1999 Ford Super Duty F Series TSBs

SOME VEHICLES EQUIPPED WITH THE 5.4L 2V ENGINE MAY EXHIBIT A WHISTLING NOISE FROMTHE FORMED NYLON TUBE INTHE IDLE-AIR BYPASS FLOW CIRCUIT.

ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE.

SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA.

SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174.

SOME IGNITION SWITCH LOCK CYLINDER ASSEMBLIES MAY EXHIBIT ROUGNESS AND / OR EXCESS EFFORT IN TURNING, KEY DOES NOT FULLY...

INFORMATION TO AID IN DIAGNOSIS FOR CLARIFICATION OF LOCK-OFF SOLENOID AND SOLENOID TANK VALVE COIL RSISTANCES FOR BI-FUEL VEHICLES.

ON SOME VEHICLES THERE MAY BE AN OIL LEAK FROM THE RIGHT HAND HEAD GASKET AT THE REAR OF THE BLOCK / HEAD JOINT.

SOME VEHICLES EQUIPPED WITH A POWERSTROKE DIESEL ENGINE MAY EXHIBIT A NOISE ABOVE THE NORMAL SOUND OF THE DIESEL COMBUSTION.

SOME VEHICLES BUILT BEFORE 01/05/2000 MAY EXHIBIT A POWER STEERING COOLER LEAK DUE TO THE COOLER IMPACTING A SOLID OBJECT.

INFORMATION ON REPROGRAMMING A PCM WITH THE LATEST CALIBRATION ON CERTAIN VEHICLES EQUIPPED WITH A 7.3L DIESEL ENGINE.

SOME VEHICLES EQUIPPED WITH 7.3L DIT ENGINE AND THE CHARGE AIR COOLER (CAC) MAY EXHIBIT OIL LEAKS AROUND THE CAC TUBE ON...

A CONDITION MAY EXIST WITH LACK OF POWER UNDER A LOAD, AT CRUISE OR ON ACCELERATION MAY OCCUR ON SOME VEHICLES BUILT...

SOME VEHICLES EQUIPPED WITH 7.3L DIT ENGINE AND ZF-M6HD 6 SPEED TRANSMISSION MAY EXHIBIT A SLIGHTLY HIGHER IDLE AT COLD TEMPERATURES.

SUBJECT REGARDING ENGINE OIL RECOMMENDATIONS FOR USE IN 2001 VEHICLES - SAE 5W-20 MOTOR OIL.

FUEL QUALITY AND MOISTURE IN CERTAIN DIESEL FUELS MAY CAUSE SOME VEHICLES TO EXHIBIT A NO START, GRADUAL LOSS OF POWER,...

SOME VEHICLES MAY EXHIBIT THE ENGINE OIL SENDING UNIT CONTACTING THE OIL DRIP SHIELD ATTACHED TO THE FRONT AXLE.

THIS BULLETIN ADDRESSES CONCERNS A NOISE AT INTIAL ENGINE STARTUP WHEN COLD FROM THE ACCESSORY DRIVE BELT.

SOME VEHICLES EQUIPPED WITH POWERSTROKE DIESEL ENGINES AFTER SERIAL NUMBER 0896812 (ENGINE BUILD DATE), MAY EXHIBIT A...

SOME VEHICLES MAY EXHIBIT AN ENGINE BUCK, SURGE, OR JERK (ALSO KNOWN AS HITCHING / HESITATION) WHILE THE SPEED CONTROL...

SOME VEHICLES EQUIPPED WITH POWERSTROKE DIESEL MAY EXHIBIT A NOISE ABOVE THE NORMAL SOUND OF THE DIESEL COMBUSTION.

SOME VEHICLES EQUIPPED WITH 6.8L ENGINE AND 4R100 TRANSMISSION MAY EXHIBIT GEAR CHANGES THAT TAKE TOO LONG TO COMPLETE...

SOME VEHICLES EQUIPPED WITH A POWERSTROKE DIESEL ENGINE MAY EXHIBIT A NOISE ABOVE THE NORMAL SOUND OF THE DIESEL COMBUSTION.

BRIEF DIAGNOSTIC INFORMATION FOR VEHICLES WITH 7.3L DIT DIESEL EXHIBITING ROUGH IDLE.

SOME VEHICLES EQUIPPED WITH 7.3L DIESEN ENGINE AND 4R100 TRANSMISSION MAY EXHIBIT A RATTLE / SCRAPPING NOISE FROM THE BELL HOUSING AREA OF THE CASE.

SOME VEHICLES EQUIPPED WITH A 7.3L DIT ENGINE MAY EXHIBIT SOME REDUCED POWER STEERING ASSIST UNDER HARD BRAKING.

SUBJECT REGARDING REQUEST FOR FIELD INPUT TO ENGINEERING FOR VEHICLES EXHIBITING A LACK OF ON-CENTER STEERING FEEL AND /...

SOME VEHICLES MAY EXHIBIT BRAKE VIBRATION OR SHUDDER WHILE BRAKING.

SOME VEHICLES EQUIPPED WITH 7.3 DIT ENGINE MAY EXHIBIT ENGINE ROUGHNESS, MISSES, BUCK / JERK, HESITATION / STUMBLE,...

SOME VEHICLES EQUIPPED WITH 7.3L DEISEL ENGINE AND 4R100 TRANSMISSION MAY EXHIBIT A RATTLE/SCRAPPING NOISE FROM THE BELLHOUSING AREA OF THE CASE.

REPEAT / REVISED MESSAGE REGARDING ROUGH IDLE.

INFORMATION ON THE 7.3L DIT ENGINES, ROTUNDA TOOL HAS ISSUED AN INJECTOR PERFORMANCE ANALYZER THAT MAY NOW BE PRUCHASED...

SOME VEHICLES MAY EQUIPPED WITH 7.3L DIESEL ENGINE, OPERATING IN COLD CONDITIONS MAY EXHIBIT A GRADUAL LOSS OF POWER AT CRUISE.

CONCERNS WITH A NO START CONDITION AFTER INSTALLATION OF A NEW 6.8L ENGINE ASSEMBLY.

SOME VEHICLES MAY EXHIBIT A NO START CONDITION AFTER INSTALLATION OF A NEW 6.8L ENGINE ASSEMBLY.

THE F-SERIES EQUIPPED WITH 7.3L DIT ENGINE AND THE CHARGE AIR COOLER (CAC) MAY EXHIBIT OIL LEAKS AROUND THE CAC TUBE ON...

INFORMATION ON THE IDLE KICKER FEATURE, WHICH UNDER CONDITIONS WILL AUTOMATICALLY ELEVATE THE IDLE SPEED AFTER 130...

SOME VEHICLES EQUIPPED WITH 7.3L DIT ENGINE MAY EXHIBIT A ROUGH ENGINE IDLE.

SOME VEHICLES BUILT AFTER 12/7/1998 EQUIPPED WITH A 7.3L DIT ENGINE MAY EXHIBIT A HOOT OR HOWLING NOISE FROM THE TURBOCHARGER.

SOME VEHICLES EQUIPPED WITH 73L DIT ENGINE MAY EXHIBIT A ROUGH ENGINE IDLE.

SOME TRUCKS EQUIPPED WITH A 7.3L DIT ENGINE MAY EXHIBIT SOME REDUCED POWER STEERING ASSIST UNDER HARD BRAKING.

AIR FILTER SATURATED WITH WATER.

SOME VEHICLES WITH 7.3L ENGINES MAY EXHIBIT AN INOPERATIVE VACUUM PUMP.

SOME VEHICLES EQUIPPED WITH A 7.3L DIT ENGINE MAY EXHIBIT A HOOT OR HOWLING NOISE FROM THE TURBOCHARGER.

SOME MEDIUM TRUCKS EQUIPPED WITH 7.3L DIT MAY EXHIBIT AN INTERMITTENT ENGINE KNOCK PERCEIVED TO BE FUEL CACKLE.

SOME VEHICLES EQUIPPED WITH DUAL REAR WHEELS (DRW) MAY EXHIBIT ERRATIC AUTOMATIC TRANSMISSION SHIFTING, ERRATIC...

SOME VEHICLES WITH 7.3L DIT DIESEL ENGINE MAY EXHIBIT A 1-2 MPH SPEED VARIATION (SURGE / HITCH) AT CRUISE AND / OR WHEN THE SPEED CONTROL IS ENGAGED.

INFORMATION ON ALL VEHICLES BUILT AFTER 5/19/99 EQUIPPED WITH THE 7.3L DIT WITH A ENGINE SERIAL # GREATER THAN 1039780...

VEHICLES BUILT AFTER 5/19/1999 WITH THE 7.3L DIT WITH A ENGINE SERIAL # GREATER THAN 1039780 NOW HAVE A FILTER SCREEN...

VEHICLES BUILT THROUGH 11/29/1999 MAY EXPERIENCE A THUMPTING NOISE FROM THE AIR CONDITIONER SYSTEM DURING COLD ENGINE STARTUP.

SUBJECT REGARDING 4R100 TRANSMISSION FLEXPLATE REPLACEMENT FOR VEHICLES WITH 7.3L DIESEL ENGINE.

ON SOME VEHICLES NOT EQUIPPED WITH CRUISE CONTROL, THE ENGINE'S IDLE SPEED MAY BE TOO LOW WHEN ENGINE IS COLD.

INFORMATION ON 7.3L DIT VEHICLES EXHIBITING AN INTERMITTENT ENGINE KNOCK WHICH MAY BE PERCEIVED AS A ROD KNOCK.

INFORMATION ON VEHICLES BUILT FROM 2/22/99 THROUGH 7/3/99 EQUIPPED WITH DUAL REAR WHEELS (DRW) EXHIBITING ERRATIC...

CONCERNS WITH A HARD TO TURN IGNITION KEY AND / OR A HARD TO REMOVE KEY FROM IGNITION CYLINDER.

EXPERIENCING A ENGINE KNOCK AT COLD START-UP.

EXPERIENCING HOOT OR HOWL NOISE FROM TURBOCHARGER.

FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS.

FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR.

EXPERIENCING A SHIFT FLARE (RISE IN ENGINE RPM) DURING 2-3 AND / OR 3-4 UPSHIFT.

FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS.

A NOISE FROM HYDRO-MAX BRAKE BOOSTER ASSEMBLY- MOTORHOME CHASSIS VEHICLES.

EXHIBITING ROUGH IDLE AND ENGINE MISS DUE TO INJECTOR BORE SCUFFING AT GREEN ENGINE BREAK-IN.

STEERING WHEEL ALIGNMENT- VEHICLES WITH MOTORHOME CHASSIS.

DRIVEABILITY-NO START/REPEAT STARTER FAILURE-REPEAT STARTER REPLACEMENT.

BROKEN EXHAUST MANIFOLD STUDS.

NO START/REPEAT STARTER FAILURE OR A STICKING/BINDING IGNITION LOCK CYLINDER, STARTER STAYING ENGAGED AT START UP.

SOME VEHICLES BUILT AFTER 12/7/1998 EQUIPPED WITH A 7.3L DIT ENGINE MAY EXHIBIT A HOOT OR HOWLING NOISE FROM THE TURBOCHARGER.

HIGH PRESSURE OIL PUMP LEAK ON VEHICLES EQUIPPED WITH 7.3L DIESEL ENGINE.

A LOSS OF POWER, OIL LEAKS AROUND THE TURBO, AND/OR EXCESSIVE EXHAUST NOISE FROM THE TURBO.

ENGINE OIL PAN CORROSION ON VEHICLES EQUIPPED WITH THE 7.3L DIESEL ENGINE.

EXTERNAL OIL LEAK DIAGNOSIS FOR 7.3L DIT ENGINES.

A LACK OF POWER UNDER A LOAD, AT CRUISE OR ON ACCELERATION MAY OCCUR ON SOME VEHICLES BUILT BEFORE 11/25/2000 EQUIPPED WITH THE 7.3L DIT ENGINE.

FUEL QUALITY AND MOISTURE IN CERTAIN DIESEL FUELS MAY CAUSE SOME VEHICLES TO EXHIBIT A NO START, GRADUAL LOSS OF POWER,...

7.3L POWERSTROKE DIESEL ENGINE WITH ENGINE SERIAL NUMBER 661894 THROUGH 1311240 MAY EXHIBIT A KNOCK NOISE ABOVE THE...

VEHICLES EQUIPPED WITH 7.3L DIT ENGINE BUILT AFTER ENGINE SERIAL NUMBER 896812 MAY HAVE A INJECTION CONTROL PRESSURE...

FOR 7.3L DIT ENGINES, ROTUNDA TOOL HAS ISSUED AN INJECTOR PERFORMANCE ANALYZER THAT MAY NOW BE PURCHASED AS AN EFFECTIVE...

ON SOME VEHICLES NOT EQUIPPED WITH CRUISE CONTROL, THE ENGINE MAY IDLE AT THE NORMAL ENGINE RPM BUT LACKS THE COLD...

SIGNIFICANT 1999 7.3L DIESEL ENGINE CONTENT REVISIONS.

ROUGH IDLE AND ENGINE MISS DUE TO INJECTOR BORE SCUFFING AT GREEN ENGINE BREAK-IN.

A CACKLING NOISE WITH THE ENGINE WARM AND SLIGHTLY ABOVE IDLE, AND/OR A BUZZING NOISE FROM THE FUEL PRESSURE REGULATOR...

SIGNIFICANT CHANGES HAVE BEEN MADE TO THE 7.3L DIT ENGINE EFFECTIVE WITH THE 1998 AND 1999 MODEL YEARS.

TURBO PEDESTAL SEAL OIL LEAK AROUND THE EXHAUST BACK PRESSURE (EBP) ACTUATOR.

A LOSS OF POWER, OIL LEAKS AROUND THE TURBO, AND/OR EXCESSIVE EXHAUST NOISE FROM THE TURBO.

ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED...

SOME VEHICLES MAY EXHIBIT A FEAD BELT SQUEAL.

SOME VEHICLES MAY EXPERIENCE THE SEAT AND SEAT BACK MAY LOSE ITS MEMORY POSITION AND NOT LATCH OR LOCK IN THE DESIRED POSITION.

ON SOME VEHICLES, THE SEAT AND SEAT BACK MAY LOSE ITS MEMORY POSITION AND NOT LATCH / LOCK IN THE DESIRED POSITION.

SUBJECT REGARDING DIAGNOSTICS AND / OR MECHANICAL CONCERNS REGARDING THE NEW VENUTURE TRANSFER CASE.

CONCERNS WITH VEHICLES EXHIBITING THE OIL PRESSURE GAUGE REGISTERING LOW OR NO OIL PRESSURE USUALLY ON INITIAL START-UP...

EXHIBITING A SQUEAL TYPE NOISE FROM THE FRONT AXLE AREA.

EXHIBITING CONCERNS WITH REAR SEAT BACK OPERATION WHEN TRYING TO ACCESS OBJECTS BEHIND THE REAR SEAT.

A TEMPORARY TECHNICAL ASSISTANCE HOTLINE HAS BEEN ESTABLISHED TO HELP WITH DIAGNOSTICS AND / OR MECHANICAL CONCERNS WITH...

A TECHNICAL ASSISTANCE HELPLINE HAS BEEN ESTABLISHED TO HELP WITH DIAGNOSTICS AND / OR MECHANICAL CONCERNS WITH THE NEW...

INFORMATION ON NORMALLY OCCURRING INTERMITTENT TRANSFER CASE BINDUP.

VEHICLES MAY EXPERIENCE FRONT STABILITY BAR BREAKING OFF, VEHICLES BUILT FROM 1/1/98.

SOME TRUCKS MAY EXHIBIT A SQUEAL TYPE NOISE FROM THE FRONT AXLE AREA.

SOME VEHICLES EQUIPPED WITH EITHER DANA 80 OR S135 AXLE MAY EXHIBIT FLUID LEAKAGE FROM THE AXLE VENT TUBE DUE TO FLUID OVERFILL.

THE SEAT BACK MAY NOT LATCH/ LOCK IN THE DESIRED POSITION AND REMAIN FOLDED FORWARD OVER THE SEAT CUSHION.

SUBJECT REGARDING ACCELERATOR PEDAL REPLACEMENT FOR VEHICLES EXHIBITING A SURGE DURING CRUISE AT HI-WAY SPEEDS.

SUBJECT REGARDING RIDE HEIGHT PRODUCTION CHANGE.

DON NOT PERFORM TSB 98-17-02 IF BUILT AFTER 2/13/1999.

7.3L DIT OIL FITER TORQUE SPECIFICATION.

SOME OPERATORS MAY REPORT THAT THE 4X4 SYSTEM IS STUCK IN 4-LOW.

SUBJECT REGARDING INCREASING FRONT AND / OR REAR GROSS AXLE WEIGHT RATINGS (GAWR).

INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA.

CONDITIONS WITH NORMALLY OCCURING INTERMITTENT TRANSFER CASE BINDUP.

SOME VEHICLES MAY DEVELOP A NEUTRALIZATION CONDITION OF THE TRANSFER CASE.

INFORMATION REGARDING ACCELERATOR PEDAL REPLACEMENT.

SOME VEHICLES MAY EXHIBIT A FLOORPAN VIBRATION DURING PART-THROTTLE ACCELERATION.

SOME VEHICLES MAY EXHIBIT A POWERTRAIN MOAN AROUND 2200 RPM.

INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS.

EXPERIENCING A SQUEALING NOISE FROM THE FRONT AXLE.

PRODUCTION CHANGE TO LOWER REAR RIDE HEIGHT.

VEHICLE EXHIBITING A 1-2 MPH SPEED VARIATION (SURGE / HITCH) AT CRUISE AND / OR WHEN THE SPEED CONTROL IS ENGAGED.

INFORMATION ON OIL FILTER TORQUE SPECIFICATION.

SOME VEHICLES MAY EXHIBIT A

CONDENSATE MAY LEAK ONTO THE PASSENGER FLOOR ON SOME VEHICLES.

CONCERNS WITH THE POWER SEAT CONTROL BUTTON ( KNOB ) MAY DETACH FROM THE SWITCH ACTUATOR.

SOME DIFFICULTY IN MATCHING THE TEXTURE OF THE OEM ANTI-CHIP STONE ABRASION MATERIAL TO RPAIR MATERIALS WHEN SERVICING.

DIAGNOSTIC TROUBLE CODE (DTC) P0340, POSSIBLE FALSE CODE.

FILM OF OIL/DUST AT THE CHARGE AIR COOLER (CAC) HOSE CONNECTIONS.

SEVERE DUTY AIR FILTER KIT DOES NOT FIT - INFORMATION.

BRAKE SHIFT INTERLOCK.*JB

INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS.

SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM.

ALL 4X4 VEHICLES WITH ELECTRONIC SHIFT ONTHE FLY TRANSFER CASES WILL DISPLAY CONTACT PLATE PIDS OPPOSITE OF THE 1999 OR...

SOME VEHICLES EQUIPPED WITH 7.3L DI MAY EXHIBIT A GEAR ROLLOVER TYPE NOISE FROM THE ZF 6 SPEED MANUAL TRANSMISSION...

INFORMATION REGARDING THE 1999 SCHEDULED MAINTENANCE GUIDE FOR ANY LIGHT TRUCK, SPORT UTILITY OR VAN EQUIPPED WITH A...

SOME VEHICLES WITH 4R1000 TRANSMISSION MAY EXHIBIT A CONCERN OF FUSE #19 BLOWN, OVERDRIVE CANCEL LIGHT (OCIL) FLASHING...

SOME VEHICLES EQUIPPED WITH THE ZF 5 SPEED TRANSMISSION MAY EXHIBIT A SQUEAK NOISE FROM THE CLUTCH SYSTEM WHEN THE CLUTCH IS DEPRESSED AND RELEASED.

RECENT REPORTS INDICATE DIFFICULTY LOCATING THE ELECTRONIC SHIFT ON THE FLY TRANSFER CASE RELAYS FOR CERTAIN VEHICLES.

SOME VEHICLES EQUIPPED WITH ELECTRONIC SHIFT ON THE FLY TRANSFER CASE MAY EXHIBIT FRONT HUBS THAT WILL NOT UNLOCK / LOCK...

VEHICLES MAY EXPERIENCE SOLID PARTICLE CONTAMINANTS FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR, MAY BE TRAPPED IN...

SUBJECT REGARDING TRANSFER CASE SHIFT RELAY LOCATION.

SOME VEHICLES EQUIPPED WITH ELECTRONIC SHIFT ON THE FLY TRANSFER CASE MAY EXHIBIT ONE OR MORE OF THE FOLLOWING...

VEHICLES MAY EXPERIENCE PARTICLE CONTAMINANTS, FROM PRIOR TRANSMISSIION CONCERNS OR EXCESS WEAR, MAY BE TRAPPED IN THE...

INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP.

EXHIBITING ELECTRONC SHIFT ON THE FLY (ESOF) AND / OR RKE MALFUNCTION AFTER REPLACING A GEM DUE TO AN INCORRECT LEVEL GEM BEING INSTALLED.

TRANSMISSION- E40D/4R100-1989-99-MAIN CONTROLS, SEPARATOR PLATES AND SEPARATOR PLATE GASKETS USAGE CHART.

SOME VEHICLES EQUIPPED WITH MANUAL TRANSMISSION TRANSFER CASE MAY DEVELOP A NEUTRALIZATION CONDITION OF THE TRANSFER CASE.

SUBJECT REGARDING TRANSFER CASE ASSISTANCE - NEW VENTURE GEAR HOTLINE.

SOME VEHICLES EQUIPPED WITHOUT POWER WINDOWS OR LOCKS, MAY EXHIBIT A MALFUNCTION INDICATOR LAMP, ERRATIC AUTOMATIC...

SOME VEHICLES WITHOUT POWER WINDOWS OR LOCKS, BUILT FROM 1/1/1998 THROUGH 9/22/1998 MAY EXHIBIT ONE OR ALL OF THE...

INFORMATION REGARDING PROCEDURE FOR SHIFTING OUT OF 4 LOW.

INFORMATION REGARDING ANNOUNCEMENT OF NEW CLUTCH AVAILABILITY.

INFORMATION REGARDING ANNOUNCING AVAILABILITY OF NEW CLUTCH RELEASE BEARING.

INFORMATION REGARDING NEW CLUTCH AVAILABLE.

INFORMATION REGARDING THE AVAILABILITY OF NEW CLUTCH RELEASE BEARING.

INFORMATION REGARDING ANNOUNCEMENT OF NEW CLUTCH AVAILABLE.

A CONCERN WITH HARD SHIFTING WHEN VEHICLE IS CLOD OR SHIFT LEVER MAY BE BROKEN / BENT.

SOME VEHICLES MAY EXHIBIT A NO 3-4 UPSHIFT, OR A 3-4 / 4-3 SHIFT HUNT ONLY WHILE THE CRUISE CONTROL IS IN USE.

CONCERNS WITH TRANSMISSION FLUID LEAKING AT THE RADIATOR.

CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK.

A " TICKING " NOISE ON INITIAL STARTUP WITH SHIFT SELECTOR IN " P " OR " N " POSITION MAY OCCUR ON SOME VEHICLES.

SERVICE PROCEDURE FOR ORANGE SERVICE TAGGED TRANSMISSIONS.

INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART.

LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK.

COLD SHIFT CONCERNS ON VEHICLES EQUIPPED WITH 4R100 AUTOMATIC TRANSMISSIONS.

NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS.

SOME VEHICLES MAY EXHIBIT INCREASED STEERING EFFORTS AT VERY LOW SPEEDS OR WHEN STOPPED WITH THE BRAKES APPLIED.

INFORMATION ON VEHICLES WITH REAR WHEEL ANTI-LOCK BRAKING SYSTEMS (ABS) THAT MAY EXHIBIT AN ABS LAMP ON WITH A STORED...

A SLIGHT PURGE OF GREASE FROM THE FRONT HUB BEARING UNIT THAT MAY BE NOTED BETWEEN THE HUB UNIT AND THE INBOARD ROTOR FLANGE.

SOME VEHICLES MAY EXHIBIT HIGHER THAN NORMAL STEERING EFFORTS WHEN THE VEHICLES IS AT A VERY LOW SPEED OR STOPPED WITH THE BRAKES APPLIED.

SOME VEHICLES MAY EXPERIENCE A PULL UNDER HARD BRAKING.

SOME VEHICLES MAY EXHIBIT AN ANTI-LOCK BRAKE LAMP ILLUMINATED AND A B1845 STORED.

SOME MAY EXHIBIT AN ANTI-LOCK BRAKE LAMP ILLUMINTED AND A B1845 STORED.

SOME VEHICLES MAY EXHIBIT A PULL TO THE LEFT WHILE BRAKING CONDITION.

SOME VEHICLES MAY EXHIBIT A PULL TO THE LEFT CONDITION WHILE BRAKING.

SOME VEHICLES MAY EXHIBIT BRAKE VIBRATION OR SHUDDER WHILE BRAKING.

VEHICLES EQUIPPED WITH REAR WHEEL ANTI-LOCK BRAKES MAY EXHIBIT AN ABS LAMP ON AND DIAGNOSTIC TROUBLE CODE C1115.

INFORMATION REGARDING VEHICLE PULLING LEFT DURING HARD BRAKING.

INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT.

EXPERIENCING A SQUAWKING NOISE WHILE IN REVERSE BACKING UP A SLIGHT GRADE AND / OR WHILE APPLYING THE BRAKES.

SOME VEHICLES MAY EXHIBIT AN ANTI-LOCK BRAKE SYSTEM (ABS) LAMP ON AND DIAGNOSTIC TROUBLE CODE (DTC) C1115).

EXHIBITING A FRONT SPRING PAD SQUEAK.

INFORMATION REGARDING NEW DESIGN FRONT ROTORS AND HUBS SERVICE TIPS.

SUBJECT ON ANTI-LOCK BRAKE SYSTEM (ABS) LAMP STRATEGY CHANGE.

A NEW PARKING BRAKE CONTROL RUBBER BUMPER STOP IS NOW AVAILABLE FOR SERVICE.

AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT.

SLIGHT PURGE OF GREASE FROM THE HUB BEARING UNIT.

CONCERNS OF DIAGNOSTIC TROUBLE CODE P1280 RETRIVED FROMTHE POWER TRAIN CONTROL MODULE (PCM).

INFORMATION REGARDING DISCHARGED BATTERY CHARGING SERVICE TIPS AND GUIDELINES.

ADDING ADDITIONAL BULBS TO TURN INDICATOR OR HAZARD FLASHER CIRCUITS.

SOME VEHICLES MAY EXHIBIT A FUSE #19 BLOWN, OVERDRIVE CANCEL LIGHT (OCIL) FLASHING AND INSTRUMENT CLUSTER GAUGES INOPERATIVE.

INFORMATION REGARDING ELECTRONIC CRASH SENSOR (ECS-2) CONFIGURATION.

INFORMATION REGARDING (NOT) TO REPROGRAM A PCM WITH THE LATEST CALIBRATION ON A PRE-DECEMBER 1998 BUILD DATE.

INFORMATION ON REPROGRAMMING THE PCM WITH THE LATEST CALIBRATION.

SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO DIAGNOSTIC...

INFORMATION ON REPLACING AND REMOVING THE GENERIC ELECTRONIC MODULE (GEM).

INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS.

SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES.

INFORMATION ON USING THE SERVICE BAY TECHNICAL SYSTEM (SBTS) AND NEW GENERATION STAR (NGS) TESTER, AND TO UPDATE THE...

SOME VEHICLES MAY EXHIBIT A MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED WITH A FALSE DIAGNOSTIC TROUBLE CODE (DTC)...

SOME CUSTOMERS MAY REQUIRE A HEAVY DUTY 7-WAY TRAILER WIRING CONNECTOR SYSTEM WHEN THE VEHICLE IS EQUIPPED WITH A 4-WAY CONNECTOR.

THE MALFUNCTION INDICATOR LAMP (MIL) MAY ILLUMINATE WITH A FALSE DIAGNOSTIC TROUBLE CODE (DTC) P1298 (INJECTOR DRIVE MODULE (IDM) FAILURE).

SOME VEHICLES MAY EXHIBIT A FRONT OR REAR PINION SEAL LEAK.

INFORMATION ON REAR AXLE PINION SEAL PART USAGE.

INFORMATION ON VEHICLES WITH DOOR COURTESY LIGHTS.

SOME MODEL YEAR VEHICLES WITH THE OPTIONAL OVERHEAD WARNING INDICATOR CONSOLE MAY EXHIBIT THE DOOR AJAR WARNING AND...

SOME VEHICLES MAY EXHIBIT A DISCOLORATION ON THE A-PILLAR OF THE CAB BETWEEN THE DOOR ON THE FRONT SEAL.

INFORMATION ON WINDSHIELD REPAIRS.

SOME VEHICLES MAY EXHIBIT A DISCOLORATION ON THE A-PILLAR OF THE CAB BETWEEN THE DOOR ON THE FRONT SEAL.

SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP.

CONCERNS WITH THE POTENTIAL EFFECTS OF ADHESIVES USED FOR BODY PANEL REPAIRS.

CONCERNS WITH ADHENSIVES NOT RECOMMENDED FOR BODY PANEL REPAIRS.

SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF,...

SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS.

INFORMATION USED WHEN PERFORMING THE AIR CONDITIONER SYSTEM RECHARGE SERVICE ON CERTAIN VEHICLES.

INFORMATION ON PERFORMING AIR CONDITIONER SYSTEM RECHARGE SERVICE.

SOME CUSTOMERS MAY COMMENT ABOUT THE CLIMATE CONTROL SYSTEM DEFAULTING TO DEFROST MODE AND / OR NO AIR DISTRIBUTION CONTROL.

EXPERIENCING CONDENSATION LEAKS ON THE PASSENGER FLOOR COMING FROM THE FLOOR DUCT OR HEATER CORE SEAL.

SOME VEHICLES MAY EXHIBIT A CONCERN OF A/C BLOWS OUT DEFROST NOZZLE ONLY.

INFORMATION REGARDING THUMP NOISE IN A/C AFTER START-UP.

INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS.

SOME VEHICLES MAY EXHIBIT CONDENSATION LEAKS ON THE PASSENGER FLOOR COMING FROM THE FLOOR DUCT OR HEATER CORE SEAL.

SUBJECT REGARDING THE A/C BLOWING OUT DEFROST NOZZLE ONLY.

EXPERIENCING THUMP NOISE IN AIR CONDITIONER (A/C) AFTER START-UP.

SQUEAK FROM THE FRONT LEAF SPRING AREA.

SOME VEHCLES BUILT FROM JOB 1 TO 5/5/1999 MAY EXHIBIT A SQUEAKING NOISE EMANATING FROM THE FRONT SPRINGS.

THE 4X4 SYSTEM, PARTICULARLY THE FRONT LOCKING HUBS.

SOME VEHICLES MAY EXHIBIT A SLOW RELEASE OF THE HUBS, AT TIMES, WHICH MAY BE REGARDED AS NOT NORMAL BY THE OPERATOR.

SOME VEHICLES BUILT FROM JOB 1 TO 5/5/1999 MAY EXHIBIT A SQUEAKING NOISE EMANATING FROM THE FRONT SPRINGS.

SOME VEHICLES MAY EXHIBIT A SQUEAKING NOISE EMANATING FROM THE FRONT SPRINGS.

INFORMATION REGARDING FRONT SWAY BAR BRACKET.

INFORMATION REGARDING FRONT SWAY BAR BRACKET.

REAR LEAF SPRING NOISE.

ON-VEHICLE FRONT INTEGRATED HUB/BEARING ROCKING END-PLAY MEASUREMENT.

NO ENGAGEMENT OR DISENGAGEMENT OF HUB LOCKS AFTER REPLACEMENT OR SERVICE.

INFORMATION REGARDING THE ACCURACY OF THE AVERAGE FUEL ECONOMY AND FUEL RANGE DISPLAYED BY THE OVERHEAD TRIP COMPUTER.

SUBJECT REGARDING THE ACCURACY OF THE AVERAGE FUEL ECONOMY AND FUEL RANGE.

SUBJECT REGARDING REMOVAL OF THE REDUNDANT FUEL CLIP.

EVAPORATOR CORE FAILED, CAUSING THE AIR CONDITIONER TO DRIP ON TO PASSENGER FLOOR.

SUBJECT REGARDING MEDIUM TRUCKS EQUIPPED WITH 7.3L DIT EXHIBITING FUEL CACKLE.

INFORMATION REGARDING FUEL CACKLE.

AWARENESS MESSAGE REGARDING NEW DIESEL INJECTOR.

EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP.

EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM.

INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM.

MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK...

SOME VEHICLES EQUIPPED WITH A DUAL MEDIA RADIO MAY EXHIBIT AN INTERMITTENT OR INOPERATIVE REAR SPEAKER (GENERALLY THE...

SOME VEHICLES EQUIPPED WITH THE OVERHEAD TRIP COMPUTER MAY APPEAR TO HAVE STUCK DISPLAYS OR A DISPLAY NOT UPDATING QUICKLY.

INFORMATION REGARDING RADIO LIGHTS AND DISPLAY FLICKER/FLASH WITH HEADLIGHTS ON.

INFORMATION REGARDING RADIO LIGHTS AND DISPLAY FLICKER/FLASH WITH HEADLIGHTS ON.

INFORMATION REGARDING THE OVERHEAD TRIP COMPUTER APPEARING TO HAVE STUCK DISPLAYS OR A DISPLAY NOT UPDATING QUICKLY.

INFORMATION REGARDING THE AUDIO SYSTEM SELECTIVE LIGHTING FEATURE.

SOME VEHICLES MAY EXHIBIT STIFF STEERING, WANDERING, OR POOR RETURNABILITY AFTER TURNS.

CONCERNS WITH FREEPLAY / STEERING WANDER.

SOME VEHICLES BUILT BEFORE 01/05/2000 MAY EXHIBIT A POWER STEERING COOLER LEAK DUE TO THE COOLER IMPACTING A SOLID OBJECT.

SOME VEHICLES BUILT BEFORE 01/05/00 MAY EXHIBIT A POWER STEERING COOLER LEAK DUE TO THE COOLER IMPACTING A SOLID OBJECT.

SOME VEHICLES MAY EXHIBIT A LACK OF ON-CENTER STEERING FEEL AND / OR STEERING WANDER, OR A CONSTANT PULL TO LEFT OR RIGHT.

SUBJECT REGARDING 5TH WHEEL LOWERING INFORMATION FOR VEHICLES BUILT AFTER 2/14/1999.

SUBJECT REGARDING 5TH WHEEL LOWERING INFORMATION FOR VEHICLES BUILT AFTER 2/14/99.

INFORMATION ON TORQUING OF TRACKBAR WHEN PERFORMING ALIGNMENT.

DO NOT PERFORM TSB 98-17-02 (REAR OF VEHICLE IS TOO HIGH - 5TH WHEEL AND GOOSE NECK APPLICATIONS - 4X4 VEHICLES) ON VEHICLES BUILT AFTER 2/13/1999.

INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE.

INFORMATION REGARDING ANTI-LOCK LIGHT ON REPAIR (H19 WARRANTY CLAIM), WHAT SHOULD BE INCLUDED IN THE CLAIM.

INFORMATION REGARDING THE ANTI-LOCK LIGHT ON REPAIR (H-19 WARRANTY CLAIM).

SOME VEHICLES MAY EXHIBIT MALFUNCTION INDICATOR LAMP ILLUMINATION, AND HAVE A P0500 DIAGNOSTIC TROUBLE CODE STORED IN MEMORY.

EXHIBITING A MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODE (DTC) STORED.

IMPROVEMENTS TO MALFUNCTION INDICATOR LAMP (MIL) DIAGNOSTICS.

RECALL INFORMATION REGARDING SPEED CONTROL CABLE REPLACEMENT.

GRADUAL LOSS OF POWER AT CRUISE.

OUTSIDE AIR TEMPERATURE OPTION OWNER'S GUIDE CORRECTION.

SOME VEHICLES MAY EXHIBIT AN AIR BAG LIGHT ON AND POSSIBLE CODES 1933 AND / OR 1935.