BumperScan
Powered byNHTSA|EPA|Community Reports|Updated
HomeTSBsFord2003 Navigator

2003 Ford Navigator TSBs

14 Technical Service Bulletins across 8 categories

View full vehicle report →

Categories

Body & Paint3Electrical2Steering2Engine2Other2HVAC & Climate1Infotainment1Brakes1

Body & Paint

3 bulletins
10008601

DOOR SQUEAK/RATTLE. *MJ

10008583

BODY-BODY JOINT REINFORCEMENT MATERIAL-REPAIR PROCEDURE.

Read full bulletin

*MJ

10008331

REAR AXLE SEAL LEAK - CONTACT REQUEST.

Read full bulletin

*MJ

Electrical

2 bulletins
10235153

For 2000-2024 Ford and Lincoln vehicles, swapping a module from a vehicle for diagnosis purposes is likely to cause errors and is not recommended.

Read full bulletin

It is also not recommended to order a replacement module using a vehicle identification number (VIN) from a different vehicle. Most modules on these affected vehicles are VIN/vehicle specific and hardware variations between modules do exist. Swapping a module from a vehicle or ordering a module using a different vehicle/VIN can cause ineffective repairs and additional vehicle down time. Make sure all appropriate Workshop Manual (WSM) procedures are followed when diagnosing the condition prior to all module replacements and only order modules using the correct VIN.

10214754

Some 2003-2020 Expedition/Navigator and 2006-2020 F-150 (non-Raptor) vehicles equipped with 4WD may exhibit...

Read full bulletin

grinding/clicking/ratcheting noise from the front wheel area. This may be due to partial engagement of the integrated wheel ends (IWE). To correct this condition, follow the Service Procedure to remove and cap the vacuum supply line or to reprogram the transfer case control module (TCCM) and replace any worn vacuum and/or IWE components.

Steering

2 bulletins
10008604

STEERING WHEEL DISCOLORATION UNDER INVESTIGATION - CONTACT REQUEST.

Read full bulletin

*MJ

10002491

POWER STEERING RETURN HOSE LEAK.

Read full bulletin

*TT

Engine

2 bulletins
10008334

ENGINE-LIGHT TICK OR RATTLE TYPE NOISE FROM ENGINE AFTER COLD START.

Read full bulletin

*MJ

10003156

VEHICLES WITH A SILVER VALVE STEM TIRE PRESSURE MONITOR SYSTEM (TPMS) MAY EXHIBIT A WARNING LIGHT/MESSAGE ON.

Read full bulletin

*TT

Other

2 bulletins
10008122

SAFETY BELT DIFFICULT TO PULL OUT DUE TO WEB STOP BUTTON USED FOR VEHICLE ASSEMBLY.

Read full bulletin

*MJ

10003167

ERRATIC OPERATION OF RETRACTABLE RUNNING BOARDS.

Read full bulletin

*TT

HVAC & Climate

1 bulletin
10013078

HIGH SIDE PRESSURE FLUCTUATIONS ON VEHICLES EQUIPPED WITH A FIXED SCROLL A/C COMPRESSOR.

Read full bulletin

*TT

Infotainment

1 bulletin
10008605

CALIBRATION OF NAVIGATION RADIO ON PRE-DELIVERY VEHICLES.

Read full bulletin

*MJ

Brakes

1 bulletin
10002508

BRAKE SHUDDER/VIBRATION.

Read full bulletin

*TT

Back to top