Duty Engine Platform
1102-14 DD13 Cylinder Head R&R
1101-14 DD15 and DD16 Cylinder Head
14TS26 Replacement of the High Pressure Fuel Pump Camshaft Oil Seal
913-14 Checking for Poor Engine Brake Performance
915-14 Backwards Running Engine Detecte
18SP706 Replacement of the High Pressure Fuel Pump Camshaft Oil Seal
18SP701Rev3 GHG14 Two-Filter Fuel System KM63 GEN2 DD15AT Engines High Pressure Fuel Feed Lines, Mounting Bracket and...
Read full bulletin
P-clips Service Kit
35-23 - Breather Oil Leak on Freightliner Tandem Rear Axles
16TS24 GHG14 DD Platform Engines With Code SPN: 3216/FMI 18, SCR Inlet NOx Sensor Drift Low
SB0006 FREIGHTLINER COURTESY ENGINEERING POLICY
1017-16 ENGINE MODEL AND SERIAL NUMBER DESIGNATION
16TL20 HEAVY DUTY ENGINE VALVE STEM SEAL INSTALLING DRIFT AND SLEEVE
0909-16 EXCESSIVE OIL CONSUMPTION
FREIGHTLINER: TANK SEAMS ARE SPLIT/CRACKED WHICH CAUSES FUEL TO LEAK.
Read full bulletin
THE VALVE MIGHT BE PLUGGED WITH CONTAMINATE. *PE
FREIGHTLINER: FAN CLUTCH NUTS.
Read full bulletin
ALWAYS USE NEW NYLOC NUTS WHEN INSTALLING THE ENGINE COOLING FAN ON A BORG WARNER (KYSOR) FAN CLUTCH. FAILURE MAY LEAD TO A LOOSE OR LOST FAN, AND DAMAGE TO THE FAN CLUTCH OR TRUCK. *PE
FREIGHTLINER: EXHAUST BELLOWS REPLACEMENT.
Read full bulletin
HAVE A FAILED EXHAUST BELLOWS ON AN EPA07 ENGINE INSTALLATION, REPLACE WITH A NEW STYLE BELLOWS, AND TWO NEW MATCHING CLAMPS. MODELS CENTURY CLASS CONVENTIONAL, COLUMBIA CASCADIA, CORONADO, AND BUSINESS CLASS M2. *PE UPDATED 4/24/12. *PE
FREIGHTLINER: TRW TAS85 STEERING GEAR INTERNAL LEAKAGE TEST.
Read full bulletin
SOME TRW TAS85 STEERING GEARS HAVE BEEN EQUIPPED WITH AN INTERNAL RELIEF VALVE. THESE STEERING GEARS ARE TYPICALLY INSTALLED WITH POWER STEERING PUMPS THAT HAVE A PRESSURE RELIEF RATING GREATER THAN 2175 PSI (150 BAR). THE INTERNAL RELIEF VALVE LIMITS MAXIMUM SUPPLY PRESSURE TO PROTECT THE STEERING GEAR. MODELS FLD CONVENTIONAL, CENTURY CLASS CONVENTIONAL, COLUMBIA, CORONADO, BUSINESS CLASS M2 AND CASCADIA. NO MODEL YEARS LISTED. *PE
Electrical
61 bulletinsCX Advocate for bulkhead module reprogramming (SS 3146-FTL)
Service Solution for M2, 108SD, 114SD - Unable to Program Replacement Bulkhead Module - Certain Model Years
Service Solution for M2, 108SD, 114SD - Unable to Program Replacement Bulkhead Module - Certain Model Years
SS 1032728 Bulkhead Module Fault Codes 524280 thru 524286 with FMI 7 Clarification
Service Solution SS 1033094 KUS Float Tube Fuel Level Sensor Inform...
Freightliner Service Bulletin for Programming Chassis Electronic Control Units (ECUs) With DiagnosticLink.
Updated Freightliner Service Bulletin for Powernet Troubleshooting Guide - Batteries, Path, Alternator, and Starter.
Read full bulletin
This bulletin replaces the version dated 5/31/2017. Information is added about the BCT-460DTNA PowerNet Assessment Tool. When troubleshooting Powernet issues, use the BCT-460DTNA PowerNet Assessment Tool. As of May 29, 2018, the AutoMeter is the only Daimler-approved tool for troubleshooting vehicle Powernet issues.
Service Bulletin about the powertrain PDM and Main PDM bracket being modified to reduce stress and vibration to the...
Read full bulletin
Powertrain Power Distribution Module (PTPDM).
Service bulletin describing that the DiagnoticLink screen images for Chassis ECU programming have ben updated.
Service Bulletin to provide instructions to replace Ignition Control System.The ICU3 is no longer installed in...
Read full bulletin
production, and has been superseded by the ICU3S. When replacing an ICU3, the ICU3S must be installed in its place.
DiagnosticLink support programming of both chassis and powertrain ECUs
SS 1034220 SSI Ultrasonic Fuel Level Sensor Information
sb54308 Chassis ECU Programming
Service Bulletin- Chassis ECU Programming
Alternator Remote Sense Wiring
0311-18 Installation of the Main Shaft Speed Sensor
13TS15 EPA10 Diesel Oxidation Catalyst (DOC) Face Plugging And Code SPN 3251-FMI2 - DOC Inlet Pressure Sensor Not...
Read full bulletin
Plausible
13TS15Rev EPA10 Diesel Oxidation Catalyst (DOC) Face Plugging And Code SPN 3251/FMI 2 - DOC Inlet Pressure Sensor Not...
Read full bulletin
Plausible
15TS9 Hydrocarbon Doser Block Fuel Compensation Pressure Sensor
305-15 EPA10 Diesel Oxidation Catalyst Inlet Pressure Sensor
503-14 FMI 3, 4: High Side Digital Output 3 Circuit Failed High
516-14 FMI 3, 4: DEF pressure sensor circuit failed hig
18SP684Rev3 EPA07 and EPA10 DD Platform EGR Delta Pressure Sensor Update
sb15020 Alternator Remote Sense WiringB
sb2070 EPA07 and Newer Gentech Coolant-Level Sensor Testing
13TS5 DD Platform Fuel Filter Module
13TS10 DD Platform Oil Coolant Module Plugs
54-275 - Chassis-Mounted Trailer PDM, Battery Power Cable Terminal Corrosion
13TL2 GHG14 Test Electronic Control Units (ECUs).\
sb54278 Powernet Troubleshooting Guide: Batteries, Path, Alternator
0311-18 Installation of the Main Shaft Speed Sensor
1205-15 Selective Catalyst Reduction (SCR) Inlet Temperature Sensor
15-016-DLR New Essential Tool For CPWA, CPPRA, Ltd CPPRA, & DSDWC Parties: Cadex CA-12 Battery Tester
15TS9 Hydrocarbon Doser Block Fuel Compensation Pressure Sensor
305-15 EPA10 Diesel Oxidation Catalyst Inlet Pressure Sensor
54-285 - Cracked Fuses on Powertrain Power Distribution Modules
16TL5 DD Platform Aftertreatment Soot Sensor Socket DSN0ATZ16001
16_TL-2 DD Platform Aftertreatment NOx Sensor Socket W470589060900
14TS5 Replacing Damaged Aftertreatment Sensor Bosses
0218-14 GHG14 Diesel Exhaust Fluid Pump Module Filter
54-278 - Powernet Troubleshooting Guide: Batteries, Path, Alternator, and Starter
813-14 Installation of the One & Two-Piece Fuel Injector Wiring Harness - Two & Three-Filter System
809-14 FMI 3, 4, 5, 31: Diesel Exhaust Fluid System Circuit Failed
802-14 FMI 3, 4: Diesel Exhaust Fluid Pressure Sensor Circuit Failed High and low
1005-14 Oil Coolant Module
14CSA22 DTNA Chassis Wiring Diagrams
18SP684Rev4 18SP684Rev4 ? EPA07 and EPA10 DD Platform EGR Delta Pressure Sensor Update
18SP705Rev5 18SP705Rev5 ? DD Platform Delta Pressure Sensor
sb54287 Powernet Distribution Box Fuse Retention on the Keep-Alive
sbw5460 Powernet Distribution Box Fuse Retention on the Keep-Alive
1110-14 EPA10 DOC Inlet Pressure Sensor
905-14 Coolant Level Circuit Failed
903-14 Selective Catalyst Reduction Inlet NOx Sensor Circuit Failed High and Low
904-14 Selective Catalyst Reduction Outlet NOx Sensor Circuit Failed High and Low
911-14 5V Sensor Supply Bank 2 Circuit Failed High
909-14 Diesel Exhaust Fluid Metering Unit Air Pressure Sensor Circuit Failed High and Low
16TL17 LABEL UPDATE FOR GHG14 TEST AFTERTREATMENT CONTROL MODULE (ACM)
FREIGHTLINER: THE WIRING FOR STOP/TURN-LIGHT CAN BE CONVERTED FROM COMBINATION TO SEPARATE STOP/TURN LIGHTS AND...
Read full bulletin
SEPARATE STOP/TURN LIGHTS CAN BE CONVERTED TO COMBINATION WHICH INVOLVES CONFIGURATION OF WIRING AND PARAMETER REFERENCE CHANGES. MODEL BUSINESS CLASS M2. NO YEARS LISTED. *PE
FREIGHTLINER: THE WINDSHIELD WIPERS MAY EXHIBIT AN UNINTENDED CYCLING DUE TO POSSIBLE MALFUNCTION TURN SIGNAL SWITCH...
Read full bulletin
THAT NEEDS TO BE REPLACED ALONG WITH WIRING SUPPORT BRACKET. MODEL 2010-2011 BUSINESS CLASS M2. *PE
FREIGHTLINER: INSTRUCTIONS TO INSTALL THE NEW RUBBER DRAW LATCH ON THE BATTERY BOX.
Read full bulletin
*RM
FREIGHTLINER LLC: WHEN REPLACING THE CHASSIS MODULE, A WIRE REPLACEMENT IS NECESSARY.
Read full bulletin
*RM UPDATED 4/24/12. *PE
Pre-Delivery & Maintenance
35 bulletinsService Solution SS 1032989 BHM Fault Code Changes
Service Solution SS 1033180 BHM Fault Code SPN 524251 FMI 7 - Extr...
Service Solution SS 1033289 BHM Fault Code SPN 524249 / FMI 7
Service Bulletin for Powertrain PDM and Main PDM Bracket Modication.
Read full bulletin
This bulletin replaces the version dated 10/31/2019. The build date section has been added.
Service Bulletin for Guidelines for Cleaning and Disinfecting Cab Surfaces.
Read full bulletin
The following guidelines are for cleaning and disinfecting commonly touched surfaces on the inside and outside of a vehicle. For best results, follow cleaning and disinfecting procedures fully and consistently. Ensure there is adequate ventilation when using chemicals. NOTICE: Wipe down fragile components carefully to avoid damaging the vehicle.
Warranty Information Letter for Warranty Training Online.
Read full bulletin
DTNA is pleased to announce the release of new Warranty-related training videos. The videos provide Warranty content in short instructional videos that are available on demand through the AftermarkeTV Video Channel icon on the Aftermarket Resource Center (ARC) home page.
Warranty Policy Letter for Handling for Authorized Service Location Part Transfers.
Read full bulletin
To promote 24-hour throughput and maximum efficiency, DTNA is adjusting multiple handling policies: Launching a new handling allowance for parts ordered from another Authorized Service Location because the facing Part Distribution Center (PDC) is out of stock Retiring Detroit's Customer First Program
Open recall and Field service Campaigns report send out to Dealers, General Managers, Service managers and warranty...
Read full bulletin
managers
Service Bulletin for severe duty main PDM installation for vehicles operating in severe moisture and/or corrosive...
Read full bulletin
environments.
Technical Service Letter communicating that information on DD Heavy Duty Platform Belt and Belt Tensioner can be found...
Read full bulletin
on TechLit.
Warranty Information Letter sent to customers regarding new refrigerator supplier for returning parts.
Service Bulletin provided to customers regarding ICU3 to ICU3S Replacement
Service Bulletin- sb54311 ICU Odometer Programming
Service Information Bulletin
Service Bulletin New "Natural Gas Vehicle Information" Webpage
Service Bulletin 9816- DuPont? Imron Elite
Release of DiagnosticLink 8.08 Service Pack 2
If a GVWR certification label is lost or damaged, Freightliner will supply a duplicate label.
Read full bulletin
Log on to DTNAConnect.com and under "DTNAConnect Resources", select the "Tool and Services" plus sign. Select "Request for Certification Label or OWI." Fillout the form, then select "Review."
13m2- Equipment Owner Field Service Campaign - 13M2
13m2 -Final-23-SEP-2013 Field Service Campaign 13M2
sb83155 Espar Service Information
507-14 Inspection of the DD15 and DD16 Axial Power Turbine
sb54194 Required Maintenance for Freightliner-Branded and Delco Cassette Players
sb54122 ICU3 Service Cluster AvailableB
15-015 Warranty Exclusions Reminder
14-026-DLR SelecTruck Warranty Enhancements
Canadian Warranty Parts Return Address Change
OWL Enhancement Service Model Field
Warranty Classroom Training in 2018
12-041-DLR Over the Counter No Hassle Warranty (OTC)
_Warranty Recognition Program - Coming Soon
14WO-9_Warranty_Access Detroit New User Warranty Access Request
14TL9 Special Tool Warranty Program.
16TS14 EPA10 AND GHG14 SERVICE REPLACEMENT 1-BOX DOC INLET CHANGE
FREIGHTLINER: 294 BOLT REPLACEMENT FOR PREMIERE 690 COUPLING.
Read full bulletin
EFFECTIVE IMMEDIATELY, ALL 294 BOLTS USED IN COUPLING ASSEMBLIES 690L, 690R, 690T, AND REPAIR KITS 690LRK, 690 TRK, OR INDIVIDUAL BOLT SALES, MUST USE THE FOLLOWING MAINTENANCE REQUIREMENTS-NEW 690 COUPLINGS, OR A NEW, OR REPLACED 294 BOLT: RECORD THE DATE OF INSTALLATION. NO MODEL YEARS ARE LISTED. *PE
Brakes
18 bulletinsRear Brake Calipers and Anchor Plates.
Service Solution for M2 ABS Wiring Harness Rubs On Forward Cab Mount.
Read full bulletin
ABS chassis harness is rubbing on the rear of the driver side forward cab mounting bracket on M2 106 trucks with a 160 MM Cab Hgt. This may cause open or shorted circuits in multiple wires in the harness transitioning from the chassis to the cab. Noticeable symptoms include illumination of the ABS and ATC indictor lamps.
Service Solution 1033889- Hydromax Hydraulic Brake Booster Pump Function Logic
SS 1033322 ABS light illuminating in ICU, ABS solenoids will not self-check
FL705 Bendix Rear Brake Calipers
sb60157 Roof Noise, M2 and 108SD/114SD Day Cabs
sb4267 Brake Shimmy?Meritor SteeLite X30? Brake Drum with Excessive RunoutB
sb4256 Enabling M2 Exhaust Brake Lights
FL705 Bendix Rear Brake Calipers
SS 1033322 ABS light illuminating in ICU, ABS solenoids will not self-check
sb4267 Brake Shimmy - Meritor SteeLite X30 Brake Drum with Excessive Runout
sb60157 Roof Noise, M2 and 108SD/114SD Day Cabs
14TL5 ABS Power Line Carrier Converter Available Through PDC
16TL3 Pocket iQ? ABS Product Family Kit is Available at PDC
42-64 - Accessing a Service Brake Light Signal on M2 Vehicles
FREIGHTLINER: DUE TO POSSIBLE THERMAL OVERLOAD ON BENDIX AIR DISC BRAKES: THE ABS SENSOR WIRES MELTED; BRAKE ACTUATOR...
Read full bulletin
FAILED TO PROPERLY OPERATE BECAUSE OF VENT HOLE NOT OPEN; CALIPERS COATED WITH BRIGHT ORANGE OR RED DUST AND TAPPED/GUIDE PIN BOOTS AFFECTED WHEEL END MELTED OR HEAT DAMAGE. *PE
FREIGHTLINER: ON SOME TRUCKS, WHENEVER BRAKES ARE APPLIED, THE TRUCK WOULD EXPERIENCE SEVERE SHIMMY OR SHAKING.
Read full bulletin
MODELS FLD CONVENTIONAL, CENTURY CLASS CONVENTIONAL, ARGOSY COE, COLUMBIA, CORONADO, BUSINESS CLASS M2, CASCADIA, 108SD/114SD. NO MODEL YEARS LISTED. *PE UPDATED 11/1/12. *PE
FREIGHTLINER: GENTECH LOW COOLANT LEVEL SENSOR (PART NO.
Read full bulletin
06-62384-002) IS ASSEMBLED WITH A TWO PIECE HOUSING HELD TOGETHER WITH TWO LOCKING TABS, ONE ON THE TOP AND THE OTHER ON THE BOTTOM. MODELS CASCADIA, CORONADO, BUSINESS CLASS M2. *PE
Suspension
18 bulletinsRevised Freightliner Service Bulletin for Axle Flange Gasket Replaced with O-Ring.
Read full bulletin
Revision removed steps instructing removal and installation of wheels. Daimler Trucks North America has released a new axle shaft to hub rubber O-ring (part number 11-30728-000) as a replacement for the paper gasket (part number 11-14418-000). The new O-ring will provide better sealing and is reusable. It is quicker and easier to use compared to the paper gasket, because using a paper gasket requires cleaning the hub when the axle shaft is removed.
Freightliner Service Bulletin for Axle Flange Gasket Replaced with O-Ring.
Read full bulletin
Daimler Trucks North America has released a new axle shaft to hub rubber O-ring (part number 11-30728-000) as a replacement for the paper gasket (part number 11-14418-000). The new O-ring will provide better sealing and is reusable. It is quicker and easier to use compared to the paper gasket, because using a paper gasket requires cleaning the hub when the axle shaft is removed.
Freightliner Service Bulletin for Non-Airliner Rear Suspension Crossmember Fastener Change.
Read full bulletin
With the start of production on March 2, 2020, the fasteners used to assemble the non-Airliner rear suspension (bogie) crossmember have changed. The rear suspension bogie crossmember gussets to the C-channel will be assembled with 5/8 - 18 fasteners. This change includes a revision to a higher friction nut that requires an increase in tightening torque. The new higher friction nut can be identified by its green color.
Service Bulletin for Hendrickson HaulMaax Rear Suspension Transverse Torque Rod Tower Bracket Replacement
Service Bulletin to fix vehicles which may have an incorrect transverse torque rod tower bracket installed on the rear drive axles at the factory.
Read full bulletin
This can result in cracking at the transverse rod tower where it is welded to the axle housing, premature wearing of the transverse torque rod tapered pin and bushings, and damage to the transverse torque rod frame bracket.
SS 1034171 Airliner Rear Suspension Chassis Lean Troubleshooting
Service Bulletin: AirLiner Suspension Six-Piece Bolted Service Crossmember
With the start of production on February 12, 2018, the fasteners used to assemble Airliner rear suspension crossmembers changed.
Read full bulletin
The forward-suspension crossmember will assembled with 5/8-18 fasteners and the rear-suspension (bogie) crossmember will be assembled with 3/4-16 fasteners.
33-28 - Bearing Spacer Replacement, ConMet PreSet Steer Hubs
35-30 - Bearing Spacer Replacement, ConMet PreSet Drive Hubs
Warranty Recognition Program Suspension
FREIGHTLINER: ON RECOMMENDATION OF CONMET, REPLACEMENT OF BEARING SPACER, WITH A NEW ONE, IS REQUIRED WHEN A HUB IS REMOVED.
Read full bulletin
*PE
FREIGHTLINER: ON RECOMMENDATION OF CONMET, THE BEARING SPACER SHOULD BE REPLACED, WITH A NEW ONE, WHEN HUB IS REMOVED.
Read full bulletin
NO MODEL YEARS LISTED. *PE
FREIGHTLINER: FOR SOME MODEL TRUCKS, RECOMMENDATION OF PREVENTIVE MAINTENANCE INTERVALS FOR REAR HEAVY DUTY SUSPENSION...
Read full bulletin
AND OFF HIGHWAY AND SEVERE SERVICE OPERATING CONDITIONS REQUIRES FREQUENT INSPECTIONS. *PE
FREIGHTLINER: INFORMATION ON LUBRICATING THE WHEEL BEARINGS OF THE REAR DRIVE AXLES.
Read full bulletin
*RM
FREIGHTLINER: THE REAR SUSPENSION AIR SPRING HAS BEEN REDESIGNED.
Read full bulletin
*RM
DAIMLER TRUCKS: TROUBLESHOOTING FOR A MISALIGNMENT OF THE SUSPENSION AIR SPRINGS.
Read full bulletin
*RM
FREIGHTLINER: HEAVY DUTY FRONT SWAY BAR INSTALLATION.
Read full bulletin
FRONT SUSPENSION SWAY BARS MAY EXPERIENCE PREMATURE WEARING OF THE UPPER BAYONET BUSHINGS ON THE CONNECTING RODS. NO MODEL YEARS LISTED. *PE UPDATED 5/6/11. *PE
Transmission
18 bulletinsRevised Warranty Policy Letter for Alliance/Mascot Aftermarket Warranty and Claim Filing.
Read full bulletin
Revisions are in blue. With Mascot now in partnership with Detroit Reman and Alliance Parts, DTNA is pleased to announce that Mascot coverage has been added to OWL. Remanufactured Alliance/Mascot parts include transmission, differential, steering gear, and steering pump used in an on-highway vehicle applications. The Alliance/Mascot aftermarket warranty coverage period has not changed: depending on the part, coverage is for one (1) or two (2) years and current parts, labor, and reimbursement policies apply.
Warranty Policy Letter for Alliance/Mascot Aftermarket Warranty and Claim Filing.
Read full bulletin
With Mascot now in partnership with Detroit Reman and Alliance Parts, DTNA is pleased to announce that Mascot coverage has been added to OWL. Remanufactured Alliance/Mascot parts include transmission, differential, steering gear, and steering pump used in an on-highway vehicle applications. The Alliance/Mascot aftermarket warranty coverage period has not changed: depending on the part, coverage is for one (1) or two (2) years and current parts, labor, and reimbursement policies apply.
Service Bulletin for Lengthening the Backup Light Harness.
Read full bulletin
Though the backup light harness is long enough to connect to the backup light switch, it may be short enough that the wire seals in the connector can be stressed. Moisture entering through the seals can cause corrosion, resulting in a bad connection and/or failure of the switch. As a result, backup lights and, if equipped, the backup alarm, may not function when the vehicle is shifted into reverse.
0405-18 Symptom Diagnostics - Range Up or Down Shift Issue
26-50 - M2 Shift Cable Noise, Allison Transmissions
sb2650 M2 Shift Cable Noise, Allison Transmissions
0405-18 Symptom Diagnostics - Range Up or Down Shift Issue
sb2074 Kysor Fan Clutch Rocking Runout Inspection
sb2069 Kysor Fan Clutch Sticking
sb2052 Horton Drivemaster Fan Clutch Hub Bearings
145-13 Description and Operation of Gear Train and Related Parts
15-010-DLR Transmission Cooler Line Photos
810-14 Clutch Position Sensor
1105-14 Flywheel, Ring Gear and Flywheel Housing
26-50 - M2 Shift Cable Noise, Allison Transmissions
DAIMLER TRUCK: THICKNESS AND EXCESS MATERIAL FROM DIE PUNCHING MAY PREVENT RETAINING SNAP RINGS FROM FULLY SEATING IN...
Read full bulletin
DIFFERENTIAL LOCK SHIFT FORK ASSEMBLIES, CAUSING DIFFERENTIAL LOCK TO REMAIN UNENGAGED OR ENGAGED. MODELS 2011-2012 BUSINESS CLASS M2, CASCADIA, COLUMBIA, CORONADO, WESTERN STAR 4900. *PE
FREIGHTLINER: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER.
Read full bulletin
THE REMY 29MT STARTERS ON CERTAIN VEHICLES MAY CONTAIN CLUTCH ROLLS WITH IMPROPER HEAT TREATMENTS. *PE
FREIGHTLINER: NEW TRANSMISSION COOLANT LINE CLAMPS.
Read full bulletin
EPA07 VEHICLES EQUIPPED WITH WATER TO OIL TRANSMISSION COOLER IN RADIATOR END TANK, NEW CLAMPS ARE AVAILABLE FOR TRANSMISSION COOLANT LINES. THE NEW CLAMPS REFINES OLDER VERSION TO SUBSTANTIALLY IMPROVE GRIP. NO MODEL YEARS LISTED. *PE
Body & Paint
17 bulletinsService Solution SS 1032998 M2 mirror wind noise
Warranty Information Letter - Expanded guidelines for paint-related claims sent out to Freightliner, Western star,...
Read full bulletin
Thomas Built Bus, Export and Direct warranty customers
Service Bulletin M2 Heated Windshield Modification
Service Bulletin 9810- Chassis Paint Usage
Service Bulletin 9819- Body Paint Repair Process
Freightliner M2 Roof Repair
A new design for the M2 grille went into prduction on February 5, 2018.
Read full bulletin
The hood design has also changed slightly to accommodate a different grille fastening strategy. The old grille and hood part part numbers will no longer be produced, and will supersede to the new design with new part numbers.
The right-hand cab panel on New Cascadia can come into contact with the right-hand chassis-side fairing when making a left turn.
Read full bulletin
This contact can result in an audible popping noise, paint-damage to the rocker panel and damage to the back-side of the chassis-side fairing.
0312-18 Installation Output Shaft Seal
sb9815 Paint Finish Standards
54-280 - Video Available for Servicing APEX 150 Sealed 16-Pin Connectors
sb60154 60-154 - Fastener Removal Improves Durability of Cowl Panel
sb98020 Axalta Paint Finish CareB
FL633-DLR Certification Door Labels - Tire Inflation
0312-18 Installation Output Shaft Seal
12-040-DLR Roof Fairing Removal Program
FREIGHTLINER: PROCEDURE OF REMOVING A LOWER PINION COVER IN THE REAR AXLES AND HOW TO RESEAL IT.
Read full bulletin
*RM
Lighting
12 bulletinsWarranty Policy Letter for Chassis Progressive Damage Policy Change.
Read full bulletin
Effective for repair orders opened on or after April 27, 2020, if an Authorized Service Location installed a part which later has a warrantable failure, progressive damage and labor may be covered under the Aftermarket Parts Limited Parts Warranty (Parts Warranty).
Warranty Policy Letter for Handling Change: Over the Counter Aftermarket Parts Replacement Program.
Read full bulletin
DTNA is pleased to announce that handling will increase to 33% for Misc. Replacement Part type claims filed under the Over the Counter (OTC) Aftermarket Parts Replacement Program.
sb2046 ABA Hose Clamp Torque Values
Some vehicles may have been incorrectly shimmed at the factory, and may lean slightly to the right or left.
Read full bulletin
While this does not affect the operation of the vehicle, it may be visually unpleasing to many customers.
sb3133 Step Clamps Are Not Reusable
14-024-DLR DTNA & JAD Highlights - Q1 & Q2
54-218 - Adding Daytime Running Lights (DRL)Option to Business Class M2 Vehicles
14-036-DLR DTNA & JAD Highlights - Q3
FREIGHTLINER: INFORMATION ON THE OPTION OF ADDING, TO BUSINESS CLASS M2 TRUCKS, THE DAYTIME RUNNING LIGHTS (DRL), DEPENDING ON TYPE OF TRUCK.
Read full bulletin
*PE
FREIGHTLINER: SOME TRUCKS ARE EQUIPPED WITH RADIATOR MOUNTED SURGE TANKS ARE MISDIAGNOSED DUE TO FAULT CODE BEING...
Read full bulletin
GENERATED DURING LOW COOLANT LEVEL IN SURGE TANK WHICH MUST BE FILLED TO COLDMAX LEVEL, *PE
DAIMLER TRUCKS: THERE MAY BE A RATTLE IN THE SWIVEL TYPE UTILITY LAMP.
Read full bulletin
THE BOLT MAY ALSO LOOSEN OVER TIME. *RM
FREIGHTLINER: A NEW BULB SOCKET IS AVAILABLE FOR TURN/PARK LIGHTS THAT IS METALIZED TO WITHSTAND HIGH HEAT WITHOUT OUT GASSING.
Read full bulletin
MODEL YEARS UNKNOWN. MODELS COLUMBIA, BUSINESS CLASS M2 AND CASCADIA. *PE UPDATED ON 6/14/2011. *KB
Software & Calibration
6 bulletinsWarranty Information Letter announcing DTNA is adjusting the Standard Repair Times (SRTs) shown.
Read full bulletin
The updated times will be applied to repair orders opened on or after April 5, 2021.
129-13 DD Platform GHG 14 SPN 3361 FMI 3, 4, 5 UPDATE
1207-15 Updated procedures with adding EPA10 to the GHG14 title
Computer Hook-Up Standard Diagnostic Time Update
AEO15M1 GHG14 DD PLATFORM SOFTWARE REPROGRAMMING FOR AUTO ELEVATE
FREIGHTLINER: CONTAMINATION OF AIR INTAKE.
Read full bulletin
*PE UPDATED 2/28/12. *PE
Tires & Wheels
6 bulletins14TL-7Rev DD Platform Flywheel Housing Runout Tool W470589032100
17TL25 TruckCam? Alignment System
ICI12-028-DLR FL632 - Interim Notice
14TL7 DD Platform Flywheel Housing Runout Tool W470589032100
907-14 Installation and Removal of the Flywheel Housing
0902-16 SYMPTOM DIAGNOSTICS - BELT COMING OFF, SHREDDING OR MISALIGNMENT
HVAC & Climate
4 bulletins506-15 Air Compressor Coolant Lines
49-35 - DEF Return Line Fitting Heater, 6-Gallon Tanks
49-35 - DEF Return Line Fitting Heater, 6-Gallon Tanks
FREIGHTLINER: BULLETIN PERTAINING TO THE REPLACEMENT OF AIR CONDITION HIGH PRESSURE (FAN CYCLING) SWITCH ON CERTAIN MODEL TRUCKS.
Read full bulletin
*PE
Infotainment
3 bulletinsSS 1032974 High Oil Pressure on 2017 DTNA Vehicles Instrument Cluster Display
Service Bulletin revision to an earlier submission of SB54-308 for October 2019 (19MC2968).
Read full bulletin
The prior submission added new screenshots. This revision adds clarification for vehicle programming.
DAIMLER TRUCKS (FREIGHTLINER): THE INSTRUMENT DISPLAY PANEL, THE COOLANT PUMP, AND RADIATOR ON CERTAIN HYBRID ELECTRIC...
Read full bulletin
VEHICLES MAY REQUIRE UPDATES AFTER INSPECTION. *PE
Steering
3 bulletinsTech Talk discussion about power steering fluid.
Steering Intermediate Shaft Replacement
FREIGHTLINER: THERE IS A PROCEDURE TO REPLACE THE POWER STEERING PUMP.
Read full bulletin
*RM
Hybrid & EV
3 bulletinsThe modified parked regeneration strategy has been standard on GHG17 units since the start of GHG17 production and was...
Read full bulletin
added to EPA10 and GHG14 units with a software update. The modified regeneration utilizes an improved strategy to clean the DOC inlet face and reduce downtime due to DOC face plugging.
15TS5Rev GHG14 DD Platform DEF Pump Leaks and Code 4374 FMI 0 Under Pressurized DEF System
604-13 Performing a Parked Regeneration