2005 Ford Ranger TSBs
30 Technical Service Bulletins across 9 categories
Categories
Engine
10 bulletinsCertain 2005-2014 Mustang, 2005-2006 GT, 2004-2011 Ranger, 2006-2012 Fusion & MKZ/Zephyr, 2006-2011 Milan, and 2007-2010...
Read full bulletin
Edge & MKX Vehicles Driver & Passenger Airbag Module Quality Control Inspection: Ford Motor Company has determined that some vehicles claimed by dealers as repaired under Takata Airbag Safety Recalls 15S21, 17S42, 18S02, 19S01, and 21S12 may not have received the claimed repairs. The propellant in certain Takata airbag inflators can experience an alteration over time with exposure to certain climate conditions. A combination of time, high temperature fluctuations, and humidity contribute to the degradation of the propellant in the inflators. This degradation can cause the propellant to burn too quickly, creating high pressure inside the inflator, and in extreme cases causing the inflator to rupture in the event of a crash necessitating airbag deployment. A ruptured inflator can send inflator parts toward vehicle occupants resulting in serious injury or death. Additional information regarding Takata recalls can be found at www.nhtsa.gov and www.safercar.gov.
POSSIBLE ENGINE DAMAGE - INSTALL SPECIAL SERVICE TOOLS PRIOR TO REMOVING CRANKSHAFT PULLEY BOLT.
Read full bulletin
*KB
POSSIBLE ENGINE DAMAGE - INSTALL SPECIAL SERVICE TOOLS PRIOR TO REMOVING CRANKSHAFT PULLEY BOLT - SERVICE TIP.
Read full bulletin
*TT
MIL ON WITH VARIOUS MISFIRE RELATED DTC'S P0300-P0306 AND P0316 - 3.0L-2V VULCAN ENGINE.
Read full bulletin
*TT
HIGH IDLE BETWEEN SHIFTS OR IN NEUTRAL - 4.0L ENGINE WITH MANUAL TRANSMISSION.
Read full bulletin
*TT
SPARK KNOCK DURING ACCELERATION - 4.0L ENGINE.
Read full bulletin
*TT
SURGING SENSATION DURING CRUISE AT STEADY SPEEDS OF 35-50 MPH (56-80 KM/H) - 4.0L ENGINE.
Read full bulletin
*TT
HIGH IDLE AT COLD START.
Read full bulletin
*TT
HARD START OR FLOODING WHEN ENGINE IS COLD.
Read full bulletin
*TT
HARD START OR FLOODING DURING COLD START ON 2.3L ENGINE.
Read full bulletin
*TT
Electrical
4 bulletinsCertain 2005-2014 Mustang, 2005-2006 GT, 2004-2011 Ranger, 2006-2012 Fusion and MKZ/Zephyr, 2006-2011 Milan, and...
Read full bulletin
2007-2010 Edge & MKX Vehicles Driver & Passenger Airbag Module Quality Control Inspection REASON FOR THIS SUPPLEMENT Updated Ranger Technical Information to include images of a pass and fail airbag inflator inspection for 2007-2011 model years.
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs).
Read full bulletin
The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate when reading these PIDs and cannot display quickly enough to validate a concern. The PCM automatically monitors these inputs more accurately and will set diagnostic trouble codes (DTCs) when appropriate. Using these PIDs for diagnostics will lead to inaccurate results and improper ETB replacements. If a concern is intermittent and no DTCs are present, refer to historical DTCs and the PC/ED, Section 3 No DTCs Present Index chart for further information.
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES.
Read full bulletin
*TT
GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES.
Read full bulletin
*TT
Other
4 bulletinsLIMITED SLIP AXLE CHATTER, SHUDDER, BINDING SENSATION, OR VIBRATION DURING LOW SPEED TURNING MANEUVERS - VEHICLES BUILT BEFORE 4/1/2005.
Read full bulletin
*TT
FRONT AXLE LEAKS FLUID FROM VENT TUBE - VEHICLES EQUIPPED WITH 4X4 OR AWD.
Read full bulletin
*TT
WELD BONDING PROCEDURE.
Read full bulletin
*TT
RECOMMENDED 12VOLT SWITCHED ACCESSORY SOURCES.
Read full bulletin
FISHER. *TT
Brakes
4 bulletinsBRAKE LAMP CONCERNS. *TT
ABS DTC C1233 AND C1234 REVERSED IN ABS MODULE.
Read full bulletin
*EH
DRIVESHAFT THUMP CLUNK ON LIGHT ACCELERATION FROM STOP OR WHEN BRAKING AND COMING TO A STOP.
Read full bulletin
*EH
GRABBING CONDITION FROM REAR DRUM BRAKES.
Read full bulletin
*AR *TT
Pre-Delivery & Maintenance
3 bulletinsNEUTRAL TOW CAPABILITY - SERVICE KIT REQUIREMENTS.
Read full bulletin
*TT
NEUTRAL TOW CAPABILITY -- SERVICE KIT REQUIREMENTS.
Read full bulletin
*TT
SAFETY BELT WEB STOP BUTTON SERVICE.
Read full bulletin
*EH
Transmission
2 bulletinsNO 3RD GEAR, DTC P0733 (3RD GEAR INCORRECT RATIO) AND FLASHING TCIL - VEHICLES BUILT PRIOR TO 9/23/2004.
Read full bulletin
*TT
IMPROPERLY FORMULATED TRANSMISSION FLUID THAT, OVER TIME, MAY CAUSE DELAYED/HARSH REVERSE ENGAGEMENTS.
Read full bulletin
CUSTOMER SATISFACTION PROGRAM 04B22. 5R55S/E & 5R44E TRANSMISSION FLUID ADDITIVE. *TT SUPPLEMENT #1. *TT SUPPLEMENT #2. *TT SUPPLEMENT #3. *TT
Air Bags & Safety
1 bulletinFORD: 2005-2006 FORD GT, 2005-2008 MUSTANG, AND 2004-2005 RANGER VEHICLES OPERATED IN FLORIDA, HAWAII, PUERTO RICO, OR...
Read full bulletin
THE U.S VIRGIN ISLANDS ARE IN NEED OF AN AIRBAG INFLATOR REPLACEMENT. 06/11/15 *TA.
Tires & Wheels
1 bulletinVIBRATION DIAGNOSIS - TIRE/WHEEL RUNOUT.
Read full bulletin
*TT
Fuel System
1 bulletinNO START/HARD START/ROUGH RUNNING DURING COLD WEATHER - INCORRECT SEASONAL FUEL BLEND.
Read full bulletin
*TT