2005 Ford Taurus TSBs
31 Technical Service Bulletins across 10 categories
Categories
Engine
8 bulletinsCAMSHAFT TICK NOISE - 3.0L 4V ENGINE ONLY.
Read full bulletin
*TT
SPARK KNOCK, HESITATION ABOVE 3000 RPM, LOSS OF POWER, MISFIRE, AND POSSIBLE ENGINE DAMAGE DUE TO DETONATION AND PRE-IGNITION - 3.0L-2V VULCAN GAS/FFV.
Read full bulletin
*TT
WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING.
Read full bulletin
*TT
SURGE, IDLE ROLL, ROUGH IDLE ONLY WHEN THE ENGINE COOLING FANS ARE OPERATING.
Read full bulletin
*TT
VARIOUS DRIVEABILITY CONDITIONS-3.0L 2V AND FLEX FUEL ENGINE.
Read full bulletin
*SC
NO CRANK - BATTERY DISCHARGED ON 3.0L 4V ENGINE.
Read full bulletin
*TT
HARD START, EXCESSIVE OIL PRESSURE, OIL LEAKS AT OIL FILTER O-RING ON 3.0L 2V ENGINES BUILD DATES 9/27/2004 AND 9/28/2004 ONLY.
Read full bulletin
*TT
ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS.
Read full bulletin
TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04.
Body & Paint
4 bulletinsThis article supersedes TSB 19-2026 to update the vehicle model years affected.
Read full bulletin
Some 2000 and newer Ford/Lincoln/Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended.
Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns...
Read full bulletin
appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Follow the Service Procedure steps to correct the condition
Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns...
Read full bulletin
appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Follow the Service Procedure steps to correct the condition
POWER WINDOW CONCERNS - SERVICE TIP.
Read full bulletin
*TT
Electrical
4 bulletinsThe Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs).
Read full bulletin
The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate when reading these PIDs and cannot display quickly enough to validate a concern. The PCM automatically monitors these inputs more accurately and will set diagnostic trouble codes (DTCs) when appropriate. Using these PIDs for diagnostics will lead to inaccurate results and improper ETB replacements. If a concern is intermittent and no DTCs are present, refer to historical DTCs and the PC/ED, Section 3 No DTCs Present Index chart for further information.
EXTENDED WARRANTY COVERAGE FOR VEHICLES WITH HARD START WHEN OPERATING ON E85 FUEL, POWERTRAIN CONTROL MODULE (PCM) CALIBRATION.
Read full bulletin
WARRANTY EXTENDED FOR 10 YEARS OR 100,000 MILES WHICH EVER COMES FIRST. SAMPLE CONSUMER LETTER ATTACHED. *KB
3.0L 4V - MIL ON - WITH MULTIPLE COIL DTC CODES.
Read full bulletin
*KB
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES.
Read full bulletin
*TT
Transmission
4 bulletinsERRATIC FLUID LEVEL READING ON TRANSAXLE DIPSTICK-LEAKS-4F50N, AX4N, AX4S TRANSAXLE.
Read full bulletin
*SC
DTCS P0760 AND P0763-4F50N TRANSAXLE-VEHICLES BUILT BEFORE 3/15/2005.
Read full bulletin
THIS MAY BE DUE TO A SHORTED TRANSAXLE INTERNAL HARNESS, CAUSED BY A SHARP EDGE ON THE INSIDE OF THE SIDE COVER CASTING. *SC
4F50N TRANSAXLE NO 1-2 UPSHIFT AND DIAGNOSITC TROUBLE CODE P0732.
Read full bulletin
*TT
GROAN/BUZZ/VIBRATION WHEN THE GEAR SELECTOR IS IN PARK WITH THE VEHICLE PARKED ON AN INCLINE.
Read full bulletin
*TT THIS BULLETIN UPDATES PREVIOUS BULLETIN 17358, DATED 11/01/2003 TO INCLUDE 2005 MODELS. *TT
Fuel System
3 bulletinsFLEX FUEL - LONG CRANK/HARD START.
Read full bulletin
*TT
NO START/HARD START/ROUGH RUNNING DURING COLD WEATHER - INCORRECT SEASONAL FUEL BLEND.
Read full bulletin
*TT
REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR.
Read full bulletin
*TT
Other
3 bulletinsRKE INOPERATIVE. *EH
WELD BONDING PROCEDURE.
Read full bulletin
*TT
SAFETY BELT RETRACTION SPEED.
Read full bulletin
*TT
Pre-Delivery & Maintenance
2 bulletinsPOWER LOCK CONCERNS - SERVICE TIP.
Read full bulletin
*TT
SAFETY BELT WEB STOP BUTTON SERVICE.
Read full bulletin
*EH
Infotainment
1 bulletinTENTHS DIGIT NOT DISPLAYED ON ODOMETER AFTER 10,000 MILES/KILOMETERS.
Read full bulletin
*TT
Software & Calibration
1 bulletinACCELERATION PEDAL VIBRATION.
Read full bulletin
*EH UPDATES. *TT
Air Bags & Safety
1 bulletinAIR BAG SYSTEM WARNING LIGHT ON WITH DIAGNOSTIC TROUBLE CODE (DTC) B1884.
Read full bulletin
*MJ