2004 Ford Thunderbird TSBs
32 Technical Service Bulletins across 9 categories
Categories
Electrical
8 bulletinsEXCESSIVE ELECTRICAL SYSTEM CURRENT DRAW WHICH COULD RESULT IN A DISCHARGED BATTERY AND A NO CRANK CONDITION.
Read full bulletin
*TT SERVICE TIPS. *TT
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs).
Read full bulletin
The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate when reading these PIDs and cannot display quickly enough to validate a concern. The PCM automatically monitors these inputs more accurately and will set diagnostic trouble codes (DTCs) when appropriate. Using these PIDs for diagnostics will lead to inaccurate results and improper ETB replacements. If a concern is intermittent and no DTCs are present, refer to historical DTCs and the PC/ED, Section 3 No DTCs Present Index chart for further information.
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES.
Read full bulletin
*TT
KEY-IN-IGNITION WARNING CHIME SOUND WHENEVER THE DRIVER'S DOOR IS OPEN (EVEN WITH NO KEY IN THE IGNITION), THE EASY EXIT...
Read full bulletin
FEATURE INOPERATIVE WHEN THE KEY IS REMOVED FROM THE IGNITION, OR THE STEERING COLUMN (AND SEAT IF APPLICABLE) MOVING BACK AND FORTH WHEN THE KEY IS REMOVED FROM THE IGNITION ON VEHICLES WITH A FORD ACCESSORY REMOTE START KIT. *TT
DIAGNOSTIC TROUBLE CODE (DTC) P2106 STORED IN THE PCM (POWERTRAIN CONTROL MODULE).
Read full bulletin
*TT
DIAGNOSTIC TROUBLE CODE (DTC) U0300 (INTERNAL CONTROL MODULE SOFTWARE INCOMPATIBILITY) STORED IN THE PCM WITH NO OTHER DTC'S PRESENT.
Read full bulletin
*TT
AN INTERMITTENT MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODE (DTC) P0462 (FUEL LEVEL SENSOR A...
Read full bulletin
CIRCUIT LOW) OR P2067 (FUEL LEVEL SENSOR B CIRCUIT LOW) CAUSED BY AN IMPROPERLY INSTALLED REMOTE START SYSTEM. *TT
MALFUNCTION INDICATOR LAMP (MIL) ON WITH IGNITION COIL RELATED DIAGNOSTIC TROUBLE CODES (P035X).
Read full bulletin
*TT
Engine
6 bulletinsFORD/LINCOLN/MERCURY: MAY HAVE SLUDGE BUILDUP IN THROTTLE BODY LEADING TO LESS AIRFLOW OR ENGINE IDLING RPM...
Read full bulletin
FLUCTUATION AND HARD STARTS OR BATTERY DISCONNECT OR DEAD BATTERY AFTER KEEP ALIVE MEMORY (KAM) CLEAR. MODELS 2003-05 THUNDERBIRD, 05-06 MUSTANG, 06-08 FUSION, 04-05 EXPLORER, 05-06 EXPEDITION, 05-07 F-150; 2003-06 LS, 06 ZEPHYR, 05-06 NAVIGATOR; 06-08 MILAN. *PE
FORD/LINCOLN MERCURY: CERTAIN 2003-2005 MODEL YEAR LINCOLN LS AND FORD THUNDERBIRD VEHICLES EQUIPPED WITH 3.9L ENGINE...
Read full bulletin
WITH EXTENDED WARRANTY COVERAGE ON IGNITION COIL ASSEMBLIES AND ON 2003 MY VEHICLES ONLY , ENGINE VALVE COVER GASKETS. *PE
WATER/MOISTURE IN COP WELLS - DTC P0301-P0308 - 3.9L ENGINE - VEHICLES BUILT THROUGH 5/1/2004.
Read full bulletin
*TT
UNUSUAL ENGINE NOISE OR ENGINE KNOCK CONCERNS DUE TO REGULAR FUEL.
Read full bulletin
*TT
ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS.
Read full bulletin
TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04.
ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED...
Read full bulletin
USING THE OPTIONAL WORLDWIDE DIAGNOSTIC SYSTEM (WDS) COIL ON PLUG (COP) KIT. 2003 SUPER DUTY F SERIES INCLUDED. *TT
Transmission
6 bulletinsAUTOMATIC TRANSMISSION SOLENOID EMISSIONS WARRANTY EXTENSION.
Read full bulletin
SAMPLE CONSUMER LETTER ATTACHED. *KB
DELAYED OR HARSH REVERSE ENGAGEMENTS - 5R55S TRANSMISSION - VEHICLES BUILT PRIOR TO 09/23/2004.
Read full bulletin
*TT
IMPROPERLY FORMULATED TRANSMISSION FLUID THAT, OVER TIME, MAY CAUSE DELAYED/HARSH REVERSE ENGAGEMENTS.
Read full bulletin
CUSTOMER SATISFACTION PROGRAM 04B22. 5R55S/E & 5R44E TRANSMISSION FLUID ADDITIVE. *TT SUPPLEMENT #1. *TT SUPPLEMENT #2. *TT SUPPLEMENT #3. *TT
STEERING GEAR SQUEAK WHEN TURNING THE STEERING WHEEL, ESPECIALLY DURING LOW SPEED PARKING MANEUVERS.
Read full bulletin
*TT
MALFUNCTION INDICATOR LAMP (MIL) ON, E DISPLAYED FOR GEAR POSITION, HARSH SHIFTS, AND DIAGNOSTIC TROUBLE CODES (DTCS)...
Read full bulletin
P0705 AND P1702 AFTER POWERTRAIN CONTROL MODULE (PCM) REPROGRAMMING. *TT
STEERING GEAR NOISE. *TT
Lighting
3 bulletinsMALFUNCTION INDICATOR LAMP (MIL) AND ELECTRONIC THROTTLE CONTROL (ETC) LAMPS ON WITH BOTH DIAGNOSTIC TROUBLE CODE (DTC) P2106 AND P2135.
Read full bulletin
*TT
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS.
Read full bulletin
VARIOUS MODELS INCLUDING 2004 F-SERIES. *TT
ELECTTRONIC THROTTLE CONTROL WARNING MESSAGE OR LAMP ON - MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE...
Read full bulletin
CODE (DTC) P2106 - POSSIBLE DRIVEABILITY SYMPTOMS. *TT
Pre-Delivery & Maintenance
2 bulletinsMOISTURE IN STORAGE COMPARTMENT.
Read full bulletin
*EH
REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS.
Read full bulletin
*TT
Other
2 bulletinsVIBRATION FELT FOR A FEW MILES OF DRIVING AFTER PARKING.
Read full bulletin
*EH
DIAGNOSTIC TROUBLE CODE (DTC) P0300-P0308 OR P0350-P0358.
Read full bulletin
*TT
Brakes
2 bulletinsDIAGNOSTIC TROUBLE CODE (DTC) C1145 AND/OR C1155 STORED IN ANTI-LOCK BRAKE SYSTEM (ABS) MODULE.
Read full bulletin
*TT
ABS WARNING INDICATOR ON WITH DIAGNOSTIC TROUBLE CODE C1145 AND/OR C1155.
Read full bulletin
*TT
Fuel System
2 bulletinsREAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR.
Read full bulletin
*TT
INOPERATIVE ELECTRIC REAR WINDOW DEFROSTER (HEATED BACKLITE) GRID LINES, INTEGRAL ANTENNA CONCERNS.
Read full bulletin
*TT
HVAC & Climate
1 bulletinSQUEAKING NOISE WHEN SWITCHING CLIMATE CONTROL BETWEEN PANEL, FLOOR AND PANEL/FLOOR MODES.
Read full bulletin
*TT